- PTAB · Jun 18, 2025 · IPR2025-00426 · APJ Stephen E Belisle · IPR · Institution
The Board instituted IPR on claims 11–15 over Jarvinen and Fox under § 103 and granted Samsung’s motion to join the T-Mobile IPR.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Because the issues presented in the instant Petition are identical to those in the T-Mobile IPR, we determine for the same reasons that there is a reasonable likelihood that Petitioner would prevail in showing that at least one of the Challenged Claims is unpatentable. Therefore, we institute inter partes review for the same reasons stated in our Decision on Institution in the T-Mobile IPR. See IPR2024-01468, Paper 17.” slip op. at 7
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“Petitioner’s Motion addresses each of these considerations. Mot. 1–8. According to Petitioner, its “[P]etition challenges the validity of the same claims of the ’868 patent on identical grounds to those in the T-Mobile IPR,” “[t]here are no substantive differences between [Petitioner’s] and the T-Mobile IPR Petitioners’ Petition,” and “[Petitioner] also relies on the same supporting evidence.” Id. at 4–5. Petitioner argues that its “petition will not raise any new issues of unpatentability and will not impose any additional burden on the Board or Patent Owner, or add additional complexity to the case,” and that joinder will not unduly burden or negatively impact the trial schedule. Id. at 6. Further, Petitioner agrees to take an “understudy” role, and “[u]nless and until the current Petitioners in [the T-Mobile IPR] cease to participate in the T-Mobile IPR, [Petitioner] will not assume an active role.” Id. at 7–8. Thus, according to Petitioner, Patent Owner will not suffer prejudice if the two proceedings are joined. Id. at 8. Patent Owner has not disputed the above contentions by Petitioner and does not point to any particular prejudice relating to joining the two proceedings. In light of these considerations, Petitioner has shown that joinder to the T-Mobile IPR is appropriate in this case. Therefore, we grant Petitioner’s Motion for Joinder.” slip op. at 8
NonePatents in suitUS 9,094,868 - PTAB · May 7, 2025 · IPR2024-01468 · APJ Stephen E Belisle · IPR · Institution
Instituted IPR of claims 11–15 based on the asserted obviousness ground over Jarvinen and Fox.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. 35 U.S.C. § 314(b) (2024); 37 C.F.R. § 42.4(a). We may not institute an inter partes review “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). The “reasonable likelihood” standard is “a higher standard than mere notice pleading” but “lower than the ‘preponderance’ standard to prevail in a final written decision.” Hulu, LLC v. Sound View Innovations, LLC, IPR2018-01039, Paper 29 at 13 (PTAB Dec. 20, 2019) (precedential). When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim. 37 C.F.R. § 42.108(a). Applying those standards, and upon consideration of the information presented in the Petition, Preliminary Response, and supplemental briefing, we determine that Petitioner has demonstrated a reasonable likelihood of success in proving that at least one of the Challenged Claims is unpatentable. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). Accordingly, we institute an inter partes review as to all Challenged Claims of the ’868 patent on all relevant grounds raised in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“In determining the level of ordinary skill in the art, various factors may be considered, including the “type of problems encountered in the art; prior art solutions to those problems; rapidity with which innovations are made; sophistication of the technology; and educational level of active workers in the field.” In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995) (citation omitted). Neither party argues, at least at this stage of the proceeding, that the outcome of this case would differ based on our adoption of any particular definition of the level of ordinary skill in the art. Considering the subject matter of the ’868 patent, the background technical field, the prior art, and Petitioner’s proposed and unopposed definition of the skilled artisan (Ex. 1012 ¶ 20), we apply the level of skill set forth above.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Only those claim terms that are in controversy need to be construed, and only to the extent necessary to resolve the controversy. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (stating that “we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). Petitioner submits that “all claim terms should be given their plain and ordinary meaning” (Pet. 10–11), and “Patent Owner agrees” (Prelim. Resp. 4). In determining at this stage of the proceeding that Petitioner has demonstrated a reasonable likelihood of establishing unpatentability of at least one challenged claim (namely dependent claim 11 in this case), we need not and do not construe expressly any claim terms. Nevertheless, we encourage the parties to submit proposed constructions for the limitation “determining a UE [i.e., User Equipment] environment information,” as recited in dependent claim 11. See Ex. 1001, 49:12–15, 1:40–42 (emphasis added). To the extent that a party proposes that this limitation should have its ordinary and customary meaning, the party should submit and explicitly identify such