- Yealink (USA) Network Technology Co., Ltd. / Yealink Network Technology Co., Ltd. v. Barco NVNo claims unpatentablePTAB · Oct 5, 2026 · IPR2025-00598 · APJ David C Mckone · IPR · Final written decision
Claims 1–31 were not shown unpatentable under either § 103 ground because the asserted combinations did not teach required claim limitations.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedOther
“admissions by Patent Owner in litigation, contends that a person of ordinary skill in the art would have had “a Master of Science (M.S.) degree in electrical engineering or computer science, and five years of work experience in a related field” and that “[a]dditional educational experience could substitute for some of the work experience.” Pet. 5 (citing Ex. 1002 ¶¶ 36–37). “Patent Owner does not dispute Petitioner’s proposed level of skill in the art (Petition, 5) at this time.” PO Resp. 6. On the complete record, we adopt Petitioner’s description of the level of ordinary skill in the art, as it is uncontested and is consistent with the technology described in the ’347 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“In the Preliminary Response, “Patent Owner accept[ed] the Petition’s claim construction.” Prelim. Resp. 6. However, in the Patent Owner Response, Patent Owner argues that “the claims of the ’347 Patent require no construction as they are valid under their plain and ordinary meaning.” PO Resp. 6. Based on the complete record, we do not find it necessary to provide express claim constructions of any claim terms. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (noting that “we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 9
- Expert testimonyPetitioner expert discountedDecided for patent owner
“Beel actually discloses the following: [0321] On the peripheral device 32 the video packets are received at the corresponding plug and play port, e.g. the USB port 11, read by the Human Interface Driver (HID) interface handler 13, unpacked to remove HID protocol headers in an unpacker 20 and then transmitted to the communications network by a transmitter 21. The network can be wireless for example WiFi or LiFi network. [0322] Having been routed over a communications network to the base unit 33, the incoming stream is read from the communications interface such as a WiFi access point 22, unpacked in an unpacker 25, decoded in a decoder 26 and then inserted into a suitable composition such as an OpenGL based composition in the compositor 29 for display on a central display device. Ex. 1005 ¶¶ 321–322 (emphasis added to portions quoted by Petitioner). Patent Owner notes that “[t]he Petition mistakenly cites to ¶ 322 of Beel but quotes ¶ 321.” PO Resp. 20 n.3. However, it appears that Petitioner has grafted together a portion of paragraph 321 that introduces peripheral device 32 with a portion of paragraph 322, which discusses features of base unit 33. However, this grafting has been done in such a way as to convey (incorrectly) that peripheral device 32, not base unit 33, includes unpacker 25, decoder 26, and compositor 29 that process the first processed video data received by the first peripheral device to generate second video data. Dr. Almeroth’s testimony, which copies Petitioner’s incorrectly altered quotation to paragraph 322 of Beel, is unreliable as to this claim limitation and is entitled to no weight.4 Thus, Petitioner has no expert testimony on which to rely for this claim limitation.” slip op. at 19
- Strike new argumentNew argument disregardedDecided for patent owner
“5 At the oral argument, when challenged on its reliance on paragraph 322, Petitioner argued that paragraph 321 of Beel teaches this limitation. Tr. 22:26–23:24. Petitioner did not make this argument in the Petition and, instead, raised it for the first time during oral argument; thus, it will not be considered. See Dell Inc. v. Acceleron, LLC, 884 F.3d 1364, 1369 (Fed. Cir. 2018) (“Unless it chose to exercise its waiver authority under 37 C.F.R. § 42.5(b), the Board was obligated to dismiss Dell’s untimely argument given that the untimely argument in this case was raised for the first time during oral argument.”). Even if we were to consider this new argument, it would not be persuasive. As Patent Owner observes (PO Resp. 20), any processing performed by peripheral device 32 in paragraph 321 is on data received from the processing device and destined for the base station via the network, rather than data flowing in the direction of the first processed video data of claim 1.” slip op. at 22
Patent outcomesUS 11,966,347 not shown unpatentableClaim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 11,966,347 - Shenzhen Tuozhu Technology Co., Ltd. v. Stratasys, Inc.All claims unpatentablePTAB · Sep 28, 2026 · IPR2025-00611 · APJ Christopher L Ogden · IPR · Final written decision
Claims 1–10, 12, 13, 19, and 20 are unpatentable under § 103 over the stated Douglas–Mark and Hamilton-based grounds.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“The parties agree that experience could substitute for a degree, and vice versa. Pet. 3; PO Resp. 10. The parties’ proposed levels of ordinary skill are substantially similar. For this decision, as in the Institution Decision, we adopt Petitioner’s proposed level, which is supported by credible testimonial evidence and is consistent with the problems addressed in the ’774 patent. See Ex. 1001, 1:16–52. Our decision would be the same, however, if we were to adopt Patent Owner’s proposal.” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Other
