- Shenzhen Tuozhu Technology Co., Ltd. v. Stratasys, Inc.All claims unpatentablePTAB · Sep 28, 2026 · IPR2025-00611 · APJ Christopher L Ogden · IPR · Final written decision
Claims 1–10, 12, 13, 19, and 20 are unpatentable under § 103 over the stated Douglas–Mark and Hamilton-based grounds.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“The parties agree that experience could substitute for a degree, and vice versa. Pet. 3; PO Resp. 10. The parties’ proposed levels of ordinary skill are substantially similar. For this decision, as in the Institution Decision, we adopt Petitioner’s proposed level, which is supported by credible testimonial evidence and is consistent with the problems addressed in the ’774 patent. See Ex. 1001, 1:16–52. Our decision would be the same, however, if we were to adopt Patent Owner’s proposal.” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Other
“Neither Petitioner nor Patent Owner argues that we need to construe any claim terms explicitly. See Pet. 2–3; PO Resp. 10. However, the parties contest two material claim-construction issues which we address below. To the extent that the parties’ positions depend on interpreting other claim language in a particular way, we discuss the relevant claim language below in the context of the parties’ arguments regarding the prior art.” slip op. at 8
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“We disagree with Patent Owner that a person of ordinary skill in the art would have understood that limitation 1.2 must be performed before limitations 1.3 or 1.4. See Ex. 1001, 35:21–24. See Interactive Gift Exp., Inc. v. Compuserve Inc., 256 F.3d 1323, 1342 (Fed. Cir. 2001) (“Unless the steps of a method actually recite an order, the steps are not ordinarily construed to require one.” (citing Loral Fairchild Corp. v. Sony Corp., 181 F.3d 1313, 1322 (Fed. Cir. 1999)). The evidence suggests that a “target printer” is any printer that is ultimately selected for fabricating the object, and such a printer could send its configuration information either before or after that determination is made in limitation 1.2. This interpretation does not render the word “target” meaningless. At some point, a printer must be determined to be the target printer, which is the one intended to ultimately fabricate the three-dimensional object. But the target printer still exists, and is capable of being queried, before that determination is made. We find the examples in the ’774 patent pertinent to this question. The ’774 patent states that “the target printer may include more than one printer.” Ex. 1001, 18:66–67. In discussing the step of “query target printer for properties 306” (Fig. 3A), the ’774 patent states that “[i]n one aspect, numerous queries are sent to numerous printers, e.g., for use in selecting one or more of the printers as the target printer.” Id. at 19:8–10. Alternatively, “the query is sent to a printer that is not necessarily the target printer as described herein, e.g., when the query or information received from a response to the query is used for the selection of the target printer.” Id. at 19:11–14. Importantly, the second embodiment states that the queried printer “is not necessarily the target printer,” suggesting that the queried printer could be the target printer even before it is determined to be such. Id. at 19:11–12 (emphasis added). Based on the evidence of record, a person of ordinary skill in the art would have understood that the “target printer” can be determined after the query recited in limitation 1.3 or the reception of configuration information recited in limitation 1.4. Thus, the evidence does not impose an ordering between limitations 1.2 and 1.3 or between limitations 1.2 and 1.4. The evidence also does not support Patent Owner’s argument that the two reverse-order examples in the ’774 patent are unclaimed embodiments.” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightMotivation foundDecided for petitioner
“We disagree that Petitioner’s arguments are based on impermissible hindsight, because they are based on the disclosures in Douglas and Mark, and Petitioner has articulated a persuasive reason to combine those references without referring to the ’774 patent itself, as we discuss below. See In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971) (an obvious rationale is not improper hindsight if it “takes into account only knowledge which was within the level of ordinary skill at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure”).” slip op. at 29
Patent outcomesUS 11,886,774 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,886,774 - Valve Corporation v. Immersion CorporationAll claims unpatentablePTAB · Mar 23, 2026 · IPR2024-00582 · APJ Christopher L Ogden · IPR · Final written decision
Claims 1–6, 14–16, and 19 are unpatentable based on anticipation by or obviousness over Pratt, and obviousness over Pratt–Ku, Ku, or Ku–Jiang.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“The parties agree that formal education could substitute for practical experience, and vice versa. Pet. 6, PO Resp. 18. The parties’ proposed levels of ordinary skill appear to be substantially similar, supported by testimonial evidence, and consistent with the asserted prior art and the types of problems and solutions identified in the ’738 patent. See, e.g., Ex. 1001, 1:6–61. Although we discern no difference in the outcome of this decision from choosing one over the other, we adopt Petitioner’s proposed level of skill for this decision. The outcome of our decision would be the same under Patent Owner’s proposal.” slip op. at 7
