- Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Solus’s rehearing request, leaving institution denied for claims 1–8 because the petition did not adequately show motivation to combine Hanafusa and Dobashi.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve Dobashi’s RSm values. Dobashi teaches that because RSm “can be adopted as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66–3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66– 3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 4
§ 103 obviousnessPatents in suitUS 11,346,014 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show that claims 1–10 were likely obvious over the asserted combinations.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re 1 US 2013/0108922 A1, published May 2, 2013 (Ex. 1004, “Shinozaki”). 2 G. Khatibi, Temperature Dependent Elastic and Thermal Properties of Thin Copper Foils, Copper; Proceedings of the International Conference Copper ’06 (2006) (Ex. 1006, “Khatibi”). 3 Korean Patent Pub. No. 10-2012-0003485, published Jan. 10, 2012 (Ex. 1013; Ex. 1014 (English translation), “Toshio”). 4 US 2013/0108887 A1, published May 2, 2013 (Ex. 1012, “Kim”). 5 Griesi, M.B., Characterization of Electrodeposited Copper Foil Surface Roughness for Accurate Conductor Power Loss Modeling (2014) (Master’s Thesis, University of South Carolina) (Ex. 1015, “Griesi”). rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Not shown unpatentable
“For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE[6] value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added).” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner, however, does not adequately explain why a POSITA would have been motivated to modify Kim’s copper foil surface to have a Pc value of 19.2 as reported in Griesi. In particular, neither Petitioner nor Dr. Randall points us to, nor do we discern, any teaching in Griesi that a peak count of 19.2 provides any particular benefits or properties that would have lead a POSITA to modify Kim’s copper foil surface as Petitioner proposes. Instead, Petitioner’s arguments that a POSITA would have been motivated to modify Kim’s copper foil surface with Griesi’s peak count patent itself. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 421 (2007) (stating that the fact finder must be aware “of the distortion caused by hindsight bias and must be cautious of arguments reliant upon ex post reasoning”). It was Petitioner’s burden to establish that the combined teachings Kim and Griesi disclose limitation [1g] as proposed. We are not persuaded that we misapprehended Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 8
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish the Khatibi, alone or in combination with Shinozaki, Toshio, and Kim, discloses limitation [1d]. We concluded that Petitioner failed to meet that burden for the reasons explained in our Decision. We are not persuaded that we overlooked or misapprehended Khatibi’s disclosures, or Petitioner’s evidence and explanation thereof, in doing so.7” slip op. at 5
§ 103 obviousnesscites KSRPatents in suitUS 10,811,689 - PTAB · Oct 7, 2025 · IPR2025-00545 · APJ David Cotta · IPR · Institution
The Board instituted IPR of claims 1, 3–11, 13–21, and 23–30 on all asserted grounds after finding a reasonable likelihood that at least one challenged claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 314(a), inter partes review may not be instituted unless the Petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Petitioner has established a reasonable likelihood of prevailing on its assertion that at least one of the challenged claims is unpatentable based on the grounds advanced here. Thus, for reasons explained below, we institute inter partes review of claims 1, 3–11, 13–21, and 23–30 of the ’904 patent.” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“F. Claim Construction We interpret a claim “using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. 282(b).” 37 C.F.R. § 42.100(b) (2024). Under this standard, we construe the claim “in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” Id.” slip op. at 11
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Id. at 18–19. Petitioner also notes that “[a] person could also have qualified with more formal education and less technical experience, or vice versa.” Id. at 19. Patent Owner does not offer a definition of the person of ordinary skill in the art. Petitioner’s definition appears to be consistent with the field of the invention reflected in the prior art of record and the disclosure of the ’904 patent. Accordingly, for purposes of this Decision, we adopt Petitioner’s proposed definition of the person of ordinary skill in the art.” slip op. at 11
