• Lenovo (United States) Inc. / Motorola Mobility LLC v. Theta IP, LLCNo claims unpatentable
  PTAB · Oct 16, 2024 · IPR2023-00697 · APJ Barbara A Benoit · IPR · Final written decision

  Claims 1, 3, 4, and 8 were not proven unpatentable: Rauhala does not disclose the required simultaneous signal-strength determinations, and Masaaki does not cure the deficiency for claim 4.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Following institution, Patent Owner maintained the same level of ordinary skill proposed in its preliminary response and did not address our discussion of the level of ordinary skill in the art in the Institution Decision. PO Resp. 24–25; see also Prelim. Resp. 24. For the reasons discussed in the Institution Decision, we adopt and apply for this Decision the level of ordinary skill articulated by Petitioner and used previously in our Institution Decision. See Dec. 8–10. In light of our review of the complete record, we find that this formulation is consistent with the ’825 patent, the prior art of record, and is supported by the testimony of Dr. Baker. See Ex. 1002 ¶¶ 27– 31. Our decision would not change, however, if we had applied Patent Owner’s proposed level of ordinary skill.” slip op. at 12

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner

    “We agree with Patent Owner that the desired signal and interferer signal must be received at the same time. The plain language of the claim requires the wireless transceiver to “receiv[e] a wireless signal having a desired signal and an interferer signal,” the determining of a signal strength of the interferer signal and the determining of a signal strength of the desired signal must be performed at the same time; otherwise, the determinations of signal strengths would not be of the same wireless signal. The specification supports this understanding. “When a receiver is actively receiving a desired signal, each block in the signal path has at its input the desired signal as well as noise and possibly interfering signals.” Ex. 1001, 5:20–22; see also id. at 5:31–33 (“FIGS. 2A and 2B illustrate examples of desired signals, interferers, and noise that may be received by one of the various circuits in a” slip op. at 21

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable

    “We agree with Patent Owner that Rauhala does not state that the signal strengths are measured simultaneously or at the same time. Indeed, as discussed above, Rauhala indicates unequivocally in the same paragraph the opposite—that detector DET provides to control unit 42 “an indication about either the receive channel signal strength RSS or the strength of any signal on the reception band.” Ex. 1004 ¶ 17. Rauhala describes that “control unit 42 provides two one-bit control signals cA and cM” based on indications received from detector DET. Id. Importantly, Rauhala indicates that “at the same time as” describes how the control unit 42 uses the received inputs RSS and RSSn shown in Figure 4, which are described earlier in paragraph 17 as indications of either RSS or RSSn from detector DET. Id. (“Signal cA is 0 when signal RSS is greater than S4 and signal RSSn is at the 11 Dr. Baker’s reply declaration correctly quotes Rauhala paragraph 17 but cites to paragraph 18. We deem this harmless error. same time smaller than Sn. . . . Signal cM is 1 when signal RSS is not greater than S4 and signal RSSn is at the same time at least Sn. Otherwise, signal cM is 0.”). The burden remains on Petitioner to demonstrate by a preponderance of the evidence that Rauhala discloses the disputed limitations as arranged or combined in the claim. Petitioner does not persuasively reconcile these “either/or” statements regarding the functioning of detector DET with the “at the same time as” statements regarding control signals output by control unit 42 in paragraph 17. We do not find persuasive Petitioner counsel’s position expressed at the hearing that Rauhala’s “either/or” statements are “simply an imprecise description” (Tr. 16:22–24). We do not see a lack of precision in Rauhala’s “either/or” statements.” slip op. at 30

  • Expert testimonyPetitioner expert discountedPatent owner expert creditedDecided for patent owner

    “When asked at his deposition to explain Rauhala’s use of the word “or” regarding the functioning of detector DET, Dr. Baker asserted that “[detectors] can be designed to determine RSS or RSSn.” Ex. 2016, 85:5– 12. We find Dr. Baker’s testimony that “it’s reasonable that if you can design . . . the detector to detect one or the other, you can also design it to detect both” to be without factual support. Id. at 85:13–16. He points to no textbook or other independent evidence to support that would have led one of ordinary skill to design such a detector or to support that one of ordinary skill would have understood Rauhala’s detector to be so designed. Furthermore, Dr. Baker recognizes that “Rauhala doesn’t teach the details of what’s in the detector.” Id. at 91:6–7. We give little weight to Dr. Baker’s unsupported testimony that one could design a detector to detect both RSS and RSSn from the same wireless signal. See 37 C.F.R. 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); see also Xerox Corp. v. Bytemark, Inc., No. IPR2022-00624, 2022 WL 3648989, at *6 (PTAB 2022) (precedential) (Director affirming because “the cited declaration testimony is conclusory and unsupported, adds little to the conclusory assertion for which it is offered to support, and is entitled to little weight”).” slip op. at 31

  Patent outcomesUS 10,129,825 not shown unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 10,129,825
• Lenovo (United States) Inc. / Motorola Mobility LLC v. Theta IP, LLCNo claims unpatentable
  PTAB · Oct 16, 2024 · IPR2023-00698 · APJ Thomas L Giannetti · IPR · Final written decision

  Claims 7–11, 13, and 19–21 were not shown unpatentable because Rauhala does not disclose simultaneous desired and interferer signal-strength determinations, defeating anticipation and the obviousness combination.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “The two proposals are materially similar in the education requirement, but differ marginally in professional experience required (three versus five years). See supra. While we were persuaded, on the preliminary record, that both Petitioner’s and Patent Owner’s proposals were consistent with the problems and solutions in the ’202 patent and the prior art of record, on balance, we determined that Petitioner’s proposal was a better reflection of the level of skill in the prior art, and we therefore adopted it for our Institution Decision. See Institution Dec. 12–13. For this Decision, we adopt the description of the person of ordinary skill articulated by Petitioner and used previously in our Institution Decision. In light of our review of the complete record, we find that this formulation is consistent with the ’202 patent, the prior art of record, and is supported by the testimony of Dr. Baker. See Baker I Decl. ¶¶ 28–32. Our Decision would not change, however, if we had applied Patent Owner’s proposed level of ordinary skill.” slip op. at 12