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“We find insufficient support in the specification or prosecution history to narrow the term “haptic effect” to only one that has not been modified or combined with another haptic effect. The ’738 patent still refers to combined or modified haptic effects as a “haptic effect.” Ex. 1001, 11:35–38 (“a haptic effect may further be modified or combined with another haptic effect” and “the haptic effect can include one or more haptic effects”). We also find no support for importing into the construction of “haptic effect” the ’738 patent’s example in which a haptic effect can be “based on the proximity signal and the touch sensor signal.” That is already an explicit claim limitation. Id. at 14:19–20 (“generate a haptic output signal based at least in part on the first [proximity] and second [touch] sensor signals”). Including that limitation as part of the construction of “haptic effect” would render the limitation superfluous. See Apple, Inc. v. Ameranth, Inc., 842 F.3d 1229, 1237 (Fed. Cir. 2016) (“The Board was correct to not include in its construction of ‘menu’ features of menus that are expressly recited in the claims . . . . Construing a claim term to include features of that term already recited in the claims would make those expressly recited features redundant.”). We also disagree with Patent Owner that the ’738 patent’s references to haptic effects modified or combined with other haptic effects are unclaimed embodiments. The ’738 patent discloses that a proximity-based haptic effect may be combined with a touch-based haptic effect, such as when “a particular haptic effect associated with a particular control on a user interface element [is] further . . . modified or combined with another haptic effect based on the proximity sensor signal,” or when “the haptic effect [to be output by the processor] . . . include[s] a haptic effect meant to confirm ‘pushing’ on a virtual button.” Ex. 1001, 11:32–40. These examples are consistent with the claim language and we find no credible evidence in the record that these embodiments are intended to be excluded from the claimed invention. Thus, we agree with Petitioner that it would be incorrect to construe the term “haptic effect” to include the extraneous limitations Patent Owner proposes. We also agree with Petitioner that a person of ordinary skill in the art reading the ’738 patent disclosure would have understood that a combined or modified haptic effect is still a haptic effect.” slip op. at 11
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“To show anticipation under § 102, a petitioner must locate every element in a claim, arranged as recited in the claim, in a single prior art reference. See Net MoneyIN, Inc. v. VeriSign, Inc., 545 F.3d 1359, 1369 (Fed. Cir. 2008). The limitations may be present in the reference “either explicitly or inherently.” In re Schreiber, 128 F.3d 1473, 1477 (Fed. Cir. 1997). In making this determination, we consider the reference “together with the knowledge of one of ordinary skill in the pertinent art.” In re Paulsen, 30 F.3d 1475, 1480 (Fed. Cir. 1994) (citing In re Samour, 571 F.2d 559, 562 (CCPA 1978)).” slip op. at 13
- Obviousness (§103) › Motivation to combine / reasonable expectation of successUnpatentableMotivation foundUnpatentable
“We find Petitioner’s arguments persuasive and disagree with Patent Owner’s arguments to the contrary. Ku discloses summing two overlapping vibration signals, one “based at least in part on” data from a proximity sensor and another “based at least in part on” data from a touch sensor. Ex. 1008, Fig. 12 (items 705, 710, and 715). The summed signal 715 is the basis for generating what the user would perceive as a single haptic effect. See Ex. 1004 ¶ 210–212. This meets limitation 1F. We agree with Petitioner’s argument as to why there would have been a motivation to modify Pratt to include Ku’s teachings. Petitioner’s argument is not merely that Pratt was ready for improvement; Petitioner persuasively argues that a person of ordinary skill in the art would have had reason to add Ku’s method for confirming that the user has touched the intended icon to Pratt’s system. Both Pratt and Ku already disclose using both proximity and touch data in generating a haptic effect, and based on the evidence of record, we are of the view that combining the two teachings would not have been uniquely challenging or otherwise beyond the level of ordinary skill in the art. See Leapfrog Enters., Inc. v. Fisher-Price, Inc., 485 F.3d 1157, 1162 (Fed. Cir. 2007) (“Leapfrog presents no evidence that the inclusion of a reader in [electronic children's toys] was uniquely challenging or difficult to one of ordinary skill in the art.” (citing KSR, 550 U.S. at 419–420))” slip op. at 32
Patent outcomesUS 11,175,738 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,175,738 - Aptiv Services US, LLC v. Microchip Technology, Inc.All claims unpatentablePTAB · Mar 20, 2026 · IPR2024-00646 · APJ Christopher L Ogden · IPR · Final written decision
Claims 1–18 are unpatentable under § 103 over Al-Shyoukh, Ivanov, and Stanescu; the Board did not reach the alternative ground.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner’s proposal is most like Petitioner’s alternative proposal which would include a bachelor’s degree and two years of experience. However, Patent Owner does not provide a specific number of years of industry experience and Patent Owner would include mixed-signal IC design as an alternative to analog circuit design. We consider analog circuit design to be most pertinent to the problems and solution discussed in the ’074 patent. See Ex. 1001, 1:15–2:44. In addition, we find credible Petitioner’s argument that an ordinarily skilled artisan with a bachelor’s degree would have had two years of experience, whereas Patent Owner’s proposal does not provide a specific number of years. Thus, we determine that a person of ordinary skill in the art would have had a bachelor’s degree and two years of experience in analog circuit design. Nevertheless, the outcome of our decision would be the same under either of the party’s proposals.” slip op. at 8
- Prior constructionPrior construction adoptedDecided for petitioner
“Because neither party has argued that the district-court constructions should be modified or elaborated for this proceeding, and the constructions appear reasonable, we adopt these constructions for this decision. We also take judicial notice of the district court’s Memorandum supporting the claim construction order. Ex. 3001.9” slip op. at 10
