- Padagis US LLC v. Neurelis, Inc.InstitutedPTAB · Sep 16, 2025 · IPR2025-00465 · APJ Timothy G Majors · IPR · Institution
The Board instituted IPR on claims 1–18 because Petitioner showed a reasonable likelihood of proving claim 1 obvious over Gwozdz and Meezan.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“A claim is unpatentable under 35 U.S.C. § 103 if the differences between the claimed invention and the prior art are such that the claimed invention as a whole would have been obvious at the time the invention was made to a person having ordinary skill in the relevant art. KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 406 (2007). The question of obviousness is resolved on the basis of underlying factual determinations including: (1) the scope and content of the prior art; (2) any differences between the claimed subject matter and the prior art; (3) the level of ordinary skill in the art; and (4) secondary considerations (i.e., objective indicia) of nonobviousness when presented.6 Graham v. John Deere Co., 383 U.S. 1, 17–18 (1966). To show unpatentability based on a combination of teachings, “[a]n obviousness determination [also] requires finding both that a skilled artisan would have been motivated to combine the teachings of the prior art references to achieve the claimed invention, and that the skilled artisan would have had a reasonable expectation of success in doing so.” CRFD” slip op. at 7
- Skill levelSkill level petitioner adoptedDecided for petitioner
“[A POSA] would have been a pharmaceutical scientist, chemist, or biologist involved in the research and development of pharmaceutical formulations and/or delivery, and would have at least a Bachelor’s degree with at least 5 years of experience, or a Master’s, Ph.D. or Pharm.D. degree with several years of experience. In addition, a POSA would have had knowledge of benzodiazepine structure and function, and would further have knowledge and practical experience working with intranasal and transmembrane formulations, including knowledge of the physiology and anatomy of the nasal cavity, with relevant experience in developing intranasal formulations. Pet. 23–24; Ex. 1062 ¶ 20. Patent Owner “does not dispute” Petitioner’s POSA definition at this stage. Prelim. Resp. 18. We apply Petitioner’s proposed POSA definition for this Decision, which definition appears to be generally consistent with the cited prior art.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“standard used in a civil action before the courts under 35 U.S.C. § 282(b), including construing claim language in accordance with its ordinary and customary meaning as understood by the POSA, in view of the patent’s specification and considering the patent’s prosecution history. 37 C.F.R. § 42.100(b). We need only expressly construe terms to the extent needed to resolve the controversy before us. Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019).” slip op. at 8
- Disclosure Requirements (§112) › Written description (Ariad)Written description inadequateNot entitled to earlier dateDecided for petitioner
“applicant, as part of the bargain with the public, must describe his or her invention so that the public will know what it is and that he or she has truly made the claimed invention.” AbbVie Deutschland GmbH & Co., KG v. Janssen Biotech, Inc., 759 F.3d 1285, 1298 (Fed. Cir. 2014). “[T]he test for sufficiency [of the written description requirement] is whether the disclosure of the application relied upon reasonably conveys to those skilled in the art that the inventor had possession of the claimed subject matter as of the filing date sought.” Ariad Pharm., Inc. v. Eli Lilly and Co., 598 F.3d 1336, 1351 (Fed. Cir. 2010) (en banc) (explaining that “the description must clearly allow persons of ordinary skill in the art to recognize that [the inventor] invented what is claimed”) (internal quotation marks omitted); see also id. at 1352 (“[A] description that merely renders the invention obvious does not satisfy the requirement.”).” slip op. at 25
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites KSR · GrahamPatents in suitUS 11,241,414 - Padagis US LLC v. Neurelis, Inc.InstitutedPTAB · Sep 16, 2025 · IPR2025-00466 · APJ Timothy G Majors · IPR · Institution
The Board instituted IPR on claims 1–27 because Petitioner showed a reasonable likelihood of prevailing on at least one claim, including claim 1 over Gwozdz and Meezan.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 314(a), an inter partes review may not be instituted unless it is determined that there is a reasonable likelihood that the petitioner will prevail with respect to at least one of the claims challenged in the petition. For reasons explained below, we conclude that Petitioner shows a reasonable likelihood that it will prevail with respect to at least one of the ’786 patent’s challenged claims.1 We institute inter partes review on all challenged claims. SAS Inst. Inc. v. Iancu, 584 U.S. 357, 362–63 (2018); 37 C.F.R. § 42.108(a) (“When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.”).” slip op. at 2
- Disclosure Requirements (§112) › Written description (Ariad)Not entitled to earlier dateDecided for petitioner
