- PTAB · Mar 20, 2024 · IPR2023-01381 · APJ Jon B Tornquist · IPR · Institution
Instituted IPR of claims 1–12 on all petition grounds; the Board found a reasonable likelihood of success on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). Having considered the arguments and evidence presented by Petitioner and Patent Owner, we determine that the information presented in the Petition demonstrates a reasonable likelihood that Petitioner would prevail on at least one of the challenged claims of the ’294 patent. Accordingly, we institute an inter partes review as to all of the challenged claims of the ’294 patent on all of the grounds of unpatentability set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends a person of ordinary skill in the art “would have possessed at least a four-year degree in electrical engineering, chemical engineering, physics, or material science, or a closely related field, and at least two years of experience in semiconductor device design or fabrication, including the processing of semiconductor materials, analysis of device operation, or the development of new device topologies.” Pet. 5–6. Patent Owner does not address the knowledge or education of a person of ordinary skill in the art. On this record, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it appears consistent with the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (holding that the prior art itself can reflect the appropriate level of ordinary skill in the art).” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner
“Petitioner contends the terms “compensated GaN layer” and “above” require construction. Pet. 12–17; Prelim. Reply 1–5. Patent Owner contends only the term “compensated GaN layer” requires construction. Prelim. Resp. 5–15; Prelim. Sur-reply 1–3. Upon review of the parties’ arguments and evidence, we determine that only the term “compensated GaN layer” requires construction. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 8
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“Claims Claim terms are generally given their ordinary and customary meaning, which is the “meaning that the term would have to a person of ordinary skill in the art in question at the time of the invention.” Phillips, 415 F.3d at 1313. Patent Owner does not present evidence that the ordinary meaning in the art of a “GaN layer” is “GaN gate material.” Indeed, the prior art of record discloses multiple GaN layers that do not appear to be “gate material.” Ex. 1006 ¶ 32; Ex. 1005 ¶ 74 (“the channel layer 20 is GaN”); Ex. 1008 ¶¶ 24–25 (noting that the buffer layer and semiconductor layer are GaN). Nor does Patent Owner contend that the term “compensated” requires or implies a particular orientation or location with respect to the gate contact. Thus, by itself, the term “compensated GaN layer” does not require a “compensated GaN gate material.” Rather, Patent Owner contends that given the placement of the “compensated GaN layer” above the barrier layer and below the gate contact, one of ordinary skill in the art would have understood that the claimed “compensated GaN layer” is a “compensated GaN gate material.” Prelim. Resp. 7. We are not persuaded by this argument, at this stage of the proceeding, because the prior art (Uemoto) discloses a compensated GaN layer that is above a barrier layer and below a gate contact, as recited in claim 1, and Patent Owner contends this layer is not a “compensated GaN layer.” Ex. 1006, Fig. 7; Prelim. Resp. 31–32. This tends to suggest that the placement of a “compensated GaN layer” above a barrier layer and below a gate contact, without more, does not necessarily indicate that said layer is part of the gate. In view of the foregoing, on this record, we determine that the language and structure of claim 1 does not support a construction requiring that the “compensated GaN layer” be a “compensated GaN gate material.”” slip op. at 11
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,350,294 - PTAB · Mar 20, 2024 · IPR2023-01383 · APJ Kimberly Mcgraw · IPR · Institution
The Board instituted review of claims 1–5 on all asserted grounds after finding a reasonable likelihood that claim 1 would have been obvious over Yoshida, Beach, and Sheppard.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons set forth below, we determine that Petitioner has sufficiently shown a reasonable likelihood that it would prevail with respect to at least one claim of the ’508 patent. Accordingly, we institute an inter partes review of all challenged claims of the ’508 patent on all grounds asserted in the Petition. See SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1359– 60 (2018); PGS Geophysical AS v. Iancu, 891 F.3d 1354, 1360 (Fed. Cir. 2018) (stating that a decision to institute is “a simple yes-or-no institution choice respecting a petition, embracing all challenges included in the petition”).” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“had a “at least a four-year degree in electrical engineering, chemical engineering, physics, or material science or a closely related field and at least two years of experience in semiconductor device design or fabrication, including the processing of semiconductor materials, analysis of device 1 The Leahy-Smith America Invents Act (“AIA”), Pub. L. No. 112–29, 125 Stat. 284 (Sept. 16, 2011), includes revisions to Section 103 that became effective on March 16, 2013. Because the challenged claims issued from an application filed before March 16, 2013, we apply the pre-AIA law to the challenges. See Ex. 1001, code (30). 2 JP H11-261053, published Sept. 24, 1999 (Ex. 1004, pp. 8–11 (original language), pp. 1–7 (certified English translation), p. 12 (certification) “Yoshida”)). All references are to the English translation portion of Ex. 1004. 3 US 2007/0057624, published June 23, 2005 (Ex. 1005, “Beach”). 4 US 7,238,560, issued July 3, 2007 (Ex. 1006, “Sheppard”). 5 US Pub. App. No. 2006/0273347, published Dec. 7, 2006 (Ex. 1007, “Hikita-347”). 6 US Pub. App. No. 2008/0079023, published Apr. 3, 2008 (Ex. 1008, “Hikita-023”). education could substitute for professional experience and vice versa.” Pet. 11 (citing Ex 1003 ¶ 69). Patent Owner does not challenge Petitioner’s definition or offer its own. See generally, Prelim. Resp. In light of the record before us, and for purposes of this Decision, we adopt Petitioner’s proposal regarding the level of ordinary skill in the art. Based on our review of the ’508 patent and the prior art of record, we determine that the definition offered by Petitioner comports with the qualifications a person would have needed to understand and implement the teachings of the ’508 patent and the prior art.” slip op. at 10
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownOther
“At this stage of the proceeding, based on the present record, we determine that the claims require that the dielectric layer steps of [1f] must occur before the ohmic contact steps of [1g] but that the claims do not require that the gate structure be formed before the source and drain contacts. Step [1f] recites depositing a dielectric layer; applying a contact photo resistant pattern; etching the dielectric layer to open the drain and source contact area; and removing the contact photo resistant pattern. Ex. 1001, 7:5–9. Thus, it appears that the drain and source contact area recited in step [1f3] is the area where the drain and source contacts are formed. The ohmic contact steps of [1g] are directed to forming the drain and source contacts. As a matter of logic, the drain source contact area must be opened before the drain and source contacts are formed. As such, the dielectric layer steps of and removal of the contact photo resistant pattern––must be performed before the ohmic contact steps of [1g] to form the Ohmic drain and source contacts are performed. Petitioner does not dispute this construction. See Reply 1–9 (disputing whether the gate must be formed before the source and drain, but not disputing that the dielectric layer [1f1] must be deposited before forming the source and drain contacts [1g]).” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“contact is formed after the source and drain contacts are formed––differs from Beach’s process––which appears to form the gate contact at the same time as the ohmic (source/drain). We also acknowledge Patent Owner’s arguments that these two methods are inconsistent and contrary to each other. Prelim. Resp. 20–22. However, Petitioner has provided evidence and argument, supported by declaration testimony, that it would have been obvious to combine Yoshida and Beach to arrive at the subject matter of claim 1. For example, Petitioner asserts that a POSITA would have been motivated to use Beach’s resist pattern 13 as a single gate photo resistant pattern to etch away both Yoshida’s gate contact layer and doped GaN layer in order to remove the second mask step to decrease costs and simplify the manufacturing process, as well as improve gate alignment. Pet. 21 (citing, inter alia, Ex. 1003 ¶¶ 125–126). Petitioner has also provided evidence and arguments, supported by declaration testimony, that a POSITA would have been motivated to use Beach’s resist pattern 13 as a metal photo resistant pattern to etch away Yoshida’s metal Al (ohmic contact metal) deposited on layer 4. Pet. 35 (citing Ex. 1004 ¶¶ 10, 22; Ex. 1003 ¶ 135). These contentions are sufficient, for purposes of institution, to show that a POSITA would have had reason to combine Yoshida and Beach in the manner and arguments, supported by declaration testimony, that a POSITA would have had a reasonable expectation of success in combining the teachings of the prior art to arrive at the claimed invention. Pet. 20. We have considered all of Patent Owner’s arguments to the contrary, and determine they raise issues best resolved on a full record. For all of the foregoing reasons, we determine that Petitioner has sufficiently shown that Yoshida, Beach, and Sheppard teach or suggest all of the limitations of claim 1 and that a person of ordinary skill in the art would have had reason to combine the teachings of the asserted art. Accordingly, we determine that Petitioner has demonstrated a reasonable likelihood of showing that claim 1 would have been obvious over Yoshida, Beach, and Sheppard.” slip op. at 29
Claim construction§ 103 obviousnesscites PhillipsPatents in suitUS 8,404,508 - Amphenol Corp. v. PPC Broadband, Inc.InstitutedPTAB · Mar 20, 2024 · IPR2023-01363 · APJ Jon B Tornquist · IPR · Institution
Instituted IPR on claims 1, 2, and 10–13 because Petitioner showed a reasonable likelihood of prevailing on at least one challenged claim, including obviousness over Holmberg and Battey.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). Having considered the arguments and evidence presented by Petitioner and Patent Owner, we determine that the information presented in the Petition demonstrates a reasonable likelihood that Petitioner would prevail on at least one of the Challenged Claims of the ’483 patent. Accordingly, we institute an inter partes review as to all the Challenged Claims of the ’483 patent on all the grounds of unpatentability set forth in the Petition.” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner contends claim 1 should be construed to require that “the drop cable retain its external jacket as it is routed internally.” Pet. 10. Petitioner contends this construction differs from Patent Owner’s apparent construction in the district court, “which allows the external jacket to be removed as the drop cable enters the DIB and the fibers routed inside the box without the external jacket.” Id. at 10–11. Patent Owner contends Petitioner’s narrower construction requiring the “drop cable” retain its external jacket is incorrect, but contends “the Board need not resolve this claim construction dispute to deny institution because Petitioner’s proposed Grounds 1–5 are all insufficient under” either party’s construction. Prelim. Resp. 9. Upon review of the parties’ arguments and the prior art of record, we determine that no claim terms require express construction for purposes of this decision. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)). We address below, however, whether the recited cable types themselves constitute claim limitations.” slip op. at 11
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“slack fiber. Prelim. Resp. 33–37. These arguments are not persuasive. First, Petitioner does not propose a bodily incorporation of Battey’s shelf into the device of Holmberg. Rather, Petitioner’s proposed combination retains splice tray 230 of Holmberg and relies on Battey for its disclosure of using a hinge connection for the splice tray. Pet. 40 (asserting that one of ordinary skill in the art “would have found it obvious to modify Holmberg pursuant to Battey, resulting in splice tray 230 moveable relative to main body 216”), 43 (“Such a modification would have been a simple substitution of a hinged connection instead of a fastener.”). Second, although Battey utilizes a fixedly mounted slack basket to store excess cable, we are directed to no disclosure or teaching in Battey that teaches away from using other means of storing slack fiber.” slip op. at 23
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDecided for petitioner
“For the reasons set forth below, we determine that part two of the Advanced Bionics framework has not been satisfied. Thus, we need not address whether part one of the framework is satisfied in view of the alleged cumulative nature of Laporte and Battey.” slip op. at 30
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 9,008,483 - Amperex Technology Ltd. v. Semiconductor Energy Laboratory Co., Ltd.Institution deniedPTAB · Mar 12, 2024 · IPR2023-01349 · APJ Christopher M Kaiser · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood of proving any challenged claim unpatentable on the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons set forth below, we determine the information presented in the Petition does not establish a reasonable likelihood that Petitioner would prevail with respect to at least one of the challenged claims. Accordingly, we do not institute an inter partes review of any claim on any ground asserted in the Petition.” slip op. at 2
- BurdenDenied