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“1. Rationale for proposed combination Petitioner asserts Merriman061 teaches that it is “highly desirable to target advertisements to the appropriate potential customer base” and discloses “techniques for gathering profile information about users and 26 1:52–53, 1:64–2:3, 2:6–30, 4:44–5:7, 5:50–59, 7:46–8:30, 8:39–46; Ex. 1002 ¶ 123). According to Petitioner, Jaye “recognizes the importance of collecting profile information for targeted advertising” and discloses “techniques for combining profile information from multiple local websites visited by users into more comprehensive global profiles that may be shared with ‘interested outside parties, such as advertisers.’” Id. at 21 (citing Ex. 1005, code (57), 1:18–38, 2:6–10, 2:6–8, 2:15–3:40, 5:5–19, 6:1– 7:45, 8:40–10:41,14:22–25; Ex. 1002 ¶ 123). Petitioner contends that a person of ordinary skill in the art would have been motivated to “incorporate Jaye’s techniques for collecting and combining profile information to enhance and improve Meriman061’s ad targeting by providing more information about the users to whom the ads are targeted.” Id. (citing Ex. 1002 ¶ 123). Having reviewed the arguments and evidence included in the Petition, including the Houh Declaration, which are not substantively addressed by Patent Owner at this stage, we are persuaded that Petitioner sufficiently demonstrates, for purposes of this Decision, that it would have been obvious to combine Merriman061 and Jaye in the manner set forth in the Petition.” slip op. at 26
Claim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 8,494,904 - Geneoscopy, Inc. v. Exact Sciences CorporationAll claims unpatentablePTAB · Jul 9, 2025 · IPR2024-00459 · APJ Ryan H Flax · IPR · Final written decision
Claims 1–20 are unpatentable as obvious under § 103 over each of the six asserted grounds.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“Here, as in our Institution Decision, we do not discern a significant difference between the parties’ respective proposed definitions beyond the number of years of experience after obtaining a doctoral degree. Compare Pet. 12, with Prelim. Resp. 47, and Resp. 19–20; see also DI 7–8. Under either proposed definition, the ordinarily skilled artisan would have been very highly skilled and educated. For purposes of this Final Decision, we maintain that Patent Owner’s definition appears to be reasonable (and it falls between Petitioner’s two definitions asserted in the reexamination request and in the Petition). Further, Patent Owner’s proposed definition appears to comport with the level of skill in the art reflected in the prior art of record and the ’781 patent itself, for example, Vilkin’s authors are a group of medical doctors and an editor of the journal is a PhD, Joost Louwagie, the named inventor of the ’781 patent, holds a PhD in Biochemistry, and the authors of Itzkowitz are medical doctors and PhDs. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (“[T]he prior art itself [may] reflect[] an appropriate level” as evidence of the ordinary level of skill in the art) (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985)); see Ex. 1005, 3 (list of authors); Ex. 1016 (Dr. Louwagie profile); Ex. 1055; see also generally Reply (Petitioner did not contest our similar determination at Institution). Therefore, we adopt and use Patent Owner’s definition of the ordinarily skilled artisan, set forth above. C.” slip op. at 13
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner asserts that no claim construction is necessary in this proceeding. See generally Pet. Similarly, Patent Owner states that it “does not believe that claim construction is necessary to resolve patentability” in this proceeding. Resp. 21. “[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). We agree with the parties that no construction of any claim term is necessary for purposes of our Final Decision. D.” slip op. at 14
- Expert testimonyOther
“Pet. 12. In support of these grounds for unpatentability, Petitioner relies on, inter alia, the 1st and 2nd Declarations of Duncan Whitney, PhD. Ex. 1002; Ex. 1080. In support of its positions, Patent Owner relies on, inter alia, the 1st and 2nd Declarations of Vadim Backman, PhD, and the Declaration of Peter Wood. Ex. 2001; Ex. 2022; Ex. 2023.” slip op. at 10
