- Shenzhen Tuozhu Technology Co., Ltd. v. Stratasys, Inc.All claims unpatentablePTAB · Sep 28, 2026 · IPR2025-00611 · APJ Christopher L Ogden · IPR · Final written decision
Claims 1–10, 12, 13, 19, and 20 are unpatentable under § 103 over the stated Douglas–Mark and Hamilton-based grounds.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“The parties agree that experience could substitute for a degree, and vice versa. Pet. 3; PO Resp. 10. The parties’ proposed levels of ordinary skill are substantially similar. For this decision, as in the Institution Decision, we adopt Petitioner’s proposed level, which is supported by credible testimonial evidence and is consistent with the problems addressed in the ’774 patent. See Ex. 1001, 1:16–52. Our decision would be the same, however, if we were to adopt Patent Owner’s proposal.” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Other
“Neither Petitioner nor Patent Owner argues that we need to construe any claim terms explicitly. See Pet. 2–3; PO Resp. 10. However, the parties contest two material claim-construction issues which we address below. To the extent that the parties’ positions depend on interpreting other claim language in a particular way, we discuss the relevant claim language below in the context of the parties’ arguments regarding the prior art.” slip op. at 8
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“We disagree with Patent Owner that a person of ordinary skill in the art would have understood that limitation 1.2 must be performed before limitations 1.3 or 1.4. See Ex. 1001, 35:21–24. See Interactive Gift Exp., Inc. v. Compuserve Inc., 256 F.3d 1323, 1342 (Fed. Cir. 2001) (“Unless the steps of a method actually recite an order, the steps are not ordinarily construed to require one.” (citing Loral Fairchild Corp. v. Sony Corp., 181 F.3d 1313, 1322 (Fed. Cir. 1999)). The evidence suggests that a “target printer” is any printer that is ultimately selected for fabricating the object, and such a printer could send its configuration information either before or after that determination is made in limitation 1.2. This interpretation does not render the word “target” meaningless. At some point, a printer must be determined to be the target printer, which is the one intended to ultimately fabricate the three-dimensional object. But the target printer still exists, and is capable of being queried, before that determination is made. We find the examples in the ’774 patent pertinent to this question. The ’774 patent states that “the target printer may include more than one printer.” Ex. 1001, 18:66–67. In discussing the step of “query target printer for properties 306” (Fig. 3A), the ’774 patent states that “[i]n one aspect, numerous queries are sent to numerous printers, e.g., for use in selecting one or more of the printers as the target printer.” Id. at 19:8–10. Alternatively, “the query is sent to a printer that is not necessarily the target printer as described herein, e.g., when the query or information received from a response to the query is used for the selection of the target printer.” Id. at 19:11–14. Importantly, the second embodiment states that the queried printer “is not necessarily the target printer,” suggesting that the queried printer could be the target printer even before it is determined to be such. Id. at 19:11–12 (emphasis added). Based on the evidence of record, a person of ordinary skill in the art would have understood that the “target printer” can be determined after the query recited in limitation 1.3 or the reception of configuration information recited in limitation 1.4. Thus, the evidence does not impose an ordering between limitations 1.2 and 1.3 or between limitations 1.2 and 1.4. The evidence also does not support Patent Owner’s argument that the two reverse-order examples in the ’774 patent are unclaimed embodiments.” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightMotivation foundDecided for petitioner
“We disagree that Petitioner’s arguments are based on impermissible hindsight, because they are based on the disclosures in Douglas and Mark, and Petitioner has articulated a persuasive reason to combine those references without referring to the ’774 patent itself, as we discuss below. See In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971) (an obvious rationale is not improper hindsight if it “takes into account only knowledge which was within the level of ordinary skill at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure”).” slip op. at 29
Patent outcomesUS 11,886,774 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,886,774 - Google LLC v. Mindbasehq, LLCAll claims unpatentablePTAB · Mar 16, 2026 · IPR2021-01252 · APJ Kara L Szpondowski · IPR · Remand
On remand, claims 14–19, 33–40, and 43–46 were held unpatentable as obvious; the Federal Circuit’s affirmed findings leave claims 1–13, 20–32, 41, and 42 unpatentable as well.
RulingsRemand decision- RemandOther
“to both cases vacating and remanding in part and affirming in part our Final Written Decisions. Appeal Dec. With respect to Petitioner’s appeals, the Federal Circuit addressed the “dictionary routine” claims (claims 14–19 and 33–40) and the “normalization” claims (claims 43–46). Appeal Dec. 7–14. For the “dictionary routine” claims, the Federal Circuit vacated and remanded, stating that In sum, as Google contends and we now hold, the “dictionary routine” claims can be practiced by use of an already-created dictionary, and do not also require the automatic creation of a dictionary. The Board needs to consider Google’s evidence and argument by applying this construction of the automatically classifying and storing limitation, and using this understanding to determine whether Conlon may, in fact, render the “dictionary routine” claims obvious (and, relatedly, whether its prior distinctions of Conlon may be immaterial). Appeal Dec. 10–11. For the “normalization” claims, the Federal Circuit also vacated and remanded, stating that our “decision to exclude Google’s rebuttal argument and supplemental declaration is based on a clear factual error,” so on remand we “must include evaluation of the evidence and argument Google provided in reply.” Id. at 13–14. With respect to Patent Owner’s cross-appeals, the Federal Circuit affirmed. Id. at 14–16.” slip op. at 3
