- Samsung Electronics Co., Ltd. / Apple Inc. v. RJ Technology LLCSome claims unpatentablePTAB · Jan 17, 2025 · IPR2024-00597 · APJ Jon B Tornquist · IPR · Final written decision
Claims 2–4 and 6–18 are unpatentable as obvious over Abe and Guyomard, with claims 9–10 also obvious over Iwaizono; claims 1 and 5 were not shown unpatentable.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person of ordinary skill in the art “would have had a Master’s degree in material science, chemical engineering, chemistry, or similar field with four years of experience designing testing, and building secondary lithium batteries.” Pet. 11 (citing Ex. 1002 ¶ 51). Petitioner further contends that a person of ordinary skill in the art would have been aware of “(1) positive electrode materials, (2) negative electrode materials, (3) separators, (4) electrolytes, (5) charge-discharge parameters, and (6) protection circuits, as well as ‘battery failure modes’ such as plating and the formation of dendrites.” Id. (citing Ex. 1002 ¶¶ 50–51). Patent Owner “does not dispute Petitioner’s level of ordinary skill.” PO Resp. 17. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the disclosures of the ’641 patent and the prior art of record.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“We also agree with Patent Owner that the charge cut-off voltage is not necessarily the applied voltage during charging. PO Resp. 20. Rather, depending on the charging protocol used and when in the charging cycle the voltage is applied, the applied voltage could be higher than the battery voltage. Ex. 2013; Ex. 2006 ¶ 91. For example, as discussed in more detail below with respect to the Uemura grounds, when fast charging using constant current is used and the charging rate is not slow, the applied voltage will be higher than the battery voltage when the constant current charging phase is stopped. Ex. 2006 ¶ 91; Ex. 2013. Likewise, during constant current/constant voltage charging, the applied voltage approximates the battery voltage only when the battery is nearly completely charged. Ex. 2013; Ex. 2006 ¶ 91. Thus, the applied voltage may be, but is not necessarily, the charge cut-off voltage. In view of the foregoing, we construe “charge cut-off voltage” in claims 1 and 5 as “the maximum value to which the battery is configured to be charged.” PO Resp. 18; Ex. 2008, 217:6–11; Pet. Reply 5. Contrary to Patent Owner’s arguments, however, we do not understand the phrase “configured to be charged” to necessarily represent a single voltage for the battery that is determined based on the structure and chemistry of the battery. Pet. Reply 4–5. Rather, the charge cut-off voltage is a selected potential, or voltage, of the battery or cell at the end of charging that is controlled by a circuit or device, such as a charger or control circuit within the battery. Ex. 1001, 9:50–55; Ex. 1048, 2, 7–8; Ex. 1008, 3:9–13. And, for the reasons discussed herein, the charge cut-off voltage may be, but is not necessarily, the same as the applied voltage during charging. PO Resp. 20.” slip op. at 15
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“charge cut-off voltage “greater than 4.2 V but less than 5.8 V” and calculating a specific or theoretic capacity “with a charge cut-off voltage limited to 4.2” (claim 1) or “with a charge cut-off voltage set at 4.2 V” (claim 5). Ex. 1001, 16:56–61, 17:6–11. Although the parties dispute the precise scope of these claim terms, the parties agree that the first use of “charge cut-off voltage” in claims 1 and 5 refers to the potential of the battery as a whole (between the cathode and the anode), and not a half-cell voltage using lithium metal as a counter electrode.10 Tr. 17:1–3 (agreeing 10 With respect to the phrase “as calculated by a theoretic capacity with a charge cut-off voltage set at 4.2 V,” the parties in fact appear to be in that the first use of “charge cut-off voltage” in claim 5 refers to a full-cell voltage); Sur-reply 5; PO Resp. 22. We need not further construe the claims to resolve the disputes between the parties. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 16
- Expert testimonyPatent owner expert creditedDecided for patent owner
“Given Mr. Juzkow’s unambiguous testimony that Uemura uses constant current charging that would stop when the applied voltage reached 11 The chart is reproduced from SAFT, Charging your lithium-ion batteries: 5 expert tips for a longer lifespan, (https://www.saft.com/energizing-iot/charging-your-lithium-ion-batteries-5-expert-tips-longerlifespan#:~: text=When%20the%20battery%20provides%20current,This%20restore s%20the%20battery's%20capacity). 4.3 V, as well as Dr. Yao’s persuasive testimony that Uemura’s constant charging rate is not slow, we credit the testimony of Dr. Yao that one of ordinary skill in the art would have understood that the internal voltage to which the battery of Uemura was charged is less than 4.3 V. Ex. 2006 ¶ 119. In particular, Dr. Yao persuasively testifies that one of ordinary skill in the art would have believed that the charge cut-off voltage was no more than 4.2 V, and most likely equal to “about 4 V.” Id. ¶¶ 119–122.” slip op. at 21
Patent outcomesUS 7,749,641 mixedClaim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,749,641 - Samsung Electronics Co., Ltd. / Apple Inc. v. RJ Technology LLCSome claims unpatentablePTAB · Jan 17, 2025 · IPR2023-01183 · APJ Jon B Tornquist · IPR · Final written decision
