- Palo Alto Networks, Inc. / Cisco Systems, Inc. et al. v. Centripetal Networks, Inc.All claims unpatentablePTAB · Jun 11, 2026 · IPR2022-01199 · APJ Kevin F Turner · IPR · Remand
On remand, the Board held claims 1, 24, and 25 unpatentable as obvious over Buruganahalli; the copying evidence did not outweigh the strong obviousness showing.
RulingsRemand decision- RemandOther
“Scope on Remand On remand, the panel here will not address issues outside the scope of the Federal Circuit’s mandate. See Hayward Indus., Inc. v. Pentair Water Pool & Spa, Inc., 814 F. App’x 592, 597 (Fed. Cir. 2020) (“The Board is bound by the terms of a mandate issued by an appellate court. Aydin Corp. v. Widnall, 121 F.3d 726, 1997 WL 413329, at *3 (Fed. Cir. 1997). ‘Unless remanded by [an appellate] court, all issues within the scope of the appealed judgment are deemed incorporated within the mandate and thus are precluded from further adjudication.’ Engel Indus., Inc. v. Lockformer Co., 166 F.3d 1379, 1383 (Fed. Cir. 1999).”). The sole issue on remand is whether “the evidence of copying” is sufficient to overcome the obviousness ground of unpatentability over Buruganahalli. Centripetal Networks, 19–20. We restate portions of the former Final Written Decision, as an aid to the reader, but substantially incorporate the analysis of the prior Decision below. C.” slip op. at 4
- Director reviewDirector review, deniedDenied
“not object to a new panel of APJs hearing this case if remanded.” Id. at 20. As such, Patent Owner requested Director Review (Paper 74), asking that the Director “de-institute,” based on an abuse of discretion. The Director (Paper 75) denied the request and directed the Board to assign a new panel on remand (see Papers 76, 77). B.” slip op. at 3
- Skill levelOther
“Level of Ordinary Skill in The Art We adopt the level of ordinary skill in the art adopted in the prior Decision. See Decision 25. F.” slip op. at 13
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“This argument is unpersuasive because Buruganahalli uses rules/policies to filter encrypted packets by correlating them with handshaking packets that have unencrypted data, in the same way that is done in the ‘856 Patent. The only “filtering step” in the patent that “use[s] rules to filter encrypted packets without decryption” (PO Resp. 20) is the hello message approach used, for example, at steps 19 and 23 (see id.), which is clearly disclosed in Buruganahalli.7 As explained above, the ‘856 Patent does not describe applying rules to encrypted packets. Instead, it describes (a) filtering encrypted packets by correlating them with unencrypted data in other packets and (b) by decrypting the packets and applying the rules that are recited in the claims to unencrypted data. As also explained above, the amendment added the rules of step 22, which are applied to decrypted data, to a claim that was drafted to cover filtering of encrypted packets. However, among the criteria used in the filtering performed at step 22 is a “uniform resource identifier (URI),” which, we conclude, covers Buruganahalli’s “domain name.” Thus, despite the error made during prosecution, the claims that issued cover Buruganahalli’s method of determining that a session should be filtered based on a domain name in unencrypted handshake data.” slip op. at 28
Patent outcomesUS 9,917,856 unpatentable§ 103 obviousnessPatents in suitUS 9,917,856 - Palo Alto Networks, Inc. / Cisco Systems, Inc. et al. v. Centripetal Networks, Inc.All claims unpatentablePTAB · Jun 11, 2026 · IPR2022-00182 · APJ Kevin F Turner · IPR · Remand
On remand, claims 1, 24, and 25 are unpatentable under § 103 over Buruganahalli; the evidence of copying does not outweigh the strong obviousness showing.
