• Tesla, Inc. v. Intellectual Ventures II LLCNo claims unpatentable
  PTAB · Jun 23, 2026 · IPR2025-00219 · APJ Frederick C Laney · IPR · Final written decision

  Claims 11–22 were not shown unpatentable under any § 103 ground because the prior art did not teach or suggest receiving the claimed resource allocation and multi-level TPC command on one physical channel.

  RulingsFinal written decision

  • BurdenNot shown unpatentable

    “onset to show with particularity why the patent it challenges is unpatentable.” Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1363 (Fed. Cir. 2016) (citing 35 U.S.C. § 312(a)(3) (requiring inter partes review petitions to identify “with particularity . . . the evidence that supports the grounds for the challenge to each claim”)). This burden of persuasion never shifts to the patent owner. See Dynamic Drinkware, LLC v. Nat’l Graphics, Inc., 800 F.3d 1375, 1378 (Fed. Cir. 2015). Moreover, a petitioner should 1 The Leahy-Smith America Invents Act (“AIA”), Pub. L. No. 112-29, 125 Stat. 284 (2011), amended 35 U.S.C. § 103, effective March 16, 2013. Because the application from which the ’153 patent issued claims priority to an application filed before this date, the pre-AIA version of § 103 applies. not “place the burden on [the Board] to sift through information presented by the Petitioners, determine where each element [of the challenged claims] is found in [the cited references], and identify any differences between the claimed subject matter and the teachings of [the cited references.]” Google Inc. v. EveryMD.com LLC, IPR2014-00347, Paper 9 at 25 (PTAB May 22, 2014).” slip op. at 5

  • Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner

    “The second and third asserted benefits—reduced complexity and reduced latency—rest on the declaration of Dr. Kotzin (Ex. 1003 ¶ 64) rather than on any disclosure of Andersson or Khan. We accord that testimony little weight on this point because it asserts the benefits in conclusory terms without explaining why they would result from inserting a scheduling grant into Andersson’s undefined “other bits,” as distinct from Khan’s separate-slot design.” slip op. at 20

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “A. Level of Ordinary Skill in the Art Petitioner asserts that ordinarily skilled artisans “would have a bachelor’s degree in electrical engineering, computer engineering, computer science, or equivalent training, and approximately two years of experience working in the field of wireless communication systems or design of similar communication systems.” Pet. 14. Petitioner’s proposed definition, which Patent Owner does not dispute, appears reasonable and consistent with the asserted prior art and the ’500 Patent. Therefore, we adopt it as the ordinary level of skill of an artisan in the field of the patented technology for our analysis below.” slip op. at 7

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Patent Owner offers a proposed construction for the recited “single physical channel” found in limitation 11.2 and “an accumulation of TPC commands” found in independent claims 12 and 18. PO Resp. 9–17. Petitioner likewise addresses the scope of an accumulation of TPC commands, but Petitioner does not contest directly Patent Owner’s proposed construction for “single physical channel.” Pet. Reply 2–7. We determine, however, that no express construction of any claim term is necessary to resolve the dispute between the parties. Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 8

  Patent outcomesUS 9,706,500 not shown unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 9,706,500
• Apple Inc. v. Theta IP, LLCSome claims unpatentable
  PTAB · Nov 25, 2025 · IPR2024-00819 · APJ Russell E Cass · IPR · Final written decision

  Claims 1–19 are unpatentable as obvious over Behbahani, Leete, and Tan; claim 20 was not shown unpatentable because the references did not teach its required comparison of desired and interferer signal strengths.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “Petitioner thus proposes a Master’s degree with two years of experience, while Patent Owner proposes a Bachelor’s degree with five years of experience. At the institution stage, we did not see a material difference in the proposals given that both parties also indicate that more education could substitute for less experience and vice versa, and thus adopted Patent Owner’s proposal. Inst. Dec. 9. We requested that the parties address during trial if either believed that the choice of one proposal over the other would make a difference in the patentability analysis. Id. Neither party has done so. Accordingly, because nothing in the record persuades us that our preliminary finding in the Institution Decision was incorrect, and because neither party has challenged our finding, we maintain our adoption of Patent Owner’s proposed level of ordinary skill in the art.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for patent owner

    “Here, as in the Director’s example, Petitioner advanced a narrower construction of the dynamic limitations before the district court, which the district court declined to adopt. Pet. 9; Ex. 2015; Ex. 2025, 31–47. Instead, the district court adopted a “plain-and-ordinary meaning” construction, which Patent Owner proposed. PO Resp. 38; PO Sur-reply 10 n.2; Ex. 2015; Ex. 2025, 31–47. In the Petition, Petitioner proposed applying the plain and ordinary meaning construction that had already been preliminarily adopted by the district court. Compare Pet. (filed May 1, 2024) with Ex. 2015 (preliminarily adopting plain and ordinary meaning construction on March 25, 2024). Applying Revvo, we find that Petitioner had a sufficient reason for advancing the broader, court-adopted construction in this IPR. Thus, we give the dynamic limitation its plain-and-ordinary meaning, which is “adjusting during operation based—at least in part—on information gained during operation.”” slip op. at 13

  • Prior constructionPrior construction adoptedDecided for patent owner

    “In our Institution Decision, we stated that we “will give the term ‘signal path’ its ‘plain and ordinary meaning’ and not limit it only to analog components, as the district court found and the parties agree.” Inst. Dec. 11. Given that the parties continue to agree on this point, we see no need to depart from the construction we adopted in our Institution Decision. Moreover, applying Revvo, we find that Petitioner had a sufficient reason for advancing the broader, court-adopted construction in this IPR for the same reasons as discussed above. In this proceeding, the dispute between the parties concerns the application of this and the surrounding claim language (i.e., “in the receiver signal path,” “in the signal path”) to the disclosures in Behbahani. See PO Resp. 43–45. Therefore, we will provide further discussion in the context of the parties’ arguments regarding Behbahani below. However, we agree with Patent Owner’s plain reading of the claim language to the extent it requires adjusting an impedance and/or bias current of a circuit while it is in the signal path. See Id. at 50–51.” slip op. at 14