“We find that Petitioner has made a threshold showing that the ’558 Provisional does not provide written description support for claim 1’s pharmaceutical solution consisting of each of the recited elements, including n-dodecyl beta-D-maltoside. It is true that “n-Dodecyl β-D-maltoside” can be found listed in the SIGMA Catalog. Ex. 1026, 316. But Dr. Donovan’s testimony helps put that listing in context. It is merely one among well over 100 ionic and non-ionic detergents listed in the cited six pages of the SIGMA Catalog. See 1026, 316–321; Ex. 1062 ¶ 50. When further considered in the context of paragraphs 150–152 of the ’558 Provisional, which generically suggest that “enhancer” compounds can be used in “some embodiments”—then introducing at least 15 classes of potential enhancers16 including “preferred” lysophospholipids and acyl carnitines—the listing of n-dodecyl beta-D-maltoside among at least 150 biological detergents in the SIGMA Catalog is even more remote. Moreover, although satisfaction of the written description requirement is not limited to what is exemplified in a priority application, none of the ’558 Provisional’s examples use any “enhancer,” much less any detergent, any alkyl glycoside, or n-dodecyl beta-D maltoside in particular. The 16 The ’558 Provisional suggests that whether “a given compound” will function as an “enhancer” in a formulation requires testing. Ex. 1008 ¶ 150 (indicating “an in vivo or good model test” may “determin[e] whether the uptake of the drug is enhanced to a clinically significant degree”). ethanol. See Ex. 1008 ¶¶ 172–174 (Examples 1 and 2). In short, we find no sufficient disclosure of “blaze marks” in the ’558 Provisional that point to the inventors’ possession of a pharmaceutical solution that includes n-dodecyl beta-D-maltoside as claimed. Purdue Pharma L.P. v. Faulding Inc., 230 F.3d 1320, 1326–27 (Fed. Cir. 2000) (analogizing an application’s generic disclosures to a forest of unmarked trees and explaining that, “to satisfy the written description requirement,” there must be “blaze marks directing the skilled artisan to that tree [within the forest that represents the claimed invention]” in the application).” slip op. at 28
- PTAB / AIA Trials › §315(e) estoppelEstoppel does not applyDecided for patent owner
“and applying collateral estoppel to vacate a claim construction in an underlying IPR). In an IPR, “a party seeking to invoke collateral estoppel must show: ‘(1) the issue is identical to one decided in the first action; (2) the issue was actually litigated in the first action; (3) resolution of the issue was essential to a final judgment in the first action; and (4) [the party against whom collateral estoppel is being asserted] had a full and fair opportunity to litigate the issue in the first action.’” Google LLC v. Hammond Development Int’l, Inc., 54 F.4th 1377, 1381 (Fed. Cir. 2022) (quoting In re Freeman, 30 F.3d 1459, 1465 (Fed. Cir. 1994)) (alteration in original).14 “It is [also] well established that patent claims need not be identical for collateral estoppel to apply.” Id. at 1381. Instead, “collateral estoppel requires the issues of patentability be identical.” Id. If “the differences between the unadjudicated patent claims and adjudicated patent claims do not materially alter the question of invalidity, collateral estoppel applies.” Ohio Willow Wood Co. v. Alps South, LLC, 735 F.3d 1333, 1342–43 (Fed. Cir. 2013) (affirming application of collateral estoppel where claims adjudicated as obvious required a “polymeric” gel whereas similar, unadjudicated claims required a “block copolymer” gel). “Collateral estoppel also applies to common issues in actions involving different but related patents.” Mycogen Plant Sci., Inc. v. Monsanto Co., 252 F.3d 1306, 1310 (Fed. Cir. 2001), vacated on other grounds, 353 U.S. 1109 (2002).” slip op. at 22
- Novelty / Anticipation (§102) › Prior-art status of a reference › Patents / published applications (effective date, provisional support)Reference is prior artReference not prior artMixed
“We agree that at least one portion of Gwozdz is not prior art. To establish that the cited disclosures in Gwozdz are prior art, Petitioner must show support for those disclosures in the Gwozdz Provisional. In re Riggs, 131 F.4th 1377, 1384 (Fed. Cir. 2025) (explaining that “the portion of the application relied on . . . as prior art must be supported by the provisional application”). Petitioner did not establish that Gwozdz’s disclosure of “penetration enhancers” finds support in the Gwozdz Provisional. Pet. 22. Conversely, Patent Owner shows that the phrase is absent in the Gwozdz Provisional. Prelim. Resp. 37.20 Based on this record, we determine that Gwozdz’s mention of “penetration enhancers” is not prior art to the 19 Patent Owner argues this “penetration enhancers” disclosure in Gwozdz is not prior art regardless which of the disputed priority dates (March 28, 2008, or March 27, 2009) one accords to the challenged claims. Prelim. Resp. 33. 20 We also agree that collateral estoppel does not bar Patent Owner from challenging Gwozdz’s prior-art status in this case. Patent Owner’s apparent concession that Gwozdz was prior art during the 451 IPR does not equate to the issue being actually litigated. Prelim. Resp. 34–35; Ex. 1040, 14 (“Patent Owner does not contest that Gwozdz is entitled to this filing date” of the Gwozdz Provisional). Purdue, 767 F. App’x at 922 (determining “[t]he priority date for the Joshi reference . . . cannot be determined based on collateral estoppel” where patentee could have argued, but did not in fact argue, Joshi’s prior-art status in an earlier matter).” slip op. at 35
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites KSR · GrahamPatents in suitUS 11,793,786 - PTAB · Aug 11, 2025 · IPR2025-00560 · APJ Barry L Grossman · IPR · Institution
The Board instituted IPR on claims 1–29 and every asserted ground, finding a reasonable likelihood that claim 1 is unpatentable over Chang and Fang.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). The Board determines whether to institute a trial on behalf of the Director. 37 C.F.R. § 42.4(a).” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner asserts that a person of ordinary skill in the art would have had “bachelor’s degree in mechanical engineering or a similar field and at least two years of experience designing human breast pump equipment. More education could substitute for experience and vice versa.” Pet. 8 (citing Ex. 1003 ¶¶ 15–18). Mr. Bauer’s Declaration testimony states he considered some of the factors listed above. Ex. 1003 ¶ 17. Mr. Bauer testifies that based on his background and experience, in his opinion, the level of ordinary skill is as stated by Petitioner. Id. at 18. For purposes of this Decision, based on the prior art, the sophistication of the disclosed technology in the ’381 patent, and Mr. Bauer’s undisputed testimony, we adopt Petitioner’s definition of the level of ordinary skill.13” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“We do not perceive the need to construe any claim limitation. Claims must be construed “only to the extent necessary to resolve the controversy.” AstraZeneca AB v. Mylan Pharms. Inc., 19 F.4th 1325, 1345 (Fed. Cir. 2021) (quoting Vivid Techs., Inc. v. American Science & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“Because binding. We wish to have the record developed before rendering any binding determination, finding, or conclusion. 