meaning. O2 Micro Int’l Ltd. v. Beyond Innovation Tech. Co., 521 F.3d 1351, 1361 (Fed. Cir. 2008) (“A determination that a claim term ‘needs no construction’ or has the ‘plain and ordinary meaning’ may be inadequate when a term has more than one ‘ordinary’ meaning or when reliance on a term’s ‘ordinary’ meaning does not resolve the parties’ dispute.”). For example, the parties should discuss (a) the meaning and scope of “determining” as used in the subject limitation; (b) the meaning and scope of “environment information” as used in the subject limitation; (c) any relationship or overlap between “environment information” and “link quality positioning information,” as recited in dependent claims 7 and 11 (see Ex. 1001, 48:62–65, 49:12–15); and (d) whether UE “environment information” includes location or orientation of the UE.” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“Petitioner contends the skilled artisan would have had rational reasons to combine the teachings of Jarvinen and Fox to arrive at the invention of dependent claim 11 (which includes the features of independent claim 1 and dependent claim 7) and would have had a reasonable expectation of success in doing so. Pet. 37–41; see, e.g., id. at 38 (“[The skilled artisan] faced with the problem of estimating a UE’s future link quality at a location would have looked to Fox because Fox solves the problem of estimating future link quality with the exact same information available to Jarvinen.”); Ex. 1012 ¶ 70 (Dr. McClellan testifying that “[a]ll of the data upon which Fox relies is already disclosed and linked together in Jarvinen’s database, and it would have been obvious for [the skilled artisan] to combine Fox’s method of looking up previous link quality to estimate future link quality with Jarvinen’s teachings.”); ¶ 72 (Dr. McClellan testifying that “modifying Jarvinen to perform Fox’s link quality estimation would have constituted a simple substitution of a known element to yield predictable results.”). Patent Owner does not dispute such reasons or expectations at this stage of the proceeding. For the reasons and evidence set forth in pages 37–41 of the Petition, we are persuaded that Petitioner’s cited evidence provides sufficient rational reasons for purposes of institution to combine Jarvinen and Fox to arrive at the invention of claim 11, and to do so with a reasonable expectation of success. c) Summary At this stage of the proceeding and based on the record before us, we are persuaded that Petitioner’s cited evidence provides sufficient rational reasons for purposes of institution to combine Jarvinen and Fox with a reasonable expectation of success, and sufficiently supports Petitioner’s contention that dependent claim 11 would have been unpatentable as obvious over the combination of Jarvinen and Fox. Thus, for the foregoing reasons and those stated in Petitioner’s preliminary briefing (Pet. 17–47, 50–51, 54), we determine that Petitioner has established a reasonable likelihood that it would prevail in showing that claim 11 would have been unpatentable as obvious over the combination of Jarvinen and Fox.” slip op. at 18
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,094,868 - PTAB · Apr 25, 2025 · IPR2024-01463 · APJ David Cotta · IPR · Institution
The Board instituted inter partes review of claims 1–10 on all asserted grounds, finding a reasonable likelihood of success on at least one claim.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“predict how the district court in the related district court litigation will proceed because the court may determine whether or not to stay any individual case . . . based on a variety of circumstances and facts beyond our control and to which the Board is not privy.” Sand Revolution II LLC v. Cont’l Intermodal Grp., IPR2019-01393, Paper 24, 7 (PTAB June 16, 2020) (informative). We decline to speculate on how the court may rule on the pending motion to stay. Accordingly, this factor is neutral.” slip op. at 13
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 314(a), inter partes review may not be instituted unless the Petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Petitioner has established a reasonable likelihood of prevailing on its assertion that at least one of the challenged claims is unpatentable based on the grounds advanced here. We decline to deny the Petition on a discretionary basis as requested by Patent Owner. Thus, for reasons explained below, we institute inter partes review of claims 1–10 of the ’706 patent.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“TC(220), and ΔRz/Ra are result effective variables and that copper foils having ΔPD, TC(220), and ΔRz/Ra values that meet the values recited in claim 1 have advantageous properties. See, e.g., Ex. 1005 ¶ 45 (Kim ’761, disclosing that preferably the “difference in peak count roughness Rpc between the shiny surface . . . and the matte surface . . . of the electrolytic copper foil . . . is preferably 60 or less” because “when the difference in the peak count roughness Rpc exceeds 60 capacity maintenance of the secondary battery is deteriorated.”);15 Ex. 1007, 3:16–23, 4:14–23 (Cheng, disclosing that the foils of Cheng’s invention have (220) and (311) surfaces that provide increased elongation and that solve a high roughness problem that rendered traditional products unsuitable for use in a lithium ion