  • Expert testimonyPatent owner expert discountedOther

    “Patent Owner’s arguments generally fail to address why Behbahani’s Variable Bandpass Filter Block does not teach the recited “plurality of circuits [comprising/including] . . . a filter,” and instead focus on why the low-pass and high-pass filter circuits do not teach the limitation, which is not Petitioner’s position. As stated above, we agree with Patent Owner’s plain reading of the claim language – i.e., that it “requires adjusting the bias, in or of a circuit.” See PO Resp. 49. However, Patent Owner’s reading of the claim does not persuasively address why the Variable Bandpass Filter Block does not teach the recited “circuit.” We have reviewed Dr. Larson’s cited testimony and disagree with Patent Owner that he provided “a well-supported opinion . . . as to why a [person of ordinary skill in the art] would not understand the entire bandpass box to be a single ‘circuit,’ or to reflect variation in ‘an impedance’ or ‘a bias’ in the claims.” Sur-reply 4 (citing Ex. 2020 ¶¶ 46–48, 71, 74–83). Dr. Larson testifies that the ’330 patent (which has the same specification as the ’164 patent) “teach[es] these adjustments [that dynamically change operating parameters] as changes effected in a single circuit block.” Ex. 2020 ¶ 46 (citing, e.g., Ex. 1001, Figs. 8A, 9A, 8:20–25, 8:36–39, 9:36–59, 10:1–18 (emphasis added)). Dr. Larson does not provide further explanation as to what he means by a “single circuit block,” but relies on Figures 8A and 9A, which show a “function block,” and other disclosures referring to a “function block.” See id. There is no dispute that the recited “circuit” in the receiver signal path is referring to these “function blocks.” See Tr. 22:20–23:4. The ’164 patent states that Figure 8A, which includes function block 820, is “an embodiment of the present invention” 8:28–30. Similarly, Figure 9A, which includes function block 920, “illustrate[s] one of the possible power saving techniques.” Id. at 3:41–42. The ’164 patent describes that “[f]unctional block 820 . . . may be a filter, mixer, amplifier, or other circuit or circuits in a wireless transceiver or other electronic circuits or system.” Id. at 8:30–33 (emphasis added). Based on these disclosures, we are not convinced that Function Block 820 or 920 cannot include multiple filters in a Variable Bandpass Filter Block, or that Behbahani’s Variable Bandpass Filter Block does not teach the recited “circuit.” Dr. Larson also relies on Figure 6 of the ’164 patent to conclude that” slip op. at 45

  Patent outcomesUS 11,564,164 mixed
  Claim construction§ 103 obviousnessDiscretionary denialcites KSR · Graham
  Patents in suitUS 11,564,164
• Apple Inc. v. Theta IP, LLCAll claims unpatentable
  PTAB · Nov 24, 2025 · IPR2024-00816 · APJ Russell E Cass · IPR · Final written decision

  Claims 1–7, 9–13, 16, 23, 25–27, and 29 are unpatentable as obvious over Behbahani, Leete, and Tan.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “Petitioner thus proposes a Master’s degree with two years of experience, while Patent Owner proposes a Bachelor’s degree with five years of experience. At the institution stage, we did not see a material difference in the proposals given that both parties also indicate that more education could substitute for less experience and vice versa, and thus adopted Patent Owner’s proposal. Inst. Dec. 11. We requested that the parties address during trial if either believed that the choice of one proposal over the other would make a difference in the patentability analysis. Id. Neither party has done so. Accordingly, because nothing in the record persuades us that our preliminary finding in the Institution Decision was incorrect, and because neither party has challenged our finding, we maintain our adoption of Patent Owner’s proposed level of ordinary skill in the art.” slip op. at 10

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner

    “Here, as in the Director’s example, Petitioner advanced a narrower construction of the dynamic limitations before the district court, which the district court declined to adopt. Pet. 10; Ex. 2015; Ex. 2025, 31–47. Instead, the district court adopted a “plain-and-ordinary meaning” construction, which Patent Owner proposed. PO Resp. 36–38; PO Sur-reply 10 n.2; Ex. 2015; Ex. 2025, 31–47. In the Petition, Petitioner proposed applying the plain and ordinary meaning construction that had already been preliminarily adopted by the district court. Compare Pet. (filed May 1, 2024) with Ex. 2015 (preliminarily adopting plain and ordinary meaning construction on March 25, 2024). Applying Revvo, we find that Petitioner had a sufficient reason for advancing the broader, court-adopted construction in this IPR. Thus, we give the dynamic limitation its plain-and-ordinary meaning, which is “adjusting during operation based—at least in part—on information gained during operation.”” slip op. at 14

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable

    “Variable Bandpass Filter Block does not teach the recited “component” or “impedance” that is dynamically adjusted, and instead focus on why the low-pass and high-pass filter circuits do not teach the limitation, which is not Petitioner’s position. As stated above, we agree with Patent Owner’s plain reading of the claim language – i.e., that it “requires adjusting a variable impedance of a circuit or component thereof, while it is in the signal path.” See PO Resp. 49. However, Patent Owner’s reading of the claim does not persuasively address why the Variable Bandpass Filter Block does not teach the recited “circuit” or “component.” We have reviewed Dr. Larson’s cited testimony and disagree with Patent Owner that he provided “a well-supported opinion . . . as to why a [person of ordinary skill in the art] would not understand the entire bandpass box to be “a component,” “a circuit,” or “an impedance” in the claims.” Sur-reply 4 (citing Ex. 2020 ¶¶ 46–48, 71, 74–83). Dr. Larson testifies that the ’330 patent “teach[es] these adjustments [that dynamically change operating parameters] as changes effected in a single circuit block.” Ex. 2020 ¶ 46 (citing, e.g., Ex. 1001, Figs. 8A, 9A, 8:20–25, 8:36–39, 9:36–59, 10:1–18 (emphasis added)). Dr. Larson does not provide further explanation as to what he means by a “single circuit block,” but relies on Figures 8A and 9A, which show a “function block,” and other disclosures referring to a “function block.” Id. There is no dispute that the recited “circuit” or “component” in the receiver signal path is referring to these “function blocks.” See Tr. 22:20–23:4. The ’330 patent states that Figure 8A, which includes function block 820, is “an embodiment of the present invention” that describes a “possible power saving technique[].” Ex. 1001, 3:30–33, 8:20–25. Similarly, Figure 9A, which includes function block 920, “illustrate[s] one of the possible power saving techniques.” Id. at 3:33–34. The ’330 patent describes that “[f]unctional block 820 . . . may be a filter, mixer, amplifier, or other circuit or circuits in a wireless transceiver or other electronic circuits or system.” Ex. 1001, 8:22–25 (emphasis added). Based on these disclosures, we are not convinced that Function Block 820 or 920 cannot include multiple filters in a Variable Bandpass Filter Block, or that Behbahani’s Variable Bandpass Filter Block does not teach the recited “circuit,” “component,” or “impedance.”” slip op. at 42

