- PTAB · Dec 17, 2025 · IPR2025-01023 · APJ Benjamin D M Wood · IPR · Institution
The Board instituted IPR on all asserted grounds against claims 1, 3, 7, and 9, finding a reasonable likelihood that Petitioner would prevail on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“c. Conclusion as to Claim 1 Having reviewed the record and the parties’ arguments, we determine that Petitioner has a reasonable likelihood of prevailing with respect to claim 1, and therefore has satisfied the threshold requirement for institution of inter partes review on the basis of Ground 1. 3. Claims 3, 7, and 9 Petitioner contends that Bassompiere teaches the limitations of claim 3, 7, and 9, and supports its contentions with citations to Bassompiere and to Dr. Sharrafzadeh’s declaration. Pet. 57–63. At this stage of the proceeding, Patent Owner does not raise any arguments specifically directed to these claims. “When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” 37 C.F.R. § 42.108(a). We must “either (1) institute as to all claims challenged in the petition and on all grounds in the petition, or (2) institute on no claims and deny institution.” CTPG at 5–6, 64; see also PGS Geophysical AS v. Iancu, 891 F.3d 1354, 1359–60 (Fed. Cir. 2018) (stating a decision to institute is “a simple yes-orno institution choice respecting a petition, embracing all challenges included in the petition”). Thus, because we have decided to grant institution on Ground 1 with respect to claim 1, we must do the same for claims 3, 7, and 9.” slip op. at 38
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner does not offer any reason why we should deviate from the Board’s determinations in the prior IPRs that one of ordinary skill in the art would have had knowledge of Kalman filters and quaternion mathematics. Nor are we aware of any such reason. On the contrary, the Board’s prior determinations are consistent with the level of ordinary skill reflected by prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978). Bassompiere, for example, teaches using a data merging algorithm that is, “[a]dvantageously,” extended Kalman filtering. Ex. 1006, 4:17. Bassompiere also teaches using quaternions to determine a device’s pitch and roll about a horizontal reference frame. Id. at 6:3–8, 20:10–21:1. Nasiri teaches that quaternions can be used to represent a device’s “orientation in space.” Ex. 1008, 30:27– 30. Patent Owner argues that Dr. Sarrafzadeh’s testimony regarding the level of skill in the art in this proceeding contradicts his testimony in the prior IPRs, which did not include knowledge of Kalman filters and quaternion mathematics in his definition of the level of ordinary skill in the art. Prelim. Resp. 24–26. Patent Owner asserts that this contradiction “undermin[es] his credibility.” Id. at 26. We disagree. The testimony Dr. Sarrafzadeh provided in the earlier IPRs obviously preceded the Board’s determinations in those proceedings that, on the whole record, including the testimony of then-Patent Owner’s declarant, the level of ordinary skill included knowledge of Kalman Filters and quaternions. Dr. Sarrafzadeh’s testimony in this proceeding reasonably aligns with those determinations. Accordingly, for the above reasons, we adopt Petitioner’s definition of the level of ordinary skill in the art for purposes of this Decision.” slip op. at 13
- Expert testimonyPetitioner expert creditedDecided for petitioner
“We disagree with Patent Owner’s characterization. The teaching to use quaternions instead of Euler angles comes from Bassompiere, not Dr. Sarrafzadeh. See Ex. 1006, 20:10–11 (“A first variant embodiment consists in replacing the angles of torsion θ and ψ by a quaternion formulation of the same torsion.”). Rather than supplying a missing limitation, we understand Dr. Sarrafzadeh to be explaining how a person of ordinary skill in the art would have implemented Bassompiere’s teaching to use quaternions instead of Euler angles given that person’s knowledge of quaternion mathematics. Patent Owner also argues that “switching from Euler angles to quaternions is not a routine substitution but requires the reengineering of the EKF.” Prelim. Resp. 28. Patent Owner similarly contends that Dr. Sarrafzadeh “devotes nearly twenty pages of his declaration to rewriting Bassompiere’s Euler-based equations ‘in quaternion form,’ and explaining how to convert them back to Euler angles,” and notes that “[a]s other researchers in the field have confirmed, ‘[w]hile implementing orientation tracking using quaternions provides advantages like avoiding gimbal lock, it is significantly more complex than the Kalman filer using Euler angles.’” Prelim. Resp. 32–33 (citing Ex. 1002, 31–51; quoting Ex. 2027, 1). Patent Owner thus contends that replacing Euler angles with quaternions “is not a ‘trivial’ substitution.” Id. at 33. But Petitioner does not appear to be arguing that replacing Euler angles with quaternions would have been “trivial” or simple, only that doing so was taught by Bassompiere and within the knowledge and capabilities of a person of ordinary skill in the art. We determined above that a skilled artisan had knowledge of extended Kalman filters and quaternion mathematics such knowledge, and we are required to consider the knowledge and capabilities of a person of ordinary skill in our analysis. Further, at this preliminary stage, Patent Owner’s assertion that the Euler angle/quaternion switch would not have been a routine substitution is supported only with attorney argument, which is entitled to no weight. Icon Health & Fitness, Inc. v. Strava, Inc. 849 F.3d 1034, 1043 (Fed. Cir. 2017). As such, it does not outweigh Dr. Sarrafzadeh’s contrary testimony. See, e.g., Ex. 1002 ¶ 56.” slip op. at 30
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“The parties agree that the claimed “spatial reference frame” is associated with a device, has its origin at the same point in the device, and has axes that are always fixed with respect to the device. The only disagreement is whether that device is a “3D pointing device” or an “electronic device.” The Specification indicates that “electronic device” encompasses 3D pointing devices as well as, e.g., smartphones and navigation equipment, and therefore is the broader term. Ex. 1001, 8:35–39. At this stage of the proceeding, we determine that the threshold question of institution can be decided under either construction, because Patent Owner does not dispute that the primary asserted reference, Bassompiere, teaches a “spatial reference frame” associated with a 3D pointing device. Pet. 30–31. Therefore, at this stage of the proceeding, we decline to resolve the parties’ dispute. See Vivid Techs., Inc. v. Am. Sci. & Eng'g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those [claim] terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”); Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (approving Board decision not to construe claim language where the construction is not material to the dispute).” slip op. at 15