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“We agree with Petitioner that “gm boosting” is the only gm enhancement referred to in the ’074 patent, that the ’074 patent uses the terms “gm enhanced” and “gm-boost” synonymously, and that Patent Owner has failed to point to any credible intrinsic evidence of this alleged distinction. Although, “[i]n the absence of any evidence to the contrary, we must presume that the use of . . . different terms in the claims connotes different meanings, CAE Screenplates Inc. v. Heinrich Fiedler GmbH, 224 F.3d 1308, 1317 (Fed. Cir. 2000), in this case there is evidence to the contrary. In particular, the ’074 patent never refers to “gm enhancement” as a function separate from “gm boosting.” Indeed, the transistors (368, 370, and 382) that Patent Owner identifies as performing the function of “gm enhancement” are disclosed as part of a “gm-boost stage.” Ex. 1001, 5:8–24. Patent Owner’s alleged separation of Figure 3B into distinct “gm boosting” and “gm enhancement” is not consistent with the intrinsic evidence and is based on the conclusory testimony of Dr. Taylor. Thus, based on the evidence of record, we disagree with Patent Owner’s proposed construction distinguishing the terms “gm enhanced” and “gm-boost” in claim 1. Rather, we find persuasive Petitioner’s argument that a person of ordinary skill in the art would have regarded these terms to be synonymous. We need not otherwise construe these two terms to resolve the contested issues in this proceeding. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner
“We find Petitioner’s argument persuasive that a person of ordinary skill in the art would have had reason to follow Ivanov’s teachings to include an enable/disable function in Al-Shyoukh’s biasing circuit to limit that circuit’s standby current for reasons of power-efficiency. Pet. 25–26; Ex. 1002 ¶¶ 67–68. The evidence of record also suggests that an enable/disable function was well known in the art and that it would have been within the level of ordinary skill in the art to add such a function to a biasing circuit, taking into consideration any known tradeoffs. Pet. Reply 17–18; Ex. 1002 ¶¶ 60, 67–68; PO Resp. 13–14 (acknowledging that “any [person of ordinary skill in the art” would attest[ that] engineering is full of tradeoffs” and listing some of the known tradeoffs that “a [person of ordinary skill in the art] would need to consider”). We also disagree with Patent Owner’s argument that Al-Shyoukh, Rincon-Mora, or other references teach away from adding an enable/disable function to Al-Shyoukh. Patent Owner has not pointed to anything in the prior art that criticizes, discredits, or otherwise discourages investigation into the claimed invention. Meiresonne v. Google, Inc., 849 F.3d at 1382.” slip op. at 34
Patent outcomesUS 9,471,074 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,471,074 - Caption Health, Inc v. University Of British ColumbiaInstitution deniedPTAB · Dec 19, 2025 · IPR2025-01066 · APJ Mary C Hoffman · IPR · Institution
Institution was denied because Petitioner did not show a reasonable likelihood that any challenged claim was unpatentable, including failure to show the claimed image-receiving quality-assessment neural network.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). Under 35 U.S.C. § 314(a), an inter partes review may not be instituted “unless . . . the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Based on the current record and for the reasons explained below, Petitioner has not demonstrated a reasonable likelihood of prevailing with respect to at least one of the challenged claims of the ’591 patent. Thus, we do not institute this inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Because Petitioner’s formulation is supported by declaratory testimony and appears consistent with the level of skill reflected in the asserted prior art and the ’591 patent, and because Patent Owner does not provide any supporting evidence, we adopt Petitioner’s formulation of the level of ordinary skill in the art. See Ex. 1002 ¶¶ 31–33. Our decision would be the same regardless of the differences between Petitioner’s and Patent Owner’s formulations.” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“The parties do not propose any express claim construction. Pet. 11– 12; Prelim Resp. 17. We also determine that no express claim construction is necessary for our Decision, apart from that discussed in our below analysis. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (holding that only terms in controversy must be construed “and only to the extent necessary to resolve the controversy”) (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 11
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundReasonable expectation not foundNot shown unpatentable
“Petitioner also fails to provide sufficient rationale and a reasonable expectation of success in combining Krishnan and Lee to arrive at a quality assessment neural network configured to receive an image. See Pet. 34–37. For example, the Petition lacks an explanation of why a POSITA would have been motivated to modify Krishnan’s quality assessment neural network to be configured to receive an image, instead of extracted features, in view of Lee’s image-receiving category classifying neural network. Id. Without such further explanation, Petitioner’s challenge falls short. Petitioner’s argument that neural networks for image quality assessment were “well-known” is not persuasive—it does not address the particular scope of limitation 1i, which also requires that the neural network is configured to receive images. Pet. 35 (citing Ex. 1002 ¶¶ 47–51, 118; Exs. 1017, 1023, 1024, 1026). Petitioner’s argument that combining Krishnan and Lee “would merely amount to applying known work from the field . . . to yield predictable results” is not persuasive because the Petition ties this reasoning to modifying Krishnan with Lee’s view-category-specific assessment parameters, not modifying Krishnan’s quality assessment neural network to receive images instead of extracted features. Id. at 37 (citing Ex. 1002 ¶ 126). Lastly, we note Petitioner’s expert’s discussion regarding neural networks for image quality assessments. Ex. 1002 ¶¶ 43–53 (citing Exs. 1010, 1015, 1016, 1017, 1018, 1023, 1024, 1026). However, the Petition does not explain how this evidence demonstrates that the proposed combination teaches or suggests a quality assessment neural network configured to receive images, or that such would have been obvious in the context of the claimed invention. See Pet. 32–37.” slip op. at 19
