- Reed Semiconductor Corp. v. Monolithic Power Systems, Inc.All claims unpatentablePTAB · Jan 22, 2026 · IPR2024-01158 · APJ Ken B Barrett · IPR · Final written decision
Claims 1–5, 7–15, 17, and 18 are unpatentable: claims 1–4, 9–14, 17, and 18 as anticipated by Tateishi, and claims 5, 7, 8, and 15 as obvious over Tateishi.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“We discern no material difference between the parties’ definitions. Petitioner’s definition is consistent with the level of ordinary skill reflected in the prior art references of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (recognizing that the prior art itself may reflect an appropriate level of skill in the art). For purposes of this decision, we apply Petitioner’s definition of the person of ordinary skill in the art. We note, however, that were we to adopt Patent Owner’s assessment, the outcome of this Decision would be the same.” slip op. at 13
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“After considering the parties’ arguments and evidence, we determine that Patent Owner has not offered persuasive evidence that a person of ordinary skill in the art reading the claims in light of the Specification would understand the plain and ordinary meaning of “control signal” to be as narrow as Patent Owner proposes. We do not construe the claims such that the “control signal” must be the exclusively controlling factor of a component, as Patent Owner urges. Petitioner’s position, on the other hand, is consistent with the evidence of record. We construe “control signal” as having its plain and ordinary meaning, namely a signal configured to control a circuit component. D. The Asserted Anticipation of Claims 1–4, 9–14, 17, and 18 by Tateishi” slip op. at 24
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“We determine that Petitioner has demonstrated by a preponderance of the evidence that Tateishi discloses the “control signal” recited in limitations 1B2 and 1D of independent claim 1.” slip op. at 37
- BurdenNot shown unpatentable
“based on the Tateishi application publication (Ex. 1007), that the Tateishi Patent (Ex. 1005) also anticipates claims 1–4, 9–14, 17, and 18. See Pet. 23–24 (“The Tateishi Patent is also prior art under (pre-AIA) §102(e)”; identifying Ground 1 as anticipation “under §102 by Tateishi and/or the Tateishi Patent”). However, we are unable to locate in the Petition or Petitioner’s Reply a discussion of or citation to the Tateishi Patent other than under the Petitioner’s heading “Identification of Challenge and Relief Requested” on pages 23 and 24 of the Petition. Cf. id. at i–x (Table of Contents identifying a section of the Petition discussing the Tateishi (Application) anticipation ground but not a section discussing a Tateishi Patent anticipation ground). Although the issued patent may be substantively identical to the published application, Petitioner does not assert that, and we decline to compare the documents to determine whether that is the case. In light of Petitioner’s silence on the alternative ground, Petitioner has not demonstrated by a preponderance of the evidence that the Tateishi Patent anticipates 1–4, 9–14, 17, and 18.” slip op. at 47
Patent outcomesUS 9,041,377 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,041,377 - MPL Brands NV, Inc. v. Buzzballz, LLCAll claims unpatentablePTAB · Dec 16, 2025 · IPR2024-01098 · APJ Cynthia M Hardman · IPR · Final written decision
Claims 1–6 are unpatentable as anticipated by or obvious over Kick and as obvious over Ackermann and Kaminski, with or without Hutchinson.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“(sometimes abbreviated herein as “POSITA”) would have had “(i) an associate’s or bachelor’s degree in mechanical, industrial or manufacturing engineering and (ii) at least two to three years of practical experience with designing or manufacturing mechanical products, such as food or beverage packaging. A POSITA could substitute additional education for industry experience and vice versa.” Pet. 15 (citing Ex. 1002 (Delson Decl.) ¶ 14).” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner
“Petitioner asserts that no claim term requires an express construction. See Pet. 15. We agree and find it unnecessary to construe any claim term to resolve the issues in this case. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (noting that “we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 13
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportPriority date, deniedDecided for petitioner
“is no earlier than the February 25, 2020, filing date of the ’195 application. Petitioner demonstrates by a preponderance of the evidence that the volume limitations recited in independent claim 1 and dependent claims 2 and 6 lack adequate written description support in the ’934 application as filed. See Pet. 10–11. The specification, figures, and claims of the ’934 application as originally filed do not disclose any volume limitations. See Ex. 1004 (’934 prosecution history), 1–17. Instead, the volume limitations recited in the challenged claims find their first support in Figure 7, which was filed over one month after the ’934 application was filed. Compare id. at 1–17, with id. at 34–56. The addition of new matter during prosecution of a patent application is prohibited. See 35 U.S.C. § 132(a) (“No amendment shall introduce new matter into the disclosure of the invention.”); see also 37 C.F.R. § 1.121(f); Manual of Patent Examining Procedure § 608.04. Therefore, we agree with Petitioner that “the new matter improperly added during the prosecution of the ’934 application cannot be considered part of the disclosure of the original, April 19, 2010 application and/or relied upon for claiming priority in subsequent applications.” Pet. 9.” slip op. at 20