14 The citation to Ex. 1005, 2290 appears to be an error. We do not find the cited claim construction at this location. we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy,’ we need not construe the claim preambles here where the construction is not ‘material to the [obviousness] dispute.’” (citations omitted)).” slip op. at 13
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“Petitioner also asserts that “[m]ultiple reasons would have prompted a POSITA to implement a diaphragm pump in Chang’s breast pump device in accordance with Fang’s suggestions.” Id. at 21–24. Based on the record before us, we agree that Fang discloses a diaphragm, as recited in clause 1[a][1]. We also agree, based on the record before us, that a person of ordinary skill would have had multiple reasons to use Fang’s diaphragm pump in Chang’s device with a reasonable expectation of success.” slip op. at 21
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,813,381 - Inergy Technology, Inc. v. Force Mos Technology Co., Ltd.Some claims unpatentablePTAB · May 16, 2025 · IPR2024-00094 · APJ Mary C Hoffman · IPR · Final written decision
Claims 1 and 3–5 are unpatentable over Kobayashi and Hshieh; claims 2 and 6 were not shown unpatentable over the asserted combinations.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner asserts that a person of ordinary skill in the art (“POSITA”), “at the filing date of the ’409 [p]atent[,] would have a master’s degree in electrical engineering, and at least two years of relevant work experience in the field of integrated circuit design and manufacturing.” Pet. 13 (citing Ex. 1003 ¶ 52). Patent Owner does not dispute Petitioner’s proffered level of ordinary skill in the art. PO Resp. 9 (citing Ex. 2021 ¶ 55). We adopt Petitioner’s proffered level of ordinary skill in the art, which is supported by unopposed declaration testimony and consistent with the ’409 patent and prior art of record. See, e.g., Ex. 1001, 1:6–3:8 (describing the invention and related art in terms of integrated circuit design and fabrication). Neither party, moreover, indicates the overall result would change based on a different definition.” slip op. at 10
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for patent owner
“Based on the arguments and evidence, we disagree with Petitioner’s proposed construction requiring the corners to be rounded via a particular process, because doing so would improperly import a process of manufacture from the Specification into apparatus claims. See Cont’l Circuits LLC v. Intel Corp., 915 F.3d 788, 799 (Fed. Cir. 2019) (explaining that, generally, a novel product that meets the criteria of patentability is not limited to the process by which it was made, however, process steps can be treated as part of a product claim if the patentee has made clear that the process steps are an essential part of the claimed invention). Here, the portions of the Specification relied on by Petitioner (Ex. 1001, 2:10–20, 4:53–64) disclose a process for manufacturing but do not make clear that the process is an essential part of the claimed invention. We also disagree with Petitioner’s assessment of the prosecution history, i.e., that the claims were amended to distinguish the claimed rounded corners from Pfirsch’s rounded corners, which, presumably, are formed as an incidental result of lithography. On the contrary, the Examiner found (and Patent Owner acknowledged) that Pfirsch has rounded corners. Ex. 1002, 276, 295, 302. As Patent Owner correctly points out, the claims were amended during prosecution to include a “circular” contact to distinguish over Pfirsch’s square contact. See id. Petitioner does not otherwise point to evidence that Patent Owner clearly and unmistakably limited the claim scope to rounded corners formed by a particular process.” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundUnpatentable
“is ‘known’ is not sufficient for a motivation to combine.” PO Resp. 47. However, the motivation-to-combine analysis is a flexible one, and the “known-technique” rationale is adequate to show a motivation to combine. For example, “if a technique has been used to improve one device, and a person of ordinary skill in the art would recognize that it would improve similar devices in the same way, using the technique is obvious unless its actual application is beyond his or her skill.” KSR, 550 U.S. at 417; see also Intel Corp. v. PACT XPP Schweiz AG, 61 F.4th 1373, 1380 (Fed. Cir. 2023) (quoting Intel Corp. v. Qualcomm Inc., 21 F.4th 784, 799–800 (Fed. Cir. 2021) (“If there’s a known technique to address a known problem using ‘prior art elements according to their established functions,’ then there is a motivation to combine.”). Here, as discussed above, the record shows that top view rounding was a known technique to eliminate corners, and that corners were a known problem (e.g., corners tend to reach undesirable higher peak electric field leading to premature breakdown voltage). See, e.g., Ex. 1003 ¶¶ 37, 39, 42– 44, 55–57, 122, 133, 135–141; Ex. 1005, 7:57–8:4; Ex. 1006, 1:18–21, 2:19–39, 5:3–17, Figs. 6A–8B; Ex. 1011, 1:29–41; Ex. 1012; PO Resp. 13, 46 (citing Ex. 1011, 1:34–40); Ex. 2021 ¶ 87. Furthermore, there is no dispute that modifying Kobayashi to eliminate corners via top view rounding was anything more than a “minor and commonplace modification” of cell shape within the skill of an ordinary artisan, or that top view rounding would change Kobayashi’s established function. Pet. 60; Ex. 2021 ¶ 86.” slip op. at 30