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner

    “The absence of meaningful disclosure of the implementation details of the circuit in the ’330 patent suggests that the circuit implementation details Patent Owner argues about now would have been within the understanding of a person of ordinary skill in the art. That is, Patent Owner did not provide in its own specification “the type of detail [it] now argues is necessary in prior art references,” which permits a “finding that one skilled in the art would have known how to implement the features of the references and would have concluded that the reference disclosures would have been enabling.” In re Epstein, 32 F.3d 1559, 1568 (Fed. Cir. 1994). When a patent specification does not “specifically describe[]” any “equipment or techniques to be used,” it may be deduced “that all of the equipment and technical knowledge required to perform the claimed method” is known to one of ordinary skill in the art. In re Fox, 471 F.2d 1405, 1407 (CCPA 1973); see also Southwire Co. v. Cerro Wire LLC, 870 F.3d 1306, 1312 (Fed. Cir. 2017) (without proof to the contrary, when there is no focus on a disputed claim limitation in the specification, the limitation is merely “an observed result of an old process”). To that end, Petitioner provides persuasive testimony from Dr. Abidi that signal strength measurement circuits were known in the art, and that a person of ordinary skill in the art would have understood how to implement a known technique for measuring signal strength, which is not disputed by Patent Owner. Ex. 1003 ¶¶ 180– 181; Ex. 1042 ¶¶ 12–16; see Pet. Reply 24–26; Pet. 60–62. Accordingly, we agree with Petitioner that Behbahani’s disclosure at least suggests circuitry for performing such a determination of signal strength. See Pet. Reply 24 (citing Pet. 60–61; Ex. 1003 ¶¶ 92–98, 179–181). Petitioner further argues that Tan “provides an example of circuitry used to detect signals at various points in the low-pass filter signal path as a means of implementing a prefilter automatic gain control.” Pet. 60–61 (citing Ex. 1006, 481); Ex. 1003 ¶ 180. The example in Tan is a peak detector circuit. Pet. 61; Ex. 1003 ¶ 180; Ex. 1006, Fig. 8. Dr. Abidi testifies that a person of ordinary skill in the art would have been motivated to use Tan’s signal strength measurement circuitry to measure nodes AI and AO. Ex. 1003 ¶ 180. In response to Patent Owner’s argument that Petitioner does not sufficiently explain how to use Tan’s peak detector in Behbahani (PO Resp. 70), Dr. Abidi provides testimony explaining how Tan’s peak detector circuit provides a measure of the signal strength, which we find persuasive, and is unrebutted by Patent Owner. Ex. 1042 ¶ 15.” slip op. at 30

  Patent outcomesUS 7,010,330 unpatentable
  Claim construction§ 103 obviousnessDiscretionary denialcites KSR · Graham
  Patents in suitUS 7,010,330
• Apple Inc. v. Theta IP, LLCAll claims unpatentable
  PTAB · Nov 24, 2025 · IPR2024-00817 · APJ Kara L Szpondowski · IPR · Final written decision

  Claims 1–8 are unpatentable as obvious over Behbahani, Leete, and Tan; Patent Owner’s motion to strike is denied.

  RulingsFinal written decision

  • Strike new argumentNew argument consideredDenied

    “Pursuant to 37 C.F.R. § 42.23(b), a reply “may only respond to arguments raised in the corresponding . . . patent owner response.” We agree with Petitioner, for the reasons stated in the Opposition, that the arguments and declaration testimony is responsive to arguments raised in the Patent Owner Response. See Opp Mot. 7–11 (explaining the positions taken in the Petition, Patent Owner’s arguments in Response, and the arguments presented in Reply); Corephotonics, Ltd. v. Apple Inc., 84 F.4th 990, 1008– 1009 (Fed. Cir. 2023). Petitioner does not provide a new theory of unpatentability; rather, Petitioner responds and elaborates on the theory presented in the Petition to explain why Patent Owner’s arguments are incorrect. E.g., Chamberlain Grp., Inc. v. One World Techs., Inc., 944 F.3d 919, 925 (Fed. Cir. 2019) (“Parties are not barred from elaborating on their arguments on issues previously raised.”); Belden Inc. v. Berk-Tek LLC, 805 F.3d 1064, 1081–82 (Fed. Cir. 2015) (reasoning that rebuttal evidence should be responsive such that it is offered “to explain, repel, counteract, or disprove the evidence of the adverse party”). “[T]he introduction of new evidence in the course of the trial is to be expected in [IPR] trial proceedings” and permissible “as long as the opposing party is given notice of the evidence and an opportunity to respond to it.” Genzyme Therapeutic Prods. Ltd. P’ship v. Biomarin Pharm. Inc., 825 F.3d 1360, 1366 (Fed. Cir. 2016).” slip op. at 12

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “Petitioner thus proposes a Master’s degree with two years of experience, while Patent Owner proposes a Bachelor’s degree with five years of experience. At the institution stage, we did not see a material difference in the proposals given that both parties also indicate that more education could substitute for less experience and vice versa, and thus adopted Patent Owner’s proposal. Inst. Dec. 11. We requested that the parties address during trial if either believed that the choice of one proposal over the other would make a difference in the patentability analysis. Id. Neither party has done so. Accordingly, because nothing in the record persuades us that our preliminary finding in the Institution Decision was incorrect, and because neither party has challenged our finding, we maintain our adoption of Patent Owner’s proposed level of ordinary skill in the art.” slip op. at 15

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for patent owner

    “Thus, the parties do not dispute the meaning of “signal path,” and we adopt the district court’s construction of plain and ordinary meaning, as agreed by the parties. See PO Resp. 40–41; Pet. 9; Ex. 2025, 14. The dispute concerns the application of this and the surrounding claim language (i.e., “in the receiver signal path”) to the disclosures in Behbahani. See PO Resp. 40–42. Therefore, we will provide further discussion in the context of the parties’ arguments regarding Behbahani below. However, we agree with Patent Owner’s plain reading of the claim language in limitation 1(e) and the corresponding limitations in independent claims 3, 5, 7, and 8 – i.e., that “[t]he plain language requires adjusting a bias current, or a bias current and an impedance, in a circuit, while it is in the signal path.” See PO Resp. 48. We determine that it is not necessary to provide an express interpretation of any other claim terms for purposes of this Decision. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017); Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”).” slip op. at 20

  • Settled expectationsNot reached

    “Owner’s] settled expectations in long-standing patent rights, and Office policies and efficiency.” Id.; see id. at 25–26. Patent Owner’s arguments essentially reassert the arguments made in the Preliminary Response that inter partes review should be discretionarily denied under 35 U.S.C. § 314(a) and 35 U.S.C. § 325(d). In the Institution Decision, we were not persuaded by these arguments. Inst. Dec. 15–22. Patent Owner argues that in Ecto World, LLC v. RAI Strategic Holdings, Inc., IPR2024-01280, Paper 13 (PTAB May 19, 2025) (§ A precedential) supports denial under 35 U.S.C. § 325(d). Sur-reply 25. However, Ecto World was designated precedential on May 19, 2025, and our Standard Operating Procedure 2 provides that “[a] precedential decision is binding Board authority in subsequent matters involving similar facts or issues.” SOP2, 7 (emphasis added). Therefore, re-evaluation under Ecto World does not appear to be appropriate under the circumstances here. Patent Owner also argues that proceedings can be properly dismissed post-institution in the Director’s discretion. Sur-reply 26. In support, Patent Owner cites to Hulu LLV v. Piranha Media Distribution, LLC, IPR2024- 01252, Paper 17, at 3 (PTAB April 17, 2025). Id. However, in Hulu, the patent owner timely sought Director Review after the institution decision, and upon Director Review, the institution decision was vacated and denied. IPR2024-01252, Papers 16, 19, 27. By contrast, here, Patent Owner raised this issue for the first time in the Sur-reply (filed August 5, 2025, nearly three months after Ecto World was designated precedential), approximately three weeks prior to oral argument. Patent Owner also did not file a motion to terminate the proceeding. Although we recognize that “that the Board has the inherent authority to reconsider institution decisions (beyond the regulatory time for a patentee’s entitlement to seek reconsideration),” Sling TV, L.L.C. v. Realtime Adaptive Streaming LLC, 840 F. App’x 598, 598–99 (Fed. Cir. 2021), we decline to do so at this late stage in the proceeding.” slip op. at 63

  Patent outcomesUS 10,129,825 unpatentable
  Claim construction§ 103 obviousnessDiscretionary denialcites KSR · Graham
  Patents in suitUS 10,129,825
• Apple Inc. v. Theta IP, LLCNo claims unpatentable
  PTAB · Nov 24, 2025 · IPR2024-00818 · APJ Kara L Szpondowski · IPR · Final written decision

  Claims 1, 2, and 4–23 were not shown unpatentable over Behbahani, Leete, and Tan because the combination did not teach comparing desired and interferer signal strengths.

  RulingsFinal written decision

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached

    “Behbahani teaches “comparing the strength of the desired signal to the strength of the interfere signal,” as recited in limitation 1(a). See PO Resp. 68–69; Sur-reply 21–23. Although Petitioner argues that Behbahani “expressly teaches comparing the desired and interferer signal strengths,” Petitioner does not cite to sufficient evidence in support of this statement. Pet. 38. The basis of Petitioner’s argument is that Behbahani teaches the same process for determining signal strengths as shown in Figure 4 of the ’202 patent. Figure 4 of the ’202 patent is reproduced below: Figure 4 shows, among other things, signal strength indicator circuits 440 and 450 connected to input line 410 and output line 460, on either side of gain element 420 and filter 430. Ex. 1001, 6:53–57. The input signal on input line 410 is shown as desired signal 412 and interferers 464 and 466. Id. at 59–61. Figure 4 is further described as follows. The signal strength indicators 440 and 450 do not provide information as to the relative sizes of the desired and interfering signals. Rather, a cumulative signal level is provided at their outputs. For example, the first signal strength indicator 440 outputs a level corresponding to the sum of desired signal 412 and interfering signals 414 and 416, while the second signal strength indicator 450 provides a signal level corresponding to the sum of desired signal 462 and interfering signals 464 and 466. In this specific example, the gain of the gain and filter circuit combinations is shown as approximately one, while the interfering signals 414 and 416 signal levels are reduced. A comparison of the signal levels provided by the signal strength indicators 440 and 450 indicates that much of the combined received signal on line 410 has been filtered. Accordingly, it may be deduced that large interfering signals present at the input are being filtered by the filter 430. From this information, as will be shown in greater detail below, the bias, impedance, and gain of the gain stage 420 and filter 430 combination may be optimized to reduce power dissipation. Ex. 1001, 6:61–7:13 (emphasis added). In other words, Figure 4 shows a comparison of a sum of the desired and interferer signals output from the strength indicator circuits, not a comparison of the strength of the desired signal and the strength of the interferer signal, as required by the claim language. See Sur-reply 22–23. The ’202 patent describes Figure 4 as “an embodiment,” and claims are not limited to specific embodiments described in the specification. See Phillips v. AWH Corp., 415 F.3d 1303, 1323 (Fed. Cir. 2005) (en banc). Petitioner even admits that Figure 4 “compar[es] a cumulative signal strength at a first node to a cumulative signal strength at a second node.” Pet. 36 (emphasis added). In the Reply, Petitioner argues that Patent Owner “ignores the” slip op. at 33

