- PTAB · Jun 18, 2025 · IPR2025-00311 · APJ Christopher M Kaiser · IPR · Institution
The Board instituted IPR of claims 1, 3–11, and 17–22 on all asserted grounds because Petitioner showed a reasonable likelihood of prevailing on claim 1 over Mazumder and Mori.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“based on Petitioner’s first stipulation filed on December 18, 2024.15 Prelim. Resp. 13–15. Patent Owner does not address Petitioner’s updated second stipulation filed on April 8, 2025. This updated second stipulation mitigates any concerns of duplicative efforts between the district court and the Board, as well as concerns of any potentially conflicting decisions. See Sand at 12. We therefore find that this factor weighs against exercising discretion to deny institution. See id., n.5. 5. Whether Petitioner and the Defendant in the Parallel Proceeding are the Same Party Whereas Petitioner does not address factor 5, Patent Owner argues that the parties to this proceeding are both in the related district court litigation. Pet. 98–99; Prelim. Resp. 15. While it is common in IPR proceedings for the petitioner and patent owner to also be parties in a related district court proceeding, this factor weighs slightly in favor of discretionary denial. Fintiv, Paper 11 at 13–14.” slip op. at 15
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“c) Conclusion Regarding Claim 1 Based on the current record, we determine that there is a reasonable likelihood that Petitioner will prevail in demonstrating that claim 1 is unpatentable as obvious over the combination of Mazumder and Mori. Accordingly, we institute inter partes review with respect to all claims and all grounds asserted in the Petition. 5. Claims 3, 5–7, 9, 10, and 19–22 Because Petitioner demonstrates a reasonable likelihood of success in proving that at least one claim of the ’324 patent is unpatentable, we institute on all grounds and all claims raised in the Petition. See 37 C.F.R. § 42.108(a). Therefore, at this stage of the proceeding, it is not necessary for us to provide an assessment of every challenge raised by Petitioner, especially, as in this case, when Patent Owner does not separately argue those claims. See Prelim. Resp. 28–46. Those challenges, in our view, are best left for trial after full development of the record.” slip op. at 27
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“reference must be analogous art to the claimed invention. In re Bigio, 381 F.3d 1320, 1325 (Fed. Cir. 2004). For a reference to be analogous art, it must be “either in the field of the applicant's endeavor or [be] reasonably pertinent to the problem with which the inventor was concerned.” In re Kahn, 441 F.3d 977, 986-87 (Fed. Cir. 2006) (citing In re Oetiker, 977 F.2d 1443, 1447 (Fed. Cir. 1992)). “A reference is reasonably pertinent if, even though it may be in a different field from that of the inventor's endeavor, it is one which, because of the matter with which it deals, logically would have commended itself to an inventor's attention in considering his problem.” In re Clay, 966 F.2d 656, 659 (Fed. Cir. 1992).” slip op. at 20
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“Mazumder because “the presentation of both image types would have beneficially aided the remote user to more easily visually compare the actual image and virtual image to quickly identify any defects or problems with the fabrication process.” Pet. 23–24 (citing Ex. 1003 ¶ 113). Patent Owner argues that “it is hindsight to use ‘the invention to define the problem the invention solves.’” Prelim. Resp. 43 (quoting Mintz v. Dietz & Watson, Inc., 679 F.3d 1372, 1377 (Fed. Cir. 2012); citing AT&T Services Inc. et. al. v. Innovative Sonic Ltd., IPR2024-001143 (PTAB Feb. 11, 2025)). According to Patent Owner, because neither Mazumder nor Mori teaches visual comparison of image types, the idea to improve the Mazumder-Mori combination by simultaneously displaying different image types and thus permitting visual comparison must be driven by hindsight. Id. at 44–45. But Petitioner cites evidence other than the ’324 patent to support the person of ordinary skill in the art having a desire to visually compare the different images presented in the Mazumder-Mori combination. Pet. 23–24 (citing Ex. 1003 ¶ 113). Specifically, Dr. Wolfe testifies that “the presentation of the actual images captured by the camera and the virtual images simultaneously within the user interface would have beneficially aided the remote user to more easily visually compare the actual image and virtual image to quickly identify any defects or problems with the fabrication process” and that a person of ordinary skill in the art would have recognized this. Ex. 1003 ¶ 113. Thus, Petitioner has shown sufficiently for the purpose of the present decision that Mori teaches or suggests the disputed limitation of claim 1. We encourage the parties to develop the arguments and the record surrounding this issue further during the trial.” slip op. at 26
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,562,324 - PTAB · Jun 6, 2025 · IPR2025-00300 · APJ Sharon Fenick · IPR · Institution
