• Aylo Freesites Ltd v. DISH Technologies L.L.C.Some claims unpatentable
  PTAB · Feb 2, 2026 · IPR2024-00940 · APJ John A Hudalla · IPR · Final written decision

  Claims 1–11 are unpatentable as obvious over Leaning and over Leaning with Klemets; claims 12–20 were not shown unpatentable on the asserted grounds.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Level of Ordinary Skill in the Art Citing testimony from Dr. Houh, Petitioner contends a person of ordinary skill in the art “would have had at least a B.S. degree in computer science or electrical engineering (or comparable degree) and two years of experience in networking or streaming media, or a M.S. in computer science or electrical engineering (or comparable degree).” Pet. 12 (citing Ex. 1003 ¶ 45). Patent Owner does not address the level of ordinary skill in the art in its post-institution papers. We adopt Petitioner’s definition of the level of ordinary skill in the art. On the present record, we are satisfied that this definition of the level of skill is consistent with the teachings of the ’234 patent and the asserted prior art.” slip op. at 11

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “We determine that no construction of “virtual timeline” is necessary. See, e.g., Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). Rather, as discussed below, the parties’ dispute appears to be about whether the “virtual timeline” identified by Petitioner is used to arrange the requested streamlets, as is also recited in claim 9. We address that argument below. See infra § II.D.10.” slip op. at 13

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for patent owner

    “On this record, we determine that the recitation “to achieve continuous presentation” is limiting and requires an amount of continuous (uninterrupted) playback/presentation after an upshift or downshift. The specification describes agent controller 702 determining whether to upshift based on a trigger threshold Θup, which itself is based on various factors including a current read ahead margin and a minimum safety margin. See Ex. 1001, 17:44–58. If agent controller 702 can sustain upshift quality, then it will upshift and request higher quality streams. See id. at 17:58–61. Conversely, when an upshift is not possible, agent controller 702 determines whether to downshift based a different threshold Θdown, which itself is based on the same sort of factors. See id. at 18:4–7. When the stream quality is not adequate, it downshifts. See id. at 18:7–14. These disclosures are similar to the language of claim 12, which recites “repeatedly generating a factor indicative of a current ability to receive the digital content at a rate sufficient for presenting the digital content as the digital content is received, . . . wherein the factor relates to a performance of the network” and “making the successive determinations whether to change the requested bit rate based on the factor to achieve continuous presentation of the digital content using the individually-requestable portions of the highest bit rate one of the copies determined receivable at that time.” Ex. 1001, 20:5–16 (emphasis added). That is, claim 12 refers to “achiev[ing] continuous presentation” based on what is “sufficient for presenting the digital content,” trading quality to ensure continuous playback.” slip op. at 14

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundUnpatentableUnpatentable

    “server comprises at least two servers and wherein at least one streamlet is requested from a first of the at least one server and at least one other streamlet is requested from a second server of the at least one server other than the first server.” Ex. 1001, 19:7–12. Petitioner references its mapping of the “at least one server” in claim 1 to Leaning’s server 1. Pet. 20 (citing Ex. 1004, 2:15–16, 2:18–22, 2:31–32, 5:8–14, Fig. 1), 23 (citing Ex. 1004, 6:13–26, 9:3–7, 16:6–12), 37; see supra §§ II.D.2.b–c. Petitioner contends that, “[t]o the extent Leaning does not disclose at least two servers wherein one sub-file (streamlet) is requested from a first server and another sub-file (streamlet) is requested from a second server such an arrangement would have been obvious in view of the knowledge of a [an ordinarily skilled artisan].” Id. at 37. Citing the common nature of such an arrangement, Petitioner contends that an ordinarily skilled artisan would have been motivated to provide multiple web servers containing the same sets of sub-files for streams in order to have redundancy in the system and allow for clients to establish connections with multiple servers and request a first sub-file from a first web server and, if the connection between the first web server becomes congested or the first web server otherwise fails or becomes unavailable, request a subsequent sub-file from the second web server. Id. at 37–38 (citing Ex. 1003 ¶ 85; Ex. 1012, 108,5 Fig. 4-11). Patent Owner does not dispute Petitioner’s analysis for claim 3. We are persuaded that it would have been obvious to implement Leaning’s server 1 as two servers that store different streamlets based on Dr. Houh’s uncontested testimony about system redundancy. See Ex. 1003 ¶ 85. His testimony is backed by a contemporaneous reference about HTTP that shows requests for different objects from different servers over parallel TCP connections. See, e.g., Ex. 1012, 108–09, Fig. 4-11. Thus, we determine that Petitioner has shown, by a preponderance of the evidence, that the subject matter of claim 3 would have been obvious over Leaning.” slip op. at 34

  Patent outcomesUS 11,991,234 mixed
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,991,234
• Lenovo (United States), Inc. v. University Of RochesterSome claims unpatentable
  PTAB · Feb 2, 2026 · IPR2024-01225 · APJ Thu A Dang · IPR · Final written decision

  Claims 1 and 3–7 are unpatentable as obvious; claims 8–12 were not shown unpatentable because the asserted grounds did not establish asynchronous operation between domains.

  RulingsFinal written decision

  • Claim Construction › Intrinsic evidence (Phillips canons) › Specification disavowal / 'present invention' languageDisclaimer not foundDecided for petitioner

    “specification is the ‘single best guide to the meaning of a disputed term,’ . . . and ‘is, thus, the primary basis for construing the claims.’” Trs. of Columbia Univ. in City of New York v. Symantec Corp., 811 F.3d 1359, 1362 (Fed. Cir. 2016) (citations omitted). Although Patent Owner contends that the Specification disparages systems that impose significant restrictions on the possible choices of frequencies (PO Resp. 21), we find availing Petitioner’s contention that “[s]upport for Patent Owner’s construction is absent from the specification.” Pet. Reply 10. As Petitioner points out, Patent Owner’s claim construction “appears to be based on a single paragraph of the ’443 patent referring to preexisting ‘synchronization schemes [that] restrict the phase relationship and relative frequencies of the clocks.” Id. That is, the only reference by Patent Owner to the Specification is that the Specification states that “Some synchronization schemes restrict the . . . relative frequencies of the clocks, thereby eliminating the need for hardware arbitration [27]. Unfortunately, these schemes impose significant restrictions on the possible choices of frequences.” PO Resp. 26 (citing Ex. 1001, 6:32–36). We agree with Petitioner that such disclosure in the Specification “does not describe how these synchronization schemes ‘restrict the phase relationship and relative frequencies’ with any specificity.’” Pet. the Specification that some schemes impose restrictions on the possible choices of frequency is not a disparagement of any system that has limited choices of frequency or would preclude the claims from covering such prior art techniques. Instead, as Petitioner points out, the Specification of the ’443 patent states “[t]he preferred embodiment uses four domains […] so that domains may vary somewhat in size and still be covered by a single clock.” Id. (citing Ex. 1001, 5:57–59). As Dr. Baker testified in support of Petitioner’s contention, “the preferred embodiment of the ’443 patent relies on a single external master clock that distributes a signal to the local PLL of each domain.” See Ex. 1032 ¶ 9. Thus, although Patent Owner contends that clock signals generated based on a master clock cannot be interpreted to be generated independently of the clock signals generated for others of the plurality of domains (PO Resp. 49), we agree with Petitioner that such claim construction would “exclude[] the preferred embodiment of the ’443 patent,” which is disfavored. Pet. Reply 11. For the reasons discussed above, we conclude that “changeable independently” of the other domains does not require that the separate clocks in the plurality of domains be globally-asynchronous.” slip op. at 12

  • Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportPriority date, deniedDecided for petitioner

    “As both parties recognize, (PO Resp. 5; Pet. Reply 12), “[actual] [r]eduction to practice in the United States requires that the invention be embodied in tangible form.” Scott v. Koyama, 281 F.3d 1243, 1247 (Fed. Cir. 2002). In particular, actual reduction to practice requires a showing of the invention in a physical or tangible form that shows every element. not sufficient. See Kimberly-Clark v. Johnson & Johnson, 745 F.2d 1437, 1445 (Fed. Cir. 1984). Here, Patent Owner does not provide any evidence showing every element of the claims in physical or tangible form, as required, but rather contends that the Specification refers to the Paper, wherein the Paper stated that simulation using a software, SimpleScalar, was performed. PO Resp. 16. We are persuaded by Petitioner’s contention that the SimpleScalar simulation was not an actual reduction to practice of the claimed invention. Pet. Reply 12. As Petitioner points out, claim 1, for example, is directed to a “microprocessor,” wherein “Patent Owner has presented no evidence and has not alleged that any physical microprocessor was ever produced or operated.” Id. at 13; see PO Resp. 15–17. And as Petitioner points out, “Patent Owner has produced no evidence of any physical prototype of the claimed microprocessor that could have validated the simulation.” Pet. Reply 13–14. We agree with Petitioner that, at most, such simulation “demonstrated feasibility for prototyping of a microprocessor,” but not a tangible form of the microprocessor itself as required for an actual reduction to practice. Id. at 14; see also Standard Mfg. Co. v. United States, 25 Cl. Ct. 1, 67 (1991) (“The feasibility of the optical alignment system may have been proven by the optical mock-up, but the optical mock-up was not a reduction to practice of the proposed MHU–145/M trailer.”).” slip op. at 36

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableNot shown unpatentableMixed

    “Here, we find that Petitioner has not met its burden to prove that one of ordinary skill in the art would have recognized that “the functional units of Georgiou operate asynchronously since they have different clocks.” Pet. 74 (citing Ex. 1002 ¶¶ 53–56, 211–219). Specifically, although Petitioner relies on Georgiou for teaching different clocks, Petitioner’s conclusory statement that such application would operate asynchronously requires gapfilling. Id. As Patent Owner points out, Georgiou discloses a clocking architecture in which “all domain clocks are derived from a shared master clock through predetermined rational dividers.” PO Resp. 49. Petitioner concedes during the oral hearing that, in systems such as Georgiou, each domain clock is set a fraction of a master clock, and thus, the various domain clocks are “possibly” synchronous with each other. Tr. 59:4–14 (JUDGE DANG: . . . would being fractions of the master, wouldn’t they be synchronized with each other? MR UHR: They may be, . . . the answer is possibly.”) Thus, we find Petitioner’s contention that a POSITA would have recognized that the functional units of Georgiou operate “asynchronously” lacks sufficient support in the record. We find the testimony of Dr. Baker insufficient to support Petitioner’s position. Ex. 1002 ¶¶ 53–56, 213, 215–219. In his declaration, Dr. Baker testified that he “provided several references . . . that explain operating domains asynchronous to one another while the domains operate synchronously.” Id. ¶¶ 215–219. However, although such references explain “globally asynchronous, local synchronous (GALS) systems” (id. ¶ 216), Dr. Baker does not explain why a POSITA “would have known that a functional unit of Georgiou also operates asynchronous with respect to at different frequencies.” Id. ¶ 217. Without evidentiary support, we are left with speculation and impermissible hindsight. See in Re Wagner, 379 F.2d 1011, 1017 (CCPA 1967). We decline to engage in speculation. See, e.g., In re Vaidyanathan, 381 F. App’x 985, 993 (Fed. Cir. 2010); In re Wallen, 565 F. App’x 867, 869 (Fed. Cir. 2014), both citing In re Zurko, 258 F.3d 1379, 1386 (Fed. Circ. 2001) ([T]he Board must point to some concrete evidence in the record in support of these findings.”). In sum, based on our review of the record, we find Petitioner’s showing is insufficient. Thus, based on the complete record presented, we determine that Petitioner has not persuasively shown that Georgiou teaches “operating the microprocessor such that each domain operates synchronously, while the domains operate asynchronously relative to one another,” as recited in claim 8.” slip op. at 28

  • BurdenMixed

    “of ordinary skill in the art would have recognized that “the functional units of Georgiou operate asynchronously since they have different clocks.” Pet. 74 (citing Ex. 1002 ¶¶ 53–56, 211–219). Specifically, although Petitioner relies on Georgiou for teaching different clocks, Petitioner’s conclusory statement that such application would operate asynchronously requires gapfilling. Id. As Patent Owner points out, Georgiou discloses a clocking architecture in which “all domain clocks are derived from a shared master clock through predetermined rational dividers.” PO Resp. 49. Petitioner concedes during the oral hearing that, in systems such as Georgiou, each domain clock is set a fraction of a master clock, and thus, the various domain clocks are “possibly” synchronous with each other. Tr. 59:4–14 (JUDGE DANG: . . . would being fractions of the master, wouldn’t they be synchronized with each other? MR UHR: They may be, . . . the answer is possibly.”) Thus, we find Petitioner’s contention that a POSITA would have recognized that the functional units of Georgiou operate “asynchronously” lacks sufficient support in the record. We find the testimony of Dr. Baker insufficient to support Petitioner’s position. Ex. 1002 ¶¶ 53–56, 213, 215–219. In his declaration, Dr. Baker testified that he “provided several references . . . that explain operating domains asynchronous to one another while the domains operate synchronously.” Id. ¶¶ 215–219. However, although such references explain “globally asynchronous, local synchronous (GALS) systems” (id. ¶ 216), Dr. Baker does not explain why a POSITA “would have known that a functional unit of Georgiou also operates asynchronous with respect to at different frequencies.” Id. ¶ 217. Without evidentiary support, we are left with speculation and impermissible hindsight. See in Re Wagner, 379 F.2d 1011, 1017 (CCPA 1967). We decline to engage in speculation. See, e.g., In re Vaidyanathan, 381 F. App’x 985, 993 (Fed. Cir. 2010); In re Wallen, 565 F. App’x 867, 869 (Fed. Cir. 2014), both citing In re Zurko, 258 F.3d 1379, 1386 (Fed. Circ. 2001) ([T]he Board must point to some concrete evidence in the record in support of these findings.”). In sum, based on our review of the record, we find Petitioner’s showing is insufficient. Thus, based on the complete record presented, we determine that Petitioner has not persuasively shown that Georgiou teaches “operating the microprocessor such that each domain operates synchronously, while the domains operate asynchronously relative to one another,” as recited in claim 8.” slip op. at 28