- Obviousness (§103) › KSR rationalesMotivation foundUnpatentable
“We agree that Kobayashi’ s Figure 5A solely cannot be relied upon as disclosing the claimed diameter. See Hockerson-Halbertstadt, Inc. v. Avia Group Int'l, 222 F.3d 951, 956 (Fed. Cir. 2000) (patent drawings not designated as being drawn to scale cannot be relied upon to define precise proportions of elements if the specification is completely silent on the issue). However, we do not agree that Petitioner failed to show Kobayashi suggests the recited diameter. We disagree with Patent Owner’s assertion that Dr. Liu’s “vague, purported ‘design considerations’” are “unsupported.” PO Resp. 43. Although Kobayashi is silent on the width/diameter of the trench contact in Figure 5A, Kobayashi discloses trenched gates having dimensions below 0.5 μm, which demonstrates that it was known in the art, and required no more than an exercise of ordinary skill in the art, to create trenched features of widths well below 1 μm. Kobayashi also discloses that the width of each trench, and the distance between the adjacent trenches (which includes the trench contact), must be selected to optimum sizes . . . [and] these sizes . . . have some degrees of freedom.” Ex. 1005, 7:42–48. This demonstrates a POSITA would seek to optimize trench contact width or diameter. Dr. Liu’s testimony regarding design considerations suggests the desirability of a reduced diameter trench contact, e.g., to minimize the width of the trench contact for purposes of easier filling, to minimize the total width of the unit cell, and to minimize manufacturing time by reducing etch back time. See Ex. 1003 ¶¶ 111–114. As Patent Owner acknowledges, “there is always a motivation to speed up the fabrication process or shrink feature sizes of semiconductors.” PO Resp. 43 (citing 2021 ¶ 131). However, contrary to Patent Owner’s arguments, these are not generic motivations “untethered” from Kobayashi. Id. Indeed, Kobayashi directly addresses the fabrication process (including new techniques to obtain trench widths under 0.5 μm) and the need to optimize the size of trench gates and the space in between (which includes the trench contact). Ex. 1005, 7:43–54, 7:19–9:53. Patent Owner also argues that Petitioner presents no evidence that modifying Kobayashi to have a diameter smaller than 1 μm is predictable. PO Resp. 44. We disagree. As discussed above, Petitioner points to Kobayashi’s teachings that the sizes are to be optimized and that the trench gate width is smaller than 0.5 μm, which suggests making other trench features of that width was within ordinary skill. Ex. 1003 ¶ 112. Furthermore, Kobayashi’s silence as to the dimensions of the trench contact suggests that the trench contact diameter dimension is likely in the ballpark of the other explicitly disclosed trenched feature dimensions and is a matter of routine optimization. In addition, Patent Owner advances no persuasive evidence that the claimed diameter produces unexpected results or is otherwise critical. Patent Owner also argues that reducing trench contact diameter has downsides (i.e., reduced ease of filling for metal plugs and reduced current carrying capacity) not addressed by Petitioner; however, Petitioner is not required to address those tradeoffs in its Petition, and we do not see how those tradeoffs would prevent the proposed combination. PO Resp. 44; see Medichem, S.A. v. Rolabo, S.L., 437 F.3d 1157, 1165 (Fed. Cir. 2006) (“a given course of action often has simultaneous advantages and disadvantages, and this does not necessarily obviate motivation to combine.”); Winner Int'l Royalty Corp. v. Wang, 202 F.3d 1340, 1349 n.8 (Fed. Cir. 2000) (“The fact that the motivating benefit comes at the expense of another benefit, however, should not nullify its use as a basis to modify the disclosure of one reference with the teachings of another. Instead, the benefits, both lost and gained, should be weighed against one another.”). Here, Dr. Liu listed numerous benefits of having a reduced diameter, which weigh against the potential downsides raised by Patent Owner. Ex. 1003 ¶¶ 111–114. Moreover, we do not see how the downsides/tradeoffs prevent modifying Kobayashi in the manner suggested when the same tradeoffs appear to be applicable to the ’409 patent. Having considered Patent Owner’s arguments, and taking into” slip op. at 43
Patent outcomesUS 7,812,409 mixedClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 7,812,409 - Inergy Technology, Inc. v. Force Mos Technology Co., Ltd.No claims unpatentablePTAB · May 16, 2025 · IPR2024-00093 · APJ Grace Karaffa Obermann · IPR · Final written decision
Claims 1–9 were not proven unpatentable because the asserted references did not establish the claimed epitaxial layer or the required coverage of the trench sidewalls.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner defines a person of ordinary skill in the art as having “a Master’s degree in electrical engineering, and at least two years of relevant work experience in the field of integrated circuit design and manufacturing.” Pet. 13 (citing Ex. 1003 ¶¶ 32–37, 57). Patent Owner does not dispute Petitioner’s definition. PO Resp. 6. We adopt Petitioner’s proposed definition of the level of ordinary skill in the art because it is supported by unopposed declaration testimony and appears to be consistent with the disclosures of the ’634 patent and the asserted prior art references. See Ex. 1001, 1:6–2:33 (describing the invention and related art in terms of integrated circuit design and fabrication); see also Ex. 1006 ¶¶ 1–6 (Hirler); Ex. 1008 ¶¶ 1–37 (Kobayashi); Ex. 1009 ¶¶ 2–29 (Shiraishi). Neither party, moreover, indicates the overall result would change based on a different definition.” slip op. at 7