  • Expert testimonyPetitioner expert discountedDecided for patent owner

    “85:13–16. He admits that “Rauhala doesn’t teach the details of what’s in the detector.” Id. at 91:6–7. He points to no textbook or other independent evidence that would have led a person of ordinary skill to design such a detector. Our Trial Practice Guide cautions against crediting such unsupported testimony: The Board has broad discretion to assign weight to be accorded expert testimony. Yorkey v. Diab, 601 F.3d 1279, 1284 (Fed. Cir. 2010). However, the testimony must be based on sufficient facts and data. Fed. R. Evid. 702(b). “Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.” 37 C.F.R. § 42.65(a). Patent Trial and Appeal Board Consolidated Trial Practice Guide 35 (Nov. 2019).7 We therefore give Dr, Baker’s unsupported testimony on this issue little weight.” slip op. at 24

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “We construe claim terms only as relevant to the parties’ contentions and only to the extent necessary to resolve the issues in dispute. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999); Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co. Matal, 868 F.3d 1013, 1017 (Fed. Cir. 2017). Having considered the positions of the parties, we find that for the purpose of this decision, we do not need to construe these terms to resolve a dispute.” slip op. at 9

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable

    “requirement.” Pet. Reply 5. We do not agree with Petitioner. We find that the language of the claims supports Patent Owner’s argument that the desired signal and the interferer signal are received together. As discussed infra, claim limitations 7.7 and 7.8 recite determining a signal strength of the interferer signal and determining a signal strength of the desired signal. These determinations must be performed at the same time; otherwise, the determinations of signal strengths would not be of the same wireless signal. See Larson II Decl. ¶ 70; Baker II Decl. ¶¶ 48–49 (explaining that consideration of signal strengths detected at the same time would be “essential”). The specification of the ’202 patent further supports this finding: “When a receiver is actively receiving a desired signal, each block in the signal path has at its input the desired signal as well as noise and possibly interfering signals.” Ex. 1001, 5:22–24; see also Figs. 2A, 2B (showing interferer signals and desired signals together).” slip op. at 17

  Patent outcomesUS 10,524,202 not shown unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Graham
  Patents in suitUS 10,524,202
• Intuit Inc. v. Samesurf, Inc.No claims unpatentable
  PTAB · Jun 25, 2024 · IPR2023-00341 · APJ Barbara A Benoit · IPR · Final written decision

  Claims 1–16 were not shown unpatentable over Lebrun and Wang or over Prajapat and Wang because the combinations did not teach key invitation and webpage retrieval limitations.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for patent owner

    “of the parties, we found that a person of ordinary skill in the art (“POSITA”) “would have had (1) at least a bachelor’s degree in computer science, 7 Patent Owner has not offered objective evidence of non-obviousness. See generally PO Resp.; PO Sur-reply; see also Pet. 21 (indicating Petitioner is not aware of any evidence of secondary considerations). least two years of work experience in software development and/or web-based software,” which reflected Petitioner’s proposal. Dec. 12; see Dec. 10–12 (discussing the respective proposals and level of ordinary skill reflected in the challenged patent and asserted prior art). Patent Owner accepts this level of ordinary skill in the art. PO Resp. 37. Accordingly, we apply this determination of the level of ordinary skill in the art for purposes of this Decision.” slip op. at 12

  • Expert testimonyPetitioner expert discountedPatent owner expert creditedDecided for patent owner

    “Petitioner’s citations in this regard to Dr. Lieberman’s declaration do not adequately support Petitioner’s “forwarding” contention. Pet. Reply 8 (citing Ex. 1003 ¶¶ 37, 149); Ex. 1003 ¶ 37 (indicating the challenged patent describes the invitation as being sent by email, instant message, or social network communication); Ex. 1003 ¶ 149 (describing the group-surfing server receiving the session-creation message, creating the group-surfing session, and “inform[ing] the participants in the group-surfing session”). Petitioner does not identify any testimony from Dr. Lieberman that supports Petitioner’s Reply position that Lebrun’s group-surfing server “forwards” the session-creation message to the group-surfing session participants, nor are we aware of any such testimony. See, e.g., Ex. 1003 ¶ 149 (The group-surfing server “responds to the group session request ‘by (1) creating a group-surfing session, and (2) informing the participants [web clients] in the group-surfing session.”); see generally Ex. 1034. Petitioner cannot satisfy its burden of proving obviousness by employing “mere conclusory statements.” In re Magnum Oil Tools Int’l, Ltd., 829 F.3d 1364, 1380 (Fed. Cir. 2016).” slip op. at 29

  • Strike new argumentNew argument disregardedGranted in part

    “surfing server as forwarding the session-creation message to the invited web client. PO Sur-reply 12. Although Lebrun describes the group-surfing server as “informing the participants in the group-surfing server session” after receiving the session-creation message and creating the group-surfing session, Lebrun does not describe forwarding or otherwise sending the session-creation message to the participants. Ex. 1005, 32:26–28, 44:12–14. Petitioner’s citations in this regard to Dr. Lieberman’s declaration do not adequately support Petitioner’s “forwarding” contention. Pet. Reply 8 (citing Ex. 1003 ¶¶ 37, 149); Ex. 1003 ¶ 37 (indicating the challenged patent describes the invitation as being sent by email, instant message, or social network communication); Ex. 1003 ¶ 149 (describing the group-surfing server receiving the session-creation message, creating the group-surfing session, and “inform[ing] the participants in the group-surfing session”). Petitioner does not identify any testimony from Dr. Lieberman that supports Petitioner’s Reply position that Lebrun’s group-surfing server “forwards” the session-creation message to the group-surfing session participants, nor are we aware of any such testimony. See, e.g., Ex. 1003 ¶ 149 (The group-surfing server “responds to the group session request ‘by (1) creating a group-surfing session, and (2) informing the participants [web clients] in the group-surfing session.”); see generally Ex. 1034. Petitioner cannot satisfy its burden of proving obviousness by employing “mere conclusory statements.” In re Magnum Oil Tools Int’l, Ltd., 829 F.3d 1364, 1380 (Fed. Cir. 2016).” slip op. at 29