The Board instituted IPR on claims 1–12 on all asserted grounds and granted LG’s motion to join the Vizio IPR, subject to participation limits.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“ANALYSIS A. Institution of Inter Partes Review We instituted an inter partes review in the Vizio IPR on all challenged claims and all asserted grounds of unpatentability. Vizio IPR, Paper 12; see also Vizio IPR, Paper 1 (the “Vizio Petition”). Petitioner here challenges the same claims and asserts the same grounds of unpatentability as those on which we instituted the Vizio IPR. Compare Pet. 1–2, with Vizio Petition, 1–2. Petitioner also relies on an identical declaration from the same declarant as relied upon by the petitioner in the Vizio IPR. Mot. 1 (“[Petitioner] . . . relies upon the same expert declaration as relied upon in the Vizio IPR.”); Ex. 1003, 1 (cover page indicating Declaration of Henry Houh in support of the petition submitted in IPR2024-00723), 134 (signature page dated March 21, 2024). Because the grounds of unpatentability in the instant Petition are identical to those in the Vizio IPR, for the same reasons stated in our Decision to Institute in the Vizio IPR we institute inter partes review in this proceeding on the grounds presented in the Petition. See Vizio IPR, Paper 12, 12–41 (analyzing challenges in the Vizio Petition).” slip op. at 10
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“We determine that Petitioner has met its burden of showing that joinder is appropriate because the “Petition is substantively identical to the petition in the Vizio IPR,” “challenging the same claims of the ’384 Patent on the same grounds while relying on the same prior art, arguments, and evidence,” and relying “upon the same expert declaration as relied upon in the Vizio IPR.” Mot. 1, 4–5. Petitioner represents that joinder will not impact the Vizio IPR schedule. Id. at 5–6. Petitioner also represents that it “explicitly agrees to take an ‘understudy’ role” and “will assume the primary role only if Vizio cease to participate in the Vizio IPR.” Id. at 6– 7.” slip op. at 11
NonePatents in suitUS 9,578,384 - PTAB · Mar 20, 2025 · IPR2024-01406 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board instituted IPR on claims 1, 3, 4, 8–13, and 15 on all asserted grounds, finding a reasonable likelihood that Takeuchi anticipates those claims.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314 (2018); see also 37 C.F.R. § 42.4 (2023). For the reasons discussed below, we determine that Petitioner establishes a reasonable likelihood of prevailing with respect to the unpatentability of at least one claim of the ’202 patent. Accordingly, we institute an inter partes review of claims 1, 3, 4, 8–13, and 15 of the ’202 patent. A. Real Parties in Interest” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“or “POSITA”) would have had “a bachelor’s degree in mechanical engineering, electrical engineering, or a related field, and three to four years of experience, or a master’s degree in mechanical engineering, electrical engineering, or a related field, and one to two years of experience.” Pet. 6 (citing Ex. 1003 ¶ 13). Petitioner further contends that “[s]uch experience would include a familiarity with thermal fluid delivery devices and/or the components and underlying technology used therein, and a higher level of 1 US 5,249,586, issued Oct. 5, 1993 (Ex. 1004, “Morgan”). 2 EP 0 845 220 B1, published Jan. 26, 1998 (Ex. 1006, “Susa”). 3 US 2005/0205084 A1, published Sept. 22, 2005 (Ex. 1007, “Gupta”). 4 US 6,155,268, issued Dec. 5, 2000 (Ex. 1009, “Takeuchi”). at 6–7 (citing Ex. 1003 ¶ 13). Patent Owner states that, for purposes of the Preliminary Response, “Patent Owner maintains that Petitioners’ arguments fail even under Petitioners’ POSA definition.” Prelim. Resp. 13. On this record, we preliminarily adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’202 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))). B. Claim Construction” slip op. at 6
- Prior constructionPrior construction adoptedDecided for petitioner
“term “wicked into contact” that the Board adopted in a prior inter partes review proceeding that addressed the same term in an earlier, related patent. Pet. 7 (citing IPR2020-01602, Paper 32 at 8–15 (PTAB March 30, 2022)). ‘wicked into contact’ to mean: ‘wicked into contact (1) with the heater, or (2) with an area in close proximity to, and exposed [to] the heat produced by, the heater,’” and “[t]he present Petition adopts this formal construction for purposes of this IPR proceeding.” Id. (citing IPR2020-01602, Paper 32 at 15). Patent Owner also “adopts this construction for purposes of” the Preliminary Response, and argues that “Petitioner’s grounds fail even under its proposed construction of ‘wicked into contact.’” Prelim. Resp. 13. For purposes of this Decision, we adopt the Board’s prior construction of “wicked into contact,” namely, “wicked into contact (1) with the heater, or (2) with an area in close proximity to, and exposed to the heat produced by, the heater,” which is undisputed on this record. See Philip Morris Products, S.A. v. RAI Strategic Holdings, Inc., IPR2020-01602, Paper 32 at 8–15 (PTAB March 30, 2022). C. Asserted Anticipation by Morgan” slip op. at 7