Claims 2–4 and 6–18 are unpatentable as obvious over Abe and Guyomard, with claims 9 and 10 also obvious over Iwaizono; claims 1 and 5 were not shown unpatentable.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person of ordinary skill in the art “would have had a Master’s degree in material science, chemical engineering, chemistry, or similar field with four years of experience designing testing, and building secondary lithium batteries.” Pet. 11 (citing Ex. 1002 ¶ 51). Petitioner further contends that a person of ordinary skill in the art would have been aware of “(1) positive electrode materials, (2) negative electrode materials, (3) separators, (4) electrolytes, (5) charge-discharge parameters, and (6) protection circuits, as well as ‘battery failure modes’ such as plating and the formation of dendrites.” Id. (citing Ex. 1002 ¶¶ 50–51). Patent Owner “does not dispute Petitioner’s level of ordinary skill.” PO Resp. 17. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the disclosures of the ’641 patent and the prior art of record.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“constructions. First, we agree with Petitioner that the ’641 patent indicates that the charge cut-off voltage selected for a particular battery need not be a fixed property of the battery or something that is set by the design and chemistry of the battery. Consistent with this conclusion, the ’641 patent discloses that a “charging device controls the charge cut-off voltage of the single lithium-ion cell within a range from 4.3 V to 5.8 V.” Ex. 1001, 9:50– 55. This strongly suggests that the charge cut-off voltage is controlled by the charger and is not necessarily an inherent property of the battery. Patent Owner contends that this is merely an unclaimed embodiment, but the relevant disclosure states that the charging device for the “present invention” may be any type of device “with the proviso that said charging device controls the charge cut-off voltage.” Id. at 9:50–53.” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“charge cut-off voltage “greater than 4.2 V but less than 5.8 V” and calculating a specific or theoretic capacity “with a charge cut-off voltage limited to 4.2” (claim 1) or “with a charge cut-off voltage set at 4.2 V” (claim 5). Ex. 1001, 16:56–61, 17:6–11. Although the parties dispute the precise scope of these claim terms, the parties agree that the first use of “charge cut-off voltage” in claims 1 and 5 refers to the potential of the battery as a whole (between the cathode and the anode), and not a half-cell voltage using lithium metal as a counter electrode.10 Tr. 17:1–3 (agreeing 10 With respect to the phrase “as calculated by a theoretic capacity with a charge cut-off voltage set at 4.2 V,” the parties in fact appear to be in that the first use of “charge cut-off voltage” in claim 5 refers to a full-cell voltage); Sur-reply 5; PO Resp. 22. We need not further construe the claims to resolve the disputes between the parties. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 16
- Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner
“Given Mr. Juzkow’s unambiguous testimony that Uemura uses constant current charging that would stop when the applied voltage reached 11 The chart is reproduced from SAFT, Charging your lithium-ion batteries: 5 expert tips for a longer lifespan, (https://www.saft.com/energizing-iot/charging-your-lithium-ion-batteries-5-expert-tips-longerlifespan#:~: text=When%20the%20battery%20provides%20current,This%20restore s%20the%20battery's%20capacity). 4.3 V, as well as Dr. Yao’s persuasive testimony that Uemura’s constant charging rate is not slow, we credit the testimony of Dr. Yao that one of ordinary skill in the art would have understood that the internal voltage to which the battery of Uemura was charged is less than 4.3 V. Ex. 2006 ¶ 119. In particular, Dr. Yao persuasively testifies that one of ordinary skill in the art would have believed that the charge cut-off voltage was no more than 4.2 V, and most likely equal to “about 4 V.” Id. ¶¶ 119–122. Petitioner argues that because the battery of Uemura is charged “to” a maximum voltage of 4.3 V, Uemura discloses the claimed charge cut-off voltage under either Petitioner’s or Patent Owner’s construction of the term. Pet. Reply 11–12 (citing Ex. 1009 ¶ 81; Ex. 1044 ¶¶ 56–59). This argument is not persuasive because Mr. Juzkow unambiguously testified that charging in Uemura stopped when the applied voltage reached 4.3 V, and Uemura discloses that the battery was charged “at” a voltage ranging from 4.3 V to 2.0 V, not “to” such a voltage. Ex. 1009 ¶ 81; Ex. 2008, 113:2–13; Ex. 2006 ¶ 119 n.64; Sur-reply 9. In view of the foregoing, we determine that Petitioner has not demonstrated by a preponderance of the evidence that Uemura anticipates independent claims 1 and 5 of the ’641 patent.” slip op. at 21
Patent outcomesUS 7,749,641 mixedClaim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,749,641 - Mercedes-Benz USA, LLC v. Daedalus Prime LLCNo claims unpatentablePTAB · Jan 8, 2025 · IPR2023-01343 · APJ Thomas L Giannetti · IPR · Final written decision
Claims 1–7, 13–15, 17, and 18 were not shown unpatentable because Bose and White, alone or in the asserted combinations, failed to teach claimed workload comparisons or workload monitoring.