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable

    “receive webpage content from the website server in particular ways as identified in limitations [1e] and [1g]. Similarly, claim 1 requires the invitee device to retrieve data from the website server in response to receiving “the information related to the shared web browsing interaction from the synchronization server” (limitation [1f.iii]). For the reasons discussed above, Petitioner has not shown by a preponderance of the evidence its combination of Lebrun and Wang does so. For the required website server interaction, in its Petition, Petitioner relies on Lebrun’s description of an alternative embodiment applicable only when no cookies or other identity information are involved (Ex. 1005, 35:17–19). See, e.g., Pet. 30 (citing Ex. 1005, 35:17–19). As Patent Owner indicates, this alternative is not relevant to the subject matter recited in claim 1 which requires identity information. PO Resp. 45. Petitioner does not address this shortcoming in its Reply. See generally Pet. Reply. Rather, in its Reply, for website server interaction, Petitioner relies on Lebrun’s functionality of sending a web page from the web server to the web client as shown in Lebrun’s Figure 1. See, e.g., Pet. Reply 11 (citing Ex. 1005, 32:21–24, 31:27–30, Fig. 1). Specifically, Petitioner contends that Lebrun discloses that (i) a URL for the initial web page is included in session-creation message 151 (Ex. 1005, 32:21–24), (ii) the web site sends a web page directly to the web client (Fig. 1), and (iii) the web site delivers information 132 to web clients or the group-surfing server 140 “in response Pet. Reply 11. Although this shows the web site sending a web page directly to a web client, the prior art of Lebrun does not do so in the manner required by the claims (limitations [1e], [1f.i], [1f.iii], [1g]).” slip op. at 46

  Patent outcomesUS 9,483,448 not shown unpatentable
  § 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 9,483,448
• Precision Planting LLC / Agco Corporation v. Deere & CompanyNo claims unpatentable
  PTAB · Dec 2, 2020 · IPR2019-01048 · APJ Barry L Grossman · IPR · Final written decision

  Claims 1–20 were not proven unpatentable over Hedderwick and Koning because Petitioner did not establish a persuasive motivation to combine the references as proposed.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “Based on the prior art, Dr. Glancey’s opinion testimony and analysis, and providing some, but minimal, weight to Dr. Taylor’s opinion testimony, we determine that the evidence favors Patent Owner’s proposed level of skill, primarily based on Dr. Glancey’s analysis and reasons summarized above. Accordingly, we determine that a person of ordinary skill in a technology pertinent to the challenged claims would have had an undergraduate degree in mechanical engineering, agricultural engineering, or similar field, and two years of experience designing agricultural products or related machinery, or five years of experience designing agricultural products or related machinery, without a four-year undergraduate engineering degree. A recipient of other academic degrees may qualify as a person of ordinary skill if they have taken coursework or have experience in the pertinent technology. Additional education could offset less work experience; additional work experience could offset less education or coursework.” slip op. at 18

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co. Ltd., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). We determine that an explicit construction of the claims is not necessary for the purposes of determining whether the challenged claims are not patentable. slip op. at 20

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundReasonable expectation not foundNot shown unpatentable

    “sufficiently persuasive evidence, even in combination, to establish why a person of ordinary skill would have modified Hedderwick by (1) selectively gleaning only a portion of Koning’s conveying system, i.e., belt 44 with bristles 45, (2) selectively excluding Koning’s belt 23, and then (3) modifying Koning’s brush belt by reversing its orientation so that it carries seeds deposited into the bristles, as in the ’906 patent, rather than covering and guiding seeds carried by a separate and distinct conveyor belt, as in Koning. See WBIP, LLC v. Kohler Co., 829 F.3d 1317, 1327 (Fed. Cir. 2016) (finding an absence of a motivation to reverse parts to an orientation that was “totally backwards” from what one of skill in the art would even attempt). Petitioner’s arguments do not acknowledge the different function of Koning’s brush belt, or explain why a person of ordinary skill would have been motivated to adapt Koning’s brush belt to such a use and reasonably expect success in doing so. We determine Petitioner fails to meet its burden of providing a sufficiently persuasive explanation or reason for concluding that one of skill in the art would have combined these particular references to produce the claimed invention. “Without any explanation as to how or why the references would be combined to arrive at the claimed invention, we are left with only hindsight bias.” Metalcraft v. Toro, 848 F.3d at 1367. “[W]e cannot allow hindsight bias to be the thread that stitches together prior art patches into something that is the claimed invention.” Id.” slip op. at 30

  • ExcludeOther

    “II. MOTION TO EXCLUDE Petitioner and Patent Owner each move to exclude a substantial number of exhibits on a number of different evidentiary grounds. See Pet. Mot. Excl.; PO Mot. Exclude. As our analysis does not refer to any of those exhibits, we dismiss each motion as moot.” slip op. at 12

  Patent outcomesUS 9,686,906 not shown unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 9,686,906
• Precision Planting, LLC / Agco Corp. v. Deere & CompanyNo claims unpatentable
  PTAB · Nov 30, 2020 · IPR2019-01044 · APJ Timothy J Goodson · IPR · Final written decision

  Claims 1–8 were not shown unpatentable under § 103 over Hedderwick, Koning, and Benac because Petitioner did not establish motivation to combine or a reasonable expectation of success.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedPetitioner expert discountedDecided for patent owner

    “have had either (1) a bachelor’s degree plus four years of experience in mechanical engineering, agricultural engineering, or a related field or (2) a master’s degree plus two years of experience in mechanical engineering, agricultural engineering, or a related field.” Pet. 42 (citing Ex. 1002 ¶¶ 19– 20). In the testimony the Petition cites in support of that proposal, Mr. Prairie lists factors that are typically considered in assessing the level of ordinary skill in the art, and then states “[b]ased on these factors together with my experience and expertise,” his opinion of the level of ordinary skill in the art is the same as Petitioner proposes. Ex. 1002 ¶¶ 19–20. This conclusory testimony is entitled to little weight. See 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”).” slip op. at 12

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “construed using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. 282(b).” See Changes to the Claim Construction Standard for Interpreting Claims in Trial Proceedings Before the Patent Trial and Appeal Board, 83 Fed. Reg. 51,340, 51,358 (Oct. 11, 2018) (amending 37 C.F.R. § 42.100(b) effective November 13, 2018) (now codified at 37 C.F.R. § 42.100(b) (2019)).6 That standard “includ[es] construing the claim in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” Id.; see also Phillips v. AWH Corp., 415 F.3d 1303 (Fed. Cir. 2005) (en banc). We determine that no terms require express construction to resolve the parties’ dispute. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (claim terms need only be construed “to the extent necessary to resolve the controversy”); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (applying Vivid Techs. in the context of an inter partes review). V. OBVIOUSNESS OVER HEDDERWICK, KONING, AND BENAC” slip op. at 14