“Given this, to show that Blangero’s disclosure of MgO or LiF in its coating teaches or suggests a rock-salt crystal structure, Petitioner needs to explain why a person of ordinary skill in the art either would have understood the compounds to have a rock-salt crystal structure when manufactured according to the disclosure of Blangero or would have chosen to use MgO or LiF in a rock-salt crystal structure rather than in another available form. On the first point, Petitioner argues that “‘the stable phase at room temperature and pressure conditions’ of MgO is ‘a rocksalt cubic structure of NaCl (space group Fm-3m).’” Pet. 28 (quoting Ex. 1030, 16; citing Ex. 1003 ¶ 142). But, as Petitioner’s declarant, Dr. Hayes, points out, Blangero does not teach forming MgO in a room-temperature process. Ex. 1003 ¶ 142 (Blangero’s “second firing step” occurs at “925 °C for 12 hours”); see Ex. 1005 ¶ 110 (teaching the firing step to which Dr. Hayes refers). Thus, the significance of rock-salt-type MgO being “the stable phase at room temperature and pressure conditions” is unclear. To the extent that Dr. Hayes explains why MgO, which “is well known to crystallize even at substantially lower temperatures,” such as “room temperature and pressure conditions,” would “do so more readily at [a higher temperature of] 925 °C,” this argument is not discussed, nor even cited, in the Petition. Ex. 1003 ¶¶ 90–94; see Pet. 28. Accordingly, any reliance on this argument by Petitioner constitutes improper incorporation by reference. 37 C.F.R. § 42.6(a)(3). Thus, Petitioner does not show sufficiently that a person of ordinary skill in the art either would have understood MgO to have a rock-salt crystal structure when manufactured according to the disclosure of Blangero or would have chosen to use MgO in a rock-salt crystal structure rather than in another available form. Similarly, with respect to LiF, neither Petitioner nor Dr. Hayes sufficiently explains the choice of rock-salt-type material over other options. Pet. 29 (arguing only that Ex. 1013 shows that “LiF has rock salt structure”); Ex. 1003 ¶ 143 (same). Thus, Petitioner does not show sufficiently that Blangero teaches or suggests a rock-salt crystal structure by virtue of its teaching that either MgO or LiF is present.” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not found
“The 2012 study on which Petitioner relies did not find “superior structural stability” over other lithium-titanium-oxygen compounds, as Petitioner argues. Instead, the study noted that the structure of “LiTiO2 prepared by high-temperature sintering TiO2 with lithium salt . . . impl[ies] LiTiO2 has superior structural stability in organic electrolyte as compared to other Li-Ti-O oxides.” Ex. 1029, 1. Thus, the structural stability was implied from the chemical structure of the material rather than found through study of the material. Moreover, the implied structural stability was only for LiTiO2 that was prepared in a particular way, by high-temperature sintering of TiO2 with lithium salt, and Petitioner does not allege that a person of ordinary skill in the art would have prepared the LiTiO2 they substituted for Blangero’s Li2TiO3 using this method. As for Petitioner’s argument that the study found that LiTiO2 outperformed Li2TiO3, we are not persuaded. The study compared particles with an LiTiO2 coating to uncoated particles, not to particles coated with Li2TiO3. Ex. 1029, 4, Figs. 4(c), 4(d). Although the study notes that particles coated with “[m]onoclinic Li2TiO3 and spinel Li4Ti5O12” exhibit “a noticeable capacity decay . . . when charged at high operating voltage and cycled above room temperature,” it concludes only that particles coated with LiTiO2 “exhibited inspiring high-voltage cycling capability as well as thermal stability than the pristine counterpart.” Id. at 1, 4. In addition, the pristine particles used in the study were made from “Li[NixCoyMnz]O2 (0≤x,y,z<1) (called as LNCM),” and the particles in Blangero do not contain either nickel or manganese in their cores. Ex. 1005 ¶¶ 9–40 (particles contain lithium, oxygen, cobalt, and metals chosen from the group consisting of aluminum, gallium, boron, magnesium, titanium, iron, copper, calcium, barium, yttrium, tin, antimony, sodium, zinc, zirconium, silicon); Ex. 1029, 1. Petitioner does not explain why a person of ordinary skill in the art would expect the study’s results to extend to Blangero’s particles made from a different material. Pet. 29–30. Because Petitioner has not shown sufficiently that Blangero teaches or suggests a second region comprising a rock-salt crystal structure or that a person of ordinary skill in the art would have had a reason to substitute rocksalt-type LiTiO2 for the materials disclosed in Blangero, Petitioner has not shown a reasonable likelihood that it would prevail on claim 1 on its Blangero-based grounds.” slip op. at 15
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner, “[i]ndividuals with different education and additional experience could still [have been] of ordinary skill in the art if that additional experience compensate[d] for a deficit in their education and experience.” Id. On the present record, Patent Owner does not contest Petitioner’s definition of a person of ordinary skill in the art. Prelim. Resp. 19. In light of the record before us, and for purposes of this Decision, we adopt Petitioner’s proposal regarding the level of ordinary skill in the art. Based on our review of the ’660 patent and the prior art of record, we determine that the definition offered by Petitioner comports with the qualifications a person would have needed to understand and implement the teachings of the ’660 patent and the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown”) (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985)).” slip op. at 8
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,043,660 - Apple Inc. v. RJ Technology, LLCInstitutedPTAB · Feb 23, 2024 · IPR2023-01350 · APJ Jon B Tornquist · IPR · Institution
The Board instituted inter partes review of claims 5–14 on all four asserted obviousness grounds, finding a reasonable likelihood that Apple would prevail on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). Having considered the arguments and evidence presented by Petitioner and Patent Owner, we determine that the information presented in the Petition demonstrates a reasonable likelihood that Petitioner would prevail on at least one of the challenged claims of the ’641 patent. Accordingly, we institute an inter partes review as to all the challenged claims of the ’641 patent on all the grounds of unpatentability set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends a person of ordinary skill in the art, as of the earliest possible priority date for the ’641 patent, “would have held a Bachelor’s degree in chemistry or chemical engineering, with at least 4 years of experience in cell design, electrochemical techniques, and battery materials development.” Pet. 4. Petitioner further contends that a “Master’s Degree can substitute[] for some of the relevant experience,” and “[e]quivalent training with battery specific experience can accommodate other degreed fields.” Id. Patent Owner does not dispute Petitioner’s definition, “except noting that other majors may provide equivalent education and experience designing, testing, and building lithium-ion batteries.” Prelim. Resp. 14. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art for purposes of this Decision. The parties may further address at trial whether “other majors” should be added to this definition, and whether such a modification would have any impact on the unpatentability analysis in this case.” slip op. at 6