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“obvious over Kick. Pet. 16–41. Kick published with the additional figures and disclosure the applicant submitted during prosecution of the ’934 application, and its detailed description and figures are the same as or similar to that of the ’904 patent. See id. at 16; compare Ex. 1007 (Kick), with Ex. 1001. Petitioner compares Kick to each limitation of the challenged claims. See Pet. 16–41. Based on the record before us, we find that Kick teaches or suggests each of the limitations of the challenged claims, for the reasons discussed in the Petition. See id. Accordingly, we determine that Petitioner has established by a preponderance of the evidence that Kick renders claims 1–6 of the ’904 patent unpatentable as anticipated and as obvious.” slip op. at 22
Patent outcomesUS 11,738,904 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,738,904 - PTAB · Nov 18, 2025 · IPR2025-00782 · APJ Ken B Barrett · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that any challenged claim was unpatentable over the asserted grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Having considered the arguments and evidence presented by Petitioner and Patent Owner, we determine that Petitioner has not demonstrated a reasonable likelihood of prevailing on at least one of the challenged claims of the ’469 patent. Accordingly, we do not institute an inter partes review of the challenged claims.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that: [A] POSITA would have had at least a bachelor’s degree in computer science, computer engineering, business information systems, software engineering, or systems engineering and at least two years of experience in computer networking or telecommunications. Ex.1002 ¶21; see also Ex.1001 (1:14-31). Additional education could substitute for professional experience. Ex.1002 ¶21. Significant work experience could substitute for formal education. Ex.1002 ¶21. Pet. 7–8. Patent Owner, at this stage, does not disagree or propose a different definition of the person of ordinary skill in the art. Petitioner’s definition is consistent with the level of ordinary skill reflected in the prior art references of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (recognizing that the prior art itself may reflect an appropriate level of skill in the art). For purposes of this decision, we apply Petitioner’s definition of the person of ordinary skill in the art.” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner states that it “do[es] not believe explicit construction is required to resolve this Petition.” Pet. 7. Patent Owner proposes constructions for “Internet,” “access the Internet,” “subscriber access website.” Prelim. Resp. 12–15. On this record and for purposes of this decision, we determine that no claim terms require express construction. D. Alleged Anticipation of Claims 1, 2, 10, 11, and 24–28 by Bruner and” slip op. at 10
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentable
“We find Patent Owner’s argument to be persuasive. Petitioner does not explain adequately how Bruner discloses the positional requirement of a subscriber access unit being coupled between the satellite dish and the router. Accordingly, Petitioner has not shown sufficiently for purposes of institution that Bruner anticipates independent claim 24. Although, for the obviousness challenge, Petitioner contends that Clark discloses a wireless router (for limitation 24c), Petitioner relies solely on Bruner for the “between” limitation. See Pet. 17 (“Bruner and/or Bruner in view of Clark both disclose each limitation of claim 24c, including a router (e.g., Bruner’s ‘ADS’ and Clark’s ‘wireless router’)”); id. at 18–19 (the discussion of the “between” limitation 24d asserting that “Bruner discloses claim 24d,” with no mention of Clark). Furthermore, Petitioner merely asserts that both Bruner and Clark disclose a router. See id. at 17–18. Petitioner, however, does not indicate clearly which is used in the proposed combination, does not describe the configuration of a proposed combination or a proposed modification of Bruner’s system, and fails to set forth an adequate and persuasive reason with rational underpinning as to why a person of ordinary skill in the art would have modified Bruner’s system to arrive at the positional requirement of the subscription access unit being coupled between the satellite dish and a router. See id. at 13–14 (motivation section for this ground); id. at 18–19 (addressing the “between” limitation 24d). Accordingly, Petitioner has not shown a reasonable likelihood of prevailing on its challenge to independent claim 24 as obvious over Bruner in view of Clark.” slip op. at 14
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 7,324,469 - PTAB · Sep 10, 2025 · IPR2025-00141 · APJ Ken B Barrett · IPR · Remand
The Board instituted IPR of claims 1–21 on all asserted grounds after finding a reasonable likelihood of prevailing on the Nishida-based challenges.