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“The Federal Circuit concluded that Petitioner’s construction of “automatically classifying and storing” (as recited in limitation [14.3]), is correct. Appeal Dec. 8. That is, “the ‘dictionary routine’ claims can be practiced by [the] use of an already-created dictionary, and do not also require the automatic creation of a dictionary.” Id. at 10; see also Reply 7 (the limitation is “directed to the use of a dictionary function to automatically look up words and their syntax”); Appeal Dec. 8 (“nothing about the term . . . would inform a person of ordinary skill in the art that automatic ‘creation’ of a database, in addition to the ‘use’ of an already-created database, is a requirement of the dictionary routine claims”); id. (“the plain and ordinary meaning of the claim language is broad enough to include ‘use’”); id. (agreeing with Petitioner that “the specification describes the ‘dictionary routine’ as the act of looking up words already in the database”); id. at 9 (stating that “[i]t is notable, as well, that the specification nowhere describes automatically creating a dictionary; all instances of creating dictionary entries rely, at least in part, on manual data entry by users”). As directed by the Federal Circuit, we will apply this construction in our analysis.8 Id. 8 Patent Owner argues that the Federal Circuit “cherry-picks” and misinterprets the patents’ specifications, and “ignores the clearly contrary specification language.” PO Remand Br. 4–5, 10; id. at 8 (arguing that that the specification clearly set forth the definition of the claim term, and “the Board must accept term definitions . . . above all external definitions”). We do not consider these arguments on the construction of this limitation, because the Federal Circuit has directed us to proceed under its construction of the limitation. We also agree with Petitioner that the Federal Circuit’s claim construction is “foreclosed from further consideration” under its” slip op. at 17
- Obviousness (§103) › Motivation to combine / reasonable expectation of successUnpatentableMotivation foundUnpatentable
“We agree with Petitioner that claim 43 is obvious over the combination of Conlon, Miller, and Fong. The Federal Circuit stated, “[i]n this context, ‘normalization’ generally refers to de-duplicating and simplifying database entries (for instance, combining entries for ‘car’ and ‘automobile’).” Appeal Dec. 4 (cited at Pet. Response Br. 5). This is consistent with the disclosure in the ’433 patent. E.g., Ex. 1001, 16:55– 17:24 (discussing, for example, “recogniz[ing] that the differently named data elements in different structures are actually the same data element . . . is referred to as normalizing the names of the same data elements,” “recogniz[ing] that the same named data elements in different structures are actually different data elements . . . is referred to as normalizing the names of the different data elements,” and “normalizing multiple single data elements”). This is also consistent with how Fong describes “normalization.” Ex. 1029, 76 (The “Function” of “Normaliz[ing] the collection of entities” is to “[r]emove redundancies and detect errors”); see also Ex. 1057 ¶ 226. Patent Owner’s arguments that Fong’s normalization is “different” from the normalization described in the ’433 patent does not persuasively rebut Petitioner’s arguments. As Petitioner points out, Patent Owner does not provide a construction for “normalization,” despite claiming that the term is “defined” in the ’433 patent. Pet. Remand Resp. Br. 6; PO Remand Br. 13. Moreover, although Patent Owner purports to identify differences between the ’433 patent and Fong, the “normalization” applied is expressly recited in limitations [43.1.1], [43.1.2], and [43.2], and the subsequent actions taken on those normalized databases (i.e., comparing and recording) are recited in limitations [43.3]–[43.5]. That is, the “normalization” required by the claim is reflected in the claim language itself, and is broader than argued by Patent Owner. See In re Baxter Travenol Labs., 952 F.2d 388, 391 (Fed. Cir. 1991) (“It is not the function of this court to examine the claims in greater detail than argued by an appellant, looking for nonobvious distinctions over the prior art”). Patent Owner does not explain how these purported “differences” (e.g., that Fong may require the use of “database keys,” “identifiers,” “entities,” or determining ‘non-key attributes’ from key attributes) impacts the claim language, or Petitioner’s showing. See EWP Corp. v. Reliance Universal Inc., 755 F.2d 898, 907 (Fed. Cir. 1985) (A prior art reference “must be considered for everything it teaches by way of technology and is not limited to the particular invention it is describing and attempting to protect”). For the same reasons, as well as those set forth by Petitioner, we are also not persuaded by Patent Owner’s arguments that each DBMS requires a normalization process that is customized for it. Pet. Remand Resp. Br. 6–7. These arguments by Patent Owner also are not commensurate with the scope of the claim language, which does not recite a DBMS, and generally recites “normalizing” or “normalized” without regard to the DBMS. Id. Dr. Jansen provides an example of a database in unnormalized form that is converted into a normalized form, based on Fong’s four conditions, as applied to the claim language. See Reply 31–35; Ex. 1057 ¶¶ 226–261. Therefore, we are not persuaded by Patent Owner’s arguments that Petitioner has not explained how the example maps onto the limitations. PO Remand Resp. Br. 6–12. Patent Owner’s complaint that Dr. Jansen created the graphic in the example does not undermine Petitioner’s showing. E.g., Trial Practice Guide,14 I.G., (“Experts may testify about the teachings of the prior art and how they relate to the patentability of the challenged claims.”). We find Dr. Jansen’s testimony credible and persuasive in explaining why the combination of Conlon and Fong teaches the claim limitations. After considering the properly presented evidence and arguments of the complete record, we determine that Petitioner has shown, by a preponderance of the evidence, that the combination of Conlon, Miller, and Fong teaches the limitations in claim 43, that one of ordinary skill in the art would have been motivated to combine the teachings of Conlon, Miller, and Fong, and that claim 44 would have been obvious over Conlon, Miller, and Fong. 2. Analysis of Dependent Claims 44–46 Claims 44–46 depend, directly or indirectly, from claim 41. We, likewise, determine whether the combination renders obvious claims 44–46, taking into account the arguments made in Petitioner’s Reply Briefs and Dr. Jansen’s Supplemental Rebuttal Declarations. Petitioner contends that dependent claims 44–46, would have been obvious over Conlon, Miller, and Fong, and provides explanation as to how the prior art teaches each claim limitation. Pet. 84–86; Reply 35–39; Pet. Remand Br. 13–14. Patent Owner does not provide further briefing on dependent claims 44–46. 14 Available at https://www.uspto.gov/patents/ptab/trial-practice-guide#step2. Patent Owner did not specifically challenge Petitioner’s contentions as” slip op. at 31
- Strike new argumentNew argument disregardedDecided for petitioner