RulingsFinal written decision- Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner
“We are persuaded and find for the reasons given that Petitioner fails to prove by a preponderance of the evidence that White teaches or suggests “receiving a bus workload for a communication bus and a first processing element workload for a first processing element based on an integrated circuit reaching a limit.” Patent Owner’s expert Dr. Brogioli testifies that “[t]he workload is a function of the demands imposed by, e.g., applications running on the system, and may or may not be subject to direct control, whereas the conditions under which that workload is processed are controlled directly.” Brogioli Decl. ¶ 66. We agree with Dr. Brogioli and find that White’s frequency and voltage monitoring and adjustments do not result in the power management logic receiving the bus workload as recited in claim element 4[a]. Id. ¶¶ 64–66. We find the testimony of Mr. Wyatt on this issue unconvincing. Wyatt Decl. ¶ 103. In support of his opinion that “monitoring the operating voltages and frequencies of the logic core 120A and common logic bridge 110 is monitoring the workload of those components,” he states: “It was well understood that operating frequency and voltage of a component reflect the activity and use, or workload, of that component.” Id. However, he does not provide any evidentiary support for this statement. We, therefore, give it little weight. See PTAB Consolidated Trial Practice Guide 40 (Nov. 2019)5 (“Opinions expressed without disclosing the underlying facts or data may be given little or no weight.”) (citing Rohm & Haas Co. v. Brotech Corp., 127 F.3d 1089, 1092 (Fed. Cir. 1997)).” slip op. at 30
- Skill levelSkill level petitioner adoptedDecided for petitioner
“response. Paper 9. At the institution stage, therefore, Patent Owner did not dispute Petitioner’s description of a person of ordinary skill in the art or provide its own description. We regarded Petitioner’s description as consistent with the prior art before us. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (prior art itself may reflect an appropriate level of skill). Thus, for the purpose of our Institution Decision, we adopted Petitioner’s proposal. Institution Dec. 12–13. In its Response, Patent Owner states that it “uses this definition” in its analysis. PO Resp. 15 (citing Brogioli Decl. ¶ 25). In view of the foregoing, for this Decision, we adopt the description of the person of ordinary skill articulated by Petitioner and used in our Institution Decision. In light of our review of the complete record, we find that this formulation is consistent with the ’494 patent and the prior art of record, and is supported by the testimony of Mr. Wyatt. See Wyatt Decl. ¶ 21.” slip op. at 14
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed patent owner constructionGranted
“Post-institution, Patent Owner proposes a construction for the term “workload.” PO Resp. 15–16. Patent Owner contends that “[a] person of ordinary skill in the art would understand that in the ’494 patent, the term ‘workload’ means ‘an amount of activity over a quantum or period of time.’” Id. at 15. Dr. Brogioli’s testimony supports this construction, as does Mr. Wyatt’s. Brogioli Decl. ¶¶ 36–38; Wyatt Dep. 34:14–36:9. The ’494 patent also supports this construction. Ex. 1001, 8:20–22, 9:60–63. Petitioner does not dispute this proposed construction in its Reply. For the reasons given, we adopt Patent Owner’s construction for “workload.”” slip op. at 15
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“Nowhere does Petitioner or its expert point to an explicit disclosure in Bose of making a comparison of the claimed “bus workload and a bus workload threshold.” Instead, Petitioner relies on its expert’s opinion as to what a person of ordinary skill might have known, without any additional supporting evidence. See, e.g., Pet. 26 (“[A person of ordinary skill] would have understood global PMCU compares a workload threshold as exemplified by the predicted power and performance of each power mode and the monitored workload to select and adjust the power mode of a component” (citing Wyatt Decl. ¶¶ 54–55)). This opinion is not supported by the record. The only disclosure of a comparison in Bose that we have been shown is the comparison of PowerTotal to PowerMax in step 303 of Figure 3, which Petitioner does not rely on to meet the “comparison” limitation in the claim. Hearing Tr. 17:16–20. Also without proper support is Petitioner’s assertion that “a [person of ordinary skill] would have understood that in Bose, selecting or adjusting power mode for a component entails comparing a workload threshold, such as predicted power and performance associated with each power mode with real time statistics, such as the monitored workload of a component.” Pet. 26 (citing Wyatt Decl. ¶¶ 55–56). We determine that for the reasons given, Petitioner fails to demonstrate by a preponderance of the evidence that the claimed comparison element 1[g] of claim 1 is taught or suggested by Bose. We find, therefore, that Petitioner has not demonstrated that claim 1 is anticipated by Bose, nor has Petitioner demonstrated that to a person of ordinary skill, claim 1 would have been obvious in light of Bose.” slip op. at 25
Patent outcomesUS 8,898,494 not shown unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites KSRPatents in suitUS 8,898,494 - Mercedes-Benz USA, LLC v. Daedalus Prime LLCAll claims unpatentablePTAB · Jan 8, 2025 · IPR2023-01333 · APJ Thomas L Giannetti · IPR · Final written decision