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot reached
“To establish anticipation, each and every element in a claim, arranged as recited in the claim, must be found in a single prior art reference. Net Karsten Mfg. Corp. v. Cleveland Golf Co., 242 F.3d 1376, 1383 (Fed. Cir. 2001). “A reference may anticipate inherently if a claim limitation that is not expressly disclosed is ‘necessarily present, or inherent, in the single anticipating reference.’” In re Montgomery, 677 F.3d 1375, 1379 (Fed. Cir. 2012) (quoting Verizon Servs. Corp. v. Fibernet Va., Inc., 602 F.3d 1325, 1336–37 (Fed. Cir. 2010)). Based on the current record, we are not persuaded that Petitioner sufficiently establishes that Morgan discloses “a storage compartment . . . being arranged such that the liquid aerosol-forming material can be wicked into contact with the electrical resistance heater to volatilize the liquid aerosol-forming material” as recited in claim 1.” slip op. at 12
Claim construction§ 102 anticipationcites PhillipsPatents in suitUS 11,925,202 - PTAB · Feb 27, 2025 · IPR2024-01228 · APJ Kimberly Mcgraw · IPR · Institution
The Board instituted IPR on all challenged claims and all asserted grounds after finding a reasonable likelihood that claim 1 is unpatentable over Fukui.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“c) Conclusion Petitioner shows a reasonable likelihood that it would prevail in showing that claim 1 is unpatentable over Fukui. Accordingly, we institute inter partes review of all challenged calms based on all grounds asserted in the Petition. See SAS, 138 S.Ct. at 1354.” slip op. at 25
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDenied
“III. DISCRETION TO DENY INSTITUTION UNDER 35 U.S.C. § 325(d) Patent Owner argues that if the Board determines that Petitioner’s Fukui-based grounds 1 and 2 are deficient, then the Board should deny institution under § 325(d). Prelim. Resp. 26. In particular, Patent Owner asserts that remaining grounds 3 through 5 rely on art (i.e., Sauter) a reference that is substantially similar to art that was before the Examiner (i.e., Sedor). Id. at 26–27. Because we do not determine that Fukui-based grounds are deficient, we decline to exercise our discretion to deny institution under § 325(d).” slip op. at 31
- Skill levelSkill level petitioner adoptedDecided for petitioner
“time it was made, we consider the level of ordinary skill in the pertinent art at the time of the invention. Graham, 383 U.S. at 17. Petitioner contends that a person of ordinary skill in the art (“POSITA”) “would have a B.S. degree or equivalent in mechanical or electrical engineering or similar fields, in addition to a minimum of two years of professional experience with or graduate studies involving design, development, and/or utilization of optical communication systems.” Pet. 26. (citing Ex. 1003 ¶¶ 19–21). At this stage of the proceeding, Patent Owner neither responds to Petitioner’s proposed definition, nor provides a definition of its own. See Prelim. Resp. Petitioner’s undisputed proposed definition appears to be consistent with the cited prior art and the disclosure of the ’422 patent, and we adopt it for purposes of this Decision.” slip op. at 10
- Claim Construction › Intrinsic evidence (Phillips canons) › Prosecution history disclaimer / disavowalTerm construed petitioner constructionDecided for petitioner
“Based on the present record, we agree with Petitioner that Patent Owner’s statements during prosecution are relevant to claim construction. Pet. 24–25. During prosecution of the parent application to the ’422 patent, Patent Owner stated, inter alia, that “a person of ordinary skill in the art would understand that the width of a cassette is simply the width of the cassettes from side to side and not some other ‘dimension’ such as the number of receptables or the like.” Ex. 1002, 187. Patent Owner further stated that it disagreed with the Examiner’s statement that paragraph 15 of the specification6 defines width in terms of the number of receptacles and that such a definition of width makes no sense in view of other claims where the standard with is defined in terms of a width of front edge of a tray on which the cassettes are secured. Id. We note that at this stage of the proceeding, Patent Owner has not provided any argument or evidence opposing Petitioner’s proposed construction or supporting the claim construction that it proposed during the district litigation. Our construction is preliminary and the parties are invited to address this claim construction more fully during trial.” slip op. at 13
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,656,422 - PTAB · Feb 27, 2025 · IPR2024-01382 · APJ Josiah C Cocks · IPR · Institution
The Board instituted IPR on claims 1–30 and all petition grounds, finding a reasonable likelihood of success based on Fukui’s teachings.