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,129,591 - Nokia Of America Corporation / AT&T Services, Inc. v. Iarnach Technologies LimitedSome claims unpatentablePTAB · Dec 10, 2025 · IPR2024-00899 · APJ Christopher L Ogden · IPR · Final written decision
Claims 1–3, 5, 10, 11, and 14 are unpatentable as obvious; claims 4, 12, 13, and 15 were not shown unpatentable under the asserted § 103 grounds.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“(citing Ex. 1003 ¶ 22). Patent Owner does not contest this proposed level of ordinary skill. PO Resp. 5. Also, neither party argues that the precise level of ordinary skill would be dispositive in this proceeding. We adopt Petitioner’s proposed level of ordinary skill because it is undisputed, supported by testimonial evidence, and consistent with the asserted prior art and the types of problems and solutions in the ’892 patent. See, e.g., Ex. 1001, 1:19–2:8.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for petitioner
“We agree with Petitioner. The evidence of record, including the ’892 patent and its prosecution history,9 indicates that the ordinary and customary meaning of “transitioning . . . from . . . to” encompasses both direct and indirect transitions. Looking first to the claim language itself, the word “directly” appears in claims 1, 6, and 10, but not claim 14, presumptively suggesting that claim 14 was intended to more broadly capture systems with either direct or indirect transitions. See CAE Screenplates Inc. v. Heinrich Fiedler GmbH, 224 F.3d 1308, 1317 (Fed. Cir. 2000) (“In the absence of any evidence to the contrary, we must presume that the use of . . . different terms in the claims connotes different meanings.”). Holding otherwise would fail to give any effect to the word “direct” as it appears in claims 1, 6, and 10. See Stumbo v. Eastman Outdoors, Inc., 508 F.3d 1358, 1362 (Fed. Cir. 2007) (denouncing claim constructions methodologies that render phrases in claims superfluous).” slip op. at 12
- Expert testimonyPetitioner expert creditedOther
“predictable and well-motivated variation of G.987.3, at the time of the claimed invention, to include a direct transition between the ONU’s two low-power states. See KSR v. Teleflex, 550 U.S. at 417 (“When a work is available in one field of endeavor, design incentives and other market forces can prompt variations of it, . . . . If a person of ordinary skill can implement a predictable variation, § 103 likely bars its patentability.”). We credit Dr. Sergienko’s testimony that a person of ordinary skill in the art would have been motivated to reduce power consumption and would have looked to ways of modifying G.987.3 to further that design goal. See Ex. 1003 ¶ 70; see also Ex. 1007, 97 (“For a variety of reasons, it is desirable to reduce the power consumed by an ONU as much as possible . . . .”). We also credit Dr. Sergienko’s testimony that there were only a small number of ways to modify the state transitions in G.987.3’s ONU, and that it would have been obvious to consider those possibilities. Ex. 1003 ¶ 70. Patent Owner does not contest this. Dr. Litvin concedes, for Patent Owner, that “there is no conceivable way the [ITU] did not consider the proposed transition” between the ONU’s two low-power states when drafting G.987.3, although he contends the standards body prohibited such direct transitions as “a conscious and reasoned design choice.” Ex. 2007 ¶ 108; see also id. ¶ 109 (opining that there were only four possible choices for transitions in the ONU, and the ITU “undoubtedly considered all of them, including the direct transition from . . . Listen and . . . Asleep”); PO Resp 24 (conceding that “G.987 explicitly considered the very direct transitions that Petitioner say would be used”). We also find persuasive Petitioner’s additional or alternative argument that Röger would have motivated modifying G.987.3 by allowing the ONU, while in sleep mode, to periodically turn on its receiver and check for messages from the OLT, which would have been direct transitions between “first” and “second” states as recited in claim 1. Pet. 20–22 & n.4; Ex. 1003 ¶¶ 82–84. The evidence suggests that modifying G.987 as Petitioner proposes would have been within the abilities of a person of the ordinary skill in the art at the time of the claimed invention—either to add a direct transition between Listen and Asleep states or to allow the ONU, while in its sleep (both transmitter and receiver off) mode, to periodically turn on its receiver temporarily to listen for polling messages from the OLT, as Röger teaches. Pet. 11–12, 14–15, 19; Ex. 1003 ¶¶ 70, 74. We also agree with Petitioner that there would have been motivation” slip op. at 26