Claims 1–24 are unpatentable as obvious over Sutardja, Sutardja and Rychlik, or Sutardja and Carmack; the Board did not reach the Mathieson-based grounds.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“We regarded Petitioner’s description as consistent with the prior art before us. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (prior art itself may reflect an appropriate level of skill). Thus, for the purpose of our Institution Decision, we adopted Petitioner’s proposal. Institution Dec. 14–15.” slip op. at 14
- Expert testimonyPetitioner expert creditedDecided for petitioner
“We decline to “throw out” Dr. Horst’s testimony for several reasons. First and foremost, Patent Owner has not moved or otherwise sought to exclude his testimony, or even filed an objection. Hearing Tr. 46:19–47:1. Thus, the issue of whether the testimony should be excluded is not properly before us. Further, Petitioner asserts that “[t]his distinction is irrelevant.” Pet. Reply 2. We agree. Patent Owner has not pointed to any opinion by Dr. Horst that turns on the alleged “flaw” in the definition of the person of ordinary skill. Id. at 46:19–48:3. Finally, there is no prejudice. Patent Owner’s expert used the definition proposed by Patent Owner in his analysis. See Brogioli Decl. ¶ 25. Nor could Patent Owner show us with specificity any place in the record where resolving this dispute would make a difference in this case. Hearing Tr. 46:3–47:3. For the reasons given, we do not see the need to modify our definition of a person of ordinary skill or to exclude or give little weight to Dr. Horst’s opinions.” slip op. at 15
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed patent owner constructionGranted
“operating system.” PO Resp. 12–13. Relying on the Microsoft Computer Dictionary, Patent Owner contends that “[a]n ‘operating system’ is, and would be understood by a person of ordinary skill in the art to be, ‘The software that controls the allocation and usage of hardware resources such as memory, central processing unit (CPU) time, disk space, and peripheral devices.’” PO Resp. 13 (citing Ex. 2007, 378). Dr. Brogioli’s testimony generally supports this construction, as does Dr. Horst’s. See Brogioli Dep. 8:17–22; Horst Dep. 32:3–8. Petitioner responds that the term “should be understood in accordance with its plain meaning,” and therefore does not require construction, but does not dispute Patent Owner’s proposed construction. Pet. Reply 2. For the reasons given, we adopt Patent Owner’s construction for “operating system.” However, we do not see this construction as dispositive of the central issue of whether the operating system in Sutardja controls the transition of the cores. See Section II.D.1, infra. slip op. at 16
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“PMS module do not ‘control’ the core switching module or the hardware on which it runs. Instead, the kernel and the PMS module only make system calls to the core switching module.” PO Resp. 27. We disagree that this is not sufficient control to meet this claim limitation. As Dr. Horst’s testimony (quoted supra) explains, the PMS module and kernel modules “trigger a transition” by generating a call to the hypervisor module or a core switching module. Horst Decl. ¶ 124. Patent Owner’s argument fails because it assumes the claims require direct control, when the claims recite no such restriction (nor have we been asked by either party to construe the claims as such).” slip op. at 28
Patent outcomesUS 10,049,080 unpatentableClaim construction§ 103 obviousnesscites KSRPatents in suitUS 10,049,080 - PTAB · Dec 16, 2024 · IPR2024-00997 · APJ Christopher L Ogden · IPR · Institution
The Board denied institution of IPR challenging claims 1–10, exercising its discretion under § 314(a) because the Fintiv factors favored denial.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivDenied
“Based on the preliminary record, we can reasonably expect trial in the parallel district court proceedings to begin four to five months prior to the deadline for our final written decision, based on the scheduled trial date and the median time-to-trial statistics. See Fintiv Memo 8–9 & n.12 (approving the use of median time-to-trial statistics). Even if the proceedings are staggered, at least one of the proceedings would likely begin and conclude well before our decision, making it highly likely that there will be duplicate efforts in evaluating the challenged claims based on the prior art. Thus, we agree with Patent Owner that the second factor weighs substantially in favor of discretionary denial.” slip op. at 9
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied fintivInstitution denied
“and Trademark Office under 37 C.F.R. § 42.4(a), we may only institute an inter partes review when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a); see also 37 C.F.R. § 42.108(c). However, institution of inter partes review is discretionary. See Harmonic Inc. v. Avid” slip op. at 2
- Skill levelSkill level petitioner adoptedOther
“ordinary skill in the art. See Phillips v. AWH Corp., 415 F.3d 1303, 1312– 1313 (Fed. Cir. 2005) (en banc) (the level of ordinary skill is pertinent to claim construction); Graham v. John Deere Co. of Kan. City, 383 U.S. 1, 17–18 (1966) (the level of ordinary skill is one of the factors to consider when determining obviousness). For this decision, we adopt Petitioner’s proposed level of ordinary skill, which is “the equivalent of an undergraduate degree in Electrical Engineering, Computer Science, or Computer Engineering; familiarity with the relevant 3GPP standards as of this time; and at least two years of experience in design, development, and/or testing of cellular networks.” Pet. 15–16 (citing Ex. 1003 ¶¶ 43–44). Although Patent Owner argues for a higher level of ordinary skill (see Prelim. Resp. 7–8), our determination that the Petition lacks compelling merits would be the same under Patent Owner’s proposal.” slip op. at 15