RulingsRemand decision- RemandOther
“Scope on Remand On remand, the panel here will not address issues outside the scope of the Federal Circuit’s mandate. See Hayward Indus., Inc. v. Pentair Water Pool & Spa, Inc., 814 F. App’x 592, 597 (Fed. Cir. 2020) (“The Board is bound by the terms of a mandate issued by an appellate court. Aydin Corp. v. Widnall, 121 F.3d 726, 1997 WL 413329, at *3 (Fed. Cir. 1997). ‘Unless remanded by [an appellate] court, all issues within the scope of the appealed judgment are deemed incorporated within the mandate and thus are precluded from further adjudication.’ Engel Indus., Inc. v. Lockformer Co., 166 F.3d 1379, 1383 (Fed. Cir. 1999).”). The sole issue on remand is whether “the evidence of copying” is sufficient to overcome the obviousness ground of unpatentability over Buruganahalli. Centripetal Networks, 19–20. We restate portions of the former Final Written Decision, as an aid to the reader, but substantially incorporate the analysis of the prior Decision below. C.” slip op. at 4
- Obviousness (§103) › Objective indicia / secondary considerations › CopyingObjective indicia outweighedNot shown unpatentable
“given to the Eastern District of Virginia court’s opinion because it was later vacated. The district court considered all of the Read factors (applying Read Corp. v. Portec, Inc., 970 F.2d 816, 826-827 (Fed. Cir. 1992)), of which only the first factor is directed to deliberate copying, although factors 2 and 9 bear indirectly on the issue of copying. The district court determined that “[t]he fact that Cisco released products with Centripetal’s functionality within a year of these meetings goes beyond mere coincidence. Therefore, the fact that Cisco’s system mirrors the functionality of the Centripetal patents is compelling evidence that damages should be enhanced for copying.” Ex. 1027, 157. Without more, it is difficult to evaluate the processes that the district court employed to reach its determination. As the Federal Circuit instructed, we need “not [] go searching throughout the entire litigation record to find the evidence of copying, but [we have] an obligation to consider the specific evidence that was put before” us. Centripetal Networks, 19. We continue to determine that the vacated finding of the district court should be provided little weight, especially in view of the strong case of obviousness discussed above. Examination of Aaron Striegel We also do not find the Aaron Striegel’s testimony to be particularly persuasive. The testimony provides statements such as “I found evidence that it could be plausible,” “[s]o we can see the timeline is very plausible,” and “I found it very plausible that indeed that this technology could have made its way into these respective accused products.” Ex. 1029, 31:12–32:3. This testimony suggests the possibility of copying but does not demonstrate actual evidence of copying. At most, this testimony indicates that further consideration of the underlying evidence is warranted, but does little to support an ultimate finding of copying. Again, even taking this testimony as evidence of copying, it still must stand up against the strong case of obviousness discussed above.” slip op. at 40
- Obviousness (§103) › Objective indicia / secondary considerations › NexusObjective indicia no nexusDecided for petitioner
“The District Court did not provide an element-by-element analysis of how the claims of the ‘856 Patent cover this description. See Ex. 1027, 41. However, from the description, we understand the Court to have concluded that the system receives rules, identifies a set of packets as part of a flow using the NetFlow logs, “determines” that encrypted packets in the flow match known malicious signatures based on unencrypted data in other packets (e.g., data in the SNI), and then filters the flow based in a URI (e.g., that from the SNI), routing it to the null interface. The Court does not describe how the system “determines” that encrypted packets match known malicious signatures based on information in unencrypted packets, but we assume that is done as in the ‘856 Patent, by correlation, i.e., an encrypted packet is “determined” to match a threat indicator if it is in the same flow as a packet with unencrypted information that matches the threat indicator.10 With that understanding, we conclude that the allegedly infringing system operates, as least at the level described in the court’s decision, in the same way Buruganahalli’s system operates, filtering encrypted packets due to their presence in a flow that includes packets with unencrypted data, such as in a handshaking packet. It follows that Patent Owner is unable to establish a nexus, because “[w]here the offered secondary consideration actually results from something other than what is both claimed and novel in the claim, there is no nexus to the merits of the claimed invention.” Novartis AG v. Torrent Pharms. Ltd., 853 F.3d 1316, 1330” slip op. at 38
- Obviousness (§103) › Objective indicia / secondary considerations › Long-felt need / failure of othersDecided for petitioner
“need and industry recognition for the technology claimed in the ‘856 Patent because it describes the problem of detecting threats in encrypted traffic as ‘unsolvable.’” PO Resp. 68 (citing Ex. 1027, 64). Given that this is a press release by a company announcing that company’s new commercial product, however, we 8 The concurrence reevaluates Patent Owner’s evidence of industry praise and nexus, but we deem such considerations outside the remit of the Federal Circuit’s remand. are reluctant to give the “unsolvable” characterization much weight, as it may amount to puffery. But beyond that, it appears that the problem identified as “unsolvable” in the press release––“detect[ing] known attack signatures even in encrypted traffic”––had, in fact, already been solved in Buruganahalli, using the very same hello message, flow correlation, and man-in-the-middle techniques described in the ‘856 Patent. We thus cannot say that the press release identifies a long-felt need that was actually unsolved. See ZUP, 896 F.3d at 1374 (explaining that “[w]here the differences between the prior art and the claimed invention are . . . minimal . . . it cannot be said that any long-felt need was unsolved”) (quoting Geo. M. Martin Co. v. All. Mach. Sys. Int’l LLC, 618 F.3d 1294, 1304–05 (Fed. Cir. 2010) (first alteration in original)).” slip op. at 35
Patent outcomesUS 9,917,856 unpatentable§ 103 obviousnessPatents in suitUS 9,917,856 - Apple Inc. v. DH International Ltd.All claims unpatentablePTAB · Apr 16, 2026 · IPR2025-00172 · APJ Brian P Murphy · IPR · Final written decision
Claims 1–20 are unpatentable as obvious over Suga and Gorsuch; the Board denied Patent Owner’s motion to exclude.