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“We find persuasive Petitioner’s arguments that it would have been a predictable and well-motivated variation of G.987.3, at the time of the claimed invention, to include a direct transition between the ONU’s two low-power states. See KSR v. Teleflex, 550 U.S. at 417 (“When a work is available in one field of endeavor, design incentives and other market forces can prompt variations of it, . . . . If a person of ordinary skill can implement a predictable variation, § 103 likely bars its patentability.”). We credit Dr. Sergienko’s testimony that a person of ordinary skill in the art would have been motivated to reduce power consumption and would have looked to ways of modifying G.987.3 to further that design goal. See Ex. 1003 ¶ 70; see also Ex. 1007, 97 (“For a variety of reasons, it is desirable to reduce the power consumed by an ONU as much as possible . . . .”). We also credit Dr. Sergienko’s testimony that there were only a small number of ways to modify the state transitions in G.987.3’s ONU, and that it would have been obvious to consider those possibilities. Ex. 1003 ¶ 70. Patent Owner does not contest this. Dr. Litvin concedes, for Patent Owner, that “there is no conceivable way the [ITU] did not consider the proposed transition” between the ONU’s two low-power states when drafting G.987.3, although he contends the standards body prohibited such direct transitions as “a conscious and reasoned design choice.” Ex. 2007 ¶ 108; see also id. ¶ 109 (opining that there were only four possible choices for transitions in the ONU, and the ITU “undoubtedly considered all of them, including the direct transition from . . . Listen and . . . Asleep”); PO Resp 24 (conceding that “G.987 explicitly considered the very direct transitions that Petitioner say would be used”). We also find persuasive Petitioner’s additional or alternative argument that Röger would have motivated modifying G.987.3 by allowing the ONU, while in sleep mode, to periodically turn on its receiver and check for messages from the OLT, which would have been direct transitions between “first” and “second” states as recited in claim 1. Pet. 20–22 & n.4; Ex. 1003 ¶¶ 82–84. The evidence suggests that modifying G.987 as Petitioner proposes would have been within the abilities of a person of the ordinary skill in the art at the time of the claimed invention—either to add a direct transition between Listen and Asleep states or to allow the ONU, while in its sleep (both transmitter and receiver off) mode, to periodically turn on its receiver temporarily to listen for polling messages from the OLT, as Röger teaches. Pet. 11–12, 14–15, 19; Ex. 1003 ¶¶ 70, 74.” slip op. at 26
Patent outcomesUS 9,806,892 mixedClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,806,892 - PTAB · Dec 9, 2025 · IPR2025-00756 · APJ Thu A Dang · IPR · Institution
The Board instituted IPR on claims 1, 2, 5–8, 11, and 12 on three §103 grounds, finding a reasonable likelihood of unpatentability over the asserted combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“III. CONCLUSION Because we determine that Petitioner has demonstrated a reasonable likelihood that it would prevail in showing at least one of the challenged claims is unpatentable, we institute inter partes review as to all challenged claims and grounds presented in the Petition. At this stage of the proceeding, we have not made a final determination as to the patentability of any of these challenged claims. ORDER For the reasons given, it is ORDERED that pursuant to 35 U.S.C. § 314, an inter partes review is instituted as to claims 1, 2, 5–8, 11, and 12 of the ’803 patent to determine whether: 1) claims 1, 5–7, 11, and 12 are unpatentable under 35 U.S.C. § 103 as obvious over TS 36.300, TS 36.321, and TS 36.331; 2) claims 1, 2, 5–8, 11, and 12 are unpatentable under 35 U.S.C. § 103 as obvious over Ericsson and TS 25.331; and 3) claims 5, 6, 11, and 12 are unpatentable under 35 U.S.C. § 103 as obvious over Ericsson, TS 25.331, and Sebire; and” slip op. at 27
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“ordinary meaning, “primary” and “non-primary” cells are all cells that the WTRU is connected to (PO Resp. 16), the plain language in claim 1, and similarly in claim 7, does not require a “primary” node or “non-primary” cell to have a connection to the WTRU. See Ex. 1001, 10:38−56; 11:11–26. We find unavailing Patent Owner’s contention that the claims require that the WTRU “be connected to more than one cell,” wherein cells that are “associated with a wireless network node,” but are not connected to the WTRU “at the same time” cannot be “primary” or “non-primary” cells. PO Resp. 16. In the ’803 patent, nothing in the Specification clearly limits “primary” and “non-primary” cells as Patent Owner proposes. Prelim. Resp. 16. Patent Owner points to the Specification of the ’803 patent to show that, for softer handover, the WTRU is connected “with more than one cell [] which are controlled by the same Node-B,” and “[o]ne of the[se] cells 808 may be designated as a primary cell 808a, while other cells are designated as a non-primary cells 808b.” Id. (alterations in original) (citing Ex. 1001, 8:44–46, 9:4–6, Figs. 8A–B). However, this portion of the Specification (describing a softer handover embodiment in which a cell “may be designated” as a primary while other as non-primary) does not provide a clear definition to warrant interpreting the “primary” and “non-primary” cells as requiring “connection” to the WTRU “at the same time.” Id. That is, nothing in the Specification clearly precludes “primary” and “non-primary” cells from being “source” and “target” cell, as Patent Owner contends. PO Resp. 16. and the Specification, we determine that the terms “primary” and “non-primary” recited in claims 1 and 7 are not limited to cells connected to a WRTU at the same time. We determine no further explicit construction of this term is necessary to resolve the controversy. See Vivid Techs., 200 F.3d at 803.” slip op. at 8