  Patent outcomesUS 7,089,443 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 7,089,443
• Boe Technology Group Co., Ltd. v. Optronic Sciences LLCSome claims unpatentable
  PTAB · Jan 26, 2026 · IPR2024-01130 · APJ Benjamin D M Wood · IPR · Final written decision

  Claims 5 and 6 are unpatentable over the instituted grounds; claims 7–9 were not shown unpatentable because their scope could not be ascertained.

  RulingsFinal written decision

  • PTAB / AIA Trials › Real party in interest / privityRpi dispute resolved for petitionerDecided for petitioner

    “After the hearing, with our authorization,1 Patent Owner moved to dismiss this proceeding because, according to Patent Owner, the Petition did not identify all real parties-in-interest as required be 35 U.S.C. § 312(a)(2). 1 IPR2024-01131, Paper 43, 45:1–8. Paper 42. Petitioner opposed the motion. Paper 44. We denied the motion. Paper 46.” slip op. at 2

  • Skill levelSkill level board ownOther

    “arguments and evidence in support of its proposed definition of the level of ordinary skill in the art at the time of the invention, we determine that Petitioner’s definition is too broad. Petitioner asserts that one of ordinary skill in the art would have “approximately one or more years of professional experience with electronic and optoelectronic system design.” Pet. 3. But Petitioner does not appear to dispute the testimony of Patent Owner’s declarant, Dr. Bretschneider, that “the field of optoelectronics” is “broad and expansive and encompasses solar cells, optical fiber, and any application of LEDs, not just the design of LED packages.” Ex. 2020 ¶ 78. Therefore, one having experience with optoelectronic system design would not necessarily have experience designing LED backlights for LCD displays. We have also carefully considered Patent Owner’s arguments and evidence in support of its proposed definition of the level of ordinary skill in the art at the time of the invention. In light of our analysis of the prior art and the AAPA, we determine that Patent Owner’s requirement of “at least one year of practical experience in design of LED packages and one year of practical experience in design of thermal management systems for LEDs” is not sufficiently precise. Patent Owner does not specify that the required experience is in the context of designing LED backlights for LCD displays. One having this experience would necessarily have experience addressing thermal-management concerns associated with such backlights.” slip op. at 18

  • Expert testimonyPetitioner expert discountedDecided for patent owner

    “Because Dr. Baker does not have the requisite experience designing LED backlights for LCD displays, he is not qualified to offer expert testimony from the vantage point of a person of ordinary skill in the art of designing LED backlights for LCD displays. Kyocera Senco Indus. Tools Inc. v. Int’l Trade Comm’n, 22 F.4th 1369, 1377–78 (Fed. Cir. 2022).” slip op. at 23

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner

    “Neither party asserts that “connecting” is a term of art requiring expert testimony to construe. We agree with Petitioner that “connecting” should be construed consistently with the “fastener” term, because it is the “fastener” (or the second portion thereof) to which the circuit board is “connecting.” Because the parties agree that “fastener” is “[a] feature that attaches or holds something in place, “connecting” means “attaching or holding.”” slip op. at 26

  Patent outcomesUS 7,168,842 mixed
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 7,168,842
• Juniper Networks, Inc. v. Monarch Networking Solutions LLCSome claims unpatentable
  PTAB · May 5, 2025 · IPR2024-00175 · APJ Norman H Beamer · IPR · Final written decision

  Claims 7, 9–11, 13, 14, 16, and 17 are unpatentable as obvious over Biswas and Kumar; the remaining challenged claims were not shown unpatentable.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Pet. 14 (citing Ex. 1003 ¶¶ 62–64). Patent Owner does not dispute Petitioner’s proposal. PO Resp. 8–9. Petitioner’s proposal is consistent with the level of ordinary skill in the art as reflected by the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); GPAC, 57 F.3d at 1579. On this record, the level of ordinary skill is neither in dispute nor dispositive of any challenge. For purposes of this Decision, we apply Petitioner’s articulation.” slip op. at 10

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Claim terms need only be construed to the extent necessary to resolve the controversy. Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017). The parties submit that no claim construction is necessary. Pet. 14; PO Resp. 15. We have not been presented with the need to construe any claim terms for this Decision. D.” slip op. at 11

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner

    “We determine that Petitioner has provided sufficiently articulated reasoning with rational underpinnings for the proffered combined teachings of Biswas and Kumar. We are persuaded by Petitioner’s declarant’s testimony that one of ordinary skill would have known to use the masking techniques exemplified by Kumar to implement the disclosed operation in Biswas of edge routers providing hosts with port number ranges. Ex. 1003 ¶¶ 77, 97–101. Accordingly, we determine that Petitioner has proved by a preponderance of the evidence that one of ordinary skill in the art would have been motivated to combine Biswas and Kumar.” slip op. at 13

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableNot shown unpatentableMixed

    “This disclosure is inconsistent with any suggestion that the Fangman system, when routing a telephone call to its destination, identifies the private IP address of the destination telephone by determining the port range to which the port number of the destination telephone belongs. When Fangman describes the NAPPT process, it does not indicate that port ranges are used, but rather repeatedly states that port numbers are used: The [service gateway] receives a data packet from the IP device, including a public destination IP address . . . a destination port number . . . and source information, NAPPTs the data packet, using the [public destination IP address] and the [destination port number] to identify the [IP telephone] . . . . Ex. 1024, code (57). Performing NAPPT on the data packet received from the destination may include using the public destination IP address and the destination port number to uniquely identify the IP telephone, and changing the public destination IP address to a private source IP address of the IP telephone while leaving the destination port number unchanged. Ex. 1024, 4:28–33. The SG 170 may maintain a table of semi-permanent mappings of the external IP address and ports to the internal hosts and ports. Ex. 1024, 8:49–51.” slip op. at 33

  Patent outcomesUS 8,693,369 mixed
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,693,369
• Billerud Aktiebolag (Publ) v. Westrock MWV, LLCSome claims unpatentable
  PTAB · Mar 12, 2025 · IPR2023-01206 · APJ Elizabeth M Roesel · IPR · Final written decision

  Claims 1, 2, and 4–22 are unpatentable as obvious; claim 23 was not shown unpatentable. Substitute claims 25–26 are allowed, while 24 and 27 are denied for lack of written-description support.

