• Juniper Networks, Inc. / Ruckus Wireless, Inc. et al. v. Chrimar Systems, Inc.All claims unpatentable
  PTAB · Dec 29, 2017 · IPR2016-01397 · APJ Robert J Weinschenk · IPR · Final written decision

  Claims 1, 2, 7, 26, 29, 38, 39, 40, 47, 55, and 69 are unpatentable as obvious over the asserted prior art combinations.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “Patent Owner indicates that the only difference between the parties’ respective definitions of the level of ordinary skill in the art is that Petitioner uses the phrase “at least.” PO Resp. 10. According to Patent Owner, the phrase “at least” is “too open ended” and “would result in an expert, who has a Ph.D. and 15 years of experience, being considered an ordinary artisan.” Id. Patent Owner, however, does not identify any specific instance in which the difference between the parties’ respective definitions of the level of ordinary skill in the art impacts the analysis or conclusions of either party, or either party’s declarant, in this case. See id. Our findings and conclusions in this case would be the same under either party’s definition of the level of ordinary skill in the art. To the extent necessary, though, we adopt Patent Owner’s definition, which is supported by the declaration of Dr. Vijay K. Madisetti. Id.; Ex. 2038 ¶ 26. As such, we determine that a person of ordinary skill in the art would have had a B.S. degree (or equivalent) in electrical engineering or computer science and three years of experience in the design of network communications products, and would have been familiar with data communications protocols, data communications standards (and standards under development at the time, including the 802.3 standard), and the behavior of data communications products available on the market.” slip op. at 6

  • Prior constructionPrior construction adoptedDecided for petitioner

    “second pairs of contacts used to carry BaseT Ethernet communication signals.” Ex. 1001, 17:14–16. In a decision on institution in IPR2016- 01391, we construed the term “BaseT” in a related patent to mean “twisted pair Ethernet in accordance with the 10BASE-T or 100BASE-T standards.” Juniper Networks, Inc. v. Chrimar Systems, Inc., Case IPR2016-01391, slip op. at 11–12 (PTAB Dec. 22, 2016) (Paper 9). Our construction is consistent with Petitioner’s proposal that the term “BaseT” be construed to mean “10BASE-T and 100BASE-T.” Pet. 5. Our construction also is consistent with the construction adopted by the United States District Court for the Eastern District of Texas in a related case. Ex. 2021, 18. Further, Patent Owner “does not contest” our construction. PO Resp. 12. We note that our findings and conclusions in this case are not dependent on a particular construction of the term “BaseT.” Nonetheless, because neither party disputes our prior construction of that term, we adopt it in this case. Specifically, we construe the term “BaseT” in claim 1 to mean “twisted pair Ethernet in accordance with the 10Base-T or 100Base-T standards.”” slip op. at 7

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner

    “We agree with Petitioner that Patent Owner’s proposed construction is not the broadest reasonable interpretation. First, Patent Owner does not direct us to any intrinsic evidence to support its proposed construction, but instead relies on a single piece of extrinsic evidence. PO Resp. 12–13. Specifically, Patent Owner cites to a document that discusses the term “protocol” in the context of explaining how “networks that make up the Internet” communicate with one another. Ex. 2047, 1. That, however, is not the context in which the term “protocol” is used in the ’838 patent. For example, the ’838 patent relates to tracking electronic equipment in an Ethernet network. Ex. 1001, 1:27–30, 17:13–23. As a result, we are not persuaded that the extrinsic evidence cited by Patent Owner establishes the meaning of the term “protocol” in the context of the ’838 patent. Second, Patent Owner’s proposed construction addresses the term “protocol” in isolation from the remainder of the claim language. By limiting the term “protocol” to a mutually agreed upon method of communication, Patent Owner’s proposed construction appears to require a communication protocol. Claim 2, though, recites a detection protocol, not a communication protocol. Id. at 17:24–26. Claim 2 further specifies that the detection protocol is based on different magnitudes of DC current flow detected by the central piece of network equipment via Ethernet contacts. Id. at 17:13–26. Patent Owner does not explain specifically why the central piece of network equipment must mutually agree upon a method of communication with other network equipment in order to detect different magnitudes of DC current flow. See PO Resp. 12–13; Pet. Reply 26–27. Third, the specification of the ’838 patent indicates that the detection protocol does not require a mutually agreed upon method of communication. For example, the ’838 patent describes one embodiment as follows: The existence of a connection between hub 1 and central module 15a is monitored by test voltage source 64 and test voltage monitor 66 through a pair of receive data lines. Current from test voltage source 64 flows through a data line to an isolation transformer within hub 1. The current flows through the primary winding of the isolation transformer and returns on the other receive data line to the test voltage monitor 66. An interruption in the flow of current is detected by the test voltage monitor 66. . . . Similarly, current sourced onto a transmit line from signal modulator 7 and isolation power supply 8 through remote module 16a to the isolation transformer of PC 3A which returns on the other transmit line is monitored by test voltage monitor 84” slip op. at 8

  • Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner

    “phantom power circuit would have degraded the Ethernet data signal is not persuasive. Patent Owner’s declarant, Dr. Madisetti, states that “[s]witching the resistor would create noise that would degrade the Ethernet data propagation and reduce bandwidth,” but does not otherwise explain or provide support for that statement. Ex. 2038 ¶ 86. In contrast, Petitioner’s declarant, Mr. Crayford, explains that the resistor in Bloch would have produced low frequency signals, which would have been unlikely to interfere with the higher frequency data signals of an Ethernet network. Pet. Reply 11; Ex. 1046 ¶¶ 49–51. Mr. Crayford also explains that even if the resistor in Bloch would have caused some interference with the Ethernet data signals, it would have been within the knowledge and capabilities of a person of ordinary skill in the art to separate the low frequency resistor signals from the high frequency Ethernet data signals, such as by using a filter. Pet. Reply 11; Ex. 1046 ¶ 49; Ex. 2039, 172:20–173:3. Patent Owner’s argument that applying operating power to the transformers in Bloch would saturate the coils also is not persuasive. Patent Owner’s argument is premised on annotations that Petitioner added to Figure 1 of Bloch in the Petition. PO Resp. 27 (citing Pet. 44). Specifically, Petitioner added a red line to Figure 1 of Bloch to indicate the flow of DC current through the system, but, as Patent Owner points out, the red line only shows current flowing through one side of the transformer. Pet. 44; PO Resp. 27. Petitioner’s declarant, Mr. Crayford, clarified during his deposition that the annotations to Figure 1 were intended to illustrate the direction of current flow, and that, even if not shown expressly by the annotations, the current clearly flows through both sides of the transformer. Ex. 2039, 167:14–169:22. Specifically, Mr. Crayford stated that “I did not choose to highlight both of the pairs of the twisted pair which is the current path, but clearly they’re parallel connectors connected to the same transformers with the power and return path on the center tap,” so “they probably should be highlighted.” Id. at 167:23–168:4. Thus, contrary to Patent Owner’s argument, Petitioner does not propose applying operating power to just one side of the transformers in Bloch. Further, we are not persuaded by Patent Owner’s argument that, even if operating power was applied to both sides of the transformer in Bloch, there would still be a saturation problem. Bloch teaches that the phantom power circuit “is connected to the two center taps of the transformers,” thereby indicating that applying operating power to the center taps of the transfomers would work. Ex. 1005, 3:9–23. Further, consistent with the teaching of Bloch, Mr. Crayford explained that the objective of balancing the coils on either side of the transformer is “very well known.” Ex. 2039, 169:14–22.” slip op. at 48