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“f) Motivation to combine Ericsson and TS 25.331 Petitioner contends that a “POSITA would have been motivated to combine Ericsson and TS 25.331 because they are directed to similar technologies and a skilled artisan would have understood the benefits of combining these two references,” and “would have understood that there was a high likelihood of success in making the combination.” Pet. 34 (citing Ex. 1003 ¶¶ 156–157). In particular, the references “are both reasonably pertinent to the problem faced by the inventor, namely protocols for handover in a telecommunications system.” Id. (citing Ex. 1003 ¶ 158). According to Petitioner, the combination “involves the predictable use of interchangeable prior art elements according to their established functions” more than routine engineering.” Id. at 37 (citing Ex. 1003 ¶ 174). At this stage of the proceeding, Patent Owner does not present arguments in the Preliminary Response addressing the specific merits of Petitioner’s contentions with respect to the motivation to combine Ericsson and TS 25.331. See generally Prelim. Resp. 15–18. We find availing Petitioner’s contention that Ericsson and TS25.331 are “directed to similar technologies,” and that a “skilled artisan would have understood the benefits of combining these two references.” Pet. 34. On this preliminary record, we are persuaded that Petitioner has made a sufficient showing that a POSITA would have had a reason to combine the teachings of Ericsson and TS 25.331.” slip op. at 20
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner, relying on the testimony of Dr. Kakaes, contends that a person of ordinary skill in the art (POSITA) “would have had a B.S. in Electrical Engineering or a related field with at least three years of experience designing, developing, and/or testing telecommunication systems,” and “would also have familiarity with the wireless standards and well-known protocols for accessing wireless networks existing at the relevant time,” wherein “[m]ore education may supplement practical experience or vice versa.” Pet. 12–13. At this stage in the proceeding, Patent Owner does not contest Petitioner’s proposal or offer an alternative. On this record, we are persuaded that Petitioner’s proposal is consistent with the technology described in the Specification and the cited prior art. For purposes of this Decision, we adopt Petitioner’s proposed level of skill.” slip op. at 10
Claim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 10,764,803 - PTAB · Nov 6, 2025 · IPR2025-00820 · APJ Neil T Powell · IPR · Institution
The Board instituted IPR on claims 1–11 on all petition grounds, finding a reasonable likelihood that claim 1 would have been obvious over Tadros, Porter, Kalili, and Texin 990R.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). To institute an inter partes review, we must determine that the information presented in the Petition and the Preliminary Response shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that there is a reasonable likelihood that Petitioner will prevail with respect to at least one challenged claim. We institute an inter partes review of claims 1–11 based on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Pet. 17–18 (citing Ex. 1007 ¶¶ 13–15). Patent Owner does not dispute Petitioner’s explanation of the level of skill in the art. See generally Prelim. Resp. At this stage of the proceeding and on the present record, we adopt Petitioner’s uncontested proposed level of ordinary skill in the art, which we find consistent with the level of ordinary skill in the art reflected by the ’090 patent and the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Additionally, only terms that are in controversy need to be construed, and these need be construed only to the extent necessary to resolve the controversy. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Both parties indicate that no claim terms need to be expressly construed. Pet. 29–30; Prelim. Resp. 5. Consistent with that, we determine that we need not construe any claim terms expressly in order to resolve the parties’ dispute regarding whether Petitioner has demonstrated a reasonable likelihood of prevailing.” slip op. at 8
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“Weighing the parties’ arguments and evidence, we find Petitioner’s arguments and evidence sufficient at this stage to demonstrate a reasonable likelihood of prevailing. Pet. 8–17, 30–49. For example, regarding whether of Porter’s disclosure to the problem faced by inventor of the ’090 patent. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 144–164. The ’090 patent illustrates that its inventor faced the problem of selecting desirable materials for an aligner, including selecting a desirable material for an aligner’s hard layer. Ex. 1001, 5:44–59. Petitioner and Dr. Osswald provide significant evidence and reasoning tending to show that Porter’s discussion of Tritan logically would have commended itself to the attention of an inventor facing the problem of selecting an aligner hard layer. Pet. 8 (citing Ex. 1007 ¶¶ 98–108, 125–127, 144–164). For example, Dr. Osswald explains that “because Tritan copolyesters are BPA-free, Rafih specifically discloses Tritan EX401 as an exemplary material” for its oral appliance. Id. ¶ 99 (citing Ex. 1104, 5:4–64, claims 2, 9, 10). In view of this, Dr. Osswald testifies that “Rafih would inform a [person of ordinary skill in the art] that Porter’s guidance regarding replacing polycarbonate with Tritan applies to dental appliances.” Ex. 1007 ¶ 146. At this stage, weighing Petitioner’s evidence against Patent Owner’s contrary attorney argument that Porter focuses on dishware, we determine Petitioner has shown sufficiently that Porter is analogous art. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 144–164; Prelim. Resp. 1, 9–10, 18–21.” slip op. at 11
Claim construction§ 103 obviousnesscites PhillipsPatents in suitUS 11,648,090 - PTAB · Nov 6, 2025 · IPR2025-00821 · APJ Neil T Powell · IPR · Institution