- Obviousness (§103) › Objective indicia / secondary considerations › NexusObjective indicia no nexusDecided for petitioner
“We have no reasonable doubt that aspects of the Cologuard product practice the invention of the ’781 patent’s claims 1 and 3, which are most generally directed to steps of collecting two portions of a fecal sample at home, and combining a respective buffer stabilizer/preservative with each of the two portions for claim 1, and then processing those fecal samples by testing for blood and nucleic acids (e.g., DNA) for claim 3. These appear to be nearly the most basic steps for using the Cologuard kit. See generally Ex. 2032. And, these steps do illustrate a certain ease of use and consumerfriendliness that may be a contributing factor in Cologuard’s success. See, e.g., Ex. 2022 ¶¶ 140–142, 155, 158–159, 170–171.” slip op. at 25
Patent outcomesUS 11,634,781 unpatentableClaim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 11,634,781 - Apple Inc. v. Masimo CorporationSome claims unpatentablePTAB · Jul 3, 2025 · IPR2024-00290 · APJ Richard H Marschall · IPR · Final written decision
Claims 1–3, 6, 11–17, 21, 22, 27, 28, 32, 34, 36, 37, and 42–44 are unpatentable as obvious; claims 4 and 18–20 were not shown unpatentable.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“In our Institution Decision, we deemed the differences in the parties’ proposals not material due to their substantial overlap, adopted Patent Owner’s proposal for purposes of that Decision, noted that the outcome of the Decision would not change if we adopted Petitioner’s proposal, and instructed the parties to “explain the differences and their relevance to the patentability issues in this case, and state whether any issue in the case turns on those differences” if either party continued to propose differing proposals during trial. Inst. Dec. 10–11. After institution, neither party has explained the materiality of the differences in their proposals or argued that any issues in this case turn on those differences. Based on our review of the parties’ proposals, we find Patent Owner’s proposal consistent with the level of skill exemplified by the prior art of record and the disclosure of the ’223 patent. Accordingly, we apply Patent Owner’s proposal in our analysis in this Decision. See Okajima, 261 F.3d at 1355 (“[T]he prior art itself” may reflect an appropriate level of the ordinary level of skill in the art. (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))). The outcome of this Decision would not change if we applied Petitioner’s proposed definition.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“persuasive and reject Patent Owner’s argument that we should construe the limitation as requiring the absence of one parameter from the display prior to the replacement and the absence of the other parameter after the replacement. We do not view either requirement proposed by Patent Owner as justified based on our review of the claims, specification, and prosecution history.” slip op. at 16
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableNot shown unpatentableMixed
“preponderance of the evidence that the combination of Naghavi, Hochstedler, and Burnes discloses all of the limitations of claim 1 and that a POSITA would have been motivated to combine the references in the manner Petitioner proposes with a reasonable expectation of success. See Pet. 9–30. Accordingly, we determine that Petitioner proves by a preponderance of the evidence that claim 1 would have been obvious based on Naghavi, Hochstedler, and Burnes.” slip op. at 58
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“proposed combination based on the argument that a POSITA would have been motivated to switch the layout responsive to a parameter value changing. Pet. 11–15 (citing Ex. 1003 ¶¶ 35–40, 47–52). For example, we agree with Petitioner that a motivation exists to change the layouts to “best suit the condition of [the] patient” because Naghavi expressly describes an “interactive and dynamic” GUI that “may automatically detect changes in health status . . . and automatically react and rearrange the available options to best suit the condition” of the patient. Ex. 1005 ¶ 63. The supporting expert testimony persuasively relies on this aspect of Naghavi when concluding that “such a change in the severity of a parameter can indicate a change in the patient’s health that may require close monitoring” and a POSITA “would have been motivated to implement this approach of the combination in order to achieve” Naghavi’s objectives. Ex. 1003 ¶ 48 (citing Ex. 1005 ¶ 63); see also Pet. Reply 23 (“[T]he rearrangement of parameters, as already suggested by Naghavi and implemented according to Hochstedler, advantageously ensures an easy-to-use user interface, e.g., by highlighting information that has changed to warrant user attention.” (citing Pet. 13–14; Ex. 1003 ¶¶ 42–43)); Ex. 1003 ¶¶ 42–43.” slip op. at 51