RulingsRemand decision- Director reviewDirector review, grantedGranted
“partes review of U.S. Patent No. 8,266,749 B2 (“the ’749 patent,” Ex. 1001). Paper 1 (“Pet.”). The Petition challenges the patentability of claims 1–21 of the ’749 patent. Nike, Inc. (“Patent Owner”)2 filed a Preliminary Response to the Petition. Paper 6 (“Prelim. Resp.”). With our authorization, Petitioner filed a Reply to Patent Owner’s Preliminary Response (Paper 10) and Patent Owner filed a Sur-reply (Paper 13). We discretionarily denied institution under 35 U.S.C. § 325(d). Paper 20. Petitioner filed a request for Director Review of the Decision denying institution. Paper 21. Director Review was granted, the Decision denying institution of inter partes review was vacated, and the case was remanded to the Board. Id. at 4. Specifically, the case was “remanded to the Board with instructions to consider Petitioner’s Nishida grounds and to determine whether the Petition should be instituted.” Id. at 3–4.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“presented in the Petition and the Preliminary Response “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Having considered the arguments and evidence presented by Petitioner and Patent Owner, we determine that Petitioner has demonstrated a reasonable likelihood of prevailing on at least one of the challenged claims of the ’749” slip op. at 2
- Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner
“In support of Petitioner’s position, Dr. Adanur testifies that “Nishida discloses that the unfinished surface area 1.1 is part of the web 1 itself,” that Nishida discloses that the computer-controlled process can (using Nishida’s phrase) “put in” up to seven different textile fibers or yarns into the web of material in one operation, and that, “[t]hus, Nishida discloses simultaneously knitting its layouts 2 and tongue 40 (each a ‘textile element’) with the unfinished surface area 1.1 (a ‘surrounding textile structure’).” Ex. 1002 ¶ 216 (citing Ex. 1022, 2:12–20, 4:47–55, 5:45–49). For purposes of institution, we credit that testimony over the testimony of Dr. Pastore, because, on the current record, we regard Dr. Adanur’s testimony as more consistent with the evidence. This and the other related issues may be explored more fully during the trial.” slip op. at 23
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that: A person of ordinary skill in the art (“POSITA”) in the field of the ’749 patent in March 2004 would have been someone with at least a few years of experience in knit materials and knitting methods and machines that can be used in making footwear, or a bachelor’s degree in textile-related sciences, engineering, or industrial product design, or equivalent academic or work experience, including in the footwear industry. EX1002, ¶68. Such a person of ordinary skill would have at least a general understanding of general construction processes and materials used in the manufacturing process of fabric-based articles. For individuals with a lower educational level, a person could still be of ordinary skill in the art provided that person’s working experience compensates for any such lower educational level, or vice versa. See id. Pet. 23–24. Patent Owner states that, “[f]or purposes of this Preliminary Response, Nike applies Skechers’ definition for a person of ordinary skill in the art.” Prelim. Resp. 14. Petitioner’s definition is consistent with the level of ordinary skill reflected in the prior art references of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (recognizing that the prior art itself may reflect an appropriate level of skill in the art). For purposes of this decision, we apply Petitioner’s definition of the person of ordinary skill in the art.” slip op. at 10
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,266,749 - Tesla, Inc. v. Graphite Charging Company LLCNo claims unpatentablePTAB · Aug 19, 2025 · IPR2024-00388 · APJ Ken B Barrett · IPR · Final written decision
Claims 1–20 were not shown unpatentable because Wang and Wang with AESO did not establish the claimed analysis, and Cooley did not disclose reducing current power consumption.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“the claims require a decision engine to perform those elements.” Tr. 48:17– 20. In light of this, we fail to understand the basis for Patent Owner’s objection to the characterization of the level of ordinary skill involving experience with “intelligent” techniques or devices that control grid electricity. We determine that Petitioner’s definition is consistent with the level of ordinary skill reflected in the Specification and the prior art references of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (recognizing that the prior art itself may reflect an appropriate level of skill in the art). We, therefore, apply Petitioner’s definition of the person of ordinary skill in the art. We note, however, that were we to adopt Patent Owner’s assessment, the outcome of this Decision would be the same.” slip op. at 11
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“Patent Owner (PO Resp. 12, 49–50) points to the Specification’s list of “[e]xamples of power reduction actions.” Ex. 1001, 8:47–63. Patent Owner asserts that the list includes numerous examples of power reductions that occur in the present and one that takes place in the future—namely, “scheduling nonessential operations at a different time (e.g., nonessential software or hardware upgrades).” Ex. 1001, 8:61–62 (cited at PO Resp. 12, 50). We are persuaded by Patent Owner’s contention (PO Resp. 12) that the applicant, by including the term “current” in the claims, intentionally narrowed the claims to power consumption reductions that occur temporally in the present, rather than those that occur in the future. See Pet. Reply 6–7 (Petitioner asserting that Patent Owner’s position is “inconsistent with the specification’s examples,” but then arguing that the Specification does not support that position rather than pointing to any purported inconsistencies). Because the independent claims recite the term “current,” construing the term in the temporal sense is not, as Petitioner argues, importing into the claims an example from the Specification. See Pet. Reply 8.” slip op. at 13
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundReasonable expectation not foundNot shown unpatentable