RulingsFinal written decision- ExcludeMotion to exclude, deniedDenied
“Patent Owner also asserts prejudice for “not knowing” which Suga Exhibit “the Petitioner and Petitioner’s expert is relying on (see Exhibit 1021 and 1022),” without further explanation. Mot. Reply 6. Exhibit 1022 is a dictionary definition of “node.” How this relates to Patent Owner’s argument of prejudice is not explained. Id. at 5–6. The Board perceives no difficulty following Petitioner’s arguments and evidence, which cite Suga Exhibit 1005, including the testimony of Dr. Buehrer regarding the English language translation of Suga, which is identical in Exhibits 1005 and 1017. Patent Owner, moreover, opted not to depose Dr. Buehrer, did not file a deposition transcript of Dr. Buehrer in this proceeding, and does not allege any difference or substantive deficiency in the English language translation in Suga Exhibits 1005 and 1017, which are identical. We fail to see any prejudice to Patent Owner.” slip op. at 84
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“d. Conclusion for Claim 1 For the reasons given above, we determine the Petition establishes by” slip op. at 60
Patent outcomesUS 9,022,294 unpatentable§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,022,294 - Google LLC v. DH International Ltd.All claims unpatentablePTAB · Feb 10, 2026 · IPR2024-01322 · APJ Brian P Murphy · IPR · Final written decision
Claims 1–20 are unpatentable as obvious over Mooney; the Board also found Mooney combined with Lee renders the disputed limitations obvious.
RulingsFinal written decision- Skill levelSkill level board ownDecided for petitioner
“A person of ordinary skill in the art (“POSITA”) at the time of the alleged invention of the ’294 patent would have had at least a bachelor’s degree in electrical engineering, or a related field, and at least two years of experience in design, development, and/or testing of network-enabled consumer devices, and familiarity with payment cards, or the equivalent, with additional education substituting for experience and vice versa. Pet. 2 (citing Lipoff Decl. Ex. 1003 ¶ 57). “Patent Owner agrees with the Petitioner on the level of ordinary skill in the art.” Resp. 4. Patent Owner adds that a POSITA would have had “at least three years of relevant industry or research experience in wireless communication between devices.” Id. (citing Ex. 2001 ¶¶ 26–29). Mr. Zaheer testifies that a POSITA “would” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“The claim language and specification define and describe an “activation cue” in functional terms: a data communication from an external source is received by the cell phone and recognized as an activation cue if it causes the switching element to be assigned its first (activated) state. Ex. 1001, 9:28–31, 9:42–46, 10:14–16, 13:55–60, 14:53–59, 15:4–6, 19:20–26. Patent Owner agrees that “upon an activation cue being received by portable electronic device 10, switching element 44b switches to its activated state.” Resp. 19 (quoting Ex. 1001, 10:14–16). The activation cue may be a predetermined bit sequence, a predetermined contactless data transmission, continuously emitted, pulsed, or punctual, but these are unclaimed non-limiting embodiments of the preferred form of data transmission. Id. at 9:25–26 (“for example a predetermined bit sequence”), 11:20–22 (“One example . . . emit an activation cue in the form of a predetermined contactless data transmission”), 14:65–15:3 (continuously emitted, pulsed or punctual cue). We will not read such preferred embodiments from the specification into claim language that is not so limited. See SuperGuide Corp. v. DirecTV Enterprises, Inc., 358 F.3d 870, 875 (Fed. Cir. 2004) (care should be taken “not to import into a claim limitations that are not part of the claim”); see also In re Van Geuns, 988 F.2d 1181, 1184 (Fed. Cir. 1993) (“limitations are not to be read into the claims from the specification”); see also IQRIS Techns. LLC v. Point Blank Enterprises, Inc., 2025 WL 727717, *4 (Fed. Cir. 2025) (“It is the claims, not the preferred embodiments, that” slip op. at 15
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) does not applyDecided for petitioner
“operatively linked to said electronic circuit” under 35 U.S.C. Section 112, sixth paragraph or not, the result is the same. We note there is no presumption of applying means-plus-function analysis to the switching element, because the limitation does not use the words “means for” that would mandate such claim construction treatment, and “switching” may invoke structure as well as function. See Williamson v. Citrix Online, LLC, 792 F.3d 1339, 1349–1350 (Fed. Cir. 2015) (en banc) (holding that “use of the word ‘means’ creates a presumption that § 112, ¶ 6 applies”). Regardless, we look to the meaning of the claim phrase at issue in view of the specification. We determine that the ’294 patent provides a clear, concise meaning for the switching element upon which both parties rely for construction. Patent Owner’s express agreement with Petitioner, that the claimed switching element is described in the ’294 patent as “any type of device allowing data to be conveyed according to alternate data conveyance operations in response to an activation cue being received by transceiver 18 or not,’” is particularly telling because it is not consistent with Patent Owner’s argument that the switching element means “switching of the data.” Resp. 7, 31 (citing Ex. 1001, 9:28–318). The claim language does not recite, and the specification does not describe, the switching element as a device that switches the data. Therefore, we determine the claimed “data conveyance switching element” means any type of switching device that allows data to be 8 We presume Patent Owner’s citation to “Exh. 2001, 9:28-31” on page 7 was intended to be a citation to the ’294 patent (Ex. 1001), as cited on page 31. whether or not an “activation cue” is received by the cell phone “cue receiver.”” slip op. at 21
