• Apple Inc. v. RJ Technology LLCSome claims unpatentable
  PTAB · Feb 18, 2025 · IPR2023-01350 · APJ Jon B Tornquist · IPR · Final written decision

  Claims 5–10 are unpatentable as obvious; claims 11–14 were not shown unpatentable because the evidence did not establish the claimed capacity retention after 400 cycles.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends a person of ordinary skill in the art “would have held a Bachelor’s degree in chemistry or chemical engineering, with at least 4 years of experience in cell design, electrochemical techniques, and battery materials development.” Pet. 4. Petitioner further contends that a “Master’s Degree can substitute[] for some of the relevant experience,” and “[e]quivalent training with battery specific experience can accommodate other degreed fields.” Id. 9 The parties here do not address objective evidence of nonobviousness. Patent Owner does not dispute Petitioner’s definition of the ordinarily skilled artisan. PO Resp. 20. We adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the ’641 patent, the prior art of record, and the parties’ arguments.” slip op. at 6

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “The parties agree that the term “charge cut-off voltage” is “the maximum voltage to which the battery is configured to be charged.” PO Resp 21–22; Pet. Reply 1. The parties dispute, however, whether the “charge cut-off voltage” is a “battery property” or “the voltage applied to the battery during charging.” PO Resp. 21–24; Pet. Reply 1–6. We need not resolve the precise meaning of “charge cut-off voltage” because there is no dispute that Yamaki discloses this limitation under either party’s interpretation of the claim term. Upon review of the prior art and the parties’ arguments, we determine that no terms of the ’641 patent require express construction. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))); Pet. Reply 1 (asserting that the challenged claims are unpatentable under either parties’ construction of “charge cut-off voltage”).” slip op. at 7

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successUnpatentableMotivation foundUnpatentable

    “Patent Owner’s arguments do not persuasively undermine Petitioner’s position. Sakamoto expressly discloses setting the ratio of negative to positive electrode active material in the range of 1.05 to 1.30. Ex. 1005 ¶ 8. Sakamoto also explains why this range is preferable, i.e., if the ratio is roughly equal “the charge-discharge cycle performance is insufficient due to significant deterioration from charging and discharging,” and if the ratio is 10 Citations to the prosecution history of Yamaki are to the page numbers added to the lower right corner of the document. too high “too much of the compound does not participate in charging and discharging.” Id. ¶¶ 6, 8. These disclosures are sufficient to explain why one of ordinary skill in the art would have found it obvious to select the ratios disclosed in Sakamoto in Yamaki. Id. ¶ 8 (providing a secondary battery with a capacity ratio between 1.05 and 1.30 and noting that by setting the ratio within this range the resulting secondary lithium battery is “safe due to low risk of heat being generated and an explosion occurring”). We also disagree that Sakamoto teaches away from elevated voltages or from increasing the amount of lithium in circulation. See PO Resp. 29. Contrary to Patent Owner’s arguments, Sakamoto provides no general teaching against using a charge cut-off voltage above 4.2 V, or against increasing the level of lithium in circulation. Nor does Sakamoto “criticize, discredit, or otherwise discourage” the claimed invention. In re Fulton, 391 F.3d 1195, 1201 (Fed. Cir. 2004). Rather, Sakamoto warns against setting the reversible capacities of the positive and negative electrode substantially equal as this may result in excess lithium plating on the surface of the electrode. Ex. 1005 ¶¶ 6, 8. We agree with Petitioner that this disclosure would lead one of ordinary skill in the art to design a battery with a higher capacity in the negative electrode active material than the positive electrode active material. Pet. 11–12.” slip op. at 14

  • Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundDecided for petitioner

    “We also disagree that Sakamoto teaches away from elevated voltages or from increasing the amount of lithium in circulation. See PO Resp. 29. Contrary to Patent Owner’s arguments, Sakamoto provides no general teaching against using a charge cut-off voltage above 4.2 V, or against increasing the level of lithium in circulation. Nor does Sakamoto “criticize, discredit, or otherwise discourage” the claimed invention. In re Fulton, 391 F.3d 1195, 1201 (Fed. Cir. 2004). Rather, Sakamoto warns against setting the reversible capacities of the positive and negative electrode substantially equal as this may result in excess lithium plating on the surface of the electrode. Ex. 1005 ¶¶ 6, 8. We agree with Petitioner that this disclosure would lead one of ordinary skill in the art to design a battery with a higher capacity in the negative electrode active material than the positive electrode active material. Pet. 11–12.” slip op. at 15

  Patent outcomesUS 7,749,641 mixed
  Claim construction§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 7,749,641
• Samsung Electronics Co., Ltd. / Apple Inc. v. RJ Technology LLCSome claims unpatentable
  PTAB · Jan 17, 2025 · IPR2024-00597 · APJ Jon B Tornquist · IPR · Final written decision

  Claims 2–4 and 6–18 are unpatentable as obvious over Abe and Guyomard, with claims 9–10 also obvious over Iwaizono; claims 1 and 5 were not shown unpatentable.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person of ordinary skill in the art “would have had a Master’s degree in material science, chemical engineering, chemistry, or similar field with four years of experience designing testing, and building secondary lithium batteries.” Pet. 11 (citing Ex. 1002 ¶ 51). Petitioner further contends that a person of ordinary skill in the art would have been aware of “(1) positive electrode materials, (2) negative electrode materials, (3) separators, (4) electrolytes, (5) charge-discharge parameters, and (6) protection circuits, as well as ‘battery failure modes’ such as plating and the formation of dendrites.” Id. (citing Ex. 1002 ¶¶ 50–51). Patent Owner “does not dispute Petitioner’s level of ordinary skill.” PO Resp. 17. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the disclosures of the ’641 patent and the prior art of record.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner

    “We also agree with Patent Owner that the charge cut-off voltage is not necessarily the applied voltage during charging. PO Resp. 20. Rather, depending on the charging protocol used and when in the charging cycle the voltage is applied, the applied voltage could be higher than the battery voltage. Ex. 2013; Ex. 2006 ¶ 91. For example, as discussed in more detail below with respect to the Uemura grounds, when fast charging using constant current is used and the charging rate is not slow, the applied voltage will be higher than the battery voltage when the constant current charging phase is stopped. Ex. 2006 ¶ 91; Ex. 2013. Likewise, during constant current/constant voltage charging, the applied voltage approximates the battery voltage only when the battery is nearly completely charged. Ex. 2013; Ex. 2006 ¶ 91. Thus, the applied voltage may be, but is not necessarily, the charge cut-off voltage. In view of the foregoing, we construe “charge cut-off voltage” in claims 1 and 5 as “the maximum value to which the battery is configured to be charged.” PO Resp. 18; Ex. 2008, 217:6–11; Pet. Reply 5. Contrary to Patent Owner’s arguments, however, we do not understand the phrase “configured to be charged” to necessarily represent a single voltage for the battery that is determined based on the structure and chemistry of the battery. Pet. Reply 4–5. Rather, the charge cut-off voltage is a selected potential, or voltage, of the battery or cell at the end of charging that is controlled by a circuit or device, such as a charger or control circuit within the battery. Ex. 1001, 9:50–55; Ex. 1048, 2, 7–8; Ex. 1008, 3:9–13. And, for the reasons discussed herein, the charge cut-off voltage may be, but is not necessarily, the same as the applied voltage during charging. PO Resp. 20.” slip op. at 15