RulingsInstitution decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“A person of ordinary skill in the art (POSITA) would have a B.S. degree or equivalent in mechanical or electrical engineering or similar fields, in addition to a minimum of two years of professional experience with or graduate studies involving design, development, and/or utilization of optical communication systems. Pet. 24 (citing Ex. 1003 ¶¶ 19–21). Patent Owner does not dispute Petitioner’s assessment of the level of ordinary skill in the art, or offer its own assessment. Based on this record, we adopt Petitioner’s articulation of the level of ordinary skill in the art, which is consistent with the ’423 patent and the asserted prior art, and we apply it in our patentability evaluations below. See also Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the prior art, itself, can reflect appropriate level of ordinary skill in art).” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“In this proceeding, Patent Owner does not dispute any of Petitioner’s contentions as to claim construction or offer any construction of its own for any term. We are mindful of Petitioner’s view that Patent Owner’s litigation construction is inconsistent with the plain language of the claims. We also question whether that construction adds clarity in seemingly substituting “width that accommodates” for “width,” and replacing “standard width units” with “receptable modules,” without, on this record, support for such word variations. Nevertheless, our determination whether to institute trial does not require resolution of any claim construction dispute or necessitate that we adopt any particular construction for any claim term. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (holding that only claim terms in controversy need to be construed, and only to the extent necessary to resolve the controversy (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 15
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“At this time, we find persuasive Petitioner’s position that Fukui’s teachings account for the pertinent “width” requirements of each of claims 1, 9, and 17. See, e.g., Pet. 30, 32–46. On this record, Dr. Ralph provides sufficient testimony that under either of the parties’ proposed constructions of the limitations involving cassette widths, Fukui’s teachings account for those limitations. See, e.g., Ex. 1003 ¶¶ 71–98.” slip op. at 24
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“Owner’s challenge to Petitioner’s Fukui-based grounds is whether, in Fukui, a conversion module (e.g., 20) that is formed by coupling together two unit modules establishes that conversion module as a new structure identifiable as a unitary cassette.11 We discern that Fukui uses the term “conversion module” to refer to component 10, and uses that same term, i.e., “conversion module” to refer to component 20. See, e.g., Ex. 1004, 6:33–35, 7:23–25. The components 10A and 10B that make-up conversion module 20 are characterized as each being a “unit module.” See, e.g., id. at 7:25–27. Thus, once unit modules 10A and10B are coupled together to form the structure that is “conversion module 20,” the current record reasonably suggests that the conversion module 20 is a component analogous to conversion module 10, but with a larger width, i.e., two times the width. Further, Fukui also characterizes unit modules 10A and 10B as being “fixed” to one another via coupling member 21 (see, e.g., id. at 10:11–16) forming “one body” (see, e.g., id. at 8:2–3). Further still, as described and shown in Fukui (e.g., Figure 5), conversion module 20 is structured to operate via a singular multicore optical connector 16 from which optical fibers F1 extend to all of the single-core optical connectors 17 of the conversion module. Id. at 7:52– 11 There is no dispute on this record that the term “module” as used in Fukui is analogous to the term “cassette” as used in the ’423 patent. 8:6. Thus, conversion module 20 is recognizable has having a singular system of fiber optic components within its body.” slip op. at 23
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · GrahamPatents in suitUS 11,740,423 - PTAB · Feb 27, 2025 · IPR2024-01227 · APJ Christopher M Kaiser · IPR · Institution
The Board instituted IPR on all grounds for claims 1–5 and 8–13, finding a reasonable likelihood that claim 8 is anticipated by Fukui and claims 1 and 8 are obvious over Fukui-based grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“At this preliminary stage, we determine whether the information presented shows a reasonable likelihood that Petitioner would prevail in establishing that at least one of the challenged claims would have been unpatentable over the proposed prior art. We analyze the asserted grounds with the above-noted principles in mind.” slip op. at 10
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsNot reached
“Patent Owner contends that we should deny institution under 35 U.S.C. § 325(d) “because the Petition presents ‘the same or substantially the same prior art or arguments previously . . . presented to the Office.’” Prelim. Resp. 25–31 (alteration in original). Specifically, Patent Owner explains, the Office previously considered Sedor during the ’542 patent’s prosecution, and Sauter was made of record but not considered during prosecution. Id. Patent Owner, however, states that it “recognizes that this argument only reaches Sauter-based grounds, not Fukui-based grounds. This argument thus only needs to be addressed after the Board confirms the fundamental deficiencies in Petitioner’s Fukui-based grounds.” Id. at 25 n.3. Because, as set forth below, we do not, on the present record, find any “fundamental deficiencies in Petitioner’s Fukui-based grounds” that inhibit institution of trial, we regard Patent Owner’s § 325 request as moot, and we need not consider it further.” slip op. at 10
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art “would have [had] a B.S. degree or equivalent in mechanical or electrical engineering or similar fields, in addition to a minimum of two years of professional experience with or graduate studies involving design, development, and/or utilization of optical communication systems.” Pet. 26. On the present record, Patent Owner does not dispute this proposed level of skill. Prelim. Resp. 1–31. Neither party explains why the outcome of this case would be affected by the adoption of any of the proffered definitions of a person of ordinary skill in the art. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as it appears consistent with the ’542 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 11
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“enough to resolve . . . the lead Fukui ground” but that “[t]here are two disputes relevant to the alternative Sauter ground.” Pet. 22. With respect to the first of these “disputes,” Petitioner presents two claim constructions for the claim term or phrase “cassette width as measured between outer side edges thereof of one of one, two, three, four and six standard width units.” Id. at 23. The constructions are said to be from “the co-pending litigation,” with one characterized as “Patent Owner’s proposed construction”6 and the other as “CommScope’s proposed construction.”7 Of note is Petitioner’s 6 The claim construction attributed to Patent Owner is: “cassette width as measured between the outer side edges thereof that accommodates one of one, two, three, four, or six receptable modules.” Pet. 23. 7 Petitioner’s construction is: “The cassette width as measured between the outer side edges thereof equals one, two, three, four, or six times the contention that “[Patent Owner]’s construction cannot be correct,” and accompanying explanation in that respect. Id. at 22–23, 24. Patent Owner acknowledges that there is a dispute between the parties as to the noted claim construction but urges that “[t]he Board, however, need not fully resolve this claim construction dispute,” as, in Patent Owner’s view, the grounds based on Sauter are deficient based on either construction. Prelim. Resp. 21–22. We are mindful of Petitioner’s view that Patent Owner’s litigation construction is not correct. We also question whether that construction adds clarity in substituting “width that accommodates” for “width of,” and replacing “standard width units” with “receptable modules,” without, on this record, support for such word variations. Nevertheless, our determination whether to institute trial does not require resolution of any claim construction dispute, nor does it necessitate that we adopt any particular construction for the pertinent claim term. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). We invite the parties to develop the record more fully on this claim- construction issue during trial.” slip op. at 12
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,435,542 - PTAB · Feb 27, 2025 · IPR2024-01218 · APJ Josiah C Cocks · IPR · Institution
The Board instituted IPR of claims 1–5 and 8–13 on all petitioned grounds, finding a reasonable likelihood that at least one challenged claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“institute an inter partes review. The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted unless “there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a).” slip op. at 2
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“Stated somewhat generally, the core question underlying Patent Owner’s challenge to Petitioner’s Fukui-based grounds is whether a conversion module (e.g., 20) that is formed by coupling together two unit modules establishes that conversion module as a new structure identifiable as a unitary cassette. We discern that Fukui uses the term “conversion module” to refer to component 10, and uses that same term, i.e., “conversion module” to refer to component 20. See, e.g., Ex. 1004, 6:33–35, 7:23–25. The components 10A and 10B that make-up conversion module 20 are characterized as each being a “unit module.” See, e.g., id. at 7:25–27. Thus, once unit modules 10A and 10B are coupled together to form the structure that is “conversion module 20,” the current record reasonably suggests that the conversion module 20 is a component analogous to conversion module 10, but with a larger width, i.e., two times the width. Further, Fukui also characterizes unit modules 10A and 10B as being “fixed” to one another via coupling member 21 (see, e.g., id. at 10:11–16) and forming “one body” (see, e.g., id. at 8:2–3). Further still, as described and shown in Fukui (e.g., Figure 5), conversion module 20 is structured to operate via a singular multicore optical connector 16 from which optical fibers F1 extend to all of the single-core optical connectors 17 of the conversion module. Id. at 7:52– 8:6. Thus, conversion module 20 is recognizable has having a singular system of fiber optic components within its body. At this time, we regard such characterization of the coupled unit modules 10A and 10B as reasonably giving rise to an understanding that the resulting conversion module 20 constitutes a unitary module or cassette component.” slip op. at 20