secondary battery), 10:27–34 (Cheng, disclosing that in the foils of Cheng’s invention “the roughness difference between both sides was extremely small” and thus “it was . . . not easy for the electrolytic copper foil to break or fracture during the charging-discharging cycles and the life of a battery is thus increased”), Tables 3 & 4 (Cheng, disclosing embodiments and comparative examples with TC(220) values meeting the requirements of claim 1); Ex. 1008, 6:36–44 (Wolski, disclosing that “the surface roughness Rz at the matte side of the untreated copper foil of the present invention is the same or smaller than the surface roughness Rz at the shiny side . . . so that the surface treated copper foil . . . becomes more low-profiled . . . whereby it becomes a foil having a large etching factor”), 9:1–29 & Table 2 (Wolski, disclosing 15 Dr. Randall testifies that “Kim ’761’s peak count roughness Rpc corresponds to the peak density PD of the ’706 patent.” Ex. 1003 ¶ 52. At this stage in the proceeding, this testimony is unrebutted. 38 embodiments meeting the ΔRz/Ra of claim 1, describing them as having “matte side roughnesses” that are “sufficiently small,” and as having “excellent” “high temperature elongation characteristics”), 11:37–41 (Wolski, describing comparative examples as having “large” matte side roughnesses “whereby etching factors are not good”), 12:12–27 (Wolski, teaching that “as compared with a conventional untreated copper foil, both surfaces of the untreated copper foil obtained by [Wolski’s] invention are flat” resulting in a low profile foil that has “excellent elongations at room temperature and high temperature and also high tensile strength”). The teachings in the prior art support the presently unrebutted testimony of Dr. Randall explaining why the POSA would have been motivated to modify Kim ’761’s copper foil to have the claimed TC(220) and ΔRz/Ra. Ex. 1003 ¶¶ 66–68, 71–74; Pfizer Inc., v. Sanofi Pasteur Inc., 94 F.4th 1341, 1348 (Fed. Cir. 2024) (“Where [a gap in prior art] includes a parameter not necessarily disclosed in the prior art, it is not improper to consider whether or not it would have been recognized as result-effective. If so, then the optimization of that parameter is ‘normally obvious.’”). Accordingly, we are not persuaded by Patent Owner’s argument that Petitioner failed to articulate a sufficient motivation to combine the references. To the contrary, the preliminary record presents a strong showing that the POSA would have been motivated to combine the references in the manner described in the Petition.” slip op. at 38
- Skill levelSkill level petitioner adoptedDecided for petitioner
“At this stage of the proceeding, Patent Owner does not contest Petitioner’s definition of the level of skill in the art. Prelim. Resp. 4 (“For purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art”). Petitioner’s definition appears to be consistent with the field of the invention reflected in the prior art of record and the disclosure of the ’706 patent. Accordingly, for purposes of this Decision, we adopt Petitioner’s proposed definition of the person of ordinary skill in the art.” slip op. at 21
Claim construction§ 103 obviousnessDiscretionary denialcites KSR · GrahamPatents in suitUS 11,591,706 - PTAB · Mar 26, 2025 · IPR2024-01345 · APJ Andrew L Nalven · IPR · Institution
The Board instituted IPR of claims 1–12 on all asserted grounds after finding a reasonable likelihood that claims 1, 2, 4–6, 8–10, and 12 are obvious over Lee and claims 3, 7, and 11 over …
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Pursuant to 35 U.S.C. § 314(a), an inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons provided below, we determine that Petitioner has demonstrated a reasonable likelihood that at least one claim of the ’968 patent is unpatentable, and we institute an inter partes review. 37 C.F.R. § 42.108(a).” slip op. at 2
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) does not applyDecided for petitioner
“We agree that the lack of the word “means” recited in claims 1 and 9 creates a rebuttable presumption that § 112(6) does not apply. Williamson, 792 F.3d at 1348. “When a claim term lacks the word ‘means,’ the presumption can be overcome and § 112[(6)] will apply if the challenger demonstrates that the claim term fails to ‘recite[] sufficiently definite structure’ or else recites ‘function without reciting sufficient structure for performing that function.’” Id. at 1349 (citation omitted). “One way to demonstrate that a claim limitation fails to recite sufficiently definite structure is to show that, although not employing the word ‘means,’ the claim limitation uses a similar ‘nonce word that can operate as a substitute for ‘means’ in the context of § 112 [(f)].’” MTD Products, Inc. v. Iancu, 933 F.3d 1336, 1341 (Fed. Cir. 2019) (quoting Williamson, 792 F.3d at 1350). Patent Owner argues that “[a] general-purpose computer, i.e., a ‘controller,’ fails to recite sufficiently definite structure for performing the DSC’s claimed function.” PO Sur-Reply 3–4. Petitioner responds that the term “controller” has previously been found to not invoke § 112(6) because it is understood as having a definite meaning of structure. Pet. Reply 1–2 (citations omitted). Petitioner is correct that the Board and district courts have in some cases found a “controller” to recite sufficient