“Given the interchangeable nature taught for various features of Wang’s embodiments, it would have been a routine and obvious matter for a POSA to combine aspects from Wang’s various embodiments (e.g., data acquisition, internal hardware, data analysis performed by the UMC receiver 400 and/or the display 200). Moreover, many of Wang’s embodiments–particularly of specific smart appliance types– include common components, thus further confirming combinability of aspects of the disclosed embodiments. A POSA would have had a reasonable expectation of success in combining features of the embodiments together. Id. at 77–78 (citing Ex. 1003 ¶¶ 201–203). We determine that these reasons are inadequate and too generic to satisfy Petitioner’s burden as they lack a clear explanation of what and how “aspects from Wang’s various embodiments” are proposed to be combined along with reasoning specific to that proposal. Petitioner, for example, does not explain adequately or persuasively why a person of ordinary skill in the art would have added a display that purportedly receives and analyzes data to a “smart appliance,” when that appliance already has an application processor that purportedly receives and analyzes the same data. It is not enough for Petitioner to allege that all of the elements of the challenged claims can be found somewhere in the various embodiments of Wang; Petitioner must also show that a person of ordinary skill in the art would have had a reason to combine the elements in the manner as arranged in the challenged claims. See KSR Int’l Co., 550 U.S. at 418 (“[A] patent composed of several elements is not proved obvious merely by demonstrating that each of its elements was, independently, known in the prior art. Although common sense directs one to look with care at a patent application that claims as innovation the combination of two known devices according to their established functions, it can be important to identify a reason that would have prompted a person of ordinary skill in the relevant field to combine the elements in the way the claimed new invention does.”). We find Petitioner has not shown an adequate reason to combine embodiments.” slip op. at 38
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightNot shown unpatentable
“We determine that these reasons are inadequate and too generic to satisfy Petitioner’s burden as they lack a clear explanation of what and how “aspects from Wang’s various embodiments” are proposed to be combined along with reasoning specific to that proposal. Petitioner, for example, does not explain adequately or persuasively why a person of ordinary skill in the art would have added a display that purportedly receives and analyzes data to a “smart appliance,” when that appliance already has an application processor that purportedly receives and analyzes the same data. It is not enough for Petitioner to allege that all of the elements of the challenged claims can be found somewhere in the various embodiments of Wang; Petitioner must also show that a person of ordinary skill in the art would have had a reason to combine the elements in the manner as arranged in the challenged claims. See KSR Int’l Co., 550 U.S. at 418 (“[A] patent composed of several elements is not proved obvious merely by demonstrating that each of its elements was, independently, known in the prior art. Although common sense directs one to look with care at a patent application that claims as innovation the combination of two known devices according to their established functions, it can be important to identify a reason that would have prompted a person of ordinary skill in the relevant field to combine the elements in the way the claimed new invention does.”). We find Petitioner has not shown an adequate reason to combine embodiments.” slip op. at 38
Patent outcomesUS 8,291,243 not shown unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,291,243 - Lululemon USA Inc. v. Nike, Inc.All claims unpatentablePTAB · Aug 6, 2025 · IPR2024-00460 · APJ Ken B Barrett · IPR · Final written decision
Claims 1–21 are unpatentable: claims 1–21 under Nishida grounds and claims 11 and 21 also over Nishida with Zuckerman; Zuckerman-only grounds fail for lack of a surrounding structure.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that: A hypothetical person of ordinary skill in the art (“POSA”) would have had at least a bachelor’s degree in textile engineering, mechanical engineering, or similar technical degree and at least 3 years of experience working with knitted textiles for use in fabric-based articles, including apparel such as footwear. Ex.1003, ¶¶34-37. For individuals with different educational backgrounds, a person could still be of ordinary skill in the art provided that person’s additional experience compensates for any differences in that person’s education as stated above. Id., ¶37. Pet. 14–15. Patent Owner states that, “[f]or purposes of this proceeding, Nike applies lululemon’s proposed level of skill in the art.” PO Resp. 13. Petitioner’s definition is consistent with the level of ordinary skill reflected in the prior art references of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (recognizing that the prior art itself may reflect an appropriate level of skill in the art). For purposes of this decision, we apply Petitioner’s definition of the person of ordinary skill in the art.” slip op. at 9
- Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“Id. at 99:12–25. Dr. Brookstein stated during his deposition that he has “49 years of experience of teaching textile engineering.” Id. at 97:6–8. We credit Dr. Brookstein’s testimony over that of Dr. Pastore’s because it is consistent with the reference and based on decades of experience in the textile field. Nishida’s claim 1 states that, “during the production of the material web (1), [shoe patterns] . . . are produced by . . . a textile production method within the material web.” Ex. 1005, 9. We find that Nishida’s claim language discloses the recited, “simultaneously knitting a textile element with a surrounding textile structure.”” slip op. at 22
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“We find the District Court’s reasoning persuasive, and we, like the District Court, decline to adopt Petitioner’s overly broad proposed construction. However, for purposes of deciding the dispositive fact issue before us, we need not determine the precise boundaries of “surrounding textile structure,” for example whether it completely or mostly encircles the textile element, and if “mostly,” what percentage of encircling is required. See Pet. Reply 2 (Petitioner characterizing Patent Owner’s position as “mostly” means over 50%); id. at 4 (Petitioner impliedly arguing that the “surrounding” need not be complete, i.e., 100%); PO Sur-reply 3–4 (Patent Owner arguing that “Zuckerman’s textile structures . . . each abut only about 25% of the periphery of Zuckerman’s blank.”). We find that a person of ordinary skill in the art would not understand the portion of Zuckerman’s strip 13 in purple to surround the green blank 11 (textile element) under any reasonable construction of “surrounding textile structure.” Dr. Pastore testifies that “Zuckerman discloses two separate textile structures adjacent the blank—one on each side . . . they abut only two sides of Zuckerman’s blank, with each structure abutting only about a quarter of the blank’s periphery,” and opines that “a POSITA would not have understood these two separate structures, designated by purple in the figure above, to be a textile structure ‘surrounding’ the blank [shown in green].” Ex. 2003 ¶ 54. We find Dr. Pastore’s tesimony credible as it is consistent with Zuckerman’s Figure and with the plain and ordinary meaning of “surrounding” and with the Specification of the ’749 patent (particularly Figure 9). Dr. Brookstein’s testimony, on the other hand, is based on Petitioner’s overly broad proposed construction—that any part of a textile area that is not a textile element is “surrounding textile structure”—” slip op. at 44
