- Berkshire Hathaway Energy Company / Pacificorp v. Birchtech Corp.Institution deniedPTAB · May 18, 2026 · IPR2025-00278 · APJ David Cotta · IPR · Institution
The Board denied institution of Berkshire Hathaway Energy Company and PacifiCorp’s petition because it had instituted the earlier-filed IPR2025-00274 challenging the same patent.
RulingsInstitution decision- PTAB / AIA Trials › Real party in interest / privityRpi dispute resolved for petitionerDecided for petitioner
“request from Patent Owner for Director Review, finding that Patent Owner introduced “evidence sufficient to put RPI and privity at issue” and remanding with instructions to “allow discovery, narrowly tailored to resolve the RPI and privity issues” including “at least materials sufficient to clarify the evidence the Board found to be ‘ambiguous’ and to avoid the need for the Board to ‘speculate as to the nature of the redacted material.’” Paper 57 (Decision on Request for Director Review). The Director instructed that after allowing such discovery, we “should then determine on the full record whether Petitioners have met their burden of demonstrating that the Petitions are not time-barred under § 315(b), applying the framework set forth in Worlds Inc. v. Bungie, Inc., 903 F.3d 1237, 1242–44 (Fed. Cir. 2018). Concurrently herewith, we issue a decision in IPR2025- 00278 finding that Petitioner has met its burden of demonstrating that its Petition is not time-barred under 35 U.S.C. § 315(b).” slip op. at 2
- Other 314aInstitution denied discretionary otherInstitution denied
“Review Decision instructing that “if the Board determines that Petitioners met their burden to identify all RPIs in the Petitions, then the Board should maintain at most one IPR challenging each of the ’114 patent, the ’517 patent, the ’430 patent, and the ’225 patent.” Paper 79, 3. Together with its Petition in this proceeding and the proceeding in IPR2025-00274, Petitioner filed an Explanation Regarding the Necessity of Multiple Petitions. Paper 2 (“Explanation”); IPR2025-00274, Paper 2. In the Explanation, Petitioner “request[s] that, if the Board uses its discretion to institute the Petitions, the Board consider the merits of IPR2025-00274 . . . before IPR2025-00278.” Explanation, 3. Further to Petitioner’s request, we first considered the merits of IPR2025-00274. For the reasons discussed in our concurrently issued decision in IPR2025-00274, we institute inter partes review on the grounds set forth in the Petition in IPR2025-00274. Further to the Director’s instruction that we “maintain at most one IPR challenging . . . the ’114 patent,” and the Petitioner’s request that we consider the merits of IPR2025-00274 before IPR2025-00278, we deny institution of the Petition in this proceeding.” slip op. at 3
Discretionary denialPatents in suitUS 10,343,114 - Berkshire Hathaway Energy Company / Pacificorp v. Birchtech Corp.Institution deniedPTAB · May 18, 2026 · IPR2025-00281 · APJ David Cotta · IPR · Institution
The Board denied institution because it had instituted IPR2025-00280 challenging the same patent, consistent with the Director’s instruction to maintain at most one IPR.