Patent outcomesUS 8,190,223 mixedClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,190,223 - Apple Inc. v. Willow Laboratories, Inc.All claims unpatentablePTAB · Jun 26, 2025 · IPR2024-00296 · APJ Alyssa A Finamore · IPR · Final written decision
Claims 1–4, 6, 8, 10–13, 15, 17, 19–21, 23–26, and 28 are unpatentable as obvious over Abdul-Hafiz and Raley, or over Abdul-Hafiz, Raley, and Secker.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“appear to be that Patent Owner specifies that the POSITA’s knowledge and experience may include optical sensors and that the POSITA may have a degree emphasizing software. We do not deem these differences material, particularly because the optical sensors and technologies at issue are those used in physiological monitoring technologies. Moreover, both parties agree that the POSITA would have a working knowledge of physiological monitoring technologies. Ex. 1003 ¶ 22; Ex. 2079 ¶ 37. Nonetheless, we find the additional specificity of Patent Owner’s definition to be helpful. Also, Patent Owner’s definition appears to be consistent with the level of skill in the art reflected in the prior art of record and the disclosure of the ’911 patent. Accordingly, for purposes of this Decision, we adopt Patent Owner’s proposed definition of the POSITA. We note, however, that we would reach the same outcome under either definition of the POSITA. See also PO Resp. 12 (Patent Owner asserting “under any proposed level of skill, the claims’ patentability is confirmed for at least the reasons set forth below.”).” slip op. at 13
- Expert testimonyPetitioner expert creditedDecided for petitioner
“Dr. Kenny’s explanation finds support in Raley, and we find his explanation credible. Ex. 1079 ¶¶ 9–11. We agree that Raley’s opening 26 has a vertical depth. In order for emitters 21, 22, 23, 24 to be flush with opening 26 as depicted in Raley’s Figure 3 (see PO Resp. 17–18 (arguing that LEDs are flush with opening 26)), the opening must have a depth to accommodate the thickness of the emitters. We further agree that opening 26 is within a solid body, namely interconnect cable 20. We also agree that, in view of the structure and function of Raley’s probe 40 and interconnect cable segment 20, a POSITA would have understood opening 26 is designed to receive the emitters therein. Given that Raley’s interconnect cable segment 20 includes opening 26 that is designed to receive emitters 21, 22, 23, 24 therein, Petitioner has persuaded us that Raley’s LEDs are recessed into a cavity under both the plain and ordinary meaning of “cavity” and Petitioner’s construction from the Delaware Litigation.” slip op. at 27
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed petitioner constructionDecided for petitioner
“testimony regarding a POSITA’s understanding of Figure 11B of Abdul-Hafiz. Ex. 2079 ¶¶ 87–88. More pertinent to claim construction, however, is a POSITA’s understanding of the claim term in view of the Specification. See, e.g., Phillips, 415 F.3d at 1315 (“As we stated in Vitronics, the specification ‘is always highly relevant to the claim construction analysis. Usually, it is dispositive; it is the single best guide to the meaning of a disputed term.’” (quoting Vitronics Corp. v. Conceptronic, Inc., 90 F.3d 1576, 1582 (Fed. Circ. 1996))). In this regard, Petitioner points to Dr. Madisetti’s Rebuttal Expert Report, which was submitted on behalf of Patent Owner in the Delaware Litigation, where, upon reviewing the Specification of the ’911 patent for written description support for the claims, Dr. Madisetti testifies that “[a] POSITA would have known that the detection surface area of a given detector is essentially the entire surface area of the detector.” Ex. 1082 ¶ 912. During oral argument, Patent Owner attempts to reconcile the apparent inconsistency between this testimony and Patent Owner’s proposed construction. Tr. 34:20–36:12. In particular, Patent Owner asserts that, according to the ’911 patent Specification, the entire surface of the light-detecting side of the detector is the area that light reaches because there is “nothing blocking the entire area of the of the light-detecting side of the detector from receiving light.” Id. at 35:12–13. Patent Owner’s assertion, however, ignores EMI shield grid 2444 and foil 2450 that are placed on and at least partly cover the light-detecting side of the detector. Ex. 1001, 13:38–53, Fig. 24. Accordingly, we find Dr. Madisetti’s testimony regarding a POSITA’s understanding of the Petitioner’s construction, and we adopt Petitioner’s construction of “a detection surface area of the at least one detector” as the surface area of the light-detecting side of the detector.” slip op. at 16
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundUnpatentable
“reasons against it in the Sur-reply, we are persuaded that a POSITA would have found it obvious to modify Abdul-Hafiz’s aperture to have an area smaller than the detection surface area to prevent optical noise sources such as ambient light and piped light reaching the detector. We disagree with Patent Owner that Petitioner does not explain why a POSITA would have made Abdul-Hafiz’s aperture smaller than the detection surface area. Preventing optical noise sources explains why a POSITA would have made Abdul-Hafiz’s aperture smaller than the detection surface area because making the area of the aperture smaller than the detection surface area helps prevent optical noise sources from reaching the detector. Even if Abdul-Hafiz’s low noise housing 400 and fixed shield 1005 mitigate optical motivation to make something better. See Dystar Textilfarben GmbH & Co. Deutschland KG v. C.H. Patrick Co., 464 F.3d 1356, 1368 (Fed. Cir. 2006) (“[W]e have repeatedly held that an implicit motivation to combine exists . . . when the ‘improvement’ is technology-independent and the combination of references results in a product or process that is more desirable, for example because it is stronger, cheaper, cleaner, faster, lighter, smaller, more durable, or more efficient.”). Adding an additional protection against optical noise by limiting the diameter of Abdul-Hafiz’s aperture would have enhanced the optical noise mitigation of the low noise housing and fixed shield. Moreover, apart from Abdul-Hafiz, Petitioner does not identify in the prior art an opening having a smaller area than a detection surface area. Petitioner, however, identifies a known relationship between the size of the opening relative to the detection surface area and preventing optical noise from ambient light and piped light. Pet. 50 (citing Ex. 1004 ¶¶ 3, 33); Reply 11–12 (citing Ex. 1011, 96–97, Fig. 6.6; Ex. 1079 ¶¶ 30–32; Ex. 1080 ¶ 73; Ex. 1081, 12:51–63, 14:19–47, 14:28–47). When one parameter is known to influence a specific result, such as the size of the opening relative to the detection surface area preventing optical noise, discovering the optimum value of the parameter is generally obvious. See In re Boesch, 617 F.2d 272, 276 (Fed. Cir. 1980) (“Discovery of an optimum value of a result effective variable in a known process is ordinarily within the skill of the art.” (citing In re Antoine, 559 F.2d 618 (CCPA 1977); In re Aller, 220 F.2d 454 (CCPA 1955))). Furthermore, we agree with Petitioner that the proposed modification to Abdul-Hafiz, namely reducing the area of the aperture to be smaller than the detection surface area, is simple and that a” slip op. at 43
Patent outcomesUS 10,984,911 unpatentableClaim construction§ 103 obviousnesscites PhillipsPatents in suitUS 10,984,911 - PTAB · Jun 26, 2025 · IPR2024-00294 · APJ David Cotta · IPR · Final written decision
Claims 1–20 are unpatentable; proposed substitute claims 21–24 are also unpatentable, so the contingent motion to amend is denied.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“appear to be that Patent Owner specifies that the POSA’s knowledge and experience may include optical sensors and that the POSA may have a degree emphasizing software. We do not deem these differences material, particularly because the optical sensors and technologies at issue are those used in physiological monitoring technologies and both parties agree that the POSA would have a working knowledge of physiological monitoring technologies. Ex. 1003 ¶ 24; PO Resp. 11. We find the additional specificity of Patent Owner’s definition to be helpful. In addition, Patent Owner’s definition appears to be consistent with the level of skill in the art reflected in the prior art of record and the disclosure of the ’507 patent. Accordingly, we adopt Patent Owner’s proposed definition of the person of ordinary skill in the art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (“[T]he prior art itself [may] reflect[] an appropriate level” as evidence of the ordinary level of skill in the art. (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))). We note that we would reach the same outcome under either definition of the POSA. Cf., PO Resp. 12 (asserting that Petitioner’s proposed definition is “flawed” but also asserting that “patentability is confirmed” “[r]egardless of the level of skill”).” slip op. at 14
- Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication establishedDecided for petitioner
“Ex. 1007, 1528. The dispute between the parties focuses on whether D’Angelo was made available to attendees of the IEEE EMBS conference identified in this header and, if so, what effect that has.16 Accordingly, we begin our analysis by considering the conference.” slip op. at 42
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“understood Mendelson to disclose averaging signals. We do not find in Mendelson any discussion of summing or averaging signals. See generally Ex. 1011, 912–915. Our inability to find a teaching of averaging in Mendelson is consistent with the testimony of Drs. Kenny and Duckworth. Dr. Kenny testifies that “there is simply no disclosure in Mendelson itself of any summing or averaging of collected signals.” Ex. 1083 ¶ 23. And in his deposition, Dr. Duckworth was unable to identify any express disclosure of averaging in Mendelson. See Ex. 1087, 103:9–114:11 (confirming that certain aspects of his declaration testimony relating to averaging of signals are not discussed in Mendelson). Accordingly, Mendelson, standing alone, does not support that the POSA would have understood Mendelson’s Sensor Module to have output averaged signals” slip op. at 28
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundUnpatentable
“the PDA to read out ‘data that’s been stored’ (i.e., previously measured physiological data) even after the Receiver Module’s battery had died” because Mendelson’s Receiver Module lacks “a microSD card or other nonvolatile storage from which measured data could be ‘read out’ after its battery has died.” PO Resp. 37; see also Ex. 2037 ¶ 147 (testimony of Dr. Duckworth confirming that Mendelson’s system could not store data that could be read out after its battery died). Accordingly, Patent Owner argues the POSA “would not have been motivated to modify Mendelson’s Receiver Module to draw power from the PDA as proposed because doing so would not allow the PDA to ‘read out’ the previously ‘measured physiological data’ after the Receiver Module’s battery died.” PO Resp. 39.” slip op. at 60
§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 10,736,507 - Apple Inc. v. Masimo CorporationSome claims unpatentablePTAB · Jun 25, 2025 · IPR2024-00290 · APJ Richard H Marschall · IPR · Final written decision
Claims 1–3, 6, 11–17, 19, 21, 22, 27, 28, 32, 34, 36, 37, and 42–44 are unpatentable as obvious; claims 4, 18, and 20 were not shown unpatentable.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“In our Institution Decision, we deemed the differences in the parties’ proposals not material due to their substantial overlap, adopted Patent Owner’s proposal for purposes of that Decision, noted that the outcome of the Decision would not change if we adopted Petitioner’s proposal, and instructed the parties to “explain the differences and their relevance to the patentability issues in this case, and state whether any issue in the case turns on those differences” if either party continued to propose differing proposals during trial. Inst. Dec. 10–11. After institution, neither party has explained the materiality of the differences in their proposals or argued that any issues in this case turn on those differences. Based on our review of the parties’ proposals, we find Patent Owner’s proposal consistent with the level of skill exemplified by the prior art of record and the disclosure of the ’223 patent. Accordingly, we apply Patent Owner’s proposal in our analysis in this Decision. See Okajima, 261 F.3d at 1355 (“[T]he prior art itself” may reflect an appropriate level of the ordinary level of skill in the art. (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))). The outcome of this Decision would not change if we applied Petitioner’s proposed definition.” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed patent owner constructionDecided for petitioner
