- Shenzhen Tuozhu Technology Co., Ltd. v. Stratasys, Inc.No claims unpatentablePTAB · Jun 9, 2026 · IPR2025-00321 · APJ Christopher M Kaiser · IPR · Final written decision
The Board held claims 1, 2, 5–7, 9, 16, and 17 not unpatentable because the asserted combinations did not establish the required purge-tower teachings or prior-art status.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art “would have had (1) at least a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a related field, and (2) at least two years of research or industry experience in 3D printing or materials used for 3D printing.” Pet. 5 (citing Ex. 1003 ¶¶ 14–16). Petitioner also argues that “[a]dditional experience could substitute for a formal degree or formal training (and vice versa).” Id. Patent Owner proposes a slightly different level of skill, arguing that a person of ordinary skill in the art “would have had a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a comparable field and at least two years of experience related to 3D printing, with additional experience potentially being a substitute for a formal degree or training (and vice versa).” Prelim. Resp. 24. Neither party explains why the outcome of this case would be affected by the adoption of any of the proffered definitions of a person of ordinary skill in the art. We adopt Petitioner’s assessment of the level of ordinary skill in the art, as it appears consistent with the ’324 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 8
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownOther
“According to the ’713 patent, “[p]urge tower 24 itself may be . . . recycled or otherwise discarded as desired.” Ex. 1001, 8:27–28. This description provides some support for Patent Owner’s view, because a purge tower too intimately integrated with the part would be difficult or impossible to recycle or discard. This is further supported by the ’713 patent’s statement that “purge tower 24 may be printed at any suitable location on build substrate 44 (i.e., at any location in the x-y build plane not occupied by 3D part 20 or support structure 22).” Id. at 8:30–34. It also is supported by Dr. Hickner’s testimony that the ’713 patent “clearly shows . . . the 24 purge tower separated from the part” and that “the purge tower is a separate physical object.” Ex. 2016, 28:8–10, 64:1–9. On the other hand, there is evidence supporting Petitioner’s view that, as long as the purge tower is generally separate from the part and the support structure, it may still make contact with those portions of the print. As noted above, “purge tower 24 may be printed at any suitable location on build substrate 44 (i.e., at any location in the x-y build plane not occupied by 3D part 20 or support structure 22).” Ex. 1001, 8:30–34. This language does not exclude locations adjacent to or in contact with the part or the support structure. Thus, determine that a “purge tower,” as that term is used in the context of the ’713 patent, may not be an integrated portion of a printed part or support structure but need not be free of all contact with the printed part or support structure.” slip op. at 9
- BurdenNot shown unpatentable
“There is evidence of record to support both Petitioner’s view and Patent Owner’s view. On the record developed at trial, however, we cannot say that the preponderance of the evidence favors Petitioner, who bears the burden of proof. See 35 U.S.C. § 316(e). Accordingly, Petitioner has not shown by a preponderance of the evidence that KISSlicer teaches printing a layer of a purge tower each time the printer switches one extruder to the operating mode. Because proving the obviousness of claims 1 and 16 requires such a showing, Petitioner has not shown by a preponderance of the evidence that claims 1 and 16 would have been obvious over the combination of Priedeman and KISSlicer. 5. Analysis of Remaining Claims Claims 2, 6, 7, 9, and 17 all depend, directly or indirectly, from claim 1 or claim 16. Accordingly, they all include the limitations of either claim 1 or claim 16. Because, as discussed above, Petitioner has not shown that the combination of Priedeman and KISSlicer teaches or suggests all the limitations of claims 1 and 16, Petitioner also has not proven by a preponderance of the evidence that claims 2, 6, 7, 9, and 17 would have been obvious over that combination of references.” slip op. at 21
- Obviousness (§103) › Analogous artAnalogous artOther
“On the record developed at trial, we agree with Petitioner. According to several industry forum posts, people interested in three-dimensional printing located the website where KISSlicer was posted between February 2012 and April 2012. Ex. 1028, 1 (post discussing and directing others to KISSlicer on April 11, 2012); Ex. 1031, 1 (two posts discussing KISSlicer on March 16, 2012, and March 21, 2012); Ex. 1032, 1 (two posts discussing KISSlicer on February 11, 2012, and February 14, 2012). Thus, not only was it possible for people of ordinary skill in the art to locate KISSlicer; people of ordinary skill in the art actually did locate it. Accordingly, Petitioner has shown by a preponderance of the evidence that KISSlicer was publicly accessible.” slip op. at 19