  RulingsFinal written decision

  • Expert testimonyPetitioner expert discountedOther

    “Exhibits 1013 and 1014 are also not admissible as expert testimony because Mr. Wirén is not “qualified as an expert by knowledge, skill, experience, training, or education.” Fed. R. Evid. 703. “To offer expert testimony from the perspective of a skilled artisan in a patent case—like for claim construction, validity, or infringement—a witness must at least have ordinary skill in the art. Without that skill, the witness’ opinions are neither relevant nor reliable.” Kyocera Senco Indus. Tools Inc. v. Int’l Trade Comm’n, 22 F.4th 1369, 1376–77 (Fed. Cir. 2022). Mr. Wirén does not meet our definition of a person of ordinary skill in the art. See Section II.B, supra. That definition is based on the undisputed testimony of Messrs. Zotterman and Klass. Ex. 1003 ¶ 24; Ex. 2003 ¶ 26. Although Mr. Wirén has a Master’s of Science in chemical engineering, he lacks any experience or specialization in paperboard manufacturing. Ex. 2011, 12:1–10, 19:6–25, 20:2–7. We therefore agree with Patent Owner that Exhibits 1013 and 1014 are the testimony of Mr. Wirén and should be excluded from evidence because Mr. Wirén is not a person of ordinary skill in the relevant art. PO MTE 5–6, 9; Sundance, Inc. v. DeMonte Fabricating Ltd., 550 F.3d 1356, 1362 (Fed. Cir. 2008) (“Unless a patent lawyer is also a qualified technical” slip op. at 61

  • Skill levelSkill level board ownOther

    “Level of Ordinary Skill in the Art Based on the testimony of the parties’ witnesses, we determine that a person of ordinary skill in the art would have had a bachelor’s degree in paper science and engineering, chemical engineering, process engineering, mechanical engineering, or a related degree, with three to five years of experience in paperboard manufacturing, or a master’s degree in paper science and engineering, chemical engineering, process engineering, or mechanical engineering, or a similar field with a specialization in paperboard manufacturing. Ex. 1003 ¶ 24; Ex. 2003 ¶ 26. We find that the level of ordinary skill in the art, as articulated above, is consistent with the level of technical understanding and competence reflected in the ’142 Patent Specification and the asserted prior art references.” slip op. at 10

  • Claim Construction › Intrinsic evidence (Phillips canons) › Specification disavowal / 'present invention' languageTerm construed petitioner constructionDecided for petitioner

    “A claim construction that excludes a particular element is viewed as a “negative limitation.” Ethicon LLC v. Intuitive Surgical, Inc., 847 Fed. App’x 901, 907 (Fed. Cir. Mar. 15, 2021). “[S]uch exclusions must find support either in ‘the words of the claim’ or through an ‘express disclaimer or independent lexicography in the written description that would justify adding that negative limitation.’” Id. (citing Omega Eng’g, Inc. v. Raytek Corp., 334 F.3d 1314, 1323 (Fed. Cir. 2003); CCS Fitness, Inc. v. Brunswick Corp., 288 F.3d 1359, 1366–67 (Fed. Cir. 2002)). “The standards for finding lexicography and disavowal are exacting.” GE Lighting Sols., LLC v. AgiLight, Inc., 750 F.3d 1304, 1309 (Fed. Cir. 2014). “To act as its own lexicographer, a patentee must ‘clearly set forth a definition of the disputed claim term,’ and ‘clearly express an intent to define the term.’” Id. (citing Thorner, 669 F.3d at 1365). Similarly, disclaimer or disavowal requires that the specification or prosecution history demonstrate that the invention does not include a particular feature. Id. Here, we find no claim language, lexicography, or disclaimer in the ’142 Patent or its file history that would support defining a “hot-hard calender” as requiring that only one of the two rollers be heated to an elevated temperature.” slip op. at 12

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundUnpatentable

    “a contact surface of said thermo-roller is heated to an elevated temperature of at least 250°F.” Petitioner shows persuasively that the temperature limitation is taught by the combination of Fugitt and Papermaking. Pet. 32–34. Fugitt discloses that “[t]he rolls of the calender may be steam heated.” Ex. 1004 ¶ 26. In a section titled “Heated Rolls,” Papermaking discloses that “Steam can be used up to 170°C [338°F] surface temperature.” Ex. 1010, 95, 98. Petitioner is thus correct that, “[w]hile Fugitt teaches that a hot calender may be steam heated, Papermaking clarifies that one of ordinary skill in the art would understand that steam heated thermo-rollers may reach up to 338°F.” Pet. 36. Based on these disclosures, we are persuaded by Mr. Zotterman’s testimony that it would have been “obvious to heat the thermo-roller of Fugitt to at least 250°F.” Ex. 1003 ¶ 159. combine Fugitt and Papermaking because of Papermaking’s status as a “trusted handbook[],” because both references disclose a method of manufacturing a paperboard structure with hot calendering,” and “because of the known advantages of heated rollers.” Pet. 36–37; Ex. 1003 ¶¶ 157, 159, 162. Petitioner’s contention is supported by Papermaking’s disclosures that, for cartonboard, “[p]recalendering is used before the coater to reduce roughness and porosity” and “[h]igh thermo roll temperatures (in some cases over 200°C) result in bulk savings because of the temperature gradient.” Ex. 1005, 80–82; see also Pet. 38; Ex. 1003 ¶ 164 (citing these disclosures). Papermaking’s disclosed range of “up to 170°C [338°F]” for steam- heated rolls (Ex. 1010, 98), overlaps the claimed range of “at least 250°F.” Patent Owner agrees. Tr. 27:11–13. “If the relevant comparison between a disputed claim limitation and the prior art pertains to a range of overlapping values, ‘. . . even a slight overlap in range establishes a prima facie case of obviousness.’” Genentech, Inc. v. Hospira, Inc., 946 F.3d 1333, 1341 (Fed. Cir. 2020) (citing In re Peterson, 315 F.3d 1325, 1329 (Fed. Cir. 2003)). “[S]uch an overlap creates a presumption of obviousness, and . . . the burden of production falls upon the patentee to come forward with pertinent evidence that the overlapping range would not have been obvious in light of the prior art.” Id. (citing E.I. DuPont de Nemours & Co. v. Synvina C.V., 904 F.3d 996, 1006, 1008 (Fed. Cir. 2018)). slip op. at 21