structure. On this preliminary record, we are not persuaded that the evidence is sufficient to establish that the term “designation software controller” fails to recite sufficiently definite structure and overcome the presumption that § 112(6) does not apply. At this juncture, neither party has provided sufficient evidence as to how the claimed “designation software controller” would reasonably be understood by persons of ordinary skill in the art. See Williamson, 792 F.3d at 1349 (“The standard is whether the words of the claim are understood by persons of ordinary skill in the art to have a sufficiently definite meaning as the name for structure.”). In addition, regardless of whether “designation software controller” alone connotes structure, the claim language that follows the term “designation software controller” appears to provide structure. Specifically, the claim language appears to include a step-by-step procedure, namely 1) keep the information in memory in response to a termination of viewing; and 2) designate the succeeding part of the digital moving image contents when the viewing starts again. See Ergo Licensing, LLC v. CareFusion 303, Inc., 673 F.3d 1361, 1365 (Fed. Cir. 2012) (“Even described ‘in prose,’ an algorithm is still ‘a step-by-step procedure for accomplishing a given result.’”); Sage Prods., Inc. v. Devon Indus., Inc., 126 F.3d 1420, 1427–28 (Fed. Cir. 1997) (“where a claim recites a function, but then goes on to elaborate sufficient structure, material, or acts within the claim itself to perform entirely the recited function, the claim is not in means-plus-function format”). Accordingly, for purposes of this decision, we do not construe the claimed “designation software controller” as a means-plus-function limitation. No further construction of this term is necessary for purposes of this decision. During trial, the parties may provide further briefing on this issue.” slip op. at 10
- Skill levelSkill level petitioner adoptedDecided for petitioner
“(“POSITA”) would have had “a Bachelors’ degree in electrical or computer engineering or a comparable field of study, plus approximately two to three years of professional experience with television and digital display systems, distributed multimedia communications, and networked computer systems.” Pet. 3–4 (citing Ex. 1002 ¶ 48). Patent Owner does not challenge Petitioner’s proffered definition as to the level of ordinary skill in the art. Prelim. Resp. 5. For purposes of this Decision, we adopt Petitioner’s assessment, which is consistent with the level of skill reflected in the specification and asserted prior art.” slip op. at 14
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“viii. Conclusion as to Claim 1 Based on the current record, we are persuaded by Petitioner’s showing for limitations 1[a] through 1[e]. Accordingly, we determine that Petitioner has demonstrated a reasonable likelihood of prevailing on its assertion that claim 1 would have been obvious over Lee.” slip op. at 22
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,948,968 - PTAB · Mar 19, 2025 · IPR2024-01358 · APJ William V Saindon · IPR · Institution
The Board instituted IPR of claims 1–24, finding a reasonable likelihood that claim 1 would have been obvious over Jüschke.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review under 35 U.S.C. § 314(b) and 37 C.F.R. § 42.4(a). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted unless “there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons provided below, we determine that Petitioner has demonstrated a reasonable likelihood that at least one claim of the ’704 patent is unpatentable, and we institute an inter partes review. 37 C.F.R. § 42.108(a).” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownOther
“1. “deployment scenarios” Claim 1 recites a machine learning model that “includes model parameters associated with values corresponding to one or more deployment scenarios.” Ex. 1001, 14:23–25. The ’704 patent provides a list of “deployment scenarios” that includes “a cellular base station . . . in an in-line mode.” Id. at 2:39–41; see also id. at 2:38–65 (entire list). The “in-line mode” is shown in Figures 6A and 7A, in which machine learning model 103 is placed “between an input 601 and an amplifier 603.” Id. at 10:38–42, 10:47–50. Figure 6A depicts the in-line mode and is reproduced below:” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successInstituted
“associated with the base station as claimed, focusing on the words “associated with.” Prelim. Resp. 26–28. Patent Owner argues that Petitioner’s position is that the model is “implemented within” the base station, but that the claim requires the model to be “associated with” the base station. Id. at 27. On this record, with no claim construction offered, we fail to see how Patent Owner construes a model “implemented within,” i.e., used in, a base station to not also be “associated with” the base station. That is, it would seem that a model used in a base station is associated with that base station. Accordingly, we do not find Patent Owner’s argument persuasive on this preliminary record.” slip op. at 12
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,018,704 - PTAB · Feb 25, 2025 · IPR2024-01315 · APJ Robert J Weinschenk · IPR · Institution