RulingsInstitution decision- Other 314aInstitution denied discretionary otherInstitution denied
“Review Decision instructing that “if the Board determines that Petitioners met their burden to identify all RPIs in the Petitions, then the Board should maintain at most one IPR challenging each of the ’114 patent, the ’517 patent, the ’430 patent, and the ’225 patent.” Paper 79, 3. Together with its Petition in this proceeding and the proceeding in IPR2025-00280, Petitioner filed an Explanation Regarding the Necessity of Multiple Petitions. Paper 2 (“Explanation”); IPR2025-00281, Paper 2. In the Explanation, Petitioner “request[s] that, if the Board uses its discretion to institute the Petitions, the Board consider the merits of IPR2025-00280 . . . before IPR2025-00281.” Explanation, 3. Further to Petitioner’s request, we first considered the merits of IPR2025-00280. For the reasons discussed in our concurrently issued decision in IPR2025-00280, we institute inter partes review on the grounds set forth in the Petition in IPR2025-00280. Further to the Director’s instruction that we “maintain at most one IPR challenging . . . the ’517 patent,” and the Petitioner’s request that we consider the merits of IPR2025-00280 before IPR2025-00281, we deny institution of the Petition in this proceeding.” slip op. at 3
Discretionary denialPatents in suitUS 10,596,517 - PTAB · Oct 14, 2025 · IPR2025-00747 · APJ Richard H Marschall · IPR · Institution
The Board denied institution because Buttiker was not prior art, so Petitioner did not show a reasonable likelihood that claims 5, 6, 9, or 10 were unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“establish a reasonable likelihood of proving that any of the challenged claims would have been obvious because all of the challenges rely on Buttiker for specific limitations, and Buttiker is not prior art to the challenged claims of the ’271 patent. Accordingly, Petitioner has not shown” slip op. at 16
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportPriority date awardedDecided for patent owner
“When claiming the benefit of priority to a provisional application, the provisional application must provide written description support for the claims in question. See 35 U.S.C. § 119(e) (referring to “an invention 10 Petitioner does not dispute Patent Owner’s arguments on this point in its Preliminary Reply. See Prelim. Reply 2–4. disclosed in the manner provided by section 112(a)”); see also New Railhead Mfg., L.L.C. v. Vermeer Mfg. Co., 298 F.3d 1290, 1294 (Fed. Cir. 2002) (“[T]o be afforded the priority date of the provisional application, . . . the written description of the provisional must adequately support the claims of the non-provisional application.”). Patent Owner argues that the ’688 provisional application supports claims 5, 6, 9, and 10 of the ’271 patent because they describe the method of controlling the pumps and thermal modulators to achieve selected temperatures upstream of the brewing chamber and creating a resulting solvent used to infuse a solute, creating an infused beverage. See Prelim. Sur-reply 3–4 (citing Prelim. Resp. 16–18, 35–37; Ex. 1012, 12–15). Patent Owner also refers to Figure 2 of the ’688 provisional application, which discloses the device that performs the method described in the application. See id. at 4–5. With one exception that we address immediately below, Petitioner does not contest these assertions or argue that the ’688 provisional application fails to disclose the subject matter claimed in claims 5, 6, 9, and 10 of the ’271 patent. See Pet. 18–20; Prelim. Reply 2–4. Based on our review of the record, the ’688 provisional application provides adequate written description support for the challenged claims of the ’271 patent.11 See Ex. 1012, 11–15 (describing Figure 2 of the ’688 provisional application and related methods), Fig. 2.” slip op. at 12
- Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityReference not prior artPrinted publication establishedDecided for patent owner
“only qualify as prior art under section 102(a)(1) because section 102(a)(2) does not apply to purely foreign patent publications like Buttiker. See 35 U.S.C. § 102(a)(2) (describing scope of prior art as including “a patent issued under section 151” (addressing issued U.S. patents) and “an application for patent published or deemed published under section 122(b)” (addressing published U.S. applications)); MPEP § 2152 (“The documents upon which a prior art rejection under 35 U.S.C. 102(a)(2) may be based are U.S. patent documents only.”).10 Under section 102(a)(1), Buttiker may be prior art if it “was patented [or] described in a printed publication . . . before the effective filing date of the claimed invention.” 35 U.S.C. § 102(a)(1). Buttiker published after the ’688 provisional application was filed, but before the other applications to which the ’271 patent claims priority were filed. See Ex. 1010, 1; Ex. 1001, code (60). Accordingly, whether the ’271 patent claims at issue here have adequate support in the ’688 provisional application determines whether Buttiker is prior art to those claims because Buttiker’s publication predates later applications to which the ’271 patent claims priority.” slip op. at 12
- Disclosure Requirements (§112) › Written description (Ariad)Written description adequateDecided for patent owner