  Patent outcomesUS 11,293,142 mixed
  Claim construction§ 103 obviousness§ 112 disclosurecites Phillips · KSR · Graham
  Patents in suitUS 11,293,142
• Apple Inc. v. RJ Technology LLCSome claims unpatentable
  PTAB · Feb 18, 2025 · IPR2023-01350 · APJ Jon B Tornquist · IPR · Final written decision

  Claims 5–10 are unpatentable as obvious; claims 11–14 were not shown unpatentable because the evidence did not establish the claimed capacity retention after 400 cycles.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends a person of ordinary skill in the art “would have held a Bachelor’s degree in chemistry or chemical engineering, with at least 4 years of experience in cell design, electrochemical techniques, and battery materials development.” Pet. 4. Petitioner further contends that a “Master’s Degree can substitute[] for some of the relevant experience,” and “[e]quivalent training with battery specific experience can accommodate other degreed fields.” Id. 9 The parties here do not address objective evidence of nonobviousness. Patent Owner does not dispute Petitioner’s definition of the ordinarily skilled artisan. PO Resp. 20. We adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the ’641 patent, the prior art of record, and the parties’ arguments.” slip op. at 6

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “The parties agree that the term “charge cut-off voltage” is “the maximum voltage to which the battery is configured to be charged.” PO Resp 21–22; Pet. Reply 1. The parties dispute, however, whether the “charge cut-off voltage” is a “battery property” or “the voltage applied to the battery during charging.” PO Resp. 21–24; Pet. Reply 1–6. We need not resolve the precise meaning of “charge cut-off voltage” because there is no dispute that Yamaki discloses this limitation under either party’s interpretation of the claim term. Upon review of the prior art and the parties’ arguments, we determine that no terms of the ’641 patent require express construction. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))); Pet. Reply 1 (asserting that the challenged claims are unpatentable under either parties’ construction of “charge cut-off voltage”).” slip op. at 7

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successUnpatentableMotivation foundUnpatentable

    “Patent Owner’s arguments do not persuasively undermine Petitioner’s position. Sakamoto expressly discloses setting the ratio of negative to positive electrode active material in the range of 1.05 to 1.30. Ex. 1005 ¶ 8. Sakamoto also explains why this range is preferable, i.e., if the ratio is roughly equal “the charge-discharge cycle performance is insufficient due to significant deterioration from charging and discharging,” and if the ratio is 10 Citations to the prosecution history of Yamaki are to the page numbers added to the lower right corner of the document. too high “too much of the compound does not participate in charging and discharging.” Id. ¶¶ 6, 8. These disclosures are sufficient to explain why one of ordinary skill in the art would have found it obvious to select the ratios disclosed in Sakamoto in Yamaki. Id. ¶ 8 (providing a secondary battery with a capacity ratio between 1.05 and 1.30 and noting that by setting the ratio within this range the resulting secondary lithium battery is “safe due to low risk of heat being generated and an explosion occurring”). We also disagree that Sakamoto teaches away from elevated voltages or from increasing the amount of lithium in circulation. See PO Resp. 29. Contrary to Patent Owner’s arguments, Sakamoto provides no general teaching against using a charge cut-off voltage above 4.2 V, or against increasing the level of lithium in circulation. Nor does Sakamoto “criticize, discredit, or otherwise discourage” the claimed invention. In re Fulton, 391 F.3d 1195, 1201 (Fed. Cir. 2004). Rather, Sakamoto warns against setting the reversible capacities of the positive and negative electrode substantially equal as this may result in excess lithium plating on the surface of the electrode. Ex. 1005 ¶¶ 6, 8. We agree with Petitioner that this disclosure would lead one of ordinary skill in the art to design a battery with a higher capacity in the negative electrode active material than the positive electrode active material. Pet. 11–12.” slip op. at 14

  • Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundDecided for petitioner

    “We also disagree that Sakamoto teaches away from elevated voltages or from increasing the amount of lithium in circulation. See PO Resp. 29. Contrary to Patent Owner’s arguments, Sakamoto provides no general teaching against using a charge cut-off voltage above 4.2 V, or against increasing the level of lithium in circulation. Nor does Sakamoto “criticize, discredit, or otherwise discourage” the claimed invention. In re Fulton, 391 F.3d 1195, 1201 (Fed. Cir. 2004). Rather, Sakamoto warns against setting the reversible capacities of the positive and negative electrode substantially equal as this may result in excess lithium plating on the surface of the electrode. Ex. 1005 ¶¶ 6, 8. We agree with Petitioner that this disclosure would lead one of ordinary skill in the art to design a battery with a higher capacity in the negative electrode active material than the positive electrode active material. Pet. 11–12.” slip op. at 15

  Patent outcomesUS 7,749,641 mixed
  Claim construction§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 7,749,641
• Samsung Electronics Co., Ltd. / Apple Inc. v. RJ Technology LLCSome claims unpatentable
  PTAB · Jan 17, 2025 · IPR2024-00597 · APJ Jon B Tornquist · IPR · Final written decision

  Claims 2–4 and 6–18 are unpatentable as obvious over Abe and Guyomard, with claims 9–10 also obvious over Iwaizono; claims 1 and 5 were not shown unpatentable.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person of ordinary skill in the art “would have had a Master’s degree in material science, chemical engineering, chemistry, or similar field with four years of experience designing testing, and building secondary lithium batteries.” Pet. 11 (citing Ex. 1002 ¶ 51). Petitioner further contends that a person of ordinary skill in the art would have been aware of “(1) positive electrode materials, (2) negative electrode materials, (3) separators, (4) electrolytes, (5) charge-discharge parameters, and (6) protection circuits, as well as ‘battery failure modes’ such as plating and the formation of dendrites.” Id. (citing Ex. 1002 ¶¶ 50–51). Patent Owner “does not dispute Petitioner’s level of ordinary skill.” PO Resp. 17. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the disclosures of the ’641 patent and the prior art of record.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner

    “We also agree with Patent Owner that the charge cut-off voltage is not necessarily the applied voltage during charging. PO Resp. 20. Rather, depending on the charging protocol used and when in the charging cycle the voltage is applied, the applied voltage could be higher than the battery voltage. Ex. 2013; Ex. 2006 ¶ 91. For example, as discussed in more detail below with respect to the Uemura grounds, when fast charging using constant current is used and the charging rate is not slow, the applied voltage will be higher than the battery voltage when the constant current charging phase is stopped. Ex. 2006 ¶ 91; Ex. 2013. Likewise, during constant current/constant voltage charging, the applied voltage approximates the battery voltage only when the battery is nearly completely charged. Ex. 2013; Ex. 2006 ¶ 91. Thus, the applied voltage may be, but is not necessarily, the charge cut-off voltage. In view of the foregoing, we construe “charge cut-off voltage” in claims 1 and 5 as “the maximum value to which the battery is configured to be charged.” PO Resp. 18; Ex. 2008, 217:6–11; Pet. Reply 5. Contrary to Patent Owner’s arguments, however, we do not understand the phrase “configured to be charged” to necessarily represent a single voltage for the battery that is determined based on the structure and chemistry of the battery. Pet. Reply 4–5. Rather, the charge cut-off voltage is a selected potential, or voltage, of the battery or cell at the end of charging that is controlled by a circuit or device, such as a charger or control circuit within the battery. Ex. 1001, 9:50–55; Ex. 1048, 2, 7–8; Ex. 1008, 3:9–13. And, for the reasons discussed herein, the charge cut-off voltage may be, but is not necessarily, the same as the applied voltage during charging. PO Resp. 20.” slip op. at 15

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “charge cut-off voltage “greater than 4.2 V but less than 5.8 V” and calculating a specific or theoretic capacity “with a charge cut-off voltage limited to 4.2” (claim 1) or “with a charge cut-off voltage set at 4.2 V” (claim 5). Ex. 1001, 16:56–61, 17:6–11. Although the parties dispute the precise scope of these claim terms, the parties agree that the first use of “charge cut-off voltage” in claims 1 and 5 refers to the potential of the battery as a whole (between the cathode and the anode), and not a half-cell voltage using lithium metal as a counter electrode.10 Tr. 17:1–3 (agreeing 10 With respect to the phrase “as calculated by a theoretic capacity with a charge cut-off voltage set at 4.2 V,” the parties in fact appear to be in that the first use of “charge cut-off voltage” in claim 5 refers to a full-cell voltage); Sur-reply 5; PO Resp. 22. We need not further construe the claims to resolve the disputes between the parties. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 16

  • Expert testimonyPatent owner expert creditedDecided for patent owner

    “Given Mr. Juzkow’s unambiguous testimony that Uemura uses constant current charging that would stop when the applied voltage reached 11 The chart is reproduced from SAFT, Charging your lithium-ion batteries: 5 expert tips for a longer lifespan, (https://www.saft.com/energizing-iot/charging-your-lithium-ion-batteries-5-expert-tips-longerlifespan#:~: text=When%20the%20battery%20provides%20current,This%20restore s%20the%20battery's%20capacity). 4.3 V, as well as Dr. Yao’s persuasive testimony that Uemura’s constant charging rate is not slow, we credit the testimony of Dr. Yao that one of ordinary skill in the art would have understood that the internal voltage to which the battery of Uemura was charged is less than 4.3 V. Ex. 2006 ¶ 119. In particular, Dr. Yao persuasively testifies that one of ordinary skill in the art would have believed that the charge cut-off voltage was no more than 4.2 V, and most likely equal to “about 4 V.” Id. ¶¶ 119–122.” slip op. at 21

  Patent outcomesUS 7,749,641 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 7,749,641
• Samsung Electronics Co., Ltd. / Apple Inc. v. RJ Technology LLCSome claims unpatentable
  PTAB · Jan 17, 2025 · IPR2023-01183 · APJ Jon B Tornquist · IPR · Final written decision

  Claims 2–4 and 6–18 are unpatentable as obvious over Abe and Guyomard, with claims 9 and 10 also obvious over Iwaizono; claims 1 and 5 were not shown unpatentable.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person of ordinary skill in the art “would have had a Master’s degree in material science, chemical engineering, chemistry, or similar field with four years of experience designing testing, and building secondary lithium batteries.” Pet. 11 (citing Ex. 1002 ¶ 51). Petitioner further contends that a person of ordinary skill in the art would have been aware of “(1) positive electrode materials, (2) negative electrode materials, (3) separators, (4) electrolytes, (5) charge-discharge parameters, and (6) protection circuits, as well as ‘battery failure modes’ such as plating and the formation of dendrites.” Id. (citing Ex. 1002 ¶¶ 50–51). Patent Owner “does not dispute Petitioner’s level of ordinary skill.” PO Resp. 17. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the disclosures of the ’641 patent and the prior art of record.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner

    “constructions. First, we agree with Petitioner that the ’641 patent indicates that the charge cut-off voltage selected for a particular battery need not be a fixed property of the battery or something that is set by the design and chemistry of the battery. Consistent with this conclusion, the ’641 patent discloses that a “charging device controls the charge cut-off voltage of the single lithium-ion cell within a range from 4.3 V to 5.8 V.” Ex. 1001, 9:50– 55. This strongly suggests that the charge cut-off voltage is controlled by the charger and is not necessarily an inherent property of the battery. Patent Owner contends that this is merely an unclaimed embodiment, but the relevant disclosure states that the charging device for the “present invention” may be any type of device “with the proviso that said charging device controls the charge cut-off voltage.” Id. at 9:50–53.” slip op. at 12

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “charge cut-off voltage “greater than 4.2 V but less than 5.8 V” and calculating a specific or theoretic capacity “with a charge cut-off voltage limited to 4.2” (claim 1) or “with a charge cut-off voltage set at 4.2 V” (claim 5). Ex. 1001, 16:56–61, 17:6–11. Although the parties dispute the precise scope of these claim terms, the parties agree that the first use of “charge cut-off voltage” in claims 1 and 5 refers to the potential of the battery as a whole (between the cathode and the anode), and not a half-cell voltage using lithium metal as a counter electrode.10 Tr. 17:1–3 (agreeing 10 With respect to the phrase “as calculated by a theoretic capacity with a charge cut-off voltage set at 4.2 V,” the parties in fact appear to be in that the first use of “charge cut-off voltage” in claim 5 refers to a full-cell voltage); Sur-reply 5; PO Resp. 22. We need not further construe the claims to resolve the disputes between the parties. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 16

  • Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner

    “Given Mr. Juzkow’s unambiguous testimony that Uemura uses constant current charging that would stop when the applied voltage reached 11 The chart is reproduced from SAFT, Charging your lithium-ion batteries: 5 expert tips for a longer lifespan, (https://www.saft.com/energizing-iot/charging-your-lithium-ion-batteries-5-expert-tips-longerlifespan#:~: text=When%20the%20battery%20provides%20current,This%20restore s%20the%20battery's%20capacity). 4.3 V, as well as Dr. Yao’s persuasive testimony that Uemura’s constant charging rate is not slow, we credit the testimony of Dr. Yao that one of ordinary skill in the art would have understood that the internal voltage to which the battery of Uemura was charged is less than 4.3 V. Ex. 2006 ¶ 119. In particular, Dr. Yao persuasively testifies that one of ordinary skill in the art would have believed that the charge cut-off voltage was no more than 4.2 V, and most likely equal to “about 4 V.” Id. ¶¶ 119–122. Petitioner argues that because the battery of Uemura is charged “to” a maximum voltage of 4.3 V, Uemura discloses the claimed charge cut-off voltage under either Petitioner’s or Patent Owner’s construction of the term. Pet. Reply 11–12 (citing Ex. 1009 ¶ 81; Ex. 1044 ¶¶ 56–59). This argument is not persuasive because Mr. Juzkow unambiguously testified that charging in Uemura stopped when the applied voltage reached 4.3 V, and Uemura discloses that the battery was charged “at” a voltage ranging from 4.3 V to 2.0 V, not “to” such a voltage. Ex. 1009 ¶ 81; Ex. 2008, 113:2–13; Ex. 2006 ¶ 119 n.64; Sur-reply 9. In view of the foregoing, we determine that Petitioner has not demonstrated by a preponderance of the evidence that Uemura anticipates independent claims 1 and 5 of the ’641 patent.” slip op. at 21

  Patent outcomesUS 7,749,641 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 7,749,641
• Western Digital Technologies, Inc. / Kioxia Corporation et al. v. Viasat, Inc.Some claims unpatentable
  PTAB · Nov 20, 2023 · IPR2023-00408 · APJ Elizabeth M Roesel · IPR · Final written decision

  Claims 1, 4, 8, 15, 17, and 19 are unpatentable as anticipated by Wu; claim 2 was not shown unpatentable under the Jo-Wu or Jo-Wan obviousness grounds.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “The parties’ articulations of the level of ordinary skill in the art are similar, and we adopt parts of each party’s description of a POSITA’s education and experience. We agree with Patent Owner that computer engineering is a relevant field of study. PO Resp. 3. Our finding is supported by the ’700 Patent, which describes systems, devices, methods, and software for forward error correction for a flash memory system, which may be integrated with a computer, server, or other computing device. Ex. 1001, 3:23–30. We adopt Patent Owner’s proposal regarding the length of a POSITA’s practical experience—two years—rather than four years, as proposed by Petitioner. Neither Petitioner nor Dr. Dolecek assert that two years of practical experience would have been insufficient to acquire POSITA’s experience would have been limited to “hardware implementation.” PO Resp. 3. Our finding is supported by the ’700 Patent, which states that “embodiments may be implemented by hardware, software, firmware, middleware, microcode, hardware description languages, or any combination thereof.” Ex. 1001, 10:26–28. Petitioner’s assertion that a POSITA needs to have experience in “error correction coding (‘ECC’) systems (which include forward error correction or ‘FEC’systems)” (Pet. 19; Ex. 1003 ¶ 25) is consistent with the ’700 Patent, which discloses methods, systems, and devices for forward error correction for flash memory. Ex. 1001, code (57); see also Ex. 1003 ¶¶ 57, 66 (explaining that error correction coding (“ECC”) includes forward error correction (“FEC”)). For these reasons, we find that a POSITA would have had a bachelor of science degree in electrical engineering, computer engineering, or computer science or a related field, and two years of experience designing, developing, or researching error correction coding systems, which include forward error correction systems.” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction needed

    “The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.” Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (quoting Vivid Techs., Inc. v. Am. Sci. Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). Neither party seeks express constructions of any claim terms. See Pet. 20; see generally PO Resp. We do not need to provide an express construction for any claim terms for purposes of resolving the controversy before us. slip op. at 11

  • Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner

    “We find that Dr. Dolecek’s testimony about Wu’s Figure 8 and a “plurality of data streams” is more credible than Dr. Bagherzadeh’s testimony on this topic. Dr. Bagherzadeh testifies that Wu’s scrambler “does not split, copy, or otherwise ‘generate a plurality of partially decoded data streams.’” Id. ¶¶ 100, 108. But that testimony fails to take into account what the depiction of multiple double-sided arrows in Wu’s Figure 8 would have meant to a POSITA, as Dr. Dolecek testifies. Ex. 1003 ¶ 86 (reproducing Wu’s Figure 8 with double-headed arrows between ECC engines 822-0 to 822-M and scrambler 103 shaded yellow to identify a “plurality of partially decoded data streams”). The evidence does not support Dr. Bagherzadeh’s opinion that Wu’s Figure 8 is “incompatible” with Wu’s description and “there’s no way to generate a plurality of data streams from the Scrambler to the ECC Engines.” Ex. 2023 ¶ 109. As Dr. Dolecek explained below, when viewed through the eyes of a POSITA, Wu discloses that the scrambler can generate a plurality of data streams.” slip op. at 18

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable

    “arrows between scrambler 103 and ECC Engines 822-0 to 822-M in Wu’s Figure 8 is sufficient to disclose the generation of a plurality of data streams, as claimed. Pet. 36–37; Pet. Reply 2–6. As between Petitioner’s position that the multiple arrows in Wu’s Figure 8 represent multiple data streams (Pet. 36–37; Pet. Reply 2–3), and Patent Owner’s position that “those arrows are not meant to be taken literally as literal data streams” (Tr. 35:16–17), we find that Petitioner’s position is more reasonable, consistent with the legal standard for anticipation, and amply supported in the record. “In an anticipation analysis, the dispositive question is whether a skilled artisan would ‘reasonably understand or infer’ from a prior art reference that every claim limitation is disclosed in that single reference.” Acoustic Tech., Inc. v. Itron Networked Sols., Inc., 949 F.3d 1366, 1373 (Fed. Cir. 2020) (citing Akamai Techs., Inc. v. Cable & Wireless Internet Servs., Inc., 344 F.3d 1186, 1192 (Fed. Cir. 2003)). “Expert testimony may shed light on what a skilled artisan would reasonably understand or infer from a prior art reference.” Id. (citing Monsanto Tech. LLC v. E.I. DuPont de Nemours & Co., 878 F.3d 1336, 1345 (Fed. Cir. 2018)).” slip op. at 17

  Patent outcomesUS 8,615,700 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,615,700
• Western Digital Technologies, Inc. / Kioxia Corporation et al. v. Viasat, Inc.Some claims unpatentable
  PTAB · Nov 20, 2023 · IPR2022-01126 · APJ Elizabeth M Roesel · IPR · Final written decision

  Claims 1, 4, 8, 15, 17, and 19 are unpatentable as anticipated by Wu; claim 2 was not shown unpatentable under the asserted obviousness grounds.