The Board instituted review of claims 1 and 3 on all three asserted obviousness grounds because Petitioner showed a reasonable likelihood of prevailing.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Further, when instituting an inter partes review, we “will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” 37 C.F.R. § 42.108(a). Here, Petitioner demonstrates a reasonable likelihood of prevailing in showing that at least one of the challenged claims is unpatentable. Thus, we institute an inter partes review of the challenged claims on all the grounds of unpatentability in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“B. Level of Ordinary Skill in the Art Petitioner argues that a person of ordinary skill in the art “would have had a Bachelors’ degree in electrical engineering or a comparable field of study, plus approximately two to three years of professional experience with electronic and optoelectronic device design.” Pet. 6 (citing Ex. 1002 ¶¶ 34– 37). Petitioner’s description of the level of ordinary skill in the art is supported by the testimony of Petitioner’s declarant, Dr. Dean Neikirk. Ex. 1002 ¶¶ 34–37. Patent Owner does not dispute Petitioner’s description at this stage of the proceeding. See Prelim. Resp. 1. We adopt Petitioner’s description for the purposes of this Decision.” slip op. at 6
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner
“C. Claim Construction In an inter partes review proceeding, a patent claim is construed using the same standard used in a civil action under 35 U.S.C. § 282(b), including construing the claim in accordance with the ordinary and customary meaning of the claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent. 37 C.F.R. § 42.100(b). Neither party proposes an express construction for any claim terms. Pet. 7; see Prelim. Resp. 1. We determine that no claim terms require express construction for purposes of this Decision.” slip op. at 6
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“E. Asserted Obviousness of Claims 1 and 3 over Anzai and Yamazaki Petitioner argues that claims 1 and 3 would have been obvious over Anzai and Yamazaki. Pet. 47–57. Petitioner presents evidence indicating that the Anzai and Yamazaki combination teaches the limitations of claims 1 and 3, and that a person of ordinary skill in the art would have had reason to combine these references. Id. Patent Owner does not present any substantive arguments regarding this asserted ground. See Prelim. Resp. 1. On this record, Petitioner demonstrates a reasonable likelihood of prevailing in showing that claims 1 and 3 would have been obvious over Anzai and Yamazaki. F. Asserted Obviousness of Claims 1 and 3 over Anzai and Yamada Petitioner argues that claims 1 and 3 would have been obvious over Anzai and Yamada. Pet. 57–63. Petitioner presents evidence indicating that the Anzai and Yamada combination teaches the limitations of claims 1 and 3, and that a person of ordinary skill in the art would have had reason to combine these references. Id. Patent Owner does not present any substantive arguments regarding this asserted ground. See Prelim. Resp. 1. On this record, Petitioner demonstrates a reasonable likelihood of prevailing in showing that claims 1 and 3 would have been obvious over Anzai and Yamada.” slip op. at 12
Claim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 8,158,477 - PTAB · Feb 12, 2025 · IPR2024-01131 · APJ Benjamin D M Wood · IPR · Institution
The Board instituted IPR of claims 1–6 and 8–14 on all asserted grounds, finding a reasonable likelihood that BOE would prevail on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“If, at the time of the institution decision, the district court has not issued orders related to the patent at issue in the petition, this fact weighs against exercising discretion to deny institution . . . .” Fintiv, Paper 11, 10. That appears to be the case here. Although the litigation may have been pending for a year, the parties have not yet begun the court’s claim-construction process, are in the early stages of fact discovery, and the court has not issued any substantive orders regarding the ’801 patent. See Ex. 2001, 4–5. Because the parties’ and the court’s investment in the parallel proceeding is not extensive, this factor weighs against exercising our discretion to deny institution. slip op. at 12
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Having reviewed the current record and the parties’ contentions, we determine that Petitioner has shown a reasonable likelihood of prevailing in showing that Kwak anticipates claim 9. We have reviewed Patent Owner’s arguments in opposition to this ground and, on this preliminary record, find them unpersuasive.” slip op. at 21