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“Petitioner argues that “the sidewalls of said trenches in said base layer are covered” should be construed to mean that “the entire sidewalls of” those trenches are covered. Pet. 18–19. We refer to this as “the sidewall limitation.” Petitioner shows persuasively that the disclosure and file history of the ’634 patent support its position on the sidewall limitation. Id. Patent Owner, for its part, observes that, after the filing of the Petition. two District Courts adopted the construction proposed by Petitioner.” PO Resp. 21 (citing Ex. 2010, 6–9; Ex. 2011, 23). Patent Owner also agrees to apply Petitioner’s construction for purposes of this proceeding. Id. We agree with Patent Owner that an express construction of the sidewall limitation is necessary to this Decision, id., and adopt Petitioner’s undisputed definition because it is supported by the record. No other claim term requires express construction for purposes of this Decision.” slip op. at 8
- BurdenNot shown unpatentable
“On this record, Petitioner fails to demonstrate that any claim is unpatentable under any ground asserted in the Petition. IV. CONCLUSION For the above reasons, we determine that Petitioner fails to establish by a preponderance of the evidence that claims 1–9 of the ’634 patent are unpatentable.” slip op. at 34
- Expert testimonyPetitioner expert discountedPatent owner expert creditedDecided for patent owner
“Alternatively, even if we set aside that timing issue, Dr. Liu’s bare opinion, advanced for the first time during cross-examination, that an epitaxial layer is “obvious” from Hirler’s disclosure is inadequate to support the challenges. Id. at 24–25. We accord little weight to Dr. Liu’s opinion because it is conclusory. See Xerox Corp. v. Bytemark, Inc., IPR2022-00624, Paper 9 at 15 (PTAB Aug. 24, 2022) (precedential). In any event, Petitioner does not meet, on this record, the “high standard” required to establish an inherent disclosure of an epitaxial layer in Hirler. PO Resp. 24.6 Dr. Liu opined for the first time during cross-examination “that it would have been impossible to create Hirler’s more lightly doped n- drift zone layer on top of its more heavily doped n+ substrate layer other than via epitaxy.” Id. at 25 (citing Ex. 2014, 164:16– 165:20). But Patent Owner effectively refutes that proposition with evidence that such a layer “could be created by counter-doping,” even if, as Dr. Liu contends, counter-doping may have been less ideal due to “disadvantageous mobility.” Id. (citing Ex. 2012 ¶ 133; Ex. 2014, 166:15–167:8).” slip op. at 11
Patent outcomesUS 7,629,634 not shown unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 7,629,634 - Jiangsu Favored Nanotechnology Co., Ltd. v. P2i Ltd.All claims unpatentablePTAB · Apr 11, 2025 · IPR2024-00380 · APJ Sheldon M Mcgee · IPR · Final written decision
Claims 1–5, 7, and 9–14 are unpatentable as obvious over Cohen and Legein or Francesch and Legein; Petitioner’s motion to strike is denied as moot.
RulingsFinal written decision- Skill levelSkill level board ownDecided for petitioner
“The parties agree that a person of ordinary skill in the art in the field of the ’087 patent in June 20154 “would have had at least a bachelor’s degree in a field such as chemistry, physics, or chemical engineering, as well as at least two years of experience with plasma-polymerization techniques.” Pet. 20 (citing Ex. 1002 ¶¶ 22–29); PO Resp. 13 (Patent Owner stating that it “does not dispute this characterization of the level of ordinary skill in the art.”); see also PO Sur-reply 1–2 (noting both parties’ agreement on the education and experience level of the ordinarily skilled artisan).” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“On the fully developed trial record, we determine that no claims need an express construction. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co. Ltd., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (holding that only claim terms in controversy need to be construed, and only to the extent necessary to resolve the controversy (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 9
- Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner
“Because of Patent Owner’s shifting definitions of the education and experience level of the ordinarily skilled artisan, it is unclear on the complete record what precise definition Patent Owner and Dr. Senkevitch are applying when arguing the skilled artisan’s capabilities. PO Resp. 13, 22–27, 31–32, 34–40; PO Sur-reply 1–6, 11–13; Ex. 2007 ¶¶ 30, 31, 33, 34, 37, 40, 52–55, 60, 68, 74, 76, 77, 80–86, 89, 91, 94, 95, 100, 102–105, 108, 110, 111, 113–116, 118–120, 122, 124, 127–134. We, therefore, give Dr. Senkevitch’s testimony regarding the capabilities of a person of ordinary skill in the art minimal weight, which leaves us with Patent Owner’s insufficiently supported arguments regarding the skilled artisan’s capabilities. PO Resp. 13, 22–27, 31–32, 34–40; PO Sur-reply 1–6, 11–13. Moreover, as Petitioner correctly points out, the ʼ087 patent expressly teaches that the precise conditions for forming a protective polymeric coating “will vary depending upon factors such as, without limitation, the nature of the monomer compound, the crosslinking agent, the substrate, as well as the desired properties of the coating” and that such “conditions can be determined using routine methods.” Ex. 1001 15:1–15:5 (emphasis added); Pet. Reply 17. Where the patent itself leaves to the judgment of an ordinarily skilled artisan the assessment of these factors to ascertain suitable conditions for forming the protective coating, we find persuasive Petitioner’s view that it would have been well within the level of ordinary skill to ascertain such suitable conditions.” slip op. at 20