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“The parties argue that we need not address any claim-construction issues for our analysis, and we agree. See Pet. 15; Prelim. Resp. 25. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 16
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · GrahamPatents in suitUS 10,798,754 - PTAB · Dec 16, 2024 · IPR2024-01012 · APJ Julia Heaney · IPR · Institution
The Board instituted IPR on claims 1–16 and all asserted grounds, finding a reasonable likelihood of unpatentability and declining Fintiv discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Upon consideration of the Petition in view of the record at this stage, we determine that Petitioner has established a reasonable likelihood that it would prevail in showing the unpatentability of at least one claim challenged in the Petition. We also determine that the arguments and evidence of record do not support discretionary denial of the Petition under 35 U.S.C. § 314(a). Accordingly, we grant institution of an inter partes review of all claims and all grounds asserted in the Petition.1” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“parties on the present record, we are persuaded Petitioner sufficiently shows the combination of Bosnyak-392 and Son teaches or suggests all of the limitations of claim 1, and sufficiently explains how a person of ordinary skill in the art would have used Bosnyak-392’s teaching of using exfoliated, open-ended carbon nanotube fibers having two different aspect ratios in a composition with improved electrical and mechanical properties, with Son’s implementation of a specific bimodal distribution of aspect ratios, to arrive at the composition of claim 1 with a reasonable expectation of success. We do not find persuasive Patent Owner’s arguments that Bosnyak- 392 teaches away from using nanotubes with a lower aspect ratio, or that Bosnyak-392 has an objective of maintaining longer nanotubes. See Prelim. Resp. 5–9. Patent Owner’s arguments appear to be based on a mischaracterization of Bosnyak-392, which read as a whole, discusses methods for exfoliating carbon nanotubes and physical properties of exfoliated nanotubes, such as length and diameter, that are not apparent when the nanotubes are aggregated. E.g., Ex. 1005 ¶ 37. Although Bosnyak-392 recognizes that nanotube exfoliating techniques tend to reduce nanotube length (see Ex. 1003 ¶ 28), it does not discourage the use of shorter nanotubes. Rather, it recognizes that using short and long nanotubes together can produce a composite with improved electrical and mechanical properties. See id. (citing Ex. 1005 ¶ 73). See In re Fulton, 391 F.3d 1195, 1201 (Fed. Cir. 2004) (a reference does not teach away from a claimed invention unless it “criticizes, discredits, or otherwise discourages” the claimed solution).” slip op. at 17
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundDecided for petitioner
“We do not find persuasive Patent Owner’s arguments that Bosnyak- 392 teaches away from using nanotubes with a lower aspect ratio, or that Bosnyak-392 has an objective of maintaining longer nanotubes. See Prelim. Resp. 5–9. Patent Owner’s arguments appear to be based on a mischaracterization of Bosnyak-392, which read as a whole, discusses methods for exfoliating carbon nanotubes and physical properties of exfoliated nanotubes, such as length and diameter, that are not apparent when the nanotubes are aggregated. E.g., Ex. 1005 ¶ 37. Although Bosnyak-392 recognizes that nanotube exfoliating techniques tend to reduce nanotube length (see Ex. 1003 ¶ 28), it does not discourage the use of shorter nanotubes. Rather, it recognizes that using short and long nanotubes together can produce a composite with improved electrical and mechanical properties. See id. (citing Ex. 1005 ¶ 73). See In re Fulton, 391 F.3d 1195, 1201 (Fed. Cir. 2004) (a reference does not teach away from a claimed invention unless it “criticizes, discredits, or otherwise discourages” the claimed solution).” slip op. at 18
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“Having considered both sides’ arguments as to Fintiv factors 2 and 3, we determine that the considerations of these factors weigh against exercising discretionary denial. Neither party directs us to any substantive order issued by the district court in the parallel litigation, which indicates the court has not yet considered claim construction or potential invalidity of the ’282 patent. The Markman hearing will not occur until June 2025, and the expert discovery cutoff is not until August 2025. Ex. 2002. Thus, although the parties have begun discovery as to invalidity issues, much further work remains in the parallel district court litigation. We also take into account Petitioner’s prompt filing of the Petition, as weighing against exercising discretionary denial. See Fintiv 11 (“If the evidence shows that the petitioner filed the petition expeditiously, such as promptly after becoming aware of the claims being asserted, this fact has weighed against exercising the authority to deny institution . . . .”).” slip op. at 34
Claim construction§ 103 obviousnessDiscretionary denialcites KSR · GrahamPatents in suitUS 10,608,282 - PTAB · Dec 16, 2024 · IPR2024-01005 · APJ Julia Heaney · IPR · Institution