  Patent outcomesUS 9,019,838 unpatentable
  Claim construction§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 9,019,838
• DTS, Inc. / Phorus, Inc. v. Avago Technologies General IP (Singapore) Pte. Ltd.Other
  PTAB · Dec 26, 2017 · IPR2017-02201 · APJ Daniel J Galligan · IPR · Order

  The Board dismissed the petition and terminated the proceeding as to all parties because the parties had settled their dispute.

  RulingsOther

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Other

    “and 37 C.F.R. § 42.72, these sections relate, respectively, to termination of “[a]n inter partes review instituted under this chapter” and to termination of “trial,” which “means a contested case instituted by the Board based upon a petition.” 35 U.S.C. § 317; 37 C.F.R. §§ 42.2, 42.72. This proceeding is in the preliminary stage, and no decision whether to institute a trial has been made. As such, we treat the parties’ request as seeking dismissal of the Petition to thereby terminate the proceeding.” slip op. at 2

  • PTAB / AIA Trials › Other PTAB motions (exclude, strike, seal, additional discovery, rehearing)Granted

    “U.S. Patent No. 6,684,060 B1. Mot. 3–4. The parties represent that “there are no other agreements or understandings, oral or written, between DTS and Avago, including any collateral agreements, made in connection with, or in contemplation of, the termination of the present proceeding.” Mot. 3. Under these circumstances, we determine that it is appropriate to dismiss the Petition (Paper 1) and terminate this proceeding. See 37 C.F.R. §§ 42.71(a), 42.74(a). We also determine that it is appropriate to treat the Agreements as business confidential information to be kept separate from the patent file. See 37 C.F.R. § 42.74(c).” slip op. at 2

  None
  Patents in suitUS 6,684,060
• Apple Inc. v. Saint Lawrence Communications, LLCRehearing denied
  PTAB · Dec 26, 2017 · IPR2017-01244 · APJ Daniel N Fishman · IPR · Rehearing

  The Board denied Apple’s rehearing request, leaving in place the denial of institution because Petitioner did not show a reasonable likelihood of proving claims 1–21 and 29–42 unpatentable.

  RulingsRehearing decision

  • RehearingRehearing, deniedDenied

    “review the decision for an “abuse of discretion.” 37 C.F.R. § 42.71(c). “The burden of showing a decision should be modified lies with the party challenging the decision,” and, “[t]he request must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed” in the record. 37 C.F.R. § 42.71(d). A request for rehearing is not an opportunity to present new arguments. See id. An abuse of discretion may arise if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors. Star Fruits S.N.C. v. U.S., 393 F.3d 1277, 1281 (Fed. Cir. 2005); Arnold P’ship v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004); In re Gartside, 203 F.3d 1305, 1315–16 (Fed. Cir. 2000).” slip op. at 2

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “We discern no teaching or suggestion in this text of Salami that the preemphasized signal is used on a perceptual weighting filter. We find no support in the cited portions of Salami for Petitioner’s assertion that the preemphasized signal is first applied to LP analysis and then the same preemphasized signal is perceptually weighted (i.e., applied to a perceptually weighted filter). Petitioner’s argument in the Petition does not explain specifically how the cited text teaches the identified claim limitations and, thus, amounts to little more than an unsupported conclusory remark. Dr. Cohen merely repeats the same argument without providing any further explanation.” slip op. at 4

  • Expert testimonyPetitioner expert discountedDecided for patent owner

    “We discern no teaching or suggestion in this text of Salami that the preemphasized signal is used on a perceptual weighting filter. We find no support in the cited portions of Salami for Petitioner’s assertion that the preemphasized signal is first applied to LP analysis and then the same preemphasized signal is perceptually weighted (i.e., applied to a perceptually weighted filter). Petitioner’s argument in the Petition does not explain specifically how the cited text teaches the identified claim limitations and, thus, amounts to little more than an unsupported conclusory remark. Dr. Cohen merely repeats the same argument without providing any further explanation.” slip op. at 4

  None
  Patents in suitUS 6,807,524
• Semiconductor Components Industries, LLC (D/B/A On Semiconductor) v. Power Integrations, Inc.Rehearing denied
  PTAB · Dec 21, 2017 · IPR2016-00995 · APJ Daniel N Fishman · IPR · Rehearing

  The Board denied Patent Owner’s rehearing request, leaving claims 26 and 27 unpatentable as anticipated by MC33362.

  RulingsRehearing decision

  • RehearingRehearing, deniedDenied

    “review the decision for an “abuse of discretion.” 37 C.F.R. § 42.71(c). “The burden of showing a decision should be modified lies with the party challenging the decision,” and “[t]he request must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed” in the record. 37 C.F.R. § 42.71(d). A request for rehearing is not an opportunity to present new arguments. See id. An abuse of discretion may arise if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors. Star Fruits S.N.C. v. United States, 393 F.3d 1277, 1281 (Fed. Cir. 2005); Arnold P’ship v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004); In re Gartside, 203 F.3d 1305, 1315–16 (Fed. Cir. 2000).” slip op. at 2

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for petitioner

    “arguments. Our claim construction made clear in interpreting “multi-function circuit” that we agree with Patent Owner that the circuit is separate and distinct from the recited “control circuit” in the sense that the claim recites two distinct elements. Dec. 18. However, our interpretation further determined that although we agree “that the multi-function circuit and the control circuit are separate and distinct components in the claims, the claim language does not require that the functions performed by the two distinct circuits must be similarly separate and distinct.” Id. at 22. We further observed that, contrary to Patent Owner’s assertions, the Specification of the ’908 patent mentions certain functions of the multi-function circuit that are clearly tightly coupled to the “core regulation” function of the recited “control circuit.” Id. at 24–25 (e.g., shutting down the power supply in response to detecting over-voltage or under-voltage conditions). Thus, our Decision is consistent with our interpretation of “multi-function circuit” and expressly disagrees with Patent Owner’s arguments that the functions of the two circuits must also be separate and distinct.” slip op. at 3

  Claim construction
  Patents in suitUS 6,538,908
• Hengdian Group Dmegc Magnetics Co., Ltd. / Zhejiang Innuovo Magnetics Co., Ltd. et al. v. Hitachi Metals, Ltd.Rehearing denied
  PTAB · Dec 21, 2017 · IPR2017-01313 · APJ Jo-Anne M Kokoski · IPR · Rehearing

  The Board denied Petitioner’s rehearing request and left in place its § 325(d) denial of institution for claims 1–8 because materially the same prior art had been considered by the Office.