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Plain and ordinary meaningDecided for petitioner
“[external] data exchange device” as a device with a data transceiver coupled to a circuit that carries out the function of exchanging data. Pet. 7–8 (citing Ex. 1001, 2:14–17, 4:7–14, 9:3–6; Ex. 1003 ¶¶ 67–68). As above, whether we construe the “[external] data exchange device” under 35 U.S.C. Section 112, sixth paragraph or not, the result is the same. Patent Owner, quoting the description of a data exchange device in the ’294 patent, contends that a “[external] data exchange device” “can be any sort of data exchange device comprising an electronic circuit (not shown) therein and a data transceiver 9a.” Resp. 8 (quoting Ex. 1001, 9:4–6). Patent Owner also responds to the Petition by clarifying that “[a]n external data exchange device is not a transceiver but a device with a transceiver.” Id. (citing Ex. 2001 ¶ 48). Petitioner argues in reply that Patent Owner does not contest Petitioner’s mappings of Mooney’s “cordless telephone base unit” or “cellular network infrastructure” to the claimed data exchange devices, such that no construction is necessary to resolve the dispute. Reply 5 (citing Resp. 16–37; Wellman, Inc. v. Eastman Chem. Co., 642 F.3d 1355, 1361 (Fed. Cir. 2011)). Limitations [1.c] and [1.d] recite “a first [second] data transceiver operatively linked to said electronic circuit [in the cell phone],” both of which are defined functionally as “for exchanging data between said electronic circuit [in the cell phone] and a first [second] external data exchange device over a first [second] communication link.” Nothing in the the other independent claims, further limits the form or function of the “[external] data exchange device,” although a device external to the cell phone may invoke additional structure. We determine the plain meaning of “[external] data exchange device” as claimed and described in the ’294 patent governs: any [external] device that comprises an electronic circuit and data transceiver for exchanging data with the electronic circuit in the cell phone over a communication link. slip op. at 22
Patent outcomesUS 9,022,294 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,022,294 - Google LLC v. Metarail, Inc.Rehearing deniedPTAB · Aug 25, 2025 · IPR2024-01270 · APJ Frances L Ippolito · IPR · Rehearing
The Board denied Google’s rehearing request, leaving in place the denial of institution because the Petition did not show a reasonable likelihood that Belanger-Halevy teaches limitation [1C] of claims 1–26.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. ANALYSIS A request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, a reply or sur-reply.” 37 C.F.R. § 42.71(d). The party challenging a decision bears the burden of showing the decision should be modified. Id. We address Petitioner’s rehearing arguments below.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“[m]issing, however, from Halevy’s disclosure is any teaching or suggestion that a ‘plurality of computer-readable field identifiers’ are mapped ‘to one another’ as required by claim 1.” Dec. 22. We discussed and quoted extensively from Petitioner’s expert declaration of Dr. Fox and Patent Owner’s expert declaration of Dr. Malek. Id. at 22–26 (citing Ex. 1003 ¶ 104; Ex. 2001 ¶¶ 69, 71). In reviewing the parties’ submissions, we found that: Halevy’s disclosures are consistent with Patent Owner’s arguments and Dr. Malek’s testimony that Halevy does not teach mapping fields to one another or mapping of fields to one another through SO-properties. For example, as described, in Figure 6 and Halevy as a whole, Halevy does not teach or suggest mapping or linking different keywords to one another, rather the keywords are mapped to SO-properties. slip op. at 5
- Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner
“Dr. Fox states that “Halevy’s disclosure of a form database in which corresponding fields from different forms on different websites map to the same SO-properties would have been recognized by a POSA as what the ’378 patent refers to as a universal variable map.” Ex. 1003 ¶ 108 (citing Ex. 1001, 17:42–46). Based on this conclusory opinion, Dr. Fox reasons that Halevy’s form database is a “universal variable map” that must also link computer-readable field identifiers (including parameter names) from multiple different websites to each other in the form database, because the field identifiers are mapped to the same SO-properties associated with an SO-class. Id. We observe first that Dr. Fox’s conclusion is not supported by the cited portions of the ’378 patent. In column 17, lines 42–46, the ’378 patent explains that fields or variables may be part of forms and variations of these data fields or variables “may include a source form, a destination form, a single source to many destination form, many sources to one destination form, cascading forms (e.g., a first form links to a second form which links to a third form, etc.) and so on.” Ex. 1001, 17:42–46. While this portion of the ’378 patent indicates that forms may include variations on fields or variables, it does not describe any linking or mapping of variables to one another. Ex. 2001 ¶ 76 (“[T]hat portion of the specification does not have anything to do with the definition of a “universal variable map.” Rather, it merely discusses different types of variables and fields that might appear in different types of forms.”). Dec. 28–29. We again referred to the disclosure of the ’378 patent to address evidence in the Petition relied upon by Dr. Fox to support Petitioner’s position. Id. We credited Dr. Malek’s testimony over Dr. Fox’s testimony because Dr. Malek underlined the distinctions between the asserted Belanger-Halevy prior art combination and limitation [1C]. Dec. 28–31. In short, any confusion applying the prior art Belanger-Halevy references to the claim limitation is rooted in the Petition. The Board denied the Petition because the Petition did not demonstrate a reasonable likelihood of showing that Belanger-Halevy discloses or teaches limitation [1C] of the ’378 patent.” slip op. at 5
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner
“Finally, with regard to the Reply and Sur-Reply submitted by the parties (Req. 9), we note that our Decision on Institution reviewed the parties’ discussion of claim construction, but ultimately determined that “[b]ased on our review of the preliminary record, we do not need to construe any terms expressly to reach our decision.” Dec. 11. Thus, we disagree with Petitioner that we misconstrued the mapping limitation where we did not find it necessary to construe any claim term for the purposes of our institution decision because we determined the Petition deficient for failing to meet our threshold requirements as discussed above and in detail in the Decision on Institution. See Req. 1–11.” slip op. at 7
Claim constructionPatents in suitUS 9,633,378 - PTAB · Jun 18, 2025 · IPR2025-00321 · APJ Christopher M Kaiser · IPR · Institution
The Board instituted IPR on claims 1, 2, 5–7, 9, 16, and 17, finding a reasonable likelihood that claim 1 is anticipated by Boyer.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“approximately two weeks before the statutory deadline for a final written decision, but the most recent median time-to-trial statistics for Judge Gilstrap in the Eastern District of Texas indicate that the actual trial date will likely be in July 2026, which is later than the statutory deadline to issue a final written decision in this proceeding in mid-June 2026. See Ex. 2001, 7 (median time from filing to trial of 23.2 months); Prelim. Resp. 10. Thus, we find this factor is neutral or weighs slightly against discretionary denial.” slip op. at 10
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“At this preliminary stage, we determine whether the information presented shows a reasonable likelihood that Petitioner would prevail in establishing that at least one of the challenged claims would have been unpatentable over the proposed prior art. We analyze the asserted grounds with the above-noted principles in mind.” slip op. at 7
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art “would have had (1) at least a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a related field, and (2) at least two years of research or industry experience in 3D printing or materials used for 3D printing.” Pet. 5 (citing Ex. 1003 ¶¶ 14–16). Petitioner also argues that “[a]dditional experience could substitute for a formal degree or formal training (and vice versa).” Id. Patent Owner proposes a slightly different level of skill, arguing that a person of ordinary skill in the art “would have had a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a comparable field and at least two years of experience related to 3D printing, with additional experience potentially being a substitute for a formal degree or training (and vice versa).” Prelim. Resp. 24. Neither party explains why the outcome of this case would be affected by the adoption of any of the proffered definitions of a person of ordinary skill in the art. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as it appears to be consistent with the ’713 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 16
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction needed
“We note that, as discussed below, we are able to determine whether to institute inter partes review of the ’713 patent without expressly construing the term “from multiple print heads or deposition lines.” See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). As for Patent Owner’s argument that Petitioner has failed to carry its burden to identify how the claims are to be construed, we disagree on the present record. Although Petitioner does not provide a preferred construction for the single term it proposes requires construction, Petitioner does identify which of its two alternative constructions applies to each of its asserted grounds of unpatentability. Pet. 6 (“Under the first construction, [the obviousness grounds] are applicable, and [the anticipation ground] would be excluded from the claim scope. Under the alternative construction, all of [the asserted grounds] are applicable.”). In our view, this approach does not fail to satisfy Petitioner’s burden under 37 U.S.C. § 42.104(b)(3).” slip op. at 17
Claim construction§ 102 anticipationDiscretionary denialcites PhillipsPatents in suitUS 9,421,713 - Njoy, LLC / Njoy Holdings, Inc. v. Juul Labs, Inc.No claims unpatentablePTAB · Jun 10, 2025 · IPR2024-00231 · APJ Avelyn M Ross · IPR · Final written decision
Claims 14–16, 18, 27–29, 31, and 32 were not proven unpatentable because the asserted references failed to establish the claimed airflow path or a reason to make the proposed combinations.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner’s and Patent Owner’s proposed levels of skill are similar and differ in that Petitioner’s relevant degrees and corresponding two years of experience additionally includes “industrial design” and “product design” and familiarity with “electrically powered vaporizing articles, their components or the underlying technologies” where Patent Owner requires two years of experience “designing electro-mechanical consumer products or an advanced degree.” Compare Pet. 7, with PO Resp. 2. Patent Owner alleges that “Petitioner has failed to establish unpatentability under either standard,” indicating that the level of skill in the art is not a dispositive issue. PO Resp. 3. In light of the record before us, we adopt Petitioner’s proposal regarding the level of ordinary skill in the art. Based on our review of the ’123 patent and the prior art of record, we determine that the definition offered by Petitioner comports with the qualifications a person would have needed to understand the ’123 patent and the prior art. We note that the outcome of this Decision would be the same under Patent Owner’s proposed definition.” slip op. at 11
- Expert testimonyPetitioner expert creditedOther
“In this case, Mr. McAlexander meets both Petitioner’s and Patent Owner’s proposed level of skill in the art. As a result, we are persuaded Mr. McAlexander has the requisite skill and relevant expertise to offer testimony in this matter. For example, Mr. McAlexander has a Bachelor’s Degree in Electrical Engineering and far more than 2 years of experience in the electrical engineering field. Ex. 1027, 3–6, 7. In addition, Mr. McAlexander has provided expert consulting services in a wide range of technology areas involving the process and design of electro-mechanical consumer products. Ex. 1003 ¶ 5. Through one of Mr. McAlexander’s business ventures, his laboratory has “performed detailed airflow analyses, designing and constructing specialized apparatuses to emulate human breath, allowing for precise activation testing of ENDS devices.” Ex. 1043 ¶ 16. That said, a declarant’s expertise, even clothed as a skilled artisan, does not entitle a naked opinion persuasive weight. Ashland Oil, Inc. v. Delta Resins & Refractories, Inc., 776 F.2d 281, 294 (Fed. Cir. 1985). Here, Patent Owner had the opportunity to, and in fact did, thoroughly cross examine Mr. McAlexander about the purported deficiencies in his testimony. See, e.g., Exs. 2052, 2054; Daubert v. Merrell Dow Pharm., Inc., 509 U.S. 579, 595 (1993) (“Vigorous cross examination [and] presentation of contrary evidence . . . are the traditional and appropriate means of attacking shaky but admissible evidence.”). Therefore, to the extent Patent Owner credibly identifies deficiencies in Mr. McAlexander’s testimony or that testimony lacks factual support or is based on broad, conclusory assertions, we will assign appropriate weight. See Velander v. Garner, 348 F.3d 1359, 1371 (Fed. Cir. 2003) (explaining that it is within the Board’s discretion, as the trier of fact, to accord appropriate weight to the evidence presented).” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Petitioner contends that the parties proposed a construction for “pressure valve,” a limitation appearing in claims 18 and 31, during the ITC investigation. Pet. 7 (citing Ex. 1001, 41:58–65). Patent Owner contends that the terms of the ’123 patent should be given their plain and ordinary meaning. PO Resp. 4. Because resolution of the issues presented in this case do not require construction of the term “pressure valve,” we do not expressly construe this claim term. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (holding that “only those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy”); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs. in the context of an inter partes review).” slip op. at 14
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“We agree with Patent Owner. To anticipate a claim, a reference “must not only disclose all elements of the claim within the four corners of the document, but must also disclose those elements ‘arranged as in the claim.’” Net MoneyIN, 545 F.3d at 1369. “The requirement that the prior art elements themselves be arranged as in the claim means that the claims cannot be treated . . . as mere catalogs of separate parts, in disregard of the part-to-part relationships set forth in the claims.” Therasense, Inc. v. Becton, Dickinson & Co., 593 F.3d 1325, 1332 (Fed. Cir. 2010). Indeed, the prior art reference “must clearly and unequivocally disclose the claimed [invention] or direct those skilled in the art to the [invention] without any need for picking, choosing, and combining various disclosures not directly related to each other by the teachings of the cited reference.” Net MoneyIN, 545 F.3d at 1371 (citation omitted). “[D]ifferences between the prior art reference and the claimed invention, however slight, invoke the question of obviousness, not anticipation.” Id.” slip op. at 20
Patent outcomesUS 10,130,123 not shown unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,130,123 - Juul Labs, Inc. v. Njoy, LLCNo claims unpatentablePTAB · May 21, 2025 · IPR2024-00161 · APJ Christopher M Kaiser · IPR · Final written decision
Claims 1–27 were not shown unpatentable because the asserted obviousness grounds failed to establish the claimed central airflow passageway or a reason to combine the references.