The Board instituted IPR on claims 1–23 and all asserted grounds, finding a reasonable likelihood that at least one challenged claim would have been shown unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). Upon consideration of the Petition, the Preliminary Response, and the evidence of record, we determine that Petitioner has established a reasonable likelihood that it would prevail in showing the unpatentability of at least one claim challenged in the Petition. We also determine that the arguments and evidence of record do not support discretionary denial under 35 U.S.C. § 314(a). Accordingly, we institute an inter partes review of all claims and all grounds asserted in the Petition.1” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“under the sixth Fintiv factor only after a determination that the first five Fintiv factors favor discretionary denial. CommScope, 4–5. Here, we do not find the first five factors cumulatively weigh in favor of discretionary denial. Therefore, we determine that the circumstances here do not warrant an analysis of whether the Petition presents compelling merits, and the considerations of the sixth Fintiv factor weigh against exercising discretionary denial. F. Conclusion Having considered the parties’ arguments in view of the Fintiv factors, and taking into account Petitioner’s stipulation, we determine that the circumstances here do not warrant exercising discretion under § 314(a) to deny institution. IV.” slip op. at 35
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Thus, although both parties indicate that no claim construction is necessary at this stage of the proceeding, it is apparent that they disagree as to the meaning of “discrete carbon nanotubes.” While Petitioner appears to construe “discrete carbon nanotubes” as “nanotubes that are generally individually distinct” (Pet. 13), Patent Owner argues a more restricted construction requiring that “discrete carbon nanotubes” not be reacted with other components. Prelim. Resp. 3. The evidence relating to claim 10 In quotations from the Preliminary Response throughout this Decision, we have retained bolding and underlining added to the text by Patent Owner. construction that Patent Owner offers on the current record, however, does not address its proposed restriction. See id. at 9, n. 4, citing Ex. 1001, 3:9, 5:39–40 (“The ’649 Patent describes the ‘discrete carbon nanotubes’ as, for example, ‘individually dispersed’, ‘individualized carbon nanotubes’, ‘dispersed as individual nanotubes’, and ‘essentially discrete individual fibers, not entangled as a mass.’”). As discussed in Section II.D.2 below, we determine based on the record at this stage of the proceeding that Petitioner demonstrates sufficiently for purposes of institution that Sun discloses or suggests “discrete carbon nanotubes.” Therefore, we do not explicitly construe any claim terms in this Decision. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). If either party intends to argue a claim construction at trial, however, including what is the ordinary meaning of a term, they should do so in a clearly designated section of their briefing. See Patent Trial and Appeal Board Consolidated Trial Practice Guide (Nov. 21, 2019) (“CTPG”), 46, 49 (available at https://www.uspto.gov/TrialPracticeGuideConsolidated); O2 Micro Int’l Ltd. v. Beyond Innovation Tech. Co., 521 F.3d 1351, 1361 (Fed. Cir. 2008) (“A determination that a claim term ‘needs no construction’ or has the ‘plain and ordinary meaning’ may be inadequate when a term has more than one ‘ordinary’ meaning or when reliance on a term’s ‘ordinary’ meaning does not resolve the parties’ dispute.”). Claim construction arguments should not be relegated to patentability arguments on the facts.” slip op. at 7
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner argues a person of ordinary skill in the art at the time of the invention “would have had at least [a] Master’s degree in materials science, chemistry, chemical engineering, a field relevant to polymer science and engineering, or the equivalent, and at least three years of experience in nanomaterials, electrochemistry, batteries, or polymer related activities.” Pet. 5 (citing Ex. 1003 ¶ 19). Petitioner further argues that “[a]dditional work experience can compensate for less formal education, and vice versa.” Id. Patent Owner does not dispute the level of ordinary skill in the art. Prelim. Resp. 4. For purposes of this decision, we adopt Petitioner’s definition of the level of ordinary skill in the art because it is consistent with the ’649 patent and the asserted prior art.” slip op. at 9
Claim construction§ 103 obviousnessDiscretionary denialcites KSR · GrahamPatents in suitUS 9,636,649 - PTAB · Dec 16, 2024 · IPR2024-01013 · APJ Jon B Tornquist · IPR · Institution
The Board instituted IPR on claims 1–4 and 7–18 on all three asserted obviousness grounds, finding a reasonable likelihood of success and declining discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). Having considered the arguments and evidence set forth by Petitioner and Patent Owner, we determine that the information presented in the Petition demonstrates a reasonable likelihood that Petitioner would prevail on at least one of the challenged claims of the ’483 patent. We also determine that the arguments and evidence of record do not support discretionary denial under either 35 U.S.C. § 314(a) or § 325(d). Accordingly, we institute an inter partes review as to all of the challenged claims of the ’483 patent on all of the grounds of unpatentability set forth therein.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“We agree with Patent Owner that, “given the breadth of remaining grounds of invalidity in parallel litigation,” Petitioner’s stipulation “would only resolve a small portion of the issues before the court.” Prelim. Sur-reply 3. Nevertheless, the stipulation offered by Petitioner does mitigate, at least to some extent, concerns of “potentially conflicting decisions.” Sand Revolution at 12. Accordingly, we determine that Fintiv factor 4 weighs, at least to some extent, against exercising our authority to deny institution.” slip op. at 33