Patent outcomesUS 8,266,749 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,266,749 - Skechers U.S.A., Inc. v. Nike, Inc.Institution deniedPTAB · Jun 9, 2025 · IPR2025-00151 · APJ Ken B Barrett · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood of proving any of claims 1–27 unpatentable on the asserted anticipation and obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Having considered the arguments and evidence presented by Petitioner and Patent Owner, we determine that Petitioner has not demonstrated a reasonable likelihood of prevailing on at least one of the challenged claims of the ’636 patent. Accordingly, we do not institute an inter partes review of the challenged claims.” slip op. at 2
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for patent owner
“25:5 (limitation 1a1: “a portion of the knitted component defining the upper”). “Where a claim lists elements separately, ‘the clear implication of the claim language’ is that those elements are ‘distinct component[s]’ of the patented invention.” Becton, Dickinson & Co. v. Tyco Healthcare Grp., LP, 616 F.3d 1249, 1254 (Fed. Cir. 2010) (quoting Gaus v. Conair Corp., 363 F.3d 1284, 1288 (Fed. Cir. 2004)) (alteration in original). Thus, the claim language suggests that the “integral knit tongue” is a component distinct, at least to some degree, from the “upper.” See also Ex. 1001, 2:27–28 (the Specification stating that “[a] knitted component including the upper and an integral knit tongue is incorporated into the article of footwear.”). Limitation 1d reinforces this understanding by requiring the tongue to be joined to a portion of the throat area of the upper. See id. at 6:35–38 (the Specification indicating that the “throat area” is an area of the upper); cf. Ex. 2014, 18–19 (defining “Throat”: “The main opening of a shoe extending from the vamp [(the front part of a shoe upper that covers the toes and part of the foot)] to the ankle.”). In addition to suggesting that the tongue is a component distinct from the upper, the claim language indicates that the integral knit tongue extends through a throat area. See Ex. 1001, 25:10–11 (limitation 1b: “an integral knit tongue . . . extending through a throat area of the knitted component”). With that context, we turn to the parties’ arguments.” slip op. at 11
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentable
“claim language does not specify it, both parties contend that the “portion of the knitted component” constitutes the majority of the upper. See Pet. 25– 26, 30 (Petitioner applying in this ground that which it characterizes as Patent Owner’s claim construction position); Prelim. Resp. 43 (Patent Owner noting that the Specification states that “a majority of upper 120 is formed from a knitted component 130,” and contending that limitation 1a1 means that “a majority of the upper must be knitted.” (quoting Ex. 1001, 6:57–59)). Nevertheless, we determine for the following reasons that Petitioner has not shown sufficiently that central textile element 60 of Dua-956 defines an upper within the meaning of the claims. See Pet. 26. Petitioner contends that, “[w]ith respect to what defines the upper, the ’636 patent discloses that the ‘upper generally extends over the instep and toe areas of the foot, along the medial and lateral sides of the foot, under the foot, and around the heel area of the foot.’” Pet. 27 (citing Ex. 1001, 1:44–46, 6:66–67). Petitioner reasons that, “[a]s such, the ’636 patent describes the upper as extending around six parts of the foot: (1) the instep area, (2) the toe area, (3) the medial side, (4) the lateral side, (5) under the foot, and (6) the heel area.” Id. Applying this reasoning to the reference, Petitioner contends that, “[o]f the six upper parts identified in the ’636 patent, only two of them—the medial and lateral sides—are not formed by the central textile element 60,” and therefor “the majority of the parts of the upper are formed by the central element 60.” Id. at 30 (citing Ex. 1002 ¶¶ 103–109). Petitioner provides an annotated versions of Figures 8B and 8C of Dua-956, reproduced below, to depict its contentions. Id. at 30. Above are Figures 8B and 8C of Dua-956—which are, respectively, perspective views depicting a second step and a third step in assembling the article of footwear (Ex. 1029, 3:41–45)—with central textile element 60 shaded green. As Petitioner concedes (Pet. 30) and as the annotated figures above show, central textile element 60 does not form the medial and lateral sides of the footwear. Thus, even if central textile element 60 constitutes the majority of parts of the upper, the sides of the upper remain undefined by the central textile element. Petitioner does not explain adequately how the upper is defined when the side components are missing. We determine that Petitioner has not demonstrated adequately for institution that Dua-956 discloses “a portion of the knitted component defining the upper,” as recited in independent claim 1.” slip op. at 20
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentable
“Petitioner contends that “both upper 70 and 30' are constructed as a single, unitary knit element that defines the upper, and it would have been obvious to construct upper 30 in the same manner.” Pet. 65. Petitioner next turns to Horii, asserting that “Horii discloses “shoes 1 that are characterized by the fact that the entire upper is constructed of a single piece of upper member 2 that is made through weft knitting or circular knitting.’” Id. at 67 (citing Ex. 1017, 9) (emphasis omitted). Petitioner reasons that “[a] POSITA would have been motivated to manufacture Dua-956’s upper 30, for example, using the multilayer, single fabric of Horii because Horii’s single-piece knit upper would have provided upper 30 with a seamless structure.” Id. at 68. We disagree with Petitioner’s assertion that “[c]onstructing Dua-956’s upper 30 as a single, unitary knit component would not materially change the analysis under Ground 1A.” Pet. 70. In Ground 1A, Petitioner contends that “‘forward portion 61’ of the central textile element 60 is an integral knit tongue that extends through a throat area of the knitted component in the assembled upper 30.” Id. at 34. During the assembly of footwear 10, forward portion 61 is flipped over the top of the footwear and the separate textile elements 40 and 50 (the sides of the footwear) are stitched to the lateral and medial edges (64a and 64b) of forward portion 61—the purported tongue. See Ex. 1029, 9:5–11, Figs. 8B, 8C. Petitioner does not explain adequately how, when modifying the embodiment used in Ground 1A to have a seamless top portion, the purported integral knit tongue is retained in that combination. See Pet. 70 (Petitioner asserting that the proposed combination would still have an exterior surface, an inner surface, lace elements 33, channels 44/54, and loops 35, “along with the other structures identified under Ground 1A,” but not specifically discussing the purported integral knit tongue.). We determine that Petitioner has not demonstrated a reasonable likelihood of demonstrating that claims 1–6, 8–17, and 19–27 would have been obvious over Dua-596 alone or in combination with Horii.” slip op. at 24
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,510,636 - Skechers U.S.A., Inc. v. Nike, Inc.Institution deniedPTAB · Jun 9, 2025 · IPR2025-00150 · APJ Ken B Barrett · IPR · Institution
The Board denied institution because Skechers did not show a reasonable likelihood that claims 1–23 were unpatentable, principally because the asserted art did not disclose the construed integral knit tongue.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsDenied
“An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Having considered the arguments and evidence presented by Petitioner and Patent Owner, we determine that Petitioner has not demonstrated a reasonable likelihood of prevailing on at least one of the challenged claims of the ’562 patent. Accordingly, we do not institute an inter partes review of the challenged claims.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that: A person of ordinary skill in the art (“POSITA”) in the field of the ’562 patent in February 2012 would have been someone with at least a few years of experience in knit materials and knitting methods and machines that can be used in making footwear, or a bachelor’s degree in textile-related sciences, engineering, or industrial product design, or equivalent academic or work experience, including in the footwear industry. EX1002, ¶68. Such a person of ordinary skill would have at least a general understanding of general construction processes and materials used in the manufacturing process of fabric-based articles. For individuals with a lower educational level, a person could still be of ordinary skill in the art provided that person’s working experience compensates for any such lower educational level, or vice versa. See id. Pet. 22. Patent Owner states that, “[f]or the purposes of this Preliminary Response only, Nike applies Petitioner’s proposed level of skill in the art.” Prelim. Resp. 15. Petitioner’s definition is consistent with the level of ordinary skill reflected in the prior art references of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (recognizing that the prior art itself may reflect an appropriate level of skill in the art). For purposes of this decision, we apply Petitioner’s definition of the person of ordinary skill in the art.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownDecided for patent owner
“inquiries.” Medichem, S.A. v. Rolabo, S.L., 353 F.3d 928, 933 (Fed. Cir. 2003). “The first step in both analyses is a proper construction of the claims . . . [and t]he second step in the analyses requires a comparison of the properly construed claim to the prior art.” Id. Although an explicit claim construction analysis by a petitioner is not required in every case, a petition nonetheless must identify how the challenged claims are to be construed and how, as so construed, they are unpatentable under the statutory grounds asserted. 37 C.F.R. § 42.104(b)(3)–(4). And, being part of a prima facia case, such an analysis is part of Petitioner’s burden to demonstrate a reasonable likelihood of prevailing on its patentability challenges. Petitioner has failed to satisfy the threshold burden for every ground based on this construction.” slip op. at 14
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“We do not find Petitioner’s contentions regarding the two annotated figures to be persuasive. First, those contentions, and the cited opinions of Dr. Adanur, are based on a claim construction that, as discussed above, we reject and for which neither party advocates. Second, Petitioner does not explain adequately why a person of ordinary skill in the art would discern, even with Petitioner’s added red ovals, a tongue distinct from the upper and tongue extending through the throat area. We also do not find persuasive Petitioner’s contentions regarding differing textures. See Pet. 32–33. Even if differing textures could rise to the level of distinguishing an integral knit tongue from the upper, the purported tongue texture 48" is not confined to the area identified by Petitioner as the tongue. See Pet. 31 (annotated Figure 11, reproduced above). For example, texture 48" outside of Petitioner’s oval appears to wrap approximately halfway around the ankle opening, which is not argued to be consistent with an ordinary artisan’s understanding of a tongue. Or, put another way, there is no indication that the portion of the 48" texture within Petitioner’s red oval, which purportedly represents the tongue, is distinguishable from the remaining portion of the 48" texture outside of the red oval. We are not persuaded that Petitioner has demonstrated a reasonable likelihood of proving that a person of ordinary skill in the art would consider the relatively large area depicted as having texture 48" to be an “integral knit tongue.” In light of the above, we determine that Petitioner has not demonstrated a reasonable likelihood of prevailing on its challenge to independent claim 1 and its dependent claims 2–4 as anticipated by Dua-592.” slip op. at 23
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,060,562 - Nokia Of America Corporation / Ericsson Inc. et al. v. General Access Solutions, Ltd.No claims unpatentablePTAB · Apr 14, 2025 · IPR2023-01416 · APJ Ken B Barrett · IPR · Final written decision
The Board held claims 1–15 and 18 not unpatentable; the petition failed to prove the asserted anticipation and obviousness grounds, including failure to establish WiMAX as prior art.
