- PTAB · Dec 18, 2025 · IPR2025-01071 · APJ Benjamin D M Wood · IPR · Institution
The Board instituted IPR of claims 1–7, 12, 14, and 25 because Petitioner showed a reasonable likelihood of prevailing on its § 103 obviousness challenge over Bassompiere.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority under 35 U.S.C. § 314, which provides that an inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). On the preliminary record before us, we determine that Petitioner has satisfied this threshold requirement, and therefore we institute inter partes review of claims 1–7, 12, 14, and 25 of the ’687 patent.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner does not offer any reason why we should deviate from the Board’s determinations in the prior IPRs that one of ordinary skill in the art would have had knowledge of Kalman filters and quaternion mathematics. Nor are we aware of any such reason. On the contrary, the Board’s prior determinations are consistent with the level of ordinary skill reflected by prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978). Bassompiere, for example, teaches using a data merging algorithm that is, “[a]dvantageously,” extended Kalman filtering. Ex. 1006, 4:17. Bassompiere also teaches using quaternions to determine a device’s pitch and roll about a horizontal reference frame. Id. at 6:3–8, 20:10–21:1. Patent Owner argues that Dr. Sarrafzadeh’s testimony regarding the level of skill in the art in this proceeding contradicts his testimony in the prior IPRs, which did not include knowledge of Kalman filters and quaternion mathematics in his definition of the level of ordinary skill in the art. Prelim. Resp. 24–26. Patent Owner asserts that this contradiction “undermin[es] his credibility.” Id. at 26. We disagree. The testimony Dr. Sarrafzadeh provided in the earlier IPRs obviously preceded the Board’s determinations in those proceedings that, on the whole record, including the testimony of then-Patent Owner’s declarant, the level of ordinary skill included knowledge of Kalman Filters and quaternions. Dr. Sarrafzadeh’s testimony in this proceeding reasonably aligns with those determinations. Accordingly, we adopt Petitioner’s definition of the level of ordinary skill in the art for purposes of this Decision.” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“The parties agree that the claimed “spatial reference frame” is associated with a device, has its origin at the same point in the device, and has axes that are always fixed with respect to the device. The only disagreement is whether that device is a “3D pointing device” or an “electronic device.” The Specification indicates that “electronic device” encompasses 3D pointing devices as well as, e.g., smartphones and navigation equipment, and therefore is the broader term. Ex. 1001, 13:20– 23. At this stage of the proceeding, we determine that the threshold question of institution can be decided under either construction, because Patent Owner does not dispute that the primary asserted reference, Bassompiere, teaches a “spatial reference frame” associated with a 3D pointing device. Pet. 25–27. Therefore, at this stage of the proceeding, we decline to resolve the parties’ dispute. See Vivid Techs., Inc. v. Am. Sci. & Eng'g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those [claim] terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”); Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (approving Board decision not to construe claim language where the construction is not material to the dispute). 2. “predicted axial accelerations” Petitioner does not propose a construction for “predicted axial accelerations,” but, in the concurrent California Litigation, contends that it should be accorded its “plain and ordinary meaning.” Ex. 2007, 3. In subsequent briefing that will be discussed more fully below, Petitioner asserts that its declarant, Dr. Sarrafzadeh, “applied the ‘plain and ordinary’ meaning for all claim terms, including the ‘predicted axial accelerations’ term,” in this proceeding. Paper 14, 1. Petitioner also submits in that briefing that “the term ‘axial acceleration’ (whether predicted or measured) . . . ordinarily encompasses three types of acceleration,” i.e., “linear, centrifugal, and gravitational.” Id. at 3, 4. Patent Owner contends that “predicted axial accelerations” should be construed as “[g]ravitational acceleration along the electronic device’s axes derived from the current quaternion.” Prelim. Resp. 18. Patent Owner asserts that “[t]he claims and specification consistently define ‘predicted axial accelerations’ as gravitational accelerations along the device’s axes at time T, derived from the current quaternion.” Id. (citing Ex. 1001, claim 1, 17:18–30, 17:45–52). Patent Owner further submits that “because ‘predicted axial accelerations’ are computed from the current quaternion they only contain gravitational accelerations along the device’s axes.” Id. at 19 (citing Ex. 2023 ¶ 23). Here too, the threshold question of institution can be decided without” slip op. at 14
- BurdenDecided for petitioner
“We disagree with Patent Owner’s characterization. The teaching to use quaternions instead of Euler angles comes from Bassompiere, not Dr. Sarrafzadeh. See Ex. 1006, 20:10–11 (“A first variant embodiment consists in replacing the angles of torsion θ and ψ by a quaternion formulation of the same torsion.”). Rather than supplying a missing limitation, we understand Dr. Sarrafzadeh to be explaining how a person of ordinary skill in the art would have implemented Bassompiere’s teaching to use quaternions instead of Euler angles given that person’s knowledge of quaternion mathematics. Patent Owner also argues that “switching from Euler angles to quaternions is not a routine substitution but requires the reengineering of the EKF.” Prelim. Resp. 28. Patent Owner similarly contends that Dr. Sarrafzadeh “devotes nearly twenty pages of his declaration to rewriting Bassompiere’s Euler-based equations ‘in quaternion form,’ and explaining how to convert them back to Euler angles,” and notes that “[a]s other researchers in the field have confirmed, ‘[w]hile implementing orientation tracking using quaternions provides advantages like avoiding gimbal lock, it is significantly more complex than the Kalman filer using Euler angles.’” Prelim. Resp. 32 (citing Ex. 1002, 31–51; quoting Ex. 2027, 1). Patent Owner thus contends that replacing Euler angles with quaternions “is not a ‘trivial’ substitution.” Id. at 32. But Petitioner does not appear to be arguing that replacing Euler angles with quaternions would have been “trivial” or simple, only that doing so was taught by Bassompiere and within the knowledge and capabilities of a person of ordinary skill in the art. Pet. 33–34. We determined above that a skilled artisan had knowledge of extended Kalman filters and quaternion mathematics, and we are required to consider the knowledge and capabilities of a person of ordinary skill in our analysis. Further, at this preliminary stage, Patent Owner’s assertion that the Euler angle/quaternion switch would not have been a routine substitution is supported only with attorney argument, which is entitled to no weight. Icon Health & Fitness, Inc. v. Strava, Inc. 849 F.3d 1034, 1043 (Fed. Cir. 2017). As such, it does not outweigh Dr. Sarrafzadeh’s contrary testimony. See, e.g., Ex. 1002 ¶ 56.” slip op. at 29
Claim constructioncites Phillips · KSR · GrahamPatents in suitUS 11,698,687 - PTAB · Dec 17, 2025 · IPR2025-01023 · APJ Benjamin D M Wood · IPR · Institution
The Board instituted IPR on all asserted grounds against claims 1, 3, 7, and 9, finding a reasonable likelihood that Petitioner would prevail on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“c. Conclusion as to Claim 1 Having reviewed the record and the parties’ arguments, we determine that Petitioner has a reasonable likelihood of prevailing with respect to claim 1, and therefore has satisfied the threshold requirement for institution of inter partes review on the basis of Ground 1. 3. Claims 3, 7, and 9 Petitioner contends that Bassompiere teaches the limitations of claim 3, 7, and 9, and supports its contentions with citations to Bassompiere and to Dr. Sharrafzadeh’s declaration. Pet. 57–63. At this stage of the proceeding, Patent Owner does not raise any arguments specifically directed to these claims. “When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” 37 C.F.R. § 42.108(a). We must “either (1) institute as to all claims challenged in the petition and on all grounds in the petition, or (2) institute on no claims and deny institution.” CTPG at 5–6, 64; see also PGS Geophysical AS v. Iancu, 891 F.3d 1354, 1359–60 (Fed. Cir. 2018) (stating a decision to institute is “a simple yes-orno institution choice respecting a petition, embracing all challenges included in the petition”). Thus, because we have decided to grant institution on Ground 1 with respect to claim 1, we must do the same for claims 3, 7, and 9.” slip op. at 38
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner does not offer any reason why we should deviate from the Board’s determinations in the prior IPRs that one of ordinary skill in the art would have had knowledge of Kalman filters and quaternion mathematics. Nor are we aware of any such reason. On the contrary, the Board’s prior determinations are consistent with the level of ordinary skill reflected by prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978). Bassompiere, for example, teaches using a data merging algorithm that is, “[a]dvantageously,” extended Kalman filtering. Ex. 1006, 4:17. Bassompiere also teaches using quaternions to determine a device’s pitch and roll about a horizontal reference frame. Id. at 6:3–8, 20:10–21:1. Nasiri teaches that quaternions can be used to represent a device’s “orientation in space.” Ex. 1008, 30:27– 30. Patent Owner argues that Dr. Sarrafzadeh’s testimony regarding the level of skill in the art in this proceeding contradicts his testimony in the prior IPRs, which did not include knowledge of Kalman filters and quaternion mathematics in his definition of the level of ordinary skill in the art. Prelim. Resp. 24–26. Patent Owner asserts that this contradiction “undermin[es] his credibility.” Id. at 26. We disagree. The testimony Dr. Sarrafzadeh provided in the earlier IPRs obviously preceded the Board’s determinations in those proceedings that, on the whole record, including the testimony of then-Patent Owner’s declarant, the level of ordinary skill included knowledge of Kalman Filters and quaternions. Dr. Sarrafzadeh’s testimony in this proceeding reasonably aligns with those determinations. Accordingly, for the above reasons, we adopt Petitioner’s definition of the level of ordinary skill in the art for purposes of this Decision.” slip op. at 13
- Expert testimonyPetitioner expert creditedDecided for petitioner