  RulingsFinal written decision

  • PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted

    “1 Kioxia Corporation and Kioxia America, Inc. filed a petition and a motion for joinder in IPR2023-00408 and have been joined as petitioners to this proceeding. INTRODUCTION A. Background and Summary Western Digital Technologies, Inc. (“Petitioner”) filed a Petition (Paper 1, “Pet.”) seeking an inter partes review of claims 1, 2, 4, 8, 15, 17, and 19 (the “challenged claims”) of U.S. Patent No. 8,615,700 B2 (Ex. 1001, “the ’700 Patent”). Viasat, Inc. (“Patent Owner”) filed a Preliminary Response. Paper 12 (“Prelim. Resp.”). We instituted an inter partes review. Paper 13 (“Institution Decision” or “Inst. Dec.”). Kioxia Corporation and Kioxia America, Inc. (collectively, “Kioxia”) filed a substantively identical petition, and we granted institution and joined Kioxia as a petitioner to this proceeding. Paper 25 (copy of Paper 9 from IPR2023-00408).” slip op. at 1

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “The parties’ articulations of the level of ordinary skill in the art are similar, and we adopt parts of each party’s description of a POSITA’s education and experience. We agree with Patent Owner that computer engineering is a relevant field of study. PO Resp. 3. Our finding is supported by the ’700 Patent, which describes systems, devices, methods, and software for forward error correction for a flash memory system, which may be integrated with a computer, server, or other computing device. Ex. 1001, 3:23–30. We adopt Patent Owner’s proposal regarding the length of a POSITA’s practical experience—two years—rather than four years, as proposed by Petitioner. Neither Petitioner nor Dr. Dolecek assert that two years of practical experience would have been insufficient to acquire POSITA’s experience would have been limited to “hardware implementation.” PO Resp. 3. Our finding is supported by the ’700 Patent, which states that “embodiments may be implemented by hardware, software, firmware, middleware, microcode, hardware description languages, or any combination thereof.” Ex. 1001, 10:26–28. Petitioner’s assertion that a POSITA needs to have experience in “error correction coding (‘ECC’) systems (which include forward error correction or ‘FEC’systems)” (Pet. 19; Ex. 1003 ¶ 25) is consistent with the ’700 Patent, which discloses methods, systems, and devices for forward error correction for flash memory. Ex. 1001, code (57); see also Ex. 1003 ¶¶ 57, 66 (explaining that error correction coding (“ECC”) includes forward error correction (“FEC”)). For these reasons, we find that a POSITA would have had a bachelor of science degree in electrical engineering, computer engineering, or computer science or a related field, and two years of experience designing, developing, or researching error correction coding systems, which include forward error correction systems.” slip op. at 9

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable

    “arrows between scrambler 103 and ECC Engines 822-0 to 822-M in Wu’s Figure 8 is sufficient to disclose the generation of a plurality of data streams, as claimed. Pet. 36–37; Pet. Reply 2–6. As between Petitioner’s position that the multiple arrows in Wu’s Figure 8 represent multiple data streams (Pet. 36–37; Pet. Reply 2–3), and Patent Owner’s position that “those arrows are not meant to be taken literally as literal data streams” (Tr. 35:16–17), we find that Petitioner’s position is more reasonable, consistent with the legal standard for anticipation, and amply supported in the record. “In an anticipation analysis, the dispositive question is whether a skilled artisan would ‘reasonably understand or infer’ from a prior art reference that every claim limitation is disclosed in that single reference.” Acoustic Tech., Inc. v. Itron Networked Sols., Inc., 949 F.3d 1366, 1373 (Fed. Cir. 2020) (citing Akamai Techs., Inc. v. Cable & Wireless Internet Servs., Inc., 344 F.3d 1186, 1192 (Fed. Cir. 2003)). “Expert testimony may shed light on what a skilled artisan would reasonably understand or infer from a prior art reference.” Id. (citing Monsanto Tech. LLC v. E.I. DuPont de Nemours & Co., 878 F.3d 1336, 1345 (Fed. Cir. 2018)).” slip op. at 17

  • Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner

    “We find that Dr. Dolecek’s testimony about Wu’s Figure 8 and a “plurality of data streams” is more credible than Dr. Bagherzadeh’s testimony on this topic. Dr. Bagherzadeh testifies that Wu’s scrambler “does not split, copy, or otherwise ‘generate a plurality of partially decoded data streams.’” Id. ¶¶ 100, 108. But that testimony fails to take into account what the depiction of multiple double-sided arrows in Wu’s Figure 8 would have meant to a POSITA, as Dr. Dolecek testifies. Ex. 1003 ¶ 86 (reproducing Wu’s Figure 8 with double-headed arrows between ECC engines 822-0 to 822-M and scrambler 103 shaded yellow to identify a “plurality of partially decoded data streams”). The evidence does not support Dr. Bagherzadeh’s opinion that Wu’s Figure 8 is “incompatible” with Wu’s description and “there’s no way to generate a plurality of data streams from the Scrambler to the ECC Engines.” Ex. 2023 ¶ 109. As Dr. Dolecek explained below, when viewed through the eyes of a POSITA, Wu discloses that the scrambler can generate a plurality of data streams. After quoting from Dr. Dolecek’s deposition testimony (Ex. 2023 ¶ 107 (quoting Ex. 2024, 32:15–22)), Dr. Bagherzadeh asserts that “Dr. Dolecek does not explain how she believes the intra-channel operation of the Scrambler on the ‘one long data stream’ it receives could generate a account Dr. Dolecek’s testimony in response to follow-up questions from Patent Owner. Q So you have found the plurality of data streams in the three arrows of Figure 8 going from the scrambler to the ECC engines? A Yes. . . . Q And how exactly, in your understanding as a person of skill, does the scrambler generate that plurality? . . . THE WITNESS: . . . So the person of ordinary skill in the art would understand that these are multiple arrows here indicated explicitly to suggest parallel operations of the ECC engines. And for them to have parallel operations, a person of ordinary skill in the art would assume that they are receiving inputs at the same time, and the scrambler would, for example, do that by sending descrambled data to different engines at a time, one at a time. . . . Q So how does the scrambler’s function of intrachannel rearrangement generate multiple data streams? . . . THE WITNESS: Once it’s descrambled on a per-block basis, it simply sends that block to a given engine, ECC engine. . . . Q Can the scrambler send out multiple data streams in parallel at the same time? A If it’s designed like that, yes. Ex. 2024, 32:24–34:7 (objections and witness’s false start omitted). Q So describe for me how in Figure 8 that would work for your analysis where the scrambler receiving the data from the multiplexer would then generate the plurality of partially decoded data streams. A Right. Figure 8. So if it receives a long string of data that has already been processed by the 104 unit, it would perform intra- -- intrachannel, if you will, intrablock disarrangement of data. And then it could” slip op. at 18

  Patent outcomesUS 8,615,700 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,615,700

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.