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDecided for petitioner
“During prosecution, the examiner stated that the carbon nanotubes of the applied prior art reference “are considered discrete and exfoliated . . . because they are dispersed in the composite cathode slurry mixture.” Ex. 1002, 5–6. The Board determined, however, that “without more,” the examiner’s bare statement was insufficient to address the prior art reference’s “express teaching that suggests bundling or agglomeration of carbon nanotubes.” Id. at 6 (noting that Figure 2 of the prior art reference suggested that the carbon nanotubes were in fact bundled and agglomerated). In contrast to the art and analysis provided by the examiner during prosecution, Petitioner identifies a specific disclosure in Ohata demonstrating that the carbon nanotubes are “discrete, non-agglomerated, and exfoliated.” Pet. 32–33 (citing Ex. 1004, Fig. 1(b)). In further contrast to the arguments presented during prosecution, Patent Owner identifies no disclosure in Ohata, or any other prior art reference, that would suggest that the carbon nanotubes of Ohata, Kavan, and Gong or Liu are agglomerated or non-discrete. Prelim. Resp. 22–23. As such, we determine that the prior art and arguments set forth in the Petition are not substantially the same as those previously analyzed by the Office. Thus, we decline to exercise discretion to dismiss the Petition under 35 U.S.C. § 325(d).” slip op. at 37
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art would have had “at least a Master’s degree in materials science, chemistry, chemical engineering, a field relevant to polymer science and engineering, or the equivalent, and at least three years of experience in nanomaterials, electrochemistry, batteries, or polymer related activities.” Pet. 7. Petitioner further contends that “[a]dditional work experience can compensate for less formal education and vice versa.” Id. For purposes of its Preliminary Response, Patent Owner “does not dispute the Petition’s definition of [the] level of ordinary skill in the art.” Prelim. Resp. 3. On this record, we preliminarily adopt Petitioner’s definition of the person of ordinary skill in the art as it appears consistent with the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (holding that the prior art itself can reflect the appropriate level of ordinary skill in the art).” slip op. at 6
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,153,483 - PTAB · Dec 16, 2024 · IPR2024-01011 · APJ Jeffrey W Abraham · IPR · Institution
The Board instituted IPR on claims 1–5 under all asserted grounds, finding a reasonable likelihood of prevailing on at least one claim and no basis for discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Having considered the arguments and evidence set forth by Petitioner and Patent Owner, we determine that the information presented in the Petition demonstrates a reasonable likelihood that Petitioner would prevail on at least one of the challenged claims of the ’924 patent. We also determine that the arguments and evidence of record do not support discretionary denial of the Petition under 35 U.S.C. § 314(a). Accordingly, we institute an inter partes review as to all of the challenged claims of the ’924 patent on all of the grounds of unpatentability set forth therein.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“Although the parties appear to agree that this factor is neutral, we note that a district court denial of a motion to stay without prejudice, accompanied by an indication that the district court would consider a renewed motion, “suggests the district court may be willing to avoid duplicative efforts and await the PTAB’s final resolution of the patentability issues raised in the petition before proceeding with the parallel litigation.” Fintiv at 6–7. “This fact has usually weighed against exercising authority to deny institution.” Id. (also noting that factors 2 and 3 are relevant to how much weight to give to the court’s willingness to reconsider a stay); see also T-Mobile, Paper 16 at 12 (noting that a stay was unlikely in that case given the proximity of the trial date to the entry of the institution decision). In view of the forgoing, we determine that Fintiv factor 1 weighs against exercising our authority to deny institution.” slip op. at 39
- Skill levelSkill level petitioner adoptedDecided for petitioner
“had at least a Master’s degree in materials science, chemistry, chemical engineering, a field relevant to polymer science and engineering, or the equivalent, and at least three years of experience in nanomaterials, electrochemistry, batteries, or polymer related activities” and that “[a]dditional work experience can compensate for less formal education, and vice versa.” Pet. 8 (citing Ex. 1003 ¶ 11). For purposes of its Preliminary Response, Patent Owner “does not dispute the Petition’s definition of [the] level of ordinary skill in the art.” Prelim. Resp. 2. On this record, we preliminarily adopt Petitioner’s definition of the person of ordinary skill in the art because it appears consistent with the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (holding that the prior art itself can reflect the appropriate level of ordinary skill in the art).” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner argues that “no formal claim constructions are necessary.” Pet. 9. Patent Owner contends that all claim terms should be interpreted “in accordance with their ordinary and customary meaning.” Prelim. Resp. 2. Upon review of the record, we determine that no claim terms require express construction for purposes of this Decision. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 8