“Patent Owner’s arguments do not undermine Petitioner’s showing. Patent Owner did not specifically challenge Petitioner’s contentions as to the sufficiency of Conlon’s disclosure for claim 1410 in the Patent Owner Response. In the Sur-replies, Patent Owner argues that the claim requires that at least some relationships are created “automatically,” and “these automatic embodiments . . . are represented in this group of claims.” Sur-reply 9. Along these lines, in the additional briefing Patent Owner argues that Conlon does not teach “automatic,” but merely teaches “semi-automatic.” PO Remand Br. 9–10. The crux of Patent Owner’s argument, however, is that the Federal Circuit did not properly construe the limitation, and ignored certain disclosures in the ’433 (and ’680) patent. Id. at 10–11; see Pet. Remand Resp. Br. 1–4; PO Remand Resp. Br. 4–5. The Federal Circuit held that “the dictionary routine claims can be satisfied by mere use of a lexical database, and do not also require the automatic creation of additional definitions.” Appeal Dec. 10. Moreover, the statements from Conlon that Patent Owner relies upon relate to creating a database, not using the database. See id. As discussed above, on remand we are directed to apply the Federal Circuit’s construction. Patent Owner does not explain 10 As discussed in the original Final Written Decisions, Patent Owner raised several arguments that generally applied to all the claims, challenging, for example, the level of ordinary skill in the art, whether Conlon, Miller, and Beckwith were analogous art, and several general arguments relating to Conlon and the motivation to combine Conlon with a DBMS. See Final Dec. 14–23, 25–27. We were not persuaded by Patent Owner’s arguments; the Federal Circuit affirmed, determining that our findings were supported by substantial evidence. Appeal Dec. 14–16. why Petitioner’s contentions are not persuasive in light of the Federal Circuit’s construction of this limitation. In addition, Patent Owner argues in the Sur-replies that “[c]laims 14– 19 are not disclosed by the proffered prior art” and cites to paragraphs 78–83 of the Ranka Rebuttal Declarations. Sur-reply 10. As discussed in the original Final Written Decisions, Patent Owner’s reliance on six paragraphs of Dr. Ranka’s Rebuttal Declarations is an improper incorporation by reference, as Patent Owner did not discuss that testimony or further elaborate on these arguments in the Sur-replies. 37 C.F.R. § 42.6(a)(3); Cisco Systems, Inc. v. C-Cation Techs., LLC, IPR2014-00454, Paper 12 at 9–10 (PTAB Aug. 29, 2014) (informative); see, e.g., Final Dec. 37–39, 45, 48–50, 52. Therefore, we will not consider arguments that are not made in the Sur-replies, but are instead improperly incorporated by reference to the cited paragraphs in Dr. Ranka’s Rebuttal Declarations. Accordingly, after considering the evidence and arguments of the complete record, we determine that Petitioner has shown, by a preponderance of the evidence, that Conlon teaches limitation [14.3], and that claim 14 would have been obvious over Conlon.” slip op. at 21
Patent outcomesUS 6,665,680 unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 6,665,680 - Apple Inc. v. Varia Holdings LLCAll claims unpatentablePTAB · Feb 27, 2026 · IPR2024-01364 · APJ Norman H Beamer · IPR · Final written decision
Claims 1–39 are unpatentable under § 103 over Willgert and Mooney; claims 3–9, 15–19, 22–28, and 34–38 are also unpatentable over Willgert, Mooney, Holloway, and Pitroda.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“Based on a review of the record, we adopt Patent Owner’s proposed level of ordinary skill in the art, with its inclusion of a Computer Science background, because it is consistent with the evidence of record, including the asserted prior art and ‘984 patent specification. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). However, our Decision would not be altered if Petitioner’s definition applied.” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“d) Analysis Re Construing “Voice Call Signals” We conclude that it is unnecessary to define “voice call signal.” Patent Owner’s construction would read into the term additional limitations that are for the most part already set forth in the claims: “a switchable mobile communications device capable of . . . voice call communication” (claims 1, 13, 21, 32); “output . . . a voice call signal for transmission . . . over a wireless network” (claims 13, 21, 32); “wherein the mobile communication device is a selected one of a wireless mobile phone and a personal digital assistant equipped with communication capability” (claims 12, 20, 31, 39). Thus the claims require a mobile communications device that is capable of communicating a voice call signal, but do not restrict the voice call signal to only be communicated by a mobile communications device. Likewise, claims 13, 21, and 32 (but not claim 1) require the voice call signal to be transmitted over a wireless network, but do not restrict transmission to only a wireless network, and do not restrict the wireless network to “a network of a wireless network service provider,” as Patent Owner would require.” slip op. at 15
- Claim Construction › Intrinsic evidence (Phillips canons) › Specification disavowal / 'present invention' languageTerm construed board ownDisclaimer not foundDecided for petitioner
“construction for the RFID transponder signal or data terms — it is sufficient for purposes here to conclude that the claims encompass Petitioner’s “functional emulation” articulation. See Reply 11–12. That is, the purpose of the frequent references to “emulated,” “emulation,” or the like in the ‘984 patent is to emphasize the fact that the mobile communications device of the claims has a dual role: to provide voice call communications, and to transmit RFID transponder data. In the latter role, transmitted RFID transponder data appears to an RFID reader to have been transmitted from an ordinary RFID transponder. But there is no need to rewrite the claims to restore the emulation terms, given that, as we discuss further below, Patent Owner deliberately removed those terms during prosecution. The functional emulation implicit in the ‘984 specification and claims” slip op. at 22
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“the fact that Willgert teaches that integrating its communications unit into a mobile telephone designed for Bluetooth communication was a “highly user-friendly application,” and that it was well known practice to use a Bluetooth headset wirelessly communicating with the phone to enable hands-free phone calls, as specifically taught by Mooney. Pet. 12–14 (citing Ex. 1004 ¶¶ 8, 30–32; Ex. 1005, Fig. 3, ¶¶ 7, 39, 46–48; Ex. 1021; Ex. 1003 ¶¶ 72–76). Petitioner further argues that Bluetooth headsets were widely available, that incorporating the headset involved known methods yielding predictable results, and that one of ordinary skill would have reasonably expected to succeed in combining the teachings of Willgert and Mooney. Id. at 15–16 (citing Ex. 1004 ¶¶ 8, 10; Ex. 1005, ¶ 8; Ex. 1017, 1, 3; Ex. 1021, 2; Ex. 1003 ¶¶ 77–79). Patent Owner does not specifically address the issue of motivation to combine Willgert and Mooney. See generally PO Resp. We find, based on the record, that Petitioner has proved by a preponderance of the evidence that a person of ordinary skill in the art would have been motivated to combine Willgert and Mooney as proffered by Petitioner with a reasonable expectation of success.” slip op. at 31
