- PTAB · May 26, 2026 · IPR2025-00425 · APJ Kristina M Kalan · IPR · Remand
The Board denied institution of IPR2025-00425 because it instituted the earlier-considered IPR2025-00424 challenging the same patent.
RulingsRemand decision- RemandOther
“Request for Director Review. See Paper 35; IPR2025-00424, Paper 35. The request was denied without prejudice and the cases were remanded to the Board to “allow discovery, narrowly tailored to resolve the RPI and privity issues.” Paper 41, 4. Following such discovery, we were instructed to “then determine on the full record whether Petitioners have met their burden of demonstrating that the Petitions are not time-barred under § 315(b), applying the framework set forth in Worlds Inc. v. Bungie, Inc., 903 F.3d 1237, 1242– 44 (Fed. Cir. 2018).” Id. A later-issued Order Supplementing Director Review Decision instructed that “if the Board determines that Petitioners met their burden to identify all RPIs in the Petitions, then the Board should maintain at most one IPR challenging” the ’225 patent. Paper 64, 3. Concurrently herewith, we issue a decision in IPR2025-00424 finding that Petitioner has met its burden of demonstrating that the Petition in that case is not time-barred under 35 U.S.C. § 315(b).” slip op. at 3
- Other 314aInstitution denied discretionary otherInstitution denied
“In connection with the ’225 patent, Petitioner filed two petitions requesting inter partes review: the petition in this proceeding (IPR2025- 00425), and the petition in IPR2025-00424. In this proceeding and in IPR2025-00424, Petitioner filed an Explanation regarding the necessity of multiple petitions. Paper 2; IPR2025-00424, Paper 2. Petitioner requested that, “if the Board uses its discretion to institute the Petitions, the Board consider the merits of IPR2025-00424 . . . before IPR2025-00425.” Paper 2,” slip op. at 2
Discretionary denialPatents in suitUS 10,589,225 - Berkshire Hathaway Energy Company / Pacificorp v. Birchtech Corp.Institution deniedPTAB · May 20, 2026 · IPR2025-00423 · APJ Zhenyu Yang · IPR · Institution
The Board denied institution of IPR challenging claims 1–4 and 6–29 because it instituted the ranked IPR2025-00422 under the Director’s instruction to maintain at most one IPR.
RulingsInstitution decision- Parallel petitionsInstitution denied discretionary otherDenied
“Paper 34. Birchtech Corp. (“Patent Owner”) filed a Request for Director Review in each case. See Paper 40; IPR2025-00422, Paper 39. The Director denied the request without prejudice in each case and remanded the cases to the Board to “allow discovery, narrowly tailored to resolve the RPI and privity issues.” Paper 49, 4. The Director later issued an Order Supplementing Director Review Decision in each case, instructing that “if the Board determines that Petitioners met their burden to identify all RPIs in the Petitions, then the Board should maintain at most one IPR challenging” the ’430 patent. Paper 72, 3.” slip op. at 2
Discretionary denialPatents in suitUS 10,668,430 - PTAB · Feb 10, 2026 · IPR2025-00688 · APJ Kristina M Kalan · IPR · Remand
On remand, the Board denied institution of IPR on claims 1–18 because this was the second-ranked petition and the Director directed institution of only one petition.