“Neither Petitioner nor Patent Owner argues that we need to construe any claim terms explicitly. See Pet. 2–3; PO Resp. 10. However, the parties contest two material claim-construction issues which we address below. To the extent that the parties’ positions depend on interpreting other claim language in a particular way, we discuss the relevant claim language below in the context of the parties’ arguments regarding the prior art.” slip op. at 8
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“We disagree with Patent Owner that a person of ordinary skill in the art would have understood that limitation 1.2 must be performed before limitations 1.3 or 1.4. See Ex. 1001, 35:21–24. See Interactive Gift Exp., Inc. v. Compuserve Inc., 256 F.3d 1323, 1342 (Fed. Cir. 2001) (“Unless the steps of a method actually recite an order, the steps are not ordinarily construed to require one.” (citing Loral Fairchild Corp. v. Sony Corp., 181 F.3d 1313, 1322 (Fed. Cir. 1999)). The evidence suggests that a “target printer” is any printer that is ultimately selected for fabricating the object, and such a printer could send its configuration information either before or after that determination is made in limitation 1.2. This interpretation does not render the word “target” meaningless. At some point, a printer must be determined to be the target printer, which is the one intended to ultimately fabricate the three-dimensional object. But the target printer still exists, and is capable of being queried, before that determination is made. We find the examples in the ’774 patent pertinent to this question. The ’774 patent states that “the target printer may include more than one printer.” Ex. 1001, 18:66–67. In discussing the step of “query target printer for properties 306” (Fig. 3A), the ’774 patent states that “[i]n one aspect, numerous queries are sent to numerous printers, e.g., for use in selecting one or more of the printers as the target printer.” Id. at 19:8–10. Alternatively, “the query is sent to a printer that is not necessarily the target printer as described herein, e.g., when the query or information received from a response to the query is used for the selection of the target printer.” Id. at 19:11–14. Importantly, the second embodiment states that the queried printer “is not necessarily the target printer,” suggesting that the queried printer could be the target printer even before it is determined to be such. Id. at 19:11–12 (emphasis added). Based on the evidence of record, a person of ordinary skill in the art would have understood that the “target printer” can be determined after the query recited in limitation 1.3 or the reception of configuration information recited in limitation 1.4. Thus, the evidence does not impose an ordering between limitations 1.2 and 1.3 or between limitations 1.2 and 1.4. The evidence also does not support Patent Owner’s argument that the two reverse-order examples in the ’774 patent are unclaimed embodiments.” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightMotivation foundDecided for petitioner
“We disagree that Petitioner’s arguments are based on impermissible hindsight, because they are based on the disclosures in Douglas and Mark, and Petitioner has articulated a persuasive reason to combine those references without referring to the ’774 patent itself, as we discuss below. See In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971) (an obvious rationale is not improper hindsight if it “takes into account only knowledge which was within the level of ordinary skill at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure”).” slip op. at 29
Patent outcomesUS 11,886,774 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,886,774 - Tesla, Inc. v. Intellectual Ventures II LLCSome claims unpatentablePTAB · Jul 1, 2026 · IPR2025-00222 · APJ Frederick C Laney · IPR · Final written decision
Claims 1, 2, 4, 5, 8–11, 13, and 14 are unpatentable over Yu and Miyazaki; claims 15, 16, and 19 were not shown unpatentable over Matsushima.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person of ordinary skill in the art “at, and before, the earliest claimed priority date of the ’158 patent . . . would have had a bachelor’s degree in electrical engineering, computer engineering, computer science, or a related field and 2–3 years of experience in digital imaging systems,” adding that “[l]ess experience may be sufficient with additional education, and likewise, less education may be sufficient with additional work experience.” Pet. 6–7 (citing Ex. 1003 ¶¶ 16–18). Patent Owner does not offer a competing definition or dispute Petitioner's articulation. Based on the entire record, we adopt Petitioner’s characterization of the level of skill for one of ordinary skill in the art because that characterization, we find, is consistent with the ’158 patent and the asserted prior art.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownOther
“We determine that the claims require a per-channel determination of integration time—that is, an integration time arrived at for each sensor or channel individually—and cannot be satisfied by a single global value merely applied uniformly across the sensors. We do not, however, read the independent claims to require that the per-channel integration times differ from one another.” slip op. at 11