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Neither party contends any terms of the ’641 patent require express construction. Pet. 4–5; Prelim. Resp. 13–14. And, for purposes of this decision, we agree that no claim terms require express construction. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“This argument is not persuasive. Contrary to Patent Owner’s arguments, the Federal Circuit has held that “generic” reasons to combine are not inherently suspect, and may reasonably include a desire to make a device “stronger, cheaper, cleaner, faster, lighter, smaller, more durable or more efficient.” See Intel Corp. v. Qualcomm Inc., 21 F.4th 784, 797 (Fed. Cir. 2021) (quoting DyStar Textilfarben GmbH v. C.H. Patrick Co., 464 F.3d 1356, 1368 (Fed. Cir. 2006)). Regardless, Petitioner’s asserted reasons to combine are specific (improved safety and less deterioration after repeated charging and discharging cycles), as is the proposed combination (implementing Sakamoto’s range of ratios for the positive and negative electrode materials in Yamaki’s lithium ion battery). Pet. 9–12. Identification of specific benefits that are tied to specific elements of specific prior art references is sufficient to support an obviousness ground. See Intel, 21 F.4th at 797.” slip op. at 11
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 7,749,641 - Mara Renewables Corporation v. DSM IP Assets, B.V.Institution deniedPTAB · Feb 23, 2024 · IPR2023-01342 · APJ Jon B Tornquist · IPR · Institution
The Board denied institution because the petition did not show a reasonable likelihood that any challenged claim was anticipated or obvious over the asserted references.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). Having considered the arguments and evidence presented by Petitioner and Patent Owner, we determine that Petitioner has not demonstrated a reasonable likelihood of prevailing on at least one of the challenged claims of the ’959 patent. Accordingly, we deny institution of an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that, as of the earliest claimed priority date of the ’959 patent, an ordinarily skilled artisan “would have had a Master of Science degree in an academic discipline emphasizing chemistry, chemical engineering, or biochemistry, in combination with training or at least two to three years of related work experience with lipid chemistry technologies, including but not limited to lipid extraction technologies.” Pet. 6 (citing Ex. 1003 ¶¶ 63–64). Alternatively, Petitioner proposes that an ordinarily skilled artisan “could have also had a Doctorate degree in a relevant academic discipline with one to two years of related work experience in the same discipline.” Id. Petitioner argues that an ordinarily skilled artisan “would have been familiar with microbial oils” and “would have understood the benefits of polyunsaturated fats (PUFAs), microbial sources for obtaining them, and methods for culturing and extracting oils from those microbial sources.” Id. (citing Ex. 1003 ¶¶ 36–48, 64). Patent Owner does not provide a definition of the level of ordinary skill in the art, but “reserves its right to proffer what it contends to be the appropriate level of ordinary skill in the art should the Board institute review.” Prelim. Resp. 15. Patent Owner asserts, however, that a person of ordinary skill in the art would have a detailed understanding of the information provided in its Technology Background section, including “the expected impact of cellular biomass growth characteristics on the proportion of triglycerides and phospholipids produced during a microbial fermentation.” Id. For purposes of this Decision, we adopt Petitioner’s definition of the skill level of an ordinarily skilled artisan as it is consistent with the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (holding that the prior art itself can reflect the appropriate level of ordinary skill in the art). As to the background knowledge possessed by the ordinarily skilled artisan, we agree that such an artisan would have been aware of methods for culturing and extracting oils from microbial sources, including the impact of growth characteristics on the proportions of triglycerides and phospholipids produced during microbial fermentation. Pet. 6; Prelim. Resp. 15.” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner contends that all claim terms of the ’959 patent “should be given their plain and ordinary meaning.” Pet. 3. Patent Owner does not contend that any claim terms require construction. Prelim. Resp. 14–15. For purposes of this Decision, we determine that no claim terms require express construction. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 8
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“3. Analysis In order to anticipate a claim, a prior art reference “must not only disclose all elements of the claim within the four corners of the document, but must also disclose those elements ‘arranged as in the claim.’” NetMoneyIN, Inc. v. VeriSign, Inc., 545 F.3d 1359, 1370 (Fed. Cir. 2008) (quoting Connell v. Sears, Roebuck & Co., 722 F.2d 1542, 1548 (Fed. Cir. 1983)). Radianingtyas discloses microbial oils with various levels of DHA and arachidonic acid. There is no disclosure of an individual microbial oil, however, that contains at least 45% DHA and 1.5% or less arachidonic acid by weight as required by claim 1. With respect to the level of DHA, although Radianingtyas might be interpreted to disclose that some microorganisms can produce up to 60% DHA,8 Radianingtyas discloses that the DHA content of ONC-T18 is “typical[ly]” 35% of the total intracellular fatty acids, and in each experiment disclosed in Radianingtyas DHA was produced by ONC-T18 at 8 Radianingtyas discloses that “the oil producing microbe can produce a lipid composition comprising from about 25% to about 40% of an omega-3 fatty acid, such as n-3 DHA.” Ex. 1007, 26:31–33. It then gives examples that include 15%, 20%, 45%, 50%, 55%, and 60%, which are outside of the disclosed range. Id. at 26:33–34. Dr. Curtis contends the disclosure as a whole should be read as “from about 15% to about 60% of an omega-3 fatty acid, such as n-3 DHA.” Ex. 1003, 39 n.1. Dr. Curtis identifies no microbe in Radianingtyas, however, that is shown to produce more than 40% DHA, and Radianingtyas expressly notes that the typical DHA content produced by ONC-T18 is 35%. Thus, we question Dr. Curtis’ conclusions regarding the DHA content disclosure of Radianingtyas. levels less than “at least 45%.”9 Ex. 1007, 32:21–25 (noting that the “typical composition of fatty acids” produced by ONC-T18 includes 25% DHA), 34:4–37:14 (noting that the control microorganism produced 13.54%, 19.98%, 18.77%, 18.77%, 21.48%, 28.48%, and 14.13% DHA) (Figure 12), 91 (Table 5) (noting that total DHA produced by ONC-T18 was from 24- 34.2%), 99:22–24 (“Of particular interest is ONC-T18 which produces up to 90% of its C20 to C22 content as DHA which is approximately 35% of the total intracellular fatty acids.”). Thus, we are not persuaded that Radianingtyas discloses microbial oils produced by ONC-T18 that have a DHA content of “at least 45%.” As noted by Petitioner, Radianingtyas provides a definition of “purify” and “purifying,” and notes that when these terms are used, it means that a composition could be, for example, 90% pure. Pet. 11; Ex. 1007, 7:26–8:2. As an example of how the term “purified” may be used, Radianingtyas states “[f]or example, if a disclosed eukaryotic microorganism, for example, produces 35% DHA, this could be further ‘purified’ such that the final lipid composition was greater than 90% DHA.” Id. at 8:2–4. We are directed to no actual microbial oil in Radianingtyas, however, that was purified to have increased levels of DHA. Rather, Petitioner only proffers what Radianingtyas might say if such an oil existed or had been purified to increase levels of DHA.10” slip op. at 12