  RulingsRehearing decision

  • RehearingRehearing, deniedDenied

    “II. ANALYSIS A request for rehearing must identify specifically all matters the party believes we misapprehended or overlooked, and the place where each matter was addressed previously in a motion, an opposition, or a reply. 37 C.F.R. § 42.71(d). Additionally, Petitioner, as the party challenging the Decision, has the burden of showing it should be modified. Id. When rehearing a decision on a petition, the Board will review the decision for an abuse of discretion. See 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold P’ship v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re Gartside, 203 F.3d 1305, 1315–16 (Fed. Cir. 2000)).” slip op. at 3

  • PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsInstitution denied 325dDecided for patent owner

    “As an initial matter, we note that Petitioner states that, for purposes of its Request, it “do[es] not argue Uchida and Uchida II are not materially the same.” Req. Reh’g 3. Because we have discretion to reject a petition if “the same or substantially the same prior art or arguments previously were presented to the Office,” see 35 U.S.C. § 325(d) (emphasis added), Petitioner has not established that we abused our discretion in denying the Petition. Given that Uchida (asserted here) and Uchida II (previously presented to the Office) are “materially the same,” substantially the same prior art was previously before the Office. Indeed, the presence of Uchida in the Petition and the materially-identical Uchida II in the prosecution history alone is a sufficient basis to exercise our discretion under Section 325(d).” slip op. at 3

  Discretionary denial
  Patents in suitUS 6,527,874
• SAP America, Inc. v. Lakshmi ArunachalamAll claims unpatentable
  PTAB · Dec 21, 2017 · CBM2016-00081 · APJ Kevin F Turner · CBM · Final written decision

  Claims 20 and 21 are unpatentable under § 101 and § 103; the motion to amend proposing claims 22–49 is denied.

  RulingsFinal written decision

  • Skill levelSkill level board ownDecided for petitioner

    “Petitioner argues that “[b]ased on the technologies disclosed in the ’506 patent, one of ordinary skill in the art at the time of the alleged invention would have had the equivalent of a Bachelor’s degree or higher in computer science or computer engineering, as well as at least 3–5 years of academic or industry experience in the relevant field.” Pet. 10 (citing Ex. 1002 ¶ 22). Although Patent Owner does not address the level of ordinary skill in its Patent Owner’s Response, Patent Owner does opine about the same in its Motion to Amend. Therein, Patent Owner argues that: a person of ordinary skill in the art in 1995 would have been a person who had a degree in computer science, or the equivalent of that degree, and some substantive experience with Web technologies then being developed and considered by persons then working on internet systems. [Ex. 2006, 23] It would have been very rare to find anyone to have had a computer degree and as much as three to five years of experience in the area of Web technology as of November 1995. (Id.) Mot. Amend 5–6. Based on the positions of Petitioner and Patent Owner, we find mostly agreement as to the level of skill of such ordinarily skilled artisans and we are persuaded that one of ordinary skill in the art at the time of the invention would have had the equivalent of a degree in computer science or computer engineering, as well as some substantive experience 29 with Web technologies then being developed and considered by persons then working on Internet systems. This level of skill is considered and applied in the grounds below.” slip op. at 29

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed petitioner constructionNo construction neededOther

    “networked object,” and that we “willfully left out ‘Individual’ and only construed ‘Network Object.’” PO Resp. 36. Patent Owner is correct that we did not construe “individual networked object.” The reason is that it is not a term recited in the challenged claims, nor claim 14, from which the challenged claims depend. We construed “networked object,” i.e., without “individual,” because it is a term recited in the claims. Patent Owner also argues that the proper construction of “networked object” is “the information entries and attributes in a DOLSIB [distributed on-line service information base].” Id. (citing Ex. 1001, 8:50–54). We do not agree. Although the specification of the ’506 Patent details that “[t]he networked object identity 11 identifies the information entries and attributes in the DOLSIB as individual networked objects,” that is not a definition of “network objects.” We continue to find that the broadest reasonable construction, in view of the specification, of “networked object” is “an object that operates within a network or transmitted over a network.” We are not persuaded that “individual networked object” need be construed because it is not a claim term, and we are not persuaded that every recitation of “networked object” must refer to an “individual networked object.” Patent Owner argues that we did not construe the claim term “attributes,” which should be understood as “characteristics of an object.” Id. at 36–37 (citing Ex. 1001, 4:45–58, 23:19–25). Petitioner counters that the passages cited by Patent Owner do not support the proffered definition, because those passages do not contain the word “attribute.” Pet. Reply 4. Although Patent Owner’s construction is not unreasonable, claim 14 already recites that the step of “associating an object identity with information entries and attributes,” so that “attributes” need not be referred to as “characteristics of an object,” since such an association is already directly recited in the claims. As such, we are not persuaded that the claim term “attributes” needs explicit construction. Similarly, Patent Owner argues that “information entries” should be construed as “values of the characteristics of an object.” PO Resp. 37 (citing Ex. 1001, 4:45–58, 23:19–25). Again, we find it unnecessary to tie “information entries” to an object, since the association is already provided 12 in claim 14. Therefore, we are not persuaded that the claim term “information entries” needs explicit construction. With respect to the claim term “virtual information store,” we construed that term as “an information store in which information entries and attributes are associated with a networked object identity,” as discussed above. Patent Owner argues that we have not given proper effect to the word “virtual,” arguing that the proper construction is “a transient information store that is temporarily created and which contains information entries and attributes associated with a networked object identity.” PO Resp. 39–41. Patent Owner cites to the specification of the ’506 Patent (Ex. 1001, 3:1–5, 8:47–54), and “[t]he IBM Computer Dictionary” (id.), but, as Petitioner points out, Patent Owner has not “submitted this dictionary as an exhibit or provided any further information to locate the dictionary.” Further, the sections of the ’506 Patent cited by Patent Owner are not explicit about the store being “transient” or “temporarily created;” this is an inference drawn by Patent Owner. See PO Resp. 40. The introduction of the terms “transient” and “temporarily” to the construction adds more ambiguity to the claim term because the specification of the ’506 Patent does not discuss how long any “virtual information store” would be stored or maintained. In addition, we are not persuaded that Patent Owner’s provision of affirmatively containing the information entries and attributes is necessary because having a store in which the information entries and attributes are associated with a networked object identity would have been understood by ordinarily skilled artisans as being a store containing those elements. 13 Therefore, we are not persuaded that the claim term “virtual information store” requires a different construction and we maintain the construction provided in the Institution Decision, which is reproduced above.” slip op. at 11

  • BurdenUnpatentable

    “not have been obvious to make any changes to Lawlor’s system,” and that “the whole purpose of Lawlor is to establish a system built upon an existing software and infrastructure that would require no changes.” PO Resp. 80–81 (emphasis in original). We do not agree. We agree with Petitioner that Patent Owner misinterprets Lawlor’s teachings, “improperly concluding that Lawlor teaches away from any combination or modification.” Pet. Reply 24 (emphasis in original). Lawlor explains that “[b]ecause the central computer interacts with the user's bank as a standard POS or ATM network node, no significant software changes are required at the banks’ computers,” demonstrating that Lawlor makes use of a standard ATM network and existing external systems without significant modification. Ex. 1004, Abstr. As explained by Dr. Sirbu, incorporation of techniques described in CORBA into Lawlor’s system would not require modification to the external systems of Lawlor or additional processing at the central computer of Lawlor. Ex. 1002 ¶ 72. Lawlor system does not restrict or disparage modification, and Patent Owner has not pointed out any portion that purportedly restricts or disparages modification. Patent Owner also argues that Lawlor does not disclose “an OSI Layer 7 application layer switch as is the VAN Switch in FIG. 5B.” PO Resp. 79. As discussed above, however, challenged claims 20 and 21 do not recite a VAN switch, and the only consideration of such a switch comes from Patent Owner’s claims constructions that we do not adopt. As such, we are persuaded that Petitioner has shown by a 45 preponderance of the evidence that claim 20 is unpatentable over the combination of Lawlor and CORBA, and that the subject matter of claim 21 is unpatentable over the combination of Lawlor, CORBA and Billings.” slip op. at 45

  • PTAB / AIA Trials › Motions to amend / substitute claimsMotion to amend, deniedDenied

    “2. 37 C.F.R. § 42.221(a)(2)(i) Rule 221(a)(2)(i) requires that the amendments in a motion to amend must respond to a ground of unpatentability involved in the trial. Patent Owner’s new claims do not respond to any ground of unpatentability in the trial. Those grounds are based on 35 U.S.C. §§ 101, 103 and directed at claims 20 and 21. Pet. 28–73. Both claims 20 and 21 depend on claim 14 and the grounds of unpatentability consider all of the elements of claim 14. Thus, for example, new claim 25, which recites “[t]he apparatus of claim 14, wherein the user device is a multi-media device,” does not purport to demonstrate that such a claim brings the subject matter into the scope of § 101, nor that such a multi-media device would not be obvious over Lawlor, CORBA, and Billings. See Mot. Amend 9–17. Patent Owner’s analysis addresses claims 22–49 as a group and does not address all of the elements of the new claims. Id. Patent Owner also fails to indicate if any of the new claims include any feature of the challenged claims. For at least these reasons, we find that Patent Owner has not complied with the substantive requirements of 37 C.F.R. § 42.221(a)(2)(i). 3. 37 C.F.R. § 42.221(a)(2)(ii) and 35 U.S.C. § 326(d)(3) Rule 221(a)(2)(i) requires that the amendment may not seek to enlarge the scope of the claims of the patent. We also note that this rule is fully supported by 35 U.S.C. § 326(d)(3), which details that “[a]n amendment under this subsection may not enlarge the scope of the claims of the patent.” Patent Owner appears to take this rule as merely requiring that “the new claims do not enlarge the scope of any of the old claims.” Mot. Amend 3. 52 The “old claims,” however, are the only two claims existing in the ’506 Patent, namely claims 20 and 21. They are the “scope of the claims of the patent,” and the scope cannot refer to any claim that might have existed during the prosecution of the ’506 Patent. See Arlington Industries, Inc. v. Bridgeport Fittings, Inc., 345 F.3d 1318, 1329–30 (Fed. Cir. 2003). Therefore, we look to the scope of claims 20 and 21 to determine the scope of the claims of a patent. Proposed new claims in the Motion to Amend improperly enlarge the scope of claims 20 and 21. For example, new claim 27 recites “[t]he apparatus of claim 14, wherein the service is configurable specific to the context of a Web merchant.” This proposed claim is broader, in at least one aspect, than claims 20 and 21, which also depend from claim 14, because it contains none of the elements of claims 20 and 21, although it adds an additional element, i.e., “the service is configurable specific to the context of a Web merchant.” For at least these reasons, we find that Patent Owner has not complied with the substantive requirements of 37 C.F.R. § 42.221(a)(2)(ii) or 35 U.S.C. § 326(d)(3). 4. § 42.221(a)(3) and 35 U.S.C. § 326(d)(1)(B) Section (a)(3) of Rule 221 discusses that a patent owner must propose a reasonable number of substitute claims, and goes on to discuss that “[t]he presumption is that only one substitute claim would be needed to replace each challenged claim, and it may be rebutted by a demonstration of need.” The claims subject to the instant proceeding are claims 20 and 21, such that the normal presumption would be for the inclusion of two substitute claims. 53 Patent Owner does not address why the proposed 28 claims are a reasonable number of substitutes for the 2 challenged claims, so Patent Owner cannot be said to have rebutted the one for one presumption by any demonstration of need. We also note that this rule is fully supported by 35 U.S.C. § 326(d)(1)(B), which details that for the amendment of a patent, for each challenged claim, “a reasonable number of substitute claims” must be proposed. Petitioner points out that the meaning of “reasonable number of substitute claims” has been previously addressed by the Board, providing “in the absence of special circumstance, a challenged claim can be replaced by only one claim, and a motion to amend should, for each proposed substitute claim, specifically identify the challenged claim which it is intended to replace.” Opp. 1–2 (citing Idle Free at 5). Furthermore, as Petitioner addresses, Patent Owner has failed to identify which of the challenged claims are intended to be replaced by the new claims. Id. Patent Owner’s response appears to be that “PO does not propose a reasonable number of substitute claims, because it is not necessary.” PO Reply 2. This, however, is not responsive. For at least these reasons, we find that Patent Owner has not complied with the substantive requirements of 37 C.F.R. § 42.221(a)(3) or the statutory requirements of § 326(d)(1)(B). 5. 37 C.F.R. § 42.221(b)(1) Rule 221(b)(1) requires that a motion to amend must show the changes clearly and set for the support in the original disclosure of the patent for claim that is added. In the case of new claims 22–49, Patent Owner does 54 not indicate any changes from the claims subject to the present proceeding. The claims are indicated as being new, so that no changes from the pending claims are discussed at all. See Claim App’x. In addition, Patent Owner argues that written description support for the new claims can be found in a chart provided in a reexamination of the patent. Mot. Amend 3 (citing inter partes Reexamination Control No. 95/001,129). We note that such incorporation by reference is not permitted under our rules. 37 C.F.R. § 42.6(a)(3). As well, as Petitioner points out, Patent Owner has not demonstrated that the claims provided in the chart are the same as the new claims. Opp. 4. Given this deficit, Patent Owner cannot successfully meet the regulatory requirements under 37 C.F.R. § 42.221(a) or (b)(1) regarding written description support, based on the present record. Additionally, Patent Owner has failed to provide any mapping of the new claims to those old claims, and, as Petitioner points out, the Board determined during the cited inter partes reexamination that no written description support was provided for a number of limitations identical to those recited in the new claims. Id. (citing Ex. 1007, 32–36). For at least these reasons, we find that Patent Owner has not complied with the substantive requirements of 37 C.F.R. § 42.221(b)(1). 6. Conclusion As discussed above, Patent Owner has not demonstrated compliance with 37 C.F.R. §§ 42.221(a), 42.221(a)(2)(i), 42.221(a)(2)(i), 42.221(a)(3), or 42.221(b)(1) or 35 U.S.C. § 326(d)(1)(B) and (3). As such, Patent Owner has failed to meet the substantive requirements for a motion to amend.” slip op. at 52

  Patent outcomesUS 7,340,506 unpatentable
  Claim construction§ 101 eligibility§ 103 obviousnesscites Alice · Mayo · Enfish · KSR · Graham
  Patents in suitUS 7,340,506
• Henny Penny Corporation v. Frymaster L.L.C.No claims unpatentable
  PTAB · Dec 21, 2017 · IPR2016-01435 · APJ Bart A Gerstenblith · IPR · Final written decision

  Claims 1–3, 5–12, and 17–21, 23 were not proven unpatentable over Kauffman and Iwaguchi, with Howard for claims 18 and 20, because the motivation to combine was insufficiently shown.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Level of Ordinary Skill in the Art Petitioner proposes that the level of ordinary skill in the art at the time of the invention would have been a “Bachelors of Science degree in Biosystems & Agricultural Engineering (or equivalent) or other Engineering major with a minor in Food Science and Technology and have had one or more years’ experience in the field of research and development of foods.” Pet. 7 (citing Ex. 1011 ¶ 74). Patent Owner does not propose an explicit level of ordinary skill in the art in its Response. Dr. Keener, however, expressly adopts Petitioner’s proposed level of skill in the art. Ex. 2032 ¶ 63. Consistent with the level of ordinary skill in the art reflected by the prior art of record, see Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978), we adopt Petitioner’s unopposed position as to the level of ordinary skill in the art.” slip op. at 13

  • Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesTerm construed board ownDecided for petitioner

    “means for re-circulating” In the Institution Decision, we preliminarily construed the claim term “means for re-circulating” as a means-plus-function limitation, invoking 35 U.S.C. § 112, ¶ 6. Id. at 17–18. We construed the function as “re-circulating said cooking oil” and identified the corresponding structure as “a pump and structural equivalents thereof.” Id. at 18–19. Neither party contests our construction of the term, and we maintain that construction here for the same reasons. slip op. at 7

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner

    “We agree with Patent Owner that we need not expressly construe the term “adapter.” We reiterate the following from our Institution Decision: The term “adapter” appears in each claim of the ’691 patent. Neither party contends that the specification or prosecution history contains a lexicographic definition of the term, and neither party asserts that the specification or prosecution history contains a disclaimer of any portion of the plain and ordinary meaning of the term. From our review of the record, the structure and location of the adapter recited in the claims is provided by other claim language describing that (1) the adapter is located external to the fryer, (2) the sensor is disposed in the adapter, (3) the adapter is installed between two portions of the return pipe or drain pipe, and (4) the adapter has two opposite ends wherein one of the two ends is connected to one of the two portions of either the return pipe or the drain pipe and the other end is connected to the other portion of pipe.3 Inst. Dec. 9–10. In light of the above discussion, and because the focus of the parties’ dispute is not on the meaning of the term “adapter,” we decline to expressly construe the term further.” slip op. at 8

  • Strike new argumentNew argument disregardedDecided for patent owner

    “Differences Between the Prior Art and the Claims; Motivation to Modify We instituted Petitioner’s challenge of these claims, and those that depend therefrom, based on Petitioner’s position that Kauffman disclosed most of the elements of the independent claims with the exception of a sensor capable of measuring an electrical property that is indicative of total polar materials. See, e.g., Inst. Dec. 31. Thus, the theory of obviousness, as discussed above, relies upon substituting Iwaguchi’s sensor for Kauffman’s analyzer. See id. at 31 (“Petitioner provides a second argument that relies upon a modification to Kauffman’s system, in which Iwaguchi’s sensor is employed instead of Kauffman’s analyzer. Because Petitioner provides adequate support for this second position, we address Patent Owner’s arguments based on this proposed combination.”). Petitioner confirmed at the oral argument that its Petition proposed a theory in which Iwaguchi’s sensor is simply swapped for that of Kauffman’s and did not present a more general theory as to modifying Kauffman’s sensor per the teachings of Iwaguchi: JUDGE WEINSCHENK: Did you include both of those alternative theories in your petition or is that something that you’re – you’ve come up with now in the reply? MR. VAIDYA: It’s something that we -- again, in the reply, we wanted to make it very clear that we aren’t going on a 102 basis and we are -- and what -- I think what -- we did have that alternate in the reply, so the alternate -- and I can point to paragraphs if that helps. And so, the idea is again primarily we’re going with the idea of swapping sensors, but that it would be possible to modify the sensor in Kauffman. JUDGE GERSTENBLITH: Because in the petition, it was a swap of the sensors. MR. VAIDYA: That’s right. JUDGE GERSTENBLITH: And that’s what we instituted -- MR. VAIDYA: That’s correct. JUDGE GERSTENBLITH: -- based on. MR. VAIDYA: That’s correct. Tr. 13:21–14:12. We disregard Petitioner’s alternative position as it was an attempt to raise a new theory of unpatentability improperly for the first time in the Reply. See 37 C.F.R. § 42.23(b) (“All arguments for the relief requested in a motion must be made in the motion. A reply may only respond to arguments raised in the corresponding opposition, patent owner preliminary response, or patent owner response.”).” slip op. at 16

  Patent outcomesUS 8,497,691 not shown unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,497,691
• Taiwan Semiconductor Manufacturing Company Limited / Globalfoundries U.S. Inc. v. Godo Kaisha IP Bridge 1All claims unpatentable
  PTAB · Dec 20, 2017 · IPR2016-01264 · APJ Michael J Fitzpatrick · IPR · Final written decision

  Claims 1–3, 5–7, and 9 are unpatentable as obvious over Zhang and Ding, and over Zhang, Ding, and Sun.

  RulingsFinal written decision

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner

    “Claims 1 and 5 recite “therein,” not “throughout.” The term “therein” means “in there” (i.e., in the first film). That readily apparent meaning unmistakably was conveyed by the Institution Decision. See Inst. Dec. 5–7 (rejecting Patent Owner’s attempt to read “therein” as “throughout.”). As further conveyed by our Institution Decision, Patent Owner’s attempt to incorporate “a mixture” into the limitation is another, unsupported, mechanism that would require nitrogen throughout. See id.” slip op. at 10

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner

    “not adopted. First, Patent Owner proposes to substitute “non-crystalline” for “amorphous.” Id. at 16 (citing Ex. 2003; Ex. 2008). Although both the intrinsic and extrinsic evidence are probative that “amorphous” and “crystalline” are antonyms, the ’324 patent uses the term “amorphous” dozens of times and not once uses the term “non-crystalline.” Further, the meaning of the term “amorphous” is readily apparent in light of the specification; there is no need for extrinsic evidence. See Phillips, 415 F.3d at 1317 (Extrinsic evidence “is less significant than the intrinsic record in determining the legally operative meaning of claim language.”) (internal quotation marks omitted). This is especially so here because the asserted prior art provides an in haec verba disclosure of the “amorphous” aspect of this limitation. See Ex. 1005, 3:39–41 (Ding teaching that the tantalum nitride (TaNx) layer is “amorphous”). In fact, Patent Owner’s proposed construction would not clarify what “amorphous” means; rather, it appears to be a vehicle by which Patent Owner would add a negative limitation prohibiting any portion of the second film being crystalline. See PO Resp. 16 (“As the specification and claims of the patent clearly distinguish between crystalline and amorphous materials and their different characteristics in a barrier film, a second film consisting essentially of amorphous metal nitride requires amorphous metal nitride throughout, and not merely a portion or portions of the film.”). Such a negative limitation is not part of the claim. Second, Patent Owner proposes to substitute “compound containing nitrogen” for “nitride.” Id. (citing Ex. 2004; Ex. 2009; Ex. 2011 ¶¶71–74). Although Patent Owner persuades us that a nitride is a compound containing nitrogen, there is no need to explicitly construe the limitation. The plain and ordinary meaning of “nitride” in light of the specification is readily apparent, and there can be no reasonable dispute in this inter partes review as to whether the “nitride” aspect of this limitation is taught by the asserted prior art. See, e.g., Ex. 1005, 6:64 (disclosing a “TaNx/Ta barrier layer structure”), 3:27 (designating “TaNx” as meaning “tantalum nitride”). Further, if we were to substitute the words “compound containing nitrogen” for “nitride,” we would introduce yet another transitional phrase— “containing”—into the claim. Doing so would obfuscate what the prior transitional phrase (i.e., “composed of,” which, at Patent Owner’s urging, we have construed to mean “consisting essentially of”) modifies.” slip op. at 14

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “the art. Petitioner argues that a person of ordinary skill in the art would have had “an equivalent of a Master of Science degree from an accredited institution in electrical engineering, materials science, or physics, or the equivalent, a working knowledge of semiconductor processing technologies for integrated circuits, and at least two years of experience in semiconductor processing analysis, design, and development.” Pet. 11 (citing Ex. 1003 ¶64). Patent Owner argues that such an individual would have had “at least a Bachelor’s degree in Electrical, Materials, Mechanical, or Chemical Engineering, or a related degree, and at least two years of experience working in semiconductor processing and fabrication, semiconductor equipment manufacturing, or semiconductor materials.” PO Resp. 18–19 (citing Ex. 2011 ¶24). Neither party explains in detail why its proposed level of ordinary skill in the art should be adopted nor how the different levels affect the parties’ analyses. Based on the evidence of record, including the testimony of the parties’ declarants, the subject matter at issue, and the prior art of record, we adopt Petitioner’s definition. 2. Disclosure of Zhang Zhang discloses a semiconductor device that includes a two-layered” slip op. at 16

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable

    “To meet the limitations specifying that the first film is crystalline and the second film is amorphous, Petitioner cites Ding’s explicit teaching of a two-layered barrier film with a bottom layer being amorphous tantalum nitride and a top layer being crystalline tantalum. See, e.g., Pet. 24–25 (citing Ex. 1005, 3:39–41, 8:1–4). Petitioner argues that a combination of teachings from Zhang and Ding renders the claims obvious. See, e.g., Pet. 24–26, 30–34. In particular, Petitioner argues, with supporting testimony from Dr. Banerjee, that it would have been obvious to a person of ordinary skill in the art “to use crystalline and amorphous top and bottom films for the films 32 and 22 in Zhang’s barrier structure, in view of Ding, to achieve” certain advantages noted in the prior art. Id. at 25–26 (citing Ex. 1003 ¶¶92–96). For example, Petitioner notes that Ding “discloses the desirability of using an amorphous TaNx layer as the bottom layer, so the TaNx is ‘sufficiently amorphous to prevent the diffusion of copper into underlying silicon or silicon oxide surfaces.’” Id. at 24 (quoting Ex. 1005, 3:39–41 (Petitioner’s emphasis)). Similarly, Petitioner notes that Ding “also discloses the desirability of using a crystalline metal film ‘having a tantalum <002> crystalline orientation’ as a top film in the two-layer diffusion barrier because the crystalline orientation ‘enables easy wetting of the tantalum surface by the copper and 13 Petitioner’s claim 5 arguments largely—and, in all relevant aspects, exclusively—rely on its claim 1 arguments. See Pet. 44–46. Hereafter, we cite to only its claim 1 arguments. depositing of a copper layer having a high <111> crystal orientation.’” Id. at 25 (quoting Ex. 1005, 8:1–4). Petitioner further argues that such a combination of teachings would have been obvious because it would have achieved these predictable results (i.e., an amorphous layer to prevent copper diffusion and a crystalline layer to promote copper adhesion) through known techniques. Id. at 32–34. Specifically, Petitioner notes that Zhang and Ding teach similar sputter-deposition processes for forming the top and bottom films. Id. at 32–33 (citing Ex. 1004, 3:21–50; Ex. 1005, 6:63–7:29; Ex. 1003 ¶98); see also PO Resp. 46 (Patent Owner acknowledging that “Zhang and Ding disclose similar sputtering processes.”).” slip op. at 23

  Patent outcomesUS 6,538,324 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · Graham
  Patents in suitUS 6,538,324
• Taiwan Semiconductor Manufacturing Company Limited / Globalfoundries U.S. Inc. v. Godo Kaisha IP Bridge 1All claims unpatentable
  PTAB · Dec 20, 2017 · IPR2016-01249 · APJ Michael J Fitzpatrick · IPR · Final written decision

  Claims 1–3, 5–7, and 9 and proposed claims 11–12 are unpatentable as obvious over Ding and Zhang; proposed claim 13 is patentable and allowed by amendment.

  RulingsFinal written decision

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed patent owner constructionDecided for patent owner

    “essentially of” for “being composed of.” PO Resp. 11 (citing AFG Indus., Inc. v. Cardinal IG Co., 239 F.3d 1239, 1245 (Fed. Cir. 2001)). In AFG, the Court noted that, “[i]n 1942, the Court of Customs and Patent Appeals [had] stated that ‘“composed of” should be regarded as synonymous with “consisting of.”’” AFG, 239 F.3d at 1245 (quoting In re Bertsch, 132 F.2d 1014, 1019 (CCPA 1942)). However, as further explained in AFG, the Court of Customs and Patent Appeals had “qualified this statement . . . by remarking that ‘the words “composed of” may under certain circumstances be given, in patent law, a broader meaning than “consisting of.”’” Id. (quoting In re Bertsch, 132 F.2d at 1020). The Court in AFG ultimately construed “composed of” to mean “consisting essentially of.” Id. (“[W]e do agree based on the specification and other evidence before us that the term ‘composed of’ in this case is not completely closed. Rather, we think that ‘composed of’ in this case should be interpreted in the same manner as ‘consisting essentially of.’”). Thus, “composed of” means either “consisting of” or “consisting essentially of.” Id. The term “consisting of” prohibits any 4 <111> and <002> are indices that pertain to an orientation or direction of crystals. Ex. 1003 ¶51. unspecified components. Id. (citing PPG Indus. v. Guardian Indus. Corp., 156 F.3d 1351, 1354 (Fed. Cir. 1998)). The term “consisting essentially of” prohibits only unspecified components that materially affect the basic and novel characteristic(s) of a claimed invention. Id. (citing Atlas Powder Co. v. E.I. du Pont De Nemours & Co., 750 F.2d 1569, 1574 (Fed. Cir. 1984)). By arguing that “being composed of” means “consisting essentially of” as opposed to “consisting of,” Patent Owner argues for broader claim scope. For purposes of this Decision, we construe “being composed of” to mean “consisting essentially of,” as Patent Owner argues.5 In conclusion, we construe “first film being composed of crystalline metal containing nitrogen therein,” as recited in independent claims 1 and 5, to mean “first film consisting essentially of crystalline metal containing nitrogen therein.”6” slip op. at 11

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “1. Level of Ordinary Skill in the Art The parties propose similar definitions of the level of ordinary skill in the art. Petitioner argues that a person of ordinary skill in the art would have had “an equivalent of a Master of Science degree from an accredited institution in electrical engineering, materials science, or physics, or the equivalent, a working knowledge of semiconductor processing technologies for integrated circuits, and at least two years of experience in semiconductor processing analysis, design, and development.” Pet. 10–11 (citing Ex. 1003 ¶64). Patent Owner argues that such an individual would have had “at least a Bachelor’s degree in Electrical, Materials, Mechanical, or Chemical Engineering, or a related degree, and at least two years of experience working in semiconductor processing and fabrication, semiconductor equipment manufacturing, or semiconductor materials.” PO Resp. 18 (citing Ex. 2011 ¶24). Neither party explains in detail why its proposed level of ordinary skill in the art should be adopted nor how the different levels affect the parties’ analyses. Based on the evidence of record, including the testimony of the parties’ declarants, the subject matter at issue, and the prior art of record, we adopt Petitioner’s definition.” slip op. at 16

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundUnpatentableUnpatentable

    “As to Petitioner’s predictable-results assertion, Petitioner persuasively argues that a person of ordinary skill in the art would have added nitrogen to the crystalline tantalum layer of Ding for three independent reasons. First, Petitioner argues that the presence of nitrogen in Ding’s crystalline tantalum layer would make it more easily removable by chemical mechanical polishing (“CMP”), which removal by polishing both Zhang and Ding teach to do. Pet. 24–26 (citing Ex. 1003 ¶¶140, 142, 143; Ex. 1004, 1:30–34, 4:34–37; Ex. 1005, 7:56–65; Ex. 1019, 12–13; Ex. 1021, 354–63). Second, Petitioner argues that the presence of nitrogen in Ding’s crystalline tantalum layer would inhibit, to some additional extent, copper diffusion. Id. at 26–29 (citing Ex. 1003 ¶¶144–146; Ex. 1023, 8). Third, Petitioner argues that adding a small amount of nitrogen to Ding’s crystalline tantalum layer would reduce its resistivity, which was known to help reduce a device’s power consumption and RC delays. Id. at 29–30 (citing Ex. 1003 ¶147; Ex. 1015, 81 (Table 1)). Patent Owner counters that none of these purportedly predictable results are realistic. PO Resp. 46–52. With respect to the first reason offered by Petitioner (to make the first film more susceptible to CMP), Patent Owner argues that: (A) adding only “[a] small amount of nitrogen” to Ding’s crystalline tantalum layer would not change its CMP characteristics; and (B) “[a]dding significant amounts of nitrogen” would result in Ding’s previously crystalline layer becoming amorphous. Id. at 48. Patent Owner does not disclose what it considers “small” and “significant” amounts of nitrogen. Id. As a result, we cannot apply Patent Owner’s argument (even if it were persuasive) to the facts before us. Also, Patent Owner’s argument is based exclusively on declaration testimony that does not cite to any underlying evidence, let alone documentary evidence. See id. at 47–49 (citing Ex. 2011 ¶¶190–98). In contrast, Petitioner’s argument is supported by declaration testimony, which, in turn, is based on underlying evidence, including documentary evidence. See Pet. 24–26 (citing Ex. 1003 ¶¶140, 142, 143; Ex. 1004, 1:30–34, 4:34– 37; Ex. 1005, 7:56–65; Ex. 1019, 12–13; Ex. 1021, 354–63); see also Ex. 1003 ¶139. With respect to the second reason offered by Petitioner (to inhibit, to some additional extent, copper diffusion), Patent Owner argues that, in Petitioner’s asserted combination, “there would be no nitrogen to provide any copper diffusion benefit.” PO Resp. 49. Patent Owner’s argument is premised on Zhang teaching exclusively an upper surface of pure tantalum. Id. But, Zhang explicitly teaches that the upper surface may have a nitrogen content of, for example, 1%, 2%, 3%, or 4%. See Ex. 1004, 3:59–62 (“At the upper surface, the atomic percent tantalum may be at least 95% and the atomic percent nitrogen may be less than 5% if copper adhesion is particularly problematic.”). With respect to the third reason offered by Petitioner (to reduce resistivity), Patent Owner argues that adding nitrogen would actually increase resistivity. As pointed out by Petitioner, however, Patent Owner’s declarant, Harlan R. Harris, Ph.D., conceded that adding nitrogen does lower resistivity. Reply 17–18 (quoting Ex. 1036, 125:3–20). Dr. Harris testified as follows: Q. When the nitrogen flow ratio is zero in the ’324 patent, and the power is kept constant, wouldn’t that result in a film that could be pure tantalum? A. All three of those data points are at the exact same position on the graph. The N2 concentration, which is the numerator of the ratio, is set at zero. And in this particular position, the nitrogen concentration would be assumed to be zero in the film. Q. So is it within the scope of what’s taught in the ’324 patent to have a film that would have no nitrogen at all? A. It’s also apparent to anyone who is examining this of skill in the art that you can decrease from that number, which is favorable in terms of the value of resistivity by adding flow rate in the data points for all of the positions greater than zero. So you decrease resistivity by the addition of any amount of nitrogen, therefore, a person skilled in the art would not be motivated to not have nitrogen, based on this data. Q. You’re referring to the decrease in resistivity as nitrogen is added? A. Yes. Q. Which is desirable? A. You want the resistivity to go down. Ex. 1036, 124:15–125:20. We are satisfied by each of Petitioner’s proffered reasons for why a person of ordinary skill in the art would have added nitrogen to Ding’s crystalline tantalum layer, as taught by Zhang. Petitioner has shown, by a preponderance of the evidence, that claims 1 and 5 would have been obvious over Ding and Zhang.” slip op. at 24

  • PTAB / AIA Trials › Motions to amend / substitute claimsMotion to amend granted in partGranted in part

    “obvious over Ding in view of Zhang. Patent Owner’s proposed claims 11 and 12 are unpatentable because they introduce limitations—nitrogen throughout the first film (claim 11) and nitrogen at the upper surface of the first film (claim 12)—that are met by the very references asserted in the ground of unpatentability involved in this inter partes review. Patent Owner’s Motion to substitute claims 11 and 12 is premised, incorrectly, on Zhang requiring pure tantalum (and, thus, no nitrogen) at the upper surface of its tantalum-rich tantalum nitride film. In fact, Zhang does not require any portion of the tantalum-rich tantalum nitride film to be pure tantalum. Ex. 1004, 3:53–54 (“The tantalum-rich tantalum nitride film has a range of approximately 0-30 atomic percent nitrogen.”). And, Zhang explicitly teaches that the upper surface may include nitrogen. Id. at 3:57– 62 (“A lower atomic percent nitrogen at the upper surface typically gives better adhesion to copper films. At the upper surface, the atomic percent tantalum may be at least 95% and the atomic percent nitrogen may be less than 5% if copper adhesion is particularly problematic.”); Ex. 1036, 40:1–6, 42:2–9, 42:15–21, 54:14–20 (Dr. Harris acknowledging that the upper surface of the film would contain some nitrogen). Accordingly, a preponderance of the evidence establishes that Patent Owner’s proposed claims 11 and 12 are not patentable over the art of record in this inter partes review. Put another way, and as Petitioner argues, claims 11 and 12 (like challenged claim 5) are unpatentable as they claim subject matter that would have been obvious over Ding in view of Zhang. See 35 U.S.C. § 103(a); Amend Opp. 6–7 (“The instituted obviousness ground[] based on Zhang and Ding already include[s] the newly-added limitations Patent Owner seeks to add in its Substitute Claims 11–13. Thus, the Substitute Claims 11–13 remain unpatentable over each of the instituted grounds.”).14 Patent Owner’s Motion to Amend is denied with respect to claims 11 and 12.” slip op. at 33

  Patent outcomesUS 6,538,324 unpatentable
  Claim construction§ 103 obviousness§ 112 disclosurecites Phillips · Graham
  Patents in suitUS 6,538,324
• Tricklestar LLC v. Embertec Pty Ltd.All claims unpatentable
  PTAB · Dec 20, 2017 · IPR2016-01336 · APJ Stacy B Margolies · IPR · Final written decision

  Claims 1–4, 7, and 9 are unpatentable as anticipated by EP ’379; claims 5 and 6 are unpatentable as obvious over EP ’379 and EP ’752.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “We determine that the level of ordinary skill proposed by Petitioner and Petitioner’s declarant is consistent with the challenged patent and the asserted prior art, and we therefore adopt that definition of the level of ordinary skill in the art for the purposes of the analysis below. See Ex. 1001, 1:14–15 (“The invention relates to aspects of the monitoring of electrical power supply to electrical equipment.”); Ex. 1002 ¶ 1 (“The present invention relates to a method and system to provide power saving for electronic devices while such devices are in the standby mode and are not in use, particularly for a setting accommodating multiple electronic devices especially in the end-user sector.”); Ex. 1003 ¶ 1 (“The present invention relates to an automatic means switch device used to disconnect a load from” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “We determine that we do not need to expressly construe “input” (claim 1), “electrical input” (claim 9), “sensor” (claims 1 and 9), and “alert device” (claim 5) to determine whether Petitioner has shown by a preponderance of the evidence that claims 1–7 and 9 are unpatentable.” slip op. at 11

  • Novelty / Anticipation (§102) › Prior-art status of a reference › Patents / published applications (effective date, provisional support)Reference is prior artDecided for petitioner

    “EP ’379 was published April 22, 2009. Ex. 1002, [43]. Because EP ’379 was published before the earliest possible invention date of record in this proceeding, Petitioner has shown by a preponderance of the evidence that EP ’379 is prior art to claims 1–4, 7, and 9 of the ’099 patent at least under 35 U.S.C. § 102(a).” slip op. at 16

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable

    “Pet. 16. As illustrated above, Petitioner adds red ovals around what it contends, and with which we agree, correspond to the claimed sensor and microprocessor: infrared receiver unit 10 and microprocessor 12. Id. EP ’379 discloses that infrared receiver unit 10 is coupled to microprocessor 12 and that the infrared receiver unit monitors wireless output signals from a remote control. Ex. 1002, Fig. 3, ¶¶ 24, 26. Specifically, EP ’379 discloses that “the signals of the remote controls of electronic devices connected to the subject controller [are] sensed, identified, and interpreted by the controller.” Id. ¶ 23; see also id. ¶ 26 (stating that “the remote control signals controlling the devices connected to the controller can also be sensed by the controller”). According to EP ’379, “[t]he controller unit identifies as to which electronic device’s remote control the user has depressed by means of the signal receiver (10) on itself.” Id. ¶ 24. EP ’379 also discloses that the microprocessor terminates power supplied to the external electrical device based upon the absence of detection of signals from the remote control. Id. ¶ 26. EP ’379 states the following: The controller can be set to a predetermined time period in order to save power, and if no signal is received within this time period from a remote control of any device connected to it, the controller can turn OFF such devices in turn or at the same time according to a predetermined power saving rule. Id. EP ’379 adds an example of a user setting the automatic turn-off period to three hours. Id. Under this example, according to EP ’379, “if the user does not depress any key on any remote control of any electronic device connected to the controller, or if no signal is sensed by the controller within three hours, the controller may power off the electronic devices connected to itself in sequence according to an automatic turning-off rule.” Id. In sum, Petitioner shows by a preponderance of the evidence that claim 1 is unpatentable as anticipated by EP ’379.” slip op. at 20

  Patent outcomesUS 9,106,099 unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 9,106,099

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.