  • Strike new argumentNew argument consideredDenied

    “Pursuant to 37 C.F.R. § 42.23(b), a reply “may only respond to arguments raised in the corresponding . . . patent owner response.” We agree with Petitioner, for the reasons stated in the Opposition, that the arguments in the Reply and Reply declaration testimony are responsive to arguments raised in the Patent Owner Response. See Opp Mot. 7–12 (explaining the positions taken in the Petition, Patent Owner’s arguments in Response, and the arguments presented in Reply); see Corephotonics, Ltd. v. Apple Inc., 84 F.4th 990, 1008–1009 (Fed. Cir. 2023). Petitioner does not provide a new theory of unpatentability; rather, Petitioner responds and elaborates on the theory presented in the Petition to explain why Patent Owner’s arguments are incorrect. E.g., Chamberlain Grp., Inc. v. One World Techs., Inc., 944 F.3d 919, 925 (Fed. Cir. 2019) (“Parties are not barred from elaborating on their arguments on issues previously raised.”); Belden Inc. v. Berk-Tek LLC, 805 F.3d 1064, 1081–82 (Fed. Cir. 2015) (reasoning that rebuttal evidence should be responsive such that it is offered “to explain, repel, counteract, or disprove the evidence of the adverse party”). “[T]he introduction of new evidence in the course of the trial is to be expected in [IPR] trial proceedings” and permissible “as long as the opposing party is given notice of the evidence and an opportunity to respond to it.” Genzyme Therapeutic Prods. Ltd. P’ship v. Biomarin Pharm. Inc., 825 F.3d 1360, 1366 (Fed. Cir. 2016). We also note that our Consolidated Trial Practice Guide (“CTPG”) states that In most cases, the Board is capable of identifying new issues or belatedly presented evidence when weighing the evidence at the close of trial, and disregarding any new issues or belatedly presented evidence that exceeds the proper scope of reply or sur-reply. As such, striking the entirety or a portion of a party's brief is an exceptional remedy that the Board expects will be granted rarely. CTPG at 80, 84 Fed. Reg. 64,280 (Nov. 21, 2019). We follow that guidance here. Further, Patent Owner argues that Dr. Abidi’s testimony as a co- author of Behbahani is “self-serving and unsupported.” Mot. 6–7. The fact that Dr. Abidi is a co-author of Behbahani, as well as Petitioner’s expert, is not, in and of itself, sufficient to discredit Dr. Abidi’s testimony. The CTPG provides that “[t]he Board has broad discretion to assign weight to be accorded expert testimony.” CTPG 35. We are capable of discerning from the testimony and the evidence presented whether Dr. Abidi’s testimony should be entitled to any weight, either as a whole or with regard to specific issues. We will weigh the testimony on an issue-by-issue basis as appropriate. Moreover, to the extent that Patent Owner has pointed out the inadequacies of Dr. Abidi’s testimony, we are also capable of noting those inadequacies and weighing that testimony accordingly. For the foregoing reasons, Patent Owner’s motion to strike is denied.” slip op. at 11

  • Expert testimonyPetitioner expert discountedOther

    “We also disagree with Petitioner that “Dr. Abidi provided well- reasoned analysis that Behbahani teaches determining and comparing desired and interferer signal strengths.” Reply 27 (citing Ex. 1003 ¶¶ 179– 181). We have reviewed the Dr. Abidi’s testimony cited in the Petition and Reply for limitation 1(a) (Ex. 1003 ¶¶ 95, 96, 113–120, 179–181; Ex. 1042 ¶¶ 12–16), and we disagree that Dr. Abidi provided well-reasoned analysis that Behbahani teaches comparing desired signal strengths with interferer signal strengths. Rather, Dr. Abidi’s testimony focuses on determining or measuring desired and interferer signal strengths, generally simply repeats what is in the Petition, and only provides a conclusory assertion that Behbahani expressly teaches comparing the strengths of the desired and interferer signals without providing any explanation. See TQ Delta, LLC v. Cisco Sys., Inc., 942 F.3d 1352, 1358–59 (Fed. Cir. 2019) (“Conclusory expert testimony does not qualify as substantial evidence.”). Accordingly, Dr. Abidi’s supporting testimony is also deficient. See 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”). As Patent Owner points out, the only comparison mentioned by Petitioner in Behbahani is to derive the strength of the interferer signal. Sur-reply 22 (citing Pet. 38–39); Ex. 1004, 1207 (“[B]y comparing the signal level at the input and the output of the digital filter (DI and DO), the relative strength of the out-of-channel signal that passes through the analog filter is calculated”). Accordingly, for the foregoing reasons we determine that Petitioner has not shown that Behbahani teaches limitation 1(a).” slip op. at 36

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “Petitioner thus proposes a Master’s degree with two years of experience, while Patent Owner proposes a Bachelor’s degree with five years of experience. At the institution stage, we did not see a material difference in the proposals given that both parties also indicate that more education could substitute for less experience and vice versa, and thus adopted Patent Owner’s proposal. Inst. Dec. 11. We requested that the parties address during trial if either believed that the choice of one proposal over the other would make a difference in the patentability analysis. Id. Neither party has done so. Accordingly, because nothing in the record persuades us that our preliminary finding in the Institution Decision was incorrect, and because neither party has challenged our finding, we maintain our adoption of Patent Owner’s proposed level of ordinary skill in the art.” slip op. at 14

  Patent outcomesUS 10,524,202 not shown unpatentable
  Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · Graham
  Patents in suitUS 10,524,202
• Apple Inc. v. Theta IP, LLCAll claims unpatentable
  PTAB · Nov 24, 2025 · IPR2024-00820 · APJ Aaron W Moore · IPR · Final written decision

  Claims 1–3, 5–6, and 8–11 are unpatentable as obvious over Behbahani and Tan; Patent Owner’s motion to strike is denied.

  RulingsFinal written decision

  • ExcludeMotion to exclude, deniedDenied

    “Under 37 C.F.R. § 42.23(b), a reply “may only respond to arguments raised in the corresponding . . . patent owner response.” We agree with Petitioner, for the reasons stated in the Opposition, that the arguments and declaration testimony are responsive to arguments raised in the Patent Owner Response. See Opp Mot. 7–10 (explaining the positions taken in the Petition, Patent Owner’s arguments in Response, and the arguments presented in Reply); Corephotonics, Ltd. v. Apple Inc., 84 F.4th 990, 1008– 1009 (Fed. Cir. 2023). Petitioner does not provide a new theory of unpatentability; instead, Petitioner appropriately responds and elaborates on the theory presented in the Petition to explain why Patent Owner’s arguments are incorrect. See, e.g., Chamberlain Grp., Inc. v. One World Techs., Inc., 944 F.3d 919, 925 (Fed. Cir. 2019) (“Parties are not barred from elaborating on their arguments on issues previously raised.”); Belden Inc. v. Berk-Tek LLC, 805 F.3d 1064, 1081–82 (Fed. Cir. 2015) (reasoning that rebuttal evidence should be responsive such that it is offered “to explain, repel, counteract, or disprove the evidence of the adverse party”). “[T]he introduction of new evidence in the course of the trial is to be expected in [IPR] trial proceedings” and is permissible “as long as the opposing party is given notice of the evidence and an opportunity to respond to it.” Genzyme Therapeutic Prods. Ltd. P’ship v. Biomarin Pharm. Inc., 825 F.3d 1360, 1366 (Fed. Cir. 2016).” slip op. at 11

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “Petitioner thus proposes a Master’s degree with two years of experience, while Patent Owner proposes a Bachelor’s degree with five years of experience. At the institution stage, we did not see a material difference in the proposals given that both parties also indicate that more education could substitute for less experience and vice versa, and we thus adopted Patent Owner’s proposal. See Inst. Dec. 14. We requested that the parties address during trial if either believed that the choice of one proposal over the other would make a difference in the patentability analysis. Id. Neither party has done so. Accordingly, because nothing in the record persuades us that our preliminary finding in the Institution Decision was incorrect, and because neither party has challenged our finding, we maintain our adoption of Patent Owner’s proposed level of ordinary skill in the art.” slip op. at 15