RulingsFinal written decision- Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner
“Relying on the testimony of Patent Owner’s declarant Dr. Singhose, Petitioner argues that a person of ordinary skill in the art “would have known a central straight path has less airflow resistance than a circuitous one.” Reply 22–23 (citing Ex. 1035, 127:15–128:9). But the same witness also testified that higher airflow resistance might be desirable and explained that providing more resistance to airflow might result in improved mixing. Ex. 1035, 21:21–22:12, 127:20–24, 170:10–14. In addition, Dr. Singhose testifies that the complicated design of the airflow passageway in Xia “serves important functions,” including “allow[ing] large droplets to be reabsorbed by the liquid-guiding mechanism,” allowing “excessive liquid in the airflow [to] condense,” and “prevent[ing] the chemical liquid from being sucked into the mouth.” Ex. 2022 ¶ 183 (citing Ex. 1004, 11, 13–14, 16). Although Petitioner’s declarant Dr. Sturges testifies that a straight airflow passageway “would provide improved, smoother air flow,” he does not provide any evidence supporting the view that the air flow would be improved. Ex. 1007 ¶ 118. We credit the testimony of Dr. Singhose that using a straight passageway in Xia would have been detrimental rather than beneficial. Ex. 2022 ¶ 183. Petitioner also argues that the inventors’ use of a straight path is evidence that the use of a straight passageway was “merely common-sense obviousness.” Reply 22–23. This is hindsight. Otsuka Pharm. Co. v. Sandoz, Inc., 678 F.3d 1280, 1296 (Fed. Cir. 2012) (“The inventor’s own path itself never leads to a conclusion of obviousness; that is hindsight.”). Moreover, it does not address the testimony of Dr. Singhose that the use of a complicated passageway like that in Xia had benefits not present in a straight central passageway.” slip op. at 29
- Skill levelSkill level petitioner adoptedOther
“B. Level of Ordinary Skill in the Art Petitioner contends that a person of ordinary skill in the art (“POSITA”) “would have had a mechanical or electrical engineering degree, industrial design degree, or a similar technical degree, or equivalent work experience, and 5 to 10 years of experience in electromechanical devices.” Pet. 10 (citing Ex. 1007 ¶ 16). Prior to institution, Patent Owner stated that, for “the limited purpose of this Preliminary Response,” it “does not challenge the definition of a POSITA set forth in the Petition.” Prelim. Resp. 9. We adopted Petitioner’s proposed definition in our Decision granting institution. During trial, neither party disputed this definition. Upon a complete record, we see no reason to change the adopted definition.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“Patent Owner argues, however, that this presumption is overcome in the present case, and we agree. PO Resp. 28–32. We note that, although the claims require the first aperture to be “on the first end,” the claims still require that the “housing hav[e] a first aperture.” Thus, the issue is whether the aperture must be on the housing itself or part of the housing, as well as whether the aperture is on the first end of the housing. Although “having” and “includes” are used with respect to the solution holding medium to refer to elements located inside the housing, the specification of the ’881 patent suggests that the ends of the housing are part of the housing itself, rather than located inside the housing. First, “the first end . . . can be integrated into a single assembly as part of the housing.” Ex. 1001, 6:16–17. Second, “the housing . . . may comprise the cylindrical wall and two end-caps,” or “the housing . . . may comprise the cartridge wall and a single end-cap.” Id. at 3:55–59. The only figures of the ’881 patent that depict first end 206 show it at the end of the housing rather than located within the interior of housing 202. Id. at Figs. 2, 3. Moreover, there is no requirement to construe a claim term uniformly across multiple uses in the claims when doing so would be nonsensical. Microprocessor Enhancement Corp. v. Texas Instruments, Inc., 520 F.3d 1367, 1375 (Fed. Cir. 2008). Here, construing a first element that is recited as “having” or “includ[ing]” a second element always as encompassing not only second elements that are part of the first element, but also second elements that are located within the interior of the first element, would lead to nonsensical results. Claim 2 recites an airflow passageway “having a length having a circular cross section.” Ex. 1001, 17:59–60. It would be nonsensical to interpret this claim as encompassing an airflow passageway of non-circular cross section that contains another object that has a circular cross section, and neither party argues in favor of such a reading. Similarly, claim 16 recites an “airflow passageway having an interior having a uniform cross-sectional area,” and there is no reason to interpret this claim as encompassing an airflow passageway of non-uniform cross-sectional area that contains another object that itself has uniform cross-sectional area. Id. at 19:47–48. Thus, the claims do not use “having” or “includes” consistently to refer to elements located within the interior of an object; instead, they sometimes use these terms to refer to elements that are a part of an object. See Epcon Gas Sys., Inc. v. Bauer Compressors, Inc., 279 F.3d 1022, 1030–31 (Fed. Cir. 2002) (terms should be construed based on the context of how the terms are used in the claims).” slip op. at 13
- Prior constructionPrior construction not adoptedDecided for patent owner
“When we instituted trial, we preliminarily construed this phrase to encompass apertures that are located within the first end of the housing, determining on the record available at that time that “[t]he term does not require that the first aperture be located in the housing itself.” Inst. Dec. 16. We invited the parties to “address [the] construction of this term during trial,” id., and, on the full record developed during trial, we reach a different conclusion.” slip op. at 10
Patent outcomesUS 10,334,881 not shown unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,334,881 - Motorola Solutions, Inc. v. Stellar, LLCInstitutedPTAB · Mar 18, 2025 · IPR2024-01284 · APJ Nabeel U Khan · IPR · Institution