Patent outcomesUS 8,127,984 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,127,984 - Apple Inc. v. Varia Holdings LLCAll claims unpatentablePTAB · Feb 27, 2026 · IPR2024-01363 · APJ Norman H Beamer · IPR · Final written decision
Claims 1–32 are unpatentable under § 103 over Willgert and Mooney, or Willgert, Mooney, Holloway, and Pitroda, as applicable.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“Patent Owner “disputes the narrow range of educational experiences in the Petition’s POSITA definition, but does not otherwise dispute the remaining portion of the definition.” PO Resp. 13. Patent Owner contends that person of ordinary skill in the art: [W]ould have been someone “with at least a Bachelor’s degree in Electrical Engineering, Computer Science, or a related field, with a background in radio frequency communications and software development, as well as approximately two years of experience working with or researching radio frequency communication systems. Lack of work experience can be remedied by additional education, and vice versa.” PO Resp. 13–14 (citing Ex. 2004 ¶ 34).7 Based on a review of the record, we adopt Patent Owner’s proposed level of ordinary skill in the art, with its inclusion of a Computer Science background, because it is consistent with the evidence of record, including the asserted prior art and ’947 patent specification. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). However, our Decision would not be altered if Petitioner’s definition applied.” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Not reached
“d) Analysis Re Construing “Voice Call Signals” We conclude that it is unnecessary to define “voice call signal.” Patent Owner’s construction would read into the term additional limitations that are for the most part already set forth in the claims: “the voice call signal is output over a wireless network” (claims 1 ); “outputting the voice call signal over a wireless network” (claim 9); “output a voice call signal for transmission over a wireless network” (claim 16); transmit voice call signals . . . over a wireless network” (claim 26); “wherein the mobile communication device is one of a wireless mobile phone and a personal digital assistant equipped with communication capability” (claims 8, 15, 25, 32). Thus the claims require the voice call signal to be transmitted over a wireless network, but do not restrict transmission to only a wireless network, and do not restrict the wireless network to “a network of a wireless network service provider,” as Patent Owner would require. We also agree that there is nothing in the ’984 prosecution history that supports Patent Owner’s assertion that the Examiner found that the Bluetooth signal of Cooper was not a voice call signal. Cooper was distinguished because: The term “transceiver,” however, is well understood by those of ordinary skill in the art. One of ordinary skill in the art would not reasonably interpret a “transceiver” so broadly as to incorporate an entire mobile device’s circuitry, and in particular to be read on by two separate transmitters, as Cooper teaches. Ex. 1008, 40. On the other hand, we agree with Patent Owner that Petitioner’s” slip op. at 14
- Claim Construction › Intrinsic evidence (Phillips canons) › Specification disavowal / 'present invention' languageTerm construed petitioner constructionDecided for petitioner
“This functional emulation solution is served regardless of how the specific RFID transceiver is implemented — the ’947 specification specifically provides for both software and hardware implementations. Id. at 2:24–28 (“Embodiments of the present invention includes . . . certain hardware and/or software embodied therein for the practice of the emulated RFID method”), 3:35–36 (“mobile communication device 102 is equipped with hardware and/or software elements”), 3:52–54 (“substantial portions of the hardware and/or software elements employed to provide a RFID”), 5:16 (“A Hardware/Software Implementation”). There is no reason why one version of the hardware used to emulate the RFID function could not be RFID transponder circuitry. The issue is not whether an RFID transponder can emulate itself, but rather whether RFID transponder circuitry incorporated into a mobile communications device can be used to allow the mobile communications device to emulate a separate RFID transponder. For example, rather than requiring the person described in the Background of the ’947 patent to carry both a mobile phone and a “key with remote control for gaining access to his/her vehicle,” they need only carry the mobile communications device of the claims. The statement in the ’947 patent that “the present invention is related to an emulated radio frequency data input method” (Ex. 1001, 1:22–24), and the other references to emulation, are consistent with a conclusion that the claims encompass the “functional emulation” option as described above. However, there is no basis for adding the negative limitation proposed by Patent Owner (“without the use of a physical RFID transponder”). Omega Engineering, 334 F.3d at 1333 (rejecting a construction because “neither the plain text of the claims, the specification, nor the file wrapper justifies the imposition of this negative limitation”). See also BillJCo, LLC v. Apple Inc., No. 2023-2189, 2023-2190, 2025 WL 1417957, at *1 (Fed. Cir. May 16, 2025): Our court has “identified claim constructions that exclude a particular element as including a ‘negative limitation’ and held that such exclusions must find support either in ‘the words of the claim’ or through an ‘express disclaimer or independent lexicography in the written description that would justify adding that negative limitation.’” Ethicon LLC v. Intuitive Surgical, Inc., 847 F. App’x 901, 907 (Fed. Cir. 2021). Moreover, the prosecution history of the ’984 grandfather patent is not” slip op. at 22
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“Petitioner argues that this combination would have been motivated by the fact that Willgert teaches that integrating its communications unit into a mobile telephone designed for Bluetooth communication was a “highly user- friendly application,” and that it was well known practice to use a Bluetooth headset wirelessly communicating with the phone to enable hands-free phone calls, as specifically taught by Mooney. Pet. 16–18 (citing Ex. 1004 ¶¶ 8, 30, 32; Ex. 1005, Fig. 3, ¶¶ 7, 39, 48; Ex. 1021; Ex. 1003 ¶¶ 62–65). Petitioner further argues that Bluetooth headsets were a well-known concept and widely available, that incorporating the headset involved known methods yielding predictable results, and that one of ordinary skill would have reasonably expected to succeed in combining the teachings of Willgert and Mooney. Id. at 19–21 (citing Ex. 1004 ¶¶ 8, 10, 30; Ex. 1005, ¶ 8; Ex. 1016; Ex. 1017, 1, 3; Ex. 1021, 2; Ex. 1003 ¶¶ 66–68). Patent Owner does not specifically address the issue of motivation to combine Willgert and Mooney. See generally PO Resp. We find, based on the record, that Petitioner has proved by a preponderance of the evidence that a person of ordinary skill in the art would have been motivated to combine Willgert and Mooney as proffered by Petitioner with a reasonable expectation of success.” slip op. at 29