“We disagree with Patent Owner’s characterization. The teaching to use quaternions instead of Euler angles comes from Bassompiere, not Dr. Sarrafzadeh. See Ex. 1006, 20:10–11 (“A first variant embodiment consists in replacing the angles of torsion θ and ψ by a quaternion formulation of the same torsion.”). Rather than supplying a missing limitation, we understand Dr. Sarrafzadeh to be explaining how a person of ordinary skill in the art would have implemented Bassompiere’s teaching to use quaternions instead of Euler angles given that person’s knowledge of quaternion mathematics. Patent Owner also argues that “switching from Euler angles to quaternions is not a routine substitution but requires the reengineering of the EKF.” Prelim. Resp. 28. Patent Owner similarly contends that Dr. Sarrafzadeh “devotes nearly twenty pages of his declaration to rewriting Bassompiere’s Euler-based equations ‘in quaternion form,’ and explaining how to convert them back to Euler angles,” and notes that “[a]s other researchers in the field have confirmed, ‘[w]hile implementing orientation tracking using quaternions provides advantages like avoiding gimbal lock, it is significantly more complex than the Kalman filer using Euler angles.’” Prelim. Resp. 32–33 (citing Ex. 1002, 31–51; quoting Ex. 2027, 1). Patent Owner thus contends that replacing Euler angles with quaternions “is not a ‘trivial’ substitution.” Id. at 33. But Petitioner does not appear to be arguing that replacing Euler angles with quaternions would have been “trivial” or simple, only that doing so was taught by Bassompiere and within the knowledge and capabilities of a person of ordinary skill in the art. We determined above that a skilled artisan had knowledge of extended Kalman filters and quaternion mathematics such knowledge, and we are required to consider the knowledge and capabilities of a person of ordinary skill in our analysis. Further, at this preliminary stage, Patent Owner’s assertion that the Euler angle/quaternion switch would not have been a routine substitution is supported only with attorney argument, which is entitled to no weight. Icon Health & Fitness, Inc. v. Strava, Inc. 849 F.3d 1034, 1043 (Fed. Cir. 2017). As such, it does not outweigh Dr. Sarrafzadeh’s contrary testimony. See, e.g., Ex. 1002 ¶ 56.” slip op. at 30
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“The parties agree that the claimed “spatial reference frame” is associated with a device, has its origin at the same point in the device, and has axes that are always fixed with respect to the device. The only disagreement is whether that device is a “3D pointing device” or an “electronic device.” The Specification indicates that “electronic device” encompasses 3D pointing devices as well as, e.g., smartphones and navigation equipment, and therefore is the broader term. Ex. 1001, 8:35–39. At this stage of the proceeding, we determine that the threshold question of institution can be decided under either construction, because Patent Owner does not dispute that the primary asserted reference, Bassompiere, teaches a “spatial reference frame” associated with a 3D pointing device. Pet. 30–31. Therefore, at this stage of the proceeding, we decline to resolve the parties’ dispute. See Vivid Techs., Inc. v. Am. Sci. & Eng'g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those [claim] terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”); Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (approving Board decision not to construe claim language where the construction is not material to the dispute).” slip op. at 15
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,852,846 - Spotify USA Inc. v. Manuel TijerinoInstitutedPTAB · Dec 17, 2025 · IPR2025-01280 · APJ St John Courtenay III · IPR · Institution
The Board instituted IPR on claims 1–17, finding a reasonable likelihood that claim 1 is obvious over Laut, Kincaid, and Bongiovi.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2022). Under 35 U.S.C. § 314(a), we may not authorize an inter partes review unless the information in the petition and the preliminary response “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Upon consideration of the Petition, the Preliminary Response, the Reply, the Sur-reply, and the evidence of record, for the reasons given below we determine the information presented in the Petition demonstrates there is a reasonable likelihood that Petitioner would prevail in establishing the unpatentability of at least one challenged claim of the ’925 patent.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundOther
“The Board’s Preliminary Analysis — Rationale to Combine Kincaid with Laut At this stage of the proceeding, based on the express disclosures of Kincaid and Laut, we are persuaded Petitioner’s rationale is sufficient to show that a “POSITA would seek to ensure consistent loudness across tracks to maximize customer satisfaction and would thus be motivated to combine Kincaid with Laut in order to correct these problems.” Pet. 27 (citing Ex. 1003 ¶ 65). Moreover, we credit Mr. Rosenblatt’s testimony that the “POSITA’s motivation would have been at least partially financial: improving the listeners’ experiences could increase demand for the jukebox, leading to” slip op. at 19
- Skill levelSkill level petitioner adoptedDecided for petitioner
“contends that an ordinarily skilled artisan for the ’925 patent “would have had a Bachelor of Science degree and a Masters [sic] degree in Computer Science, Electrical Engineering, Computer Engineering, or an equivalent field, as well as one to two years of academic or industry experience in computer-based systems for digital audio distribution and playback, or comparable industry experience.” Pet. 3 (citing Ex. 1003 ¶ 28). Petitioner further asserts that the ordinarily skilled artisan “would have been knowledgeable about audio signal processing techniques, such as gain normalization and dynamic range compression, and software engineering.” Id. At this stage, Patent Owner does not specifically address the level of skill of the ordinary artisan. See generally Prelim. Resp. For purposes of this Decision, we adopt Petitioner’s definition of the level of ordinary skill in the art. On the present record, we are satisfied that this definition comports with the level of skill necessary to understand and implement the teachings of the ’925 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that the prior art itself can reflect appropriate level of ordinary skill in art).” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Patent Owner incorrectly interprets the issued ’925 patent claim terms under BRI. Prelim. Resp. 2. Accordingly, at this stage of the proceeding, we decline to consider Patent Owner’s proposed constructions for claim 1 under the legally incorrect broadest reasonable interpretation standard, which is only applicable during prosecution before a patent examiner. As emphasized above, in interpreting the claims of the ’925 patent, we “us[e] the same claim construction standard that would be used to construe the claim[s] in a civil action under 35 U.S.C. [§] 282(b).” See 37 C.F.R. § 42.100(b) (2023). We further emphasize that we construe claim terms only as relevant to the parties’ contentions and only to the extent necessary to resolve the issues in dispute. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999); Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017). Based on our review of the current record, we determine that no express construction of any term is necessary to resolve this case for purposes of institution. We leave it to the parties to further develop during under the proper Phillips standard applied to IPR proceedings. See Phillips, 415 F.3d at 1313.” slip op. at 14
Claim construction§ 103 obviousness§ 112 disclosurecites Phillips · KSR · GrahamPatents in suitUS 9,146,925 - PTAB · Dec 16, 2025 · IPR2025-01046 · APJ Neil T Powell · IPR · Institution
The Board instituted IPR on claims 2–15, finding a reasonable likelihood that the 1946 Cyclopedia, Lindström, and Wong render at least claim 2 obvious; claim 1 was disclaimed.
RulingsInstitution decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner responds that Petitioner’s proposed level of ordinary skill in the art is incorrect, “because design or analysis experience with other industrial wheeled vehicles would not necessarily be applicable to the art of the ’892 Patent.” Prelim. Resp. 12 (citing Ex. 2035 ¶¶ 38–39). According to Patent Owner, a person of ordinary skill in the art “would have at least a bachelor’s degree in a discipline related to mechanical engineering, physics, structural design, or an equivalent discipline, and at least two years of experience designing or analyzing rail cars.” Id. (citing Ex. 2035 ¶¶ 34, 38). The parties agree that one of ordinary skill in the art “would have had at least a bachelor’s degree in a discipline related to mechanical engineering, physics, structural design, or an equivalent discipline, and at least two years 5 Because Patent Owner statutorily disclaimed claim 1, this ground is moot. Patent Owner, however, disagrees that the experience should include designing or analyzing “similar vehicles.” Prelim. Resp. 12. At this stage, for the reasons below, limiting the ordinary skill in the art to “at least two years of experience designing or analyzing rail cars” does not affect our analysis of the parties’ dispute or our determination that there is a reasonable likelihood that Petitioner would prevail with respect to at least one of the challenged claims. Thus, based on the preliminary record, we adopt Petitioner’s proposed level of ordinary skill to determine whether review should be instituted.” slip op. at 12
- Expert testimonyPetitioner expert creditedDecided for petitioner
“Patent Owner also argues that Petitioner’s declarant does not have “actual industry experience with railcar structures” and, thus, “makes the wrong conclusions and conflates various concepts that a [person of ordinary skill in the art] with practical industry experience and knowledge would not.” Prelim. Resp. 12–13 (citing Ex. 2035 ¶ 39). For the reasons discussed below, in our preliminary analysis, we give credit to the cited testimony of Petitioner’s declarant, because it finds support in the relied-upon portions of the record.” slip op. at 13
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“At this stage, we need not construe expressly any claim term to resolve the parties’ dispute regarding whether Petitioner has demonstrated a reasonable likelihood of prevailing on at least one challenged claim. Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms that . . . are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))” slip op. at 14
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“been obvious over the 1946 Cyclopedia and Wong. Weighing the parties’ arguments and evidence, we find Petitioner provides sufficient rational underpinning for its assertion that it would have been obvious in view of Wong to implement a cross-wise extending beam to reinforce the 1946 Cyclopedia’s NSC ore car’s end slope sheet. Pet. 52–53; Prelim. Resp. 28– 30. In response to Petitioner’s assertion that “[t]he upper, outboard end of [Wong’s slope sheet 26] is reinforced by a cross-wise, L-shaped beam positioned under the slope sheet,” Patent Owner argues that “Wong does not provide reinforcement, but simply shows two sheets being connected for lading containment and load transfer.” Pet. 52; Prelim. Resp. 29. At this stage, we find Petitioner has the better position. Although we agree with Patent Owner that Wong shows two sheets connected to one another, that does not negate Petitioner’s correct observation that Wong shows an upper end of its end slope sheet 26 resting on an L-shaped structure, which apparently would reinforce end slope sheet. Pet. 52; Ex. 1003 ¶ 56. reason to look to Wong in the first place,” we again find that Petitioner has the better position at this stage. Prelim. Resp. 29. For example, Wong’s disclosure of “hopper railcar 10” (Ex. 1006, 3:6–9) and the 1946 Cyclopedia’s disclosure of “Freight Cars: Hopper Ore” (Ex. 1004, 27–28; Ex. 1054, 27–28) support Petitioner’s position that “Wong and the 1946 Cyclopedia are in the same field.” Pet. 52; see also id. at 76 (“Wong discloses a rail road hopper car (‘hopper railcar’ 10)”), 18–19 (“The ore-car section of the 1946 Cyclopedia—entitled ‘Freight Cars: Hopper Ore’— contains drawings and a photograph of an ore car manufactured by Patent Owner NSC.”); Ex. 1003 ¶ 56 (“Wong and the 1946 Cyclopedia are in the same field of hopper railcars”) (citing Ex. 1004, 27–28; Ex. 1006, code [57]). This position is not persuasively rebutted by Patent Owner’s argument that Wong’s hopper railcar 10 uses aluminum and steel together for certain reasons. Prelim. Resp. 28–29.” slip op. at 23
Claim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 8,166,892 - PTAB · Dec 16, 2025 · IPR2025-01047 · APJ Hyun J Jung · IPR · Institution
The Board instituted IPR of claims 1–44 on all presented challenges, finding a reasonable likelihood that FreightCar would prevail on at least one claim based on Hart, the 1906 Cyclopedia, and Wong.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Upon consideration of the Petition and for the reasons explained below, we determine that Petitioner has shown a reasonable likelihood of prevailing with respect to at least one of the challenged claims. Thus, we institute an inter partes review of claims 1–44 of the ’515 patent on all presented challenges. 37 C.F.R. § 42.108(a) (2024) (“When instituting . . . review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.”); see also SAS Inst. Inc. v. Iancu, 138 S. Ct. 1348, 1359–60 (2018).” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“The parties agree that one of ordinary skill in the art “would have had at least a bachelor’s degree in a discipline related to mechanical engineering, physics, structural design, or an equivalent discipline, and at least two years of experience designing or analyzing rail cars.” Pet. 29; Prelim. Resp. 9. Patent Owner, however, disagrees that the experience should include designing or analyzing “similar vehicles.” Prelim. Resp. 9. At this stage, for the reasons below, limiting the ordinary skill in the art to “at least two years of experience designing or analyzing rail cars” does not affect our analysis of the parties’ dispute or our determination that there is a reasonable likelihood that Petitioner would prevail with respect to at least one of the challenged claims. Thus, based on the preliminary record, we adopt Petitioner’s proposed level of ordinary skill to determine whether review should be instituted. Patent Owner also argues that Petitioner’s declarant does not have “actual industry experience with railcar structures” and, thus, “makes the wrong conclusions and conflates various concepts that a [person of ordinary skill in the art] with practical industry experience and knowledge of rail cars would not.” Prelim. Resp. 9–10 (citing Ex. 2035 ¶ 35). For the reasons discussed below, in our preliminary analysis, we give credit to the cited testimony of Petitioner’s declarant, because it finds support in the relied-upon portions of the record.” slip op. at 10
- Expert testimonyPetitioner expert creditedDecided for petitioner
“Patent Owner also argues that Petitioner’s declarant does not have “actual industry experience with railcar structures” and, thus, “makes the wrong conclusions and conflates various concepts that a [person of ordinary skill in the art] with practical industry experience and knowledge of rail cars would not.” Prelim. Resp. 9–10 (citing Ex. 2035 ¶ 35). For the reasons discussed below, in our preliminary analysis, we give credit to the cited testimony of Petitioner’s declarant, because it finds support in the relied-upon portions of the record.” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“to further support the upper, outboard end of the slope sheet with a crosswise, L-shaped beam as in Wong,” and one of ordinary skill in the art would have been motivated to do so, because of “the benefits of reinforcing the slope sheet at its upper end, where its connection with another structure creates a stress concentration.” Pet. 63 (citing Ex. 1003 ¶ 108). Petitioner points to Hart’s transverse beam b3 and argues that it suggests using a transverse beam like Wong if Hart is modified so that upper beam b3 no longer supports the slope sheet. Id. (citing Ex. 1008, Fig. 1). Petitioner also argues that the references are in the same field and that there would have been a reasonable expectation of success. Id. at 63–64 (citing Ex. 1003 ¶ 108; Ex. 1008, Fig. 1). Based on the preliminary record, Petitioner shows that its proposed combination of Hart, the 1906 Cyclopedia, and Wong teaches or suggests the above-quoted limitations of claim 24 and that one of ordinary skill in the art would have combined those references in the manner asserted with a reasonable expectation of success.” slip op. at 19
§ 103 obviousnesscites Phillips · KSRPatents in suitUS 8,132,515 - Orca Security Ltd. v. Wiz, Inc.InstitutedPTAB · Dec 15, 2025 · IPR2025-01087 · APJ Lisa A Murray · IPR · Institution
The Board instituted IPR on claims 1–17 because Orca showed a reasonable likelihood of prevailing on its § 103 obviousness ground over Shua and Lang.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“An inter partes review may be instituted only if “the information presented in the petition . . . and any [preliminary] response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons given below, on this record, Petitioner has established a reasonable likelihood that it would prevail in showing the unpatentability of at least one of the challenged claims. We determine that institution of an inter partes review of the challenged claims is appropriate. B. Real Parties in Interest” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“35 U.S.C. § 103 involves determining the level of ordinary skill in the pertinent art at the time the invention was made. Graham, 383 U.S. at 17. The level of skill in the art is “a prism or lens” through which we view the prior art and the claimed invention. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). The person of ordinary skill in the art is a hypothetical person who knows the relevant art. In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995). Factors to consider include the types of problems encountered in the art, the sophistication of the technology, and the educational level of active workers in the field. Id. One or more factors may predominate. Id. Petitioner asserts that one of ordinary skill in the field of the ’529 Patent would have had “a bachelor’s degree in computer engineering, computer science, electrical engineering, or a similar degree, with 2–3 years additional education or experience might substitute for these requirements.” Pet. 5; Ex. 1003 ¶¶ 32–33. Patent Owner’s Preliminary Response does not address this issue. We find Petitioner’s formulation to be consistent with the evidence of record at this stage of the proceedings, including the asserted prior art and the ’529 Patent, and we preliminarily adopt and apply that definition for purposes of this Decision. C. Claim Construction” slip op. at 6
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownOther
“Owner contends that Petitioner’s argument “inverts the appropriate understanding: just because the challenged patent identifies an example security database that stores a representation of a computing environment as nodes and edges does not mean that anything that stores a representation of a computing environment as nodes and edges is necessarily a security database.” Prelim. Resp. at 7–8. We agree with the logic of Patent Owner’s argument, but disagree that Petitioner necessarily “relies on this inverted understanding for its prior art mapping.” Id. at 8. We understand Dr. Zadok’s explanation to mean only that the claim term “security database” encompasses graph databases that include a representation of the computing environment, meaning that some (but not necessarily all) security databases are graph databases. See Ex. 1003 ¶ 100. The language in the Petition to which Patent Owner objects can be read consistently with Dr. Zadok’s declaration. Petitioner does not, however, take a position on what the outer bounds of the claim term “security database” should be. Without attempting a full construction of the term “security database,” it is possible to determine from the current record, at least on a preliminary basis, some of the database types that would fall within its scope. The ’529 Patent explains that the claimed “security database” is part of an “inspection cybersecurity threats. Specifically, it provides as follows: In certain embodiments, the cloud computing environment 110 is monitored for cybersecurity objects, threats, risks, and the like, by an inspection environment 130. In an embodiment, the inspection environment 130 is configured to monitor the cloud computing environment 110 for cybersecurity objects, threats, risks, combinations thereof, and the like. Ex. 1001, 6:1–7; see id. Fig. 1. The ’529 Patent also provides: “In an embodiment, the inspection environment 130 further includes a security database 136. In some embodiments, the security database 136 is configured to store a representation of the cloud computing environment 110, for example based on a predetermined data schema.” Id. at 7:46–50. Thus, we can conclude that the term “security database,” as used in the ’529 Patent, encompasses at least a database within an inspection environment that monitors for cybersecurity threats and is configured to store a representation of a cloud computing environment that is monitored by the inspection environment. An example of such a security database is the Neo4j® graph database. Id. at 7:58–60. As discussed below, another example is the “context map” disclosed in Shua ’048. See Ex. 1005, 15, 25.” slip op. at 19
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner
“We find nothing contradictory in Petitioner’s argument that “100% of an organization’s assets” would include its AI models. Pet. 11, 21. Shua ’048 appears to contemplate treating multiple layers of structures as assets to be mapped and monitored. Ex. 1005 ¶ 30 (Shua’s Orca system “automatically assesses the security state of discovered asset[s] throughout the technology stack, including all four cloud layers: I/S, OS, apps, and data.”). On the current record, a VM is an asset that contains other assets, including an AI model.10 We conclude that for the purposes of institution, Petitioner’s mapping, as elucidated by Dr. Zadok, adequately demonstrates that the combination of Shua and Lang discloses limitation 1[c] and the corresponding limitations in claims 9 and 10. We further conclude that Petitioner’s identification of a motivation to combine Shua with Lang is adequate for institution purposes.” slip op. at 23
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 12,003,529 - Orca Security Ltd. v. Wiz, Inc.InstitutedPTAB · Dec 15, 2025 · IPR2025-01085 · APJ Karl D Easthom · IPR · Institution