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “charge cut-off voltage “greater than 4.2 V but less than 5.8 V” and calculating a specific or theoretic capacity “with a charge cut-off voltage limited to 4.2” (claim 1) or “with a charge cut-off voltage set at 4.2 V” (claim 5). Ex. 1001, 16:56–61, 17:6–11. Although the parties dispute the precise scope of these claim terms, the parties agree that the first use of “charge cut-off voltage” in claims 1 and 5 refers to the potential of the battery as a whole (between the cathode and the anode), and not a half-cell voltage using lithium metal as a counter electrode.10 Tr. 17:1–3 (agreeing 10 With respect to the phrase “as calculated by a theoretic capacity with a charge cut-off voltage set at 4.2 V,” the parties in fact appear to be in that the first use of “charge cut-off voltage” in claim 5 refers to a full-cell voltage); Sur-reply 5; PO Resp. 22. We need not further construe the claims to resolve the disputes between the parties. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 16

  • Expert testimonyPatent owner expert creditedDecided for patent owner

    “Given Mr. Juzkow’s unambiguous testimony that Uemura uses constant current charging that would stop when the applied voltage reached 11 The chart is reproduced from SAFT, Charging your lithium-ion batteries: 5 expert tips for a longer lifespan, (https://www.saft.com/energizing-iot/charging-your-lithium-ion-batteries-5-expert-tips-longerlifespan#:~: text=When%20the%20battery%20provides%20current,This%20restore s%20the%20battery's%20capacity). 4.3 V, as well as Dr. Yao’s persuasive testimony that Uemura’s constant charging rate is not slow, we credit the testimony of Dr. Yao that one of ordinary skill in the art would have understood that the internal voltage to which the battery of Uemura was charged is less than 4.3 V. Ex. 2006 ¶ 119. In particular, Dr. Yao persuasively testifies that one of ordinary skill in the art would have believed that the charge cut-off voltage was no more than 4.2 V, and most likely equal to “about 4 V.” Id. ¶¶ 119–122.” slip op. at 21

  Patent outcomesUS 7,749,641 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 7,749,641
• Samsung Electronics Co., Ltd. / Apple Inc. v. RJ Technology LLCSome claims unpatentable
  PTAB · Jan 17, 2025 · IPR2023-01183 · APJ Jon B Tornquist · IPR · Final written decision

  Claims 2–4 and 6–18 are unpatentable as obvious over Abe and Guyomard, with claims 9 and 10 also obvious over Iwaizono; claims 1 and 5 were not shown unpatentable.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person of ordinary skill in the art “would have had a Master’s degree in material science, chemical engineering, chemistry, or similar field with four years of experience designing testing, and building secondary lithium batteries.” Pet. 11 (citing Ex. 1002 ¶ 51). Petitioner further contends that a person of ordinary skill in the art would have been aware of “(1) positive electrode materials, (2) negative electrode materials, (3) separators, (4) electrolytes, (5) charge-discharge parameters, and (6) protection circuits, as well as ‘battery failure modes’ such as plating and the formation of dendrites.” Id. (citing Ex. 1002 ¶¶ 50–51). Patent Owner “does not dispute Petitioner’s level of ordinary skill.” PO Resp. 17. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the disclosures of the ’641 patent and the prior art of record.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner

    “constructions. First, we agree with Petitioner that the ’641 patent indicates that the charge cut-off voltage selected for a particular battery need not be a fixed property of the battery or something that is set by the design and chemistry of the battery. Consistent with this conclusion, the ’641 patent discloses that a “charging device controls the charge cut-off voltage of the single lithium-ion cell within a range from 4.3 V to 5.8 V.” Ex. 1001, 9:50– 55. This strongly suggests that the charge cut-off voltage is controlled by the charger and is not necessarily an inherent property of the battery. Patent Owner contends that this is merely an unclaimed embodiment, but the relevant disclosure states that the charging device for the “present invention” may be any type of device “with the proviso that said charging device controls the charge cut-off voltage.” Id. at 9:50–53.” slip op. at 12

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “charge cut-off voltage “greater than 4.2 V but less than 5.8 V” and calculating a specific or theoretic capacity “with a charge cut-off voltage limited to 4.2” (claim 1) or “with a charge cut-off voltage set at 4.2 V” (claim 5). Ex. 1001, 16:56–61, 17:6–11. Although the parties dispute the precise scope of these claim terms, the parties agree that the first use of “charge cut-off voltage” in claims 1 and 5 refers to the potential of the battery as a whole (between the cathode and the anode), and not a half-cell voltage using lithium metal as a counter electrode.10 Tr. 17:1–3 (agreeing 10 With respect to the phrase “as calculated by a theoretic capacity with a charge cut-off voltage set at 4.2 V,” the parties in fact appear to be in that the first use of “charge cut-off voltage” in claim 5 refers to a full-cell voltage); Sur-reply 5; PO Resp. 22. We need not further construe the claims to resolve the disputes between the parties. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 16

  • Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner

    “Given Mr. Juzkow’s unambiguous testimony that Uemura uses constant current charging that would stop when the applied voltage reached 11 The chart is reproduced from SAFT, Charging your lithium-ion batteries: 5 expert tips for a longer lifespan, (https://www.saft.com/energizing-iot/charging-your-lithium-ion-batteries-5-expert-tips-longerlifespan#:~: text=When%20the%20battery%20provides%20current,This%20restore s%20the%20battery's%20capacity). 4.3 V, as well as Dr. Yao’s persuasive testimony that Uemura’s constant charging rate is not slow, we credit the testimony of Dr. Yao that one of ordinary skill in the art would have understood that the internal voltage to which the battery of Uemura was charged is less than 4.3 V. Ex. 2006 ¶ 119. In particular, Dr. Yao persuasively testifies that one of ordinary skill in the art would have believed that the charge cut-off voltage was no more than 4.2 V, and most likely equal to “about 4 V.” Id. ¶¶ 119–122. Petitioner argues that because the battery of Uemura is charged “to” a maximum voltage of 4.3 V, Uemura discloses the claimed charge cut-off voltage under either Petitioner’s or Patent Owner’s construction of the term. Pet. Reply 11–12 (citing Ex. 1009 ¶ 81; Ex. 1044 ¶¶ 56–59). This argument is not persuasive because Mr. Juzkow unambiguously testified that charging in Uemura stopped when the applied voltage reached 4.3 V, and Uemura discloses that the battery was charged “at” a voltage ranging from 4.3 V to 2.0 V, not “to” such a voltage. Ex. 1009 ¶ 81; Ex. 2008, 113:2–13; Ex. 2006 ¶ 119 n.64; Sur-reply 9. In view of the foregoing, we determine that Petitioner has not demonstrated by a preponderance of the evidence that Uemura anticipates independent claims 1 and 5 of the ’641 patent.” slip op. at 21

  Patent outcomesUS 7,749,641 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 7,749,641
• Chongqing Yanmei Technology Co., Ltd. v. Terves, LLCSome claims unpatentable
  PTAB · Aug 27, 2024 · IPR2023-00521 · APJ Jon B Tornquist · IPR · Final written decision

  Claims 19–61, 63–77, and 79 are unpatentable as anticipated by Doud; claims 78, 80, and 81 are not shown unpatentable. The contingent motion to amend is granted in part and denied in part.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person of ordinary skill in the art “would have at least a Ph.D. in chemistry, metallurgy, or material science or material engineering” or, in the alternative, “would have a Bachelor of Science or Master of Science degree in one of these disciplines plus experience involving the use and design of dissolvable metal alloys for use in creating tools and other downhole parts for well drilling or completion activities.” Pet. 13–14. Patent Owner does not oppose Petitioner’s contentions regarding the level of ordinary skill in the art. PO Resp. 12 n.4. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the ordinarily skilled artisan as it is consistent with the prior art of record.” slip op. at 7

