- Arashi Vision (U.S.) LLC D/B/A Insta360 v. Gopro, Inc.Institution deniedPTAB · Apr 28, 2025 · IPR2025-00017 · APJ Nabeel U Khan · IPR · Institution
The Board denied institution under Fintiv because the parallel ITC investigation was advanced and overlapped sufficiently with the petition.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied
“An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). The Board, however, has discretion to deny institution even when a petition meets that threshold. Cuozzo Speed Techs., LLC v. Lee, 579 U.S. 261, 273 (“[T]he agency’s decision to deny a petition is a matter committed to the Patent Office’s discretion.”). Having considered the arguments and record before us, we determine it is appropriate to exercise our discretion and decline to institute an inter partes review in this case.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivDenied
“trial allays concerns about inefficiency and duplication of efforts.” Fintiv, 6. However, when there is a parallel district court litigation and an ITC investigation, “district court litigation is often stayed under 28 U.S.C. § 1659 pending resolution of the ITC investigation.” Id. at 7. The fact that the parallel district court litigation is stayed is, therefore, not the focus of this Fintiv factor under these circumstances. Instead, Fintiv counsels that “the parties should indicate whether the patentability disputes before the ITC will resolve all or substantially all of the patentability disputes between the parties, regardless of the stay.” Id. at 9. Here, the parallel ITC investigation is not stayed and, as we explain below in our analysis of Factor 4, there is some overlap between the patentability disputes presented here and those presented at the ITC. Petitioner argues that the district court is “not bound to any ITC decision” (Pet. Reply 2), but as Fintiv reminds us, “even though the Office and the district court would not be bound by the ITC’s decision, an earlier ITC trial date may favor exercising authority to deny institution under NHK if the ITC is going to decide the same or substantially similar issues to those presented in the petition.” Fintiv, 8.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
“While Petitioner addresses all limitations of the challenged claims in its Petition, Patent Owner presents arguments under all three grounds raising issues with Petitioner’s challenges. For example, regarding the first ground, Patent Owner argues Okubo’s image cutout “does not represent a portion of a larger input image, but rather is the size of the image that is ‘picked up’ and recorded in the first instance.” Prelim. Resp. 12. Thus, according to Patent Owner, Okubo does not disclose “selecting sub-frames” as recited by limitation 1[D] of claim 1. Id. Regarding the second ground, Patent Owner argues that Okubo’s two-stage lens distortion correction process is limited to still images while Sokeila’s teachings relate to video images. Id. at 18–19. Regarding the third ground, Patent Owner argues that “Eder does not disclose selecting sub-frames representing portions of the input images, where the input images include fields of view captured through a lens of the camera.” Id. at 21. Even if we were to determine that Petitioner has demonstrated a reasonable likelihood of prevailing, the arguments presented 5 Sokeila is relied upon as a secondary reference to challenge claim 12 of U.S. Patent No. 10,958,840 B2 in IPR2024-01164 and IPR2024-01165. if trial were to be instituted. Accordingly, at this stage of the proceeding, based on the arguments and evidence set forth, we disagree that the merits of the Petition are compelling or particularly strong.” slip op. at 15
§ 103 obviousnessDiscretionary denialPatents in suitUS 10,529,052 - PTAB · Apr 25, 2025 · IPR2024-01463 · APJ David Cotta · IPR · Institution
The Board instituted inter partes review of claims 1–10 on all asserted grounds, finding a reasonable likelihood of success on at least one claim.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“predict how the district court in the related district court litigation will proceed because the court may determine whether or not to stay any individual case . . . based on a variety of circumstances and facts beyond our control and to which the Board is not privy.” Sand Revolution II LLC v. Cont’l Intermodal Grp., IPR2019-01393, Paper 24, 7 (PTAB June 16, 2020) (informative). We decline to speculate on how the court may rule on the pending motion to stay. Accordingly, this factor is neutral.” slip op. at 13
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 314(a), inter partes review may not be instituted unless the Petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Petitioner has established a reasonable likelihood of prevailing on its assertion that at least one of the challenged claims is unpatentable based on the grounds advanced here. We decline to deny the Petition on a discretionary basis as requested by Patent Owner. Thus, for reasons explained below, we institute inter partes review of claims 1–10 of the ’706 patent.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“TC(220), and ΔRz/Ra are result effective variables and that copper foils having ΔPD, TC(220), and ΔRz/Ra values that meet the values recited in claim 1 have advantageous properties. See, e.g., Ex. 1005 ¶ 45 (Kim ’761, disclosing that preferably the “difference in peak count roughness Rpc between the shiny surface . . . and the matte surface . . . of the electrolytic copper foil . . . is preferably 60 or less” because “when the difference in the peak count roughness Rpc exceeds 60 capacity maintenance of the secondary battery is deteriorated.”);15 Ex. 1007, 3:16–23, 4:14–23 (Cheng, disclosing that the foils of Cheng’s invention have (220) and (311) surfaces that provide increased elongation and that solve a high roughness problem that rendered traditional products unsuitable for use in a lithium ion secondary battery), 10:27–34 (Cheng, disclosing that in the foils of Cheng’s invention “the roughness difference between both sides was extremely small” and thus “it was . . . not easy for the electrolytic copper foil to break or fracture during the charging-discharging cycles and the life of a battery is thus increased”), Tables 3 & 4 (Cheng, disclosing embodiments and comparative examples with TC(220) values meeting the requirements of claim 1); Ex. 1008, 6:36–44 (Wolski, disclosing that “the surface roughness Rz at the matte side of the untreated copper foil of the present invention is the same or smaller than the surface roughness Rz at the shiny side . . . so that the surface treated copper foil . . . becomes more low-profiled . . . whereby it becomes a foil having a large etching factor”), 9:1–29 & Table 2 (Wolski, disclosing 15 Dr. Randall testifies that “Kim ’761’s peak count roughness Rpc corresponds to the peak density PD of the ’706 patent.” Ex. 1003 ¶ 52. At this stage in the proceeding, this testimony is unrebutted. 38 embodiments meeting the ΔRz/Ra of claim 1, describing them as having “matte side roughnesses” that are “sufficiently small,” and as having “excellent” “high temperature elongation characteristics”), 11:37–41 (Wolski, describing comparative examples as having “large” matte side roughnesses “whereby etching factors are not good”), 12:12–27 (Wolski, teaching that “as compared with a conventional untreated copper foil, both surfaces of the untreated copper foil obtained by [Wolski’s] invention are flat” resulting in a low profile foil that has “excellent elongations at room temperature and high temperature and also high tensile strength”). The teachings in the prior art support the presently unrebutted testimony of Dr. Randall explaining why the POSA would have been motivated to modify Kim ’761’s copper foil to have the claimed TC(220) and ΔRz/Ra. Ex. 1003 ¶¶ 66–68, 71–74; Pfizer Inc., v. Sanofi Pasteur Inc., 94 F.4th 1341, 1348 (Fed. Cir. 2024) (“Where [a gap in prior art] includes a parameter not necessarily disclosed in the prior art, it is not improper to consider whether or not it would have been recognized as result-effective. If so, then the optimization of that parameter is ‘normally obvious.’”). Accordingly, we are not persuaded by Patent Owner’s argument that Petitioner failed to articulate a sufficient motivation to combine the references. To the contrary, the preliminary record presents a strong showing that the POSA would have been motivated to combine the references in the manner described in the Petition.” slip op. at 38
- Skill levelSkill level petitioner adoptedDecided for petitioner
“At this stage of the proceeding, Patent Owner does not contest Petitioner’s definition of the level of skill in the art. Prelim. Resp. 4 (“For purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art”). Petitioner’s definition appears to be consistent with the field of the invention reflected in the prior art of record and the disclosure of the ’706 patent. Accordingly, for purposes of this Decision, we adopt Petitioner’s proposed definition of the person of ordinary skill in the art.” slip op. at 21
Claim construction§ 103 obviousnessDiscretionary denialcites KSR · GrahamPatents in suitUS 11,591,706 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 25, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–8 were unpatentable under the asserted obviousness grounds.