Patent outcomesUS 9,421,713 not shown unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,421,713 - Cambridge Industries USA, Inc. v. Applied Optoelectronics, Inc.Rehearing deniedPTAB · Dec 19, 2025 · IPR2025-00434 · APJ Mitchell G Weatherly · IPR · Rehearing
The Board denied Petitioner’s rehearing request, leaving institution denied because Shen and Soldano did not establish a reasonable likelihood of anticipating claims 1–7.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“When rehearing a decision on petition, the Board will review the decision for an abuse of discretion. See 37 C.F.R. § 42.71(c). An abuse of discretion may be determined if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors. See Arnold P’ship v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004). The party challenging the decision has the burden of showing the decision should be modified, and the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed” in its papers. 37 C.F.R. § 42.71(d).” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“II. ANALYSIS In our Decision, we concluded that Petitioner had failed to carry its burden of demonstrating a reasonable likelihood of prevailing that either Shen or Soldano anticipated claims 1–7. Dec. 18, 26. Petitioner argues that we should institute review for three reasons. First, Petitioner argues that we abused our discretion by (a) “refusing” to interpret the scope of the claimed” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Owner’s interpretation of “carrier” as meaning “one or more components for supporting ROSA components such as an AWG.” Dec. 9 (quoting Pet. 11). For our analysis of Petitioner’s challenges, we referred to this interpretation of “carrier” as Petitioner’s second alternative construction. Id. We also noted that Petitioner appeared to dispute Patent Owner’s interpretation when it argued that “carrier” should mean “a ceramic or silicon substrate.” Id. (quoting Pet. 10). We referred to this interpretation of “carrier” as the first alternative construction. Id. Rather than resolve this apparent dispute about the meaning of “carrier,” we found that both of Petitioner’s anticipation challenges failed under both interpretations of “carrier.” Id. at 10–26. Because we found that Petitioner had failed to carry its burden regardless of which interpretation of “carrier” applied, we found it unnecessary to resolve the dispute over that interpretation. Id. at 9–10. For the reasons expressed in Parts II.B–C below, we maintain our conclusion that Petitioner has failed to demonstrate a reasonable likelihood of proving that either Shen or Soldano anticipates any claim under either interpretation of “carrier.” Accordingly, Petitioner fails to demonstrate an abuse of discretion in our alleged “refusal” to interpret “carrier.”” slip op. at 3
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“Reh’g Req. 14. We cannot weigh Petitioner’s arguments based on its assertions about “caselaw” because Petitioner cited no cases to support its arguments. See id. Nevertheless, we infer that Petitioner intends its statements of “caselaw” to refer to the requirements to make out a case for anticipation. If so, Petitioner demonstrably miscasts what appear to be the legal principles for proving anticipation. As stated in our Decision: “A claim is anticipated only if each and every element as set forth in the claim is found, either expressly or inherently described, in a single prior art reference.” Verdegaal Bros., Inc. v. Union Oil Co. of California, 814 F.2d 628, 631 (Fed. Cir. 1987).” Dec. 7. Making a showing that a prior art reference anticipates a patent claim thus necessarily requires proof that a single reference “expressly or inherently” describes every element of that claim and with all elements being arranged in the reference as they are in the” slip op. at 7
Claim construction§ 102 anticipationPatents in suitUS 10,379,301 - Google LLC v. Sandpiper CDN, LLCInstitutedPTAB · Dec 1, 2025 · IPR2025-01010 · APJ Michael T Cygan · IPR · Institution
The Board instituted IPR on claims 1–15 and all asserted grounds, finding a reasonable likelihood that Petitioner would prevail on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons given below, on this record, Petitioner has established a reasonable likelihood that it would prevail in showing the unpatentability of at least one of challenged claims 1–15 of the ’322 patent. Accordingly, we institute an inter partes review of the ’322 patent.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“B. Level of Ordinary Skill in the Art Petitioner asserts that a person of ordinary skill in the art (“POSITA”) at the critical time “would have had at least a bachelor’s degree in computer 3 Neither party presents evidence or arguments regarding objective evidence of non-obviousness. work or research experience in the field of content delivery management or networks,” and that “[w]ork experience can substitute for formal education and additional formal education can substitute for work experience.” Pet. 10 (citing Ex. 1003 ¶¶ 61–63). Patent Owner does not provide any such assessment in its Preliminary Response. Prelim. Resp. 11. For purposes of this Decision, we adopt Petitioner’s proposed level of ordinary skill, as it appears to be consistent with the specification of the ’322 patent and the prior art of record.” slip op. at 6