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“that the combination of interlayer 160, gate insulating layer 140, and buffer layer 120 (plus additional layers in display area 200 of Kwak’s flat-panel display) cannot be considered the claimed predetermined material layer, but rather that Petitioner has not explained why they should be so considered. See Prelim. Sur-reply 2 (“[I]t is presumptively permissible to have multiple predetermined material layers as claimed . . . . [b]ut the Petition included no theory or explanation why the three to six separate layers in its theory form a predetermined material layer.”). We agree that Petitioner does not offer an express construction of “predetermined material layer.” At this point, however, we find little in either the claims, the Specification, or elsewhere in the record that limits the meaning of “predetermined material layer” in a way that would exclude the combination of interlayer 160, gate insulating layer 140, and buffer layer 120. The Specification does not expressly define “predetermined material layer” or “predetermined material,” and we have found no evidence in the record that “predetermined material layer” or “predetermined material” has a known meaning in the art, or that otherwise supports Patent Owner’s reading of those terms. Further, we find nothing in the claims or Specification that limits “material” to any specific materials. The Specification provides several nonlimiting examples of materials that can be used if the predetermined material layer is to serve as a passivation layer, and several other (or additional) materials that can be used if the predetermined material layer is to serve as a metal electrode layer. Ex. 1001, 2:47–55. Thus, in view of the Specification, a “predetermined material layer” would simply be a layer made of one or more predetermined materials. In light of Patent Owner’s acknowledgement that “a layer” can mean “one or more layers,” the term “predetermined material layer” would encompass the combination of interlayer 160, gate insulating layer 140, and buffer layer 120.” slip op. at 23
- Skill levelSkill level petitioner adoptedDecided for petitioner
“the art “would have had a Bachelors’ degree in electrical or mechanical engineering or a comparable field of study, plus approximately two to three years of professional experience with electronic and optoelectronic device design or other relevant industry experience” but “[a]dditional graduate education could substitute for professional experience, and significant experience in the field could substitute for formal education.” Pet. 2 (citing Ex. 1003 ¶¶ 34–37). Patent Owner does not offer an alternative definition. See generally Prelim. Resp. The level of ordinary skill in the art is evidenced by the references themselves. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978). As Petitioner’s unchallenged description of an ordinarily skilled artisan appears consistent with the subject matter discussed in the references and that of the challenged claims, for purposes of this Decision we apply Petitioner’s description of a person of ordinary skill in the art.” slip op. at 16
Claim constructionDiscretionary denialcites Phillips · KSRPatents in suitUS 7,226,801 - PTAB · Dec 16, 2024 · IPR2024-01012 · APJ Julia Heaney · IPR · Institution
The Board instituted IPR on claims 1–16 and all asserted grounds, finding a reasonable likelihood of unpatentability and declining Fintiv discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Upon consideration of the Petition in view of the record at this stage, we determine that Petitioner has established a reasonable likelihood that it would prevail in showing the unpatentability of at least one claim challenged in the Petition. We also determine that the arguments and evidence of record do not support discretionary denial of the Petition under 35 U.S.C. § 314(a). Accordingly, we grant institution of an inter partes review of all claims and all grounds asserted in the Petition.1” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“parties on the present record, we are persuaded Petitioner sufficiently shows the combination of Bosnyak-392 and Son teaches or suggests all of the limitations of claim 1, and sufficiently explains how a person of ordinary skill in the art would have used Bosnyak-392’s teaching of using exfoliated, open-ended carbon nanotube fibers having two different aspect ratios in a composition with improved electrical and mechanical properties, with Son’s implementation of a specific bimodal distribution of aspect ratios, to arrive at the composition of claim 1 with a reasonable expectation of success. We do not find persuasive Patent Owner’s arguments that Bosnyak- 392 teaches away from using nanotubes with a lower aspect ratio, or that Bosnyak-392 has an objective of maintaining longer nanotubes. See Prelim. Resp. 5–9. Patent Owner’s arguments appear to be based on a mischaracterization of Bosnyak-392, which read as a whole, discusses methods for exfoliating carbon nanotubes and physical properties of exfoliated nanotubes, such as length and diameter, that are not apparent when the nanotubes are aggregated. E.g., Ex. 1005 ¶ 37. Although Bosnyak-392 recognizes that nanotube exfoliating techniques tend to reduce nanotube length (see Ex. 1003 ¶ 28), it does not discourage the use of shorter nanotubes. Rather, it recognizes that using short and long nanotubes together can produce a composite with improved electrical and mechanical properties. See id. (citing Ex. 1005 ¶ 73). See In re Fulton, 391 F.3d 1195, 1201 (Fed. Cir. 2004) (a reference does not teach away from a claimed invention unless it “criticizes, discredits, or otherwise discourages” the claimed solution).” slip op. at 17
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundDecided for petitioner