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,852,846 - Reolink Innovation Inc. / Shenzhen Reolink Technology Co., Ltd. v. Throughtek Technology (Shenzhen) Co., Ltd. And Throughtek Co., Ltd.All claims unpatentablePTAB · Dec 15, 2025 · IPR2024-01193 · APJ David C Mckone · IPR · Final written decision
Claims 1–3, 5, 7–13, 15–19, and 23–25 are unpatentable: claims 1, 7, 8, 10, 11, 15, 16, 18, 19, and 23–25 as anticipated by Zhang; all challenged claims also as obvious over at least one …
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“person of ordinary skill in the art “would have had a bachelor’s degree in electrical engineering and two years of work experience with network and communication technologies.” Pet. 5 (citing Ex. 1003 ¶¶ 13–15). Patent Owner does not contest Petitioner’s proposal or provide a proposal of its own. On the complete record, we adopt Petitioner’s description of the level of ordinary skill in the art, as it is consistent with the technology described in the ’448 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 11
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededTerm construed board ownMixed
“construction of “feature flag” is inconsistent with the language of claim 8, which states that “the feature flag indicates that the running state of the second apparatus is the sleep state.” Petitioner also argues that Patent Owner’s proposal is not supported by claim 24, which depends from claim 23 and states that “the feature flag is located at a header of the sleep login packet.” Id. at 3. We agree with Petitioner. The plain language of claim 8 states what a feature flag indicates. Claim 24 recites where the feature flag is located. Neither claim suggests any of Patent Owner’s additional limitations.” slip op. at 13
- Expert testimonyPetitioner expert creditedDecided for petitioner
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“[A] prior art reference will anticipate if it ‘disclose[s] each and every element of the claimed invention . . . arranged or combined in the same way as in the claim.’” Blue Calypso, LLC v. Groupon, Inc., 815 F.3d 1331, 1341 (Fed. Cir. 2016) (quoting In re Gleave, 560 F.3d 1331, 1334 (Fed. Cir. 2009) (alteration by Federal Circuit)). “However, a reference can anticipate a claim even if it ‘d[oes] not expressly spell out’ all the limitations arranged or combined as in the claim, if a person of skill in the art, reading the reference, would ‘at once envisage’ the claimed arrangement or combination.” Id. (quoting Kennametal, Inc. v. Ingersoll Cutting Tool Co., 780 F.3d 1376, 1381 (Fed. Cir. 2015) (alteration by Federal Circuit); In re Petering, 301 F.2d 676, 681 (CCPA 1962)). For the reasons explained below, we are persuaded that Petitioner has shown, by a preponderance of the evidence, that claims 1, 7, 8, 10, 11, 15, 16, 18, 19, and 23–25 are anticipated by Zhang. slip op. at 16
Patent outcomesUS 10,602,448 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 10,602,448 - PTAB · Dec 12, 2025 · IPR2025-01327 · APJ Sheila F Mcshane · IPR · Institution
The Board instituted IPR of claims 1–19 on all asserted grounds, finding a reasonable likelihood of prevailing on the Schwan-Lee and Schwan-Lee-Strickland obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“partes review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). Under 35 U.S.C. § 314(a), we may not authorize an inter partes review unless the information in the petition and the preliminary response “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons stated below, we determine that Petitioner has established a reasonable likelihood that it would prevail with respect to at least one claim. We therefore institute inter partes review as to all of the challenged claims of the ’655 patent and all of the asserted grounds of unpatentability in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“III. ANALYSIS A. Level of Ordinary Skill in the Art Petitioner asserts that a person of ordinary skill in the art: would have had a bachelor’s degree in electrical engineering, computer engineering, computer science, or equivalent, and two years of work experience with network devices and communication technologies. EX1003, ¶¶17–19. Additional education might compensate for less experience, and vice versa. Pet. 4 (citing Ex. 1003 ¶¶ 17–19).” slip op. at 6
- Claim Construction › Intrinsic evidence (Phillips canons) › Lexicography (patentee as own lexicographer)Term construed board ownDecided for petitioner
“The ’655 patent Specification states that: The topology data table 21 of the online server 20 is mainly recorded with a link data 49 between each of the P2P devices 41– 46 within the P2P device community. The link data 49 refers to the connection relationship between the P2P devices 41–46, which includes, but is not limited to, the connection structure, connection data and/or locations of connection. Ex. 1001, 4:51–57. On this preliminary record, we agree with Petitioner that the term “link data” is a “connection relationship between the P2P devices.” This meaning is consistent with the ordinary meaning of the term within the context of the claim, that is, “link data” means data on the links (connections) between each of the P2P devices, where the Specification provides a more fulsome meaning that the term includes, at least, “the connection structure, connection data and/or locations of connection.” See id. at 4:55–57. We invite the parties to provide additional briefing on the construction of this term during trial.” slip op. at 8
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner
“Lee discloses that the P2P overlay is generated with the overlay generation unit 220 that generates the P2P overlay by analyzing information regarding “the corresponding application service, the peer, and the network,” where the network information “may include a network topology, a maximum bandwidth, a current network usage, [and] a transmission delay time, and the like.” Ex. 1005 ¶ 54. We determine that this disclosure provides support for Mr. Lett’s testimony that “Lee describes techniques for changing an overlay in response to changing network characteristics,” which could be beneficial. Ex. 1003 ¶ 48. Accordingly, on this preliminary record, we find this evidence is sufficient to support a rationale to combine Schwan and Lee. See KSR, 550 U.S. at 401 (“[I]f a technique has been used to improve one device, and a person of ordinary skill in the art would recognize that it would improve similar devices in the same way, using the technique is obvious.”).” slip op. at 13
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,727,655 - Nokia Of America Corporation / AT&T Services, Inc. v. Iarnach Technologies LimitedSome claims unpatentablePTAB · Dec 10, 2025 · IPR2024-00899 · APJ Christopher L Ogden · IPR · Final written decision
Claims 1–3, 5, 10, 11, and 14 are unpatentable as obvious; claims 4, 12, 13, and 15 were not shown unpatentable under the asserted § 103 grounds.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“(citing Ex. 1003 ¶ 22). Patent Owner does not contest this proposed level of ordinary skill. PO Resp. 5. Also, neither party argues that the precise level of ordinary skill would be dispositive in this proceeding. We adopt Petitioner’s proposed level of ordinary skill because it is undisputed, supported by testimonial evidence, and consistent with the asserted prior art and the types of problems and solutions in the ’892 patent. See, e.g., Ex. 1001, 1:19–2:8.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for petitioner
“We agree with Petitioner. The evidence of record, including the ’892 patent and its prosecution history,9 indicates that the ordinary and customary meaning of “transitioning . . . from . . . to” encompasses both direct and indirect transitions. Looking first to the claim language itself, the word “directly” appears in claims 1, 6, and 10, but not claim 14, presumptively suggesting that claim 14 was intended to more broadly capture systems with either direct or indirect transitions. See CAE Screenplates Inc. v. Heinrich Fiedler GmbH, 224 F.3d 1308, 1317 (Fed. Cir. 2000) (“In the absence of any evidence to the contrary, we must presume that the use of . . . different terms in the claims connotes different meanings.”). Holding otherwise would fail to give any effect to the word “direct” as it appears in claims 1, 6, and 10. See Stumbo v. Eastman Outdoors, Inc., 508 F.3d 1358, 1362 (Fed. Cir. 2007) (denouncing claim constructions methodologies that render phrases in claims superfluous).” slip op. at 12
- Expert testimonyPetitioner expert creditedOther
“predictable and well-motivated variation of G.987.3, at the time of the claimed invention, to include a direct transition between the ONU’s two low-power states. See KSR v. Teleflex, 550 U.S. at 417 (“When a work is available in one field of endeavor, design incentives and other market forces can prompt variations of it, . . . . If a person of ordinary skill can implement a predictable variation, § 103 likely bars its patentability.”). We credit Dr. Sergienko’s testimony that a person of ordinary skill in the art would have been motivated to reduce power consumption and would have looked to ways of modifying G.987.3 to further that design goal. See Ex. 1003 ¶ 70; see also Ex. 1007, 97 (“For a variety of reasons, it is desirable to reduce the power consumed by an ONU as much as possible . . . .”). We also credit Dr. Sergienko’s testimony that there were only a small number of ways to modify the state transitions in G.987.3’s ONU, and that it would have been obvious to consider those possibilities. Ex. 1003 ¶ 70. Patent Owner does not contest this. Dr. Litvin concedes, for Patent Owner, that “there is no conceivable way the [ITU] did not consider the proposed transition” between the ONU’s two low-power states when drafting G.987.3, although he contends the standards body prohibited such direct transitions as “a conscious and reasoned design choice.” Ex. 2007 ¶ 108; see also id. ¶ 109 (opining that there were only four possible choices for transitions in the ONU, and the ITU “undoubtedly considered all of them, including the direct transition from . . . Listen and . . . Asleep”); PO Resp 24 (conceding that “G.987 explicitly considered the very direct transitions that Petitioner say would be used”). We also find persuasive Petitioner’s additional or alternative argument that Röger would have motivated modifying G.987.3 by allowing the ONU, while in sleep mode, to periodically turn on its receiver and check for messages from the OLT, which would have been direct transitions between “first” and “second” states as recited in claim 1. Pet. 20–22 & n.4; Ex. 1003 ¶¶ 82–84. The evidence suggests that modifying G.987 as Petitioner proposes would have been within the abilities of a person of the ordinary skill in the art at the time of the claimed invention—either to add a direct transition between Listen and Asleep states or to allow the ONU, while in its sleep (both transmitter and receiver off) mode, to periodically turn on its receiver temporarily to listen for polling messages from the OLT, as Röger teaches. Pet. 11–12, 14–15, 19; Ex. 1003 ¶¶ 70, 74. We also agree with Petitioner that there would have been motivation” slip op. at 26
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“We find persuasive Petitioner’s arguments that it would have been a predictable and well-motivated variation of G.987.3, at the time of the claimed invention, to include a direct transition between the ONU’s two low-power states. See KSR v. Teleflex, 550 U.S. at 417 (“When a work is available in one field of endeavor, design incentives and other market forces can prompt variations of it, . . . . If a person of ordinary skill can implement a predictable variation, § 103 likely bars its patentability.”). We credit Dr. Sergienko’s testimony that a person of ordinary skill in the art would have been motivated to reduce power consumption and would have looked to ways of modifying G.987.3 to further that design goal. See Ex. 1003 ¶ 70; see also Ex. 1007, 97 (“For a variety of reasons, it is desirable to reduce the power consumed by an ONU as much as possible . . . .”). We also credit Dr. Sergienko’s testimony that there were only a small number of ways to modify the state transitions in G.987.3’s ONU, and that it would