RulingsRemand decision- RemandDecided for patent owner
“Remand, do not institute inter partes review based on the second-ranked petition on this complete record. As stated in the Remand, “Petitioners present ten total grounds challenging the claims of the ’370 patent and thirteen total grounds challenging the claims of the ’218 patent [in IPR2025- 00717 and IPR2025-00718].” Remand 3. The Remand cites to the Board’s Trial Practice Guide, which “explains that ‘one petition should be sufficient to challenge the claims of a patent in most situations’ and ‘multiple petitions by a petitioner are not necessary in the vast majority of cases.’” Id. (citing Patent Trial and Appeal Board Trial Practice Guide (“TPG”) § II.D.2 (Dec. 12, 2025)). The Remand states: “The TPG further explains that dispute requiring arguments under multiple prior art references.’ TPG § II.D.2.” Id. at 2–3. The Remand determines: “Given that Petitioners had ample room in each petition to present multiple grounds challenging the claims of each patent, this was not a ‘rare’ circumstance that justified the filing of multiple petitions against each patent.” Id. at 3. The Remand explains that “absent exceptional circumstances, in a case where there is a dispute over priority date, the Board should either resolve the priority date issue or institute, at most, the first-ranked petition.” Id. The Director instructed the Board panel “to determine which of the two petitions” to institute. Id. at 4. We interpret the Remand as stating that the Director has determined that only one petition for each patent should have been instituted, and as delegating the discretionary authority to the panel to determine which of the two petitions to institute. Accordingly, in view of the foregoing and in view of Petitioner’s ranking of this Petition as the second-ranked petition, we deny institution of inter partes review.” slip op. at 11
- Parallel petitionsInstitution denied discretionary otherInstitution denied
“Remand, do not institute inter partes review based on the second-ranked petition on this complete record. As stated in the Remand, “Petitioners present ten total grounds challenging the claims of the ’370 patent and thirteen total grounds challenging the claims of the ’218 patent [in IPR2025- 00717 and IPR2025-00718].” Remand 3. The Remand cites to the Board’s Trial Practice Guide, which “explains that ‘one petition should be sufficient to challenge the claims of a patent in most situations’ and ‘multiple petitions by a petitioner are not necessary in the vast majority of cases.’” Id. (citing Patent Trial and Appeal Board Trial Practice Guide (“TPG”) § II.D.2 (Dec. 12, 2025)). The Remand states: “The TPG further explains that dispute requiring arguments under multiple prior art references.’ TPG § II.D.2.” Id. at 2–3. The Remand determines: “Given that Petitioners had ample room in each petition to present multiple grounds challenging the claims of each patent, this was not a ‘rare’ circumstance that justified the filing of multiple petitions against each patent.” Id. at 3. The Remand explains that “absent exceptional circumstances, in a case where there is a dispute over priority date, the Board should either resolve the priority date issue or institute, at most, the first-ranked petition.” Id. The Director instructed the Board panel “to determine which of the two petitions” to institute. Id. at 4. We interpret the Remand as stating that the Director has determined that only one petition for each patent should have been instituted, and as delegating the discretionary authority to the panel to determine which of the two petitions to institute. Accordingly, in view of the foregoing and in view of Petitioner’s ranking of this Petition as the second-ranked petition, we deny institution of inter partes review.” slip op. at 11
Discretionary denialPatents in suitUS 10,933,370 - PTAB · Feb 10, 2026 · IPR2025-00718 · APJ Zhenyu Yang · IPR · Remand
On remand, the Board denied institution of IPR on claims 1–4 and 6–26 because it instituted the higher-ranked competing petition, IPR2025-00717.