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningPrior construction adoptedDecided for petitioner

    “Revvo Techs., Inc. v. Cerebrum Sensor Techs., Inc., IPR2025-00632, Paper 20 at 3–5 (Director Nov. 3, 2025) (precedential), addressing situations where a petitioner takes different claim construction positions before the Board and a district court. In Revvo, the petitioner advanced its own proposed claim construction in a related district court litigation but adopted in the IPR a different proposed construction, which was advanced by the patent owner in the district court litigation. Revvo at 2. The Director acknowledged that “a petitioner is not necessarily precluded from arguing different claim construction positions before a district court and the Board,” but that if the petitioner does so, it “should explain sufficiently why the different positions are warranted.” Id. at 5. “For example,” the Director explained, “if a party advances a narrow construction in the district court and the district court declines to adopt the narrow construction, the party would have sufficient reason for advancing the broader, court-adopted construction in a proceeding before the Board.” Id. Here, as in the Director’s example, Petitioner advanced a narrower construction of “signal path” before the district court, which the district court declined to adopt. See Pet. 9; Ex. 2015. Instead, the district court adopted a “plain-and-ordinary meaning” construction, which Patent Owner proposed. See PO Resp. 38, 41; Ex. 2015; Ex. 2025, 5–14. In the Petition, Petitioner proposed applying the plain and ordinary meaning constructions that had already been preliminarily adopted by the district court. Compare Pet. (filed May 1, 2024) with Ex. 2015 (preliminarily adopting plain and ordinary meaning construction on March 25, 2024). Applying Revvo, we find that Petitioner had a sufficient reason for advancing the broader, courtadopted construction in this IPR. Thus, the parties do not dispute the meanings of “signal path,” and we adopt the district court’s construction of plain and ordinary meaning, as agreed by the parties. The “signal path” dispute concerns the application of this and the surrounding claim language (i.e., “in the receiver signal path”) to the disclosures in Behbahani. See PO Resp. 41–43. Therefore, we will provide further discussion in the context of the parties’ arguments regarding Behbahani below. However, we agree with Patent Owner that “plain language [of the claims] requires adjusting the impedance (or bias) of a circuit or component in the signal path.” PO Resp. 49. The parties also address the meaning of the terms “dynamically increasing/decreasing,” which Petitioner refers to as the “dynamic limitation.” See Pet. 9; PO Resp. 37–41. Petitioner proposes that the Board accept Patent Owner’s proposed construction, which was adopted by the district court in the related litigation, both preliminarily and following the Markman hearing. See Pet. 9–10; Ex. 2015, 2–3; Ex. 2025, 40. At Institution, we adopted the district court’s construction, that the term should be given its plain and ordinary meaning which is “varying during operation based, at least in part, on information gained during operation,”4 because there was no dispute between the parties. See Inst. Dec. 16. We continue to do so for purposes of this Decision, for the same reasons as set forth above. That is, applying Revvo, we find that Petitioner had a sufficient reason for advancing the broader, court-adopted construction in this IPR.” slip op. at 18

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successUnpatentableMotivation foundDecided for petitioner

    “Petitioner further argues that Tan “provides an example of circuitry used to detect signals at various points in the low-pass filter signal path as a means of implementing a prefilter automatic gain control.” Pet. 29 (citing Ex. 1006, 481); Ex. 1003 ¶ 85. The example in Tan is a peak detector circuit. See Pet. 29–30; Ex. 1003 ¶ 85; Ex. 1006, Fig. 8. Dr. Abidi testifies that a person of ordinary skill in the art would have been motivated to use Tan’s signal strength measurement circuitry to measure nodes AI and AO, as well as to use comparable circuity to measure nodes DI and DO. See Ex. 1003 ¶¶ 85–90. In response to Patent Owner’s argument that it is not possible to measure signal strength with Tan’s peak detectors (see PO Resp. 65–68), Dr. Abidi provides testimony explaining how Tan’s peak detector circuit provides a measure of the signal strength, which we find persuasive, and which is unrebutted by Patent Owner. See Ex. 1042 ¶ 15.” slip op. at 34

  Patent outcomesUS 11,638,210 unpatentable
  Claim construction§ 103 obviousnessDiscretionary denialcites KSR · Graham
  Patents in suitUS 11,638,210
• Shenzhen Kangvape Technology Co., Ltd. v. Rai Strategic Holdings, Inc.Other
  PTAB · Jun 25, 2025 · IPR2024-01406 · APJ Jo-Anne M Kokoski · IPR · Remand

  On remand, the Board denied institution of review of claims 1, 3, 4, 8–13, and 15 under § 314(a), finding the Fintiv factors favored discretionary denial.

  RulingsRemand decision

  • PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied

    “stay or evidence exists that one may be granted if a proceeding is instituted.” Fintiv, Paper 11 at 6. A stay of litigation pending resolution of an inter partes review allays concerns about inefficiency and duplication of efforts, and strongly weighs against exercising our authority to deny institution. Fintiv, Paper 11 at 6. The Guidance Memo states that “the Board will apply the Fintiv factors when there is a parallel proceedings at the International Trade Commission.” Guidance Memo 2. Patent Owner asserts that a stay of the ITC Investigation had not been requested at the time of the Institution Decision,7 and argues that “the ITC does not stay investigations pending IPR.” PO Supp. Br. 4. Patent Owner also notes that the Institution Decision issued “just days before the ITC evidentiary hearing.” Id. Accordingly, Patent Owner argues that this factor favors denial. Id. Patent Owner is likely correct that the ITC would not have been inclined to grant a stay if one had been requested at the time the Institution Decision issued. Moreover, the ITC conducted a full evidentiary hearing less than three weeks after the Institution Decision issued, and the target date for the ITC’s final determination is four months before the statutory deadline for the Board’s final written decision. PO Supp. Br. 5. Accordingly, we” slip op. at 9

  Discretionary denial
  Patents in suitUS 11,925,202
• Shenzhen Tuozhu Technology Co., Ltd. v. Stratasys, Inc.Instituted
  PTAB · Jun 18, 2025 · IPR2025-00321 · APJ Christopher M Kaiser · IPR · Institution

  The Board instituted IPR on claims 1, 2, 5–7, 9, 16, and 17, finding a reasonable likelihood that claim 1 is anticipated by Boyer.