RulingsInstitution decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“experience working on the development of materials or components for electronic devices such as batteries.” Pet. 2. Petitioner further contends that “[a]dditional education, such as a graduate degree, could compensate for less work experience, and additional work experience could compensate for less formal education.” Id. Patent Owner states that, “[f]or purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art.” Prelim. Resp. 4. For purposes of this Decision, we adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’014 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” 37 C.F.R. § 42.100(b). Under this standard, claim terms are generally given their plain and ordinary meaning as would have been understood by a person of ordinary skill in the art at the time of the invention and in the context of the entire patent disclosure. Phillips v. AWH Corp., 415 F.3d 1303, 1313 (Fed. Cir. 2005) (en banc). Only those terms in controversy need to be construed, and only to the extent necessary to resolve the controversy. Realtime Data LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019). in this proceeding.” Pet. 3. Patent Owner contends that “[t]he Board need not construe any term in order to determine that institution should be denied.” Prelim. Resp. 4. Based on the record before us, we determine that no claim term requires express construction for purposes of this Decision. See Realtime Data, 912 F.3d at 1375.” slip op. at 8
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“For these reasons, we are not persuaded that Petitioner sufficiently establishes that a POSITA would have been motivated to modify Hanafusa in light of Dobashi with a reasonable expectation of success as Petitioner contends. Accordingly, we determine that Petitioner fails to demonstrate a reasonable likelihood of prevailing in its assertion that the subject matter of claim 1, and claims 4 and 8 that depend therefrom, would have been obvious over the combined teachings of Hanafusa and Dobashi.” slip op. at 18
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“Petitioner also focuses on Hanafusa’s teaching that all known methods can be used to make a rough surface low-profile, and Dobashi’s teaching that RSm can be used as an indicator for judgment of the surface, to support its contention that a POSITA would have been motivated to apply Dobashi’s RSm to further achieve Hanafusa’s purpose, without explaining how and why that would be the case. In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness and is rough when RSm is small.” Id. at 3:1–3, 6:27–29. Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66– 3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66–3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 14
Claim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 11,346,014 - PTAB · Apr 25, 2025 · IPR2024-00793 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Micron’s rehearing requests, finding no misapprehension or overlooked matter in its denial of institution based on the failure to show the challenged claims obvious.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“Petitioner’s own formulations of the grounds based on either Seo or Nam in combination with Choi posit the alternative theories that either Seo or Nam alone disclose Limitation [1.D], or the combination of either Seo or Nam with Choi teaches this limitation. Although Petitioner did not invoke inherency by name for the theories based on Seo or Nam alone, this is, in effect, the nature of Petitioner’s assertions, namely, voltage differentials in Seo and Nam would inherently remove fast charges. For example, with respect to Seo, Petitioner argues that “Seo teaches having a higher voltage on unselected WLs (e.g., adjacent WLs to the selected WL) during the first time period,” and “the ’342 patent recognizes [that] this voltage differential removes fast charges.” Pet. 35–36 (citing Ex. 1001, 12:24–34; Ex. 1003 ¶¶ 129–131) (emphasis omitted); see also id. at 82–83 (relying on the ’342 patent to support the contention that Nam teaches Limitation [1.D] because Nam “teaches having a higher voltage on unselected WLs (including WLs adjacent to the selected WL) relative to the selected WL during the first time period” (citing Ex. 1001, 12:24–34) (emphasis omitted)). Petitioner does not argue that Seo and Nam expressly disclose removing fast charges or sufficiently explain how a POSITA would have understood that the procedures used in Seo and Nam would have removed fast charges; instead, Petitioner effectively argues that removing fast charges is the inherent result of applying the voltage differential. See, e.g., Pet. 36 (stating Seo would have been understood to disclose “performing its read operation on chargetrap memories, which removes fast charges”).” slip op. at 5