- Claim Construction › Intrinsic evidence (Phillips canons) › Lexicography (patentee as own lexicographer)Term construed board ownDecided for patent owner
“We adopt the definition clearly and unambiguously set forth in the specification, which was likewise adopted by the Court in the related litigation. See Pet. 7–8, 55; Pet. Reply 1–2 (district court construing the term to mean “the time the image sensor collects and integrates signal from the scene”). The specification states that the integrated photo-charge “is directly related to the time the image sensor collects and integrates signal from the scene,” and that “[t]his is known as integration time.” Ex. 1001, 4:4–7. Accordingly, the ’158 patent demonstrates that the inventors indisputably acted as a lexicographer for the term “integration time.”” slip op. at 13
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownOther
“We construe “during a frame” to mean the period during which data for a single frame of an image is captured. The limitation is satisfied where the per-channel integration time is effectuated during the frame; it does not require that the integration time be re-determined mid-frame, nor does it require actuation of a “charge integration switch.” The specification’s only use of the phrase confirms this reading: “each camera channel is controlled during a frame under an independent integration time.” Ex. 1001, 3:45–50. Consistent with that usage, the specification describes selecting an integration time for each channel and then integrating the photo-signal “within a single frame of data,” and describes placing the charge-integration switch in a state to allow charge to accumulate for the selected period and then transferring the accumulated charge upon completion of the integration period. Id. at 4:51–54, 11:3–18. We decline Patent Owner’s proposal to require in-frame actuation of a charge-integration switch, for the same reason we decline to import that structure into “integration time.” We also decline to read the phrase to require mid-frame re-determination of the integration time, because the patent’s own embodiment selects an integration time and then integrates charge during the frame under that selected time. Ex. 1001, 4:51–54, 11:3– 18. So construed, “during a frame” is not redundant of the independentclaim limitation: it adds that the per-channel control occurs within a single frame (intrascene), as distinct from adjustment from one frame to the next (interscene).” slip op. at 15
Patent outcomesUS 9,232,158 mixedClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,232,158 - PTAB · Dec 19, 2025 · IPR2025-01078 · APJ Robert L Kinder · IPR · Institution
The Board instituted IPR on claims 1, 2, 4–12, 14–22, and 24–30, finding a reasonable likelihood that Kido anticipates at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. 35 U.S.C. § 314(b); 37 C.F.R. § 42.4(a) (2024). An inter partes review may not be instituted “unless. . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Moreover, a decision to institute under 35 U.S.C. § 314 may not institute on fewer than all claims challenged in the petition. SAS Inst., Inc. v. Iancu, 584 U.S. 357, 371 (2018).” slip op. at 2
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for petitioner
“At this juncture in the proceeding, and based on the current record, we do not agree with Patent Owner that “payout,” as claimed, should be limited to “the amount a player will win in relation to the amount wagered.” We recognize, as Patent Owner points out, that the examples provided in the Specification are listed in odds format. See id. at 2. The Specification, however, also states that “[a]ny suitable payouts can be used in some embodiments.” Ex. 1011, 5:18–21. This language suggests a broader interpretation of “payout” beyond just payout odds and we therefore decline to import the wager limitation into the claim term. Although the ’371 patent generally describes payouts in terms of odds, like 49:1, the intrinsic record lacks clear evidence necessary to limit the claims as Patent Owner proposes.” slip op. at 8
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner proposes “a person having at least a Bachelor’s Degree in electrical engineering, computer science, or computer engineering, or undergraduate training in an equivalent field and at least two years of relevant experience in electronic gaming technology.” Pet. 10 (citing Ex. 1003 ¶¶ 22–26). Petitioner further notes that “[a]dditional graduate education could substitute for professional experience, and significant work experience could substitute for formal education.” Id. Patent Owner does not dispute this level of skill. See Prelim. Resp. 13–14 (“Evolution does not set forth an alternative level of skill for a person of ordinary skill in the art”). For purposes of this Decision, we adopt Petitioner’s proposal, which comports with the teachings of the ’371 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (holding that the prior art itself can reflect the appropriate level of ordinary skill in the art).” slip op. at 11