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsNot reached
“IV. REQUEST FOR DENIAL UNDER 35 U.S.C. § 325 Patent Owner contends that the Board should exercise its discretion to deny under 35 U.S.C. § 325(d) on the theory that the Petitioner relies on substantially the same prior art and arguments that were previously considered by the Office. See Prelim. Resp. 31–37. Patent Owner, however, states the following: “Patent Owner recognizes that this argument only reaches Sauter-based grounds, not Fukui-based grounds. This argument thus only needs to be addressed after the Board confirms the fundamental deficiencies in Petitioner’s Fukui-based grounds.” Id. at 31, n.4. Because, as set forth above, we do not agree at this time as to any “fundamental deficiencies in Petitioner’s Fukui-based grounds” that inhibit institution of trial, we regard Patent Owner’s § 325 request as moot, and need not consider it further.” slip op. at 23
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“We are mindful of Petitioner’s view that Patent Owner’s litigation construction is not correct. We also question whether that construction adds clarity in substituting “width that accommodates” for “width of,” and replacing “standard width units” with “receptable modules,” without, on this record, support for such word variations. Nevertheless, our determination whether to institute trial does not require resolution of any claim construction dispute or necessitate that we adopt any particular construction for any claim term. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (holding that only claim terms in controversy need to be construed, and only to the extent necessary to resolve the controversy (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). 9 The claim construction attributed to Patent Owner is: “cassette width that accommodates one of one, two, three, four, or six receptable modules.” Pet. 21. 10 Petitioner’s construction is: “The cassette width equals one, two, three, four, or six times the standard width unit, without an additional amount. This means the cassette width must be evenly divisible by the standard width unit.” Pet. 21.” slip op. at 12
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · GrahamPatents in suitUS 10,795,107 - Menard, Inc. v. Signify Holdings B.V.InstitutedPTAB · Feb 14, 2025 · IPR2024-01469 · APJ Steven M Amundson · IPR · Institution
The Board instituted review of claims 1–20 on all petitioned challenges and granted Menard’s motion to join the Luminex IPR.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Here, Petitioner presents substantively identical challenges to claims 1–20 in the ’336 patent based on the same prior art, the same evidence, and the same unpatentability theories as Luminex presents in the Luminex IPR. Compare Pet. 15–89, with IPR2024-00101, Paper 1 (“Luminex Pet.”) at 15–89. According to Petitioner, the Petition differs from Luminex’s petition only because of different party names and updated sections concerning standing, related matters, real parties in interest, and counsel. Mot. 4. Because Petitioner presents substantively identical challenges to claims 1–20 in the ’336 patent based on the same prior art, the same evidence, and the same unpatentability theories as Luminex presents in the Luminex IPR, Petitioner satisfies the “reasonable likelihood” standard for instituting trial for the same reasons Luminex satisfied the “reasonable likelihood” standard for instituting trial. See Luminex Pet. 15–89; Luminex Inst. Dec. 19–64; Pet. 15–89.” slip op. at 14
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“Consistent with § 315(b) and § 315(c), the Board’s rules provide that “[a]ny request for joinder must be filed, as a motion under § 42.22, no later than one month after the institution date of any inter partes review for which joinder is requested.” 37 C.F.R. § 42.122(b). The Board’s rules also provide that § 42.101(b)’s one-year time bar “shall not apply when the petition is accompanied by a request for joinder.” Id. We instituted an inter partes review in the Luminex IPR on September 9, 2024. Luminex Inst. Dec. 1. On September 23, 2024, Petitioner filed the Petition and the Motion for Joinder. Pet. 91; Mot. 7. Under § 42.122(b), Petitioner timely filed the Petition and the Motion for Joinder. See 37 C.F.R. § 42.122(b).” slip op. at 15
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“If joined to the Luminex IPR, Petitioner agrees to take an “understudy” role and only “substantively participate” if Luminex is terminated from the Luminex IPR. Mot. 1, 5–6. Further Petitioner agrees that the following conditions will apply to it in its “understudy” role “so long as Luminex remains an active party”: (1) “all filings by [Petitioner] in the joined proceeding be consolidated with the filings of Luminex, unless a filing solely concerns issues that do not involve Luminex”; (2) Petitioner “shall not be permitted to raise any new grounds not instituted by the Board in the Luminex IPR, or introduce any argument not already introduced by Luminex”; and (3) “with regard to taking of testimony, [Petitioner] will abide by 37 C.F.R. § 42.53 or any agreement between the Patent Owner and Luminex.”” slip op. at 17
- PTAB / AIA Trials › §315(e) estoppelEstoppel appliesOther