Patent outcomesUS 9,405,947 unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 9,405,947 - Apple Inc. v. Varia Holdings LLCAll claims unpatentablePTAB · Feb 27, 2026 · IPR2024-01362 · APJ Norman H Beamer · IPR · Final written decision
Claims 1–19 are unpatentable under § 103 over Willgert and Mooney, or over Willgert, Mooney, Holloway, and Pitroda for claims 3–6, 10, 11, and 13–17.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“Patent Owner “disputes the narrow range of educational experiences in the Petition’s POSITA definition, but does not otherwise dispute the remaining portion of the definition.” PO Resp. 12. Patent Owner contends that person of ordinary skill in the art: [W]ould have been someone “with at least a Bachelor’s degree in Electrical Engineering, Computer Science, or a related field, with a background in radio frequency communications and software development, as well as approximately two years of experience working with or researching radio frequency communication systems. Lack of work experience can be remedied by additional education, and vice versa.” PO Resp. 12 (citing Ex. 2004 ¶ 34).7 Based on a review of the record, we adopt Patent Owner’s proposed level of ordinary skill in the art, with its inclusion of a Computer Science background, because it is consistent with the evidence of record, including the asserted prior art and ’974 patent specification. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). However, our Decision would not be altered if Petitioner’s definition applied.” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“We agree with Patent Owner’s description of the characteristics and operation of a wireless mobile phone, which are not in dispute. Also, the Specification’s description of wireless mobile phones is relied on by Patent Owner in its arguments regarding the construction of “voice call signal,” as discussed below. Nonetheless, Petitioner argues that it is unnecessary to construe the term, “wireless mobile phone.” Reply 4. We agree. The term “wireless mobile phone” is only used in dependent claim 19 (not in independent claim 12, as Patent Owner alleges), and the principal reference relied on by Petitioner (Willgert) explicitly discloses the use of a mobile telephone. Ex. 1001, 12:2; Ex. 1004 ¶¶ 30–32. For these reasons, and because our analysis of the issues set forth below is not dependent on Patent Owner’s proposed construction, it is unnecessary to adopt Patent Owner’s construction or otherwise construe the term “wireless mobile phone.”” slip op. at 12
- Claim Construction › Intrinsic evidence (Phillips canons) › Specification disavowal / 'present invention' languageTerm construed petitioner constructionDecided for petitioner
“to an emulated radio frequency data input method” (Ex. 1001, 1:20–21), and the other references to emulation, are consistent with a conclusion that the claims encompass the “functional emulation” option as described above. However, there is no basis for adding the negative limitation proposed by Patent Owner (“without the use of a physical RFID transponder”). Omega Engineering, 334 F.3d at 1333 (rejecting a construction because “neither the plain text of the claims, the specification, nor the file wrapper justifies the imposition of this negative limitation”). See also BillJCo, LLC v. Apple Inc., No. 2023-2189, 2023-2190, 2025 WL 1417957, at *1 (Fed. Cir. May 16, 2025): Our court has “identified claim constructions that exclude a particular element as including a ‘negative limitation’ and held that such exclusions must find support either in ‘the words of the claim’ or through an ‘express disclaimer or independent lexicography in the written description that would justify adding that negative limitation.’” Ethicon LLC v. Intuitive Surgical, Inc., 847 F. App’x 901, 907 (Fed. Cir. 2021). Patent Owner’s argument that the claim language, “[a] transceiver . . . configured to output . . . RFID transponder [signals or data],” only makes sense “if the transceiver is not itself an RFID transponder” (Sur-Reply 10) is not persuasive. Examination of the complete version of the passage that Patent Owner only paraphrases — “[a] transceiver configured to output voice call signals in the first state and to output RFID transponder signals in the second state” — shows that the transceiver is capable of both voice call and RFID functions, and thus there is no inconsistency in allowing the RFID function to be performed by RFID transponder circuitry incorporated into the transceiver.” slip op. at 24
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“Petitioner argues that this combination would have been motivated by the fact that Willgert teaches that integrating its communications unit into a mobile telephone designed for Bluetooth communication was a “highly user-friendly application,” and that it was well known practice to use a Bluetooth headset wirelessly communicating with the phone to enable hands-free phone calls, as specifically taught by Mooney. Pet. 14–17 (citing Ex. 1004 ¶¶ 8, 30–32; Ex. 1005, Fig. 3, ¶¶ 7, 39, 46–48; Ex. 1021; Ex. 1003 ¶¶ 72–76). Petitioner further argues that Bluetooth headsets were widely available, that incorporating the headset involved known methods yielding predictable results, and that one of ordinary skill would have reasonably expected to succeed in combining the teachings of Willgert and Mooney. Id. at 17–19 (citing Ex. 1004 ¶ 10; Ex. 1005, ¶ 8; Ex. 1017, 1, 3; Ex. 1021, 2; Ex. 1003 ¶¶ 77–79). Patent Owner does not specifically address the issue of motivation to combine Willgert and Mooney. See generally PO Resp. We find, based on the record, that Petitioner has proved by a preponderance of the evidence that a person of ordinary skill in the art would have been motivated to combine Willgert and Mooney as proffered by Petitioner with a reasonable expectation of success.” slip op. at 31
Patent outcomesUS 8,381,974 unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 8,381,974 - Arashi Vision (U.S.) LLC (D/B/A Insta360) v. Gopro, IncNo claims unpatentablePTAB · Nov 25, 2025 · IPR2024-01165 · APJ William V Saindon · IPR · Final written decision
Claims 1–21 were not shown unpatentable because Zhou does not teach the claimed low-light high-pass or stickiness parameter limitations.