  • Expert testimonyPetitioner expert discountedPatent owner expert creditedDecided for patent owner

    “Patent Owner’s expert, Dr. Glancey, explains that [i]f a wheel is used to load and place seeds within a moving belt with brush hairs, the wheel must be able to disengage from seeds while the seeds remain in between brush hairs. If the wheel maintains contact with the seed after the seed has moved into the brush hairs, the wheel will continue to apply force to the seed and eject or remove the seed from the profile of the brush hairs . . . . Ex. 2200 ¶ 223. Dr. Glancey testifies, credibly, that in Petitioner’s combination, seeds would have been rejected from the belt because, as the paddle wheel rotates, seeds “would be scooped through the belt.” Id. ¶ 225.” slip op. at 31

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundReasonable expectation not foundNot shown unpatentable

    “way the references use endless members in the form of brush belts and paddle wheels, versus the way Petitioner uses those components in the proposed combination. Contrary to Petitioner’s and Mr. Prairie’s assertions, the proposed combination does not merely apply known techniques to a known device, because none of the cited references use brush belts and paddle wheels in the manner Petitioner proposes. As discussed in greater detail below, Benac teaches that a paddle wheel can be used to ensure that seeds jammed in vacuum holes are released reliably, and then dropped to the ground. Benac does not address brush belts as an endless member and, therefore, does not teach that paddle wheels can be used to guide seeds into the bristles of a brush belt, as Petitioner proposes. See Pet. 64. And Koning does not teach a brush belt that captures seeds released from above, as Petitioner and Mr. Prairie propose. See Pet. 61–62; Ex. 1002 ¶ 104; Ex. 2193, 190:10–191:3; Ex. 2263, 167:21–170:9. Rather, Koning’s brush belt maintains the relative position of potatoes lying on a conveying surface by holding them from above while the conveyor moves them to the furrow. Ex. 1004, 3:16–24, 5:3–14, Fig. 4. Petitioner’s arguments do not adequately account for these differences between the references’ use of a brush belt as an endless member and paddle wheels versus the proposed combination. Moreover, Patent Owner points out problems ordinarily skilled artisans would have encountered in attempting to combine the references as Petitioner proposes. Petitioner does not persuasively explain how those issues could have been overcome, and instead simply asserts, essentially, that ordinarily skilled artisans could have figured it out. See, e.g., Ex. 1135 ¶ 80. It is Petitioner’s burden to establish that ordinarily skilled artisans would have been motivated to combine the success in doing so. See 35 U.S.C. § 316(e); In re Magnum Oil Tools Int’l, Ltd., 829 F.3d 1364, 1376 (Fed. Cir. 2016). Petitioner’s arguments and evidence do not carry that burden.” slip op. at 28

  Patent outcomesUS 8,813,663 not shown unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,813,663
• Precision Planting, LLC / Agco Corp. v. Deere & CompanyNo claims unpatentable
  PTAB · Nov 30, 2020 · IPR2019-01046 · APJ Timothy J Goodson · IPR · Final written decision

  Claims 1 and 3 were not shown unpatentable over Hedderwick, Koning, and Yamahata under § 103 because Petitioner did not establish motivation to combine or a reasonable expectation of success.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “Based on the evidence and arguments of record, we determine that the evidence favors Patent Owner’s proposed level of skill. Our determination is primarily based on Dr. Glancey’s analysis and reasons summarized above, as well as the prior art of record and the sophistication of the technology of the ’199 patent. We have considered Mr. Prairie’s opinion, but we give that testimony minimal weight due to the lack of supporting explanation. Accordingly, we adopt Patent Owner’s proposed level of ordinary skill in the art. Specifically, we determine that a person of ordinary skill in agricultural engineering, or a similar field, and two years of experience designing agricultural products or related machinery. Alternatively, a person of ordinary skill in the art would have had five years of experience designing agricultural products or related machinery, without a four-year undergraduate engineering degree.” slip op. at 13

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “IV. CLAIM CONSTRUCTION “In an inter partes review proceeding, a claim of a patent . . . shall be construed using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. 282(b).” See Changes to the Claim Construction Standard for Interpreting Claims in Trial Proceedings Before the Patent Trial and Appeal Board, 83 Fed. Reg. 51,340, 51,358 (Oct. 11, 2018) (amending 37 C.F.R. § 42.100(b) effective November 13, 2018) (now codified at 37 C.F.R. § 42.100(b) (2019)).7 That standard “includ[es] construing the claim in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” Id.; see also Phillips v. AWH Corp., 415 F.3d 1303 (Fed. Cir. 2005) (en banc). We determine that no terms require express construction to resolve the parties’ dispute. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (claim terms need only be construed “to the extent” slip op. at 14

  • BurdenNot shown unpatentable

    “Ex. 1135 ¶ 51. Yet it is Petitioner’s burden to show motivation and reasonable expectation of success for the proposed combination, not Patent Owner’s burden to show that the prior art demonstrates the futility of the proposed combination. See 35 U.S.C. § 316(e); In re Magnum Oil Tools Int’l, Ltd., 829 F.3d 1364, 1376 (Fed. Cir. 2016). Here, Petitioner’s affirmative showing on motivation and reasonable expectation of success for using Koning’s brush belt in the proposed combination is unpersuasive for the reasons discussed above. And Patent Owner’s evidence of difficulties an ordinarily skilled artisan would have expected to encounter in that proposal serves to highlight the issues that Petitioner’s showing ignores. Petitioner additionally contends that Patent Owner’s arguments are based on the erroneous premise that an ordinarily skilled artisan must be able to physically combine the references. See Pet. Reply 7 (citing In re Mouttet, 686 F.3d 1322, 1332–33 (Fed. Cir. 2012)). We disagree. Patent Owner’s arguments, summarized above, simply point out that an ordinarily skilled artisan would not have expected success in combining the references’ teachings in the way Petitioner proposes. Motivation to combine and reasonable expectation of success are properly assessed with reference to the combination as Petitioner has framed it. The Federal Circuit has explained that doing so is not inconsistent with Mouttet. See Samsung, 925 F.3d at 1382–83 (“We will not fault the Board for analyzing Petitioners’ obviousness grounds in the way presented in the Petition.”).” slip op. at 34