  RulingsInstitution decision

  • PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied

    “approximately two weeks before the statutory deadline for a final written decision, but the most recent median time-to-trial statistics for Judge Gilstrap in the Eastern District of Texas indicate that the actual trial date will likely be in July 2026, which is later than the statutory deadline to issue a final written decision in this proceeding in mid-June 2026. See Ex. 2001, 7 (median time from filing to trial of 23.2 months); Prelim. Resp. 10. Thus, we find this factor is neutral or weighs slightly against discretionary denial.” slip op. at 10

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted

    “At this preliminary stage, we determine whether the information presented shows a reasonable likelihood that Petitioner would prevail in establishing that at least one of the challenged claims would have been unpatentable over the proposed prior art. We analyze the asserted grounds with the above-noted principles in mind.” slip op. at 7

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that one of ordinary skill in the art “would have had (1) at least a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a related field, and (2) at least two years of research or industry experience in 3D printing or materials used for 3D printing.” Pet. 5 (citing Ex. 1003 ¶¶ 14–16). Petitioner also argues that “[a]dditional experience could substitute for a formal degree or formal training (and vice versa).” Id. Patent Owner proposes a slightly different level of skill, arguing that a person of ordinary skill in the art “would have had a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a comparable field and at least two years of experience related to 3D printing, with additional experience potentially being a substitute for a formal degree or training (and vice versa).” Prelim. Resp. 24. Neither party explains why the outcome of this case would be affected by the adoption of any of the proffered definitions of a person of ordinary skill in the art. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as it appears to be consistent with the ’713 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 16

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction needed

    “We note that, as discussed below, we are able to determine whether to institute inter partes review of the ’713 patent without expressly construing the term “from multiple print heads or deposition lines.” See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). As for Patent Owner’s argument that Petitioner has failed to carry its burden to identify how the claims are to be construed, we disagree on the present record. Although Petitioner does not provide a preferred construction for the single term it proposes requires construction, Petitioner does identify which of its two alternative constructions applies to each of its asserted grounds of unpatentability. Pet. 6 (“Under the first construction, [the obviousness grounds] are applicable, and [the anticipation ground] would be excluded from the claim scope. Under the alternative construction, all of [the asserted grounds] are applicable.”). In our view, this approach does not fail to satisfy Petitioner’s burden under 37 U.S.C. § 42.104(b)(3).” slip op. at 17

  Claim construction§ 102 anticipationDiscretionary denialcites Phillips
  Patents in suitUS 9,421,713
• Njoy, LLC / Njoy Holdings, Inc. v. Juul Labs, Inc.No claims unpatentable
  PTAB · Jun 10, 2025 · IPR2024-00231 · APJ Avelyn M Ross · IPR · Final written decision

  Claims 14–16, 18, 27–29, 31, and 32 were not proven unpatentable because the asserted references failed to establish the claimed airflow path or a reason to make the proposed combinations.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner’s and Patent Owner’s proposed levels of skill are similar and differ in that Petitioner’s relevant degrees and corresponding two years of experience additionally includes “industrial design” and “product design” and familiarity with “electrically powered vaporizing articles, their components or the underlying technologies” where Patent Owner requires two years of experience “designing electro-mechanical consumer products or an advanced degree.” Compare Pet. 7, with PO Resp. 2. Patent Owner alleges that “Petitioner has failed to establish unpatentability under either standard,” indicating that the level of skill in the art is not a dispositive issue. PO Resp. 3. In light of the record before us, we adopt Petitioner’s proposal regarding the level of ordinary skill in the art. Based on our review of the ’123 patent and the prior art of record, we determine that the definition offered by Petitioner comports with the qualifications a person would have needed to understand the ’123 patent and the prior art. We note that the outcome of this Decision would be the same under Patent Owner’s proposed definition.” slip op. at 11

  • Expert testimonyPetitioner expert creditedOther

    “In this case, Mr. McAlexander meets both Petitioner’s and Patent Owner’s proposed level of skill in the art. As a result, we are persuaded Mr. McAlexander has the requisite skill and relevant expertise to offer testimony in this matter. For example, Mr. McAlexander has a Bachelor’s Degree in Electrical Engineering and far more than 2 years of experience in the electrical engineering field. Ex. 1027, 3–6, 7. In addition, Mr. McAlexander has provided expert consulting services in a wide range of technology areas involving the process and design of electro-mechanical consumer products. Ex. 1003 ¶ 5. Through one of Mr. McAlexander’s business ventures, his laboratory has “performed detailed airflow analyses, designing and constructing specialized apparatuses to emulate human breath, allowing for precise activation testing of ENDS devices.” Ex. 1043 ¶ 16. That said, a declarant’s expertise, even clothed as a skilled artisan, does not entitle a naked opinion persuasive weight. Ashland Oil, Inc. v. Delta Resins & Refractories, Inc., 776 F.2d 281, 294 (Fed. Cir. 1985). Here, Patent Owner had the opportunity to, and in fact did, thoroughly cross examine Mr. McAlexander about the purported deficiencies in his testimony. See, e.g., Exs. 2052, 2054; Daubert v. Merrell Dow Pharm., Inc., 509 U.S. 579, 595 (1993) (“Vigorous cross examination [and] presentation of contrary evidence . . . are the traditional and appropriate means of attacking shaky but admissible evidence.”). Therefore, to the extent Patent Owner credibly identifies deficiencies in Mr. McAlexander’s testimony or that testimony lacks factual support or is based on broad, conclusory assertions, we will assign appropriate weight. See Velander v. Garner, 348 F.3d 1359, 1371 (Fed. Cir. 2003) (explaining that it is within the Board’s discretion, as the trier of fact, to accord appropriate weight to the evidence presented).” slip op. at 12

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “Petitioner contends that the parties proposed a construction for “pressure valve,” a limitation appearing in claims 18 and 31, during the ITC investigation. Pet. 7 (citing Ex. 1001, 41:58–65). Patent Owner contends that the terms of the ’123 patent should be given their plain and ordinary meaning. PO Resp. 4. Because resolution of the issues presented in this case do not require construction of the term “pressure valve,” we do not expressly construe this claim term. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (holding that “only those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy”); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs. in the context of an inter partes review).” slip op. at 14