RulingsRemand decision- Director reviewDirector review, grantedOther
“The Director granted Director Review, finding that the panel “abused its discretion in granting institution of two petitions that each challenge the same claims” of the ’218 patent. Paper 38 (“Remand Order”), 2. The Director vacated the DI and remanded the case to the Board “to determine which of the two petitions” to institute. Id. at 4.” slip op. at 4
- Parallel petitionsInstitution denied discretionary otherInstitution denied
“In its Explanation regarding the necessity of multiple petitions, Petitioner requests that, “if the Board uses its discretion to institute the Petitions, the Board consider the merits of IPR2025-00[71]7 (“Vosteen589/Lissianski Petition”) before IPR2025-00[71]8 (“Sjostrom/Baldrey Petition”).” Paper 2, 3. Because we institute trial in IPR2025-00717 (see IPR2025-00717, Paper 41), under the Director’s instruction in the Remand Order, and based on Petitioner’s ranking of the petitions of IPR2025-00717 and IPR2025-00718, we deny institution in this case.” slip op. at 12
Discretionary denialPatents in suitUS 10,926,218 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Solus’s rehearing request, leaving institution denied for claims 1–8 because the petition did not adequately show motivation to combine Hanafusa and Dobashi.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve Dobashi’s RSm values. Dobashi teaches that because RSm “can be adopted as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66–3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66– 3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 4
§ 103 obviousnessPatents in suitUS 11,346,014 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show that claims 1–10 were likely obvious over the asserted combinations.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re 1 US 2013/0108922 A1, published May 2, 2013 (Ex. 1004, “Shinozaki”). 2 G. Khatibi, Temperature Dependent Elastic and Thermal Properties of Thin Copper Foils, Copper; Proceedings of the International Conference Copper ’06 (2006) (Ex. 1006, “Khatibi”). 3 Korean Patent Pub. No. 10-2012-0003485, published Jan. 10, 2012 (Ex. 1013; Ex. 1014 (English translation), “Toshio”). 4 US 2013/0108887 A1, published May 2, 2013 (Ex. 1012, “Kim”). 5 Griesi, M.B., Characterization of Electrodeposited Copper Foil Surface Roughness for Accurate Conductor Power Loss Modeling (2014) (Master’s Thesis, University of South Carolina) (Ex. 1015, “Griesi”). rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Not shown unpatentable
“For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE[6] value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added).” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner, however, does not adequately explain why a POSITA would have been motivated to modify Kim’s copper foil surface to have a Pc value of 19.2 as reported in Griesi. In particular, neither Petitioner nor Dr. Randall points us to, nor do we discern, any teaching in Griesi that a peak count of 19.2 provides any particular benefits or properties that would have lead a POSITA to modify Kim’s copper foil surface as Petitioner proposes. Instead, Petitioner’s arguments that a POSITA would have been motivated to modify Kim’s copper foil surface with Griesi’s peak count patent itself. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 421 (2007) (stating that the fact finder must be aware “of the distortion caused by hindsight bias and must be cautious of arguments reliant upon ex post reasoning”). It was Petitioner’s burden to establish that the combined teachings Kim and Griesi disclose limitation [1g] as proposed. We are not persuaded that we misapprehended Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 8
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish the Khatibi, alone or in combination with Shinozaki, Toshio, and Kim, discloses limitation [1d]. We concluded that Petitioner failed to meet that burden for the reasons explained in our Decision. We are not persuaded that we overlooked or misapprehended Khatibi’s disclosures, or Petitioner’s evidence and explanation thereof, in doing so.7” slip op. at 5
§ 103 obviousnesscites KSRPatents in suitUS 10,811,689 - Seaspine Holdings Corporation v. Roger P. Jackson, M.D.Institution deniedPTAB · Aug 7, 2025 · IPR2025-00773 · APJ Mary C Hoffman · IPR · Institution