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“We disagree with Patent Owner. Although the claims of the ʼ087 patent recite obtaining the protective cross-linked polymeric coating “by exposing the device or component to a plasma,” the field of endeavor analysis in an analogous art inquiry does not exclusively turn on the claims at issue, but rather takes account of the entirety of a patent’s disclosure. See In re Bigio, 381 F.3d 1320, 1326 (Fed. Cir. 2004) (explaining that “the PTO must show adequate support for its findings on the scope of the field of endeavor in the application’s written description and claims” (emphasis added)); In re Mettke, 570 F.3d 1356, 1359 (Fed. Cir. 2009) (rejecting an argument that the field of endeavor was limited to a claimed “Internet terminal” when “the specification describes various communication media, including facsimile machines and email, as related to the invention.”). This is significant here because the ʼ087 patent discloses that “[t]he … invention relates to protective coatings” and specifically “relates to protective coatings for electronic or electrical devices and components thereof, and methods of forming such coatings.” Ex. 1001, 1:14–17. Based on this disclosure, we find that the ʼ087 patent’s field of endeavor relates to “protective coatings for electronic or electrical devices and components thereof” broadly, not just those formed on such devices or components via a plasma polymerization process as asserted by Patent Owner. Id. Although Cohen does not explicitly disclose that its crosslinked polymers constitute a “protective coating,” Cohen does disclose that its “copolymerizable mixture can be cast into films” (Ex. 1004, 2:61–62), that the polymerization can “effected in situ,” and that the polymers may be used in “numerous” electrical applications (id. at 5:17–25). Tr. 8:9–10:2, 27:2– 21; see Pet. Reply 5 (explaining how “Cohen described insulating polymers that could be applied as films and be used to protect substrates including cables and electrical coils.” (citing Ex. 1004, 2:60–63, 5:13–25)). These disclosures suggest strongly that Cohen’s crosslinked polymers––if cast into a film or formed in situ on an electrical device or component––would serve as a protective coating on that electrical device or component, even though Cohen does not expressly refer to its crosslinked polymers ipsis verbis as a “protective coating.” Thus, we find that Cohen is within the field of endeavor of the ʼ087 patent.” slip op. at 15
Patent outcomesUS 11,041,087 unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,041,087 - PTAB · Mar 27, 2025 · IPR2024-01451 · APJ Erica A Franklin · IPR · Institution
The Board instituted review of claims 1–19 on all petition grounds, finding a reasonable likelihood that claim 1 would have been obvious over Larson alone.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“of whether we exercise our discretion to deny institution under 35 U.S.C. § 314(a). Rather, when considering the Fintiv factors, we “take[] a holistic view of whether efficiency and integrity of the system are best served by denying or instituting review.” Fintiv at 6. Here, factors one and six are neutral, factors two and three weigh against discretionary denial, and factors four and five favor denial. We assign less weight to the existence of an overlap in asserted claims and prior art, in view of there being no trial date scheduled in the District Court case and no persuasive evidence that the court’s trial date would be expected to be significantly before the due date of our Final Written Decision. Therefore, after weighing all of the factors, we determine that the facts in this case that weigh against exercising discretion outweigh the facts that favor exercising discretion. Accordingly, we decline to exercise our discretion to deny institution under § 314(a).” slip op. at 13
- Skill levelSkill level petitioner adoptedDecided for petitioner
“At this stage in the proceeding, Patent Owner does not dispute Petitioner’s description of the person of ordinary skill in the art. Prelim. Resp. 27. In view of this, and because Petitioner’s uncontested description of one of ordinary skill in the art is reasonable and consistent with the ’921 patent and the cited art, we adopt Petitioner’s definition for purposes of this Decision. We note, however, that the open-ended language “at least” expands the range of experience indefinitely with no upper bound. Therefore, we do not apply this aspect of Petitioner’s formulation.” slip op. at 14
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“We determine that there is no need to expressly construe any claim term to determine whether to institute an inter partes review. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 controversy, and only to the extent necessary to resolve the controversy’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). To the extent that any discussion regarding the scope of a claim term is relevant to our decision, we address that issue in our analysis of the asserted grounds of unpatentability.” slip op. at 15
- Novelty / Anticipation (§102) › Prior-art status of a reference › Patents / published applications (effective date, provisional support)Reference not prior artDecided for patent owner
“Owner that Petitioner has not demonstrated sufficiently in the Petition, for purposes of institution, that all of the portions of Saxonov relied upon in the Petition are prior art. In particular, we determine that Petitioner has not established that the disputed portions of Saxonov are entitled to claim the benefit of the ’013 provisional filing date because Petitioner has failed to satisfy the second condition for this benefit, i.e., by showing that the provisional application provides sufficient support for certain subject matter in Saxonov relied upon for prior art purposes in the Petition.” slip op. at 28
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · GrahamPatents in suitUS 11,827,921 - Cargill, Incorporated v. Bunge Loders Croklaan USA, LLCInstitution deniedPTAB · Mar 19, 2025 · IPR2024-01360 · APJ Debra L Dennett · IPR · Institution
The Board denied institution because the petition did not show a reasonable likelihood that claims 1, 6–9, and 11–24 were unpatentable as obvious.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“institute review. The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted unless the information presented in the Petition shows “there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Having considered the arguments and the associated evidence, we determine that Petitioner does not meet the reasonable likelihood standard, and we do not institute inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“For purposes of this institution decision, and based on the present record including the disclosure in the ʼ473 patent, we apply Petitioner’s definition of the level of ordinary skill in the art at the time the invention was made, consistent with pre-AIA section 103(a). See Pet. 9–10. We determine this level of skill comports with the qualifications a person would have needed to understand and implement the teachings of the ʼ473 patent and the prior art of record. Cf. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (noting that the prior art itself may reflect an appropriate level of skill in the art).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner proposes constructions for several terms, all such constructions based on statements in the ’473 patent. See Pet. 10–12. Patent Owner presents no claim construction issues. Prelim. Resp. 8 n.3. For purposes of this Decision, we determine that no claim term requires express interpretation at this time. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (per curiam) (claim terms need to be construed “only to the extent necessary to resolve the controversy” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightMotivation not foundDecided for patent owner
“Petitioner’s representation of the problem as merely converting Petrauskaite’s disclosed mol% of triglycerides into wt% of triglycerides with simple calculations represents a form of prohibited reliance on hindsight. See Mintz v. Dietz & Watson, Inc., 679 F.3d 1372, 1377 (Fed. Cir. 2012) (hindsight to use the invention to define the problem the invention solves); see also Ecolochem, Inc. v. Southern Cal. Edison Co., 227 F.3d 1361, 1372 (Fed. Cir. 2000) (”Defining the problem in terms of its solution reveals improper hindsight in the selection of the prior art relevant to obviousness.”). “[W]hen someone is presented with the identical problem and told to make the patented invention, it often becomes virtually certain that the artisan will succeed in making the invention.” Mintz, 679 F.3d at 1377. Here, Petitioner urges that one of ordinary skill in the art need merely convert mol% of triglycerides in a specific fat blend into wt% of triglycerides in the specific fat blend. See Pet. 14–15 (“[T]he wt% of Petrauskaite’s fat blends can easily be calculated based on the generally available prior art knowledge of fatty acid compositions of palm stearin and soybean oil.”). Petitioner’s reasoning says no more than that a skilled artisan, once presented with Petrauskaite and prior art knowledge, “would have understood that they could be combined, but that is not enough.” PersonalWeb Techs., LLC, v. Apple, Inc., 848 F.3d 987, 993 (Fed. Cir. 2017) (that two references could be combined does not imply a motivation to pick out those two references and combine them to arrive at the claimed invention). Our reviewing court instructs that indicating that a skilled artisan could have made modifications to arrive at the claimed invention does not establish that a person of ordinary skill would have made such modifications. See Belden Inc. v. Berk-Tek LLC, 805 F.3d 1064, 1073 (Fed. Cir. 2015) (“obviousness concerns whether a skilled artisan not only could have made but would have been motivated to make the combinations or modifications of prior art to arrive at the claimed invention.” (citing InTouch Technologies, Inc. v. VGO Communications, Inc., 751 F.3d 1327, 1352 (Fed. Cir. 2014)). Petitioner attempts to check the “would have been motivated to modify Petrauskaite” box with testimony from its declarant, Dr. Maragoni. See Pet. 37–38. Such testimony includes [C]ombining such prior art elements according to known methods would have yielded nothing more than predictable results. A POSITA would naturally have turned to these references to understand Petrauskaite’s references better. Ex. 1003 ¶ 178. [T]he corresponding wt% of Petrauskaite’s fat blends] was readily-available and well-known in the art. Id. at ¶ 181. [T]he available information [on characterizations of oils and fats] is voluminous. Id. at ¶ 182. See Pet. 38. We find that such testimony fails to explain why the skilled artisan would have been motivated, without hindsight, to take the steps to reproduce the claimed invention, and to be conclusory, at best. On this record, we detect the taint of impermissible hindsight bias in” slip op. at 14
Claim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 7,645,473 - Ningbo Linhua Plastic Co., Ltd. v. Converter Manufacturing, LLCInstitution deniedPTAB · Mar 10, 2025 · IPR2024-01435 · APJ James A Tartal · IPR · Institution
Institution was denied for claims 6–10 and 21 because Petitioner did not show a reasonable likelihood that Portelli or Meadors rendered the claims obvious.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. 35 U.S.C. § 314(b) (2018); 37 C.F.R. § 42.4(a) (2023). An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Upon consideration of the Petition, the Preliminary Response, and the evidence of record, we conclude that the information does not demonstrate a reasonable likelihood that Petitioner” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Id. Patent Owner does not dispute Petitioner’s proposed level of ordinary skill. See generally Prelim. Resp. For purposes of this Decision, we find that the ’222 patent and the cited prior art references reflect the appropriate level of skill at the time of the claimed invention and that the level of appropriate skill reflected in these references and the ’222 patent is consistent with the definition of a person of ordinary skill in the art proposed by Petitioner. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). Accordingly, we adopt Petitioner’s asserted level of ordinary skill in the art.” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Plain and ordinary meaningNo construction neededOther