  • Expert testimonyPetitioner expert discountedDecided for patent owner

    “Petitioner’s and Mr. Prairie’s analysis does not acknowledge, much less bridge, the gap between Koning’s use of a brush belt to hold potatoes from above as they lie on a conveying surface, versus the brush belt’s use in above.10 During his deposition, Mr. Prairie resisted agreeing that the potatoes are lying on the conveyor in Koning, testifying that he takes from Koning’s description that “they are captured within the belt with brush hairs. And that there is some weight that’s along the conveying member 23.” Ex. 2193, 96:24–99:25. Mr. Prairie testified that he “do[es]n’t believe the brush hairs support the full weight of the potatoes,” but that Koning did not provide him sufficient information to answer whether the conveying member supports the majority of the weight of the potatoes. Id. at 106:22–107:21. In our view, it is clear from Koning’s description that the potatoes lie on the conveyor and the purpose of the brush belt is to maintain their position relative to each other while they are moved by the conveyor. Ex. 1004, 3:16–24, 5:3–14, Fig. 4; see also Ex. 2205 ¶¶ 140–141 (Patent Owner’s expert, Dr. Glancey, testifying that a simple mechanical analysis shows that in Koning, about 87% of the potatoes’ weight is supported by the conveying member). Mr. Prairie’s refusal to acknowledge the differences between the brush belt’s function in Koning versus the proposed combination undermines the credibility of his testimony that the proposed combination would have been a simple application of a known technique to a known device. 10 See WBIP, LLC v. Kohler Co., 829 F.3d 1317, 1327 (Fed. Cir. 2016) (noting expert testimony that supported the absence of a motivation to combine: “[I]f I can equate this one to kind of a simple analogy, if you’re trying to build a piece of furniture. What’s a typical thing? You put on a piece of wood. You take a nail, and you hit the nail with a hammer. In control terms, what Mr. Phipps is suggesting is that you put the hammer on the workbench, pick up the piece of furniture and bash the piece of furniture onto the hammer. It’s totally backwards from what I believe one of skill in the art would even attempt . . . .”). have been simple for an ordinarily skilled artisan to adapt Koning’s brush belt for use in the proposed combination, where seeds are deposited onto the brush belt from above—is further undermined by his testimony that he “can’t recall a time where I’ve seen a seed being dropped into a brush belt.” Ex. 2193, 113:5–9; see also Ex. 2263, 81:2–12 (“Q. And you never attempted to drop a seed onto a moving brush belt to see whether that would be inserted into the brush belt, correct? A. As I stated, for the purposes of this case, I did not do any physical experimentation with a moving brush belt as I didn’t feel it was necessary. The prior art discloses sufficient information.”) (objection omitted). Mr. Prairie has “had some industrial design projects where we’ve had to utilize brushes for various applications,” but he “ha[s] not used a brush belt to convey seed.” Ex. 2194, 297:6–16. Mr. Prairie testified that “prior to writing this declaration, brush belt technology was not a specific area that I study, that I was researching.” Ex. 2263, 79:6–9. Indeed, during his initial deposition in this case, the only specific example of a moving brush belt Mr. Prairie could recall seeing was Patent Owner’s ExactEmerge product. Ex. 2193, 108:6–110:10. The basis for Mr. Prairie’s opinion, that a seed would be expected to enter a moving brush belt in the proposed combination, appears to only be Koning itself. Ex. 1002 ¶¶ 79–81; Ex. 2193, 116:12–19, 118:7–23; Ex. 2263, 159:5–160:2. When asked at his deposition, Mr. Prairie did not explain any other engineering analysis he performed to make that determination. Ex. 2193, 114:23–117:12. Mr. Prairie testified that he “did not operate a brush belt for this declaration because [he] didn’t feel it was necessary to make my assessments” and he “did not do study or experimentation on a brush belt as I did not feel it was necessary.” unpersuasive because, as discussed above, Koning does not teach using a brush belt to receive and convey seeds that have been dropped onto it from above. Mr. Prairie does not account for that difference by explaining why an ordinarily skilled artisan would expect Koning’s brush belt to effectively capture and carry seeds dropped from above, as in the proposed combination.” slip op. at 26

  Patent outcomesUS 9,480,199 not shown unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 9,480,199
• Apple Inc. / HTC Corporation et al. v. Invt Spe LLCNo claims unpatentable
  PTAB · Mar 25, 2020 · IPR2018-01473 · APJ Thu A Dang · IPR · Final written decision

  Claims 1–3, 5–9, and 11 were not shown unpatentable under § 103 over Keskitalo and Lindell because Petitioner did not adequately explain why a skilled artisan would combine their teachings.

  RulingsFinal written decision

  • Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesDecided for petitioner

    “Petitioner contends that “[c]laim 1 includes limitations in means-plus[-]function format, which creates a rebuttable presumption that the [Applicant] intended to invoke 35 U.S.C. § 112, ¶ 6.”3 Pet. 7; see also Altiris Inc. v. Symantec Corp., 318 F.3d 1363, 1375 (Fed. Cir. 2003). In the Decision on Institution, we addressed Petitioner’s proposed constructions of the means-plus-function terms (Pet. 10–12), and we determined that Petitioner has set forth proposed structures that support these limitations. Dec. on Inst. 8–12; see 37 C.F.R. § 42.104(b)(3) (2018).” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “As for the other claim limitations of independent claims 1, 6, and 7, and claims 2, 3, 5, 8, 9 and 11 depending therefrom, neither party has proposed a construction of any other term. See Pet. 6–7; PO Resp. 12–13. We determine that we need not further construe expressly any other claim terms to resolve the arguments before us. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (explaining that only claim terms that are in controversy need to be construed and only to the extent necessary to resolve the controversy); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (applying Vivid Techs. to an inter partes review).” slip op. at 13

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “may be considered, including the “type of problems encountered in the art; prior art solutions to those problems; rapidity with which innovations are made; sophistication of the technology; and educational level of active workers in the field.” In re GPAC, Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995) (citation omitted). In that regard, Petitioner’s expert, Andrew C. Singer, Ph.D., testifies that a POSITA at the time of the invention would have been a person having a Bachelor’s degree in electrical engineering or the equivalent plus three years of experience working with digital communication systems or in network engineering or a Master’s degree in electrical engineering with an emphasis on communication systems or the equivalent plus one year of experience working with digital communication systems or in network engineering. Pet. 4–5; Ex. 1003 ¶ 35. Patent Owner does not dispute Dr. Singer’s assessment of the level of ordinary skill in the art. See generally PO Resp. We adopt and apply Dr. Singer’s assessment of the level of ordinary skill in the art, which is consistent with the level of ordinary skill reflected by the prior art of record. Okajima v. Bourdeau, 261 F.3d 1350, 1354–55 (Fed. Cir. 2001) (holding that absent evidence to the contrary, “the prior art itself [may] reflect[] an appropriate level” of ordinary skill in the art).” slip op. at 15