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner

    “With respect to claim 19, Petitioner proposes constructions for the terms “in situ precipitate” and “a plurality of particles of said in situ precipitate having a size of no more than 50 µm.” Pet. 11–12. With respect to claims 76–81, Petitioner proposes a construction for the term “wherein said additive material includes one or more metal materials selected from the group consisting of 0.1–35 wt. % copper, 0.1–24.5 wt. % nickel and 0.1–20 wt. % cobalt.” Id. at 13. Patent Owner contends no claims require construction for purposes of this Decision. PO Resp. 12 n.4, 17–18; Mot. 16–17. Upon review of the prior art of record, we determine that no claim terms require express construction for purposes of this Final Written Decision. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 8

  • Disclosure Requirements (§112) › Written description (Ariad)Written description inadequateWritten description adequateMixed

    “Ex. 2027, 20:25–21:5 (emphasis added). The disclosure that the “magnesium composite” of “[t]he present invention” “includes at least 50 wt% magnesium” is unambiguous and constitutes strong evidence that the inventors were not in possession of a magnesium composite with less than 50 wt. % magnesium, or additive concentrations above 50 wt. %. See SciMed Life Systems, Inc. v. Advanced Cardiovasular Systems, Inc., 242 F.3d 1337, 1343 (Fed. Cir. 2001) (noting that a description of the “present invention” as having a particular structure “is strong evidence that the claims should not be read to encompass the opposite structure”). Consistent with this conclusion, the original claims of the ’295 application all limited the additive material in the composite to 0.05 wt %–45 wt %. Ex. 2027, 26:1– 13, 29:9–15. Likewise, in each example where copper, nickel, or cobalt additives are used in the range recited in the proposed substitute claims, the magnesium composite is “over 50 wt% magnesium,” and any claims that do not require this range of magnesium are limited to an additive range of “about 0.05 wt%–45 wt% of said mixture.”8 Ex. 2027, 6:13–7:4, 7:16–19, 8 Written description support is considered from the view point of the ordinarily skilled artisan. Ariad Pharms., Inc. v. Eli Lilly and Co., 598 F.3d 1336, 1351 (Fed. Cir. 2010) (en banc). Patent Owner, bearing the burden to show written description support in any priority application for which it seeks the benefit of its filing date, provides no testimony from an ordinarily skilled artisan regarding written description support in the ’295 application, or any evidence to show what such an artisan would conclude from the express disclosures of the ’295 application. Lectrosonics, Paper 15 at 7; In re NTP, 654 F.3d 1268, 1276 (Fed. Cir. 2011) (noting that “a patent’s claims are not entitled to an earlier priority date merely because the patentee claims priority . . . Rather, for a patent’s claims to be entitled to an earlier priority date, the patentee must demonstrate that the claims meet the requirements of 35 U.S.C. § 120”). Where there is any ambiguity in the disclosures of the ’295 application, the absence of supporting testimony tends to cut against 26:2–31:2; see Ex. 1005 ¶¶ 12, 13, 18, 19, 16–21, 26, 28, claims 16–21, 26– 28. In view of the foregoing, we are not persuaded that Patent Owner has demonstrated that the inventors of the priority applications were in possession of a magnesium cast composite that included less than 50 wt. % magnesium, or greater than 50 wt. % additives. As proposed substitute claim 104 encompasses a magnesium cast composite with up to 90 wt. % additives, and therefore as little as 10 wt. % magnesium, Patent Owner has not demonstrated that the full scope of this claim finds written description support in any application prior to the ’915 application, filed on October 12, 2018.” slip op. at 17

  • Disclosure Requirements (§112) › Definiteness (Nautilus)DefiniteIndefiniteMixed

    “The definiteness requirement of § 112(a) is satisfied when “a patent’s claims, viewed in light of the specification and prosecution history, inform those skilled in the art about the scope of the invention with reasonable clarity.” Nautilus, Inc. v. Biosig Instruments, Inc., 572 U.S. 898, 910 (2014); see 37 C.F.R. § 42.100(b) (changing the claim construction standard used to review a claim proposed in a motion to amend from the broadest reasonable construction to the “same construction standard that would be used to construe the claim in a civil action under 35 U.S.C. [§] 282(b)”). Proposed substitute claim 104 generically requires “in situ precipitate” and also a specific type of in situ precipitate: “in situ galvanically-active intermetallic precipitate.” Mot. Appendix A. Although this claim would have best been clarified by Patent Owner after seeking preliminary guidance on its Motion to Amend, upon review of the written description, claims, and figures of the ’740 patent, as well as Patent Owner’s clarification in its Reply to the Opposition, we agree with Patent Owner that one of ordinary skill in the art would have understood that the “in situ galvanically-active intermetallic precipitate” is merely a more complete description of the “in situ precipitate” mentioned earlier in the sentence. Mot. Reply 4. As such, we do not find that this part of proposed substitute claim renders claim 104 indefinite.” slip op. at 22

  Patent outcomesUS 10,689,740 mixed
  Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites Graham · Nautilus
  Patents in suitUS 10,689,740
• Unified Patents, LLC v. VL Collective IP LLCSome claims unpatentable
  PTAB · Dec 18, 2023 · IPR2022-01086 · APJ Patrick M Boucher · IPR · Final written decision

  Claims 1, 3, 5, 9, 12, 13, and 15 are unpatentable over Sonohara; claims 20 and 21 were not shown unpatentable because Sonohara’s assignment rule is based on timestamps.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Patent Owner’s expert, Dr. Goodrich, proposes what Patent Owner characterizes as “a somewhat different level,” namely “an individual with at least a bachelor’s degree in Computer Science or related area and two years of experience developing software tools and/or computer systems for use in the area of audio or video creation, encoding, and/or distribution.” PO Resp. 13; Ex. 2007 ¶ 50. Although we agree that the respective articulations are “somewhat different,” they are generally similar, and our Decision does not depend on nuanced distinctions regarding the level of ordinary skill. Indeed, Dr. Goodrich describes his proposed articulation as “approximate,” such that “more work experience could compensate for less education or more education could compensate for less work experience.” Ex. 2007 ¶ 50. Because we find Petitioner’s proposal reasonable, consistent with the level of skill reflected by the prior art, and supported by Dr. Freedman’s testimony, we adopt it for this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the prior art may reflect an appropriate level of skill in the art). We nevertheless note that we would reach the same ultimate conclusion that claims 1, 3, 5, 9, 12, 13, and 15 (but not claims 20 and 21) have been shown to be unpatentable by a preponderance of the evidence were we to adopt Patent Owner’s proposal. See PO Resp. 13 (“this Response establishes that Petitioner’s arguments fail even under its preferred definition of the level of ordinary skill”).” slip op. at 12

  • Claim Construction › Intrinsic evidence (Phillips canons) › Preamble limiting or notNot reached

    “We need not resolve this dispute because we reach the same ultimate conclusion that Petitioner shows, by a preponderance of the evidence, that claims 1, 3, 5, 9, 12, 13, and 15 are unpatentable, but not that claims 20 and 21 are unpatentable, even if we apply Patent Owner’s proposed construction that the preambles are limiting and the first and second data files must be different. See Reply 15 (Petitioner asserting that “there is no need to construe the preambles as the prior art meets them even if construed”); Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). For purposes of this Decision, we accordingly treat the preambles of independent claims 1 and 9 as limiting, and with the recited “first data file” and “second data file” as distinct data files.4” slip op. at 14

  • Claim Construction › Intrinsic evidence (Phillips canons) › Lexicography (patentee as own lexicographer)Term construed board ownDecided for patent owner