The Board instituted inter partes review of claims 1–19 on all asserted grounds, finding a reasonable likelihood that at least one challenged claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Per Board practice, if the Board institutes trial, it will institute “on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” See 37 C.F.R. § 42.108(a). Having considered the arguments and evidence presented by Petitioner and Patent Owner, we determine that Petitioner has demonstrated a reasonable likelihood of prevailing on at least one of the challenged claims of the ’540 patent. We exercise our discretion to institute inter partes review and, as required, we do so as to all the challenged claims of the ’540 patent on all the grounds of unpatentability set forth in the Petition.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“issued an order temporarily staying all deadlines and hearings scheduled in the matter.6 Ex. 1058, 1–2. The District Court’s order notes that Patent Owner asserts 8 patents in the litigation, that IPRs have been instituted on 4 of those patents covering 10 of the 14 claims asserted in the litigation, and that further consideration of a stay will depend upon whether IPRs are instituted on patents including the 4 remaining claims. Id. at 1, 3. The District Court also ordered the parties to update their positions on a stay within one week of a decision on institution. It is unclear if, and when, a new trial date would be set. In light of this stay, we determine that this factor weighs strongly against discretionary denial. 2.” slip op. at 9
- Skill levelSkill level petitioner adoptedDecided for petitioner
“or undergraduate training in an equivalent field and at least two years of relevant experience in electronics technology.” Ex. 1051 ¶ 30. Dr. Sarhan further opines that “[a]dditional graduate education could substitute for professional experience, and significant work experience could substitute for formal education.” Id. Patent Owner does not contest Petitioner’s proposed level of ordinary skill. See generally Prelim. Resp. For purposes of this Decision, we adopt Petitioner’s proposed level of ordinary skill, which is supported by Dr. Sarhan’s testimony, except that we find that the phrase “at least” in Petitioner’s proposed definition creates a vague, open-ended upper bound for the level of ordinary skill, and we therefore do not adopt that aspect of the proposal.” slip op. at 15
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Having reviewed the parties’ arguments we determine, as explained further below in our analysis of claim 1 (§ III.D.4.a), that an express construction of the term “file” is not necessary at this stage of the proceeding. A final determination as to claim construction will be made at the close of the proceeding, after any hearing, based on all the evidence of record. The parties are expected to assert all their claim construction arguments and evidence in the Petition, Patent Owner’s Response, Petitioner’s Reply, Patent Owner’s Sur-reply, or otherwise during trial, as permitted by our rules.” slip op. at 17
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,310,540 - PTAB · Feb 27, 2025 · IPR2024-01228 · APJ Kimberly Mcgraw · IPR · Institution
The Board instituted IPR on all challenged claims and all asserted grounds after finding a reasonable likelihood that claim 1 is unpatentable over Fukui.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“c) Conclusion Petitioner shows a reasonable likelihood that it would prevail in showing that claim 1 is unpatentable over Fukui. Accordingly, we institute inter partes review of all challenged calms based on all grounds asserted in the Petition. See SAS, 138 S.Ct. at 1354.” slip op. at 25
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDenied
“III. DISCRETION TO DENY INSTITUTION UNDER 35 U.S.C. § 325(d) Patent Owner argues that if the Board determines that Petitioner’s Fukui-based grounds 1 and 2 are deficient, then the Board should deny institution under § 325(d). Prelim. Resp. 26. In particular, Patent Owner asserts that remaining grounds 3 through 5 rely on art (i.e., Sauter) a reference that is substantially similar to art that was before the Examiner (i.e., Sedor). Id. at 26–27. Because we do not determine that Fukui-based grounds are deficient, we decline to exercise our discretion to deny institution under § 325(d).” slip op. at 31
- Skill levelSkill level petitioner adoptedDecided for petitioner
“time it was made, we consider the level of ordinary skill in the pertinent art at the time of the invention. Graham, 383 U.S. at 17. Petitioner contends that a person of ordinary skill in the art (“POSITA”) “would have a B.S. degree or equivalent in mechanical or electrical engineering or similar fields, in addition to a minimum of two years of professional experience with or graduate studies involving design, development, and/or utilization of optical communication systems.” Pet. 26. (citing Ex. 1003 ¶¶ 19–21). At this stage of the proceeding, Patent Owner neither responds to Petitioner’s proposed definition, nor provides a definition of its own. See Prelim. Resp. Petitioner’s undisputed proposed definition appears to be consistent with the cited prior art and the disclosure of the ’422 patent, and we adopt it for purposes of this Decision.” slip op. at 10
- Claim Construction › Intrinsic evidence (Phillips canons) › Prosecution history disclaimer / disavowalTerm construed petitioner constructionDecided for petitioner
“Based on the present record, we agree with Petitioner that Patent Owner’s statements during prosecution are relevant to claim construction. Pet. 24–25. During prosecution of the parent application to the ’422 patent, Patent Owner stated, inter alia, that “a person of ordinary skill in the art would understand that the width of a cassette is simply the width of the cassettes from side to side and not some other ‘dimension’ such as the number of receptables or the like.” Ex. 1002, 187. Patent Owner further stated that it disagreed with the Examiner’s statement that paragraph 15 of the specification6 defines width in terms of the number of receptacles and that such a definition of width makes no sense in view of other claims where the standard with is defined in terms of a width of front edge of a tray on which the cassettes are secured. Id. We note that at this stage of the proceeding, Patent Owner has not provided any argument or evidence opposing Petitioner’s proposed construction or supporting the claim construction that it proposed during the district litigation. Our construction is preliminary and the parties are invited to address this claim construction more fully during trial.” slip op. at 13
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,656,422
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.