The Board instituted IPR on claims 1–21, finding a reasonable likelihood of prevailing on both § 103 grounds: Calvo and Nguyen, and Calvo, Nguyen, and Datsenko.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“presented in a petition and preliminary response shows that “there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons explained below, we determine that Petitioner establishes a reasonable likelihood that it would prevail with respect to at least one challenged claim. Accordingly, we institute an inter partes review as to the challenged claims and the grounds raised in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“B. Level of Ordinary Skill in the Art Petitioner contends that a person of ordinary skill in the art (POSITA) at the time of the ’693 Patent would have had a bachelor’s degree in computer engineering, computer science, electrical engineering, or a similar degree, with at least two years of experience in the field of cybersecurity; additional education or experience might substitute for these requirements. Pet. 7 (citing Ex. 1003 ¶¶ 63–64). Patent Owner does not provide a level of ordinary skill in the art. See generally Prelim. Resp. Based on a review of the record, we adopt Petitioner’s proposed level of ordinary skill in the art because it is consistent with the evidence of record, including the asserted prior art and ’693 patent specification.” slip op. at 6
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“support a construction that is similar to Petitioner’s construction of a “network path” as “a link between two machines.” See Pet. 17. That is, limitation 1(a) recites “selecting a reachable resource having a network path to access the reachable resource, wherein the reachable resource is a cloud object . . . having access to an external network which is external to the cloud computing environment,” and limitation 1(b) recites “actively inspecting the network path to determine if the network path of the reachable resource is accessible from the external network.” This plain language shows that a network path is simply a connection (link) between an external network object and a resource in a cloud (or cloud object). The specification provides an example of accessing “port 22”: “Active inspection allows to [sic] generate instructions directed at the reachable resource over a network path, which when received by the reachable resource cause the reachable resource to send a response.” Ex. 1001, 5:40–45. The specification also states that “a network path may include sequential representations of possible data/control flows between two or more objects in a graph.” Ex. 1001, 12:49–52; accord Ex. 1001, 12:60–62 (describing “a path show[ing] a connection between security objects and/or computing objects that communicate over a network”), 12:42–44 (“A network path is a connection of two or more security objects accessible from an external or internal network, and/or an external or internal object.”). In other words, the specification indicates that a transmitting testing object may be an object external to the cloud connected via a network path to another object (a cloud resource for testing). The “network path” may also include resources/objects (represented as graph vertices) on the path. See id. at 12:51–59 (“A path may be a vertexonly path, describing a sequence of vertex-to-vertex ‘hops,’ an edge-only path, describing only the edges included in the sequence without description of the associated vertices, or a combined edge-vertex path, describing both edges and vertexes included in the sequence.” (emphasis added)). Accordingly, for purposes of institution, we construe a “network path” as “a connection between an external object and a cloud resource, wherein the connection itself include objects and/or cloud resources.”” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“4. Remaining Terms No express construction of any other claim term is necessary to determine whether to institute inter partes review. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). D.” slip op. at 12
Claim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,936,693 - PTAB · Dec 12, 2025 · IPR2025-01116 · APJ Christopher M Kaiser · IPR · Institution
The Board instituted IPR of claims 1–15 on all asserted grounds, finding a reasonable likelihood that claim 1 would have been obvious over Sudre, Lee, and Penven.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“determine whether to institute an inter partes review under 35 U.S.C. § 314 and 37 C.F.R. § 42.4(a). Inter partes review may not be instituted unless “the information presented in the petition filed under [35 U.S.C.] section 311 and any response filed under [35 U.S.C.] section 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). “When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” 37 C.F.R. § 42.108(a) (2023). In other words, a decision to institute under § 314 may not institute on fewer than all claims challenged in the petition. SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1359–60 (2018). In addition, if the Board institutes trial, it will “institute . . . on all grounds in the petition.” PTAB Consolidated Trial Practice Guide, 5–6 (Nov. 2019)1 (“CTPG”); see also PGS Geophysical AS v. Iancu, 891 F.3d 1354, 1360 (Fed. Cir. 2018) (interpreting the statute to require “a simple yes-” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“had at least (1) a Bachelor’s Degree (or higher) in material science, materials engineering, mechanical engineering, textile engineering, or a related field, and (2) a minimum of two years of working experience in textiles engineering, fibers and textiles manufacturing, or a related field.” Pet. 4 (citing Ex. 1003 ¶¶ 21–22). Petitioner also argues that “[a]dditional education could substitute for professional experience, and vice versa.” Id. On the present record, Patent Owner does not contest Petitioner’s proposed level of ordinary skill. Prelim. Resp. 25–26. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as it appears consistent with the ’566 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Both parties argue that no claim terms require express construction at this stage of the proceeding. Pet. 3; Prelim. Resp. 26. On the present record, we agree. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). To the extent the parties’ arguments regarding unpatentability do address claim construction issues, we address these issues below.” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner
“articulated a reason why a person of ordinary skill in the art would have combined the teachings of Sudre, Lee, and Penven. Prelim. Resp. 60–63. In particular, Patent Owner argues that a person of ordinary skill in the art “would not have been motivated to look into Penven to modify the teachings of Lee because Lee and Penven disclose substantially different structures.” Id. at 60–61. This argument does not address Petitioner’s proposed reason to combine, which looks to Lee and Penven each to modify Sudre, not to Penven to modify Lee. See Pet. 79–81. In addition, “[c]ombining the teachings of references does not involve an ability to combine their specific structures.” In re Nievelt, 482 F.2d 965, 968 (CCPA 1973). In other words, “[t]he test for obviousness is not whether the features of a secondary reference may be bodily incorporated into the structure of the primary reference . . . . Rather, the test is what the combined teachings of the references would have suggested to those of ordinary skill in the art.” In re Keller, 642 F.2d 413, 425–26 (CCPA 1981). Petitioner provides “some articulated reasoning with some rational underpinning” to combine the teachings of Sudre with those of Lee and Penven. KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 418 (2007). In particular, Petitioner directs us to Sudre’s teaching of “a method for manufacturing PMC,” to Sudre’s lack of teaching of “specific parameters, such as warp thread size and spacing” to satisfy the “particular requirements” of its fabric. Pet. 79 (citing Ex. 1003 ¶¶ 248–250; Ex. 1004, 1:2–5, 6:14–17). As Petitioner points out, id. at 79–80, Lee and Penven provided yarn diameters and loop diameters that were conventional, and there is evidence of record that a person of ordinary skill in the art would have used these conventional diameters in constructing Sudre’s paper machine clothing. Ex. 1003 ¶¶ 258–261, 263–266; Ex. 1006, 3:64–66.” slip op. at 14
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,261,566 - Ipr2025-01153InstitutedPTAB · Dec 11, 2025 · IPR2025-01153 · APJ John A Squires · IPR · Director review
The Director granted institution of inter partes review in IPR2025-01153 after finding a reasonable likelihood of prevailing on at least one challenged claim and no basis for denial.
RulingsDirector review decision- Director reviewDirector review, grantedGranted
“petitioner has shown a reasonable likelihood of prevailing with respect to at least one of the claims challenged in the petition and no other non-discretionary considerations warrant denial of institution. Accordingly, institution of inter partes review is granted in the following proceedings: IPR2025-01042 IPR2025-01241 IPR2025-01264 IPR2025-01153 IPR2025-01242 IPR2025-01265 IPR2025-01179” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“petitioner has shown a reasonable likelihood of prevailing with respect to at least one of the claims challenged in the petition and no other non-discretionary considerations warrant denial of institution. Accordingly, institution of inter partes review is granted in the following proceedings: IPR2025-01042 IPR2025-01241 IPR2025-01264 IPR2025-01153 IPR2025-01242 IPR2025-01265 IPR2025-01179” slip op. at 2
NonePatents in suitUS 10,536,714 - PTAB · Dec 11, 2025 · IPR2025-01025 · APJ Timothy G Majors · IPR · Institution
The Board instituted IPR on all challenged claims and all asserted grounds, finding a reasonable likelihood that claim 1 is unpatentable over Garrison with Laub and/or Aklog.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 314(a), an inter partes review may not be instituted unless it is determined that there is a reasonable likelihood that the petitioner will prevail with respect to at least one of the claims challenged in the petition. For reasons explained below, we conclude that Petitioner shows a reasonable likelihood that it will prevail with respect to at least one of the ’910 patent’s challenged claims. We institute inter partes review on all challenged claims and on all asserted grounds. See SAS Inst. Inc. v. Iancu, 584 U.S. 357, 362–63 (2018); 37 C.F.R. § 42.108(a) (“When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.”).” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“(“POSA”) “would have had an undergraduate degree in mechanical engineering or a related engineering discipline and 2-4 years of catheter design experience and, where necessary, would have consulted with a physician regarding the methods of treatment.” Pet. 18 (citing Ex. 1003 ¶¶ 35–36).” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“standard used in a civil action before the courts under 35 U.S.C. § 282(b), including construing claim language in accordance with its ordinary and customary meaning as understood by the POSA, in view of the patent’s specification and considering the patent’s prosecution history. 37 C.F.R. § 42.100(b). We need only construe terms where the parties dispute a term’s meaning and only to the extent needed to resolve the controversy. Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019).” slip op. at 13
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“To show unpatentability based on a combination of teachings, “[a]n obviousness determination [also] requires finding both that a skilled artisan would have been motivated to combine the teachings of the prior art references to achieve the claimed invention, and that the skilled artisan would have had a reasonable expectation of success in doing so.” CRFD Rsch., Inc. v. Matal, 876 F.3d 1330, 1340 (Fed. Cir. 2017) (internal quotation marks omitted).” slip op. at 12
Claim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,974,910
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.