RulingsFinal written decision- Adverse judgmentAdverse judgmentOther
“filed with the Office a statutory disclaimer disclaiming method claims 16, 17, 19, and 20. See Ex. 2007; see also Tr. 33, 21:1–12 (Patent Owner’s counsel informing the Board that the disclaimer had been filed in the USPTO Patent Center, and Petitioner’s counsel having no objection to the filing of the disclaimer as an exhibit in this inter partes review); Tr. 34:19 1 Petitioner identifies Nokia of America Corporation, Ericsson Inc., and T-Mobile USA, Inc. as real parties in interest. Pet. 72. 2 Patent Owner identifies General Access Solutions, Ltd. as the real party in interest. Paper 6, 1. (Patent Owner’s counsel stating, “General Access has disclaimed method Claims 16, 17, 19, and 20.”). We treat disclaimed claims as if they never existed. See Facebook, Inc. v. SKKY, LLC, CBM2016-00091, Paper 12 at 8 (PTAB Sept. 28, 2017) (expanded panel) (precedential) (“The Federal Circuit has held consistently that claims disclaimed under § 253(a) should be treated as though they never existed.”) (citing, inter alia, Vectra Fitness, Inc. v. TWNK Corp., 162 F.3d 1379, 1383 (Fed. Cir. 1998) (“This court has interpreted the term ‘considered as part of the original patent’ in section 253 to mean that the patent is treated as though the disclaimed claims never existed.”); Guinn v. Kopf, 96 F.3d 1419, 1422 (Fed. Cir. 1996) (“A statutory disclaimer under 35 U.S.C. § 253 has the effect of canceling the claims from the patent and the patent is viewed as though the disclaimed claims had never existed in the patent.”)). Accordingly, the remaining claims challenged in this proceeding are apparatus claims 1–15 and method claim 18.” slip op. at 2
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“of both types of parameters to be stored in the same “device” is consistent with the claim language. The claim recites “a profile parameter storage device,” “said profile parameter storage device for storing [two parameter] values,” and refers to “the values stored at said profile parameter storage device.” Ex. 1001, 13:10–16. Accordingly, the claim language speaks of a single device for storing both types of parameters.12 And, Petitioner does” slip op. at 32
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableNot shown unpatentable
“of both types of parameters to be stored in the same “device” is consistent with the claim language. The claim recites “a profile parameter storage device,” “said profile parameter storage device for storing [two parameter] values,” and refers to “the values stored at said profile parameter storage device.” Ex. 1001, 13:10–16. Accordingly, the claim language speaks of a single device for storing both types of parameters.12 And, Petitioner does” slip op. at 32
- Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication not establishedNot shown unpatentable
“Id. “[A] work is not publicly accessible if the only people who know how to find it are the ones who created it.” Samsung Elecs. Co. v. Infobridge Pte. Ltd., 929 F.3d 1363, 1372 (Fed. Cir. 2019) (citing SRI Int’l, Inc. v. Internet Sec. Sys., Inc., 511 F.3d 1186, 1196 (Fed. Cir. 2008) Application of Bayer, 568 F.2d 1357 (CCPA 1978)). Accordingly, in this case, Petitioner must demonstrate by a preponderance of the evidence that the WiMAX exhibit was disseminated or otherwise made available to interested ordinary artisans outside of the group that created the document. Petitioner has failed to satisfy that burden.” slip op. at 48
Patent outcomesUS 6,947,477 not shown unpatentable§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 6,947,477 - PTAB · Feb 20, 2025 · IPR2024-00996 · APJ Ken B Barrett · IPR · Institution
The Board instituted review of claims 13–18 on all asserted grounds, finding a reasonable likelihood of prevailing on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDenied
“inter partes review, “the Director may take into account whether, and reject the petition or request because, the same or substantially the same prior art or arguments previously were presented to the Office.” 35 U.S.C. § 325(d). The Board uses a two-part framework in determining whether to exercise its discretion under § 325(d), specifically: (1) whether the same or substantially the same art previously was presented to the Office or whether the same or substantially the same arguments previously were presented to the Office; and (2) if either condition of [the] first part of the framework is satisfied, whether the petitioner has demonstrated that the Office erred in a manner material to the patentability of challenged claims. Advanced Bionics, Paper 6 at 8. The art or arguments presented in the Petition are not “substantially the same” as those previously presented to the Office when there are differences between them that are material to the Office’s prior consideration of the art and arguments. Wolfspeed, Inc. v. Trs. of Purdue Univ., IPR2022-00761, Paper 13 at 7–8 (Vidal Mar. 30, 2023).” slip op. at 9