RulingsFinal written decision- BurdenFwd all claims patentableNot shown unpatentable
“4. Conclusion for the Prior Art Analysis In sum, we find that Zhou does not disclose the low-light high-pass parameter or the stickiness parameter. Petitioner’s grounds for both independent claims 1 and 16 rely on Zhou for teaching a low-light high-pass parameter or a stickiness parameter. Pet. 23–28, 64. Because we find Zhou does not teach these limitations, all of Petitioner’s grounds fall for this reason. III. CONCLUSION For the reasons given above, we determine that Petitioner has not established by a preponderance of the evidence that any claim of the ’840 patent would have been obvious in view of the prior art cited.” slip op. at 18
- Skill levelSkill level petitioner adoptedOther
“A person of ordinary skill in the art (POSITA) in the field of the ’840 patent would have a bachelor’s degree in engineering or computer science, or equivalent field, and two years of experience working on image or video processing, or digital cameras. Alternatively, a POSITA would have four years of experience working on image or video processing, or digital cameras. An advanced graduate degree in the disciplines cited above may make up for the work experience indicated above. Pet. 6 (citing Ex. 1002 ¶ 32). Patent Owner applies the same standard. PO Resp. 26–27. We use this agreed-upon standard for purposes of this Decision.” slip op. at 7
- Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner
“We review this testimony based on the strength of the underlying factual basis. 37 C.F.R. § 42.65(a); Ashland Oil, Inc. v. Delta Resins & Refractories, Inc., 776 F.2d 281, 294 (Fed. Cir. 1985) (“Lack of factual support for expert opinion going to factual determinations, however, may render the testimony of little probative value . . ..”). Here, the underlying factual basis is not very strong for either witness. That said, we find that Dr. Foroosh’s testimony is more logically sound and consistent with the ’840 patent disclosure. Based on our reading of the specification, we find a clear indication that “stickiness” has to do with the past. In order to control “the extent by which preceding portion(s) . . . impacts determination of the smoothed trajectory” (emphasis added), one must control the degree by which the past frames impact determination. And to control the degree of the past’s influence, one must, as a consequence, favor the past over the future. That is, the frame of reference of the stickiness parameter is the past. The specification could have used a time-agnostic term, like a “nearness” or “adjacency” parameter, but it did not. Thus, the fact that “stickiness” is used in conjunction with “preceding” indicates that it deals with a preference for preceding frames. On this basis, we find Dr. Katsaggelos’s testimony less persuasive than Dr. Foroosh’s.” slip op. at 10
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for patent owner
“That said, we do not construe a stickiness parameter as prohibiting consideration of future frames. Instead, we determine that the stickiness parameter’s value determines the impact of the preceding portions, versus the following portions. The ’840 patent recognizes this, when it says that a stickiness parameter value of “1,” representing a “lazy” stabilizer that maximally favors the past, would not override a violation of the margin constraint based on the look-ahead (i.e., would not allow the viewing window to fall out of bounds in the event of large future motion). See Ex. 1001, 22:26–30; see also id. at 12:61–13:29 (acknowledging that favoring the past may lead to a conflict with the viewing window determination), 15:39–60 (adjusting the viewing window to ensure it does not violate a margin constraint). Thus, while a past-favoring parameter by necessity favors the past over the future, it does not prohibit consideration of the future. In view of the above, we construe the claimed “stickiness parameter” as a parameter that controls the extent by which preceding portions of the trajectory impacts determination of the smoothed trajectory, with an understanding that in order to favor preceding portions, to some extent, the parameter must relatively disfavor following portions.” slip op. at 10
Patent outcomesUS 10,958,840 not shown unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,958,840 - PTAB · Nov 12, 2025 · IPR2025-00959 · APJ Lisa A Murray · IPR · Institution
The Board instituted IPR on claims 1, 5-9, 13-17, and 25-27 across all petitioned grounds, finding a reasonable likelihood of obviousness.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“An inter partes review may be instituted only if “the information presented in the petition . . . and any [preliminary] response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons given below, on this record, Petitioner has established a reasonable likelihood that it would prevail in showing the unpatentability of at least one of the challenged claims. Accordingly, we institute an inter partes review of the challenged claims on all grounds raised in the Petition. B. Real Parties in Interest” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner asserts that one of ordinary skill in the field of the ’016 Patent would have had: a degree in computer science or computer engineering, along with 2 years of professional experience working with telecommunications systems, or an equivalent level of skill, knowledge, and experience. . . . This POSITA would have been aware of and generally knowledgeable about the standard features and functionality of emergency calling, geolocation, and text messaging systems. Pet. 15. For the purposes of its Preliminary Response, Patent Owner “does not challenge that definition.” Prelim. Resp. 5. We find Petitioner’s formulation to be consistent with the evidence of record at this stage of the proceedings, including the asserted prior art and the ’016 Patent, and we adopt and apply that definition for purposes of this Decision. C. Claim Construction” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner
“During the reissue proceedings that led to the ’016 Patent, Patent Owner represented that “the ’016 patent claim limitations requiring a ‘call reception module,’ ‘presentation module,’ ‘outgoing message module,’ and ‘transmission module’ are not means-plus-function limitations and instead require only “computer program modules that are executed by processors, rather than a generic description for software or hardware.” Ex. 1003, 156– 169; see Pet. 14. For the purposes of these proceedings only, Petitioner accepts these representations and asserts that “[n]o terms require further construction and all terms can be afforded their plain and ordinary meaning.” Id. at 14–15. For the purposes of its Preliminary Response, Patent Owner agrees with Petitioner. Prelim. Resp. 5. After reviewing the parties’ arguments and evidence, we determine that no express constructions of any terms are needed for us to render our Decision on Institution. See, e.g., Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 8