“5. CONCLUSION For the reasons discussed above, we determine that it is appropriate under the circumstances here to join Petitioner as a party to the Luminex IPR. See §§ III.D.2–III.D.4. The estoppel provisions of 35 U.S.C. § 315(e) will apply to Petitioner.” slip op. at 18
NonePatents in suitUS 10,299,336 - Motorola Solutions, Inc. v. Stellar LLCInstitutedPTAB · Feb 13, 2025 · IPR2024-01206 · APJ Brian J Mcnamara · IPR · Institution
The Board instituted IPR on claims 1–13, finding a reasonable likelihood that the challenged claims would have been obvious under the asserted Yerazunis- and Ely-based grounds.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“validity repeats all of the assertions in this Petition.” Prelim. Resp. 13. Thus, a significant portion of the resources consumed in preparing for trial would likely be useful in this proceeding. On November 11, 2024, Petitioner offered a stipulation, stating that, upon institution of this proceeding, Petitioner “will not pursue as to the challenged claims any ground raised or that reasonably could have been raised during the IPR” in the parallel litigation. See Ex. 1043 (filed in this proceeding Nov. 27, 2024). Petitioner’s stipulation applies to the following proceedings, which includes this proceeding: IPR2024-01205, challenging claims 1–20 of U.S. Patent No. 7,593,034; IPR2024-01206, challenging claims 1–13 of U.S. Patent No. 9,485,471; IPR2024-01207, challenging claims 1–22 of U.S. Patent No. 9,912,914. As all the claims of the ’471 patent are challenged in this proceeding, Petitioner’s stipulation applies to the entirety of the ’471 patent. In view of Petitioner’s stipulation, the substantial number of issues to be addressed in the District Court, Patent Owner’s acknowledgement that Petitioner’s expert report in the parallel litigation repeats the assertions in this Petition, and the potential reduction of issues to be tried in the parallel litigation, our weighing of the factors is against exercising discretion to deny institution. As discussed below, we also recognize that Petitioner’s contentions have merit. In consideration of the above, we decline to exercise discretion to deny institution. We now address the substantive issue presented in the Petition.” slip op. at 6
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“(“Petition” or “Pet.”), to institute an inter partes review (“IPR”) of claims 1– 13 (the “challenged claims”) of U.S. Patent No. 9,485,471 B2 (“the ’471 patent”). 35 U.S.C. § 311. Stellar LLC (“Patent Owner”) filed a Preliminary Response, Paper 8 (“Prelim. Resp.”), contending that the Petition should be denied as to all challenged claims. We have jurisdiction under 35 U.S.C. § 6. 35 U.S. C. § 314 provides that an inter partes review may not be instituted unless the information presented in the Petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” A decision to institute under § 314 may not institute on fewer than all claims challenged in the petition. SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1359–60 (2018). In addition, per Board practice, if the Board institutes trial, it will institute “on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” See 37 C.F.R. § 42.108(a). Having considered the arguments and the associated evidence presented in the Petition and the Preliminary Response, for the reasons described below, we institute inter partes review.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner
“Patent Owner’s arguments that an ordinarily skilled artisan would not have had reason to combine the teachings of Yerazunis and Fiore are similar to its substantive arguments that the references fail to disclose the limitations of the claims. We address these arguments in the context of the claim limitations separately below. We note that Petitioner does not rely on Fiore as disclosing all the claim limitations, and instead cites Fiore as disclosing a memory management structure applicable to the system disclosed by Yerazunis. In the context of the claimed subject matter, we determine that, for purposes of this Decision, Petitioner has demonstrated a person of ordinary skill would have had reason to apply the memory mapping structure from being overwritten, as taught by Yerazunis.” slip op. at 17
- Skill levelSkill level petitioner adoptedDecided for petitioner
“VIII. LEVEL OF ORDINARY SKILL IN THE ART Petitioner describes a person of ordinary skill in the art (“POSITA” or “ordinarily skilled artisan”) as having “at least a Bachelor’s Degree in electrical engineering, computer science, or computer engineering, or undergraduate training in an equivalent field and at least two years of relevant experience in electronics technology.” Pet. 7 (citing Ex. 1003, Sarhan Decl. ¶¶ 24–25). Petitioner further states that “[a]dditional graduate education could substitute for professional experience, and significant work experience could substitute for formal education.” Id. Patent Owner does not address the qualifications of a person of ordinary skill in the art. See generally Prelim. Resp. The level of ordinary skill in the art usually is evidenced by the references themselves. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In 4 U.S. Patent 7,158,167, issued Jan. 2, 2007 (Ex. 1017) 5 U.S. Patent Publication No. 2002/191952, published Dec. 19, 2002 (Ex. 1009) 6 U.S. Patent Publication No. 2004/008255, published Jan. 15, 2004 (Ex. 1019) 7 EP 1,064,783, published June 4, 2003 (Ex. 1015) 8 U.S. Patent 5,982,418, issued Nov. 9, 1999 (Ex. 1020) description of a person of ordinary is commensurate with the subject matter of the ’471 patent and the references, we apply Petitioner’s description for purposes of tie Decision.” slip op. at 9