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundReasonable expectation not foundNot shown unpatentable

    “position of Patent Owner. In particular, we are unpersuaded by Petitioner’s contention that it would have been obvious to modify Keskitalo such that its predetermined thresholds for transmission power are average transmission power values in accordance with the teachings of Lindell. Pet. 26. That is, we are not persuaded that Petitioner has demonstrated by the preponderance of the evidence that it would have been obvious to have used Lindell’s average transmission power values as Keskitalo’s predetermined thresholds for transmission power. See Harmonic, 815 F.3d at 1363 (citing 35 U.S.C. § 312(a)(3) as requiring inter partes review petitions to identify “with particularity . . . the evidence that supports the grounds for the challenge to each claim”); Magnum Oil Tools, 829 F.3d at 1380 (holding that Petitioner cannot satisfy its burden of proving obviousness by employing “mere conclusory statements”).” slip op. at 24

  Patent outcomesUS 6,611,676 not shown unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 6,611,676
• Telebrands Corp. v. Tinnus Enterprises, LLCNo claims unpatentable
  PTAB · Oct 10, 2018 · PGR2017-00015 · APJ Kevin W Cherry · PGR · Final written decision

  The Board held claims 1–4 not unpatentable: the obviousness grounds failed to establish the claimed elastic fastener limitation, and claim 3 was not shown indefinite or lacking written-description support.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “We agree with Petitioner and determine that a POSA would have been a person having a general knowledge about, and experience with, expandable containers, including, without limitation, balloons, and at least an associate’s degree in mechanical engineering, or the equivalent. This level of skill is consistent with the types of problems and solutions described in the ’612 patent and cited prior art. For example, the ’612 patent describes a fluid inflatable system that uses elastic valve 20A (e.g., mechanical gasket, O-ring, etc.) for sealing fluid inside multiple containers (e.g., water balloons). See Ex. 1001, 1:22–24, 3:10–16. In any event, none of the issues in this case turn on the definition of a POSA, and the prior art of record provides ample evidence of the level of skill in the art. See In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995) (finding that the Board of Patent Appeals and Interferences did not err in concluding that the level of ordinary skill was best determined by the references of record); see also Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (“[T]he absence of specific findings on the level of skill in the art does not give rise to reversible error ‘where the prior art itself reflects an appropriate level and a need for testimony is not shown”’) (internal citation omitted).” slip op. at 13

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed petitioner constructionOther

    “1. Terms Construed in the Institution Decision We construed the term “elastic fastener” in our Decision on Institution, which is set forth in the following table. Inst. Dec. 14. Claim Term Construction in Institution Decision elastic fastener “an elastic element for attaching things together” Neither party disputes the language of this construction. See generally Prelim Resp. 17; Reply. We adopt them for this Final Written Decision. See Belden Inc. v. Berk-Tek LLC, 805 F.3d 1064, 1080 (Fed. Cir. 2015) (quoting Rodale Press, Inc. v. FTC, 407 F.2d 1252, 1256–57 (D.C. Cir. 1968)) (“‘an agency may not change theories in midstream without giving respondents reasonable notice of the change’ and ‘the opportunity to present argument under the new theory.’”)” slip op. at 14

  • Disclosure Requirements (§112) › Definiteness (Nautilus)IndefiniteNot shown unpatentable

    “While the terms “unfilled state” and “filled state” describe the fullness for a container, we do not agree with Petitioner that the claim language requires determining the precise amount of fluid for each state. Section 112(b) requires that we read claim terms in the context of the surrounding claim language, not in isolation. Telebrands, 733 F. App’x at 1020. When we look at the entire claim phrase—“regardless whether the first and second ones of the plurality of containers are in a filled state or an unfilled state”— the plain language is clear that regardless of whether the balloons are in either state, the “at least first and second ones of the plurality of containers are disposed sufficiently close to each other such that they press against each other.” In other words, the exact volume of fluid or water needed to reach a “filled state” does not need to be determined in order to understand the metes and bounds of the claim so as to understand how to avoid infringement. We are further persuaded because this is consistent with the district court’s construction of this term. See Ex. 1023, 19–20.” slip op. at 17

  • Disclosure Requirements (§112) › Written description (Ariad)Written description adequateNot shown unpatentable

    “Based upon our review of the specification, and consideration of the arguments and evidence presented, Petitioner’s position is not persuasive. We agree with Patent Owner that Petitioner has failed to show that the ’612 patent does not provide such adequate guidance to a person of ordinary skill in the art. On its face, Figure 1 of the ’612 patent (reproduced below) shows containers 18 in contact or pressing against one another with the reasonable clarity required by Vas–Cath Inc. Figure 1 of the ’612 patent is reproduced above. Although the ’612 patent describes, as Petitioner notes, that tubes 16 can be different lengths, we are not persuaded that the ’612 patent’s disclosure of an embodiment with different tube lengths detracts from the concurrent disclosure in Figure 1 of an embodiment, where it is difficult to describe containers 18 as being not in contact with each other. Additionally, we agree with Patent Owner that Petitioner has failed to show adequately that a person of ordinary skill would not have understood the ’612 patent as describing the containers in Figure 1 as pressing against one another in an unfilled state. The ’612 patent indicates Figure 1 shows elastic valve 20A in an open configuration when container 18A is attached to tube 16A to allow container 18A to fill with fluid. Ex. 1001, 3:14–18. In this open configuration, container 18A is to be filled with fluid, after which, “it may be removed from tube 16A, whereupon elastic valve 20A closes, thereby closing the neck of container 18A and sealing the fluid inside.” Id. at 3:18–21 (emphasis omitted). The ’612 patent refers to Figure 1 to describe an embodiment where elastic valve 20A is in an open configuration to fill a container that has not been filled (i.e., unfilled) and removed from tube 16A. Thus, we are persuaded that, at least, Figure 1 and this accompanying description of Figure 1 in the ’612 patent provides sufficient written description for the recited limitation that “at least first and second ones of the plurality of containers are disposed sufficiently close to each other such that they press against each other . . . in a filled state or an unfilled state.”” slip op. at 21

  Patent outcomesUS 9,527,612 not shown unpatentable
  Claim construction§ 103 obviousness§ 112 disclosurecites Graham
  Patents in suitUS 9,527,612
• Fox Factory, Inc. v. Sram, LLCNo claims unpatentable
  PTAB · Apr 2, 2018 · IPR2016-01876 · APJ Kevin W Cherry · IPR · Final written decision

  Claims 7–12 and 20–26 were not proven unpatentable over Hattan and JP-Shimano because the weak motivation to combine was outweighed by objective evidence of non-obviousness.