The Board instituted review of claims 1–23, 25, and 26 on all asserted grounds, finding a reasonable likelihood that claim 1 would have been obvious over Tadros, Porter, Kalili, and Texin 990R.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority to determine whether to institute an inter partes review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). To institute an inter partes review, we must determine that the information presented in the Petition and the Preliminary Response shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that there is a reasonable likelihood that Petitioner will prevail with respect to at least one challenged claim. We institute an inter partes review of claims 1–23, 25, and 26 based on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Pet. 17 (citing Ex. 1007 ¶¶ 13–15). Patent Owner does not dispute Petitioner’s explanation of the level of skill in the art. See generally Prelim. Resp. At this stage of the proceeding and on the present record, we adopt Petitioner’s uncontested proposed level of ordinary skill in the art, which we find consistent with the level of ordinary skill in the art reflected by the ’090 patent and the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Additionally, only terms that are in controversy need to be construed, and these need be construed only to the extent necessary to resolve the controversy. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Neither party indicates that we need to construe expressly any claim terms. Pet. 27–28; Prelim. Resp. 5. Consistent with that, we determine that we need not construe any claim terms expressly in order to resolve the parties’ dispute regarding whether Petitioner has demonstrated a reasonable likelihood of prevailing.” slip op. at 8
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“arguments and evidence sufficient at this stage to demonstrate a reasonable likelihood of prevailing. Pet. 8–17, 53–71. For example, regarding whether Porter is analogous art, Petitioner sufficiently shows reasonable pertinence of Porter’s disclosure to the problem faced by inventor of the ’091 patent. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 146–165. The ’091 patent illustrates that its inventor faced the problem of selecting desirable materials for an aligner, including selecting a desirable material for an aligner’s hard layer. Ex. 1001, 5:44–59. Petitioner and Dr. Osswald provide significant evidence and reasoning tending to show that Porter’s discussion of Tritan logically would have commended itself to the attention of an inventor facing the problem of selecting an aligner hard layer. Pet. 8 (citing Ex. 1007 “because Tritan copolyesters are BPA-free, Rafih specifically discloses Tritan EX401 as an exemplary material” for its oral appliance. Id. ¶ 99 (citing Ex. 1104, 5:4–64, claims 2, 9, 10). In view of this, Dr. Osswald testifies that “Rafih would inform a [person of ordinary skill in the art] that Porter’s guidance regarding replacing polycarbonate with Tritan applies to dental appliances.” Ex. 1007 ¶ 147. At this stage, weighing Petitioner’s evidence against Patent Owner’s countervailing attorney argument that Porter focuses on dishware, we determine Petitioner has shown sufficiently that Porter is analogous art. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 146–165; Prelim. Resp. 1–2, 9–10, 34–36.” slip op. at 13
Claim construction§ 103 obviousnesscites PhillipsPatents in suitUS 11,648,091 - PTAB · Nov 6, 2025 · IPR2025-00819 · APJ Kristina M Kalan · IPR · Institution
The Board instituted IPR on all challenged claims based on both obviousness grounds, finding a reasonable likelihood of success on at least one claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“that Petitioner has demonstrated a reasonable likelihood of showing that a person of ordinary skill in the art would have been motivated to combine the teachings of Tadros, Kalili, and Texin 990R to meet the limitations of the claims challenged under this ground.” slip op. at 14
- Skill levelSkill level petitioner adoptedDecided for petitioner
“would have had at least a four-year undergraduate degree in materials science, mechanical engineering, chemical engineering, or a related field and at least two years of experience in the field of polymer science, combined with at least two years of experience in the field of design, manufacture, and processing of thermoformable polymer sheets for use in various applications, such as in orthodontic and dental appliances. Additional education could substitute for professional experience and vice versa. Pet. 18–19 (citing Ex. 1007 ¶¶ 13–15). At this stage, Patent Owner does not dispute Petitioner’s proposal or offer an alternative proposal. See generally Prelim. Resp. Because Petitioner’s proposed level of ordinary skill in the art appears to be consistent with the cited prior art and is undisputed on this record, we adopt it for purposes of this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (indicating that the prior art itself may reflect an appropriate skill level).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Only claim terms in controversy need be construed. Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”). For purposes of this Decision, we determine that no claim term requires express construction.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“that Petitioner has demonstrated a reasonable likelihood of showing that a person of ordinary skill in the art would have been motivated to combine the teachings of Tadros, Kalili, and Texin 990R to meet the limitations of the claims challenged under this ground. We disagree that Petitioner fails to meet its burden as to the motivation to combine arguments. Petitioner persuasively maps the limitations of the challenged claims to portions of the references relied upon. Pet. 28–38 (claim 1), 38–51. Petitioner also, on this record, provides adequate statements of motivation to combine with a reasonable expectation of success. See, e.g., id. at 34–36 (citing Ex. 1007 ¶¶ 31, 39–42, 147–151, 174–176). The Petition’s reliance on supporting testimony and related corroborating evidence to support the combination does not amount to impermissible hindsight, as that testimony takes into account “knowledge which was within the level of ordinary skill in the art at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure.” In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971). Without further clarification or support from Patent Owner, and in the absence of testimony to support the assertion that a POSITA would not have combined the cited references in the manner proposed with a reasonable expectation of success, we are unpersuaded by Patent Owner’s arguments in this regard.” slip op. at 14