“We do not find persuasive Patent Owner’s arguments that Bosnyak- 392 teaches away from using nanotubes with a lower aspect ratio, or that Bosnyak-392 has an objective of maintaining longer nanotubes. See Prelim. Resp. 5–9. Patent Owner’s arguments appear to be based on a mischaracterization of Bosnyak-392, which read as a whole, discusses methods for exfoliating carbon nanotubes and physical properties of exfoliated nanotubes, such as length and diameter, that are not apparent when the nanotubes are aggregated. E.g., Ex. 1005 ¶ 37. Although Bosnyak-392 recognizes that nanotube exfoliating techniques tend to reduce nanotube length (see Ex. 1003 ¶ 28), it does not discourage the use of shorter nanotubes. Rather, it recognizes that using short and long nanotubes together can produce a composite with improved electrical and mechanical properties. See id. (citing Ex. 1005 ¶ 73). See In re Fulton, 391 F.3d 1195, 1201 (Fed. Cir. 2004) (a reference does not teach away from a claimed invention unless it “criticizes, discredits, or otherwise discourages” the claimed solution).” slip op. at 18
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“Having considered both sides’ arguments as to Fintiv factors 2 and 3, we determine that the considerations of these factors weigh against exercising discretionary denial. Neither party directs us to any substantive order issued by the district court in the parallel litigation, which indicates the court has not yet considered claim construction or potential invalidity of the ’282 patent. The Markman hearing will not occur until June 2025, and the expert discovery cutoff is not until August 2025. Ex. 2002. Thus, although the parties have begun discovery as to invalidity issues, much further work remains in the parallel district court litigation. We also take into account Petitioner’s prompt filing of the Petition, as weighing against exercising discretionary denial. See Fintiv 11 (“If the evidence shows that the petitioner filed the petition expeditiously, such as promptly after becoming aware of the claims being asserted, this fact has weighed against exercising the authority to deny institution . . . .”).” slip op. at 34
Claim construction§ 103 obviousnessDiscretionary denialcites KSR · GrahamPatents in suitUS 10,608,282 - PTAB · Dec 16, 2024 · IPR2024-01005 · APJ Julia Heaney · IPR · Institution
The Board instituted IPR on claims 1–23 and all asserted grounds, finding a reasonable likelihood that at least one challenged claim would have been shown unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). Upon consideration of the Petition, the Preliminary Response, and the evidence of record, we determine that Petitioner has established a reasonable likelihood that it would prevail in showing the unpatentability of at least one claim challenged in the Petition. We also determine that the arguments and evidence of record do not support discretionary denial under 35 U.S.C. § 314(a). Accordingly, we institute an inter partes review of all claims and all grounds asserted in the Petition.1” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“under the sixth Fintiv factor only after a determination that the first five Fintiv factors favor discretionary denial. CommScope, 4–5. Here, we do not find the first five factors cumulatively weigh in favor of discretionary denial. Therefore, we determine that the circumstances here do not warrant an analysis of whether the Petition presents compelling merits, and the considerations of the sixth Fintiv factor weigh against exercising discretionary denial. F. Conclusion Having considered the parties’ arguments in view of the Fintiv factors, and taking into account Petitioner’s stipulation, we determine that the circumstances here do not warrant exercising discretion under § 314(a) to deny institution. IV.” slip op. at 35
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Thus, although both parties indicate that no claim construction is necessary at this stage of the proceeding, it is apparent that they disagree as to the meaning of “discrete carbon nanotubes.” While Petitioner appears to construe “discrete carbon nanotubes” as “nanotubes that are generally individually distinct” (Pet. 13), Patent Owner argues a more restricted construction requiring that “discrete carbon nanotubes” not be reacted with other components. Prelim. Resp. 3. The evidence relating to claim 10 In quotations from the Preliminary Response throughout this Decision, we have retained bolding and underlining added to the text by Patent Owner. construction that Patent Owner offers on the current record, however, does not address its proposed restriction. See id. at 9, n. 4, citing Ex. 1001, 3:9, 5:39–40 (“The ’649 Patent describes the ‘discrete carbon nanotubes’ as, for example, ‘individually dispersed’, ‘individualized carbon nanotubes’, ‘dispersed as individual nanotubes’, and ‘essentially discrete individual fibers, not entangled as a mass.’”). As discussed in Section II.D.2 below, we determine based on the record at this stage of the proceeding that Petitioner demonstrates sufficiently for purposes of institution that Sun discloses or suggests “discrete carbon nanotubes.” Therefore, we do not explicitly construe any claim terms in this Decision. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). If either party intends to argue a claim construction at trial, however, including what is the ordinary meaning of a term, they should do so in a clearly designated section of their briefing. See Patent Trial and Appeal Board Consolidated Trial Practice Guide (Nov. 21, 2019) (“CTPG”), 46, 49 (available at https://www.uspto.gov/TrialPracticeGuideConsolidated); O2 Micro Int’l Ltd. v. Beyond Innovation Tech. Co., 521 F.3d 1351, 1361 (Fed. Cir. 2008) (“A determination that a claim term ‘needs no construction’ or has the ‘plain and ordinary meaning’ may be inadequate when a term has more than one ‘ordinary’ meaning or when reliance on a term’s ‘ordinary’ meaning does not resolve the parties’ dispute.”). Claim construction arguments should not be relegated to patentability arguments on the facts.” slip op. at 7