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,757,959 - Opticis Co., Ltd. v. Inneos LLCInstitutedPTAB · Feb 2, 2024 · IPR2023-01256 · APJ Terry J Owens · IPR · Institution
The Board instituted review of claims 1, 2, 6, 7, and 9 on all five §103 grounds in the petition.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority to determine whether to institute an inter partes review. 37 C.F.R. § 42.4(a) (2023). Under 35 U.S.C. § 314(a), an inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” A decision to institute under 35 U.S.C. § 314 may not institute on fewer than all claims challenged in the petition. 37 C.F.R. § 42.108(a) (implemented as a result of SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1359–60 (2018)). Upon consideration of the arguments and evidence presented by Petitioner and Patent Owner, we are persuaded that Petitioner has demonstrated a reasonable likelihood that it would prevail in showing the unpatentability of at least one challenged claim. See 35 U.S.C. § 314(a). For the reasons explained below, we institute an inter partes review of all challenged claims.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“Ground 1 is based upon obviousness, not anticipation. Patent Owner’s argument is not well taken because it does not address what fixing Kurita’s single optical fiber (40) in place.” slip op. at 13
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportPriority date, deniedInstituted
“The purpose of requiring reasonable diligence by the first to conceive the invention but second to reduce to practice is to assure that the invention was not abandoned or unreasonably delayed by the first inventor during the period after the second inventor entered the field.” Brown v. Barbacid, 436 F.3d 1376, 1379 (Fed. Cir. 2006). “A patent owner need not prove the inventor continuously exercised reasonable diligence throughout the critical period; it must show there was reasonably continuous diligence.” Perfect Surgical Techniques, Inc. v. Olympus Am., Inc., 841 F.3d 1004, 1009 (Fed. Cir. 2016). “[T]here need not necessarily be evidence of activity on every single day if a satisfactory explanation is evidenced.” Monsanto Co. v. Mycogen Plant Sci., Inc., 261 F.3d 1356, 1369 (Fed. Cir. 2001). Thus, Patent Owner must provide an explanation that is satisfactory to indicate that the relied-upon computer modeling and prior art search update show reasonably continuous diligence from November 10, 2003 to January 15, 2004. Patent Owner has provided some evidence to show diligence from November 10, 2003 to January 15, 2004, but Patent Owner has not explained why, under the facts of this case, the evidence is sufficient to establish reasonably continuous diligence for the period before Bhandarkar’s effective filing date to the date of constructive reduction to practice. We have reviewed Petitioner’s contentions as to how Bhandarkar teaches the subject matter of the claims, and we find them sufficiently persuasive at this stage. Based upon the above-discussed evidence and that the optical combiner claimed in claims 1, 2, 6, 7, and 9 would have been obvious to one of ordinary skill in the art over Bhandarkar. slip op. at 26
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“institution under 35 U.S.C. § 314(a) because the factors identified in Apple, Inc. v. Fintiv, Inc., IPR2020-00019, Paper 11 (PTAB Mar. 20, 2020) (precedential) (“Fintiv”), weigh in favor of denying institution in view of the district court litigation (Prelim. Resp. 68–69). A Memorandum from Director Vidal titled Interim Procedure for Discretionary Denials in AIA Post-Grant Proceedings with Parallel District Court Litigation (USPTO June 21, 2022) (“Interim Procedure”)2 provides that “the PTAB will not deny institution of an IPR or PGR under Fintiv . . . where a petitioner stipulates not to pursue in a parallel district court proceeding the same grounds as in the petition or any grounds that could have reasonably been raised in the petition” (Interim Procedure 9). Petitioner has submitted such a stipulation (Paper 11). Thus, we do not exercise discretion to deny institution under 35 U.S.C. § 314(a).” slip op. at 27
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites PhillipsPatents in suitUS 7,198,416 - Unified Patents, LLC v. VL Collective IP LLCSome claims unpatentablePTAB · Dec 18, 2023 · IPR2022-01086 · APJ Patrick M Boucher · IPR · Final written decision
Claims 1, 3, 5, 9, 12, 13, and 15 are unpatentable over Sonohara; claims 20 and 21 were not shown unpatentable because Sonohara’s assignment rule is based on timestamps.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner’s expert, Dr. Goodrich, proposes what Patent Owner characterizes as “a somewhat different level,” namely “an individual with at least a bachelor’s degree in Computer Science or related area and two years of experience developing software tools and/or computer systems for use in the area of audio or video creation, encoding, and/or distribution.” PO Resp. 13; Ex. 2007 ¶ 50. Although we agree that the respective articulations are “somewhat different,” they are generally similar, and our Decision does not depend on nuanced distinctions regarding the level of ordinary skill. Indeed, Dr. Goodrich describes his proposed articulation as “approximate,” such that “more work experience could compensate for less education or more education could compensate for less work experience.” Ex. 2007 ¶ 50. Because we find Petitioner’s proposal reasonable, consistent with the level of skill reflected by the prior art, and supported by Dr. Freedman’s testimony, we adopt it for this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the prior art may reflect an appropriate level of skill in the art). We nevertheless note that we would reach the same ultimate conclusion that claims 1, 3, 5, 9, 12, 13, and 15 (but not claims 20 and 21) have been shown to be unpatentable by a preponderance of the evidence were we to adopt Patent Owner’s proposal. See PO Resp. 13 (“this Response establishes that Petitioner’s arguments fail even under its preferred definition of the level of ordinary skill”).” slip op. at 12
- Claim Construction › Intrinsic evidence (Phillips canons) › Preamble limiting or notNot reached