The Board denied institution because Patent Owner disclaimed claims 1–19, and declined to enter adverse judgment.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied
“challenged in the Petition and paid the requisite fee. See Ex. 2001; 37 C.F.R. § 1.321 (setting forth requirements for statutory disclaimer). Accordingly, we deny institution of the requested review. 37 C.F.R. § 42.107(e) (“No inter partes review will be instituted based on disclaimed claims.”); General Elec. Co. v. United Techs. Corp., IPR2017-00491, Paper 9 (PTAB July 6, 2017) (precedential) (denying institution based on pre-institution disclaimer of all challenged claims) (“General Electric”).” slip op. at 2
- Adverse judgmentAdverse judgmentDecided for patent owner
“interpreted Rule 42.73(b) as permitting the Board to enter adverse judgment when a patent owner disclaims all challenged claims prior to institution. See Arthrex, Inc. v. Smith & Nephew, Inc., 880 F.3d 1345, 1350 (Fed. Cir. 2018). But neither Arthrex nor Rule 42.73(b) require the entry of adverse judgment. Instead, under these circumstances, the Board has discretion to decide whether or not to enter adverse judgement. See, e.g., Bestway (USA), Inc. v. Intex Mktg., Ltd., PGR2024-00036, Paper 9, 6 (PTAB Oct. 28, 2024) (“Bestway”). Based on the facts of this case, we believe that efficient administration weighs against entry of adverse judgment. Thus, consistent with Rule 42.107(e) and General Electric, denial of institution is sufficient to dispose of this matter. See, e.g., Bestway at 8; Samsung Electronics Co., Ltd. v. Oura Health OY, IPR2024-00929, Paper 8, 3 (PTAB Dec. 9, 2024); Takeda Vaccines, Inc., v. Valneva Austria Gmbh, IPR2023-00354, Paper 7, 4 (PTAB June 9, 2023); Microsoft Corp. v. Litl, LLC, IPR2021-01011, Paper 11, 3 (PTAB Apr. 5, 2022); Cisco Sys., Inc. v. SecurityProfiling, LLC, IPR2021-01428, Paper 13, 7 (PTAB Mar. 14, 2021).” slip op. at 3
NonePatents in suitUS 11,399,873 - PTAB · Jun 25, 2025 · IPR2024-01280 · APJ Jo-Anne M Kokoski · IPR · Remand
On remand, the Board denied institution under § 314(a), finding the Fintiv factors favored denial despite declining to deny under § 325(d).
RulingsRemand decision- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsInstitution denied 325dDecided for petitioner
“Other than initials on a lengthy IDS, nothing in the record indicates that the Examiner substantively considered Takeuchi, Kim, Pienemann, or among over 1,000 other references listed on the IDS, which, as noted in the Director Review Decision, “is over 40 times the size of a typical IDS.” Pet. Remand Br. 5–6; DR Dec. 7 n.3 (citing Setting and Adjusting Patent Fees During Fiscal Year 2025, 89 FR 91898 at 91924 (Nov. 20, 2024)); Ex. 1002, 228–284. Petitioner also shows that the applicant did not respond to the Examiner’s request that the applicant specifically point out “any particular reference or portion of a reference in the [IDS] which the examiner should take [sic] pay particular attention to.” Ex. 1002, 174, 295– 302.” slip op. at 13
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivInstitution denied
“Patent Owner is likely correct that the ITC would not have been inclined to grant a stay if one had been requested at the time the Institution Decision issued. Moreover, the ITC conducted a full evidentiary hearing a month after the Institution Decision issued, and the target date for the ITC’s final determination is several months before the projected statutory deadline for the Board’s final written decision. PO Remand Br. 7. Accordingly, we determine that Fintiv factor 1 weighs in favor of discretionary denial. See also Klein Tools, Inc. v. Milwaukee Electric Tool Corp., IPR2024-01400, Paper 22 at 2 (PTAB June 9, 2025) (Acting Director Stewart determining that Fintiv factor 1 weighs in favor of discretionary denial when the ITC investigation is unlikely to be stayed, the ITC already conducted a full evidentiary hearing, and the ITC final determination is expected to issue six months before the statutory deadline for the Board’s final written decision).” slip op. at 19
Discretionary denialcites PhillipsPatents in suitUS 11,925,202 - PTAB · Jun 25, 2025 · IPR2024-01406 · APJ Jo-Anne M Kokoski · IPR · Remand
On remand, the Board denied institution of review of claims 1, 3, 4, 8–13, and 15 under § 314(a), finding the Fintiv factors favored discretionary denial.