§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 9,485,471 - Motorola Solutions, Inc. v. Stellar LLCInstitutedPTAB · Feb 13, 2025 · IPR2024-01207 · APJ Robert L Kinder · IPR · Institution
The Board instituted IPR on claims 1–22, finding a reasonable likelihood that at least one claim is unpatentable under the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“validity repeats all of the assertions in this Petition.” Prelim. Resp. 13. Thus, a significant portion of the resources consumed in preparing for trial would likely be useful in this proceeding. On November 11, 2024, Petitioner offered a stipulation, stating that, upon institution on this proceeding, Petitioner “will not pursue as to the challenged claims any ground raised or that reasonably could have been raised during the IPR” in the parallel litigation. See Ex. 1043 (filed in this proceeding Nov. 27, 2024). Petitioner’s stipulation applies to the following proceedings, which includes this proceeding: IPR2024-01205, challenging claims 1–20 of U.S. Patent No. 7,593,034; IPR2024-01206, challenging claims 1–13 of U.S. Patent No. 9,485,471; IPR2024-01207, challenging claims 1–22 of U.S. Patent No. 8,692,882; and IPR2024-01208, challenging claims 1–23 of U.S. Patent” slip op. at 6
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Having considered the arguments and the associated evidence presented in the Petition and the Preliminary Response, for the reasons described below, we institute inter partes review.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“At this stage of the proceeding, we are persuaded that Petitioner has established a reasonable likelihood that a person of ordinary skill would have combined the teachings of Yerazunis and Fiore for the reasons arguments do not directly address the specific combination proposed by Petitioner nor the specific motivations provided by Petitioner. For example, as explained further below in our analysis of claim 1, the gun embodiment of Yerazunis does not stop recording video after a triggering event. See Ex. 1017, 17:50–59. Moreover, Fiore’s file-based approach would provide the benefits highlighted by Petitioner regardless of whether Yerazunis stops recording video after a triggering event or continues recording to the next event. Similarly, the argument that Fiore does not selectively write protect data does not address Petitioner’s combination, which relies on Yerazunis, not Fiore, for teaching selectively write protecting data. Patent Owner’s argument also does not explain why a person of ordinary skill would not use Fiore’s file-based approach in implementing Yerazunis’s video recording device. Finally, Patent Owner’s argument that Fiore does not store individual segments within the circular buffer does not address Petitioner’s reliance on Yerazunis’s gun implementation in which individual segments are stored in the circular buffer. See Pet. 28 (“Yerazunis does disclose that in a gun camera embodiment, ‘the head pointer 104 and the tail pointer 102 . . . defining the area(s) of the circular buffer memory, are stored in a table to allow later retrieval of the video data pertaining to each firing of the gun.’” (quoting Ex. 1017, 17:50–56)); see also Pet. 30–32, 38–39.” slip op. at 22
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableInstituted
“of Yerazunis in combination with Fiore. On this record, Petitioner has demonstrated the similarities in the data recording systems of Yerazunis and Fiore. Petitioner asserts a reasonably sufficient basis for establishing the “specified frame data associated with [the] firing event” to be preserved as the disclosure of a designated segment that is write-protected. Based on the current record, we find Petitioner’s evidence more persuasive than Patent Owner’s assertion that Yerazunis preserves the entire buffer—not designated segments. Again, Petitioner admits Yerazunis does not expressly refer to “indexing write-protected segments as second files” but further establishes with sufficient basis that a person of ordinary skill in the art would understand the tagging features of Yerazunis aligns with the concept of indexing. Further, Petitioner shows that eventually it will be necessitated to locate or retrieve the data, providing further motivation for indexing, which is not only disclosed in Fiore, but demonstrated as well known in the art. See Pet. 28–29. Petitioner demonstrates the combination of Fiore and thus, on the current record, we are not persuaded by Patent Owner’s argument that Yerazunis only preserves post-recording data. Patent Owner further does not provide sufficient basis of reasoning that the “memory designation scheme” of Yerazunis which uses “unused block[s] of memory” establishes there is no write-protected segment. In consideration of the above, we are persuaded for purposes of this Decision that Petitioner has cited sufficient evidence to demonstrate that person of ordinary skill in the art would have had a rational basis to combine the teachings of Yerazunis and Fiore and this combination teaches these limitations of element 4.” slip op. at 33
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,692,882
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.