  RulingsFinal written decision

  • Expert testimonyPetitioner expert discountedPatent owner expert creditedOther

    “benefit of improved durability, see Pet. 63, neither the Petition nor JP- Shimano ever tie improved durability to improved chain retention, and the Petition never contends that durability was the rationale to modify Hattan in view of JP-Shimano. See Pet. 62–66. Dr. Neptune admitted that these arguments were not contained in his original declaration. Ex. 2129, 96:16– 97:5. A reply is not the place to raise an almost entirely new motivation to combine. See 37 C.F.R. § 42.23(b). While we will consider this argument, nevertheless, we find that Dr. Neptune’s shifting basis for the rationale to combine the references suggests that his reasoning is motivated heavily by hindsight, and not by what a person of ordinary skill at the time of the invention would have understood. See InTouch Techs., Inc. v. VGO Commc’ns, Inc., 751 F.3d 1327, 1349 (Fed. Cir. 2014) (holding it is improper to combine references “like separate pieces of a simple jigsaw puzzle” without “explain[ing] what reason or motivation one of ordinary skill in the art at the time of the invention would have had to place these pieces together”). Accordingly, we give little weight to Dr. Neptune’s testimony on rationale to combine. Patent Owner also argues that there is no rationale to combine,” slip op. at 18

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “of the effective filing date of the ’027 patent, “would have a skill level of at least a bachelor’s degree in mechanical engineering and/or at least three to five years’ experience in the development and design of chain drive systems and components thereof.” Pet. 1 n.1 (citing Ex. 1002 ¶ 14). Patent Owner contends that a person of ordinary skill would have a bachelor’s degree in mechanical engineering and at least one year of design experience with chainrings or related technologies. PO Resp. 12 n.3 (citing Ex. 2074 ¶ 25). Any difference between these two definitions is insignificant to this analysis. On this record, however, we find Patent Owner’s definition of a person of ordinary skill in the art to be more persuasive given the well-developed, relatively simple nature of the art, and apply it for our analysis.” slip op. at 7

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable

    “on an assumption that the chain retention techniques of Hattan and JP- Shimano are additive, and would “improve chain retention to the maximum extent possible.” Pet. 63, see also Tr. 8:6–9; Ex. 2074 ¶ 50. The Petition and Dr. Neptune’s opening declaration, however, contain no explanation to support or explain this underlying assumption. Ex. 2074 ¶ 50. This gap in Petitioner’s reasoning is problematic, at least in part, because, as Dr. Sturges explains, Hattan discloses that its device prevents the chain from jumping off the forward oblong sprocket under “any operating conditions,” Ex. 1004, 1:63–66, and that it will “compensate for any out of line condition” of the chain line and will “prevent the chain from ever jumping off of the sprocket wheel,” id. at 2:26–27, 2:34–35. Ex. 2074 ¶ 46. In view of Hattan’s disclosure, Dr. Sturges testifies that a person of ordinary skill in the art would have understood that JP-Shimano would not have improved chain retention and engagement in Hattan, because both are directed to solving the same kind of problems that result in chain drop. Ex. 2074 ¶¶ 45–47. For example, Dr. Sturges testifies that Hattan specifically states that its solution prevents chain line displacement chain drops. Id. ¶ 47. Dr. Sturges also testifies that JP-Shimano seeks to address chain drop resulting from chain line displacement. Id. ¶ 45.” slip op. at 16

  • Obviousness (§103) › Objective indicia / secondary considerations › NexusObjective indicia with nexusDecided for patent owner

    “Having reviewed Patent Owner’s evidence, we agree with Patent Owner that it has shown that it is entitled to a presumption of a nexus between the evidence secondary considerations tied to the X-Sync chainring and the invention recited in the challenged claims. In particular, we find that 5 Petitioner contends that there are “possibly” other patents that cover Patent Owner’s commercial product (Pet. Reply 22), but does not identify them. Petitioner’s allegations of other patents are too insubstantial to be entitled to any weight. Patent Owner has shown that the various X-Sync chainrings are covered by the challenged claims and are coextensive with them. See Ex. 2074 ¶¶ 63, 64 (testimony of Dr. Sturges that the products practice the claims); Ex. 2078–2089 (claim charts); Ex. 2076 ¶ 11 (explaining the families of products Patent Owner sells); Ex. 2073 ¶ 10 (explaining the families of products Patent Owner sells). Here, the claims are directed to chainrings, as well as cranksets and drivetrains that include chainrings. Thus, there is a presumption of a nexus between the evidence of secondary considerations tied to the X-Sync chainring, as well as to cranksets and drive trains that include the X-Sync chainring, and the challenged claims that recite these bicycle components. See Polaris Indus., 882 F.3d at 1073 (“[The challenged claims] broadly cover the entire vehicle, rather than ‘only a component of a commercially successful machine.’ . . . Moreover, the Board did not point to any limitation it found missing in the RZR vehicles. On these undisputed facts, we hold that the Board erred in failing to find that Polaris’s eight RZR vehicles are the inventions disclosed in [the claims].” (citation omitted)). Petitioner tries to rebut this presumption of a nexus by attempting to shift the burden of proof to Patent Owner to prove that the objective indicia is tied to certain claimed features rather than unclaimed features present in the commercial embodiments. Pet. Reply 26–27. We agree with Patent Owner that this argument improperly attempts to shift the burden to Patent Owner. Sur-Reply 8–9. Here, because Patent Owner has shown that it is entitled to a presumption of a nexus between the X-Sync chainring and the challenged claims, the burden is on Petitioner to rebut that nexus. Demaco, 851 F.2d at 1392. With respect to the improved chain retention of the X-Sync chainring, Petitioner argues that there are numerous unclaimed features, many of which are touted in advertising materials, but Petitioner asserts that none of the claimed features are touted. Pet. Reply 32–33. Petitioner argues that “[i]n light of the unclaimed features touted by [Patent Owner] and the press, and in the absence of any touting/recognition for the claimed combination,” Patent Owner cannot establish a nexus between the claimed invention and the objective indicia. Id. at 33 (citing Ethicon Endo Surgery, Inc. v. Covidien LP, 812 F.3d 1023, 1035 (Fed. Cir. 2016)). Although Petitioner points to some evidence touting other features, see id. at 33 (citing Ex. 1055), 42 (citing Exs. 2005, 2008, 2027), we find that this evidence is insufficient to overcome the presumption of a nexus that Patent Owner has established. Moreover, much of the evidence is clearly broader than Petitioner acknowledges. In addition to pointing out unclaimed features, there is also praise pointing generally to the “unique tooth profile,” Ex. 2006, “tooth profile,” Ex. 2008, Patent Owner’s “adaptation of the narrow-wide chainring tooth profile,” Ex. 2019, and the “cleverly profiled chainring,” Ex. 2023.” slip op. at 26