RulingsRemand decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“stay or evidence exists that one may be granted if a proceeding is instituted.” Fintiv, Paper 11 at 6. A stay of litigation pending resolution of an inter partes review allays concerns about inefficiency and duplication of efforts, and strongly weighs against exercising our authority to deny institution. Fintiv, Paper 11 at 6. The Guidance Memo states that “the Board will apply the Fintiv factors when there is a parallel proceedings at the International Trade Commission.” Guidance Memo 2. Patent Owner asserts that a stay of the ITC Investigation had not been requested at the time of the Institution Decision,7 and argues that “the ITC does not stay investigations pending IPR.” PO Supp. Br. 4. Patent Owner also notes that the Institution Decision issued “just days before the ITC evidentiary hearing.” Id. Accordingly, Patent Owner argues that this factor favors denial. Id. Patent Owner is likely correct that the ITC would not have been inclined to grant a stay if one had been requested at the time the Institution Decision issued. Moreover, the ITC conducted a full evidentiary hearing less than three weeks after the Institution Decision issued, and the target date for the ITC’s final determination is four months before the statutory deadline for the Board’s final written decision. PO Supp. Br. 5. Accordingly, we” slip op. at 9
Discretionary denialPatents in suitUS 11,925,202 - Samsung Electronics Co., Ltd. v. Sionyx, LLCInstitution deniedPTAB · Jun 6, 2025 · IPR2025-00065 · APJ Brian D Range · IPR · Institution
The Board denied institution of IPR challenging claims 1–44 under § 314(a), finding the Fintiv factors favoring denial outweighed the Petition’s strong merits.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivInstitution denied
“stipulation would only eliminate the District Court’s consideration of Haddad204. Despite the stipulation, the District Court would still have to consider invalidity of every claim the Petition addresses and would still have to consider the Alie, Baggenstoss, and Park references. Cf. Stellar at 4 (“Petitioner’s invalidity arguments in the district court are more expansive and include combinations of the prior art asserted in these proceedings with unpublished system prior art, which Petitioner’s stipulation is not likely to moot.”). In other words, “Petitioner’s stipulation does not ensure that [this proceeding] would be a ‘true alternative’ to the district court proceeding.” Id. at 3–4. Because of the remaining overlap between the Petition and the District Court proceeding, Fintiv factor four weighs strongly in favor of discretionary denial.” slip op. at 15
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundOther
“for back side illumination (BSI), which appears to teach or suggest a textured region with surface features “located on the light incident side of the semiconductor layer and configured to interact with incident [EMR].” Pet. 22–27 (citing Ex. 1006, Fig. 5, ¶¶ 53, 68, 96; Ex. 1004 ¶¶ 39–40, 88–95, 101–107). As Petitioner and its expert explain, a person of ordinary skill in the art would have been motivated to modify Figure 5 of Alie into a BSI device because BSI devices allow more incident light to reach the semiconductor layer, resulting in more light being absorbed, an increase in the quantum efficiency, and an improvement in the signal to noise ratio. Pet. 25–26 (citing Ex. 1006 ¶¶ 68, 70; Ex. 1004 ¶¶ 39–40, 92, 95). Patent Owner argues that Alie does teach, suggest, or disclose “a textured region comprising a plurality of shallow trench isolation features.” Prelim. Resp. 9–11. But it appears Petitioner has at least shown Alie teaches or suggests this element. See discussion supra. Patent Owner further argues that Petitioner fails to present any proof that a person of ordinary skill in the art would have been motivated to modify Figure 5 of Alie into a BSI device. Id. at 11–15. But, in our view, Petitioner has provided an adequate motivation to modify Alie—so that more light will be absorbed, yielding an increase in the quantum efficiency and an improvement in the signal to noise” slip op. at 18
- Parallel petitionsNot reached
“17 Petitioner filed petitions for IPR2025-00064 and IPR2025-00065 at the same time. Both petitions address the ’682 patent but apply different art. Patent Owner also argues the second petition (IPR2025-00065) should be denied because one petition is sufficient. Patent Owner’s Response to Petitioner’s Notice Ranking Parallel Petitions, Paper 11. Because we deny institution based on Fintiv discretion, it is not necessary to reach Patent Owner’s multiple petition argument.” slip op. at 20
§ 103 obviousnessDiscretionary denialcites KSRPatents in suitUS 10,347,682
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.