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable

    “We agree with Patent Owner. To anticipate a claim, a reference “must not only disclose all elements of the claim within the four corners of the document, but must also disclose those elements ‘arranged as in the claim.’” Net MoneyIN, 545 F.3d at 1369. “The requirement that the prior art elements themselves be arranged as in the claim means that the claims cannot be treated . . . as mere catalogs of separate parts, in disregard of the part-to-part relationships set forth in the claims.” Therasense, Inc. v. Becton, Dickinson & Co., 593 F.3d 1325, 1332 (Fed. Cir. 2010). Indeed, the prior art reference “must clearly and unequivocally disclose the claimed [invention] or direct those skilled in the art to the [invention] without any need for picking, choosing, and combining various disclosures not directly related to each other by the teachings of the cited reference.” Net MoneyIN, 545 F.3d at 1371 (citation omitted). “[D]ifferences between the prior art reference and the claimed invention, however slight, invoke the question of obviousness, not anticipation.” Id.” slip op. at 20

  Patent outcomesUS 10,130,123 not shown unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 10,130,123
• Juul Labs, Inc. v. Njoy, LLCNo claims unpatentable
  PTAB · May 21, 2025 · IPR2024-00161 · APJ Christopher M Kaiser · IPR · Final written decision

  Claims 1–27 were not shown unpatentable because the asserted obviousness grounds failed to establish the claimed central airflow passageway or a reason to combine the references.

  RulingsFinal written decision

  • Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner

    “Relying on the testimony of Patent Owner’s declarant Dr. Singhose, Petitioner argues that a person of ordinary skill in the art “would have known a central straight path has less airflow resistance than a circuitous one.” Reply 22–23 (citing Ex. 1035, 127:15–128:9). But the same witness also testified that higher airflow resistance might be desirable and explained that providing more resistance to airflow might result in improved mixing. Ex. 1035, 21:21–22:12, 127:20–24, 170:10–14. In addition, Dr. Singhose testifies that the complicated design of the airflow passageway in Xia “serves important functions,” including “allow[ing] large droplets to be reabsorbed by the liquid-guiding mechanism,” allowing “excessive liquid in the airflow [to] condense,” and “prevent[ing] the chemical liquid from being sucked into the mouth.” Ex. 2022 ¶ 183 (citing Ex. 1004, 11, 13–14, 16). Although Petitioner’s declarant Dr. Sturges testifies that a straight airflow passageway “would provide improved, smoother air flow,” he does not provide any evidence supporting the view that the air flow would be improved. Ex. 1007 ¶ 118. We credit the testimony of Dr. Singhose that using a straight passageway in Xia would have been detrimental rather than beneficial. Ex. 2022 ¶ 183. Petitioner also argues that the inventors’ use of a straight path is evidence that the use of a straight passageway was “merely common-sense obviousness.” Reply 22–23. This is hindsight. Otsuka Pharm. Co. v. Sandoz, Inc., 678 F.3d 1280, 1296 (Fed. Cir. 2012) (“The inventor’s own path itself never leads to a conclusion of obviousness; that is hindsight.”). Moreover, it does not address the testimony of Dr. Singhose that the use of a complicated passageway like that in Xia had benefits not present in a straight central passageway.” slip op. at 29

  • Skill levelSkill level petitioner adoptedOther

    “B. Level of Ordinary Skill in the Art Petitioner contends that a person of ordinary skill in the art (“POSITA”) “would have had a mechanical or electrical engineering degree, industrial design degree, or a similar technical degree, or equivalent work experience, and 5 to 10 years of experience in electromechanical devices.” Pet. 10 (citing Ex. 1007 ¶ 16). Prior to institution, Patent Owner stated that, for “the limited purpose of this Preliminary Response,” it “does not challenge the definition of a POSITA set forth in the Petition.” Prelim. Resp. 9. We adopted Petitioner’s proposed definition in our Decision granting institution. During trial, neither party disputed this definition. Upon a complete record, we see no reason to change the adopted definition.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner

    “Patent Owner argues, however, that this presumption is overcome in the present case, and we agree. PO Resp. 28–32. We note that, although the claims require the first aperture to be “on the first end,” the claims still require that the “housing hav[e] a first aperture.” Thus, the issue is whether the aperture must be on the housing itself or part of the housing, as well as whether the aperture is on the first end of the housing. Although “having” and “includes” are used with respect to the solution holding medium to refer to elements located inside the housing, the specification of the ’881 patent suggests that the ends of the housing are part of the housing itself, rather than located inside the housing. First, “the first end . . . can be integrated into a single assembly as part of the housing.” Ex. 1001, 6:16–17. Second, “the housing . . . may comprise the cylindrical wall and two end-caps,” or “the housing . . . may comprise the cartridge wall and a single end-cap.” Id. at 3:55–59. The only figures of the ’881 patent that depict first end 206 show it at the end of the housing rather than located within the interior of housing 202. Id. at Figs. 2, 3. Moreover, there is no requirement to construe a claim term uniformly across multiple uses in the claims when doing so would be nonsensical. Microprocessor Enhancement Corp. v. Texas Instruments, Inc., 520 F.3d 1367, 1375 (Fed. Cir. 2008). Here, construing a first element that is recited as “having” or “includ[ing]” a second element always as encompassing not only second elements that are part of the first element, but also second elements that are located within the interior of the first element, would lead to nonsensical results. Claim 2 recites an airflow passageway “having a length having a circular cross section.” Ex. 1001, 17:59–60. It would be nonsensical to interpret this claim as encompassing an airflow passageway of non-circular cross section that contains another object that has a circular cross section, and neither party argues in favor of such a reading. Similarly, claim 16 recites an “airflow passageway having an interior having a uniform cross-sectional area,” and there is no reason to interpret this claim as encompassing an airflow passageway of non-uniform cross-sectional area that contains another object that itself has uniform cross-sectional area. Id. at 19:47–48. Thus, the claims do not use “having” or “includes” consistently to refer to elements located within the interior of an object; instead, they sometimes use these terms to refer to elements that are a part of an object. See Epcon Gas Sys., Inc. v. Bauer Compressors, Inc., 279 F.3d 1022, 1030–31 (Fed. Cir. 2002) (terms should be construed based on the context of how the terms are used in the claims).” slip op. at 13

  • Prior constructionPrior construction not adoptedDecided for patent owner

    “When we instituted trial, we preliminarily construed this phrase to encompass apertures that are located within the first end of the housing, determining on the record available at that time that “[t]he term does not require that the first aperture be located in the housing itself.” Inst. Dec. 16. We invited the parties to “address [the] construction of this term during trial,” id., and, on the full record developed during trial, we reach a different conclusion.” slip op. at 10

  Patent outcomesUS 10,334,881 not shown unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 10,334,881

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.