    “We agree with Patent Owner’s contention that the emphasized sentence defines the term “content-related.” See PO Resp. 15–16 (Patent Owner arguing that “[t]here are thus three strong indications of lexicography: (1) ‘content-related’ is set off by quotation marks; (2) the patentee used the word ‘is’ to describe the term ‘content-related’; and (3) the patentee states what ‘content-related’ is ‘understood to mean.’” Nor does Petitioner disagree that the sentence is definitional. See Tr. 8:15–16 (referring to the “term content-related as it’s defined in the specification”). Indeed, in the Starz litigation, the district court also treated the sentence as definitional, a fact that we find significant as a matter of comity. See Ex. 1018, 111:24–112:1 (district court judge stating at Markman hearing, “I’m going to adopt . . . the express definition provided in the specification”). But like the district court, we discern insufficient reason to adopt the additional gloss that Patent Owner seeks to apply to the definition of “content-related.” That is, Patent Owner proposes that we additionally construe the phrase “syntactical meaning” within the definitional statement to arrive at Patent Owner’s proposed construction. PO Resp. 16–20. According to Patent Owner, “[t]he specification makes clear, through its use of consistent and repeated examples, that ‘syntactical meaning’ requires a specific relationship between the data segments within a data file: succeeding data segments within a data file must be ordered so as to present the content in its intended sequence when rendered.” Id. at 17 (citing VirnetX Inc. v. Cisco Sys., Inc., 767 F.3d 1308, 1317–19 (Fed. Cir. 2014); Alloc, Inc. v. ITC, 342 F.3d 1361, 1368–71 (Fed. Cir. 2003)). Patent Owner adds that the claims, the context provided by the problems solved by the ’794 patent, and the cross-examination testimony of Petitioner’s expert, Dr. Freedman, all support this additional aspect of Patent Owner’s proposed construction. Id. at 18–20. Relying on additional direct testimony by Dr. Freedman, Petitioner counters this position as “improperly import[ing] limitations from the specification that are not required by the claims” and “render[ing] other portions of claim 1 superfluous.” Reply 3 (citing Ex. 1016 ¶ 22); see Tr. 10:18–20 (Petitioner explaining at oral hearing that “the syntax information is simply just identification information which is used to find out what the order of the files is. But the identification information does not by itself indicate the order. It’s just an identifier.”). We agree with Petitioner that it would be imprudent to adopt Patent Owner’s additional gloss because, “[w]hile claims must be construed in light of the specification, . . . limitations from the specification are not to be read into the claims, . . . for ‘[i]t is the claims that measure the invention.’” Golight, Inc. v. Wal-Mart Stores, Inc., 355 F.3d 1327 (Fed. Cir. 2004) (quoting SRI Int’l v. Matsushita Elec. Corp. of Am., 775 F.2d 1107, 1121 (Fed. Cir. 1985) (other citations omitted). It is apparent that the Applicant for the ’794 patent understood how to define terminology recited in the claims, but chose to limit its definition of “content-related” in terms of the broader phrase “syntactical meaning” rather than through narrower specific reference to presentation order. In addition, claims 1 and 9 already specify “sequentially outputting the first and second data segments according to their chronological sequence,” which supports Petitioner’s observation that requiring an additional sequential order to “content-related . . . data segments” renders other portions of claim 1 superfluous. See Reply 3. We accordingly adopt the definitional construction provided by the” slip op. at 16

  • Claim Construction › Intrinsic evidence (Phillips canons) › Prosecution history disclaimer / disavowalDisclaimer not foundDecided for petitioner

    “As a basic principle of claim interpretation, prosecution disclaimer promotes the public notice function of the intrinsic evidence and protects the public’s reliance on definitive statements made during prosecution.” Omega Engineering, Inc. v. Raytek Corp., 334 F.3d 1314, 1323 (Fed Cir. 2003) (citing Digital Biometrics, Inc. v. Identix, Inc., 149 F.3d 1335, 1347 (Fed. Cir. 1998)) (emphasis added). As such, a statement during prosecution qualifies as a disavowal of claim scope only if it is “so clear as to show reasonable clarity and deliberateness” and “so unmistakable as to be unambiguous evidence of disclaimer.” Id. at 1325 (citations omitted). “Consequently, for prosecution disclaimer to attach, [Federal Circuit] precedent requires that the alleged disavowing actions or statements made during prosecution be both clear and unmistakable.” Id. at 1325–26. “The party seeking to invoke prosecution history disclaimer bears the burden of proving the existence of a clear and unmistakable disclaimer that would have been evident to one skilled in the art.” Mass. Inst. of Tech. v. Shire Pharms., Inc., 839 F.3d 1111, 1119 (Fed. Cir. 2016). And “[s]tatements by the patent owner are not considered in a vacuum; rather, the skilled artisan would look at the record as a whole in assessing claim scope.” Galderma Lab’s v. Amneal Pharma, 806 F. App’x 1007, 1010 (Fed. Cir. 2022) (citing Wang Labs., Inc. v. Toshiba Corp., 993 F.2d 858, 867 (Fed. Cir. 1993) (“The prosecution history must be examined as a whole in determining whether estoppel applies.”)). We have reviewed the prosecution history, which we summarize supra § I.A.3., and we have particularly reviewed those portions highlighted by Patent Owner. See PO Resp. 32–40. We reach the same conclusion as the district court in the Starz litigation that the standard for attachment of prosecution disclaimer is not met. See Ex. 1018, 109:15–22 (district court stating at Markman hearing, “I’ve also carefully reviewed the portions of the prosecution history relied on by VideoLabs, including the patentee’s arguments regarding the Shin and Rosenau references, and I’m up [sic: not6] persuaded there was a clear and unmistakable disclaimer of all assignment rules that perform assignments by using exact timing information”). slip op. at 20

  Patent outcomesUS 8,605,794 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,605,794
• ROKU, Inc. v. Universal Electronics, Inc.Some claims unpatentable
  PTAB · Nov 28, 2023 · IPR2022-00943 · APJ Sharon Fenick · IPR · Final written decision

  Claims 1–7, 9–13, 15, and 16 are unpatentable as obvious; claims 8 and 14 were not shown unpatentable.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner argues that: On or before 7/12/2017, [one of ordinary skill in the art] would have had a bachelor’s degree in computer science, in electrical engineering, or a related field, and approximately three years of experience or equivalent study in voice-controlled devices in smart home systems. Additional graduate education could 2 Neither party presents arguments or evidence relating to such objective evidence of nonobviousness. in the field could substitute for formal education. Pet. 18. We adopted this definition for the purposes of the Decision on Institution. Dec. on Inst. 8–9. Patent Owner adopts Petitioner’s definition. PO Resp. 4. We again adopt Petitioner’s definition, which is consistent with the level of skill as reflected in the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 8

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner

    “Absent a recitation of order, or an order mandated by grammar or logic, the steps of a method claim are not construed to require a particular order. See, e.g., Altiris, Inc. v. Symantec Corp., 318 F.3d 1363, 1369 (Fed. Cir. 2003). Patent Owner argues that the steps of claim 1, a method claim, must be performed in sequential order. PO Resp. 13–16. Without commenting on or conceding Patent Owner’s proposal, Petitioner contends that “the trial grounds meet this proposed construction.” Pet. Reply 24–25; Tr. 8:25–11:16. Our record does not reflect any indication that Patent Owner’s proposed construction requiring the sequential ordering of the method steps is not at least encompassed by the correct construction of claim 1. Because of this, and because Petitioner agrees that the arguments in the Petition meet this construction, we accept Patent Owner’s construction as correct for the purposes of this Decision.” slip op. at 10

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableNot shown unpatentableMixed