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Petitioner’s reliance on Choi does not cure the deficiencies set forth above. Petitioner asserts that “Choi explains the primary mechanism and unwanted impact of fast-charge loss on verification,” which provides the motivation “to use Seo’s and Nam’s methods to achieve fast charge removal to improve verification.” Req. 7 n.1. But again, Petitioner does not sufficiently explain how a POSITA, looking at Choi, would have understood that either Seo’s or Nam’s techniques result in fast charge removal. In other words, even if Choi teaches the impact of fast-charge loss on verification, Petitioner fails to sufficiently show that a POSITA would have understood that either Seo or Nam teach or suggest fast charge removal. It was Petitioner’s burden to establish that Seo and Nam, alone or in combination with Choi, disclose Limitation [1.D]. We are not persuaded that we misapprehended the nature of Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 7
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish that Seo and Nam, alone or in combination with Choi, disclose Limitation [1.D]. We are not persuaded that we misapprehended the nature of Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner’s reliance on Choi does not cure the deficiencies set forth above. Petitioner asserts that “Choi explains the primary mechanism and unwanted impact of fast-charge loss on verification,” which provides the motivation “to use Seo’s and Nam’s methods to achieve fast charge removal to improve verification.” Req. 7 n.1. But again, Petitioner does not sufficiently explain how a POSITA, looking at Choi, would have understood that either Seo’s or Nam’s techniques result in fast charge removal. In other words, even if Choi teaches the impact of fast-charge loss on verification, Petitioner fails to sufficiently show that a POSITA would have understood that either Seo or Nam teach or suggest fast charge removal.” slip op. at 7
§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,600,342 - PTAB · Apr 25, 2025 · IPR2024-00912 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Micron’s rehearing requests, leaving institution denied because the petitions did not show that the prior-art combinations disclose or render obvious fast-charge removal.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re Gartside, 203 F.3d 1305, 1315–16 (Fed. Cir. 2000)). The party requesting rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 3
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“It was Petitioner’s burden to establish that Seo and Nam, alone or in combination with Choi, disclose Limitation [1.D]. We are not persuaded that we misapprehended the nature of Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“determined that the combinations of Seo or Nam with Choi were not persuasive. Dec. 14–15, 19–20. For example, we determined that “Dr. Liu’s statement that ‘[a] POSITA would have recognized that the lateral-electrical-field-inducing voltage differential, as Seo discloses, is what Choi describes as driving the lateral fast-charge loss,’ is not supported by objective evidence or sufficient explanation as to why a POSITA would have come to that understanding” and was therefore insufficient to support Petitioner’s asserted motivation to combine Seo with Choi. Id. at 14–15. In particular, we were not persuaded that “Seo creates a large lateral electric field like the one described in Choi,” and, in any case, we disagreed that “Choi teaches that a large lateral electric field removes fast charges.” Id. at 15. Accordingly, regardless of the duration of the voltage application described in Seo, Petitioner failed to show that the combination of Seo and Choi would result in removal of fast charges. We further determined that Petitioner’s combination of Nam with Choi was problematic for similar reasons, given Petitioner’s reliance on similar arguments. See id. at 20.” slip op. at 10
- Expert testimonyPetitioner expert discountedOther
“the knowledge of one of ordinary skill in the art relating to charge-trap memory devices demonstrates fast charge removal. See Pet. 36, 81–82. And although Petitioner cites its declarant, Dr. Liu, for the proposition that “Seo discloses, and would have been understood to disclose, performing its read operation on charge-trap memories, which removes fast charges,” Dr. Liu does not cite objective evidence to support this assertion, aside from the ’342 patent itself. Id. at 36 (citing Ex. 1003 ¶ 136). Moreover, Dr. Liu’s testimony simply circles back to logic similar to that relied on with respect to the inherency theory, namely that, given certain similarities between Seo and the ’342 patent, Seo removes fast charges because the ’342 patent teaches removing fast charges, even though Seo does not explicitly teach doing so. See Ex. 1003 ¶ 136 (“[A] POSITA would have immediately understood from reading Seo that Seo is disclosing its read operation as applicable to Flash memories, including Flash charge-trap memories. And as the ’342 states, Seo’s operation would remove fast charges in a charge-trap memory.” (citing Ex. 1001, Abstract)). As already discussed, we disagree with this logic based on the lack of sufficient evidence to support its conclusion. See Dec. 13 (“Petitioner and Dr. Liu do not provide any objective evidence or explanation as to how or why a POSITA would have understood that Seo’s voltage amounts applied during Seo’s time periods operate the same way [as in the ’342 patent] on Seo’s memory device to generate fields with sufficient magnitude and duration to remove fast charges.”). Petitioner’s assertions regarding Nam suffer from the same shortcomings. See Dec. 19–20; Pet 82 (“[A] POSITA would have found that Nam’s teachings are applicable to charge-trap devices”); Ex. 1003 ¶¶ 293–298.” slip op. at 8