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“Based on the evidence before us, we find persuasive Petitioner’s contention that Kido’s accumulated jackpot paid when landing on a star mark reads on the claimed “a first selected position . . . to have an increased payout . . . greater than a first non-selected payout.” See Pet. 25–27, 30, 35, 36. As explained above, the current record does not support limiting the term “payout” to just the amount a player will win in relation to the amount wagered. As Petitioner notes, a payout that receives Kido’s accumulated Prog bonus payout is necessarily higher than a payout that does not receive the Prog bonus. Pet. 35–36 (“had the first selected position not been randomly selected, the player would only be eligible for the basic payout”). Further, Kido even describes its bonus routines and jackpots as payouts. Kido describes, for example, that “[w]hen the privilege unit 113 obtains the win information from the special game value award mark win determining unit 112, it awards, as a payout, the game value stored in the accumulated game value memory 117” and it describes the “jackpot (JP) amount” as “a special payout.” Ex. 1007 ¶¶ 119, 129.” slip op. at 14
Claim construction§ 102 anticipation§ 103 obviousnesscites PhillipsPatents in suitUS 11,756,371 - PTAB · Dec 9, 2025 · IPR2025-00756 · APJ Thu A Dang · IPR · Institution
The Board instituted IPR on claims 1, 2, 5–8, 11, and 12 on three §103 grounds, finding a reasonable likelihood of unpatentability over the asserted combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“III. CONCLUSION Because we determine that Petitioner has demonstrated a reasonable likelihood that it would prevail in showing at least one of the challenged claims is unpatentable, we institute inter partes review as to all challenged claims and grounds presented in the Petition. At this stage of the proceeding, we have not made a final determination as to the patentability of any of these challenged claims. ORDER For the reasons given, it is ORDERED that pursuant to 35 U.S.C. § 314, an inter partes review is instituted as to claims 1, 2, 5–8, 11, and 12 of the ’803 patent to determine whether: 1) claims 1, 5–7, 11, and 12 are unpatentable under 35 U.S.C. § 103 as obvious over TS 36.300, TS 36.321, and TS 36.331; 2) claims 1, 2, 5–8, 11, and 12 are unpatentable under 35 U.S.C. § 103 as obvious over Ericsson and TS 25.331; and 3) claims 5, 6, 11, and 12 are unpatentable under 35 U.S.C. § 103 as obvious over Ericsson, TS 25.331, and Sebire; and” slip op. at 27
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“ordinary meaning, “primary” and “non-primary” cells are all cells that the WTRU is connected to (PO Resp. 16), the plain language in claim 1, and similarly in claim 7, does not require a “primary” node or “non-primary” cell to have a connection to the WTRU. See Ex. 1001, 10:38−56; 11:11–26. We find unavailing Patent Owner’s contention that the claims require that the WTRU “be connected to more than one cell,” wherein cells that are “associated with a wireless network node,” but are not connected to the WTRU “at the same time” cannot be “primary” or “non-primary” cells. PO Resp. 16. In the ’803 patent, nothing in the Specification clearly limits “primary” and “non-primary” cells as Patent Owner proposes. Prelim. Resp. 16. Patent Owner points to the Specification of the ’803 patent to show that, for softer handover, the WTRU is connected “with more than one cell [] which are controlled by the same Node-B,” and “[o]ne of the[se] cells 808 may be designated as a primary cell 808a, while other cells are designated as a non-primary cells 808b.” Id. (alterations in original) (citing Ex. 1001, 8:44–46, 9:4–6, Figs. 8A–B). However, this portion of the Specification (describing a softer handover embodiment in which a cell “may be designated” as a primary while other as non-primary) does not provide a clear definition to warrant interpreting the “primary” and “non-primary” cells as requiring “connection” to the WTRU “at the same time.” Id. That is, nothing in the Specification clearly precludes “primary” and “non-primary” cells from being “source” and “target” cell, as Patent Owner contends. PO Resp. 16. and the Specification, we determine that the terms “primary” and “non-primary” recited in claims 1 and 7 are not limited to cells connected to a WRTU at the same time. We determine no further explicit construction of this term is necessary to resolve the controversy. See Vivid Techs., 200 F.3d at 803.” slip op. at 8
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“f) Motivation to combine Ericsson and TS 25.331 Petitioner contends that a “POSITA would have been motivated to combine Ericsson and TS 25.331 because they are directed to similar technologies and a skilled artisan would have understood the benefits of combining these two references,” and “would have understood that there was a high likelihood of success in making the combination.” Pet. 34 (citing Ex. 1003 ¶¶ 156–157). In particular, the references “are both reasonably pertinent to the problem faced by the inventor, namely protocols for handover in a telecommunications system.” Id. (citing Ex. 1003 ¶ 158). According to Petitioner, the combination “involves the predictable use of interchangeable prior art elements according to their established functions” more than routine engineering.” Id. at 37 (citing Ex. 1003 ¶ 174). At this stage of the proceeding, Patent Owner does not present arguments in the Preliminary Response addressing the specific merits of Petitioner’s contentions with respect to the motivation to combine Ericsson and TS 25.331. See generally Prelim. Resp. 15–18. We find availing Petitioner’s contention that Ericsson and TS25.331 are “directed to similar technologies,” and that a “skilled artisan would have understood the benefits of combining these two references.” Pet. 34. On this preliminary record, we are persuaded that Petitioner has made a sufficient showing that a POSITA would have had a reason to combine the teachings of Ericsson and TS 25.331.” slip op. at 20