“When claiming the benefit of priority to a provisional application, the provisional application must provide written description support for the claims in question. See 35 U.S.C. § 119(e) (referring to “an invention 10 Petitioner does not dispute Patent Owner’s arguments on this point in its Preliminary Reply. See Prelim. Reply 2–4. disclosed in the manner provided by section 112(a)”); see also New Railhead Mfg., L.L.C. v. Vermeer Mfg. Co., 298 F.3d 1290, 1294 (Fed. Cir. 2002) (“[T]o be afforded the priority date of the provisional application, . . . the written description of the provisional must adequately support the claims of the non-provisional application.”). Patent Owner argues that the ’688 provisional application supports claims 5, 6, 9, and 10 of the ’271 patent because they describe the method of controlling the pumps and thermal modulators to achieve selected temperatures upstream of the brewing chamber and creating a resulting solvent used to infuse a solute, creating an infused beverage. See Prelim. Sur-reply 3–4 (citing Prelim. Resp. 16–18, 35–37; Ex. 1012, 12–15). Patent Owner also refers to Figure 2 of the ’688 provisional application, which discloses the device that performs the method described in the application. See id. at 4–5. With one exception that we address immediately below, Petitioner does not contest these assertions or argue that the ’688 provisional application fails to disclose the subject matter claimed in claims 5, 6, 9, and 10 of the ’271 patent. See Pet. 18–20; Prelim. Reply 2–4. Based on our review of the record, the ’688 provisional application provides adequate written description support for the challenged claims of the ’271 patent.11 See Ex. 1012, 11–15 (describing Figure 2 of the ’688 provisional application and related methods), Fig. 2.” slip op. at 12
§ 102 anticipation§ 103 obviousness§ 112 disclosurePatents in suitUS 11,957,271 - Ascend Elements, Inc. v. Duesenfeld GmbHInstitution deniedPTAB · Oct 10, 2025 · PGR2025-00037 · APJ Kevin W Cherry · PGR · Institution
The Board denied institution of PGR on claims 1–14 because Petitioner did not show that any challenged claim was more likely than not unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“information presented in the petition filed under [35 U.S.C. §] 321 . . . demonstrates that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a). For the reasons set forth below, we determine that Petitioner has failed to demonstrate that it is more likely than not that at least one of claims 1–14 of the ’463 patent is unpatentable. Accordingly, we deny institution of a postgrant review of claims 1–14 based on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art “would have had at least a Bachelor’s degree in electrical engineering, material science, chemical engineering, or an equivalent field, as well as at least 2 to 3 years of academic or industry experience in the recycling or processing of lithiumion batteries. Additional formal education focusing on processing of lithium batteries may substitute for practical experience and additional practical experience can substitute for less education.” Pet. 10–11. Patent Owner does not contest this definition of a person of skill in the art. See Prelim. Resp. 11. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as, on the present record, it appears consistent with the ’463 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 8
- Expert testimonyPetitioner expert discountedPatent owner expert creditedDecided for patent owner
“distinct from “comminute[ion],” Petitioner offers only the testimony of its expert, Mr. Juzkow, who equates Tomioka’s “cutting” with “comminute[ion].” See Ex. 1003 ¶ 121. However, Mr. Juzkow provides insufficient reasoning to support his conclusion, particularly given the intrinsic and extrinsic evidence discussed above. In contrast, Patent Owner’s expert, Mr. Dantam, provides extensive reasoning, supported by citations to other evidence, to support his conclusion that Tomioka’s “dismantling” is not the claimed “comminution.” Thus, we give more weight to Mr. Dantam’s testimony than Mr. Juzkow’s testimony. Weighing this evidence all together, we find that Petitioner has failed to show that it is more likely than not that Tomioka’s teaches the claimed comminution under Petitioner’s first theory.” slip op. at 15
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundTeaching away not foundNot shown unpatentable
“obvious. Pet. 34–35. However, we agree with Patent Owner that Petitioner has also failed to show that it is more likely than not that Tomioka renders this limitation obvious. See Prelim. Resp. 28–31. To begin with, Petitioner’s contentions lack sufficient reasoning explaining why a person of ordinary skill would have modified Tomioka in the manner proposed. “[R]ejections on obviousness grounds cannot be sustained by mere conclusory statements; instead, there must be some articulated reasoning with some rational underpinning to support the legal conclusion of obviousness.” In re Kahn, 441 F.3d 977, 988 (Fed. Cir. 2006). Petitioner merely asserts that a person of ordinary skill in the art could use the roller system in place of the dismantling disclosed for the embodiments in Figures 19 and 20. On this record, we find this bare contention insufficient. actual disclosure of Tomioka. The rollers in Tomioka are used to separate the “battery body” from the “resin package enclosing the battery body,” and Tomioka specifically discloses that this technique is designed to “avoid damaging the battery body.” Ex. 1005 ¶¶ 25, 26, 29; Ex. 2011 ¶¶ 72–73. Thus, there is a significant difference between what Tomioka teaches and what Petitioner proposes to use the roller system to do. In addition, as Patent Owner points out, Tomioka specifically discloses there are risks associated with mechanically crushing battery packs, such as “risk of sparking due to residual voltage if the battery units are damaged in the process.” