• Abbott Laboratories v. Miracor Medical SASome claims unpatentable
  PTAB · Jun 11, 2026 · IPR2025-00115 · APJ Annette R Reimers · IPR · Final written decision

  Claims 1–4, 10, 11, 14, 17, 21, 22, 24, 26, 28–30, 32, 33, and 35 are unpatentable; claim 15 is not shown unpatentable, based on the four asserted obviousness grounds.

  RulingsFinal written decision

  • ExcludeMotion to exclude, deniedDenied

    “IV. PATENT OWNER’S MOTION TO EXCLUDE Patent Owner seeks to exclude portions of Dr. Wieselthaler’s Declaration (Exhibit 1041), portions of Mr. Crosby’s Reply Declaration (Exhibit 1042), portions of the deposition transcript of Dr. Wieselthaler (Exhibit 2028), and the exhibits “upon which that testimony is based” (Exhibits 1015, 1038, 1044, 1046, 1049, and 1050). Mot. 1. According to Patent Owner, the Motion was made “to preserve objections previously made in the record.” Id. (citations omitted). Patent Owner did not timely move to strike any of the evidence at issue as being outside the scope of reply evidence. Patent Owner asserts that because an inter partes review must be based on prior art consisting of patents or printed publications (citing 35 U.S.C. § 311(b)), the testimony of Mr. Crosby and Dr. Wieselthaler concerning “various physical devices allegedly known” to a person of ordinary skill in the art is inadmissible, along with all of the exhibits (consisting of printed materials such a journal abstracts, press releases, and papers) related to those physical devices. Id. at 3–4; see also Mot. Reply 1–4 (arguing that “devices that Petitioner’s witnesses assert were in public use prior to the claimed inventions, are not prior art that can form the basis of an inter partes review”). According to Patent Owner, Dr. Wieselthaler was unable to “link two of these physical devices to the printed prior art asserted in this [inter partes review], but those attempts fell apart during his cross examination.” Id. at 4. Patent Owner further reasons that because the evidence “cannot be the basis” of an inter partes review, it “has probable,” “is irrelevant and not admissible,” “presents substantial danger of confusing the issues, causing undue delay, and wasting time in this trial,” and “are not ‘based on sufficient facts[,] the product of reliable principles and methods[, or] ‘a reliable application of the principles and methods to the facts of the case.’” Id. at 7 (citing Fed. R. Evid. 401–403, 702) (modification in original). With regard to Exhibits 1015, 1038, 1044, 1046, 1049, and 1050, Petitioner argues, and we agree, that Patent Owner identifies no plausible legal theory for their inadmissibility based on the contention that they discuss physical devices. See Mot. Resp. 3. We also agree with Petitioner that the exhibits are not “the basis for any ground” asserted in this proceeding, and may be properly relied upon by Dr. Wieselthaler and Mr. Crosby as support for their rebuttal testimony directed to Patent Owner’s arguments disputing Petitioner’s asserted motivation to combine the prior art relied upon in the instituted grounds. See id. at 3–4. In regard to the disputed testimony of Dr. Wieselthaler and” slip op. at 80

  • Skill levelSkill level board ownOther

    “B. Level of Ordinary Skill in the Art In determining the level of ordinary skill in the art, various factors” slip op. at 14

  • Expert testimonyPetitioner expert discountedDecided for patent owner

    “‘electronics for power and control’”). According to Mr. Crosby, a person of ordinary skill in the art “would have understood based on the disclosure of this setup that these speed and motor parameters were monitored by a sensor providing feedback to the controller.” Ex. 1003 ¶ 725. Mr. Crosby identifies no support for this opinion, which we give little weight to. The mere fact that Bourque’s pump used software to control speed and motor parameters does not show that Bourque used “one or more sensors” to provide feedback signals to the external control unit. Indeed, Petitioner fails to identify any evidence that Bourque used any “sensor” to monitor “speed and motor parameters.” Mr. Crosby also states that “[e]ach of the ‘ultrasonic flow probe’ and the ‘solid-state catheter-type pressure transducer’ described in [Bourque] is a ‘sensor’ as recited in Claim 33 that provides feedback signals to the external control unit (e.g., ‘electronics for power and control’ and ‘data acquisition’).” Id. ¶¶ 581, 726. Mr. Crosby’s opinion is again unsupported by the evidence, because, as explained above, there is no teaching in Bourque that either the “ultrasonic flow probe” or the “pressure transducers” used in the “in vitro characterization” studies were part of the heart assist pump device. Based on our review and consideration of Petitioner’s arguments and evidence directed to claim 11, we find that Petitioner has not shown by a preponderance of the evidence that the asserted combination of Bourque and Wampler teaches or suggests each of the limitations of dependent claim 11. We reach the same conclusion for the same reasons with regard to claim 33.” slip op. at 48

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “1. “magneto coupling” Claim 1 recites, in relevant part, a second magnetic device “positioned” slip op. at 25

  Patent outcomesUS 11,674,517 mixed
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,674,517
• Abbott Laboratories v. Miracor Medical SASome claims unpatentable
  PTAB · Jun 11, 2026 · IPR2025-00096 · APJ James A Tartal · IPR · Final written decision

  Claims 1–4, 6, 7, 10, 12, and 13 are unpatentable as obvious over Schima and Akamatsu; claim 5 was not shown unpatentable.

  RulingsFinal written decision

  • ExcludeMotion to exclude, deniedDenied

    “consequence in determining the action.” Fed. R. Evid. 401. Fed. R. Evid. 702 serves “a ‘gatekeeping role,’ the objective of which is to ensure that expert testimony admitted into evidence is both reliable and relevant.” Sundance, Inc. v. DeMonte Fabricating Ltd., 550 F.3d 1356, 1360 (Fed. Cir. 2008). There is no question that the disputed testimony of Dr. Wieselthaler and Mr. Crosby is relevant to the asserted motivation to combine and reliable, only whether it becomes “not relevant” or “unreliable,” in light of limited scope upon which grounds of unpatentability may be based under 35 U.S.C. § 311(b), because the testimony is based on, or supported by, knowledge of physical devices and publications discussing physical devices. Patent Owner directs us to no support for the notion that an expert’s testimony in an inter partes review must be limited to only the prior art relied upon as grounds for unpatentability and may not take into account any knowledge of, or publications concerning, other “physical devices” that would have been known to a person of ordinary skill at the relevant time. See generally Mot.25 In sum, we find that Patent Owner has 25 Patent Owner improperly asserts for the first time in its Reply in support of the Motion that “Petitioner in this case is improperly relying on non-prior art evidence.” Mot. Reply 3. This argument was not made in the Motion, and Patent Owner fails to identify what “non-prior art evidence” it seeks to exclude. We recognize that Petitioner appears to raise the argument that “non-prior art evidence” may be relied upon by an expert, but Petitioner also fails to identify what evidence it is referring to and that argument was not responsive to any issue Patent Owner raised in the Motion. See Mot. Resp. 5. To the extent the Parties intend “non-prior art evidence” to refer to the testimony of Dr. Wieselthaler and Mr. Crosby, we view the issue as pertaining to the weight afforded that testimony, in light of the supporting evidence relied upon, rather than one of admissibility. for the exclusion of evidence in this proceeding and deny the Motion.” slip op. at 83

  • Skill levelOther

    “B. Level of Ordinary Skill in the Art In determining the level of ordinary skill in the art, various factors” slip op. at 10

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Other

    “D. Claim Construction In this proceeding we construe claims using the same claim” slip op. at 20

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable

    “5. Rationale in Support of Asserted Combination Petitioner shows, and there is no dispute, that Bourque and Wampler” slip op. at 48

  Patent outcomesUS 11,351,356 mixed
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,351,356
• Abbott Laboratories v. Miracor Medical SASome claims unpatentable
  PTAB · Jun 10, 2026 · IPR2025-00114 · APJ Annette R Reimers · IPR · Final written decision

  Claims 1, 2, 4, 5, 7, 8, 11, 12, 14–16, 18, and 19 are unpatentable under §103; claim 20 was not shown unpatentable.

  RulingsFinal written decision

  • Expert testimonyDenied

    “IV. PATENT OWNER’S MOTION TO EXCLUDE Patent Owner seeks to exclude portions of Dr. Wieselthaler’s Declaration (Exhibit 1041), portions of Mr. Crosby’s Reply Declaration (Exhibit 1042), portions of the deposition transcript of Dr. Wieselthaler (Exhibit 2028), and the exhibits “upon which that testimony is based” (Exhibits 1015, 1038, 1044, 1046, 1049, and 1050). Mot. 1. According to Patent Owner, the Motion was made “to preserve objections previously made in the record.” Id. (citations omitted). Patent Owner did not timely move to strike any of the evidence at issue as being outside the scope of reply evidence. Patent Owner asserts that because an inter partes review must be based on prior art consisting of patents or printed publications (citing 35 U.S.C. § 311(b)), the testimony of Mr. Crosby and Dr. Wieselthaler concerning “various physical devices allegedly known” to a person of ordinary skill in the art is inadmissible, along with all of the exhibits (consisting of printed materials such a journal abstracts, press releases, and papers) related to those physical devices. Id. at 3–4; see also Mot. Reply 1–4 (arguing that “devices that Petitioner’s witnesses assert were the basis of an inter partes review”). According to Patent Owner, Dr. Wieselthaler was unable to “link two of these physical devices to the printed prior art asserted in this [inter partes review], but those attempts fell apart during his cross examination.” Id. at 4. Patent Owner further reasons that because the evidence “cannot be the basis” of an inter partes review, it “has no tendency to make any fact of consequence in this trial more or less probable,” “is irrelevant and not admissible,” “presents substantial danger of confusing the issues, causing undue delay, and wasting time in this trial,” and “are not ‘based on sufficient facts[,] the product of reliable principles and methods[, or] ‘a reliable application of the principles and methods to the facts of the case.’” Id. at 7 (citing Fed. R. Evid. 401–403, 702) (modification in original). With regard to Exhibits 1015, 1038, 1044, 1046, 1049, and 1050, Petitioner argues, and we agree, that Patent Owner identifies no plausible legal theory for their inadmissibility based on the contention that they discuss physical devices. See Mot. Resp. 3. We also agree with Petitioner that the exhibits are not “the basis for any ground” asserted in this proceeding, and may be properly relied upon by Dr. Wieselthaler and Mr. Crosby as support for their rebuttal testimony directed to Patent Owner’s arguments disputing Petitioner’s asserted motivation to combine the prior art relied upon in the instituted grounds. See id. at 3–4. In regard to the disputed testimony of Dr. Wieselthaler and” slip op. at 77

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownOther

    “1. “magneto coupling” Claim 1 recites, in relevant part, “a second magnetic device . . . positioned to magnetically drive rotation of the magnetically driven rotor via a magneto coupling with the first magnetic device.” Ex. 1001, 5:34–37. Claim 11 recites, in relevant part, “the second magnetic device positioned axially closer to the first magnetic device than to the magnetically driven rotor so as to magnetically drive rotation of the magnetically driven rotor relative to the one or more walls via a magneto coupling with the first magnetic device.” Id. at 6:42–48. Petitioner argues that “magneto coupling” means “a transfer of torque from one rotating permanent magnetic component to another rotating permanent magnetic component via a magnetic field.” Pet. 8–9 (citing Ex. 1003 ¶¶ 68–87). According to Petitioner, this construction is consistent with the ’879 patent, which describes “a coupling between two rotating ‘bar magnets’—a drive wheel rotates one bar magnet which causes another bar magnet (connected to a rotor) to rotate.” Id. (citing Ex. 1003 ¶¶ 54–55 (analyzing Ex. 1001, 2:28–52, 4:44–64, Fig. 2)). Patent Owner argues that “magneto coupling” should be afforded “its plain and ordinary meaning, which would encompass a magnetic coupling through both rotating magnets and the use of a rotating magnetic Owner directs us to the testimony of Mr. Leschinsky, who explains that a person of ordinary skill in the art would have understood the ’879 patent to use “magneto coupling” to generally describe “a way to couple the rotor to a drive element while sealing the two from one another and avoiding use of a direct mechanical coupling.” Ex. 2015 ¶ 67. According to Patent Owner, “Petitioner provides no recognizable basis for limiting the plain meaning of magnetic coupling to one type of magnet and excluding another type of magnet.” PO Resp. 6–7 (citing Johnson Worldwide Associates, Inc., v. Zebco Corp., 175 F.3d 985, 989–992 (Fed. Cir. 1999)). We agree with Patent Owner that Petitioner does not provide a sufficient basis for limiting the plain meaning of “magneto coupling.” That the ’879 patent describes embodiments using bar magnets does not serve to require the use of permanent magnets for the recited “magneto coupling.” See Sisvel Int’l S.A. v. Sierra Wireless, Inc., 81 F.4th 1231, 1236 (Fed. Cir. 2023) (quoting Phillips, 415 F.3d at 1323 (“[A]lthough the specification often describes very specific embodiments of the invention, we have repeatedly warned against confining the claims to those embodiments.”)). Moreover, the claim language here is not so limited. 13 Patent Owner notes that Petitioner’s grounds of unpatentability based on Wampler and Bourque depend on the disclosure only of electromagnetic drives in each reference, implying that “Petitioner does not believe its own proposed narrower construction.” PO Resp. 6; see also Pet. 8 (Petitioner alleging that in the Parallel Proceeding Patent Owner “conflates ‘magneto coupling’ . . . with a stator drive using a stationary electromagnet, instead of a rotating magnet, to rotate the rotor magnet,” and asserting that as the basis for Petitioner’s reliance on Wampler and Bourque as teaching a “magneto coupling” in this proceeding (citing Ex. 1019, 7; Ex. 1003 ¶¶ 84–87)).” slip op. at 24

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableNot shown unpatentableUnpatentable

    “reasons discussed above. See supra Section III.D.3. Accordingly, because Petitioner’s contentions are premised on an unsupported claim construction that we reject, Petitioner fails to show how Wampler teaches or suggests “a magnetically driven rotor . . . axially adjacent to a first magnet device,” as required by claims 1 and 11, as well as by claims 2, 4, 5, 7, 8, 11, 12, 14– 16, and 18–20, which depend from either claim 1 or claim 11. In its Reply, Petitioner suggests that “[u]nder [Patent Owner’s] construction from the [Patent Owner Response], Wampler also teaches or suggests this limitation,” because Patent Owner “concedes [that] ‘axially adjacent’ components ‘have” slip op. at 36

  Patent outcomesUS 11,572,879 mixed
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,572,879
• Abbott Laboratories v. Miracor Medical SAAll claims unpatentable
  PTAB · Jun 8, 2026 · IPR2025-00112 · APJ James A Tartal · IPR · Final written decision

  Claims 1–3, 10, 11, 14, and 17 are unpatentable as obvious over Schima and Akamatsu; the other asserted grounds were not established.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “may be considered, including the “type of problems encountered in the art; prior art solutions to those problems; rapidity with which innovations are made; sophistication of the technology; and educational level of active workers in the field.” In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995). Petitioner contends a person of ordinary skill in the art at the time of the invention “would have at least a bachelor’s degree in engineering; knowledge and experience in human circulatory system anatomy and physiology; and at least five years’ experience designing and developing implantable medical devices.” Pet. 6 (citing Ex. 1003 ¶ 18).” slip op. at 10

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner

    “sufficient basis for limiting the plain meaning of “magneto coupling.” That the ’357 patent describes embodiments using bar magnets does not serve to require the use of permanent magnets for the recited “magneto coupling.” See Sisvel Int’l S.A. v. Sierra Wireless, Inc., 81 F.4th 1231, 1236 (Fed. Cir. 2023) (quoting Phillips, 415 F.3d at 1323 (“[A]lthough the specification often describes very specific embodiments of the invention, we have repeatedly warned against confining the claims to those embodiments.”)). Moreover, the claim language here is not so limited. 11 Patent Owner notes that Petitioner’s grounds of unpatentability based on Wampler and Bourque depend on the disclosure only of electromagnetic drives in each reference, implying that “Petitioner does not believe its own proposed narrower construction.” PO Resp. 6; see also Pet. 8 (Petitioner alleging that in the Parallel Proceeding Patent Owner “conflates ‘magneto coupling’ . . . with a stator drive using a stationary electromagnet, instead of a rotating magnet, to rotate the rotor magnet,” and asserting that as the basis for Petitioner’s reliance on Wampler and Bourque as teaching a “magneto coupling” in this proceeding (citing Ex. 1019, 9–11; Ex. 1003 ¶¶ 84–87)). distinguished “magneto coupling” drives from drives using stators. Pet. 7–8 (citing Ex. 1011, 1 (explaining that the rotating field is generated by rotating magnets in a magnetic coupling pump and by electric stator windings in a stator pump)). Petitioner does not explain how this cited reference evidences that one of ordinary skill in the art would have understood “magneto coupling” requires rotating permanent magnets. At most, this reference teaches an example device that provides “magneto coupling.” See Ex. 1011, 1. In sum, we agree with Patent Owner that “magneto coupling,” consistent with our Institution Decision, encompasses generating a rotating field either by rotating magnets or by an electromagnet / stator. See Inst. Dec. 22” slip op. at 22

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable

    “ignores the readily apparent fact that the lower arrow is placed in a location that misrepresents the minimum distance between the magnetically driven rotor and the second magnetic device to suggest that Wampler teaches “the second magnetic device positioned axially closer to the first magnetic device than to the magnetically driven rotor,” as required by claim 1. Petitioner purports to justify this misrepresentation by asserting that “the vast majority of the impeller 74 is spaced significantly farther apart from the stators 90 and 94 than the magnetic pieces 88 are positioned from the stators 90 and 94.” Id. at 33–34. Claim 1 does not recite any feature based on the “vast majority” of a component and it is readily apparent from Petitioner’s own annotated version of Figure 11a that the distance from both the “motor magnets [88]” and “impeller 74” to the “circular electromagnetic stator[s] [90 and 94]” is the same. We agree with Patent Owner that Petitioner has provided a “misleading Figure with two red arrows denoting measurement distances to illustrate its incorrect view that the second magnetic device is farther from the magnetically driven rotor than from the first magnetic device.” PO Resp. 13–15 (providing an annotated version of Wampler’s Figure 11a with an orange arrow showing that in Wampler the distances from the second magnetic device to both the rotor and the first magnetic device are the same). Accordingly, Petitioner fails to show that Wampler teaches “the second magnetic device positioned axially closer to the first magnetic device than to the magnetically driven rotor.”” slip op. at 29

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable

    “To orient the pump in the least obtrusive position (i.e., in the human configuration, as in Figure 3), it was decided that the rotational axis of the pump’s rotor should be perpendicular to the body’s long axis. That resulted in a sharp bend in the flow before it enters the impeller. To minimize the losses in this transition, the flow is slightly accelerated through this elbow. that this type of elbow [i.e., the elbow used with Bourque’s centrifugal pump] was unnecessary,” applying Wampler to Bourque would have improved “blood flow.” Pet. 73 (citing Ex. 1003 ¶¶ 418–419; Ex. 1007, 402; Ex. 1008 ¶¶ 75–76). As explained above, Wampler does not teach that “this type of elbow” was unnecessary. Bourque uses a centrifugal pump with an additional elbow specifically so that the centrifugal pump may be oriented “in the least obtrusive position.” Ex. 1007, 402. Moreover, there is no persuasive evidence to support Petitioner’s assertion that eliminating the elbow from Bourque would improve “blood flow.” Mr. Crosby’s declaration provides no additional explanation or support to show how “blood flow” would have been improved. See Ex. 1003 ¶ 419. Nor does Mr. Crosby address the fact that Bourque expressly states that “flow is slightly accelerated” through the elbow to “minimize losses in this transition.” Ex. 1007, 402. Eliminating the elbow from Bourque, as Petitioner and Mr. Crosby propose, would mean the pump could no longer be placed in “the least obtrusive position” according to Bourque and there is no persuasive evidence that such a modification would improve blood flow.” slip op. at 45

  Patent outcomesUS 11,351,357 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,351,357
• Western Digital Technologies, Inc. v. Godo Kaisha IP Bridge 1Some claims unpatentable
  PTAB · Apr 29, 2026 · IPR2024-01493 · APJ John D Hamann · IPR · Final written decision

  Claims 1, 3, 5, 7–11, 14, and 15 are unpatentable as obvious; claims 2, 4, 6, 12, and 13 were not shown unpatentable because the references did not establish entirely crystallized CoFeB layers.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “In our Decision on Institution, we adopted the definition Petitioner proposes for one having ordinary skill in the art at the time of the invention of the ’167 patent. Dec. on Inst. 6. Namely, we found that one of ordinary skill in the art would have had “a Ph.D. in electrical engineering, physics, materials science, or a related field, and at least one year of experience in the research, design, and/or development of magnetic/spintronic devices, or the equivalent,” or “a Master’s degree in electrical engineering, physics, materials science, or a related field, and four years of experience in the research, design, and/or development of magnetic/spintronic devices, or the equivalent.” Id. (citing Pet. 20 (citing Ex. 1024 ¶ 25)). We also found that “[l]ess work experience may be compensated by a higher level of relevant education, and vice versa.” Id. Patent Owner does not address Petitioner’s definition, nor provide its own. See generally PO Resp. Because Petitioner’s definition of the level of skill in the art is consistent with the ’167 patent and the asserted prior art, we maintain it for purposes of this Final Written Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC, 57 F.3d at 1579; In re Oelrich, 579 F.2d 86, 91 (CCPA 1978).” slip op. at 7

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for petitioner

    “Here, neither party sets forth any term for claim construction. Pet. 17; see generally PO Resp. Thus, for purposes of this Decision, we afford the claim terms their plain and ordinary meaning. See, e.g., Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’”)).” slip op. at 8

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner

    “In addition, we agree with Petitioner and find that one of ordinary skill in the art “would have been motivated to replace either or both of Bowen’s electrodes with CoFeB to increase TMR and lower Hf [(coupling field)] and Hc [(coercivity)].” Pet. 24, 27; Ex. 1055,30 2270 (“[I]t is natural to replace both the free and pinned layers to CoFeB to further increase the TMR value.”); Ex. 105631 ¶¶ 67–68 (“[B]oth the ferromagnetic layers 5, 7 are made of an FeCoB”32 for “improvement of the TMR ratio.”); Ex. 1024 ¶¶ 129, 132. We credit Dr. Bokor’s cited testimony as it is consistent with the cited evidence. Moreover, as Petitioner explains, “[r]esearchers were . . . interested in optimizing MTJs to improve MRAM performance,” and “[h]igher TMRs long promised improved performance for MRAM.” Pet. 6 30 Dexin Wang et al., 70% TMR at room temperature for SDT sandwich junctions with CoFeB as free and reference layers, 40 IEEE Trans. Magn. 2269–71 (July 2004). 31 US 2004/0136232 A1, published July 15, 2004, to Hosomi. 32 We find persuasive Dr. Bokor’s testimony that “a skilled artisan [would have] understood that CoFeB and FeCoB refer to the same alloy.” Ex. 1024 ¶ 121. 36–44) (emphasis omitted). In addition, we agree with Petitioner that one of ordinary skill in the art “would have found it obvious to use Parkin’s CoFeB layer in place of Bowen’s electrodes to increase TMR” in light of Parkin’s explicit teachings. Pet. 27; Ex. 1024 ¶ 133. In particular, Parkin explicitly teaches that “very high TMR values are unexpectedly found for MTJs with highly textured (100) MgO tunnel barriers but with nominally amorphous storage layers.” Ex. 1062, 18:49–51. Notably, Parkin provides that “[t]he TMR of the device of F[igure] 3A is nearly two times higher than the highest TMR ever reported in prior art devices using conventional alumina tunnel barriers.” Id. at 18:63–65; Pet. 27. And as we discuss above, Parkin teaches that Figure 3A’s MTJ may be inverted, such that the storage layer is formed beneath the tunnel barrier. Ex. 1062, 17:7–10. In addition, we agree that one of ordinary skill in the art would have had a reasonable expectation of success in modifying Bowen in the manner Petitioner proposes, as forming electrodes with CoFeB alloys was known. Pet. 28. As Petitioner argues, “forming electrodes with CoFeB alloys in MTJs was known and had been successfully done,” and thus we are persuaded that “one of skill would have found it to be a straightforward, predictable, and desirable improvement to TMR, Hf, and Hc in Bowen’s” slip op. at 21

  • Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundDecided for petitioner

    “We find unavailing Patent Owner’s arguments that Bowen teaches a “radically different manufacturing process[] from the claimed invention,” and that Bowen “went to heroic lengths to provide a crystalline (001) bottom electrode that provides a template for epitaxially growing a crystalline MgO(001) layer.” PO Resp. 2 (emphasis omitted). Patent Owner describes in detail Bowen’s specific manufacturing process, including the specific structure of the MTJ manufactured, and argues the claimed invention differs. PO Resp. 30–33. These arguments are inapposite. Petitioner cites the specific teachings Petitioner relies on from Bowen, rather than adopting the entirety of Bowen’s process or MTJ. See, e.g., Pet. 21–36 (citing the portions of Bowen—that in combination with Parkin—teach claim 1). Petitioner is not “compelled to adopt every single aspect of [Bowen’s] teaching without the exercise of independent judgment.” Lear Siegler, Inc. v. Aeroquip Corp., 733 F.2d 881, 889 (Fed. Cir. 1984). We also find unavailing Patent Owner’s argument that Bowen and Parkin each teach away from Petitioner’s combination because Parkin used boron to avoid crystalline electrodes whereas Bowen tried to achieve perfect crystalline electrodes. PO Resp. 4. As we discuss above, one of ordinary skill in the art would have been motivated to replace Bowen’s electrodes with CoFeB to increase TMR. And Patent Owner does not identify in either reference a specific teaching that criticizes, discredits, or otherwise 35 M. Jimbo et al., Thermal stability of spin valves using amorphous CoFeB, 165 J. Magnetism & Magnetic Materials 308–11 (1997) (“Jimbo”). combination. In re Fulton, 391 F.3d 1195, 1201 (Fed. Cir. 2004).” slip op. at 23

  Patent outcomesUS 10,680,167 mixed
  Claim construction§ 103 obviousnesscites Phillips · Graham
  Patents in suitUS 10,680,167
• Western Digital Technologies, Inc. v. Godo Kaisha IP Bridge 1Some claims unpatentable
  PTAB · Mar 27, 2026 · IPR2024-01447 · APJ Sheila F Mcshane · IPR · Final written decision

  Claims 1–2 are unpatentable as obvious over each Bowen-based combination; claims 3–4 were not shown unpatentable, and the Nagahama-based grounds failed for all claims.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “In determining the level of ordinary skill in the art, various factors may be considered, including the “type of problems encountered in the art; prior art solutions to those problems; rapidity with which innovations are 5 Nagahama, EP 1391942 A1, published February 25, 2004 (Ex. 1027, “Nagahama”). made; sophistication of the technology; and educational level of active workers in the field.” In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995) (citation omitted). The level of ordinary skill in the art is also reflected by the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). Consistent with the Institution Decision (Dec. 7), we adopt the assessment offered by Petitioner as it is consistent with the ’134 patent and the asserted prior art. Patent Owner does not dispute that Dr. Bokor is qualified as a person of ordinary skill in the art in accordance with the assessment adopted. See Tr. 90:9–15. Patent Owner, however, questions Dr. Bokor’s knowledge on the formation of crystalline materials and seeks to exclude his related testimony. See PO Resp. 1–2, 27; PO Mot. Excl. 12–15. We address this issue infra Section V.” slip op. at 7

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Petitioner “submits the claim terms should be given their plain and ordinary meaning and no claim construction is necessary to find the claims unpatentable.” Pet. 24. Patent Owner does not raise any claim construction issues in its Response. See generally PO Resp. We determine that we need not expressly construe any claim terms to resolve the parties’ disputes. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 9

  • Strike new argumentNew argument consideredDenied

    “A reply may only respond to arguments raised” in the patent owner response. 37 C.F.R § 42.23(b). The Consolidated Trial Practice Guide states that responding “does not mean proceed[ing] in a new direction with a new approach,” and “[w]hile replies . . . can help crystalize issues for decision, a reply . . . that raises a new issue or belatedly presents evidence may not be considered,” that is, “Petitioner may not submit new evidence or argument in reply that it could have presented earlier, e.g. to make out a prima facie case of unpatentability.” Consolidated Trial Practice Guide § II.I (last updated Dec. 12, 2025) (“CTPG”), available at https://www.uspto.gov/patents/ptab/trial-practice-guide. We are not persuaded by Patent Owner’s assertions that Petitioner’s reply arguments on Parkin should not be considered. As discussed supra Section II.D.3.i above, the Petition includes the assertion that if Parkin’s CoFeB electrodes were used to modify Bowen, the MgO polycrystalline or single-crystal layer would still have the same 001 orientation. Pet. 33–34 (citing Ex. 1024 ¶ 129; Ex. 1062, 9:58–10:2, 18:49–51; Ex. 1005, 4:30–32). Petitioner’s support in the Petition references disclosures relating to Parkin’s Figure 3A (Ex. 1062, 18:49–51), which discloses a MgO(100) tunnel barrier, and the Petition also notes that the structure of Figure 3A may be inverted. Pet. 40 (citing Ex. 1062, 17:7–10). Patent Owner’s arguments, in large part, are related to Petitioner’s arguments in the Reply relating to Parkin’s Figure 11. Parkin’s Figure 11 is an embodiment where the structure of the devices of Figure 3A is inverted. See Ex. 1062, 22:29–33. We do not find that Petitioner’s arguments that are at issue in the Reply represent a new direction in its approach—the Petition is clearly based on the assertion that if Parkin’s CoFeB electrodes are used in Bowen, the device would have a MgO(001) tunnel barrier layer. Further, the Petition refers to Parkin’s disclosure that the device in Figure 3A may be inverted, which would be encompassed by the Figure 11 embodiment. Moreover, in the Institution Decision, we invited additional briefing on whether Parkin’s storage magnetic electrode was an amorphous ferromagnetic electrode, which relates to Parkin’s Figure 11 (Dec. 28–29). We are also not persuaded by Patent Owner’s argument that the Petition’s assertions do not correspond to what Petitioner argues in the Reply because they were referred to in the section pertaining to limitation 1[e]. The Petition includes a cross-reference in the limitation 1[d] discussion on the tunnel barrier layer limitation: “if Sunai’s or Parkin’s CoFeB electrodes are used as described in Claims 1[e] and 2 in this Ground, one of skill would understand that the MgO . . . would still have the same (001) orientation.” Pet. 33. Further, Petitioner’s arguments in its Reply properly respond to arguments made on contested issues. Patent Owner’s contentions on the merits in its Response are largely based upon the assertion that the modified MTJ of Bowen would not have a MgO(001) layer as claimed. See PO Resp. 4–10, 18–48. Petitioner’s reply arguments on Parkin relate to whether there would be a MgO(001) layer in its structure, so we find that Petitioner’s arguments on Parkin in its Reply (Pet. Reply 2–5) and the related evidence are appropriately responsive. slip op. at 17

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner

    “We find that there is sufficient evidence in support of Petitioner’s assertion of the rationale to replace Bowen’s electrodes with CoFeB and anneal them. As discussed supra Section II.D.ii.2, Parkin’s Figure 11 depicts and describes a storage electrode that may be composed of amorphous CoFeB, with the formation of a MgO(001) barrier layer atop it. See Ex. 1062, 22:29–66. Patent Owner argues that Parkin’s benefits are because its CoFeB electrode is amorphous (PO Resp. 51–52), but this is not accurate. In Parkin, the CoFeB amorphous electrode crystallized at the interface layer between the barrier and the electrode. Id. at 19:6–19. Parkin discloses that higher TMRs were attributable to the crystallization of CoFeB. Id. at 18:63–19:22. Parkin also discloses that its completed CoFeB- MgOH(001)-CoFeB device was annealed with resulting high TMRs. Id. at 17:60–18:16. These disclosures provide support that one of skill in the art would have been motivated to replace Bowen’s electrodes with CoFeB and anneal to crystallize them because of the known improvements of TMR. Additionally, Parkin’s disclosures support that the results of the combination would have been predictable. That is, Parkin actually discloses an amorphous CoFeB electrode, formation of a MgO(001) tunnel barrier on the amorphous electrode, and annealing the assembly, with a resulting high TMR. Accordingly, Petitioner has provided reasoning with rationale underpinning for the motivation to combine. See KSR, 550 U.S. at 415 (“[t]he combination of familiar elements according to known methods is likely to be obvious when it does no more than yield predictable results”).” slip op. at 31

  Patent outcomesUS 8,405,134 mixed
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,405,134
• Samsung Electronics Co., Ltd. / Samsung Electronics America, Inc. v. Power2b, Inc.All claims unpatentable
  PTAB · Mar 13, 2026 · IPR2021-01266 · APJ John D Hamann · IPR · Remand

  On remand, the Board held claims 29, 36–38, 44–46, 48, 49, and 56–58 unpatentable as obvious over Reime, with additional grounds also supporting the challenged claims.

  RulingsRemand decision

  • ExcludeMotion to exclude, deniedDenied

    “In addition, Patent Owner filed a Motion to Exclude certain of Petitioner’s evidence (Paper 32) and Petitioner filed an Opposition (Paper 33). We denied this motion. See Final Dec. 58–61.” slip op. at 3

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for petitioner

    “transmission paths. See Pet. Reply 14–15; PO Sur-reply 15. And we agree with both parties that the light that is transmitted directly through the plate to the sensor element does not have intervening reflections—such is consistent with the plain and ordinary meaning of “directly to.” See PO Resp. 31–32; Pet. Reply 14–15; PO Sur-reply 15. Nothing in claim 48’s language, however, requires that all of the reflected light be transmitted directly to the sensor element, which Patent Owner argues. Ex. 1001, 70:32–35; PO Resp. 31–32; PO Sur-reply 14–16. Rather, we agree with Petitioner that the claim language “merely requires that some light reflected by the object goes ‘directly to’ at least one sensor element once it is transmitted through the viewing plane defining plate.” Pet. Reply 14. We also agree that “none of these dependent claims purport to be exclusive of one another.” Id. at 15. Rather, claims 46–48 simply require some light be transmitted (or propagated) for their particular transmission path, without reciting all light. See Ex. 1001, 70:24–35.” slip op. at 13

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableNot shown unpatentableMixed

    “We find Petitioner’s arguments based on Reime alone insufficient. Thus, we find that Petitioner does not show by a preponderance of the evidence that claim 49 is rendered obvious by Reime alone.” slip op. at 52

  • Obviousness (§103) › KSR rationalesUnpatentableUnpatentable

    “And in view of the above, we find persuasive Dr. Bederson’s testimony that “[c]hoosing a multi-element detector or a single-element detector would have been a simple design choice using commercially available detectors.” Ex. 1002 ¶ 117. Accordingly, we find that one of ordinary skill in the art would have found it obvious for Reime’s receivers to be implemented using discrete single-element detectors. See KSR, 550 U.S. at 417 (“When there is a design need or market pressure to solve a problem and there are a finite number of identified, predictable solutions, a person of ordinary skill has good reason to pursue the known options within his or her technical grasp. If this leads to the anticipated success, it is likely the product not of innovation but of ordinary skill and common sense.”). We find unavailing Patent Owner’s argument that “Petitioner relies on expert testimony to gap-fill missing elements regarding Reime’s failure to disclose or suggest the different claim arrangements of detector elements in a ‘detector assembly.’” PO Resp. 78 (citing Ex. 1002 ¶¶ 111–119; Ex. 2056 ¶ 171). Rather, in light of Reime’s teachings, coupled with the general knowledge of one of ordinary skill in the art, it would have been obvious to employ discrete single-element detectors for Reime’s receivers. See Koninklijke Philips N.V. v. Google LLC, 948 F.3d 1330, 1338 (Fed. Cir. 2020) (finding obviousness can rely on supported expert testimony to supply an element of a claim). We appropriately consider such evidence of the knowledge that one of ordinary skill in the art would have had as part of our obviousness analysis. See Randall Mfg. v. Rea, 733 F.3d 1355, 1362–63 (Fed. Cir. 2013). Moreover, “AAPA can be important evidence of general background knowledge, and general knowledge can be used to supply a missing claim 1371, 1378–79 (Fed. Cir. 2025). Here, Petitioner relies on the cited AAPA as evidence of one of ordinary skill in the art’s general knowledge at the time of the ’093 patent, and the AAPA is not the basis for this ground. See Pet. 4, 42–43; Pet. Remand 4–5. As Shockwave Med. explains, Federal Circuit “case law has long recognized numerous permissible uses for general background knowledge in an IPR such as, ‘for example, furnishing a motivation to combine, or supplying a missing claim limitation.” 142 F.4th at 1378–79 (quoting Qualcomm Inc. v. Apple Inc., 24 F.4th 1367, 1376 (Fed. Cir. 2022) (citing Randall Mfg., 733 F.3d at 1362; Koninklijke, 948 F.3d at 1337–38)).” slip op. at 31

  Patent outcomesUS 9,569,093 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · Graham
  Patents in suitUS 9,569,093
• Samsung Electronics Co., Ltd. / Samsung Electronics America, Inc. v. Power2b, Inc.All claims unpatentable
  PTAB · Mar 13, 2026 · IPR2021-01239 · APJ John D Hamann · IPR · Remand

  On remand, the Board held claims 17, 18, 21, 22, 26, and 30 unpatentable as obvious over Reime, with claims 17, 18, 21, 22, and 30 also obvious over Reime and Hinckley.

  RulingsRemand decision

  • ExcludeMotion to exclude, deniedDenied

    “In addition, Patent Owner filed a Motion to Exclude certain of Petitioner’s evidence (Paper 28) and Petitioner filed an Opposition (Paper 34). We denied this motion. See Paper 41, 47–50.” slip op. at 3

  • Skill levelSkill level board ownOther

    “one having ordinary skill in the art at the time of the invention of the ’850 patent: one who “would have had a bachelor’s degree in electrical engineering, computer engineering, computer science, or a related field, and . . . years of experience in the research, design, development, and/or testing of touch and/or proximity sensors, human-machine interaction and 3 The Leahy-Smith America Invents Act (“AIA”) included revisions to 35 U.S.C. § 103 that became effective on March 16, 2013. Because the ’850 patent issued from an application filed before March 16, 2013, we apply the pre-AIA version of the statutory basis for unpatentability. 4 US 2003/0034439 A1, published Feb. 20, 2003 (Ex. 1010, “Reime”). 5 US 2002/0021278 A1, published Feb. 21, 2002 (Ex. 1011, “Hinckley”). Petitioner lists the combination of Reime and Hinckley as a separate asserted ground for claim 26. We combine these two asserted grounds into one as they rely on the same combination. additional education substituting for experience and vice versa.” Final Dec. 8–9. This definition for one having ordinary skill was not the subject of appeal, and we maintain it for purposes of this Final Written Decision on Remand. Moreover, it is consistent with the ’850 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 8

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner

    “PO Resp. 17–29; Pet. Reply 8–15; PO Sur-reply 6–11. We construed this term in the Final Written Decision. Final Dec. 10–24. In particular, we concluded that (i) “detector assembly” means “two or more detector elements that detect electromagnetic radiation,” and (ii) a detector assembly is not required to be physically separate from (i.e., not interspersed with) a pixel array. Id. at 20, 22. The Federal Circuit found the first part of our construction erroneous. Appeal Dec. 7–10. In particular, the Federal Circuit concluded that “[t]he element.” Id. at 8. In addition, to guide the Board’s analysis on remand, the Federal Circuit construed “the terms ‘at an edge’ and ‘at least one edge’ [to] require a detector assembly to be arranged along one or more edges of a viewing plane defining plate.” Id. at 10–11. In other words, the Federal Circuit “clarif[ied] that arranging a detector assembly ‘at,’ ‘along,’ or ‘about’ ‘at least one edge’ or ‘an edge’ does not limit the detector assembly to being arranged entirely on ‘one edge.’” Id. at 12.” slip op. at 9

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable

    “the Federal Circuit already has concluded that claim 15 is obvious in view of Reime. Appeal Dec. 9–10. Claim 17 further recites “wherein the detector assembly comprises: a support substrate, and an arrangement of detector elements.” Ex. 1001, 67:15–18. We agree with Petitioner and find that Reime teaches these further limitations. Pet. 34–35; Pet. Remand 2–4; Pet. Resp. Remand 1–3. First, as we found in the Final Written Decision, Reime’s receivers 30 and 32 are two detector elements that detect electromagnetic radiation (i.e., light), and Reime’s receivers 30 and 32, collectively, comprise a detector assembly. Final Dec. 27–28 (citations omitted). Moreover, Reime’s two receivers 30 and 32 comprise a detector assembly having multiple detector elements (e.g., two receivers) to teach “an arrangement of detector elements.” Ex. 1010 ¶¶ 73, 86, Figs. 9A–9C; Ex. 2060,7 127:17–18; Pet. 32–33; Pet. Reply 20; Pet. Remand 3. In addition, as we found in the Final Written Decision, Reime teaches that each of receivers 30 and 32 are centered on opposite edges of the plate. 7 Deposition Transcript of Dr. Benjamin Bederson (Apr. 7, 2022). Ex. 1010, Fig. 6A, ¶ 82) (affirming that Reime teaches having one light receiver (e.g., 30 or 32) on each side of a four-sided touch pad). In further support, we agree with Petitioner and find that Reime teaches that receivers 30 and 32 “are mounted in the peripheral area surrounding the LCD 92.” Pet. 32–33; Ex. 1010 ¶ 86; see also id. at Figs. 9A–9C (showing that the receivers are positioned at the edge of the LCD screen); infra annotated Fig. 9E (showing receivers 30 and 32 along edges of the LCD). Accordingly, we find Reime’s detector assembly that comprises receivers 30 and 32 is arranged along two edges (one edge for each receiver) of the LCD, which meets the Federal Circuit’s construction for being arranged at at least one edge. See supra Section III (concluding “at least one edge” means “arranged along one or more edges”) (emphasis added).” slip op. at 12

  Patent outcomesUS 8,624,850 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · Graham
  Patents in suitUS 8,624,850
• Early Warning Services, LLC v. Intellectual Ventures II LLCNo claims unpatentable
  PTAB · Feb 11, 2026 · IPR2024-01221 · APJ Iftikhar Ahmed · IPR · Final written decision

  Petitioner failed to prove claims 1, 2, 4, 5, 7, 8, 12, 13, 17, 19–21, 23, 24, 26, 27, 29, 30, 34, 39–41, and 43 unpatentable because the cited grounds did not establish the required …

  RulingsFinal written decision

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner

    “image capture device” refers to an imaging-based barcode reader and not a laser-based barcode scanner because we are persuaded that claim language and Specification support that interpretation and also because Patent Owner persuasively shows that a person of ordinary skill in the art would have understood the term as such. Claim 1 recites an “image capture device configured to capture an image.” Ex. 1001, 16:24–25. The plain meaning of the claim term requires that the image be captured, not just scanned. The claim further requires “generating an output based on the information embedded in the image,” requiring that information is retrieved from the captured image. Id. at 16:32–33. A device that does not capture an image is not an “image capture device” under the plain language of the claim. A laser-based barcode scanner employs light reflected from a laser beam to “generate an electrical signal that corresponds to the bars and spaces in the barcode being scanned.” See Ex. 2029 ¶¶ 42–43 (explaining in detail how laser-based barcode self-emitting a laser light across a code to be scanned, with a sensor tuned to capture the reflected light from the laser.”). It simply does not capture an image. slip op. at 14

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Based on our review of the complete record, we determine that Petitioner’s stated level of ordinary skill in the art is reasonable because it is consistent with the evidence of record, including the asserted prior art. The field of the ’167 patent “relates generally to secure transactions, and more specifically, to methods and devices for providing secure identification, verification, and authorization using a portable secure device.” Ex. 1001, 1:8–11. The ’167 patent seeks “to provide methods and devices that are capable of providing secure transactions in a more efficient manner.” Id. at 3:11–13. Accordingly, we adopt Petitioner’s definition. We note, however, that our patentability analysis would be the same under Patent Owner’s definition.” slip op. at 11

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable

    “We agree with Patent Owner that Wang fails to disclose limitation 1[a]. Wang discloses a portable electronic authorization device (PEAD) that can be used as a self-checkout terminal. Ex. 1004 ¶ 115. In this context, Wang discloses By entering the UPC code or barcode using keypad on the PEAD or scanning in the UPC code or barcode using the input device built into the PEAD such as a barcode scanner or OCR reader, the PEAD can generate the receipt with the list of item prices through the wireless network and Internet by querying the item price using the barcode as the index for price lookup table which is Stored in a Server System. Id. (emphasis added). As discussed above (Section III.C.1), we are persuaded by Patent Owner’s arguments that the claimed “image capture device” refers to an imaging-based device and not a laser-based barcode scanner. Petitioner does not contend that Wang’s disclosure of the barcode scanner necessarily refers to an imaging-based device, but argues that Wang’s disclosure is sufficient because “both imaging-based barcode scanners and laser-based barcode scanners constitute image capture devices.” Reply 11. In light of our claim construction above, we disagree.” slip op. at 27

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable

    “Petitioner contends that claims 1, 4, 5, 7, 12, 17, 23, 26, 27, 29, 34, and 43 are unpatentable as obvious over the combination of Wang and Drummond. Pet. 30–43. 1. Drummond Drummond is a patent titled “Automated Banking Machine System and Method,” and “relates to an automated banking machine apparatus and system that are capable of use in a wide area network, and which provides a user with a remote electronic receipt or other record related to a transaction performed at the machine.” Ex. 1008, code (54), ¶ 2. Drummond discloses that its automated banking machine, may “initiate the sending of a non-paper transaction receipt to the customer,” “[t]he receipt may be sent using a wide area network, such as the Internet,” and “[t]he receipt may be an electronic receipt, for example a receipt in the form of an e-mail message.” Id. ¶ 247. 2. Claims 1, 4, 5, 7, 12, 17, 23, 26, 27, 29, 34, and 43 For this obviousness ground, Petitioner relies on the same arguments and evidence as its Ground 1a (anticipation by Wang), discussed above, for the majority of claim limitations. See Pet. 33–43. Importantly, Petitioner relies solely on Wang as teaching independent claim limitations [1a], [23a], and [43b] relating to an image capture device and embedded information. Pet. 36, 41, 43. Accordingly, for the reasons discussed above with respect to Ground 1a, Petitioner has not established by a preponderance of the evidence, that the subject matter of claims 1, 4, 5, 7, 12, 17, 23, 26, 27, 29, 34, and 43 would have been obvious to one of ordinary skill in the art over the combination of Wang and Drummond.” slip op. at 31

  Patent outcomesUS 7,314,167 not shown unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 7,314,167
• Luxottica Of America Inc. v. E-Vision Smart Optics, Inc.All claims unpatentable
  PTAB · Dec 30, 2025 · IPR2024-01072 · APJ John D Hamann · IPR · Final written decision

  Claims 1–26 are unpatentable as obvious over the listed prior-art combinations; the Board also denied Patent Owner’s motion to strike.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “In our Decision on Institution, we adopted the definition Petitioner proposes for one having ordinary skill in the art at the time of the invention of the ’960 patent. Dec. on Inst. 10. Namely, we found that one of ordinary skill in the art “would have had at least a bachelor’s degree in mechanical or manufacturing engineering; mechatronics; electrical engineering plus coursework in mechanical engineering, manufacturing engineering, or mechatronics; or a similar technical degree,” and “at least 2 years of experience designing eyewear and/or consumer electronics,” and that “[w]ork experience could substitute for formal education and additional formal education could substitute for work experience.” Id. (citing Pet. 10–11 (citing Ex. 1003 ¶ 28)) (alteration in original). Patent Owner proposes a different definition for one of ordinary skill in the art, but does not specifically address any deficiencies in Petitioner’s proposed definition. PO Resp. 6. Because Petitioner’s definition of the level of skill in the art is consistent with the ’960 patent and the asserted prior art, we maintain it for purposes of this Final Written Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC, 57 F.3d at 1579; In re Oelrich, 579 F.2d 86, 91 (CCPA 1978). Our analysis herein, however, does not turn on which of the parties’ definitions we adopt.” slip op. at 8

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededPlain and ordinary meaningOther

    “Here, neither party sets forth any term for claim construction. Pet. 11; PO Resp. 5–6; Pet. Reply 1–2. We determine that we do not need to construe any term to resolve the disputes between the parties. Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’”). We afford the claim terms their plain and ordinary meaning.” slip op. at 9

  • Obviousness (§103) › Analogous artAnalogous artDecided for petitioner

    “A reference qualifies as prior art for a determination under § 103 when it is analogous to the claimed invention. In re Clay, 966 F.2d 656, 658 (Fed. Cir. 1992). “Two separate tests define the scope of analogous prior art: (1) whether the art is from the same field of endeavor, regardless of the problem addressed, and (2) if the reference is not within the field of the particular problem with which the inventor is involved.” In re Bigio, 381 F.3d 1320, 1325 (Fed. Cir. 2004) (citing In re Deminski, 796 F.2d 436, 442 (Fed. Cir. 1986)). Below we focus on the first of these tests. “We determine the field of endeavor ‘by reference to explanations of the invention’s subject matter in the patent application, including the embodiments, function, and structure of the claimed invention.’” Netflix, Inc. v. DIVX, LLC, 80 F.4th 1352, 1359 (Fed. Cir. 2023) (quoting In re Bigio, 381 F.3d at 1325)). We agree with Petitioner and find that the ’960 patent is in the field of eyewear and consumer electronics. Pet. 13. The ’960 patent discloses that its “subject matter is directed to electronic eyewear modules and systems to be worn by a wearer, whereby an electronic eyewear system with a docking station can be easily joined with a plurality of electronic application modules.” Ex. 1001, 1:66–2:4; Pet. 9. We also agree with Petitioner that the ’960 patent acknowledges “a need for a single pair of fashionable eyewear capable of . . . utilizing one or more of a multitude of different application devices while the wearer is wearing the eyewear.” Ex. 1001, 1:59–62; Pet. Reply 13. Patent Owner argues that “[t]he ’960 [p]atent pertains to the field of wearable embedded electronics, namely ‘commercial eyewear comprising electronics.’” PO Resp. 24 (citing Ex. 1001, 1:24–25). We view the parties’ descriptions of the field of the ’960 patent to be substantively the same.” slip op. at 25

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner

    “We also find persuasive Petitioner’s argument and Dr. Feland’s testimony that Jannard’s “application module for eyewear is one such suitable device in which to incorporate Rosenblatt’s key or its functionality.” Pet. 47 (citing Ex. 1003 ¶ 156). This argument and testimony are consistent with Rosenblatt’s teaching of a wide variety of suitable devices. Compare id. and Ex. 1003 ¶ 156, with Ex. 1007 ¶ 7. Moreover, as Petitioner argues, Rosenblatt teaches that its “key . . . may include a clip or other connecting mechanism for attaching [the] key . . . to an object that the user typically carries,” such as “a user’s wallet, cellular telephone, personal media device (e.g., an iPod), wired headset, wireless headset, watch, bag, belt, article of clothing, or any other suitable object.” Ex. 1007 ¶ 43 (emphasis added). We find persuasive Dr. Feland’s testimony that Jannard’s eyewear system is a carried object like a wired or wireless headset in the context of Rosenblatt’s teaching. See Ex. 1003 ¶ 156; Ex. 1007 ¶ 43. We also find persuasive Dr. Feland’s testimony that incorporating Rosenblatt’s key or its functionality into Jannard’s application module “desirably ‘provid[es] functional fashion having device operation capabilities,’ which is consistent with Rosenblatt recommendations.” Ex. 1003 ¶ 156 (quoting Ex. 1007 ¶ 58) (alteration in original); Ex. 1007 ¶ 58 (“[T]he key may be integrated with operation capabilities.”). We also find persuasive Petitioner’s argument and Dr. Feland’s testimony that one of ordinary skill in the art would have been motivated to incorporate Rosenblatt’s key or its functionality in Jannard’s application module to achieve the benefits disclosed in Rosenblatt, including controlling host devices responsive to wireless communication with Jannard’s application module. Pet. 47; Ex. 1003 ¶ 156. We view this as using a known technique (Rosenblatt’s teaching of incorporating a key or its functionality into an electronic device) to improve a similar device (Jannard’s eyewear and application module with wireless communication for functions) in the same way. See KSR, 550 U.S. at 417 (“[I]f a technique has been used to improve one device, and a person of ordinary skill in the art would recognize that it would improve similar devices in the same way, using the technique is obvious unless its actual application is beyond his or her skill.”); see also Pet. 48; Ex. 1003 ¶ 157.” slip op. at 14

  Patent outcomesUS 10,598,960 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · Graham
  Patents in suitUS 10,598,960

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.