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“To establish a motivation to combine multiple prior art references, it is not necessary to identify some deficiency in the primary reference that can only be remedied by combining that reference with another. The proposed the primary reference. See, e.g., Honeywell Int’l Inc. v. 3G Licensing, S.A., 124 F.4th 1345, 1355–56 (Fed. Cir. 2025) (Obviousness “does not require that a particular combination must be the preferred, or the most desirable, combination described in the prior art in order to provide motivation for the current invention.”); see also KSR, 550 U.S. at 420 (“[T]he problem motivating the patentee may be only one of many addressed by the patent’s subject matter.”). The relevant question is not whether the proposed combination is the most desirable combination available. Rather, it is “whether there is something in the prior art as a whole to suggest the desirability, and thus the obviousness, of the claimed invention.” Honeywell, 124 F.4th at 1355 (citations omitted). Here, Petitioner has identified reasons why it would have been desirable to modify the system of Brooks to include the texted URL link of SARLOC: the caller would not need any special technical skills or equipment; existing smartphone functionality would be capable of collecting the location information; and SARLOC simply represents a specific example of a general concept taught in Brooks, that of exchanging location information through text messages. Pet. at 38–39. Because the claimed modification need only be a suitable option, rather than the “best” or “preferred” approach, Patent Owner’s argument is unpersuasive.” slip op. at 14
Claim construction§ 103 obviousnesscites Phillips · KSR · Graham - PTAB · Oct 9, 2025 · IPR2025-00847 · APJ Brian D Range · IPR · Institution
Instituted IPR on claims 1–11 because Petitioners showed a reasonable likelihood of proving at least one challenged claim unpatentable across the asserted grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” The following findings of fact and conclusions of law are not final, but are made for the sole purpose of determining whether Petitioners meet the threshold for initiating review. Any final decision shall be based on the full trial record, including any response timely filed by Patent Owner. Any arguments not raised by Patent Owner in a timely-filed response may be deemed waived. For the reasons stated below, we determine that Petitioner has established a reasonable likelihood that it would prevail with respect to at least one claim. We hereby institute an inter partes review as to claims 1–11 of the ’847 patent based upon Petitioners’ asserted grounds of unpatentability.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“would have had a master’s degree in electrical engineering, physics, chemistry, materials science, or a related field and three years of work experience in semiconductor manufacturing, such as, for example, in integrated circuit device (or transistor) design and/or manufacturing,” and “[a]dditional relevant education could substitute for professional experience, and significant work experience or training could substitute for formal education.” Pet. 11 (citing Ex. 1003 ¶ 38). Patent Owner does not dispute the level of ordinary skill in the art. See generally Prelim. Resp. For purposes of this Decision, we adopt Petitioner’s proposal as reasonable and consistent with the ’847 patent specification and the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the prior art may reflect an appropriate level of skill in the art). slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Petitioner does not propose any claim constructions, except to explain that the claim 7 limitation “the spacer further comprises an offset spacer, positioned between the gate and the spacer,” is “satisfied if one layer (an ‘offset spacer’) of the claimed ‘spacer’ lies between another layer of the ‘spacer’ and the gate.” Pet. 11. Patent Owner does not dispute Petitioner’s assertions or offer any claim constructions. See generally Prelim. Resp. Because resolution of Petitioner’s proposed construction is unnecessary to our analyses for purposes of this decision, we do not address the proposal here. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). We do not discern a need to construe any other claim language at this juncture because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC, 912 F.3d at 1375.” slip op. at 8
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“a. Claim 1 Petitioner contends that claim 1 is anticipated by Lan or, alternatively, obvious in view of Lan. Pet. 18–26. Petitioner explains how Lan teaches or suggests each recitation of claim 1, and Petitioner’s position is supported by adequate evidence for institution. Id. (citing, e.g., Ex. 1003 ¶¶ 100–125). Petitioner, for example, persuasively compares the structure of Figure 12 of Lan to each limitation of claim 1. Id. Patent Owner does not dispute Petitioner’s contentions except to argue that Lan (and the Petition’s other asserted references) “Do Not Mention, Describe, or Concern ‘Raised Epitaxial Layers.’” Prelim. Resp. 22–24. Patent Owner does not persuasively undermine Petitioner’s position.” slip op. at 13
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 7,745,847 - Apple Inc. v. Resonant Systems, Inc.All claims unpatentablePTAB · Oct 9, 2025 · IPR2025-00680 · APJ Karl D Easthom · IPR · Final written decision
Claims 2 and 3 are unpatentable under § 103 over Gregorio, Ramsay, Tierling, Rossi, and Aldrich; claim 2 is also unpatentable over Gregorio, Ramsay, Wakuda, Rossi, and Aldrich.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“would have had a degree in mechanical engineering, electrical engineering, physics, or a related technical field, and at least 2–3 years of experience related to the design or development of systems incorporating linear actuators; additional years of experience could substitute for the advanced-level degree. Ex. 1003 ¶ 30. Patent Owner offers “a similar level of ordinary skill in the art.” See PO Resp. 4. Based on a review of the record, we adopt Petitioner’s proposed level of ordinary skill in the art because it is consistent with the evidence of record, including the asserted prior art and ’337 patent specification.” slip op. at 9
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesDecided for petitioner
“An element in a claim for a combination may be expressed as a means . . . for performing a specified function without the recital of structure, material, or acts in support thereof, and such claim shall be construed to cover the corresponding structure, material, or acts described in the specification and equivalents thereof. 35 U.S.C. § 112 ¶ 6. In particular, the parties agree that the “driving component” and “control component” requirements of independent claim 2 are means-plus-function limitations. Pet. 2–6; PO Resp. 7. Construing a means-plus-function limitation under 35 U.S.C. § 112 ¶ 6 involves two steps: 1) identifying the claimed function and 2) identifying in the specification the corresponding structure that performs the claimed function. Med. Instrumentation & Diagnostics Corp. v. Elekta AB, 344 F.3d 1205, 1210 (Fed. Cir. 2003); Cardiac Pacemakers, Inc. v. St. Jude Med., Inc., 296 F.3d 1106, 1119 (Fed. Cir. 2002).” slip op. at 10
- Claim Construction › Functional claiming / §112(f) means-plus-function › Corresponding structure / algorithm (indefinite if none)Term construed petitioner constructionTerm construed board ownMixed