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownDecided for petitioner
“On the current record, we determine that the “modified embedded resource” may be a “link.” Both Petitioner and Patent Owner point to claim 13, which explicitly states that a modified embedded resource is a link. Because claim 13 depends from claim 1, claim 1 must be broad enough to encompass a modified embedded resource that is a link. Patent Owner also points to a statement in the ’322 patent that “[t]he embedded resource is a link.” Prelim. Resp. 18 (citing Ex. 1001, 4:26–31). Patent Owner argues that every embodiment of the ’322 patent “involves embedding the ‘modified embedded resource’ in another resource when it is returned to the client.” Paper 16, 2–3. Patent Owner cites to description in the ’322 patent of a “document” or a “page” returned to the requesting client. Id. (citing Ex. 1001, 4:42–48, 7:48–55). However, claim 15 does not return the modified embedded resource to the client, only the origin system. Claim 1 recites only that the “modified embedded resource” is returned to the client device with the content resource. Neither claim 1 nor claim 15 recite returning a document or a page containing the modified embedded resource, only the modified embedded resource itself. We acknowledge some tension with the adjective “embedded,” which Patent Owner argues requires that the embedded resource be embedded in something. Paper 16, 1–3. However, the clear description of an embedded patent, more strongly guides our preliminary construction.” slip op. at 9
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“We are persuaded by Petitioner’s assertions for limitations [15pre]– [15a]. Dr. Mowry attests that Verna’s client browser sends a URL 28 to a content provider 22, which is then forwarded to broker 25, which selects the appropriate cache server to serve the content and returns a re-written URL to the content server that received the client request. Ex. 1003 ¶ 67 (citing Ex. 1005 ¶¶ 12, 26, 27, 37). On the current record, this function of Verna’s broker fulfills Dr. Russ’s characterization of an API as acting as bridge establishing a connection between client and server. Ex. 2010 ¶ 50. Verma also meets Dr. Russ’s characterization of an API as “an interface that allows the client to communicate with an application executing on the server.” Ex. 2010 ¶ 50. Dr. Russ describers Verma’s broker as sending availability inquiries from the content provider (client) to servers 23 and 24 to “find out whether they currently store the requested movie file,” and provide that information back to the content provider (client). Id. ¶ 53. On the current record, this function of Verna’s broker fulfills Dr. Russ’s characterization of an API acting as an interface that allows the client to provides availability information to the broker). Consequently, we determine that Petitioner has shown Verma to disclose limitation [15a] for purposes of institution on the current record.” slip op. at 13
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,057,322 - Google LLC v. Sandpiper CDN, LLCInstitutedPTAB · Nov 25, 2025 · IPR2025-00860 · APJ Sheila F Mcshane · IPR · Institution
The Board instituted review of claims 1–20 on all asserted grounds, finding a reasonable likelihood that the Dilley, Pai, and Wang combination renders the claims obvious.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“partes review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). Under 35 U.S.C. § 314(a), we may not authorize an inter partes review unless the information in the petition and the preliminary response “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons stated below, we determine that Petitioner has established a reasonable likelihood that it would prevail with respect to at least one claim. We therefore institute inter partes review as to all of the challenged claims of the ’573 patent and all of the asserted grounds of unpatentability in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“III. ANALYSIS A. Level of Ordinary Skill in the Art Petitioner asserts that a person of ordinary skill in the art: would have had at least a bachelor’s degree in computer science, electrical engineering, or a related field, and at least two years of work or research experience in the field of content delivery management or networks. Work experience can substitute for formal education and additional formal education can substitute for work experience. Pet. 12 (citing Ex. 1006 ¶ 70). Patent Owner asserts that “the Board does not need to resolve the appropriate level of skill for a POSA [person of ordinary skill in the art] for purposes of deciding institution because the Petition fails under any articulation of a POSA.” Prelim Resp. 10. For the purposes of this Decision, we adopt the assessment offered by Petitioner as it is consistent with the ’573 patent and the prior art before us. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner asserts that no claim terms need to be expressly construed by the Board and all terms should be given their ordinary meaning. Pet. 12. Patent Owner agrees that the Phillips standard applies. Prelim. Resp. 10. We determine that we need not expressly construe any claim terms at this juncture. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 9