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“preponderance of the evidence that the combination of Naghavi, Hochstedler, and Burnes discloses all of the limitations in claim 1. b. Motivation to Combine After summarizing its proposed combination, Petitioner provides a number of reasons for combining the references. Pet. 9–17. Petitioner breaks its motivation to combine arguments into three separate categories that we address below. See id. at 13–17. Patent Owner raises a number of arguments in support of its contention that “a POSITA would not have been motivated to combine the references to replace a measured value of one parameter with the measured value of another parameter,” which we address in the context of Petitioner’s arguments below. See PO Resp. 44–57. Many of Patent Owner’s arguments rely on Patent Owner’s proposed claim constructions for “replaced” and “measured value,” which we do not adopt for the reasons discussed above. For example, the first sentence in Patent Owner’s argument contends that “Naghavi, Hochstedler and Burnes do not disclose using the same screen area to display two currently measured parameters,” but we do not read the claims as requiring the display of “two currently measured parameters” consistent with Patent Owner’s construction for “measured values.” See id. at 44 (citing Ex. 2042 ¶ 125). Such arguments lack weight given that we have rejected their premise, and although Patent Owner’s arguments are suffused with references to its claim constructions, we attempt to identify where Patent Owner does not rely on those constructions in our analysis below.” slip op. at 47
Patent outcomesUS 8,190,223 mixedClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,190,223 - Azurity Pharmaceuticals, Inc. v. Exelixis Inc.Institution deniedPTAB · Jun 4, 2025 · IPR2025-00210 · APJ Jeffrey N Fredman · IPR · Institution
The Board denied institution on all grounds because Petitioner did not show a reasonable likelihood of proving claims 1–3 unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Accordingly, we find that on the current record Petitioner has not shown that the combination of Brown, Kubo, and Remington would inherently result in less than 200 ppm impurity and Petitioner has not shown that it has a reasonable likelihood that it would prevail on the obviousness ground.” slip op. at 29
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportPriority date awardedReference not prior artDecided for patent owner
“Here, there is no dispute that the ’349 patent and Wilson, which issued from a patent application from which priority was claimed for the ’349 patent, share the identical disclosure of a pharmaceutical composition comprising Compound IA or IB; one or more fillers; one or more disintegrants; one or more glidants; and one or more lubricants. In this embodiment, the filler comprises microcrystalline cellulose. In this embodiment, the disintegrant comprises croscarmellose sodium. In this embodiment, the disintegrant comprises croscarmellose sodium and sodium starch glycolate. In this embodiment, the glidant comprises fumed silica. In this embodiment, the lubricant comprises stearic acid. Ex. 1001, 21:1–12; Ex. 1002, 20:51–62. There is express ipsis verbis disclosure of the elements recited in claim 1 of the ’349 patent.” slip op. at 13
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“1. Reason to reduce contaminant levels We agree with Patent Owner that Petitioner identifies no teaching in the prior art providing any reason to reduce levels of 6,7-dimethoxy-quinoline-4-ol specifically. And while Brown does teach a desire to form “substantially pure” compounds, Brown focuses on “at least about 90 wt.%” of the compound, then lists specifically “about 90, about 91, about 92, about 93, about 94, about 95, about 96, about 97, about 98, about 99 and about 100% wt. %.” Ex. 1003 ¶ 97. This permits a range of concentration for contaminants from about 0 to 10%.” slip op. at 24
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element) › Inherent disclosureInherency not foundNot shown unpatentable
“to modify Brown’s process with Kubo to eliminate the added step. See, e.g., Id. ¶ 73. But even with that combination, Dr. Dichtel states only that a “POSA would have expected there to be a decrease in the amount of 6,7- dimethoxy-quinoline-4-ol at the end of cabozantinib (L)-malate’s synthesis that was attributable to hydrolytic degradation of the 4- (nitrophenoxy)quinoline intermediate by avoiding its use in the synthesis.” Id. ¶ 78. That is not, however, the standard for inherency. It must be the necessary result, not a possible expected result. The Federal Circuit in Par explained that: Inherency, however, may not be established by probabilities or possibilities. The mere fact that a certain thing may result from a given set of circumstances is not sufficient. If, however, the disclosure is sufficient to show that the natural result flowing from the operation as taught would result in the performance of the questioned function, it seems to be well settled that the disclosure should be regarded as sufficient.” slip op. at 28