§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,600,342 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 23, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–10 were unpatentable over either asserted § 103 ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314 (2018); see also 37 C.F.R. § 42.4 (2023). For the reasons discussed below, we deny the Petition and do not institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“II. ANALYSIS A. Level of Ordinary Skill in the Art Petitioner contends that a person of ordinary skill in the art (“POSITA”) “would have had at least an undergraduate degree in materials science, chemical engineering, electrical engineering, or related field, or equivalent knowledge, training, or experience, with at least two years of experience working on the development of materials or components for electronic devices such as batteries.” Pet. 4. Petitioner further contends that “[a]dditional education, such as a graduate degree, could compensate for less 7 We refer to the page numbers added by Petitioner to the bottom-center of the page. formal education.” Id. (citing Ex. 1003 ¶ 10). Patent Owner states that, “[f]or purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art.” Prelim. Resp. 4. For purposes of this Decision, we adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’689 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163–64 (Fed. Cir. 1985))).” slip op. at 10
- Expert testimonyPetitioner expert discountedDecided for patent owner
“We are not persuaded, on this record, that Petitioner adequately establishes that Khatibi discloses a CTE in the claimed range of 16 to 22 µm/(m·°C.). Petitioner’s argument that Khatibi’s reported values meet this claim limitation are based solely on Dr. Randall’s testimony that Khatibi’s measurement method would produce results that would not significantly differ from results determined using the claimed method. See Pet. 16–18 (citing Ex. 1003 ¶¶ 56–60). Dr. Randall’s testimony, however, is largely conclusory and unsupported by adequate explanation and/or objective evidence. For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added). to little weight. See 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); Xerox Corp. v. Bytemark, Inc., IPR2022-00624, Paper 12 at 5 (PTAB Feb. 10, 2023) (finding that “the Board was correct in giving little weight to Petitioner’s expert because the expert declaration merely offered conclusory assertions without underlying factual support”); Upjohn Co. v. Mova Pharm. Corp., 225 F.3d 1306, 1311 (Fed. Cir. 2000) (“Lack of factual support for expert opinion to factual determinations, however, may render the testimony of little probative value in a validity determination.” (quoting Ashland Oil, Inc. v. Delta Resins and Refractories, Inc., 776 F.2d 281, 294 (Fed. Cir. 1985))); see also In re Ethicon, Inc., 844 F.3d 1344, 1348, 1352 (Fed. Cir. 2017) (concluding that the Board properly gave “little weight” to conclusory expert testimony of objective indicia). Because Petitioner offers Dr. Randall’s testimony to supply a limitation missing from the prior art, namely, the CTE measurement method, and we give Dr. Randall’s unsupported and conclusory testimony little weight, we are not persuaded that Petitioner establishes a reasonable likelihood of showing that Khatibi discloses limitation [1d].” slip op. at 17
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“second surfaces of the electrolytic copper foil ranges from 3 to 92.” Ex. 1001, 13:62–63. Petitioner contends that “Kim teaches that the electrolytic copper foil (e.g., untreated or treated copper foil) having Rz less than 2 µm is advantageous toward battery efficiency and performance,” and, similarly, Griesi describes the use of untreated electrolytic copper foil with an Rz value less than 2 µm in printed circuit boards that are compatible with secondary batteries. Pet. 58–59 (citing Ex. 1012, claim 2, ¶¶ 13, 25, 27; Ex. 1003 ¶ 157). In particular, Petitioner notes that Griesi’s Figure 3.16 describes an “Rz value of 1.2 µm.” Id. at 59 (citing Ex. 1015, 53–54; Ex. 1003 ¶ 158). Petitioner asserts that “Dr. Randall explains that a POSITA would have also recognized another surface roughness-related parameter, Rpc, in Griesi as a potentially useful parameter that can be optimized to further enhance uniformity or generally improve Kim’s copper foil surface, for example, to prevent wrinkles or achieve other advantageous effects.” Id. (citing Ex. 1003 ¶ 159). Although Dr. Randall demonstrates that Griesi’s Pc (or Rpc) value is 19.2 over a 4 mm sampling length (Ex. 1003 ¶ 155), Petitioner does not contend that Griesi addresses this value, or indicates any benefit that might be derived from its use. Instead, Griesi’s Pc value appears to be an incidental finding, which is not discussed or analyzed in the reference. See incidental, unexamined finding would lead a POSITA to import Griesi’s Pc value into Kim’s copper foil, absent a hindsight desire to reconstruct the claimed invention. As such, Petitioner’s arguments with respect to Kim and Griesi are not persuasive. See Cheese Sys. Inc. v. Tetra Pak Cheese and Powder Sys., Inc., 725 F.3d 1341, 1352 (Fed. Cir. 2013) (“Obviousness cannot be based on the hindsight combination of components selectively culled from the prior art to fit the parameters of the patented invention.” (internal quotations marks omitted)). Thus, we are not persuaded, on this record, that the combined disclosures of Kim and Griesi teach all of the elements of limitation [1g].” slip op. at 23