“supply of power from the power supply to . . . cause the moveable component to oscillate at a frequency . . . specified by one or more stored values” to portions of steps 706 and 708 of the flow diagram algorithm of Figure 7A, as described above. Thus, the control component requires a microprocessor and memory with algorithmic structure including a timing algorithm or similar coding for creating a control output signal that flips to control the direction of current flow through a coil (e.g., coil 514, Fig. 5, coil 626, Fig. 6), where the coil is structure that corresponds to the recited “driving component,” as noted above.10 We adopt the District Court’s conclusion in the Apple litigation that the “control component” structure itself does not require an H-bridge switch, but only requires that the processor generates the “d” inputs configured to operate a switch or other circuit; and further that the structure does not require does not require computing initial default values as specified in step 702 of Figure 7A (i.e., values not specified by a user). Ex. 3001, 30–33, 35. This is in accord with settled law that limits the structure to that necessary to 10 “Rather than using a formal timer mechanism, certain implementations may simply employ counted loops or other simple programming techniques for periodically carrying out tasks.” Ex. 1001, 7:7–10. perform the claimed function. 11 By the same token, we modify the District Court’s construction to the extent it would require, based on such steps as 706, 710, and 716, a specific order of the steps of generating the “p” and “d” values. The claims only require the control component to control the power supply to cause oscillation at a specified frequency and amplitude, but do not require the frequency value to be generated before the amplitude value, or vice versa.” slip op. at 17
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“The record, including testimony by Dr. Hannaford (Ex. 1003; Ex. 1049), supports Petitioner’s rationale, and shows that one of ordinary skill would have been motivated to combine Gregorio, Ramsay, and Wakuda in the manner proposed. Patent Owner does not address Petitioner’s showing for combining these references with any particularity. See generally PO Resp. We discuss below Patent Owner’s argument that Petitioner’s showing as to limitation 2.f based on the combination of Gregorio and Ramsay is conclusory.” slip op. at 34
Patent outcomesUS 8,860,337 unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 8,860,337 - PTAB · Oct 6, 2025 · IPR2025-00611 · APJ Christopher L Ogden · IPR · Institution
The Board instituted IPR of claims 1–10, 12, 13, 19, and 20 on all petition grounds after finding a reasonable likelihood that claim 1 was obvious over Douglas and Mark.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“A claim is unpatentable under § 103 “if the differences between the claimed invention and the prior art are such that the claimed invention as a whole would have been obvious before the effective filing date of the claimed invention to a person having ordinary skill in the art to which the claimed invention pertains.” 35 U.S.C. § 103; see KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 406 (2007). When a ground in a petition is based on a combination of references, we consider “whether there was an apparent reason to combine the known elements in the fashion claimed by the patent at issue.” KSR, 550 U.S. at 418 (citing In re Kahn, 441 F.3d 977, 988 (Fed. Cir. 2006)).” slip op. at 8
- Skill levelSkill level petitioner adoptedDecided for petitioner
“The parties agree that experience could substitute for a degree, and vice versa. Pet. 3 (citing Ex. 1003 ¶¶ 19–21); Prelim. Resp. 9. The parties’ proposed levels of ordinary skill are substantially similar. Although we discern no difference in the outcome of this decision from choosing one over the other, we adopt Petitioner’s proposal for this decision. Only Petitioner’s proposed level is supported by testimonial evidence on the preliminary record, and it appears to be consistent with the problems addressed in the ’774 patent. See Ex. 1001, 1:16–52. Therefore, we adopt Petitioner’s proposal for this decision.” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“CLAIM CONSTRUCTION B. In an IPR, we construe a patent claim “using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. 282(b).” 37 C.F.R. § 42.100(b). This generally includes “construing the claim in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” Id. The ordinary and customary meaning of a claim term “is its meaning to the ordinary artisan after reading the entire patent,” and “as of the effective filing date of the patent application.” Phillips, 415 F.3d at 1313, 1321. Neither Petitioner nor Patent Owner argues that we need to construe any claim terms explicitly. See Pet. 2–3; Prelim. Resp. 9. However, the parties’ positions depend on interpreting the claim language in a particular way, and we discuss the relevant claim language below in the context of the parties’ arguments regarding the prior art. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“At this stage, we find Petitioner’s arguments persuasive and disagree with Patent Owner. Patent Owner appears to equate a “fabrication profile” with a toolpath description, but nothing in the plain language of claim 1 supports that narrow interpretation. The ’774 patent describes a “fabrication profile” broadly and states that the profile can simply “include the dictionary [of configuration information],” or be “used to determine which machineready representation is available or suitable for a target printer.” Ex. 1001, 23:49–52. The preliminary evidence suggests that Douglas’s “operational parameters” would count as a “fabrication profile” because it is “the basis for generation of a machine-ready representation of the three-dimensional model that is executable on the target printer.” Id. at 23:37–39; see infra Section III.C.8. We also disagree that Petitioner’s argument is impermissible hindsight, because it is based on the disclosures in Douglas and Mark, and Petitioner has articulated a sufficiently persuasive reason to combine those references without referring to the ’774 patent itself. See In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971) (an obvious rationale is not improper hindsight if it “takes into account only knowledge which was within the level of ordinary skill at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure”). Finally, Petitioner appears to rely on Mark for providing a particular example of a fabrication profile, not to replace Douglas’s overall system in which the 3D printer can receive “operational parameters” rather than just G-code. See Pet. 8–10, 17–23; see also Ex. 1005 ¶ 41 (the print queue, which stores tool instructions, may be maintained locally on printers 204 or on print servers 208); see In re Mouttet, 686 F.3d 1322, 1332 (Fed. Cir. 2012) (“[A] determination of obviousness based on teachings from multiple references does not require an actual, physical substitution of elements.” (citing In re Etter, 756 F.2d 852, 859 (Fed. Cir. 1985) (en banc))).” slip op. at 19
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,886,774
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.