- Skill levelSkill level petitioner adoptedOther
“Petitioner contends that: [A] person of ordinary skill in the art at the time of the alleged invention (“POSITA”) would have had a bachelor’s degree or higher in electrical engineering, at least 3 years of experience designing or researching electronic circuits, and familiarity with power electronics and inductive power transfer circuits. Pet. 8 (citing Ex. 1003 ¶ 20). Patent Owner states that, “[f]or purposes of this preliminary response, Patent Owner adopts the Petitioner’s proposal.” Prelim. Resp. 17. Petitioner’s definition is consistent with the level of ordinary skill reflected in the prior art references of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (recognizing that the prior art itself may reflect an appropriate level of skill in the art). For purposes of this decision, we apply Petitioner’s definition of the person of ordinary skill in the art.” slip op. at 18
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner contends that “[a]ll claim terms should be construed according to the Phillips standard,” and “[h]ere, given the remarkable overlap between the preferred embodiment of the ’461 patent and the prior art/predictable combinations articulated in Grounds 1A–3, Petitioners submit that no claim elements need a formal construction for purposes of resolving the controversy in this proceeding.” Pet. 8. Patent Owner states that, “[t]o simplify the issues before the Board, Patent Owner has not asserted any claim constructions in this preliminary response and adopts the Petitioner’s position that ‘[a]ll claim terms should be construed according to the Phillips standard.’” Prelim. Resp. 17 (quoting Pet. 8). On this record and for purposes of this decision, we determine that no” slip op. at 19
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“At this preliminary stage of the proceeding, we do not agree with Patent Owner’s arguments. Patent Owner does not cite to evidence, such as expert testimony, to support its implied argument that Olson’s measured current is “fundamentally different” from the current received by the primary coil. See Prelim. Resp. 31–32. Petitioner’s declarant, Dr. Woods, on the other hand, testifies, inter alia, that “[t]he ‘[c]urrent measured by current measure block 226 is used in the calculation of power, which as depicted in FIG. 14, measures the ‘power in’ provided to transmit block 214/primary coil 54.” Ex. 1003 ¶ 37 (citing Ex. 1004 ¶¶ 74–75, Fig. 14) (first alteration added); see also, e.g., id. ¶ 42 (Dr. Woods testifying that the measured current to the power supply “is the current driving the external antenna 52, via the transmit block 214 and to the primary coil 54.” (citing Ex. 1004 ¶¶ 74–75, 112, Fig. 14)). Paragraph 75 of Olson, cited in support of that testimony, provides: “The power in is gauged by the power generated by charging unit 50 and is determined by multiplying the voltage of the internal voltage of charging unit 50, e.g., the voltage of a battery or batteries internal to charging unit 50, by the current driving external antenna 52.” Ex. 1004 ¶ 75 (emphasis added). We note that external antenna 52 includes primary coil 54. See, e.g., Fig. 14. Dr. Woods’ testimony is, at this stage, unrebutted. Patent Owner also argues that “Petitioner fails to provide any evidence regarding the function of Olson’s microprocessor 212 in relation to measuring input power,” and that, “[w]hile Olson describes a power calculation in paragraph [0075], Olson does not describe this power calculation as performed by microprocessor 212.” Prelim. Resp. 32 (citing Pet. 16; Ex. 1004 ¶ 72) (first alteration added). At this preliminary stage of the proceeding, we do not agree with Patent Owner’s arguments regarding the microprocessor. Although Patent Owner does not bear the burden to show patentability, we observe that Patent Owner does not suggest that there is another component in Olson’s external charging device that might perform the admittedly-disclosed power calculation. See Prelim. Resp. 32–33. Dr. Woods testifies that microprocessor 212 receives the measured current and the input voltage of the charging device, and, from those values, calculates power in. See Ex. 1003 ¶¶ 43–44 (citing, inter alia, Ex. 1004 ¶¶ 71–78, Fig. 14); see also Ex. 1004 ¶ 74, Fig. 14 (Olson stating that “[c]urrent measured by current measure block 226 is used in the calculation of power in along with the voltage of batteries 160,” and Figure 14 depicting the signal from measure block 226 as an input to microprocessor 212). Dr. Woods’ testimony is, at this stage, unrebutted.” slip op. at 26
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,626,461
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.