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner, relying on the testimony of Dr. Kakaes, contends that a person of ordinary skill in the art (POSITA) “would have had a B.S. in Electrical Engineering or a related field with at least three years of experience designing, developing, and/or testing telecommunication systems,” and “would also have familiarity with the wireless standards and well-known protocols for accessing wireless networks existing at the relevant time,” wherein “[m]ore education may supplement practical experience or vice versa.” Pet. 12–13. At this stage in the proceeding, Patent Owner does not contest Petitioner’s proposal or offer an alternative. On this record, we are persuaded that Petitioner’s proposal is consistent with the technology described in the Specification and the cited prior art. For purposes of this Decision, we adopt Petitioner’s proposed level of skill.” slip op. at 10
Claim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 10,764,803 - PTAB · Nov 6, 2025 · IPR2025-00820 · APJ Neil T Powell · IPR · Institution
The Board instituted IPR on claims 1–11 on all petition grounds, finding a reasonable likelihood that claim 1 would have been obvious over Tadros, Porter, Kalili, and Texin 990R.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). To institute an inter partes review, we must determine that the information presented in the Petition and the Preliminary Response shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that there is a reasonable likelihood that Petitioner will prevail with respect to at least one challenged claim. We institute an inter partes review of claims 1–11 based on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Pet. 17–18 (citing Ex. 1007 ¶¶ 13–15). Patent Owner does not dispute Petitioner’s explanation of the level of skill in the art. See generally Prelim. Resp. At this stage of the proceeding and on the present record, we adopt Petitioner’s uncontested proposed level of ordinary skill in the art, which we find consistent with the level of ordinary skill in the art reflected by the ’090 patent and the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Additionally, only terms that are in controversy need to be construed, and these need be construed only to the extent necessary to resolve the controversy. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Both parties indicate that no claim terms need to be expressly construed. Pet. 29–30; Prelim. Resp. 5. Consistent with that, we determine that we need not construe any claim terms expressly in order to resolve the parties’ dispute regarding whether Petitioner has demonstrated a reasonable likelihood of prevailing.” slip op. at 8
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“Weighing the parties’ arguments and evidence, we find Petitioner’s arguments and evidence sufficient at this stage to demonstrate a reasonable likelihood of prevailing. Pet. 8–17, 30–49. For example, regarding whether of Porter’s disclosure to the problem faced by inventor of the ’090 patent. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 144–164. The ’090 patent illustrates that its inventor faced the problem of selecting desirable materials for an aligner, including selecting a desirable material for an aligner’s hard layer. Ex. 1001, 5:44–59. Petitioner and Dr. Osswald provide significant evidence and reasoning tending to show that Porter’s discussion of Tritan logically would have commended itself to the attention of an inventor facing the problem of selecting an aligner hard layer. Pet. 8 (citing Ex. 1007 ¶¶ 98–108, 125–127, 144–164). For example, Dr. Osswald explains that “because Tritan copolyesters are BPA-free, Rafih specifically discloses Tritan EX401 as an exemplary material” for its oral appliance. Id. ¶ 99 (citing Ex. 1104, 5:4–64, claims 2, 9, 10). In view of this, Dr. Osswald testifies that “Rafih would inform a [person of ordinary skill in the art] that Porter’s guidance regarding replacing polycarbonate with Tritan applies to dental appliances.” Ex. 1007 ¶ 146. At this stage, weighing Petitioner’s evidence against Patent Owner’s contrary attorney argument that Porter focuses on dishware, we determine Petitioner has shown sufficiently that Porter is analogous art. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 144–164; Prelim. Resp. 1, 9–10, 18–21.” slip op. at 11
Claim construction§ 103 obviousnesscites PhillipsPatents in suitUS 11,648,090 - PTAB · Nov 6, 2025 · IPR2025-00819 · APJ Kristina M Kalan · IPR · Institution
The Board instituted IPR on all challenged claims based on both obviousness grounds, finding a reasonable likelihood of success on at least one claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“that Petitioner has demonstrated a reasonable likelihood of showing that a person of ordinary skill in the art would have been motivated to combine the teachings of Tadros, Kalili, and Texin 990R to meet the limitations of the claims challenged under this ground.” slip op. at 14