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,968,924 - Intel Corporation v. Besang Inc.No claims unpatentablePTAB · Dec 11, 2024 · IPR2023-00991 · APJ Jon B Tornquist · IPR · Final written decision
The Board held claims 1 and 13–17 not unpatentable, finding the asserted obviousness grounds deficient in claim limitations or motivation to combine.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“The parties proposed definitions differ in that Petitioner would permit a degree in “materials science” and require three years, as opposed to two years, of relevant experience. Compare Pet. 9 with PO Resp. 14. On this record, we adopt Patent Owner’s proposed definition, as it is more consistent with the prior art of record and the disclosures of the ’702 patent. We note, however, that neither party contends that the outcome of this case depends on the slight differences in the proposed definitions of a person of ordinary skill in the art.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“1996) (“It is well-settled that, in interpreting an asserted claim, the court should look first to the intrinsic evidence of record, i.e., the patent itself, including the claims, the specification and, if in evidence, the prosecution history.”). Upon review of the parties’ arguments and the intrinsic record, we agree with Petitioner that the ’702 patent does not support a construction of “stackable add-on layer” that encompasses memory cells formed by sequential deposition on a substrate without being formed and then added to a separately formed substrate. Pet. 11–12. First, the plain language of the claim does not require merely a “layer” having a plurality of vertically oriented semiconductor memory cells, but rather “a stackable add-on layer” having a plurality of vertically oriented semiconductor memory cells; that plurality is bonded to the dielectric layer. Ex. 1001, 12:29–32. A construction that gives meaning to all words of the claim is preferred. Merck & Co., Inc. v. Teva Pharm. USA, Inc., 395 F.3d 1364, 1372 (Fed. Cir. 2005) (“A claim construction that gives meaning to all the terms of the claim is preferred over one that does not do so.”).” slip op. at 12
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“As discussed above, we do not understand a “stackable add-on layer” to include memory cells that are formed by sequential deposition on or above a substrate without being added to a separately formed substrate. It is undisputed, and indeed it is Petitioner’s assertion, that Lee’s memory devices are formed by sequential deposition. Pet. 16, 29 n.11, 51 (“In Lee, each level 3104 is deposited on the underlying level of array 3101.”). Therefore, Petitioner has not shown that Lee discloses every limitation of independent claim 13 under our claim construction. Thus, Petitioner does not demonstrate by a preponderance of the evidence that claim 13 would have been obvious in view of Lee. 3. Analysis: Claims 14–17 Claims 14–17 each depend, directly or indirectly, from claim 13. Petitioner’s arguments with respect to these claims do not remedy the deficiencies noted above with respect to claim 13. Pet. 31–41. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claims 14–17 would have been obvious over Lee.” slip op. at 19
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“We agree with Patent Owner that Petitioner has not demonstrated that Aspar would improve Lee, would solve a problem in Lee, and that Petitioner is proposing to use Aspar in a way that is not disclosed in the reference. PO Resp. 49–50 (citing Ex. 2029 ¶¶ 153–162); Tr. 57:24–58:12; Pet. 61; KSR, 550 U.S. at 417 (asking whether a technique “would improve similar devices in the same way”), 420 (asking whether there was a known problem in the art), 421 (asking whether one of ordinary skill in the art had reason to “pursue the known options”); Intel, 61 F.4th at 1381 (explaining that obviousness may be demonstrated by showing that there was a known problem in the art (“cache coherency in multiprocessor systems”) and that a person of ordinary skill in the art would recognize that that the prior art solution to this problem (“global segmented secondary cache”) would improve the system of another prior art reference). Petitioner does not persuasively show that there was any known problem in the art with respect to Lee or its monolithic method of constructing memory arrays. Nor does Petitioner provide persuasive argument or evidence that Aspar’s wafer bonding would improve Lee’s memory device.10 For example, Petitioner states in a conclusory fashion that Aspar would address the known problem of “fabricating 3D structures,” but does not explain what those problems were or why Lee fails to solve them. Pet. 61. Dr. Sechen’s testimony merely parrots the Petition, providing no further analysis or explanation of what problem might exist in Lee when fabricating its 3D structures. Ex. 1003 ¶ 212. The Petition notes that Aspar transfers “thin layers of very good thickness homogeneity and with a high crystalline quality,” but the Petition never asserts that Lee’s direct deposition method fails to provide these same or similar qualities. Pet. 60–61.” slip op. at 27
Patent outcomesUS 7,378,702 not shown unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,378,702
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.