§ 103 obviousnesscites PhillipsPatents in suitUS 10,811,689 - PTAB · Apr 22, 2025 · IPR2024-00910 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Micron’s rehearing request, leaving institution denied because the Petition did not show a reasonable likelihood that claims 7–10 were obvious over Park.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re Gartside, 203 F.3d 1305, 1315–16 (Fed. Cir. 2000)). The party requesting rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended” slip op. at 2
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for patent owner
“dummy source structure might not even be an inoperable structure,” and therefore “the ’872 Patent does not use ‘dummy’ to exclude the dummy source structure from being an operable, functioning element.” Ex. 1003 ¶ 85 (citing Ex. 1001, 5:41–43, 16:63–66). In support of his testimony, Dr. Banerjee points to the Specification’s teaching that “[i]n some embodiments, one or more dummy source structures are in contact with the substrate and may provide interconnect between the 3D memory device and peripheral devices” (Ex. 1001, 5:41–43), and “[w]hen conductive materials are used to fill dummy source hole 212 (e.g., contact 224), the dummy source structure 246 may function as an interconnect to connect 3D memory device 100 with other peripheral devices” (id. at 16:63–66), which we considered and relied upon in construing “dummy source structure” in the Decision. Dec. 11–13. None of the functions identified by Dr. Banerjee, however, relate to whether the dummy source structure would function as a source to the memory cells. Specification consistently describes that function as an interconnect with other peripheral devices, and does not teach or suggest that the dummy source structure may function to provide source to the memory cells. See Ex. 1001, 5:40–43 (“In some embodiments, one or more dummy source structures are in contact with the substrate and may provide interconnect between the 3D memory device and peripheral devices.”), 11:46–48 (“In some embodiments, dummy source structures 178 may function as interconnects to connect 3D memory device 100 with other peripheral devices.”), 16:63–66 (“When conductive materials are used to fill dummy source hole 212 (e.g., contact 244), the dummy source structure 246 may function as an interconnect to connect 3D memory device 100 with other peripheral devices.”). Our construction of “dummy source structure” is consistent with the Specification, and does not foreclose the dummy source structure from being operational, for example, as an interconnect to peripheral devices. Nor is it inconsistent with the Specification’s teaching that “[i]n some embodiments, dummy source structure 246 may not connect to channel structures in the inner region.” See Req. 11 (citing Ex. 1001, 16:38–44). In the case where the dummy source structure connects with the channel structures, the other end may connect with peripheral devices, or may be a dead end. Thus, even if the dummy source structure is operable as an interconnect to connect the 3D memory device with other peripheral devices, it does not follow that a dummy source structure would function as an interconnect to a supply that provides source to the memory cells. For these reasons, we are not persuaded that we abused our discretion in our construction of the term “dummy source structure.”” slip op. at 5
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“(Paper 14, “Request” or “Req.”) of our Decision (Paper 13, “Decision” or “Dec.”) denying institution of an inter partes review of claims 7–10 (“the challenged claims”) of U.S. Patent No. 10,861,872 B2 (Ex. 1001, “the ’872 patent”). The Request challenges our determination that the information presented in the Petition did not establish a reasonable likelihood of showing that claims 7–10 would have been obvious over the teachings of Park.1 Dec. 19–23.” slip op. at 2
Claim constructionPatents in suitUS 10,861,872 - Solus Advanced Materials Co, Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 22, 2025 · IPR2024-01460 · APJ Jon B Tornquist · IPR · Institution
The Board denied institution of review of claims 1–11 because the Fintiv factors, including the early trial date and close merits case, favored discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied fintivInstitution denied
“whether to institute an inter partes review. Applying the standard set forth in 35 U.S.C. § 314(a), we may not institute an inter partes review unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Institution of inter partes review, however, is discretionary. See Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1367 (Fed. Cir. 2016) (“[T]he PTO is permitted, but never compelled, to institute an IPR proceeding.”). For the reasons stated below, we exercise our discretion not to institute an inter partes review. A. Real Parties-in-Interest” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivDenied
“Board’s projected statutory deadline to issue a final written decision. Fintiv, Paper 11 at 9. “If the court’s trial date is at or around the same time as the projected statutory deadline . . . the decision whether to institute will likely implicate other factors.” Id. Conversely, “[i]f the court’s trial date is earlier than the projected statutory deadline,” this has generally weighed “in favor of exercising authority to deny institution.” Id.” slip op. at 15
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsNot reached
“Petition under 35 U.S.C. § 325(d) because the same or substantially the same art and arguments were before the Examiner during prosecution and Petitioner’s has not demonstrated that the Examiner erred in a material manner when allowing the claims. Pet. 17–18. Given our discretionary denial of the Petition in view of the Fintiv factors, we do not address Petitioner’s further arguments with respect to § 325(d).” slip op. at 32
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner applies Petitioner’s recited level of ordinary skill in the art for purposes of its Preliminary Response. Prelim. Resp. 4. Upon review of the parties’ arguments and the prior art of record, we adopt Petitioner’s unopposed definition of the ordinarily skilled artisan for purposes of this decision as it appears consistent with the disclosures of the ’090 patent and the prior art of record. C. Claim Construction” slip op. at 9
§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,480,090 - Arashi Vision (U.S.) LLC (D/B/A Insta360) v. Gopro, Inc.Institution deniedPTAB · Mar 31, 2025 · IPR2024-01434 · APJ Jennifer S Bisk · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that the single claimed design was obvious over the asserted prior-art combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“shown that Chen686, alone or in combination with the various secondary references, teaches or suggests a camera having the same overall visual appearance of the claimed design. Thus, we determine that Petitioner has not demonstrated a reasonable likelihood that it would prevail in challenging the patentability of the ’435 patent’s claim over Chen686 and the asserted secondary references.” slip op. at 30
- Other 314aNot reached
“These deficiencies in analysis raise the question of whether the Petition adequately identifies the number of actual challenges, and evidence supporting each, with the degree of particularity required of petitions in our forum. The Petition does not explain why so many grounds are necessary under the circumstances or why the Board should impose on Patent Owner the burden of defending against so many challenges. See generally Pet. An inter partes review based on 24 distinct grounds raised against a single claim, supported by analysis lacking in particularity, potentially burdens Patent Owner unduly and makes inefficient use of the Board’s resources. See PTAB Consolidated Trial Practice Guide (Nov. 2019),22 56 (“The AIA was ‘designed to establish a more efficient and streamlined patent system that will improve patent quality and limit unnecessary and counterproductive litigation costs.’” (quoting H.R. Rep. No. 112–98, pt. 1, at 40 (2011), 2011 U.S.C.C.A.N. 67, 69 (Post grant reviews were meant to be “quick and cost effective alternatives to litigation”)). Because we understand enough of the Petition’s analysis to address each group of asserted grounds on the merits, we decline to exercise our discretion to deny institution based solely on this issue.” slip op. at 11
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner submits that a designer of ordinary skill in the art at the time of the invention would have had “a bachelor’s degree in industrial design or an equivalent field, or two years of experience designing cameras or camera housings.” Pet. 11 (citing Bressler Decl. ¶¶ 22–24). Patent Owner does not dispute this proposed definition. See generally Prelim. Resp. For purposes of this Decision, we adopt Petitioner’s uncontested proposal regarding a designer of ordinary skill in the art. See Bressler Decl. ¶¶ 22–24.” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner
“In its claim construction section, Petitioner states that the ’435 patent “encompasses a rectangular body with flat faces, a rectangular lens cover extending outward from the front of the body, rectangular buttons/access elements, and rectangles for displays” and “[a]s a whole . . . gives an ordinary designer an overall visual impression of a rectangular design for a camera/camera housing.” Pet. 12 (citing Bressler Decl. ¶¶ 25–26). These descriptions are incredibly general and do not provide an adequate understanding of the overall visual appearance of the claimed design. Moreover, we do not find them helpful in our analysis and, therefore, do not adopt them as a claim construction. Patent Owner does not explicitly address claim construction. See” slip op. at 13
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Graham - Innoscience (Zhuhai) Technology Company, Ltd. / Innoscience America, Inc. v. Efficient Power Conversion CorporationNo claims unpatentablePTAB · Mar 25, 2025 · IPR2023-01382 · APJ Kimberly Mcgraw · IPR · Final written decision
Claims 1–3 were not shown unpatentable under any of five § 103 grounds because Petitioner failed to establish sufficient motivation to modify or combine the prior art.