- Skill levelSkill level petitioner adoptedDecided for petitioner
“would have had at least a four-year undergraduate degree in materials science, mechanical engineering, chemical engineering, or a related field and at least two years of experience in the field of polymer science, combined with at least two years of experience in the field of design, manufacture, and processing of thermoformable polymer sheets for use in various applications, such as in orthodontic and dental appliances. Additional education could substitute for professional experience and vice versa. Pet. 18–19 (citing Ex. 1007 ¶¶ 13–15). At this stage, Patent Owner does not dispute Petitioner’s proposal or offer an alternative proposal. See generally Prelim. Resp. Because Petitioner’s proposed level of ordinary skill in the art appears to be consistent with the cited prior art and is undisputed on this record, we adopt it for purposes of this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (indicating that the prior art itself may reflect an appropriate skill level).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Only claim terms in controversy need be construed. Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”). For purposes of this Decision, we determine that no claim term requires express construction.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“that Petitioner has demonstrated a reasonable likelihood of showing that a person of ordinary skill in the art would have been motivated to combine the teachings of Tadros, Kalili, and Texin 990R to meet the limitations of the claims challenged under this ground. We disagree that Petitioner fails to meet its burden as to the motivation to combine arguments. Petitioner persuasively maps the limitations of the challenged claims to portions of the references relied upon. Pet. 28–38 (claim 1), 38–51. Petitioner also, on this record, provides adequate statements of motivation to combine with a reasonable expectation of success. See, e.g., id. at 34–36 (citing Ex. 1007 ¶¶ 31, 39–42, 147–151, 174–176). The Petition’s reliance on supporting testimony and related corroborating evidence to support the combination does not amount to impermissible hindsight, as that testimony takes into account “knowledge which was within the level of ordinary skill in the art at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure.” In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971). Without further clarification or support from Patent Owner, and in the absence of testimony to support the assertion that a POSITA would not have combined the cited references in the manner proposed with a reasonable expectation of success, we are unpersuaded by Patent Owner’s arguments in this regard.” slip op. at 14
Claim construction§ 103 obviousnesscites KSRPatents in suitUS 11,154,384 - PTAB · Nov 6, 2025 · IPR2025-00818 · APJ Kristina M Kalan · IPR · Institution
The Board instituted IPR on all challenged claims 1–22 based on all three asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority under 35 U.S.C. § 314(a), which provides that inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” After considering the briefing and cited evidence of record, we institute inter partes review because we find that Petitioner establishes a reasonable likelihood that it will prevail with respect to at least one of the claims challenged in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“understanding of a person of ordinary skill in the art at the time the invention was made. See Graham, 383 U.S. at 17–18. Petitioner proposes that a person of ordinary skill in the art (sometimes referred to herein as a “POSITA”) would have had at least a four-year undergraduate degree in materials science, mechanical engineering, chemical engineering, or a related field and at least two years of experience in the field of polymer science, combined with at least two years of experience in the field of design, manufacture, and processing of thermoformable polymer sheets for use in various applications, such as in orthodontic and dental appliances. Additional education could substitute for professional experience and vice versa. Pet. 18 (citing Ex. 1007 ¶¶ 13–15). At this stage, Patent Owner does not dispute Petitioner’s proposal or offer an alternative proposal. See generally Prelim. Resp. Because Petitioner’s proposed level of ordinary skill in the art appears to be consistent with the cited prior art and is undisputed on this record, we adopt it for purposes of this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (indicating that the prior art itself may reflect an appropriate skill level).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner argues that no terms require construction, but that “Petitioner applies the prior art consistent with Patent Owner’s assertions in its Infringement Contentions (EX1014, 6-20.).” Pet. 26. Patent Owner does not propose any express claim constructions. Prelim. Resp. 5. Nor does Patent Owner allege that any of Petitioner’s claim interpretations contradict Petitioner’s position in the related district court litigation. Id. Only claim terms in controversy need be construed. Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”). For purposes of this Decision, we determine that no claim term requires express construction.