• Shenzhen Tuozhu Technology Co., Ltd. v. Stratasys, Inc.All claims unpatentable
  PTAB · Sep 28, 2026 · IPR2025-00611 · APJ Christopher L Ogden · IPR · Final written decision

  Claims 1–10, 12, 13, 19, and 20 are unpatentable under § 103 over the stated Douglas–Mark and Hamilton-based grounds.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “The parties agree that experience could substitute for a degree, and vice versa. Pet. 3; PO Resp. 10. The parties’ proposed levels of ordinary skill are substantially similar. For this decision, as in the Institution Decision, we adopt Petitioner’s proposed level, which is supported by credible testimonial evidence and is consistent with the problems addressed in the ’774 patent. See Ex. 1001, 1:16–52. Our decision would be the same, however, if we were to adopt Patent Owner’s proposal.” slip op. at 7

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Other

    “Neither Petitioner nor Patent Owner argues that we need to construe any claim terms explicitly. See Pet. 2–3; PO Resp. 10. However, the parties contest two material claim-construction issues which we address below. To the extent that the parties’ positions depend on interpreting other claim language in a particular way, we discuss the relevant claim language below in the context of the parties’ arguments regarding the prior art.” slip op. at 8

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner

    “We disagree with Patent Owner that a person of ordinary skill in the art would have understood that limitation 1.2 must be performed before limitations 1.3 or 1.4. See Ex. 1001, 35:21–24. See Interactive Gift Exp., Inc. v. Compuserve Inc., 256 F.3d 1323, 1342 (Fed. Cir. 2001) (“Unless the steps of a method actually recite an order, the steps are not ordinarily construed to require one.” (citing Loral Fairchild Corp. v. Sony Corp., 181 F.3d 1313, 1322 (Fed. Cir. 1999)). The evidence suggests that a “target printer” is any printer that is ultimately selected for fabricating the object, and such a printer could send its configuration information either before or after that determination is made in limitation 1.2. This interpretation does not render the word “target” meaningless. At some point, a printer must be determined to be the target printer, which is the one intended to ultimately fabricate the three-dimensional object. But the target printer still exists, and is capable of being queried, before that determination is made. We find the examples in the ’774 patent pertinent to this question. The ’774 patent states that “the target printer may include more than one printer.” Ex. 1001, 18:66–67. In discussing the step of “query target printer for properties 306” (Fig. 3A), the ’774 patent states that “[i]n one aspect, numerous queries are sent to numerous printers, e.g., for use in selecting one or more of the printers as the target printer.” Id. at 19:8–10. Alternatively, “the query is sent to a printer that is not necessarily the target printer as described herein, e.g., when the query or information received from a response to the query is used for the selection of the target printer.” Id. at 19:11–14. Importantly, the second embodiment states that the queried printer “is not necessarily the target printer,” suggesting that the queried printer could be the target printer even before it is determined to be such. Id. at 19:11–12 (emphasis added). Based on the evidence of record, a person of ordinary skill in the art would have understood that the “target printer” can be determined after the query recited in limitation 1.3 or the reception of configuration information recited in limitation 1.4. Thus, the evidence does not impose an ordering between limitations 1.2 and 1.3 or between limitations 1.2 and 1.4. The evidence also does not support Patent Owner’s argument that the two reverse-order examples in the ’774 patent are unclaimed embodiments.” slip op. at 10

  • Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightMotivation foundDecided for petitioner

    “We disagree that Petitioner’s arguments are based on impermissible hindsight, because they are based on the disclosures in Douglas and Mark, and Petitioner has articulated a persuasive reason to combine those references without referring to the ’774 patent itself, as we discuss below. See In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971) (an obvious rationale is not improper hindsight if it “takes into account only knowledge which was within the level of ordinary skill at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure”).” slip op. at 29

  Patent outcomesUS 11,886,774 unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,886,774
• Motorola Mobility LLC / Google LLC v. Multifold International Incorporated Pte. Ltd.All claims unpatentable
  PTAB · Apr 28, 2026 · IPR2025-00040 · APJ Brian P Murphy · IPR · Final written decision

  Claims 1–9 are unpatentable: claims 1–4 and 6–9 as anticipated or obvious over the asserted references, and claim 5 as obvious over Yook or Yook in view of Purcell.

  RulingsFinal written decision

  • BurdenDecided for petitioner

    “We disagree with Patent Owner’s argument because the Petition presents argument and evidence that substantively demonstrates, with clarity and particularity, how and why each reference discloses, teaches, suggests, or otherwise renders obvious the displaying element recited in limitation 1[B]. We agree with Petitioner that “Patent Owner neglects to address the actual substance of the Petition, which clearly addresses this limitation with respect to each reference.” Reply 1–2. The Petition addresses in detail how each asserted reference discloses displaying two applications on two separate displays in accordance with the displaying element, by presenting multiple annotated figures from Yook, Lee, Aguilar, and Purcell. Pet. 27–30, 47–50, 62–63, 77–78. The Petition also cites and quotes the accompanying descriptions for the annotated figures from each prior art reference as well as explanatory expert opinion testimony from Dr. Rodriguez. Id. (citing Rodriguez Decl. Ex. 1003 ¶¶ 70–74, 119–122, 149–150, 182–183; Yook Ex. 1004 ¶¶ 47, 51, 58, 96–101, Figs. 4b, 4d, 5; Lee Ex. 1005 ¶¶ 48–53, Figs. 4, 6, 9, 10; Aguilar Ex. 1006, 7:1–7, Figs. 5–5d; Purcell Ex. 1007 ¶ 16, Fig. 2). We provide detailed examples below of how the Petition maps Yook and Lee onto the displaying element of limitation 1[B] in compliance with the particularity requirement of 35 U.S.C. § 312(a)(3); 37 C.F.R. § 42.104(b)(4). Although we do not provide detailed examples directed to Aguilar and Purcell, we find the Petition maps Aguilar and Purcell onto the displaying element of limitation 1[B] in compliance with the particularity requirement of 35 U.S.C. § 312(a)(3) and 37 C.F.R. § 42.104(b)(4).” slip op. at 14

  • Strike new argumentNew argument disregardedDecided for petitioner

    “Instead, Patent Owner chose to raise an entirely new theory of patentability. Sur-Reply 3–13; Tr. 28:8–20. Patent Owner’s new theory is based on a claim construction that construes claim 1 of the ’756 patent as “recit[ing] a specific order of steps that must be performed in the order written.” Id. at 3–4. “Because of this order, the [displaying element] must occur after both (two) ‘selecting’ steps,” and Patent Owner contends none of the prior art references asserted in the Petition “meets the order required by claim 1.” Id. at 4. We will not consider Patent Owner’s new theory of patentability raised for the first time in its Sur-Reply. See Apple Inc. v. e-Watch, Inc., IPR2015-00412, Paper 50, 44 (PTAB May 6, 2016) (“‘Respond,’ in the context of 37 C.F.R. § 42.23(b), does not mean embark in a new direction with a new approach”); see also Optivus Tech., Inc. v. Ion Beam Appl’ns S.A., 469 F.3d 978, 989 (Fed. Cir. 2006) (argument raised for the first time in the reply brief, which could have been raised in the opening brief, is waived). Patent Owner should have raised its “specific order of steps” argument in the Response. By failing to do so, Patent Owner has waived the argument. Id.” slip op. at 22

  • Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner

    “Third, we are further persuaded by Dr. Surati’s testimony that the wave shape visual indicator depicted in Figures 10A–C of the ’756 patent indicates that a user can do something, but not necessarily what that something is (e.g., minimizing or maximizing). Id. at 17 (citing Ex. 1012, 200:1–6). It is telling that Dr. Surati testified that only through repeated use and exposure would a user recognize a relationship between a wave shape and the functions of maximizing or minimizing an application. Id. (citing Ex. 1012, 197:13–199:22). We are also persuaded by Dr. Rodriguez’s testimony regarding the teachings of Yook: Yook therefore teaches giving users the ability to transition a split-screen application back into full screen mode. Further, a POSITA would have understood that this ability would undoubtedly be implemented in the form of a visual indicator, which, from the 2000s to today, is the industry’s universal method of alerting a user to an accessible function. . . . Ex. 1003 ¶ 107 (emphasis added); For claim 5, Yook discloses many different types of “icons” that are used to receive user gesture inputs. See, e.g., Figs. 1, 4e, 5a, 5c, 5d, 6, 7a, 7b, 7c, 8, 9, 10, 11, 12, 13. Examples of these icons are displayed below: Id. ¶ 108; and A POSITA would have understood that Yook’s icons can have a wave shape because the shape taken by a visual indicator, or icon, is merely a matter of common and routine design choice. Indeed, the shape of an icon does not affect its function or how a gesture input is received. Id. ¶ 109 (emphasis added). In short, we are persuaded Petitioner has established by a preponderance of the evidence that a displayed visual indicator that “has a wave shape” is a design choice not affecting the function of the visual indicator, and a visual indicator that “has a wave shape” would have been an obvious design choice to a POSITA in view of Yook.” slip op. at 30

  • Skill levelSkill level board ownDecided for petitioner

    “In determining the level of ordinary skill in the art, various factors may be considered, including the “type of problems encountered in the art; prior art solutions to those problems; rapidity with which innovations are made; sophistication of the technology; and educational level of active workers in the field.” In re GPAC, Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995) (citing Custom Accessories, Inc. v. Jeffrey-Allan Indus., Inc., 807 F.2d 955, 962 (Fed. Cir. 1986)). “These factors are not exhaustive but are merely a guide to determining the level of ordinary skill in the art.” Daiichi Sankyo Co. v. Apotex, Inc., 501 F.3d 1254, 1256 (Fed. Cir. 2007). There is uncontested evidence in the record before us that reflects the knowledge and experience of a POSITA. We adopt the parties’ agreed level of ordinary skill in the art, which is consistent with the description in the ’756 patent and the prior art of record.” slip op. at 9

  Patent outcomesUS 9,134,756 unpatentable
  Claim construction§ 103 obviousnesscites Phillips
  Patents in suitUS 9,134,756
• Samsung Electronics Co., Ltd. / Samsung Electronics America, Inc. v. Harbor Island Dynamic, LLCAll claims unpatentable
  PTAB · Mar 11, 2026 · IPR2024-01404 · APJ Hyun J Jung · IPR · Final written decision

  Claims 1–18 are unpatentable: claims 1–6, 9–14, 17, and 18 as anticipated by Cooney and obvious over Cooney; claims 7 and 15 over Cooney and Dean; claims 8 and 16 over Cooney and Farooq or …

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Based on the full record, we maintain and affirm that a person of ordinary skill in the art “would have had at least a master’s degree in electrical engineering or a similar field and at least two years of experience working with semiconductor systems” and that “[a]dditional relevant work experience can compensate for less education, and vice versa.” Pet. 9–10 (citing Ex. 1002 ¶¶ 72–74). We agree with the parties that any differences in the parties’ proposed level of ordinary skill would not affect our analysis. Pet. Reply 1; Tr. 25:4–9 (Patent Owner’s counsel agreeing that any differences in the parties’ proposed level of ordinary skill in the art are immaterial). We also find that Petitioner’s proposed level of ordinary skill in the art is consistent with the ’609 patent and the asserted prior art.” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “Based on the full record and because Petitioner’s anticipation challenge is based on giving these recitations no patentable weight and Petitioner’s obviousness challenge is based on the same recitations having patentable weight, we determine that resolving whether to give patentable weight to the recitations “to reduce thermal stress in said semiconductor substrate,” “to provide space for said conductive filler to expand inward,” and “to prevent contamination during processing of said semiconductor substrate” is not necessary to resolve the parties’ dispute. Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms that . . . are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. full record, we also determine that express claim interpretation of any other claim term is not necessary. Id.” slip op. at 10

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable

    “the claim, must be found in a single prior art reference. Net MoneyIN, Inc. v. VeriSign, Inc., 545 F.3d 1359, 1369 (Fed. Cir. 2008); Karsten Mfg. Corp. v. Cleveland Golf Co., 242 F.3d 1376, 1383 (Fed. Cir. 2001). Each element of the challenged claim must be found, either expressly or inherently, in the single prior art reference. Verdegaal Bros., Inc. v. Union Oil Co. of Cal., 814 F.2d 628, 631 (Fed. Cir. 1987). When evaluating a prior art reference in the context of anticipation, the reference must be “considered together with the knowledge of one of ordinary skill in the pertinent art.” In re Paulsen, 30 F.3d 1475, 1480 (Fed. Cir. 1994) (citing In re Samour, 571 F.2d 559, 562 (CCPA 1978)). “[A] reference can anticipate a claim even if it ‘d[oes] not expressly spell out’ all the limitations arranged or combined as in the claim, if a person of skill in the art, reading the reference, would ‘at once envisage’ the claimed arrangement or combination.” Kennametal, Inc. v. Ingersoll Cutting Tool Co., 780 F.3d 1376, 1381 (Fed. Cir. 2015) (quoting In re Petering, 301 F.2d 676, 681 (CCPA 1962)).” slip op. at 7

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner

    “find that Cooney discloses “silicon vias having a hollow center.” Ex. 1002 ¶¶ 120–123; Ex. 1004 ¶¶ 55, 60, Fig. 6. We also find that the portions of Pogge cited by Petitioner show that its “void 25 has an important function in relieving stresses caused by differences in the thermal coefficient of expansion (TCE) of the various materials in and around the feature” (Ex. 1005 ¶ 27) and that the portions of Edelstein cited by Petitioner show that, “[a]lthough it does not change the thermal expansion coefficient, the introduction of a void or voids reduces the effective modulus and Poisson ratio of the through-via, resulting in a compliant through-via that exerts much less stress and force on the surrounding structures” (Ex. 1006 ¶ 47). As discussed above, we find that Cooney’s void 25 is “entirely surrounded by” its conductive filler 24 that, in turn, is surrounded by liner 22 and substrate 10’. Ex. 1004, Fig. 6. We credit Petitioner’s relied-upon testimonial evidence that the presence of a void was known to reduce thermal stress in the surrounding substrate, because the citations to the record support it. Ex. 1002 ¶¶ 124–134; Ex. 1005 ¶¶ 1, 9, 25–28, Fig. 2D; that “a void can decrease thermal stress in the substrate”). We agree with Petitioner’s declarant that Pogge provides a void in a TSV similar to Cooney and the ’609 patent. Ex. 1001, Fig. 4; Ex. 1002 ¶ 127; Ex. 1004, Fig. 6; Ex. 1005, Fig. 2D. We, thus, credit the testimony that, because of their common structural arrangements, one of ordinary skill in the art would have understood that stress-relieving characteristics in Pogge would have been manifested in Cooney’s void. Ex. 1002 ¶ 127. We also agree with Petitioner’s declarant that Edelstein includes a void in a TSV similar to Cooney, the ’609 patent, and Pogge. Ex. 1001, Fig. 4; Ex. 1002 ¶ 130; Ex. 1004, Fig. 6; Ex. 1005, Fig. 2F; Ex. 1006, Fig. 6F. We, therefore, credit the testimony that, because of their common structural arrangements, one of ordinary skill in the art would have understood that stress-relieving characteristics in Edelstein would have also been manifested in Cooney’s void. Ex. 1002 ¶ 130.” slip op. at 33

  Patent outcomesUS 9,147,609 unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 9,147,609
• Prime Time Toys LLC / Prime Time Toys Ltd. et al. v. Spin Master, Inc.No claims unpatentable
  PTAB · Oct 10, 2025 · IPR2023-01339 · APJ Brent M Dougal · IPR · Final written decision

  Claims 4–9, 12, and 14 were not shown unpatentable because Petitioner failed to establish a reason to combine Peev and Spitballs.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedOther

    “We agree that the three definitions are similar. The parties do not advocate for any particular definition. We also determine that no distinction between the definitions is material to this Decision. As such, we do not repeat all three definitions and accept Patent Owner’s definition as most closely fitting the legal requirements: a bachelor’s degree in mechanical engineering, industrial design, or equivalent, with at least one year of relevant experience designing projectile launching systems but would also be a member of a team, which would include a person with a bachelor’s in materials science, chemistry, or equivalent (e.g., chemical engineering), or has at least one year experience working with materials for use in consumer products equivalent work experience may substitute for educational experience, and vice versa” slip op. at 7

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Neither Petitioner or Patent Owner advocate for the construction of any particular claim term. Pet. 20–21; see generally PO Resp. We determine that no terms require express construction. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 8

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable

    “conducting this kind of basic muzzle energy analysis—a conventional, even industry standard technique at the time—would not have concluded that the polymer balls that Spitballs teaches are a safer form of ammunition simply because they are softer than lightweight airsoft rounds,” because the record supports it. Ex. 2015 ¶ 59. slip op. at 12

  • Obviousness (§103) › Objective indicia / secondary considerationsNot reached

    “that softer ammunition was a possible solution and that Vat19 shows Spitballs exploding on contact with a person without harm. Reply 28–30 (citing Paper 12, 16–17; PO Resp. 63). However, we agree with Patent Owner, that Kim and Vat19 do not disclose all of the limitations of the claims. PO Resp. 61–62; PO Sur-reply 26; Ex. 1004, 302:7–22; Ex. 1022, 8, 9; Ex. 1024; Ex. 2007, 100 (ALJ concluding “there is no disclosure that [Kim’s] gel material is a SAP”); Ex. 2015 ¶¶ 236–239. Petitioner makes no assertions to the contrary. See Pet. 57–60; Reply 28–30. As discussed above, the full record does not support that one of ordinary skill in the art would have combined Peev and Spitballs for the reasons asserted by Petitioner. Petitioner’s insufficient evidence of simultaneous invention does not overcome that deficiency.” slip op. at 21

  Patent outcomesUS 8,640,683 not shown unpatentable
  Claim construction§ 103 obviousnesscites Graham
  Patents in suitUS 8,640,683
• Prime Time Toys LLC / Prime Time Toys Ltd. et al. v. Spin Master, Inc.No claims unpatentable
  PTAB · Oct 10, 2025 · IPR2023-01461 · APJ Hyun J Jung · IPR · Final written decision

  Claims 1, 2, 13, and 15–20 were not shown unpatentable because Petitioner failed to establish a sufficient motivation to combine Peev and Spitballs, including with Moorhouse.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “The parties do not address the adopted level of ordinary skill in the art. See PO Resp.; Pet. Reply; PO Sur-reply. Based on the full record, we maintain and affirm that one of ordinary skill in the art would have had: a bachelor’s degree in mechanical engineering, industrial design, or equivalent, with at least one year of relevant experience designing projectile launching systems but would also be a member of a team, which would include a person with a chemical engineering), or has at least one year experience working with materials for use in consumer products and that “equivalent work experience may substitute for educational experience, and vice versa.” Pet. 21–22 (quoting Ex. 1015, 7–8); see also Ex. 1016 ¶ 55 (stating that “Patent Owner’s and Petitioner’s definitions of the [person of ordinary skill in the art] are similar, and my opinions in this Declaration would not change if I used Patent Owner’s definition of the [person of ordinary skill in the art] rather than Petitioner’s definition”). We find that the proposed level of ordinary skill in the art is consistent with the ’255 patent and the asserted prior art.” slip op. at 7

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Neither Petitioner nor Patent Owner proposes any interpretation for any claim term. Pet. 23; see PO Resp. Petitioner notes that the ALJ in the ITC proceeding construed two terms used in the ’282 and ’683 patents, specifically “super absorbent polymer” and “a firing mechanism that directly applies a force to the ammunition.” Pet. 23 (citing Ex. 1015, 12, 14). Based on the full record, we determine that no term requires express construction to resolve the parties’ dispute. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 8

  • Expert testimonyPetitioner expert discountedMixed

    “we give little weight to the opinion of Dr. Courtney on whether Spitballs would have been considered liquid filled by one of ordinary skill in the art. Pet. Reply 15–16; PO Sur-reply 18; Ex. 1037 ¶ 55; Ex. 2121, 61:12–13; see also PO Sur-reply 14–15 (arguing that Dr. Courtney does not meet the adopted level of ordinary skill in the art). We agree with Patent Owner that Petitioner’s list of “rubber, cork, foam, and soft plastics, such as SAPs” “does not exclude all of the other types of materials Petitioner failed to address—e.g., the gelatin materials used to make paintballs.” PO Resp. 24 (citing Ex. 2117, 1). The “openended” list “has no meaningful evidentiary support” because the cited paragraphs from its declaration “make no reference at all to potential airsoft ammunition.” Pet. 38; PO Resp. 24; Ex. 1016 ¶ 77; Ex. 1017 ¶¶ 36–39, 46– 48. Petitioner’s declarant Dr. Reitman also “acknowledged that airsoft considerations are beyond the scope of her testimony.” Ex. 2030, 117:17– 118:20. We agree with Patent Owner that Petitioner’s list would include “countless distinct polymers.” PO Resp. 25; Ex. 2120, 27–28.” slip op. at 21

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable

    “In other words, Petitioner does not squarely address the testimonial evidence that the softness of Spitballs would not have been equated with safety, because of its higher weight and kinetic energy. Ex. 2015 ¶¶ 44–55. We agree with Patent Owner that Petitioner does not assert fragmentation and deformation would have overcome the greater kinetic energy of the heavier Spitballs, and that Petitioner’s declarant admitted such calculation was not done. PO Sur-reply 7 (citing Ex. 2121, 48:11–49:7); Ex. 2121, 48:11–49:7 (Petitioner’s declarant testifying that calculations of how much kinetic energy is absorbed when Spitballs bounce or explode were not done). Petitioner’s declarant also identified that back splatter can create an additional safety concern. Ex. 2121, 101:14–104:4. We agree with Patent Owner that Petitioner failed to discuss the deformation and fragmentation of Spitballs in its Petition and declarations. PO Sur-reply 6 (citing Pet. Reply 10–11; Ex. 1037 ¶ 43). We also agree that Petitioner did not explain how one of ordinary skill in the art could have reliably assessed the safety of Spitballs and airsoft rounds. Id.; see also Ex. 2121, 47:1–48:10 (Petitioner’s declarant testifying that experimentation would be the best way to quantify how much kinetic energy is absorbed through deformation and fragmentation of a given projectile). focused on the mass and diameter calculations provided by Petitioner’s declarant, and Petitioner has the burden to analyze a projectile other than the one disclosed in Spitballs, not Patent Owner. PO Sur-reply 10–11 (citing Pet. Reply 13; Ex. 1017 ¶ 67; Ex. 2015 ¶ 59). Petitioner failed to do such an analysis of a 6mm Spitball or SAP projectile. Regarding Petitioner’s reliance on deposition testimony from the ITC proceedings, as argued by Patent Owner, its declarant agreed that making ammunition softer would make injury less likely, if all other parameters were equal, not larger and heavier like a substitution with Spitballs. PO Resp. 16–17 (citing Pet. 37; Ex. 1004, 531:25–532:9; Ex. 2015 ¶¶ 60–61); Ex. 1017 ¶ 67 (Petitioner’s declarant opining that Spitballs can “grow up to 200 times their original size” to reach a mass of 1.844g); Ex. 1037 ¶ 39 (Petitioner’s declarant agreeing that “when all other variables are held constant, heavier is less safe, meaning injury potential is increased”); Ex. 2015 ¶¶ 54–59 (Patent Owner’s declarant opining that heavier and softer ammunition can pose more injury risk); Ex. 2016, 11 (indicating that airsoft ammunition typically comes in weights from 0.12g to 0.25g). We, thus, agree with Patent Owner that Petitioner fails to prove that” slip op. at 16

  Patent outcomesUS 8,596,255 not shown unpatentable
  Claim construction§ 103 obviousnesscites Phillips · Graham
  Patents in suitUS 8,596,255
• Google LLC / Cellco Partnership D/B/A Verizon Wireless et al. v. Headwater Research LLCAll claims unpatentable
  PTAB · Oct 1, 2025 · IPR2024-00943 · APJ Scott B Howard · IPR · Final written decision

  Claims 2–23, 26, 41–60, 63, 64, 91–152, and 155–171 are unpatentable; Rao anticipates some claims, and the stated Rao combinations render the remaining claims obvious.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner argues that a person having ordinary skill in the art “would have at least a bachelor’s degree in computer science, computer engineering, or a similar field, and approximately two years of industry or academic experience in a field related to computer software development and/or computer networking.” Pet. 2 (citing Ex. 1015 ¶¶ 50–52). Petitioner further argues that “[w]ork experience can substitute for education, and additional education can substitute for work experience.” Id. at 2–3 (citing Ex. 1015 ¶¶ 50–52). Because Petitioner’s proposed level of ordinary skill in the art is consistent with the field of the invention of the ’541 patent and not disputed by Patent Owner (see PO Resp.), we adopt Petitioner’s formulation of the person having ordinary skill in the art.” slip op. at 12

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “Petitioner states “[n]o terms require construction to resolve this Petition.” Pet. 3. Patent Owner does not propose any claim constructions. See PO Resp. For the purposes of this Decision, we need not expressly construe any claim terms. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (noting that “we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 13

  • Expert testimonyPetitioner expert creditedDecided for petitioner
  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableNot shown unpatentableMixed

    “preponderance of the evidence that claim 3 was anticipated by Rao.” slip op. at 25

  Patent outcomesUS 8,589,541 unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,589,541
• Alliance Laundry Systems, LLC v. Payrange LLCInstitution denied
  PTAB · Oct 1, 2025 · IPR2025-00573 · APJ Meredith C Petravick · IPR · Institution

  The Board denied institution because the Petition did not show a reasonable likelihood that claims 7 or 11 were unpatentable under the asserted obviousness grounds.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “Under 35 U.S.C. § 314(a), an inter partes review may not be instituted unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” After considering the Petition, the Preliminary Response, and the evidence of record, we determine the information presented fails to show a reasonable likelihood that Petitioner would prevail in establishing the unpatentability of at least one of the challenged claims of the ’772 patent. Accordingly, we do not institute an inter partes review of claims 7 and 11 of the ’772 patent on the grounds asserted in the Petition.” slip op. at 2

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends a person having ordinary skill in the art (“POSA”) pertaining to the ’772 patent “would have had an educational background of, engineering, computer engineering, computer science, or equivalent training, and approximately three years of experience with electronic payment systems, vending machine technologies, or distributed network systems.” Pet. 19–20; Ex. 1003 ¶¶ 20–26. “Lack of work experience can be remedied by additional education, and vice versa.” Pet. 20; Ex. 1003 ¶ 22. Patent Owner does not oppose Petitioner’s formulation of ordinary skill. See Prelim. Resp. generally. On this record, we adopt Petitioner’s assessment of the level of ordinary skill in the art as it is consistent with the ’772 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “In this inter partes review, we apply the same claim construction standard that would be used in a civil action under 35 U.S.C. § 282(b). 37 C.F.R. § 42.100(b). In applying this standard, we generally give claim terms their ordinary and customary meaning as would be understood by a person of ordinary skill in the art at the time of the invention and in the context of the entire patent disclosure. See id.; Phillips v. AWH Corp., 415 F.3d 1303, 1312–14 (Fed. Cir. 2005) (en banc). We do not need to construe any terms expressly to determine whether or not to institute a trial. See Realtime Data LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 10

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,481,772
• Samsung Electronics Co., Ltd. / Samsung Electronics America, Inc. et al. v. Chien-Min SungAll claims unpatentable
  PTAB · Sep 17, 2025 · IPR2024-00533 · APJ Frances L Ippolito · IPR · Final written decision

  Claims 1–8 are unpatentable as obvious: claims 1, 3–8 over Chou and Sung ’479; claims 6–7 also over SungECS; and claim 2 over Goers.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “We secondly conclude a POSITA would have had at least two years of experience designing and/or developing CMP technology per Patent Owner’s formulation, but we reject Patent Owner’s additional contention that this experience must include designing and/or developing pad dressers specifically. The ’270 patent claims are directed to the structure of a pad dresser, not to a method of making a pad dresser. See Ex. 1001, 17:35– 18:38. According to the ’270 patent specification, the claimed pad dresser structure is designed to condition a polishing pad so the pad may be used to attain “high performance levels in aspects such as uniformity of polished wafer, smoothness of the IC circuitry, removal rate for productivity, longevity of consumables for CMP economics, etc.” during a CMP process. Id. at 1:20–24 (Background of the Invention). Thus, the ’270 patent’s invention generally focuses on optimizing a pad dresser structure to achieve desired results in a CMP process, not necessarily on how to manufacture a pad dresser. As such, we reject Petitioner’s POSITA formulation requiring “experience in the field of integrated circuit processing and fabrication techniques” (Pet. 19) as too generic in the context of the ’270 patent’s claimed invention. We also conclude, in view of the ’270 patent disclosures discussed above, that Dr. Tsai’s opinion that ordinary skill requires experience with manufacturing pad dressers (see Ex. 2011 ¶ 28) is too conclusory and lacking in evidentiary support to be persuasive. See Best Med. v. Elekta, 46 F.4th at 1353 (“The patent’s purpose can also be informative.”).” slip op. at 9

  • ExcludeMotion to exclude, deniedDenied

    “The Federal Circuit has held: “To offer expert testimony from the perspective of a skilled artisan in a patent case — like for claim construction, validity, or infringement — a witness must at least have ordinary skill in the art.”9 Kyocera Senco Indus. Tools Inc. v. Int’l Trade Commission, 22 F.4th 1369, 1375–77 (Fed. Cir. 2022); see also Osseo Imaging, LLC v. Planmeca USA Inc., 116 F.4th 1335, 1340–41 (Fed. Cir. 2024) (holding that the proffered expert does not need to have acquired the 9 Petitioner cites the Practice Guide’s statements that there is “no requirement of a perfect match between the expert’s experience and the relevant field” and “[a] person may not need to be a person of ordinary skill in the art in order to testify as an expert under Rule 702, but rather must be ‘qualified in the pertinent art.’” Practice Guide 34 (citing SEB v. Montgomery Ward, 594 F.3d at 1373; Sundance v. DeMonte, 550 F.3d at 1363–64). To the extent there is any tension between the Practice Guide (issued in 2019) and the Kyocera holding (issued in 2022), we apply the latter here.” slip op. at 12

  • Expert testimonyPetitioner expert creditedDecided for petitioner

    “We determine Dr. Shanfield has sufficient education and experience to qualify as a person of ordinary skill in the art pertaining to the ’270 patent. Dr. Shanfield’s Ph.D. in physics satisfies the educational prerequisite of at least a bachelor’s degree in an engineering related field such as physics. See Ex. 1002 ¶ 2, App. A. Furthermore, his advanced degree (Ph.D. in physics) versus ordinary skill (a bachelor’s degree in an engineering related field) provides considerable leeway when turning to the experiential component for ordinary skill. Nonetheless, Dr. Shanfield also has at least two years of experience with designing and developing CMP technology per the experience prerequisite, as follows. Dr. Shanfield worked at Raytheon Corporation for over 10 years, during which he “worked directly with engineers in the selection, installation, and optimization of several chemo-mechanical polishing systems (CMP), including analysis of operational maintenance and performance monitoring,” and he “directly participated in establishing the required metrology (optical thickness monitoring) for maintaining polishing uniformity standards.” Ex. 1002 ¶ 3 (emphasis added). He later joined Draper Laboratory in 2003, where he currently is the Division Leader of Advanced Hardware Development. See id. ¶ 5. During Dr. Shanfield’s time at Draper, the laboratory “acquired several semiconductor-grade CMP systems for the purpose of fabricating multi-chip modules and for planarization operations in MEMS devices,” and he was “involved in their operation and optimization.” Id. (emphasis added). When asked during a deposition whether he is “an expert in CMP equipment design,” Dr. Shanfield stated he is “very familiar with the design of CMP equipment” because he has “seen many systems” and “installed or supervised the installation of systems.” Ex. 2003, 17:22–19:3. He testified he has “designed apparatus that worked with CMP equipment” although he has not “designed the CMP equipment itself.” Id. at 18:13–19. As an example of being “involved in the manufacture of CMP pad dressers” specifically, Dr. Shanfield stated that during his time at Raytheon, he worked with other professionals “to use the CMP system to process MEMS, M-E-M-S, devices” which “needed a certain kind of planarization process [that] required constant conditioning,” so the team “had to try to fabricate something that would provide conditioning that would last longer.” Id. at 19:4–20:9. Thus, we conclude Dr. Shanfield qualifies as a POSITA pertaining to” slip op. at 13

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “apply the same claim construction standard “used in the federal courts, in other words, the claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. [§] 282(b),” which is articulated in Phillips v. AWH Corp., 415 F.3d 1303 (Fed. Cir. 2005) (en banc). 83 Fed. Reg. 51,340, 51,358 (Oct. 11, 2018) (amending 37 C.F.R. § 42.100(b) effective November 13, 2018) (now codified at 37 C.F.R. § 42.100(b) (2019)). Under the Phillips standard, the “words of a claim are generally given their ordinary and customary meaning,” which is “the meaning that the term would have to a person of ordinary skill in the art in question at the time of the invention, i.e., as of the effective filing date of the patent application.” Phillips, 415 F.3d at 1312–13. Petitioner proposes constructions for terms: “superabrasive,” “protrusion,” “sharp portion,” and “attitude.” Pet. 20–21. Patent Owner does not propose constructions for any claim term. See generally, PO Resp. We discern constructions of these claim phrases or others are not required for the purposes of this Decision. Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms that . . . are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 15

  Patent outcomesUS 8,974,270 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,974,270
• Under Armour, Inc. v. Athalonz, LLCAll claims unpatentable
  PTAB · Sep 11, 2025 · IPR2024-00636 · APJ Matthew S Meyers · IPR · Final written decision

  Claims 1–8 are unpatentable as obvious over Kim; the Board did not reach the four other instituted grounds.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Based on the full record, we determine that Petitioner’s proposed level of skill is reasonable and consistent with the ’786 patent and the asserted prior art. Thus, for these reasons, we adopt Petitioner’s level of skill in the art for purposes of this Decision.” slip op. at 7

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “Based on the full record, we maintain that it is unnecessary to explicitly construe “athletic positioning” because its meaning is already captured in the claim through the recitation of the relationship between the various slopes of the sole that provide “athletic positioning” of the foot. See Ex. 1001, 44:2–14. The recitations of a “first slope,” “second slope,” “third slope,” and “reference slope” translate into the relative heights proposed in adopt Patent Owner’s proposed construction because it incorporates the specification’s consistent descriptions of “athletic positioning” in terms of relative heights and slopes. For example, one embodiment of an “athletic positioning shape” is where “the heel platform may be 10 to 30 mm higher” than “the toe cup and/or the ball of foot cup.” [Ex. 1001], 13:38–45. Another embodiment discloses “an athletic positioning sole that includes an overall geometric shape” including “the heel of the sole [at] a particular height (e.g., h1, which may be 1’s to 10’s of mm) that slopes at an angle (e.g., Ø1) to the toe on the inside edge of the sole” which “may have a height of zero to a few millimeters.” Id., 17:54–62. PO Resp. 29. However, we find Patent Owner’s contention regarding particular heights and specific angles attempts to import limitations from the Specification into claims. Superguide Corp. v. DirecTV Enterprises, Inc., 358 F.3d 870, 875 (Fed. Cir. 2004) (“Though understanding the claim language may be aided by the explanations contained in the written description, it is important not to import into a claim limitations that are not a part of the claim.”). Based on the full record, we determine that express claim construction of “athletic positioning” is not necessary to resolve the present dispute. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 9

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable

    “8. Conclusion for Ground 1 We have considered all of the arguments and evidence adduced at trial. For the reasons explained, we find Petitioner has persuasively demonstrated that Kim teaches or suggests all limitations of claims 1–8. We also find that the value of Patent Owner’s objective evidence of non-obviousness is weak in comparison to the evidence regarding the prior art under the first three Graham factors. Accordingly, we find Petitioner has shown by a preponderance of the evidence that claims 1–8 of the ’786 patent would have been obvious over Kim.” slip op. at 39

  • Obviousness (§103) › Objective indicia / secondary considerations › NexusObjective indicia no nexusDecided for petitioner

    “Based on the full record, we determine that Patent Owner fails to show nexus between the claimed invention and the asserted objective indicia of nonobviousness. PO Resp. 70–78; PO Sur-reply 25–28. Other than asserting that “the requisite nexus exists here” (PO Resp. 71), and citing to the Declaration testimony of Mr. Markison (id. (citing Ex. 2008 ¶ 322)), the Patent Owner response does not provide an analysis of Patent Owner’s product with respect to the claims of the ’768 patent, and thus does not demonstrate nexus. To the extent Patent Owner references Mr. Markison’s testimony, Mr. Markison’s testimony consists solely of the statement that Patent Owner “sells and markets golf and baseball shoes that embody the claims of the ’786 patent” with reference to an exhibit from district court litigation. See Ex. 2008 ¶ 322 (citing Ex. 2014). We find Patent Owner’s reliance on Mr. Markison’s testimony to be insufficient to establish a rebuttable presumption of nexus. Thus, Patent Owner is not entitled to a rebuttable presumption of nexus, because Patent Owner has not shown that the asserted evidence is tied to a specific product that is the disclosed and claimed invention. Fox Factory, Inc. v. SRAM, LLC, 944 F.3d 1366, 1373 (Fed. Cir. 2019). Patent Owner also does not provide any evidence that the asserted” slip op. at 33