Claim construction§ 103 obviousnesscites KSRPatents in suitUS 11,154,384 - PTAB · Nov 6, 2025 · IPR2025-00818 · APJ Kristina M Kalan · IPR · Institution
The Board instituted IPR on all challenged claims 1–22 based on all three asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority under 35 U.S.C. § 314(a), which provides that inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” After considering the briefing and cited evidence of record, we institute inter partes review because we find that Petitioner establishes a reasonable likelihood that it will prevail with respect to at least one of the claims challenged in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“understanding of a person of ordinary skill in the art at the time the invention was made. See Graham, 383 U.S. at 17–18. Petitioner proposes that a person of ordinary skill in the art (sometimes referred to herein as a “POSITA”) would have had at least a four-year undergraduate degree in materials science, mechanical engineering, chemical engineering, or a related field and at least two years of experience in the field of polymer science, combined with at least two years of experience in the field of design, manufacture, and processing of thermoformable polymer sheets for use in various applications, such as in orthodontic and dental appliances. Additional education could substitute for professional experience and vice versa. Pet. 18 (citing Ex. 1007 ¶¶ 13–15). At this stage, Patent Owner does not dispute Petitioner’s proposal or offer an alternative proposal. See generally Prelim. Resp. Because Petitioner’s proposed level of ordinary skill in the art appears to be consistent with the cited prior art and is undisputed on this record, we adopt it for purposes of this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (indicating that the prior art itself may reflect an appropriate skill level).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner argues that no terms require construction, but that “Petitioner applies the prior art consistent with Patent Owner’s assertions in its Infringement Contentions (EX1014, 6-20.).” Pet. 26. Patent Owner does not propose any express claim constructions. Prelim. Resp. 5. Nor does Patent Owner allege that any of Petitioner’s claim interpretations contradict Petitioner’s position in the related district court litigation. Id. Only claim terms in controversy need be construed. Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”). For purposes of this Decision, we determine that no claim term requires express construction.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“that Petitioner has demonstrated a reasonable likelihood of showing that a person of ordinary skill in the art would have been motivated to combine the teachings of Tadros, Kalili, and Texin 990R to meet the limitations of the claims challenged under this ground. We disagree that Petitioner fails to meet its burden as to the motivation to combine arguments. Petitioner persuasively maps the limitations of the challenged claims to portions of the references relied upon. Pet. 27–36 (claim 1), 36–46. Petitioner also, on this record, provides adequate statements of motivation to combine with a reasonable expectation of success. See, e.g., id. at 32–35 (citing Ex. 1007 ¶¶ 31, 39–41, 57–87, 146–150, 171–172). The Petition’s reliance on supporting testimony and related corroborating evidence to support the combination does not amount to impermissible hindsight, as that testimony takes into account “knowledge which was within the level of ordinary skill in the art at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure.” In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971). Without further clarification or support from Patent Owner, and in the absence of testimony to support the assertion that a POSITA would not have combined the cited references in the manner proposed with a reasonable expectation of success, we are unpersuaded by Patent Owner’s arguments in this regard. We also disagree with Patent Owner’s arguments about “adhesive lamination” using “tie layers” at this point in the proceeding. Prelim. Resp. 15–18. On this record, we are persuaded that Petitioner has adequately supported its arguments that one of ordinary skill in the art would have been motivated to use adhesive lamination to achieve the proposed combination. See, e.g., Pet. 33–35; Ex. 1007 ¶¶ 39–42, 120, 45, 51, 116, 120. Petitioner relies on Kalili as disclosing a hard layer suitable for combination with Tadros’s soft layers (Pet. 32), and more particularly, doing so in the context of a laminated multilayer aligner (Reply 4). To create the laminated multilayer aligner proposed, Petitioner’s suggested use of a particular type of well-known lamination, i.e. adhesive lamination, is sufficiently developed and supported in the Petition. Pet. 32–35. Here, Patent Owner recognizes that Kalili teaches lamination, but suggests that it does not specifically teach using adhesive lamination. Prelim. Sur-reply 5. We note, however, that the parties have identified limited types of known lamination for aligners: coextrusion, extrusion lamination, and adhesive lamination. Prelim Sur-reply 4; Pet. 14–15 n.3, 33. In KSR, the Supreme Court explained that when “there is a design need or market pressure to solve a problem and there are a finite number of identified, predictable solutions, a person of ordinary skill has good reason to pursue the known options within his or her technical grasp.” KSR, 550 U.S. at 421. “If this leads to the anticipated success, it is likely the product not of innovation but of ordinary skill and common sense.” Id. Having reviewed Petitioner’s proffered arguments as to Tadros, Kalili, and Texin 990R, including motivation to combine the references asserted in this ground, with a reasonable expectation of success, we are persuaded on this record that Petitioner has met its burden for institution with respect to Ground 1.” slip op. at 14
Claim construction§ 103 obviousnesscites KSRPatents in suitUS 10,973,613
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.