have been obvious to consider those possibilities. Ex. 1003 ¶ 70. Patent Owner does not contest this. Dr. Litvin concedes, for Patent Owner, that “there is no conceivable way the [ITU] did not consider the proposed transition” between the ONU’s two low-power states when drafting G.987.3, although he contends the standards body prohibited such direct transitions as “a conscious and reasoned design choice.” Ex. 2007 ¶ 108; see also id. ¶ 109 (opining that there were only four possible choices for transitions in the ONU, and the ITU “undoubtedly considered all of them, including the direct transition from . . . Listen and . . . Asleep”); PO Resp 24 (conceding that “G.987 explicitly considered the very direct transitions that Petitioner say would be used”). We also find persuasive Petitioner’s additional or alternative argument that Röger would have motivated modifying G.987.3 by allowing the ONU, while in sleep mode, to periodically turn on its receiver and check for messages from the OLT, which would have been direct transitions between “first” and “second” states as recited in claim 1. Pet. 20–22 & n.4; Ex. 1003 ¶¶ 82–84. The evidence suggests that modifying G.987 as Petitioner proposes would have been within the abilities of a person of the ordinary skill in the art at the time of the claimed invention—either to add a direct transition between Listen and Asleep states or to allow the ONU, while in its sleep (both transmitter and receiver off) mode, to periodically turn on its receiver temporarily to listen for polling messages from the OLT, as Röger teaches. Pet. 11–12, 14–15, 19; Ex. 1003 ¶¶ 70, 74.” slip op. at 26
Patent outcomesUS 9,806,892 mixedClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,806,892 - PTAB · Dec 9, 2025 · IPR2025-00756 · APJ Thu A Dang · IPR · Institution
The Board instituted IPR on claims 1, 2, 5–8, 11, and 12 on three §103 grounds, finding a reasonable likelihood of unpatentability over the asserted combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“III. CONCLUSION Because we determine that Petitioner has demonstrated a reasonable likelihood that it would prevail in showing at least one of the challenged claims is unpatentable, we institute inter partes review as to all challenged claims and grounds presented in the Petition. At this stage of the proceeding, we have not made a final determination as to the patentability of any of these challenged claims. ORDER For the reasons given, it is ORDERED that pursuant to 35 U.S.C. § 314, an inter partes review is instituted as to claims 1, 2, 5–8, 11, and 12 of the ’803 patent to determine whether: 1) claims 1, 5–7, 11, and 12 are unpatentable under 35 U.S.C. § 103 as obvious over TS 36.300, TS 36.321, and TS 36.331; 2) claims 1, 2, 5–8, 11, and 12 are unpatentable under 35 U.S.C. § 103 as obvious over Ericsson and TS 25.331; and 3) claims 5, 6, 11, and 12 are unpatentable under 35 U.S.C. § 103 as obvious over Ericsson, TS 25.331, and Sebire; and” slip op. at 27
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“ordinary meaning, “primary” and “non-primary” cells are all cells that the WTRU is connected to (PO Resp. 16), the plain language in claim 1, and similarly in claim 7, does not require a “primary” node or “non-primary” cell to have a connection to the WTRU. See Ex. 1001, 10:38−56; 11:11–26. We find unavailing Patent Owner’s contention that the claims require that the WTRU “be connected to more than one cell,” wherein cells that are “associated with a wireless network node,” but are not connected to the WTRU “at the same time” cannot be “primary” or “non-primary” cells. PO Resp. 16. In the ’803 patent, nothing in the Specification clearly limits “primary” and “non-primary” cells as Patent Owner proposes. Prelim. Resp. 16. Patent Owner points to the Specification of the ’803 patent to show that, for softer handover, the WTRU is connected “with more than one cell [] which are controlled by the same Node-B,” and “[o]ne of the[se] cells 808 may be designated as a primary cell 808a, while other cells are designated as a non-primary cells 808b.” Id. (alterations in original) (citing Ex. 1001, 8:44–46, 9:4–6, Figs. 8A–B). However, this portion of the Specification (describing a softer handover embodiment in which a cell “may be designated” as a primary while other as non-primary) does not provide a clear definition to warrant interpreting the “primary” and “non-primary” cells as requiring “connection” to the WTRU “at the same time.” Id. That is, nothing in the Specification clearly precludes “primary” and “non-primary” cells from being “source” and “target” cell, as Patent Owner contends. PO Resp. 16. and the Specification, we determine that the terms “primary” and “non-primary” recited in claims 1 and 7 are not limited to cells connected to a WRTU at the same time. We determine no further explicit construction of this term is necessary to resolve the controversy. See Vivid Techs., 200 F.3d at 803.” slip op. at 8
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“f) Motivation to combine Ericsson and TS 25.331 Petitioner contends that a “POSITA would have been motivated to combine Ericsson and TS 25.331 because they are directed to similar technologies and a skilled artisan would have understood the benefits of combining these two references,” and “would have understood that there was a high likelihood of success in making the combination.” Pet. 34 (citing Ex. 1003 ¶¶ 156–157). In particular, the references “are both reasonably pertinent to the problem faced by the inventor, namely protocols for handover in a telecommunications system.” Id. (citing Ex. 1003 ¶ 158). According to Petitioner, the combination “involves the predictable use of interchangeable prior art elements according to their established functions” more than routine engineering.” Id. at 37 (citing Ex. 1003 ¶ 174). At this stage of the proceeding, Patent Owner does not present arguments in the Preliminary Response addressing the specific merits of Petitioner’s contentions with respect to the motivation to combine Ericsson and TS 25.331. See generally Prelim. Resp. 15–18. We find availing Petitioner’s contention that Ericsson and TS25.331 are “directed to similar technologies,” and that a “skilled artisan would have understood the benefits of combining these two references.” Pet. 34. On this preliminary record, we are persuaded that Petitioner has made a sufficient showing that a POSITA would have had a reason to combine the teachings of Ericsson and TS 25.331.” slip op. at 20
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner, relying on the testimony of Dr. Kakaes, contends that a person of ordinary skill in the art (POSITA) “would have had a B.S. in Electrical Engineering or a related field with at least three years of experience designing, developing, and/or testing telecommunication systems,” and “would also have familiarity with the wireless standards and well-known protocols for accessing wireless networks existing at the relevant time,” wherein “[m]ore education may supplement practical experience or vice versa.” Pet. 12–13. At this stage in the proceeding, Patent Owner does not contest Petitioner’s proposal or offer an alternative. On this record, we are persuaded that Petitioner’s proposal is consistent with the technology described in the Specification and the cited prior art. For purposes of this Decision, we adopt Petitioner’s proposed level of skill.” slip op. at 10
Claim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 10,764,803 - Ericsson Inc. / Nokia Of America Corporation v. XR Communications LLCAll claims unpatentablePTAB · Nov 25, 2025 · IPR2024-00868 · APJ Kara L Szpondowski · IPR · Final written decision
Claims 1, 2, 4–6, 9–11, 13–15, and 18–20 are unpatentable as obvious over Trigui; claims 4–6, 13–15, and 18 are also unpatentable over Trigui and Rudrapatna.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner does not challenge Petitioner’s characterization of the level of ordinary skill in the art, or provide an alternative level of ordinary skill in the art. PO Resp. 9. In the Institution Decision, we adopted Petitioner’s proposed level of ordinary skill in the art, which was also undisputed by Patent Owner at that stage of the proceeding. Inst. Dec. 11–12. Because nothing in the record establishes that our preliminary finding in the Institution Decision was incorrect, and because there is no dispute, we maintain our adoption of Petitioner’s proposed level of ordinary skill in the art.” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“C. Claim Construction Petitioner contends “[n]o specific construction of any term is required,” and Petitioner has applied the “ordinary and customary meaning” of the claim terms. Pet. 13–14. Patent Owner states that, “[f]or purposes of this proceeding, Patent Owner agrees that no formal claim construction is necessary.” PO Resp. 9. Patent Owner provides the Board with the district court’s constructions in the related litigation. Id. (citing 2007, 39).4 4 The Petition in this case was filed on May 8, 2024. In the related litigation, Patent Owner’s opening brief on claim construction was filed on July 15, 2024, defendants’ responsive brief on claim construction was filed on this Decision, we need not expressly construe any claim terms to resolve the parties’ disputes. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms that . . . are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Accordingly, to the extent necessary, we apply the district court’s constructions and the plain and ordinary meaning of the claim terms. To the extent that the scope of any particular claim term requires discussion, we provide it in our assessment of the challenges.” slip op. at 12
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“Figures 6 and 10 show multiples of the system of Figure 2A. Id.; see also id. ¶ 81 (describing Figure 6) ¶ 85 (describing Figure 10). We find persuasive Petitioner’s arguments that Trigui’s arrays may consist of “subarrays.” See Pet. 24; Reply 9. For example, Trigui describes that “[t]he antenna arrays 256 may consist of sub-arrays where the antenna elements of each sub-array are combined passively to achieve a predefined pattern.” Ex. 1004 ¶ 50. To that end, Figure 6 shows one antenna array that consists of two Passive Antenna Sub-arrays (i.e., the plurality of antenna elements), and Figure 10 shows two antenna arrays that each consist of two Passive Antenna Sub-arrays (i.e., the plurality of antenna elements). See Pet. 28–32; Reply 9–11. Given this disclosure in Trigui, we do not find persuasive Patent Owner’s arguments that Figure 6 does not show a single antenna array, or that Figure 10 does not show two antenna arrays. PO Resp. 17–18. Patent Owner also argues that a person of ordinary skill in the art would understand that Trigui’s sub-arrays are not intended to be combined. PO Resp. 18. This argument contradicts Trigui’s disclosure, which shows multiples of the hardware of Figure 2A in Figures 6 and 10, and encourages multiple operator sharing of passive antenna arrays and transceivers. See, e.g., Reply 4 (describing Trigui as “providing building blocks that should be combined to understand Trigui’s full teachings”); Ex. 1004 ¶¶ 48, 68. Trigui even states as much: Although FIG 2A illustrates only a single MIMO branch DIAA, the present invention contemplates the use of multiple MIMO branches (as will be illustrated below with reference to FIGS. 6–11) . . . Similarly, I/Q signals 215 from any of the modems, as well as the beamforming weights 214, can be sent to other MIMO branches. Patent Owner’s argument that “Trigui does not teach any relationship between the number of beams and the number of MIMO transceivers” is not well developed and is unpersuasive in light of Petitioner’s showing. Petitioner has demonstrated that Trigui’s Figure 6 depicts one antenna array with two bi-directional beams. Pet. 27–28. Petitioner has further demonstrated that Trigui’s Figure 10 depicts two antenna arrays, i.e., where m=2, where each array comprises a beamformer configured to produce n different bi-directional beams, i.e., where n=2. Id. at 28–29. Petitioner’s annotated Figure 10 is reproduced below: Id. at 29. Petitioner’s annotated Figure 10 shows two copies of the arrangement shown in Figure 6, where Petitioner has identified in red the two antenna arrays, and identified in blue the beams. That is, Trigui’s Figure 10 shows two antenna arrays that each produce two beams. Figures 3 and 4 of Trigui (PO Resp. 16–17) do not address Petitioner’s contentions. See Reply 6–7. Petitioner relies on Figures 4A and 4B to support that “[e]ach of Trigui’s arrays can produce multiple beams.” Pet. 26; Reply 7. Dr. Cooklev agrees. PO Resp. 16 (citing Ex. 2003 ¶ 91). However, as described above, Petitioner relies on Figure 6 to show “n” different bidirectional beams where n=2. Pet. 27. Petitioner does not rely on Figures 3 and 4 to teach the “n” number of beams. See Reply 7. Accordingly, we do not agree with Patent Owner’s argument that the Petition provides no evidence for the “n different bidirectional beams.” See Sur-reply 11–12; see Pet. 27 (citing Ex. 1004 ¶¶ 9, 14, 74, 77, 81; Ex. 1003 ¶¶ 189, 192, 193).” slip op. at 18