“We need not resolve this dispute because we reach the same ultimate conclusion that Petitioner shows, by a preponderance of the evidence, that claims 1, 3, 5, 9, 12, 13, and 15 are unpatentable, but not that claims 20 and 21 are unpatentable, even if we apply Patent Owner’s proposed construction that the preambles are limiting and the first and second data files must be different. See Reply 15 (Petitioner asserting that “there is no need to construe the preambles as the prior art meets them even if construed”); Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). For purposes of this Decision, we accordingly treat the preambles of independent claims 1 and 9 as limiting, and with the recited “first data file” and “second data file” as distinct data files.4” slip op. at 14
- Claim Construction › Intrinsic evidence (Phillips canons) › Lexicography (patentee as own lexicographer)Term construed board ownDecided for patent owner
“We agree with Patent Owner’s contention that the emphasized sentence defines the term “content-related.” See PO Resp. 15–16 (Patent Owner arguing that “[t]here are thus three strong indications of lexicography: (1) ‘content-related’ is set off by quotation marks; (2) the patentee used the word ‘is’ to describe the term ‘content-related’; and (3) the patentee states what ‘content-related’ is ‘understood to mean.’” Nor does Petitioner disagree that the sentence is definitional. See Tr. 8:15–16 (referring to the “term content-related as it’s defined in the specification”). Indeed, in the Starz litigation, the district court also treated the sentence as definitional, a fact that we find significant as a matter of comity. See Ex. 1018, 111:24–112:1 (district court judge stating at Markman hearing, “I’m going to adopt . . . the express definition provided in the specification”). But like the district court, we discern insufficient reason to adopt the additional gloss that Patent Owner seeks to apply to the definition of “content-related.” That is, Patent Owner proposes that we additionally construe the phrase “syntactical meaning” within the definitional statement to arrive at Patent Owner’s proposed construction. PO Resp. 16–20. According to Patent Owner, “[t]he specification makes clear, through its use of consistent and repeated examples, that ‘syntactical meaning’ requires a specific relationship between the data segments within a data file: succeeding data segments within a data file must be ordered so as to present the content in its intended sequence when rendered.” Id. at 17 (citing VirnetX Inc. v. Cisco Sys., Inc., 767 F.3d 1308, 1317–19 (Fed. Cir. 2014); Alloc, Inc. v. ITC, 342 F.3d 1361, 1368–71 (Fed. Cir. 2003)). Patent Owner adds that the claims, the context provided by the problems solved by the ’794 patent, and the cross-examination testimony of Petitioner’s expert, Dr. Freedman, all support this additional aspect of Patent Owner’s proposed construction. Id. at 18–20. Relying on additional direct testimony by Dr. Freedman, Petitioner counters this position as “improperly import[ing] limitations from the specification that are not required by the claims” and “render[ing] other portions of claim 1 superfluous.” Reply 3 (citing Ex. 1016 ¶ 22); see Tr. 10:18–20 (Petitioner explaining at oral hearing that “the syntax information is simply just identification information which is used to find out what the order of the files is. But the identification information does not by itself indicate the order. It’s just an identifier.”). We agree with Petitioner that it would be imprudent to adopt Patent Owner’s additional gloss because, “[w]hile claims must be construed in light of the specification, . . . limitations from the specification are not to be read into the claims, . . . for ‘[i]t is the claims that measure the invention.’” Golight, Inc. v. Wal-Mart Stores, Inc., 355 F.3d 1327 (Fed. Cir. 2004) (quoting SRI Int’l v. Matsushita Elec. Corp. of Am., 775 F.2d 1107, 1121 (Fed. Cir. 1985) (other citations omitted). It is apparent that the Applicant for the ’794 patent understood how to define terminology recited in the claims, but chose to limit its definition of “content-related” in terms of the broader phrase “syntactical meaning” rather than through narrower specific reference to presentation order. In addition, claims 1 and 9 already specify “sequentially outputting the first and second data segments according to their chronological sequence,” which supports Petitioner’s observation that requiring an additional sequential order to “content-related . . . data segments” renders other portions of claim 1 superfluous. See Reply 3. We accordingly adopt the definitional construction provided by the” slip op. at 16
- Claim Construction › Intrinsic evidence (Phillips canons) › Prosecution history disclaimer / disavowalDisclaimer not foundDecided for petitioner
“As a basic principle of claim interpretation, prosecution disclaimer promotes the public notice function of the intrinsic evidence and protects the public’s reliance on definitive statements made during prosecution.” Omega Engineering, Inc. v. Raytek Corp., 334 F.3d 1314, 1323 (Fed Cir. 2003) (citing Digital Biometrics, Inc. v. Identix, Inc., 149 F.3d 1335, 1347 (Fed. Cir. 1998)) (emphasis added). As such, a statement during prosecution qualifies as a disavowal of claim scope only if it is “so clear as to show reasonable clarity and deliberateness” and “so unmistakable as to be unambiguous evidence of disclaimer.” Id. at 1325 (citations omitted). “Consequently, for prosecution disclaimer to attach, [Federal Circuit] precedent requires that the alleged disavowing actions or statements made during prosecution be both clear and unmistakable.” Id. at 1325–26. “The party seeking to invoke prosecution history disclaimer bears the burden of proving the existence of a clear and unmistakable disclaimer that would have been evident to one skilled in the art.” Mass. Inst. of Tech. v. Shire Pharms., Inc., 839 F.3d 1111, 1119 (Fed. Cir. 2016). And “[s]tatements by the patent owner are not considered in a vacuum; rather, the skilled artisan would look at the record as a whole in assessing claim scope.” Galderma Lab’s v. Amneal Pharma, 806 F. App’x 1007, 1010 (Fed. Cir. 2022) (citing Wang Labs., Inc. v. Toshiba Corp., 993 F.2d 858, 867 (Fed. Cir. 1993) (“The prosecution history must be examined as a whole in determining whether estoppel applies.”)). We have reviewed the prosecution history, which we summarize supra § I.A.3., and we have particularly reviewed those portions highlighted by Patent Owner. See PO Resp. 32–40. We reach the same conclusion as the district court in the Starz litigation that the standard for attachment of prosecution disclaimer is not met. See Ex. 1018, 109:15–22 (district court stating at Markman hearing, “I’ve also carefully reviewed the portions of the prosecution history relied on by VideoLabs, including the patentee’s arguments regarding the Shin and Rosenau references, and I’m up [sic: not6] persuaded there was a clear and unmistakable disclaimer of all assignment rules that perform assignments by using exact timing information”). slip op. at 20
Patent outcomesUS 8,605,794 mixedClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,605,794 - Intel Corporation v. Besang Inc.InstitutedPTAB · Dec 13, 2023 · IPR2023-00991 · APJ Jon B Tornquist · IPR · Institution
The Board instituted review of claims 1 and 13–17 on all petition grounds, finding a reasonable likelihood of success on at least one challenge to claim 13 based on combinations involving Lee or Johnson.