    “We do not agree with Patent Owner that Petitioner’s showing uses the same sound data to teach the “first sound data” of limitation 1.a and the “second sound data” of limitation 1.c. Patent Owner is correct that Rosenberg’s claim 5 describes the determination of a volume threshold based on the volume of the ambient audio signal in which characteristic form(s) (e.g., the name of the user of the media player) are present. Ex. 1006, 13:66–21, 14:28–30. However, the Petition describes using Fu’s “predetermined threshold” in combination with Hart-787’s device, which attenuates audio output of a device upon detecting a user’s utterance intended to gain the attention of the device, in order to “include adjusting the audio output volume of a wirelessly-linked audio-producing device when the voice-controlled device determines that the ambient noise level at the time a Ex. 1004, 2:22–37, 5:61–6:10, 9:18–25; Ex. 1005 ¶¶ 24, 32, 54; Ex. 1003 ¶¶ 88–89). Petitioner further proposes including a threshold that is advantageously based on the environment in which the device is operating as described in Fu, for example to respond to differing levels of noise at different times of day. Id. at 26, 29–30, 40 (citing Ex. 1006, 10:42–67, 14:28–30; Ex. 1003 ¶¶ 48–53, 55, 58, 87, 91, 107–109). We agree with Petitioner that Patent Owner’s arguments address the references individually instead of addressing the combination of the teachings proposed in the Petition. See Pet. Reply 8, 13–14; see also Dec. on Inst. 21–22, 23–24, 25–26. The Petition relies upon a combination of elements of Hart-787 with the predetermined threshold as taught in Fu and with establishing such a threshold based on the operating environment of a device as in Rosenberg. Pet. 26–31, 34–41. Patent Owner is correct that Rosenberg’s threshold is set at the time of the utterance in Rosenberg’s claim 5 and cites Petitioner’s declarant as “conceding” issues regarding how “Rosenberg’s volume threshold is determined.” PO Resp. 20–21. But this argument and the ostensible concession do not squarely address the proposed combination, which combines Fu’s teaching of an adjustment unit that “compares the volume of the ambient noise received . . . to a predetermined threshold” with Rosenberg’s teaching that such “a threshold may be ‘determined based on the volume of [an] ambient audio signal.’” Pet. 39, 40 (emphasis omitted) (quoting Ex. 1006, 14:28–30). While Patent Owner argues that “Petitioner has not proposed using a predetermined/pre-set threshold or a previously established threshold based on environmental noise in the combination of Hart-787 with F[u] and Rosenberg” (PO Resp. 46), we find, on the contrary, that the Petition describes a combination based predetermined threshold” and on a threshold “determined according to an environmental noise level.” Pet. 29–30. Thus, we find Petitioner’s unpatentability grounds do not suffer from the issues Patent Owner argues are a consequence of the purported use of the same sound data for the “first sound data” of claim limitation 1.a and for the “second sound data” of claim limitation 1.c. We do not agree with Patent Owner’s arguments regarding Fu’s teachings with respect to limitation 1.e’s “transition from a first state having a first volume level to a second state having a second volume level that is less than the first volume level” because these arguments similarly do not address the proposed combination. See PO Resp. 26–30. The Petition cites Hart-787 for attenuating the volume of an audio-producing device when a wake word is issued. Pet. 32–34, 43–44. The Petition cites Fu for adjusting volume of an audio-producing device if the level of ambient noise exceeds a predetermined threshold. Id. at 36–39, 44–45. Thus, even if Fu teaches only increasing the volume of an audio-producing device if the predetermined threshold is exceeded, the Petition relies on the combination of teachings of Hart-787 and Fu, and Patent Owner’s argument that neither reference teaches “decreasing a controllable appliance’s volume output when a previously established volume threshold is exceeded” (PO Resp. 30) does not address the combination proposed. Patent Owner’s argument that “Petitioner has not proposed modifying Fu to decrease a controllable appliance’s volume output when a volume threshold is exceeded” (PO Resp. 30) similarly does not address the combination proposed in the Petition. We also find that the preponderance of the evidence supports Petitioner’s showing regarding the motivation to combine the references.” slip op. at 23

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner

    “We also find that the preponderance of the evidence supports Petitioner’s showing regarding the motivation to combine the references. transmitted volume down control signals as the means for attenuating audio output, Petitioner contends that Hart-787 “broadly teaches” that a device transmits control command signals to the audio-producing device, relying on the testimony of its declarant. See Pet. 23 (citing Ex. 1004, 5:47–51; Ex. 1003 ¶ 82), 43–44 (citing Ex. 1004, 1:67–2:7, 2:26–27, 5:47–51; Ex. 1003 ¶ 118). In addition, Petitioner shows that these control signals were well-known in the art and would have been known to one of ordinary skill in the art at the time of the invention, supporting its showing with additional testimony from its declarant. Id. at 44 (citing Ex. 10183, 2:39–47, 5:35–38; Ex. 10194 ¶¶ 3, 13; Ex. 1003 ¶¶ 44–45, 118). We conclude Petitioner’s evidence regarding the showing in Hart-787 is sufficient with respect to this point. Hart-787 describes altering a signal sent to the speaker to attenuate the audio from that speaker. Ex. 1004, 1:67– 2:1. Petitioner’s declarant testifies that using transmitted control signals to do this would have been known to one of ordinary skill. Ex. 1003 ¶¶ 44–45, 82, 118. We consider Petitioner’s evidence regarding what one of ordinary skill in the art would have understood from Hart-787’s disclosure to be sufficient for the showing regarding the “causing one or more commands to be automatically issued to the controllable appliance to thereby cause” that appliance to transition to a lower volume level, as required in limitation 1.e. While Patent Owner argues that Petitioner’s declarant “concede[s] that Hart- 787 does not disclose or teach how its voice-controlled device decreases the audio output of the controllable appliance,” the cited portion of the” slip op. at 25

  Patent outcomesUS 10,930,276 mixed
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 10,930,276
• Universal Electronics, Inc. / Gemstar Technology (Qinzhou) Co. Ltd. et al. v. ROKU, Inc.Some claims unpatentable
  PTAB · Oct 23, 2023 · IPR2022-00818 · APJ Patrick M Boucher · IPR · Final written decision

  Claims 1–5, 8–10, and 14 are unpatentable over RadioShack; claim 11 was not shown unpatentable over Wouters and Verzulli because the combination did not disclose the claimed combining and installing steps.

  RulingsFinal written decision

  • Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication establishedDecided for petitioner

    “disseminated to the interested public, ‘public accessibility’ has been called the touch-stone in determining whether a reference constitutes a ‘printed publication’ . . . .” Jazz Pharm., Inc. v. Amneal Pharm., LLC, 895 F.3d 1347, 1356 (Fed. Cir. 2018) (quoting In re Hall, 781 F.2d 897, 898–99 (Fed. Cir. 1986)). A reference is considered “publicly accessible” if it was “disseminated or otherwise made available to the extent that persons interested and ordinarily skilled in the subject matter or art, exercising reasonable diligence, can locate it.” Id. at 1355–56 (citing In re Wyer, 655 F.2d 221, 226 (CCPA 1981)). Petitioner treats this requirement as having two aspects, namely (1) whether a person of ordinary skill could reasonably have found RemoteCentral.com and (2) whether such a skilled artisan could reasonably have found RadioShack on RemoteCentral.com. Reply 8–13; see also Tr. 33:25–34:8 (Patent Owner asserting that there are two aspects to the analysis on public accessibility: “The first is whether a [person of ordinary skill in the art] would have known to arrive at the website containing the prior art reference. The second one is . . . , [a]ssuming the [person of ordinary skill in the art] would have done so, would the [person of ordinary skill in the art], exercising reasonable diligence, have located the prior art reference on the site? And these are separate and distinct requirements, and if you fail one of them, the document is not publicly accessible.”).” slip op. at 27