- Disclosure Requirements (§112) › Written description (Ariad)Written description adequateEntitled to earlier dateDecided for patent owner
“We consider the disclosures of the Provisional Application, which refer to cases 1 and 2, in which requests are redirected to an origin server for lower popularity content and to a parent server for medium popularity content at steps 522 and 524 as shown in Figure 5, respectively, wherein the edge server receives a redirect from the popularity service without a “followme” flag. See Ex. 1011 ¶¶ 43, 44. The Provisional Application also discloses that, by comparison, if there is a “follow-me” redirect sent to the edge server, it obtains and caches a resource as shown at step 528 for higher popularity content. Id. ¶ 44. On this record, as Patent Owner asserts, these disclosures are consistent with technical reasons provided in the Provisional Application for instructing the edge server not to cache unpopular resources. See Ex. 1011 ¶¶ 68–69. In light of these disclosures, we preliminarily find support for Dr. Shenoy’s testimony that, even with the words “instruction to not cache” are not literally recited in the Provisional Application, caching and not caching are alternative options that indicate the instruction to the edge server that will be implemented for each option. See Ex. 2014 ¶ 56. Further, these disclosures provide support for Dr. Shenoy’s testimony that the disclosures “reasonably convey to those skilled in the art that Patent Owner had possession of the edge server receiving an instruction to not cache the resource (and instead simply forward the redirect).” Id. In re Johnson states that “it is not true that the factual context out of which the question under § 112 arises is immaterial. Quite the contrary. Here, . . . the ‘written description’ in the [] specification supported the claims in the absence of the limitation, and that specification, having described the whole, necessarily described the part remaining.” See Johnson, 558 F.2d at 1019. This is consistent with M.P.E.P. § 2173.05(i) which states, “[i]f alternative elements are positively recited in the specification, they may be explicitly excluded in the claims.” M.P.E.P. § 2173.05(i). Further, “the failure of the specification to specifically mention a limitation that later appears in the claims is not a fatal one when one skilled in the art would recognize upon reading the specification that the new language reflects what the specification shows has been invented.” All Dental Prodx, LLC v. Advantage Dental Prod., Inc., 309 F.3d 774, 779 (Fed. Cir. 2002). Even though we do not discern that the Provisional Application explicitly discloses an “instruction to not cache,” at least on this preliminary record, and for the purposes of this Decision, there is positive recital of instructions to cache in the Provisional Application and Petitioner has provided sufficient supporting evidence that caching and not caching are alternative options. Further, there is sufficient evidence, in the context of the disclosures of written description support in the Provisional Application, providing support for Dr. Shenoy’s testimony that Patent Owner had possession of an edge server receiving an instruction to not cache the resource. Nonetheless, we invite additional briefing on these issues, including issues relating to alternative options of caching and not caching. On this preliminary record, we find that the ’573 patent has a priority date of April 2, 2008, which predates the earliest possible date on which Newton-471 could be effective as prior art, September 30, 2014 (the date on which the earliest application in the priority chain of Newton-471 was filed). Accordingly, we preliminarily find that Newton-471 is not prior art to the challenged claims. Thus, on the present record, Petitioner has not demonstrated a reasonable likelihood that it would prevail in showing that claims 1–20 are anticipated by Newton-471.” slip op. at 13
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites Phillips · KSR · GrahamPatents in suitUS 10,924,573 - PTAB · Nov 21, 2025 · IPR2025-00930 · APJ Mitchell G Weatherly · IPR · Institution
The Board instituted IPR of claims 1–20 on all asserted grounds, finding a reasonable likelihood that Murphy renders claim 1 obvious.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Preliminary Response. Therefore, Petitioner’s arguments for unpatentability are currently unopposed. Institution of an inter partes review is authorized by statute when “the information presented in the petition filed under section 311 and any response filed under section 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Based on our review of the record, we conclude that Petitioner is reasonably likely to prevail with respect to at least one challenged claim.” slip op. at 2