“Petitioner argues that “the challenged claims are invalid under their plain and ordinary meaning.” Pet. 5. Petitioner further contends that “[t]he scope of the plain and ordinary meaning of certain claim terms must at least encompass the disclosure and accompanying illustrations in the ’222 patent.” Id. at 6 (citing no legal support for its proposition). Petitioner also refers to how Patent Owner applied certain “terms” and “other features to Petitioner’s product” in its district court complaint against Petitioner. See id. at 7–8 (citing Ex. 1007, 7–8; Ex. 1003, ¶¶ 53–57). Patent Owner does not address claim construction and does not dispute the meaning of any claim term in regard to Petitioner’s contentions. See generally Prelim. Resp. Accordingly, in view of the issues we address below, we apply the plain and ordinary meaning of claim terms and further determine that it is not necessary to address the express interpretation of any claim term. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017); Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”).” slip op. at 11
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“Figure 13 of Portelli, however, does not show the profile of an article prior to a method step of impinging to further shape it, but instead shows “a schematic sectional view of the edge of the tray . . . after it has been deformed out of the wrap path in accordance with the invention [of Portelli].” Ex. 1004, 8:11–13 (emphasis added). Petitioner fails to show any method taught by Portelli that further alters the configuration of the profile of the tray shown in Figure 13 of Portelli by, for example, an additional method step of impingement.” slip op. at 18
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,562,222 - PTAB · Feb 25, 2025 · IPR2024-01296 · APJ Amee A Shah · IPR · Institution
The Board instituted IPR of claims 1–46 on all petitioned grounds, finding a reasonable likelihood that at least one challenged claim would have been obvious.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“On balance, we determine that Fintiv factors 1–5 do not favor discretionary denial of institution. In particular, we determine that factors 1 and 5 are neutral, factors 2 and 3 weigh against denial, and factor 4 is of institution, does not outweigh factors 1–3 and 5. As a result, we need not and, therefore, do not decide whether Petitioner presents a compelling unpatentability challenge. See CommScope Techs. LLC v. Dali Wireless, Inc., IPR2022-01242, Paper 23 at 4–5 (PTAB Feb. 27, 2023) (decision on Director review) (precedential) (“[I]n circumstances where the Board determines that the other Fintiv factors 1–5 do not favor discretionary denial, the Board shall decline to discretionarily deny under Fintiv without reaching the compelling merits analysis.”). 7. Fintiv Determination The balance of all Fintiv factors do not favor the exercise of our discretionary powers to deny institution. Therefore, we determine that discretionary denial is not appropriate in this case.” slip op. at 20
- Parallel petitionsDenied
“B. 35 U.S.C. § 314(A) – PARALLEL PETITION The Petition seeks inter partes review of the same claims of the ’380 patent that Petitioner previously requested review of in IPR2024-00953. Pet. 1. Patent Owner argues that the Petition should be discretionarily denied under § 314(a) for failure to show good cause for a second petition. Prelim. Resp. 67–73. The Board denied institution in IPR2024-00953, exercising discretion under § 314(a) based on the existence of the petition in this proceeding. IPR2024-00953, Paper 18. We thus decline to deny institution based on a parallel petition.” slip op. at 21
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDenied
“However, we find that Fang is not cumulative of the art considered by the Examiner in prosecution. Further, Patent Owner does not direct attention to, and we do not see, how or where the Examiner considered Khalil for teaching removing the air line for directly connecting the external pump to connecting a pump housing to a diaphragm housing” (POPR 50), the Examiner specifically found that Khalil did not teach the diaphragm housing being fixed to a recessed surface of the pump housing (Ex. 1002, 24), for which Petitioner relies on Fang (Pet. 37). And we note that Petitioner relies on Fang for the element the Examiner found was not taught by the prior art, including Khalil. Ex. 1002, 24; Pet. 37. Accordingly, we determine that discretionary denial is not warranted because the asserted combinations, all of which include Fang, were not previously presented to the Office. Because we determine that part one of the framework is not satisfied, we need not, and therefore do not, turn to part two of the analysis, which concerns whether Petitioner demonstrates that the Office erred in a manner material to the patentability of the challenged claims. 5. Conclusion Regarding Discretionary Denial under § 325(d) The Advanced Bionics framework “reflects a commitment to defer to previous Office evaluations of the evidence of record unless material error is shown.” Advanced Bionics, IPR2019-01469, Paper 6 at 9. Under the present circumstances, we determine that the same or substantially the same prior art combinations or arguments were not previously presented to the Office. Accordingly, we decline to exercise our discretion to deny institution under § 325(d).” slip op. at 27
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“IV. CONCLUSION For the foregoing reasons, we determine that Petitioner demonstrates a reasonable likelihood of prevailing with respect to at least one of the claims challenged in the Petition. Accordingly, inter partes review of the ’380 patent shall proceed in this case on all of the grounds raised in the Petition. See SAS, 138 S. Ct. at 1359–60; PGS Geophysical AS v. Iancu, 891 F.3d 1354, 1360 (Fed. Cir. 2018).” slip op. at 65
Claim construction§ 103 obviousnessDiscretionary denialcites KSR · GrahamPatents in suitUS 11,413,380
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.