  • Strike new argumentNew argument consideredDecided for petitioner

    “addressed squarely by the principles set forth in Hulu, which addresses the standards at the institution stage and during the trial for evaluating evidence proffered to show asserted art qualifies as a printed publication. Specifically, after a petitioner has presented “evidence sufficient to establish a reasonable likelihood that the reference was publicly accessible before the critical date of the challenged patent,” such that trial is instituted, “some limited opportunities exist for the petitioner to present new evidence later.” Hulu at 13–14. These “limited opportunities” include “in a reply to the patent owner response,” provided that the additional evidence is “responsive to the prior briefing” and provided that the additional evidence does not require “completely reopen[ing] the record, by, for example, changing theories after filing a petition.” Id. at 14–15. Although Patent Owner contends that “[t]his is not an example of permissible rebuttal evidence, but rather a belated attempt to fill a gap in the evidence in the Petition,” we disagree. See Sur-reply 6. Rather, the 7 Patent Owner appears to refer incorrectly to Exhibit 1040 instead of Exhibit 1041 when identifying “articles allegedly referring to RemoteCentral.com.” See Sur-reply 5–6. progression within the instant proceeding comports well with the Hulu framework. During the preliminary proceeding, Petitioner came forth with “evidence sufficient to establish a reasonable likelihood that [RadioShack] was publicly accessible before the critical date of the challenged patent,” just as Hulu demands. Hulu at 13; Inst. Dec. 23 (“[W]e determine that Petitioner’s showing regarding public accessibility of RadioShack is sufficient under the standard we apply at this stage of the proceeding.”). Patent Owner challenges RadioShack’s status as a printed publication in its Response, just as Hulu contemplates. Hulu at 15; PO Resp. 28–41. And Petitioner submits additional evidence that replies to that challenge without changing its theory that RadioShack qualifies as a printed publication by virtue of its accessibility on the RemoteCentral.com web site and in light of date indicia on RadioShack itself.8 See Hulu at 15–16; Reply 7–13. Moreover, in determining that Petitioner’s additional evidence directed at RemoteCentral.com is properly considered, we are further mindful of the Federal Circuit’s endorsement that “the petitioner in an inter partes review proceeding may introduce new evidence after the petition stage if the evidence is a legitimate reply to evidence introduced by the patent owner.” Anacor Pharm., Inc. v. Iancu, 889 F.3d 1372, 1830–81 (Fed. 8 In its Reply, Petitioner also relies on evidence of publication of RadioShack on Radio Shack’s own public website and on “a third location,” hifi-remote.com. Reply 14. As we discuss below, we determine that the presence of RadioShack on RemoteCentral.com is sufficient to qualify RadioShack as a printed publication. We therefore do not reach the issue of whether presence on either the Radio Shack web site or on hifi-remote.com is an improper new theory raised by Petitioner in its Reply. See Tr. 8:13– 9:23 (Petitioner discussing whether reliance on hifi-remote.com presents a different theory than set forth in the Petition). Cir. 2018); see also Vidstream LLC v. Twitter, Inc., 981 F.3d 1060, 1065 (Fed. Cir. 2020) (“The Board denied VidStream’s Motion to Exclude, holding that it was appropriate to permit Twitter to respond to VidStream’s challenge [to the status of Bradford as a printed publication] by providing additional evidence to establish the Bradford publication date. We conclude that the Board acted appropriately, for the Board permitted both sides to provide evidence concerning the reference date of the Bradford book, in pursuit of the correct answer.”). We accordingly give due weight to Petitioner’s additional evidence of RadioShack’s accessibility on the RemoteCentral.com web site.” slip op. at 25

  • ExcludeMotion to exclude, deniedDenied

    “1 Patent Owner objected to Petitioner’s demonstrative slides 45 and 68 as presenting a new argument that was not previously made with respect to challenged claims 2 and 10. Paper 27; see Paper 26 (Petitioner’s demonstratives), 45, 68. At the oral hearing, we reserved ruling on the objections. Tr. 5:23–6:3. Both slides reproduce the same portions of Exhibits 1002 and 1025, with the statement that “A press and hold for an auto-scan or brand-scan is admitted prior art.” Paper 26, 45, 68. As explained below, we do not reach the predicate position upon which the objections are based. See Tr. 5:8–11 (Petitioner stating that “this Board only needs to resolve this objection if it accepts Roku’s claim construction argument that the claims cover a press and hold of a single button, but that they do not cover pressing multiple buttons to present that argument in the alternative. So, if you reject that argument, you don’t even have to resolve the objection.”). We accordingly dismiss the objections as moot.” slip op. at 2

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “We agree with this assessment, and the parties do not specifically advocate for one articulation over the other in this proceeding. See Pet. 8 (Petitioner asserting that “[t]he Challenged Claims are unpatentable under both proposed levels”); PO Resp. 5 (Patent Owner stating its “position that the challenged claims are unpatentable under either proposed level of ordinary skill”). We adopt Patent Owner’s proposed statement of the level of ordinary skill as advanced in the related ITC Investigation. But we note that we would reach the same ultimate conclusion that Petitioner shows, by a preponderance of the evidence, that all challenged claims are unpatentable were we to adopt Petitioner’s proposal instead.” slip op. at 12

  Patent outcomesUS 8,378,875 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,378,875
• Samsung Electronics Co., Ltd. v. Lynk Labs, Inc.Some claims unpatentable
  PTAB · May 5, 2023 · IPR2022-00098 · APJ Arthur M Peslak · IPR · Final written decision

  Claims 1, 3, and 4 are unpatentable as obvious over the stated combinations; claim 2 was not shown unpatentable because the driver was not shown configured to receive the rectifier’s forward voltages.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “We agree with Patent Owner that a person of ordinary skill in the art would have had experience in LED devices. For this reason, we apply Patent Owner’s proposed level of ordinary skill in the art because it comports with the level of skill reflected in the ’149 patent and the prior art of record. However, if we were to apply Petitioner’s proposed level of skill, our Decision would not be affected.” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Upon review of the entire record, we determine that no claim terms require express construction. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (noting that “we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’”) (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 10

  • Expert testimonyPetitioner expert creditedPatent owner expert discountedMixed

    “Dr. Ducharme’s testimony that “the spacing of the chips in Zhang would not likely be so close as to create overheating issues” (Ex. 2002 ¶ 111) is unsupported by any disclosure of the actual spacing of Zhang’s chips. Consequently, his testimony that there would be no overheating concerns in Zhang due to the spacing of the chips is entitled to little, if any, weight. Dr. Ducharme further testifies that the components of Zhang’s driver “could easily increase the temperature of the LED 19 chips on the circuit board, which can cause LEDs to generate less illumination, burn out and otherwise adversely affect their performance.” Ex. 2002 ¶ 126. Dr. Ducharme further testifies that “[i]t is well-known that excessive operational temperatures can reduce the illumination provided by the LEDs, can decrease the operational lifetime of the LEDs, and if the temperature is sufficiently high, it can cause LED junction failure and a burnt-out LED.” Id. We agree with this testimony, which as discussed below, is consistent with Salam. Dr. Ducharme’s testimony concerning overheating issues caused by the driver components contradicts Patent Owner’s ’s contention that there would not be “an overheating issue with Zhang’s LED exit sign circuit in Figure 2.1.” PO Resp. 30. Regardless of whether Zhang’s LEDs in Figure 2.1 have a heat problem or not, Salam teaches the advantages of using a heat sink. Salam teaches that a heat sink will result in a higher efficiency of the LEDs and improved life. Ex. 1006, 16:38–43. The Federal Circuit, in DyStar Textilfarben GmBH & Co v. C.H. Patrick Co., 464 F.3d 1356 (Fed. Cir. 2006), stated that “the desire to enhance commercial opportunities by improving a product or process is universal–and even common-sensical . . . the proper question is whether the ordinary artisan possesses the knowledge and skills rendering him capable of combining the prior art references.” Id. at 1368. Dr. Ducharme testified that a person of ordinary skill in the art “would have an understanding of the generation of heat and using a heat sink to remove unwanted heat from electronics and LED lighting devices.” Ex. 1102, 23:18–24:3. Dr. Ducharme’s testimony is consistent with Petitioner’s contention that the combination of Zhang and Salam “would have been a straightforward combination of known components and technologies, according to known methods, to produce the predictable result of reducing/ mitigating heat effects in a circuit.” Pet. 17 (citing Ex. 1002 ¶ 106). Patent Owner next contends it would be extremely burdensome and costly to modify Zhang to add a heat sink layer because “each of the multiple chips mounted and epoxied to Zhang’s circuit board in the exit sign would have to be modified.” PO Resp. 30 (citing Ex. 2002 ¶ 112). Dr. Ducharme’s testimony repeats the Patent Owner Response verbatim and is entitled to little, if any, weight. Ex. 2002 ¶ 112. Nonetheless, this contention is unavailing because it is based on Patent Owner’s bodily incorporation of Zhang and Salam. Patent Owner next contends that a person of ordinary skill in the art” slip op. at 27

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundUnpatentable

    “Regardless of whether Zhang’s LEDs in Figure 2.1 have a heat problem or not, Salam teaches the advantages of using a heat sink. Salam teaches that a heat sink will result in a higher efficiency of the LEDs and improved life. Ex. 1006, 16:38–43. The Federal Circuit, in DyStar Textilfarben GmBH & Co v. C.H. Patrick Co., 464 F.3d 1356 (Fed. Cir. 2006), stated that “the desire to enhance commercial opportunities by improving a product or process is universal–and even common-sensical . . . the proper question is whether the ordinary artisan possesses the knowledge and skills rendering him capable of combining the prior art references.” Id. at 1368. Dr. Ducharme testified that a person of ordinary skill in the art “would have an understanding of the generation of heat and using a heat sink to remove unwanted heat from electronics and LED lighting devices.” Ex. 1102, 23:18–24:3. Dr. Ducharme’s testimony is consistent with Petitioner’s contention that the combination of Zhang and Salam “would have been a straightforward combination of known components and technologies, according to known methods, to produce the predictable result of reducing/ mitigating heat effects in a circuit.” Pet. 17 (citing Ex. 1002 ¶ 106).” slip op. at 27

  Patent outcomesUS 10,517,149 mixed
  Claim construction§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 10,517,149
• Home Depot USA, Inc. v. Lynk Labs, Inc.Some claims unpatentable
  PTAB · May 5, 2023 · IPR2022-00023 · APJ Arthur M Peslak · IPR · Final written decision

  Claims 1 and 4 are unpatentable over the stated § 103 combinations; Petitioner did not show claim 2 unpatentable because it did not explain how the LED array’s forward voltage is received by the driver.

  RulingsFinal written decision

  • Skill levelSkill level board ownOther

    “degree in electrical engineering, or similar technical field, with two years of experience in the field of design and/or development of light-emitting diodes (LEDs) and circuits in the context of lighting control systems.” Pet. 11–12 (citing Ex. 1002 ¶ 34). Petitioner further contends that “[a]n increase in experience could compensate for less education.” Id. at 12. Patent Owner proposes the same level of skill in the art. See PO Resp. 6. We apply the parties’ undisputed level of ordinary skill in the art because it comports with the level of skill reflected in the ’149 patent and the prior art of record.” slip op. at 8

  • Expert testimonyPetitioner expert creditedDecided for petitioner

    “We credit Dr. Lebby’s testimony over Dr. Ducharme for the following reasons. First, in Deese, power cable 28 is inserted into an opening in rubber housing 21. Ex. 1008, Fig. 2A. [R]ubber housing 21 forms a water-tight seal around the power cable 28.” Id. at 4:63–65. Dr. Ducharme does not explain why Hochstein’s protruding heat sink shell could not similarly be inserted through rubber housing 21 with a water-tight seal. Further, Dr. Lebby relies on the similarity between the structures of Deese and Hochstein. Hochstein uses gasket 45 and weather seal 48 to seal housing 10 with electrical lead 49 and heat sink shell 38 extending therethrough. Ex. 1010, 5: 39–40, 5:63:65, Fig. 8.” slip op. at 47

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed patent owner constructionOther

    “Our analysis starts with the claim language. Claim 1 recites “a driver, wherein the driver includes at least one transistor and at least one capacitor” and “the driver is configured to receive an AC voltage from a mains power source and provide a voltage and current to the at least one LED circuit.” Ex. 1001, 23:16–17, 26:22–24. Dr. Ducharme testifies that power is determined by multiplying voltage and current. Ex. 2008 ¶ 63. The language of claim 1, thus, supports Patent Owner’s construction which is also consistent with the dictionary definition offered by Petitioner which also defines “driver” as [a] program, circuit or device used to power or control other programs, circuits or devices.” Ex. 1007, 4 (emphasis added). The Specification provides “the driver providing an AC voltage and current to one or more LED circuits.” Ex. 1001, 3:65–67. Thus, the Specification also provides support for Patent Owner’s construction. For the foregoing reasons, we apply Patent Owner’s proposed construction of “driver” because it is consistent with the language of claim 1 and the description of driver in the Specification. We note that the adjective “LED” prior to circuits or devices in Patent Owner’s construction is not necessary because that it essentially repeats limitation 1.e.” slip op. at 12

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITADecided for petitioner

    “We begin with the claim language itself which is “the package is a heat sinking reflective material.” Ex. 1001, 23:18–19 (emphasis added). In its analysis, Patent Owner parses “heat sinking reflective material” out of context by omitting the italicized language “the package is” preceding “heat sinking reflective material.” PO Resp. 29. The deposition testimony of Dr. Lebby and Dr. Ducharme’s declaration testimony cited by Patent Owner are also out of context. The Specification of the ’149 patent defines “package” as an integrated unit that “in certain applications may preferably include a heat sink, a reflective material, a lens for directing light, phosphor nano-crystals or light changing or enhancing substances.” Ex. 1001, 5:30–33. Because heat sink and reflective material are listed separately in the Specification, this disclosure suggests that, at least in certain embodiments, a package with a heat sink separate from a reflective material would fall within the scope of limitation 1.c. This is further confirmed by comparing the packages illustrated in Figures 25 and 26 of the ’149 patent which are reproduced above. Figure 25 is described as illustrating “heat sinking material 198 . . . integrated into the package 30.” Id. at 17:34–35. Figure 26 is described as illustrating reflector 202 “integrated into the package 30 for optimized light dispersion.” Id. at 17:47–49. As can be seen from a visual comparison of Figures 25 and 26, reflector 202 is separate from heat sinking material 198. Given the disclosure in the ’149 patent of a package with a heat sink” slip op. at 15

  Patent outcomesUS 10,517,149 mixed
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 10,517,149
• Samsung Electronics Co., Ltd. v. Lynk Labs, Inc.Some claims unpatentable
  PTAB · Apr 19, 2023 · IPR2021-01576 · APJ Scott Raevsky · IPR · Final written decision

  Claims 1–12 are unpatentable as obvious; claims 13–18 are not shown unpatentable because the asserted combinations fail to teach or suggest multiple LED packages connected in series.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “PO Resp. 8 (citing Ex. 2001 ¶¶ 41–42). Patent Owner argues that its definition is superior because Petitioner’s “and/or” qualifier “might be read as considering a person who has ‘related circuit design’ experience but no experience with ‘LED devices’ to be a POSITA.” Id. at 9. Patent Owner further views Petitioner’s “or a related field” phrasing as potentially including a person who has no experience with LED devices. Id. We agree with Patent Owner on both points. We agree with Patent Owner that Patent Owner’s proposal is more consistent with the problems and solutions in the ’979 patent and prior art of record. We adopt Patent Owner’s definition of the level of skill but note that had we adopted Petitioner’s level of skill, we would not have reached a different outcome here.” slip op. at 6