RulingsFinal written decision- BurdenNot shown unpatentable
“A petition must identify “with particularity . . . the evidence that supports the grounds for the challenge to each claim.” 35 U.S.C. § 312(a)(3) Here, Petitioner merely provides general assertions about multiple references, without clearly identifying how, or why a POSITA would have been motivated, to modify the processes disclosed in those references to arrive at the claimed invention. Thus, the Petition does not state with particularity that Saxler’s particular technique for etching is to be used instead of Beach’s etching step when substituting Beach’s self-aligned process for Saxler’s two mask process. Nor does the Petitioner provide a sufficient reason, absent hindsight, why a POSITA would have been motivated to combine the references to result in a process that forms Saxler’s Modified Figure 1A. Thus, for these additional reasons, Petitioner has not shown by a preponderance of the evidence that claim 1 would have been obvious over Saxler, Beach, and Shenoy.” slip op. at 34
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Both parties agree that the differences between the definitions do not impact the analysis. Resp. 11; Reply 2. In light of the record before us, and for purposes of this Decision, we adopt Petitioner’s proposal regarding the level of ordinary skill in the art. Based on our review of the ’347 patent and the prior art of record, we determine that the definition offered by Petitioner comports with the qualifications a person would have needed to understand and implement the teachings of the ’347 patent and the prior art. We also note that our Decision would be the same under either parties’ definition.” slip op. at 13
- Expert testimonyOther
“Petitioner’s expert, Dr. Shealy states that he understands paragraph 52 to mean that it is “fair game to pull the recess out of any of those figures [Figures 1A through 6].” Ex. 2004, 39:12–21. Dr. Shealy, however, also clarifies that “[a]s I said before, I think you could take all the embodiments and bring in which ones you want, depending on what you’re trying to accomplish.” Ex. 2004, 40:24–41:1. During the hearing, Petitioner admitted that Dr. Shealy’s “statement to modify the reference depending on what you're trying to accomplish” means that “a POSITA may modify with reason to do so. A POSITA would have removed Saxler’s recess to obtain the benefits of enhancement-mode.” Tr. 19:19–25. Again, the Petition does not provide a reason why a POSITA would have removed Saxler’s gate recess.” slip op. at 28
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“remove the recess in Saxler Figure 1A to arrive at the allegedly enhancement mode transistor of Modified Figure 1A. Contrary to Petitioner’s assertions in its Reply and at the hearing, the Petition makes no argument that a POSITA would have removed the recess from Saxler Figure 1A to realize the benefits of an enhancement mode transistor. See Reply 4–5; Pet. 24–68. Rather, the Petition merely asserts that a POSITA would have understood that the gate recess of Figure 1A is optional without providing any persuasive reason why a POSITA would have removed the gate recess but retained the sloped sidewalls of Figure 1A. Pet. 25, 40, 45. For example, Petitioner asserts that Saxler’s gate contact may be “recessed or non-recessed” and that when the gate recess shown in Figure 1A is not utilized, Saxler would have the structure of Saxler Modified Figure 1A. Pet. 25 (citing Ex. 1003 ¶ 81; Ex. 1007 ¶ 52, 66); see also Pet. 40, 45 (citing Ex. 1007 ¶ 52). Neither of these paragraphs provide sufficient motivation to a POSITA to remove the gate recess from Saxler Figure 1A. Saxler paragraph 52 states: Exemplary devices according to some embodiments of the present invention are schematically illustrated in FIGS. 1A through 6. Thus, while embodiments of the present invention are described herein with reference to a recessed gate structure or a non-recessed gate structure, other embodiments of the present invention may include or not include a gate recess. Accordingly, embodiments of the present invention should not be construed as limited to the particular exemplary embodiments described herein but may include any suitable structure having a cap layer and/or passivation layer as described herein. Ex. 1007 ¶ 52. Petitioner’s expert, Dr. Shealy states that he understands paragraph 52 to mean that it is “fair game to pull the recess out of any of those figures [Figures 1A through 6].” Ex. 2004, 39:12–21. Dr. Shealy, however, also clarifies that “[a]s I said before, I think you could take all the embodiments and bring in which ones you want, depending on what you’re trying to accomplish.” Ex. 2004, 40:24–41:1. During the hearing, Petitioner admitted that Dr. Shealy’s “statement to modify the reference depending on what you're trying to accomplish” means that “a POSITA may modify with reason to do so. A POSITA would have removed Saxler’s recess to obtain the benefits of enhancement-mode.” Tr. 19:19–25. Again, the Petition does not provide a reason why a POSITA would have removed Saxler’s gate recess.” slip op. at 28
Patent outcomesUS 9,748,347 not shown unpatentable§ 103 obviousnesscites Phillips · KSRPatents in suitUS 9,748,347
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.