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“Teleflex Inc., 550 U.S. 398 (2007), reaffirmed the framework for determining obviousness as set forth in Graham v. John Deere Co., 383 U.S. 1 (1966). The KSR Court summarized the four factual inquiries set forth in Graham that we apply in determining whether a claim is reasonably likely to be unpatentable as obvious under 35 U.S.C. § 103(a) as follows: (1) determining the scope and content of the prior art, (2) ascertaining the differences between the prior art and the claims at issue, (3) resolving the level of ordinary skill in the pertinent art, and (4) considering objective evidence indicating obviousness or nonobviousness. KSR, 550 U.S. at 406. With these standards in mind, we address each challenge below. C. Claims 1–6, 8–11, and 13–20: Obviousness in View of Murphy” slip op. at 6
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“A claim is anticipated only if each and every element as set forth in the claim is found, either expressly or inherently described, in a single prior art reference.” Verdegaal Bros., Inc. v. Union Oil Co. of Cal., 814 F.2d 628, 631 (Fed. Cir. 1987). The Supreme Court in KSR International Co. v. slip op. at 5
§ 102 anticipation§ 103 obviousnesscites Phillips · KSRPatents in suitUS 11,472,427 - Apple Inc. v. Apex Beam Technologies LLCInstitutedPTAB · Oct 31, 2025 · IPR2025-00900 · APJ Jeffrey S Smith · IPR · Institution
The Board instituted IPR on claims 1–20 on all asserted grounds, finding a reasonable likelihood that at least one challenged claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review may not be authorized by statute “unless . . . the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Upon consideration of the record before us, we determine Petitioner has demonstrated a reasonable likelihood that it would prevail in establishing the unpatentability of at least one of claims 1– 20 of the ’727 patent. Accordingly, we institute the requested inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“A person of ordinary skill in the art (“POSITA”) relating to the subject matter of the ’727 Patent as of [November 1, 2016] would have a bachelor’s degree in electrical engineering, computer engineering, computer science, or a similar field, along with two years of experience designing or developing wireless networks, including long-term evolution LTE/4G or 5G new radio (NR) cellular technology. APPLE-1003, Section V. Additional education might substitute for some of the experience, and additional substantial experience might substitute for some of the educational background. Id. Pet. 3–4. Patent Owner at this stage utilizes Petitioner’s proposed level of skill in the art. Prelim. Resp. 5. As Petitioner’s definition of a person of ordinary skill appears commensurate with the subject matter before us, we apply Petitioner’s definition for purposes of this Decision.” slip op. at 5
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“On this record, we agree with Petitioner. Patent Owner, in contending that Park’s hybrid CSI signal does not describe two signalings, does not address Petitioner’s mapping of the claimed “first signaling” and the claimed “second signaling.” Petitioner persuasively maps the claimed “first signaling” to Park’s hybrid CSI signal (Pet. 21), and persuasively maps the claimed “second signaling” to Park’s DCI format signal (Pet. 30). Patent Owner does not explain why Park’s DCI format signal does not describe the claimed “second signaling.” On this record, we are sufficiently persuaded by Petitioner and Dr. Akl that Park’s DCI format signal, which triggers the UE to perform aperiodic CSI reporting, describes a “second signaling . . . used to determine the Q2 antenna port(s)” as recited in limitation 1.6. See Ex. 1003 ¶¶ 137–142; Ex. 1005, 38:20–36.” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“include Shin’s CSI request field provides the benefit of allowing the network to directly configure the CSI report behavior of a UE, such that the base station can obtain channel state information regarding specific channels used by the UE and the base station in order to exchange data as taught by Shin. Pet. 59 (citing Ex. 1003 ¶ 71). Petitioner also contends that adding Shin’s CSI request field to the DCI format signal of Park is the combination of familiar elements according to known methods that yields a predictable result, and that the combination uses Shin’s known technique of including a CSI request field in a DCI format signal to improve Park’s DCI format signal in the same way. Id. at 58 (citing Ex. 1003 ¶ 69; KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 415–421 (2007)).” slip op. at 9
§ 102 anticipation§ 103 obviousnesscites KSRPatents in suitUS 11,063,727 - Aroma360, LLC v. Air Esscentials, Inc.InstitutedPTAB · Oct 8, 2025 · IPR2025-00706 · APJ Eric C Jeschke · IPR · Institution