§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,298,349 - Precision Cancer Technologies Inc. v. Oncoustics Inc.Institution deniedPTAB · Jun 3, 2025 · IPR2025-00242 · APJ David Cotta · IPR · Institution
The Board denied institution on claims 1–20 because Petitioner did not show a reasonable likelihood of prevailing on any asserted anticipation or obviousness ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Under 35 U.S.C. § 314(a), inter partes review may not be instituted unless the Petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Petitioner has not established a reasonable likelihood of prevailing on its assertion that any of the challenged claims are unpatentable based on the grounds advanced here. Thus, for reasons explained below, we deny institution of inter partes review of claims 1–20 of the ’330 patent.” slip op. at 2
- Claim Construction › Intrinsic evidence (Phillips canons) › Prosecution history disclaimer / disavowalDisclaimer foundDecided for patent owner
“area” in the challenged claims was added by amendment. Ex. 1004, 181.8 In making the amendment, Applicant stated that the language added by amendment was intended to distinguish the pending claims over Uniyal,9 which Applicant characterized as disclosing a “time series” of ultrasound data. Uniyal relies on a time series of ultrasound data. In order to distinguish Uniyal, the claims have been amended to recite a single static set of ultrasound RF data in a single frame of the tissue area. As explained in the Interview, the claims rely on a signle [sic, single] “snapshot” frame of the ultrasound RF data rather than a time series or [sic, of] RF data as disclosed in Uniyal. Applicant respectfully submits the amended claims are allowable over all of the cited reference. Id. at 186–187; see also id. at 185 (Applicant’s remarks accompanying amendment, stating: “As explained in the Interview, a static set of raw ultrasound RF signals is collected for an area. This is a snapshot of the tissue area as opposed to taking a time series of RF signals”), 191 (Examiner interview summary, stating: “Inventor noted that Uniyal uses a time series US [ultrasound] data whereas the invention uses images that are non-coherent in time (e.g., a static frame)”).” slip op. at 9
- Expert testimonyPetitioner expert discountedDecided for patent owner
“transducer, Petitioner points to Hope-Simpson’s teaching that its neural network may be “capable of ‘analyzing patterns using a with a [sic] multi-dimensional (2-or more dimensional) data set, which may also be thought of as localized data sets.’” Id. at 22 (quoting Ex. 1005 ¶ 6; alteration by Petitioner). Petitioner then asserts that “[t]he localized data sets described by Hope-Simpson are equivalent to the claimed ‘single set of raw ultrasound [RF] data forming a single frame of a tissue area.” Pet. 22 (citing Ex. 1002 ¶ 86 (testimony of Dr. Papanicolau)). But Petitioner does not explain why Hope-Simpson’s “localized data sets” equate with a single frame of a tissue area rather than, for example, a time series of frames taken at the same location. Pet. 22. Petitioner cites the testimony of Dr. Papanicolau, but Dr. Papanicolau’s testimony lacks both technical reasoning and evidentiary support; it simply mirrors the statement in Petition. Ex. 1002 ¶ 86. For this reason, we give Dr. Papanicolau’s ipse dixit testimony little weight. Xerox Corp. v. Bytemark, Inc., IPR2022-00624, Paper 9 at 15 (PTAB Aug. 24 ,2022) (Decision Denying Institution) (precedential) (finding that conclusory testimony that “does not cite to any additional supporting evidence or provide any technical reasoning to support [that testimony] . . . is entitled to little weight”); see also, 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”). Accordingly, to the extent this is the data that Hope Simpson provides to the processor, on this record, Petitioner has not sufficiently established that it constitutes a “single static set” of raw RF ultrasound data “forming a single frame.”” slip op. at 15
Claim constructioncites KSR · GrahamPatents in suitUS 11,602,330
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.