  Patent outcomesUS 10,674,786 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 10,674,786
• Under Armour, Inc. v. Athalonz, LLCAll claims unpatentable
  PTAB · Sep 10, 2025 · IPR2024-00640 · APJ Hyun J Jung · IPR · Final written decision

  Claims 1–5, 7, 9–15, and 17 are unpatentable: claims 10, 11, 15, and 17 over Won, and claims 1–5, 7, 9, and 12–14 over Won and Talarico ’911.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner argues that a person of ordinary skill in the art “would have (1) at least a B.S. or equivalent degree related to industrial or product design and at least two years’ experience designing or developing athletic shoes; or (2) at least five years designing or developing athletic shoes.” Pet. 17–18 (citing Ex. 1002 ¶ 31). According to Petitioner, “the claims are obvious in view of any reasonable definition of a [person of ordinary skill in the art].” Id. at 21. For institution, we preliminarily adopted Petitioner’s proposal. Inst. Dec. 4. “For purposes of this proceeding, Patent Owner does not dispute Petitioner’s level of ordinary skill.” PO Resp. 13 (citing Pet. 17–18). Patent Owner contends that its declarant Mr. Markison “far exceeds the proposed level of ordinary skill in the art” and, because he is registered as a patent attorney and licensed as an attorney, “can offer good faith and objective opinions on the issues in this proceeding.” Id. at 13–14 (citing Ex. 2008 ¶¶ 11–13, 17–30, 42–44). Based on the full record, we maintain and affirm that one of ordinary skill in the art “would have (1) at least a B.S. or equivalent degree related to industrial or product design and at least two years’ experience designing or developing athletic shoes; or (2) at least five years designing or developing athletic shoes.” Pet. 20–21 (citing Ex. 1002 ¶ 30); Inst. Dec. 9; Ex. 1002 ¶ 30; Ex. 2008 ¶ 44.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner

    “Petitioner notes that, although claim 1 recites a heel platform made of a “first material” and a forefoot platform made of a “second material,” the first and second materials can be the same based on Patent Owner’s apparent interpretation in related litigation. Pet. 27 n.1 (citing Ex. 1012, 30–44). Petitioner applies Patent Owner’s apparent interpretation to the challenges of this proceeding “[w]ithout conceding alternative arguments.” Id. At institution, we were persuaded by Patent Owner’s arguments and adopted a construction that the “first” and “second” materials are “different in some manner.” Inst. Dec. 7–8. Patent Owner responds that we should maintain the same construction and disputes Petitioner’s evidence that the “first” and “second” materials can be the same material. PO Resp. 15–19 (citing Pet. 27 n.1; Inst. Dec. 8, 12–13; Ex. 1012, Ex. E, 38, 52; Ex. 2014, 15). Patent Owner also argues that Petitioner should not be allowed to present new arguments or evidence in reply. Id. at 19–21. Petitioner replies that interpreting “first” and “second” materials to be different materials contradicts the plain language of the claims, the Specification, and Patent Owner’s infringement contentions. Pet. Reply 1–5 (citing Pet. 27 n.1; Prelim. Resp. 16–17; PO Resp. 16–18; Ex. 1001, 10:9– 19, 17:52–54, 21:64–22:4, 27:47–51, Figs. 43, 49, claims 1, 6; Ex. 1023, 47:1–48:1, 215:6–217:12, 224:13–225:19; Ex. 1025, 319; Ex. 1026). Patent Owner replies that Petitioner presents new arguments and evidence in reply. PO Sur-reply 5–9 (citing Pet. 27 n.1; Inst. Dec. 13; PO Resp. 16–21; Pet. Reply 1–3, 14 n.1; Paper 19). Patent Owner also argues that, even if Petitioner’s asserted new arguments and evidence are considered, they fail to support an interpretation of “first” and “second” Resp. 16–17; Pet. Reply 1–3; Ex. 1001, 17:50–54, 27:50–54, Figs. 43, 93; Ex. 1023, 215:6–217:12; Ex. 2014, 19–22)” slip op. at 12

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “4. Other Terms Based on the full record, express interpretation of other terms is not necessary to resolve the parties’ dispute. Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms that . . . are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 13

  • ExcludeMotion to exclude, grantedMotion to exclude, deniedMixed

    “Patent Owner does not satisfy its “burden of proof to establish that it is entitled to the requested relief.” 37 C.F.R. § 42.20(c). Evidence of how the inventor viewed claim terms can be useful in considering claim interpretation, and, thus, we agree with Petitioner that the exhibit is relevant. For the reasons stated below, however, we do not need to rely on the exhibit. Accordingly, Patent Owner’s Motion to Exclude Exhibit 1024 is dismissed as moot.” slip op. at 6

  Patent outcomesUS 11,510,456 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,510,456

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.