The Board instituted inter partes review of claims 1, 4, and 7–10 on all asserted grounds, finding a reasonable likelihood of prevailing on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a) (2024) (“The Board institutes the trial on behalf of the Director.”). Inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314. Upon consideration of the evidence and arguments in the record, for the reasons below, we determine that the information presented shows a reasonable likelihood that Petitioner would prevail with respect to at least one of the challenged claims. We thus institute inter partes review on all challenged claims on all asserted grounds. See SAS Inst. Inc. v. Iancu, 584 U.S. 357, 362–63, 369–70 (2018); 37 C.F.R. § 42.108(a) (“When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.”).” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“we view the prior art and the claimed invention. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). The person of ordinary skill in the art is a hypothetical person presumed to have known the relevant prior art. In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995). In determining the level of ordinary skill in the art, we may consider certain factors, including the “type of problems encountered in the art; prior art solutions to those problems; rapidity with which innovations are made; sophistication of the technology; and educational level of active workers in the field.” Id. (internal quotation marks and citation omitted).” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“same claim construction standard that would be used in a civil action under 35 U.S.C. § 282(b), as described in Phillips v. AWH Corp., 415 F.3d 1303 (Fed. Cir. 2005) (en banc). See 37 C.F.R. § 42.100(b). Under that standard, we generally give claim terms their ordinary and customary meaning, as would be understood by a person of ordinary skill in the art at the time of the invention, in light of the language of the claims, the specification, and the prosecution history. See Phillips, 415 F.3d at 1313–14. Although extrinsic evidence, when available, may also be useful when construing claim terms under this standard, extrinsic evidence should be considered in the context of the intrinsic evidence. See id. at 1317–19. Neither Petitioner nor Patent Owner propose explicit constructions for any claim terms. Pet. 12–13; see generally Prelim. Resp. At this stage of the proceeding and based on the current record, we need not construe explicitly any claim terms because doing so would not change the outcome of the analysis below. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 8
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Motivation foundInstituted
“On the current record, this argument does not identify a deficiency in Petitioner’s position as to clauses 1C and 1D. Patent Owner implies that the structures recited in clauses 1C and 1D require functionality recited elsewhere in the claim—namely, forming a “fluid dispersion” (Prelim. Resp. 4)—but Patent Owner does not adequately present evidence supporting this implied claim construction. See In re Self, 671 F.2d 1344, 1348 (CCPA 1982) (rejecting arguments “not based on limitations appearing in the claims”). Instead, Patent Owner cites to the entirety of claim 1 in support of these implied functional requirements. See Prelim. Resp. 4. Stated differently, Patent Owner has not adequately explained why any particular component (or collection of components) must perform the function of forming the “fluid dispersion” recited in clause 1G. Moreover, even assuming as correct Patent Owner’s assertion that Sevy “requires downstream separation,” Patent Owner has not explained why such a 8 In its Preliminary Response, Patent Owner appears to use different terms for the same concept: “downstream separation”; “post-formation correction”; and “post-atomization correction.” See, e.g., Prelim. Resp. 3 (“downstream separation”), 4 (“post-formation correction”), 5–6 (“post-atomization correction”). In any response, Patent Owner should clarify the scope of these terms. requirement would fall outside of the scope of claim 1. See Elbit Sys. of Am., LLC v. Thales Visionix, Inc., 881 F.3d 1354, 1359 (Fed. Cir. 2018) (“‘[A]ttorney argument is not evidence’ and cannot rebut other admitted evidence.” (quoting Icon Health & Fitness, Inc. v. Strava, Inc., 849 F.3d 1034, 1043 (Fed. Cir. 2017))). On the current record, we determine that Petitioner has made a sufficient showing that Sevy discloses or suggests the structures recited in clauses 1C and 1D.” slip op. at 14
Claim construction§ 102 anticipation§ 103 obviousnesscites PhillipsPatents in suitUS 10,583,449 - Aroma360, LLC v. Air Esscentials, Inc.InstitutedPTAB · Oct 8, 2025 · IPR2025-00707 · APJ Eric C Jeschke · IPR · Institution