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“Trigui explicitly discloses that its system may have multiple modems. See Pet. 38; Reply 15. For example, Figure 2A shows Modem A, Modem B, and Modem C for a single MIMO branch. Ex. 1004 Fig. 2A; see also id. ¶37 (“one or more modems 204, such as, for example, baseband modules of cellular base stations”) ¶ 41 (“I/Q signals 215 from any of the modems . . . can be sent to other MIMO branches”); see Pet. 34. We find persuasive Petitioner’s explanation, supported by testimony from Dr. Negus, that “Trigui teaches use cases in which two separate wireless network operators would share certain tower [equipment,] such as the antenna arrays, but each wireless network operator would have its own baseband unit (i.e., modems A for the first operator and B for the second operator).” Pet. 33 (citing Ex. 1003 ¶¶ 226–232); e.g., Ex. 1004 ¶ 48 (stating that “the present invention . . . enable[s] multiple operator sharing of a passive antenna array, transceivers, and the total available power of the DIAA”); id. (“[S]plitting resources between the multiple operators is flexible and should be done on the basis of the individual operator needs”); ¶ 2 (“enabling a versatile solution for sharing antenna elements and active electronics between multiple operators servicing the same geographic area”); see also Pet. 38–41 (providing further explanation that one modem would be implemented for each operator); Reply 18–21. Patent Owner agrees that the second modem would be for a different operator. PO Resp. 20 (stating that “[E]ven if a second modem is added, it would be for a different operator”).5 Therefore, we are persuaded 5 In the Sur-reply, Patent Owner argues the opposite; that the operators would not have separate modems. Sur-reply 4. We rely on Patent Owner’s modems that share the two DIAA arrays in Figure 10. Pet. 42; Reply 18; In re Applied Materials, Inc., 692 F.3d 1289, 1298 (Fed. Cir. 2012) (“A reference must be considered for everything that it teaches, not simply the described invention or a preferred embodiment.”). Thus, we find that Petitioner’s proposed modification for Figure 10 is derived from Trigui’s disclosures, not through hindsight. See In re McLaughlin, 443 F.3d 1392, 1395 (CCPA 1971) (“Any judgment on obviousness is in a sense necessarily a reconstruction based on hindsight reasoning, but so long as it takes into account only knowledge which was within the level of ordinary skill at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure, such a reconstruction is proper”).” slip op. at 26
Patent outcomesUS 8,737,511 unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 8,737,511 - PTAB · Nov 6, 2025 · IPR2025-00820 · APJ Neil T Powell · IPR · Institution
The Board instituted IPR on claims 1–11 on all petition grounds, finding a reasonable likelihood that claim 1 would have been obvious over Tadros, Porter, Kalili, and Texin 990R.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). To institute an inter partes review, we must determine that the information presented in the Petition and the Preliminary Response shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that there is a reasonable likelihood that Petitioner will prevail with respect to at least one challenged claim. We institute an inter partes review of claims 1–11 based on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Pet. 17–18 (citing Ex. 1007 ¶¶ 13–15). Patent Owner does not dispute Petitioner’s explanation of the level of skill in the art. See generally Prelim. Resp. At this stage of the proceeding and on the present record, we adopt Petitioner’s uncontested proposed level of ordinary skill in the art, which we find consistent with the level of ordinary skill in the art reflected by the ’090 patent and the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Additionally, only terms that are in controversy need to be construed, and these need be construed only to the extent necessary to resolve the controversy. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Both parties indicate that no claim terms need to be expressly construed. Pet. 29–30; Prelim. Resp. 5. Consistent with that, we determine that we need not construe any claim terms expressly in order to resolve the parties’ dispute regarding whether Petitioner has demonstrated a reasonable likelihood of prevailing.” slip op. at 8
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“Weighing the parties’ arguments and evidence, we find Petitioner’s arguments and evidence sufficient at this stage to demonstrate a reasonable likelihood of prevailing. Pet. 8–17, 30–49. For example, regarding whether of Porter’s disclosure to the problem faced by inventor of the ’090 patent. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 144–164. The ’090 patent illustrates that its inventor faced the problem of selecting desirable materials for an aligner, including selecting a desirable material for an aligner’s hard layer. Ex. 1001, 5:44–59. Petitioner and Dr. Osswald provide significant evidence and reasoning tending to show that Porter’s discussion of Tritan logically would have commended itself to the attention of an inventor facing the problem of selecting an aligner hard layer. Pet. 8 (citing Ex. 1007 ¶¶ 98–108, 125–127, 144–164). For example, Dr. Osswald explains that “because Tritan copolyesters are BPA-free, Rafih specifically discloses Tritan EX401 as an exemplary material” for its oral appliance. Id. ¶ 99 (citing Ex. 1104, 5:4–64, claims 2, 9, 10). In view of this, Dr. Osswald testifies that “Rafih would inform a [person of ordinary skill in the art] that Porter’s guidance regarding replacing polycarbonate with Tritan applies to dental appliances.” Ex. 1007 ¶ 146. At this stage, weighing Petitioner’s evidence against Patent Owner’s contrary attorney argument that Porter focuses on dishware, we determine Petitioner has shown sufficiently that Porter is analogous art. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 144–164; Prelim. Resp. 1, 9–10, 18–21.” slip op. at 11
Claim construction§ 103 obviousnesscites PhillipsPatents in suitUS 11,648,090 - PTAB · Nov 6, 2025 · IPR2025-00821 · APJ Neil T Powell · IPR · Institution