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner

    “specification support its construction of “formed or mounted to” as encompassing indirect attachment to the substrate. Neither the plain claim language nor the specification requires the phosphor coating to be directly attached to the substrate. Limitation 1(c) recites, wherein the LED chips comprise a phosphor coating to produce a change in a color or a quality of light emitted from the LED chips, wherein the LED chips, the power connection leads, and the phosphor coating are formed or mounted to a flexible substrate that is sufficiently flexible to be formed into a cylindrical shape[.] Ex. 1001, 22:7–12 (emphasis added). The claim is inartfully written, as it requires the LEDs to comprise a phosphor coating but then separately recites that the LED chips and the phosphor coating are formed or mounted to the substrate. But Petitioner correctly explains that the plain meaning requires that “the LED chips comprise a phosphor coating” and that “the [same] phosphor coating” (included in the LED chips) is “formed or mounted to a flexible substrate.” Reply 2. In other words, the use of the term “the” before “phosphor coating” indicates reliance on the antecedent basis of “LED chips comprise a phosphor coating,” and thus the same coating of the LED chips is formed or mounted to the substrate. Logically, by including a phosphor coating with the LED chips, which are formed or mounted to the substrate, the coating of these chips is also indirectly formed or mounted to the substrate. Conversely, it would be illogical to conclude that the claim recites two phosphor coatings, one attached to the LED chips and another attached directly to the substrate, because the structure of the claim refers to a single phosphor coating of the LED chips. Even Patent Owner concedes that the claim encompasses the phosphor coating indirectly being mounted or attached to the substrate (in addition to being directly attached). PO Resp. 11 (“The ordinary English reading of the claim language does not encompass the phosphor coating only being indirectly attached to the substrate, instead, the language indicates that the coating is directly applied to the substrate.” (emphasis changed)), 13 (“the phosphor coating . . . is not merely attached to the substrate indirectly”).” slip op. at 10

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundUnpatentable

    “After considering Patent Owner’s arguments, which we address below, we agree with Petitioner that the combination of Wojnarowski and Martin discloses this limitation and that a person of ordinary skill in the art would have been motivated to combine the references’ teachings in the manner asserted by Petitioner. Briefly, we summarize our findings, and then we address the parties’ arguments in more detail. First, we agree with Petitioner, and Patent Owner does not dispute, that Wojnarowski’s AC input voltage would have been converted to DC voltage in light of the bridge rectifier and capacitor disclosed by Wojnarowski. Pet. 25; Ex. 1002 ¶¶ 119– 20 (citing, e.g., Ex. 1005, 7:59–62, Fig. 24); PO Resp. 35–36 (acknowledging Wojnarowski discloses converting an AC input to a DC voltage). Second, we further agree with Petitioner, and Patent Owner does not dispute, that excessive current due to too few LEDs would have harmed Wojnarowski’s LEDs, and too small a current due to too many LEDs would be insufficient to power Wojnarowski’s LEDs. Pet. 26; Ex. 1002 ¶ 134; PO Resp. 48 (discussing, but not disputing, these assertions).13 Third, we agree that a POSITA would have recognized in view of Martin’s teachings and the knowledge of a skilled artisan that when configuring Wojnarowski’s device, the total forward voltage drop of the series-connected LEDs should approximately match the DC voltage output 13 Petitioner explains the relationship between voltage and current for the LEDs as follows: “the total voltage drop of the circuit would dictate the current drawn by the LED circuitry, which would have been known to be inversely proportional to the voltage.” Pet. 26 (citing Ex. 1002 ¶ 134). of Wojnarowski’s circuit. Pet. 26–27 (citing Ex. 1002 ¶¶ 132–38; Ex. 1008, Abstract (LED voltage “must be matched to the input source voltage”), ¶ 60 (“For AC or any other regularly varying input voltage, there is an additional requirement to direct drive voltage matching”)). For example, Martin teaches that “[t]he number of LEDs in the monolithic array may be selected to achieve a particular voltage drop across each device.” Ex. 1006 ¶ 22. Martin further explains, “[t]he voltage across each of the individual LEDs in the array is the line voltage divided by the number of LEDs in series,” and “[t]he number of LEDs is chosen such that the maximum voltage across each individual LED during the peak in the alternating current cycle is low enough so as not to damage the LEDs.” Id. The forward voltage drop across Martin’s 38 LEDs is about 171 V, which matches Martin’s AC input voltage peak of about 169.71 V. See id. (“At 120 RMS volts, the peak voltage will be about 180V [correction: 169.71 V],” and if the LEDs “can tolerate a maximum forward voltage of 4.5V, at least 38 LEDs connected in series are required.” (38 LEDs x 4.5 V = 171 V)); PO Resp. 41–42 (“While Martin references ‘about 180V,’ both parties agree that the correct value of the peak voltage Vp is 169.71 V.” (citing Ex. 1002 ¶ 127)). Although Martin’s LED forward voltage drop (171 V) differs slightly from the peak input voltage (169.71 V), Patent Owner conceded at the hearing that the claimed “matches” does not require an exact equivalence. Tr. 38:9–11 (“Patent Owner agrees . . . that matching has a meaning that goes beyond exact equivalence.”).14” slip op. at 22

  • Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication establishedDecided for petitioner

    “35 U.S.C. § 311(b). PO Resp. 22–25. This statute provides that “[a] petitioner in an inter partes review may request to cancel as unpatentable 1 or more claims of a patent only on a ground that could be raised under section 102 or 103 and only on the basis of prior art consisting of patents or printed publications.” § 311(b) (emphasis added). Patent Owner contends that Martin is not available as prior art under 35 U.S.C. § 311(b) because it is not a patent or printed publication and is only prior art under 35 U.S.C. § 102(e). PO Resp. 22. Patent Owner argues that documents are “printed publications” as of the date they become available to the public, and Martin became public on its publication date of October 21, 2004, after the February 25, 2004 priority date of the ’979 patent. Id. at 23. Patent Owner raises a similar argument for the Soules-II reference in Ground 6. Id. at 25– 26. Petitioner responds that the AIA framework permits the use of § 102(e) prior art in IPR proceedings, unlike formerly available covered business method review (CBM) proceedings, which restricted challenges to § 102(a) prior art. Reply 29. We agree. The statute governing the formerlyavailable CBM proceeding explicitly limits challenges based on “prior art that is described by section 102(a).” AIA § 18(a)(1)(C). In contrast, § 311(b) more broadly permits challenges “on the basis of prior art consisting of patents or printed publications.” The broader language in § 311(b) implies that unlike CBMs, IPRs are not limited to challenges solely under § 102(a) prior art. The parties cite to no Federal Circuit decisions that squarely address this issue. However, the Federal Circuit has applied § 102(e) patent application publication prior art in appeals from IPR proceedings. See, e.g., Purdue Pharma L.P. v. Iancu, 767 Fed. App’x 918, 920–21, 926 (Fed. Cir. 2019) (nonprecedential) (determining that a § 102(e) patent application publication was available as prior art in an IPR). The Board has also long permitted challenges based on patent application publications under § 102(e). See, e.g., Idle Free Sys., Inc. v. Bergstrom, Inc., IPR2012-00027, Paper 14 at 27 (PTAB Jan. 31, 2013) (instituting trial over § 102(e) ground based on a patent application publication). We therefore find Patent Owner’s § 311(b) argument unpersuasive.” slip op. at 34

  Patent outcomesUS 10,652,979 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 10,652,979

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.