RulingsInstitution decision- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownOther
“stackable add-on layer” requires something more than just any type of layer that is directly or indirectly adhered to the substrate or dielectric layer. First, the plain language of the claim does not require merely a “layer” having a plurality of vertically oriented semiconductor memory cells, but rather “a stackable add-on layer.” Ex. 1001, 12:29–32. Second, the written description of the ’702 patent strongly suggests that a “stackable add-on layer” is formed separately from the substrate and then stacked on and bonded to the substrate or a dielectric layer above the that in the invention “a plurality of vertically oriented semiconductor memory devices, or cells, may be added to a separately fabricated substrate that includes electrical devices and/or interconnect lines.” Id. at 1:47–50 (emphasis added). Likewise, the specification explains that an SOI layer refers to “a relatively thin, single crystal portion of a semiconductor wafer that can be cleaved and bonded to another previously fabricated wafer, or similar type of substrate.” Id. at 4:47–51. “In this context,” the ’702 patent explains, “the SOI layer may be thought of as an attachment layer, or stackable add-on structure which is suitable for bonding to a semiconductor substrate already containing devices and/or interconnections.” Id. at 4:53– 57. Again, this suggests that a “stackable add-on layer” is separately formed and then bonded to a previously fabricated substrate. Given the structure of the claims and the description of the invention in the written description of the ’702 patent, we preliminarily construe “stackable add-on layer” to be a layer that is formed separately from the substrate and then bonded to the substrate or a dielectric layer above the substrate. We do not understand a “stackable add-on layer” to include memory cells that are formed by sequential deposition on or above a substrate or dielectric layer without being added to a separately formed substrate. slip op. at 8
- Claim Construction › Intrinsic evidence (Phillips canons) › Specification disavowal / 'present invention' languageTerm construed board ownOther
“Independent claims 1 and 13 do not specify how the stackable add-on layer is bonded to the dielectric layer. Nor does Petitioner assert that the plain and ordinary meaning of “bonding” refers to “wafer bonding.” Thus, to limit the claims to wafer bonding, Petitioner must identify a clear expression of intent in the ’702 patent to define “bonding” as “wafer bonding,” or a clear disavowal of claim scope demonstrating that non-wafer bonding methods are outside the reach of the claims. See Thorner v. Sony Comp. Entm’t Am. LLC, 669 F.3d 1362, 1365 (Fed. Cir. 2012). Petitioner does not contend that the patentee acted as its own lexicographer by defining “bonding” as “wafer bonding,” a term that does not even appear in the ’702 patent. Id. at 1365. Nor are we directed to any clear disavowal indicating that methods of bonding other than “wafer bonding” are outside the scope of the claims. Id. at 1366. Thus, we decline to construe “bonded” in claims 1 8 Wafer bonding is a method in which semiconductor layers are formed on separate wafers and then bonded together to create a stacked semiconductor structure. Ex. 1003 ¶ 41. that the standards for lexicography and disavowal are “exacting”). As noted by Petitioner, the ’702 patent describes an SOI layer that is wafer bonded to a previously fabricated substrate. Ex. 1001, 4:47–53. Independent claims 1 and 13, however, do not require an SOI layer, and the disclosure of a single embodiment in which wafer bonding is used is not sufficient to import such a limitation into the claims. See Deere & Co. v. Bush Hog, LLC, 703 F.3d 1349, 1354 (Fed. Cir. 2012) (“While claim terms are understood in light of the specification, a claim construction must not import limitations from the specification into the claims.”); Computer Docking Station Corp. v. Dell, Inc., 519 F.3d 1366, 1374 (Fed. Cir. 2008) (“Nonetheless, this court will not countenance the importation of claim limitations from a few specification statements or figures into the claims.”). In summary, we preliminarily construe “stackable add-on layer . . . the first stackable add-on layer is/being bonded” to require a separate layer that is formed apart from the substrate and then subsequently bonded to the substrate or a dielectric layer above the substrate.9 We do not construe independent claims 1 or 13 to require any particular form or method of bonding.10” slip op. at 10
- PTAB / AIA Trials › Discretionary denial › General Plastic (serial petitions)Decided for petitioner
“The evidence of record demonstrates that Petitioner and Micron jointly developed the 3D NAND technology that is generally at issue in the district court litigation, and the parties have acknowledged “their long-term joint development partnership” for this technology. Ex. 1013 (district court complaint); Ex. 2010 (“Micron and Intel Extend their Leadership in 3D NAND Flash memory.”); Ex. 2016 (discussing the end of Intel’s and Micron’s NAND partnership). There is no assertion, however, that all 3D NAND technology infringes the challenged claims of the ’702 patent, and Micron and Intel are not accused of infringing the ’702 patent based on the same products and are not co-defendants in any district court litigation. Further, Patent Owner presents no persuasive evidence that the two parties collaborated on the development of either of the accused products, as opposed to general 3D NAND technology, and Petitioner represents that the two parties filed their petitions independently and without coordination or cooperation. Prelim. Reply 1–2; Ex. 2016, 1 (noting that each company sought to independently develop 3D NAND technology in order to “forge” their own path for future NAND development and “better optimize the technology and products for their individual business needs”). relationship between Petitioner and Micron, and Petitioner is not the same petitioner as the petitioner in IPR2023-00900. Thus, General Plastic factor 1 weighs against discretionary denial.” slip op. at 14
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“The stipulation filed in the Texas litigation mitigates, to an extent, concerns of potentially conflicting decisions and duplicative efforts between the district court and the PTAB.12 Director’s Memo at 7. Similarly, Petitioner’s stipulation in the Oregon litigation (i.e., that it will not pursue an invalidity defense that the claims challenged in this IPR proceeding are invalid based on grounds that were raised or reasonably could have been raised during the IPR) also mitigates concerns of potentially conflicting decisions and duplicative efforts. Patent Owner contends Petitioner’s stipulation falls short of a Sotera stipulation by carving out any circumstance that “otherwise terminate[s] the instituted IPR.” Prelim. Sur-reply 2–3. Patent Owner interprets this carve- on the patent application publication of the Lee patent. Ex. 1007. Because the disclosures of the Lee patent and patent application publication are substantively identical, we consider the stipulation not to pursue any obviousness ground based on Lee to apply with equal force to Lee’s patent application publication. 12 The stipulation in the Texas litigation bars the defendant from pursuing “any obviousness ground that includes” Lee or Watanabe. IPR2023-00900, Exhibit 1031. Here, Petitioner’s grounds 1A–1F challenge claims 13–17 based in whole or in part on Lee, and grounds 2A–2C and 3 challenge claims 1 and 13 based on combinations of references that do not include Lee or Watanabe. Pet. 3. As such, the grounds to be resolved by the PTAB will differ somewhat from those presented in the Texas litigation. written decision, thereby rendering the stipulation an “empty promise” as the district court in the Texas litigation will undoubtedly resolve validity before a final written decision in this case. Id. at 3. We disagree. We do not understand Petitioner’s stipulation to require that a final written decision be issued before the stipulation takes effect. Rather, so long as an inter partes review is instituted, and until such time as the IPR is terminated or vacated, Petitioner will not pursue any invalidity defense before the district court that is “based on grounds that were raised or could have been raised during the IPR.” Ex. 1034. In summary, given the stipulations filed by the petitioners in the Oregon and Texas litigations, it appears that there will be minimal, if any, overlap between the issues raised in the petitions and in the parallel district court proceedings. Accordingly, Fintiv factor 4 weighs against discretionary denial.” slip op. at 21
Claim construction§ 103 obviousnessDiscretionary denialPatents in suitUS 7,378,702 - Samsung Electronics Co., Ltd. / Micron Technology, Inc. et al. v. Netlist, Inc.All claims unpatentablePTAB · Dec 5, 2023 · IPR2023-00405 · APJ Jon M Jurgovan · IPR · Final written decision
Claims 1–30 are unpatentable as obvious over Harris, the FBDIMM Standards, and Amidi; the Board did not reach the Spiers grounds.