Instituted inter partes review of claims 1 and 3–8 on all asserted grounds after finding a reasonable likelihood of prevailing on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a) (2024) (“The Board institutes the trial on behalf of the Director.”). Inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314. Upon consideration of the evidence and arguments in the record, for the reasons below, we determine that the information presented shows a reasonable likelihood that Petitioner would prevail with respect to at least 1 As Paper 7 in this proceeding, Patent Owner mistakenly filed the Preliminary Response in a related proceeding. one of the challenged claims. We thus institute inter partes review on all challenged claims on all asserted grounds. See SAS Inst. Inc. v. Iancu, 584 U.S. 357, 362–63, 369–70 (2018); 37 C.F.R. § 42.108(a) (“When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.”).” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner does not dispute Petitioner’s proposed definition of the level of ordinary skill in the art, which appears generally consistent with the record at this stage of the proceeding, including the prior art. See GPAC Inc., 57 F.3d at 1579. We remove the phrase “at least” in both listed options, however, as that phrase adds ambiguity. Patent Owner does not argue at this stage of the proceedings that Petitioner’s proposal for the level of ordinary skill leads to an improper understanding of how a skilled artisan would understand either the challenged patent or the prior art. For purposes of this Decision, we adopt the definition of the level of ordinary skill in the art proposed by Petitioner, as revised above.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Neither Petitioner nor Patent Owner propose constructions for any claim terms. Pet. 16–17; see generally Prelim. Resp. At this stage of the proceeding and based on the current record, we need not construe explicitly any claim terms because doing so would not change the outcome of the analysis below. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 9
- Obviousness (§103) › Analogous artNot reached
“At this stage of the proceeding, the record on the analogous art issue is incomplete. Petitioner seems to take the position that Kaiser is in the same “field” (Pet. 47), but Petitioner does not fully address the issue of analogous art. Although Petitioner was not required to anticipate this argument with its initial filing (see Sanofi-Aventis Deutschland GmbH v. Mylan Pharma., Inc., 66 F.4th 1373, 1379 (Fed. Cir. 2023)), Petitioner may wish to address this issue as appropriate in future briefing. We will consider the full record on this issue, if necessary, as part of our analysis in any final written decision. On the current record and in view of our decision to institute based on other grounds, we reach no conclusion as to whether Petitioner has made a sufficient showing that one of ordinary skill in the art would have combined Goubet and Kaiser as proposed.” slip op. at 23
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites PhillipsPatents in suitUS 10,092,918 - PTAB · Oct 6, 2025 · IPR2025-00611 · APJ Christopher L Ogden · IPR · Institution
The Board instituted IPR of claims 1–10, 12, 13, 19, and 20 on all petition grounds after finding a reasonable likelihood that claim 1 was obvious over Douglas and Mark.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“A claim is unpatentable under § 103 “if the differences between the claimed invention and the prior art are such that the claimed invention as a whole would have been obvious before the effective filing date of the claimed invention to a person having ordinary skill in the art to which the claimed invention pertains.” 35 U.S.C. § 103; see KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 406 (2007). When a ground in a petition is based on a combination of references, we consider “whether there was an apparent reason to combine the known elements in the fashion claimed by the patent at issue.” KSR, 550 U.S. at 418 (citing In re Kahn, 441 F.3d 977, 988 (Fed. Cir. 2006)).” slip op. at 8
- Skill levelSkill level petitioner adoptedDecided for petitioner
“The parties agree that experience could substitute for a degree, and vice versa. Pet. 3 (citing Ex. 1003 ¶¶ 19–21); Prelim. Resp. 9. The parties’ proposed levels of ordinary skill are substantially similar. Although we discern no difference in the outcome of this decision from choosing one over the other, we adopt Petitioner’s proposal for this decision. Only Petitioner’s proposed level is supported by testimonial evidence on the preliminary record, and it appears to be consistent with the problems addressed in the ’774 patent. See Ex. 1001, 1:16–52. Therefore, we adopt Petitioner’s proposal for this decision.” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“CLAIM CONSTRUCTION B. In an IPR, we construe a patent claim “using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. 282(b).” 37 C.F.R. § 42.100(b). This generally includes “construing the claim in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” Id. The ordinary and customary meaning of a claim term “is its meaning to the ordinary artisan after reading the entire patent,” and “as of the effective filing date of the patent application.” Phillips, 415 F.3d at 1313, 1321. Neither Petitioner nor Patent Owner argues that we need to construe any claim terms explicitly. See Pet. 2–3; Prelim. Resp. 9. However, the parties’ positions depend on interpreting the claim language in a particular way, and we discuss the relevant claim language below in the context of the parties’ arguments regarding the prior art. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“At this stage, we find Petitioner’s arguments persuasive and disagree with Patent Owner. Patent Owner appears to equate a “fabrication profile” with a toolpath description, but nothing in the plain language of claim 1 supports that narrow interpretation. The ’774 patent describes a “fabrication profile” broadly and states that the profile can simply “include the dictionary [of configuration information],” or be “used to determine which machineready representation is available or suitable for a target printer.” Ex. 1001, 23:49–52. The preliminary evidence suggests that Douglas’s “operational parameters” would count as a “fabrication profile” because it is “the basis for generation of a machine-ready representation of the three-dimensional model that is executable on the target printer.” Id. at 23:37–39; see infra Section III.C.8. We also disagree that Petitioner’s argument is impermissible hindsight, because it is based on the disclosures in Douglas and Mark, and Petitioner has articulated a sufficiently persuasive reason to combine those references without referring to the ’774 patent itself. See In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971) (an obvious rationale is not improper hindsight if it “takes into account only knowledge which was within the level of ordinary skill at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure”). Finally, Petitioner appears to rely on Mark for providing a particular example of a fabrication profile, not to replace Douglas’s overall system in which the 3D printer can receive “operational parameters” rather than just G-code. See Pet. 8–10, 17–23; see also Ex. 1005 ¶ 41 (the print queue, which stores tool instructions, may be maintained locally on printers 204 or on print servers 208); see In re Mouttet, 686 F.3d 1322, 1332 (Fed. Cir. 2012) (“[A] determination of obviousness based on teachings from multiple references does not require an actual, physical substitution of elements.” (citing In re Etter, 756 F.2d 852, 859 (Fed. Cir. 1985) (en banc))).” slip op. at 19
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,886,774 - PTAB · Oct 6, 2025 · IPR2025-00531 · APJ Mitchell G Weatherly · IPR · Institution
Instituted IPR of claims 1–15 on all grounds; found a reasonable likelihood that claims 1–6 and 8–15 are obvious over Warren.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“filed a Preliminary Response. Paper 8 (“Prelim. Resp.”). Institution of an inter partes review is authorized by statute when “the information presented in the petition filed under section 311 and any response filed under section 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Based on our review of the record,1 we conclude that Petitioner is reasonably likely to prevail with respect to at least one of the challenged claims.” slip op. at 2
- BurdenInstituted
“limitations set forth in claim 1. Pet. 16–23 (citing Ex. 1004 ¶¶ 7–14, 58–63, 93, 230–324, 390–446, Figs. 18, 22A, 23A; Ex. 1003 ¶¶ 72–92). Patent Owner counters that “Warren does not teach one or more sensors configured to detect a current contact force.” Prelim. Resp. 25. The “current contact force” is detected by “one or more sensors” as recited in limitation 1b and limitation 1c requires “detecting the current contact force based on a sensor signal from the one or more sensors.” Ex. 1001, 12:40–45. Patent Owner does not currently contest Petitioner’s showing relating to Warren’s teaching of the other limitations recited in the method of claim 1. See Prelim. Resp. 25–27.” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“Petitioner cites portions of Warren and Dr. Wolfe’s testimony to support these reasons. Id. (citing Ex. 1004 ¶¶ 93, 226–252, 283–318, 331, 332; Ex. 1003 ¶¶ 65–71). Patent Owner has yet to submit expert testimony, so Dr. Wolfe’s testimony relating to the motivations of an ordinarily skilled artisan is largely unrebutted.” slip op. at 9
- Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication establishedInstituted
“available because Petitioner’s showing impermissibly incorporates argument by reference. Id. at 29–30. Although Petitioner’s showing is somewhat brief, see Pet. 2, we have no concerns about the sufficiency of that showing, which is based on direct testimony from a witness with undeniable personal knowledge of the history of the RepRap online forum in which RepRap20208 appears, Adrian Bowyer. Nor do we find it necessary to “piece together” arguments based on Mr. Bowyer’s testimony, which we find to be clear, concise, and probative on the nature of the RepRap forum and who frequented that forum during the relevant time period. Patent Owner is entitled to test the probative value of Mr. Bowyer’s testimony at trial if it desires.” slip op. at 13
§ 102 anticipation§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 9,168,698
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.