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner argues a person of ordinary skill in the art at the time of the invention “would have had at least [a] Master’s degree in materials science, chemistry, chemical engineering, a field relevant to polymer science and engineering, or the equivalent, and at least three years of experience in nanomaterials, electrochemistry, batteries, or polymer related activities.” Pet. 5 (citing Ex. 1003 ¶ 19). Petitioner further argues that “[a]dditional work experience can compensate for less formal education, and vice versa.” Id. Patent Owner does not dispute the level of ordinary skill in the art. Prelim. Resp. 4. For purposes of this decision, we adopt Petitioner’s definition of the level of ordinary skill in the art because it is consistent with the ’649 patent and the asserted prior art.” slip op. at 9
Claim construction§ 103 obviousnessDiscretionary denialcites KSR · GrahamPatents in suitUS 9,636,649 - PTAB · Dec 16, 2024 · IPR2024-01013 · APJ Jon B Tornquist · IPR · Institution
The Board instituted IPR on claims 1–4 and 7–18 on all three asserted obviousness grounds, finding a reasonable likelihood of success and declining discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). Having considered the arguments and evidence set forth by Petitioner and Patent Owner, we determine that the information presented in the Petition demonstrates a reasonable likelihood that Petitioner would prevail on at least one of the challenged claims of the ’483 patent. We also determine that the arguments and evidence of record do not support discretionary denial under either 35 U.S.C. § 314(a) or § 325(d). Accordingly, we institute an inter partes review as to all of the challenged claims of the ’483 patent on all of the grounds of unpatentability set forth therein.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“We agree with Patent Owner that, “given the breadth of remaining grounds of invalidity in parallel litigation,” Petitioner’s stipulation “would only resolve a small portion of the issues before the court.” Prelim. Sur-reply 3. Nevertheless, the stipulation offered by Petitioner does mitigate, at least to some extent, concerns of “potentially conflicting decisions.” Sand Revolution at 12. Accordingly, we determine that Fintiv factor 4 weighs, at least to some extent, against exercising our authority to deny institution.” slip op. at 33
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDecided for petitioner
“During prosecution, the examiner stated that the carbon nanotubes of the applied prior art reference “are considered discrete and exfoliated . . . because they are dispersed in the composite cathode slurry mixture.” Ex. 1002, 5–6. The Board determined, however, that “without more,” the examiner’s bare statement was insufficient to address the prior art reference’s “express teaching that suggests bundling or agglomeration of carbon nanotubes.” Id. at 6 (noting that Figure 2 of the prior art reference suggested that the carbon nanotubes were in fact bundled and agglomerated). In contrast to the art and analysis provided by the examiner during prosecution, Petitioner identifies a specific disclosure in Ohata demonstrating that the carbon nanotubes are “discrete, non-agglomerated, and exfoliated.” Pet. 32–33 (citing Ex. 1004, Fig. 1(b)). In further contrast to the arguments presented during prosecution, Patent Owner identifies no disclosure in Ohata, or any other prior art reference, that would suggest that the carbon nanotubes of Ohata, Kavan, and Gong or Liu are agglomerated or non-discrete. Prelim. Resp. 22–23. As such, we determine that the prior art and arguments set forth in the Petition are not substantially the same as those previously analyzed by the Office. Thus, we decline to exercise discretion to dismiss the Petition under 35 U.S.C. § 325(d).” slip op. at 37
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art would have had “at least a Master’s degree in materials science, chemistry, chemical engineering, a field relevant to polymer science and engineering, or the equivalent, and at least three years of experience in nanomaterials, electrochemistry, batteries, or polymer related activities.” Pet. 7. Petitioner further contends that “[a]dditional work experience can compensate for less formal education and vice versa.” Id. For purposes of its Preliminary Response, Patent Owner “does not dispute the Petition’s definition of [the] level of ordinary skill in the art.” Prelim. Resp. 3. On this record, we preliminarily adopt Petitioner’s definition of the person of ordinary skill in the art as it appears consistent with the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (holding that the prior art itself can reflect the appropriate level of ordinary skill in the art).” slip op. at 6
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,153,483
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.