RulingsFinal written decision- Expert testimonyPetitioner expert creditedOther
“the combination of Harris and FBDIMM Standards and relies on the Declaration of Dr. Andrew Wolfe (Ex. 1003) in support. Pet. 14–40. For the reasons that follow, we are persuaded that the evidence, including Dr. Wolfe’s testimony, supports Petitioner’s showing and establishes by a preponderance of the evidence that these claims are unpatentable.” slip op. at 17
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner asserts a person of ordinary skill in the art “would have had an advanced degree in electrical or computer engineering, or a related field, and two years working or studying in the field of design or development of memory systems, or a bachelor’s degree in such engineering disciplines and at least three years working in the field.” Pet. 7–8 (citing Ex. 1003 ¶ 61). Petitioner contends that additional training can substitute for educational or research experience, and vice versa. Id. at 8. Petitioner asserts that such a hypothetical person would have been familiar with the JEDEC industry standards, and knowledgeable about the design and operation of standardized DRAM and SDRAM memory devices and memory modules and how they interacted with a memory controller and other parts of a computer system, including standard communication busses and protocols, such as PCI and SMBus busses and protocols. Id. Petitioner further contends that such “a hypothetical person would also have been familiar with the structure and operation of circuitry used to access and control computer memories, including sophisticated circuits such as ASICs, FPGAs, and CPLDs, and more low-level circuits such as tri-state buffers.” Id. Petitioner further asserts that such “a hypothetical person would further have been familiar with voltage supply requirements of such structures (e.g., memory modules, memory devices, memory controller, and associated access and control circuitry), including voltage conversion and voltage regulation circuitry.” Id. Patent Owner indicates “[f]or the purposes of this [Response], Patent Owner is applying the level of ordinary skill in the art proposed by Petitioner.” Resp. 2. The evidence that Petitioner presents mostly applies to the educational level and experience of workers in the field, but also touches upon other factors as well, including problems and solutions in the prior art and complexity of the technology. See Pet. 7–8. We find Petitioner’s proposal is consistent with the level of skill in the art reflected by the ’054 patent and the prior art of record, and, therefore, we adopt Petitioner’s proposed level of ordinary skill in the art, with the exception of the open-ended language “at least,” which introduces ambiguity and may encompass skill levels beyond ordinary.” slip op. at 11
- Claim Construction › Intrinsic evidence (Phillips canons) › Preamble limiting or notPreamble limitingDecided for patent owner
“The District Court’s Claim Construction Order (Ex. 2032) issued after our Institution Decision (Paper 11). Although Petitioner argued in the District Court litigation that the claim preambles were not limiting, Petitioner does not appear to maintain that argument here following the District Court’s determination that the preambles are limiting. Ex. 2032, 35. Since the term is recited in both the preambles and bodies of these claims, there is evidence that the inventors of the ’054 patent intended the term to limit the claim, as the District Court determined. See Catalina Mktg. Int’l., Inc. v. Coolsavings,com, Inc., 289 F.3d 801, 808 (Fed. Cir. 2002) (citing Bell Commc’ns Rsch., Inc. v. Vitalink Communications Corp., 55 F.3d 615, 620 (Fed. Cir. 1995) (“dependence on a particular disputed preamble phrase for antecedent basis may limit claim scope because it indicates a reliance on both the preamble and claim body to define the claimed invention.”)).” slip op. at 16
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for patent owner
“We agree with Petitioner’s contention that “memory module” is not limited to “main memory modules . . . designed to connect to the primary memory controller.” See Reply 2. The ’054 patent states In certain embodiments, the device contains a high density Flash memory with a low density DRAM, wherein the DRAM is used as a data buffer for read/write operation. The Flash serves as the main memory. Ex. 1001, 11:3–6 (emphases added). This is the only mention of “main memory” in the ’054 patent. That the Flash memory serves as “main memory” in “certain embodiments” implies that there may be other embodiments in which this is not the case. Accordingly, we agree with Petitioner that the term “memory module” is not limited to “main memory modules . . . designed to connect to the primary memory controller.” We agree with Patent Owner that the “memory module” includes structure to connect with a “host system” including its memory controller. See, e.g., Ex. 1001, code (57), 12:52–59. The claims do not mention a “memory controller,” but they do mention that the “memory module” has an “interface” to connect with a “host system.” Ex. 1001, 38:20–25 (claim 1), 39:63–65 (claim 16), 41:6–8 (claim 24). That the “memory module” has structure for connecting to the host system’s memory controller may thus be implied from the claims. We agree with Petitioner that the District Court’s determination was that the preambles (presumably of claims 1, 4, 6, 11, 16 and 25) are limiting. Ex. 2032, 35. To the extent that the District Court’s determination construed “memory module” to include structure necessary to connect to a memory controller, our construction of “memory module” is consistent.” slip op. at 16
Patent outcomesUS 11,232,054 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,232,054
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.