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“that Petitioner has demonstrated a reasonable likelihood of showing that a person of ordinary skill in the art would have been motivated to combine the teachings of Tadros, Kalili, and Texin 990R to meet the limitations of the claims challenged under this ground. We disagree that Petitioner fails to meet its burden as to the motivation to combine arguments. Petitioner persuasively maps the limitations of the challenged claims to portions of the references relied upon. Pet. 27–36 (claim 1), 36–46. Petitioner also, on this record, provides adequate statements of motivation to combine with a reasonable expectation of success. See, e.g., id. at 32–35 (citing Ex. 1007 ¶¶ 31, 39–41, 57–87, 146–150, 171–172). The Petition’s reliance on supporting testimony and related corroborating evidence to support the combination does not amount to impermissible hindsight, as that testimony takes into account “knowledge which was within the level of ordinary skill in the art at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure.” In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971). Without further clarification or support from Patent Owner, and in the absence of testimony to support the assertion that a POSITA would not have combined the cited references in the manner proposed with a reasonable expectation of success, we are unpersuaded by Patent Owner’s arguments in this regard. We also disagree with Patent Owner’s arguments about “adhesive lamination” using “tie layers” at this point in the proceeding. Prelim. Resp. 15–18. On this record, we are persuaded that Petitioner has adequately supported its arguments that one of ordinary skill in the art would have been motivated to use adhesive lamination to achieve the proposed combination. See, e.g., Pet. 33–35; Ex. 1007 ¶¶ 39–42, 120, 45, 51, 116, 120. Petitioner relies on Kalili as disclosing a hard layer suitable for combination with Tadros’s soft layers (Pet. 32), and more particularly, doing so in the context of a laminated multilayer aligner (Reply 4). To create the laminated multilayer aligner proposed, Petitioner’s suggested use of a particular type of well-known lamination, i.e. adhesive lamination, is sufficiently developed and supported in the Petition. Pet. 32–35. Here, Patent Owner recognizes that Kalili teaches lamination, but suggests that it does not specifically teach using adhesive lamination. Prelim. Sur-reply 5. We note, however, that the parties have identified limited types of known lamination for aligners: coextrusion, extrusion lamination, and adhesive lamination. Prelim Sur-reply 4; Pet. 14–15 n.3, 33. In KSR, the Supreme Court explained that when “there is a design need or market pressure to solve a problem and there are a finite number of identified, predictable solutions, a person of ordinary skill has good reason to pursue the known options within his or her technical grasp.” KSR, 550 U.S. at 421. “If this leads to the anticipated success, it is likely the product not of innovation but of ordinary skill and common sense.” Id. Having reviewed Petitioner’s proffered arguments as to Tadros, Kalili, and Texin 990R, including motivation to combine the references asserted in this ground, with a reasonable expectation of success, we are persuaded on this record that Petitioner has met its burden for institution with respect to Ground 1.” slip op. at 14
Claim construction§ 103 obviousnesscites KSRPatents in suitUS 10,973,613 - PTAB · Oct 15, 2025 · IPR2025-00762 · APJ Scott B Howard · IPR · Institution
The Board instituted IPR on claims 1–5 and 8–12 on all asserted grounds, finding a reasonable likelihood that claim 1 would have been obvious over Koskinen.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“determine whether to institute an inter partes review. 35 U.S.C. § 314 (2024); 37 C.F.R. § 42.4(a) (2024). Inter partes review may not be instituted unless “the information presented in the petition filed under [35 U.S.C.] section 311 and any response filed under [35 U.S.C.] section 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). “When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” 37 C.F.R. § 42.108(a). For the reasons set forth below, upon considering the briefing and the evidence of record, we determine that the information presented in the Petition establishes a reasonable likelihood that Petitioner will prevail with respect to at least one of the challenged claims. Accordingly, we institute inter partes review on all of the challenged claims based on all of the grounds identified in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner argues that a person having ordinary skill in the art “would have had a bachelor’s degree in electrical engineering, computer engineering, computer science, or a related field and at least two years of practical experience with design or development of telecommunication and/or wireless communications systems, or the equivalent.” Pet. 7 (citing Ex. 1003 ¶¶ 19–21). Petitioner further argues that “[a]dditional education” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“For the purposes of this Decision, we need not expressly construe any claim terms.6 See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (noting that “we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“Additionally, a person having ordinary skill in the art would have known and been familiar with information elements (IEs) that specified an RLC reordering timer value based on (1) general knowledge that IEs carried information in RRC messages and (2) that 3GPP TSs describe an IE carrying recording timer duration information for the RLC layer. See Ex. 1003 ¶ 151; Ex. 1014, 219–20. Accordingly, it would have been obvious to a person having ordinary skill in the art “that the PDCP timer information, which used similar variables as its RLC counterpart (Koskinen, ¶¶37-38), would also be carried in a PDCP configuration IE.” Ex. 1003 ¶ 151.” slip op. at 13