  Patent outcomesUS 9,182,027 not shown unpatentable
  § 103 obviousnesscites KSR
  Patents in suitUS 9,182,027
• Fox Factory, Inc. v. Sram, LLCNo claims unpatentable
  PTAB · Apr 2, 2018 · IPR2017-00118 · APJ Kevin W Cherry · IPR · Final written decision

  Claims 7–12 and 20–26 were not proven unpatentable under either § 103 ground because the objective evidence of non-obviousness outweighed the case for obviousness.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “of the effective filing date of the ’027 patent, “would have a skill level of at least a bachelor’s degree in mechanical engineering and/or at least three to five years’ experience in the development and design of chain drive systems and components thereof.” Pet. 1 n.1 (citing Ex. 1023 ¶ 16). Patent Owner contends that a person of ordinary skill would have a bachelor’s degree in mechanical engineering and at least one year of design experience with chainrings or related technologies. PO Resp. 12 n.3 (citing Ex. 2074 ¶ 25). Any difference between these two definitions is insignificant to this analysis. On this record, however, we find Patent Owner’s definition of a person of ordinary skill in the art to be more persuasive given the well-developed, relatively simple nature of the art, and apply it for our analysis.” slip op. at 7

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner

    “We find that Petitioner has shown a sufficient rationale to combine the teachings of the references. Petitioner has offered evidence that Thompson would have been improved by adding the wide-narrow teeth of JP-Shimano in certain situations when the chain approaches the chairing from the rear gears at an angle. Ex. 1050 ¶¶ 12–14; Ex. 1006, 15:73–75. We find this evidence persuasive and give it significant weight. We do note that we also give some weight to Patent Owner’s evidence that Thompson and JP- Shimano do largely overlap in their solutions, and that the benefits of the combination would be limited. Ex. 2074 ¶¶ 45–50. We find that even though Patent Owner’s arguments do not amount to a teaching away, they do slightly weaken the factual basis of Petitioner’s combination. See Polaris Indus., Inc. v. Arctic Cat, Inc., 882 F.3d 1056, 1069 (Fed. Cir. 2018) (“But even if a reference is not found to teach away, its statements regarding preferences are relevant to a finding regarding whether a skilled artisan would be motivated to combine that reference with another reference.”).” slip op. at 15

  • Obviousness (§103) › Objective indicia / secondary considerations › NexusObjective indicia with nexusObjective indicia no nexusDecided for patent owner

    “Unclaimed features do not prevent the presumption of a nexus, but they may be the basis for rebutting the presumption. Id. To do so, a person challenging patent validity must show that the commercial success, or other objective evidence of non-obviousness, was due to “extraneous factors” including “additional unclaimed features.” Polaris Indus., Inc. v. Arctic Cat, Inc., 882 F.3d 1056, 1072 (Fed. Cir. 2018). Merely pointing out unclaimed features in the X-Sync chainring is not enough. Id. (“However, a patent challenger cannot successfully rebut the presumption with argument alone— it must present evidence.”).” slip op. at 20

  • Obviousness (§103) › Objective indicia / secondary considerations › Commercial successObjective indicia outweighedDecided for patent owner

    “We have reviewed Patent Owner’s evidence of sales and market share, and find that it demonstrates substantial commercial success within the single chainring market. Ex. 2076 ¶¶ 16–29. In particular, we find the large growth in market share and sales volume, and resulting large market share in the single chainring market, to be indicative of commercial success. Id. ¶¶ 20–29. We find this evidence compelling and entitled to substantial weight. We do not agree with Petitioner’s argument that Patent Owner’s growth in the single-chainring market was primarily due to cannibalization of its multi-chainring market share, and that Patent Owner’s lack of achieved growth in the overall chainring market (single- and multi-) indicates that there was no commercial success. As Patent Owner notes, cannibalization does not preclude commercial success. See Medtronic, Inc. v. Daig Corp., 789 F.2d 903, 907 (Fed. Cir. 1986). Moreover, Patent Owner presented evidence that it has achieved this large market share, in the single-chainring market, while charging between two and eight times the prices of its competitors in the single chainring market. Ex. 2076 ¶ 13 (stating that Patent Owner’s X-Sync chainrings are sold for more than $90, which is at least twice as expensive as the Race Face chainrings, and in some cases eight times more expensive). Patent Owner also noted that this large market share does not include the sales of its competitors who are licensees. Id. ¶¶ 26–29; see also Tr. 16:12–15 (agreeing that Patent Owner’s drivetrain as a whole was a commercial success). Thus, we find that Patent Owner has presented substantial evidence of commercial success. As we noted above, Petitioner points to evidence that the sales information presented is primarily directed to sales of X-Sync chainrings as parts of cranksets and drivetrain groupsets. See Pet. Reply 21–24. We found above that, for data related to cranksets and groupsets, Patent Owner has only established a nexus for claims 11, 12, 25, and 26. Thus, we find that a strong demonstration of a nexus that exists between claims 11, 12, 25, and 26 and this commercial success information. Accordingly, we find that commercial success weighs significantly in favor of non-obviousness of claims 11, 12, 25, and 26.” slip op. at 30

  Patent outcomesUS 9,182,027 not shown unpatentable
  § 103 obviousnesscites KSR
  Patents in suitUS 9,182,027

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.