The Board instituted review of claims 1–23, 25, and 26 on all asserted grounds, finding a reasonable likelihood that claim 1 would have been obvious over Tadros, Porter, Kalili, and Texin 990R.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority to determine whether to institute an inter partes review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). To institute an inter partes review, we must determine that the information presented in the Petition and the Preliminary Response shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that there is a reasonable likelihood that Petitioner will prevail with respect to at least one challenged claim. We institute an inter partes review of claims 1–23, 25, and 26 based on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Pet. 17 (citing Ex. 1007 ¶¶ 13–15). Patent Owner does not dispute Petitioner’s explanation of the level of skill in the art. See generally Prelim. Resp. At this stage of the proceeding and on the present record, we adopt Petitioner’s uncontested proposed level of ordinary skill in the art, which we find consistent with the level of ordinary skill in the art reflected by the ’090 patent and the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Additionally, only terms that are in controversy need to be construed, and these need be construed only to the extent necessary to resolve the controversy. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Neither party indicates that we need to construe expressly any claim terms. Pet. 27–28; Prelim. Resp. 5. Consistent with that, we determine that we need not construe any claim terms expressly in order to resolve the parties’ dispute regarding whether Petitioner has demonstrated a reasonable likelihood of prevailing.” slip op. at 8
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“arguments and evidence sufficient at this stage to demonstrate a reasonable likelihood of prevailing. Pet. 8–17, 53–71. For example, regarding whether Porter is analogous art, Petitioner sufficiently shows reasonable pertinence of Porter’s disclosure to the problem faced by inventor of the ’091 patent. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 146–165. The ’091 patent illustrates that its inventor faced the problem of selecting desirable materials for an aligner, including selecting a desirable material for an aligner’s hard layer. Ex. 1001, 5:44–59. Petitioner and Dr. Osswald provide significant evidence and reasoning tending to show that Porter’s discussion of Tritan logically would have commended itself to the attention of an inventor facing the problem of selecting an aligner hard layer. Pet. 8 (citing Ex. 1007 “because Tritan copolyesters are BPA-free, Rafih specifically discloses Tritan EX401 as an exemplary material” for its oral appliance. Id. ¶ 99 (citing Ex. 1104, 5:4–64, claims 2, 9, 10). In view of this, Dr. Osswald testifies that “Rafih would inform a [person of ordinary skill in the art] that Porter’s guidance regarding replacing polycarbonate with Tritan applies to dental appliances.” Ex. 1007 ¶ 147. At this stage, weighing Petitioner’s evidence against Patent Owner’s countervailing attorney argument that Porter focuses on dishware, we determine Petitioner has shown sufficiently that Porter is analogous art. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 146–165; Prelim. Resp. 1–2, 9–10, 34–36.” slip op. at 13
Claim construction§ 103 obviousnesscites PhillipsPatents in suitUS 11,648,091 - PTAB · Nov 6, 2025 · IPR2025-00819 · APJ Kristina M Kalan · IPR · Institution
The Board instituted IPR on all challenged claims based on both obviousness grounds, finding a reasonable likelihood of success on at least one claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“that Petitioner has demonstrated a reasonable likelihood of showing that a person of ordinary skill in the art would have been motivated to combine the teachings of Tadros, Kalili, and Texin 990R to meet the limitations of the claims challenged under this ground.” slip op. at 14
- Skill levelSkill level petitioner adoptedDecided for petitioner
“would have had at least a four-year undergraduate degree in materials science, mechanical engineering, chemical engineering, or a related field and at least two years of experience in the field of polymer science, combined with at least two years of experience in the field of design, manufacture, and processing of thermoformable polymer sheets for use in various applications, such as in orthodontic and dental appliances. Additional education could substitute for professional experience and vice versa. Pet. 18–19 (citing Ex. 1007 ¶¶ 13–15). At this stage, Patent Owner does not dispute Petitioner’s proposal or offer an alternative proposal. See generally Prelim. Resp. Because Petitioner’s proposed level of ordinary skill in the art appears to be consistent with the cited prior art and is undisputed on this record, we adopt it for purposes of this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (indicating that the prior art itself may reflect an appropriate skill level).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Only claim terms in controversy need be construed. Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”). For purposes of this Decision, we determine that no claim term requires express construction.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“that Petitioner has demonstrated a reasonable likelihood of showing that a person of ordinary skill in the art would have been motivated to combine the teachings of Tadros, Kalili, and Texin 990R to meet the limitations of the claims challenged under this ground. We disagree that Petitioner fails to meet its burden as to the motivation to combine arguments. Petitioner persuasively maps the limitations of the challenged claims to portions of the references relied upon. Pet. 28–38 (claim 1), 38–51. Petitioner also, on this record, provides adequate statements of motivation to combine with a reasonable expectation of success. See, e.g., id. at 34–36 (citing Ex. 1007 ¶¶ 31, 39–42, 147–151, 174–176). The Petition’s reliance on supporting testimony and related corroborating evidence to support the combination does not amount to impermissible hindsight, as that testimony takes into account “knowledge which was within the level of ordinary skill in the art at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure.” In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971). Without further clarification or support from Patent Owner, and in the absence of testimony to support the assertion that a POSITA would not have combined the cited references in the manner proposed with a reasonable expectation of success, we are unpersuaded by Patent Owner’s arguments in this regard.” slip op. at 14