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,863,573 - PTAB · Oct 6, 2025 · IPR2025-00611 · APJ Christopher L Ogden · IPR · Institution
The Board instituted IPR of claims 1–10, 12, 13, 19, and 20 on all petition grounds after finding a reasonable likelihood that claim 1 was obvious over Douglas and Mark.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“A claim is unpatentable under § 103 “if the differences between the claimed invention and the prior art are such that the claimed invention as a whole would have been obvious before the effective filing date of the claimed invention to a person having ordinary skill in the art to which the claimed invention pertains.” 35 U.S.C. § 103; see KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 406 (2007). When a ground in a petition is based on a combination of references, we consider “whether there was an apparent reason to combine the known elements in the fashion claimed by the patent at issue.” KSR, 550 U.S. at 418 (citing In re Kahn, 441 F.3d 977, 988 (Fed. Cir. 2006)).” slip op. at 8
- Skill levelSkill level petitioner adoptedDecided for petitioner
“The parties agree that experience could substitute for a degree, and vice versa. Pet. 3 (citing Ex. 1003 ¶¶ 19–21); Prelim. Resp. 9. The parties’ proposed levels of ordinary skill are substantially similar. Although we discern no difference in the outcome of this decision from choosing one over the other, we adopt Petitioner’s proposal for this decision. Only Petitioner’s proposed level is supported by testimonial evidence on the preliminary record, and it appears to be consistent with the problems addressed in the ’774 patent. See Ex. 1001, 1:16–52. Therefore, we adopt Petitioner’s proposal for this decision.” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“CLAIM CONSTRUCTION B. In an IPR, we construe a patent claim “using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. 282(b).” 37 C.F.R. § 42.100(b). This generally includes “construing the claim in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” Id. The ordinary and customary meaning of a claim term “is its meaning to the ordinary artisan after reading the entire patent,” and “as of the effective filing date of the patent application.” Phillips, 415 F.3d at 1313, 1321. Neither Petitioner nor Patent Owner argues that we need to construe any claim terms explicitly. See Pet. 2–3; Prelim. Resp. 9. However, the parties’ positions depend on interpreting the claim language in a particular way, and we discuss the relevant claim language below in the context of the parties’ arguments regarding the prior art. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“At this stage, we find Petitioner’s arguments persuasive and disagree with Patent Owner. Patent Owner appears to equate a “fabrication profile” with a toolpath description, but nothing in the plain language of claim 1 supports that narrow interpretation. The ’774 patent describes a “fabrication profile” broadly and states that the profile can simply “include the dictionary [of configuration information],” or be “used to determine which machineready representation is available or suitable for a target printer.” Ex. 1001, 23:49–52. The preliminary evidence suggests that Douglas’s “operational parameters” would count as a “fabrication profile” because it is “the basis for generation of a machine-ready representation of the three-dimensional model that is executable on the target printer.” Id. at 23:37–39; see infra Section III.C.8. We also disagree that Petitioner’s argument is impermissible hindsight, because it is based on the disclosures in Douglas and Mark, and Petitioner has articulated a sufficiently persuasive reason to combine those references without referring to the ’774 patent itself. See In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971) (an obvious rationale is not improper hindsight if it “takes into account only knowledge which was within the level of ordinary skill at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure”). Finally, Petitioner appears to rely on Mark for providing a particular example of a fabrication profile, not to replace Douglas’s overall system in which the 3D printer can receive “operational parameters” rather than just G-code. See Pet. 8–10, 17–23; see also Ex. 1005 ¶ 41 (the print queue, which stores tool instructions, may be maintained locally on printers 204 or on print servers 208); see In re Mouttet, 686 F.3d 1322, 1332 (Fed. Cir. 2012) (“[A] determination of obviousness based on teachings from multiple references does not require an actual, physical substitution of elements.” (citing In re Etter, 756 F.2d 852, 859 (Fed. Cir. 1985) (en banc))).” slip op. at 19
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,886,774
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.