Claim construction§ 103 obviousnesscites KSRPatents in suitUS 11,154,384 - PTAB · Nov 6, 2025 · IPR2025-00818 · APJ Kristina M Kalan · IPR · Institution
The Board instituted IPR on all challenged claims 1–22 based on all three asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority under 35 U.S.C. § 314(a), which provides that inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” After considering the briefing and cited evidence of record, we institute inter partes review because we find that Petitioner establishes a reasonable likelihood that it will prevail with respect to at least one of the claims challenged in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“understanding of a person of ordinary skill in the art at the time the invention was made. See Graham, 383 U.S. at 17–18. Petitioner proposes that a person of ordinary skill in the art (sometimes referred to herein as a “POSITA”) would have had at least a four-year undergraduate degree in materials science, mechanical engineering, chemical engineering, or a related field and at least two years of experience in the field of polymer science, combined with at least two years of experience in the field of design, manufacture, and processing of thermoformable polymer sheets for use in various applications, such as in orthodontic and dental appliances. Additional education could substitute for professional experience and vice versa. Pet. 18 (citing Ex. 1007 ¶¶ 13–15). At this stage, Patent Owner does not dispute Petitioner’s proposal or offer an alternative proposal. See generally Prelim. Resp. Because Petitioner’s proposed level of ordinary skill in the art appears to be consistent with the cited prior art and is undisputed on this record, we adopt it for purposes of this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (indicating that the prior art itself may reflect an appropriate skill level).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner argues that no terms require construction, but that “Petitioner applies the prior art consistent with Patent Owner’s assertions in its Infringement Contentions (EX1014, 6-20.).” Pet. 26. Patent Owner does not propose any express claim constructions. Prelim. Resp. 5. Nor does Patent Owner allege that any of Petitioner’s claim interpretations contradict Petitioner’s position in the related district court litigation. Id. Only claim terms in controversy need be construed. Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”). For purposes of this Decision, we determine that no claim term requires express construction.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“that Petitioner has demonstrated a reasonable likelihood of showing that a person of ordinary skill in the art would have been motivated to combine the teachings of Tadros, Kalili, and Texin 990R to meet the limitations of the claims challenged under this ground. We disagree that Petitioner fails to meet its burden as to the motivation to combine arguments. Petitioner persuasively maps the limitations of the challenged claims to portions of the references relied upon. Pet. 27–36 (claim 1), 36–46. Petitioner also, on this record, provides adequate statements of motivation to combine with a reasonable expectation of success. See, e.g., id. at 32–35 (citing Ex. 1007 ¶¶ 31, 39–41, 57–87, 146–150, 171–172). The Petition’s reliance on supporting testimony and related corroborating evidence to support the combination does not amount to impermissible hindsight, as that testimony takes into account “knowledge which was within the level of ordinary skill in the art at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure.” In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971). Without further clarification or support from Patent Owner, and in the absence of testimony to support the assertion that a POSITA would not have combined the cited references in the manner proposed with a reasonable expectation of success, we are unpersuaded by Patent Owner’s arguments in this regard. We also disagree with Patent Owner’s arguments about “adhesive lamination” using “tie layers” at this point in the proceeding. Prelim. Resp. 15–18. On this record, we are persuaded that Petitioner has adequately supported its arguments that one of ordinary skill in the art would have been motivated to use adhesive lamination to achieve the proposed combination. See, e.g., Pet. 33–35; Ex. 1007 ¶¶ 39–42, 120, 45, 51, 116, 120. Petitioner relies on Kalili as disclosing a hard layer suitable for combination with Tadros’s soft layers (Pet. 32), and more particularly, doing so in the context of a laminated multilayer aligner (Reply 4). To create the laminated multilayer aligner proposed, Petitioner’s suggested use of a particular type of well-known lamination, i.e. adhesive lamination, is sufficiently developed and supported in the Petition. Pet. 32–35. Here, Patent Owner recognizes that Kalili teaches lamination, but suggests that it does not specifically teach using adhesive lamination. Prelim. Sur-reply 5. We note, however, that the parties have identified limited types of known lamination for aligners: coextrusion, extrusion lamination, and adhesive lamination. Prelim Sur-reply 4; Pet. 14–15 n.3, 33. In KSR, the Supreme Court explained that when “there is a design need or market pressure to solve a problem and there are a finite number of identified, predictable solutions, a person of ordinary skill has good reason to pursue the known options within his or her technical grasp.” KSR, 550 U.S. at 421. “If this leads to the anticipated success, it is likely the product not of innovation but of ordinary skill and common sense.” Id. Having reviewed Petitioner’s proffered arguments as to Tadros, Kalili, and Texin 990R, including motivation to combine the references asserted in this ground, with a reasonable expectation of success, we are persuaded on this record that Petitioner has met its burden for institution with respect to Ground 1.” slip op. at 14
Claim construction§ 103 obviousnesscites KSRPatents in suitUS 10,973,613
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.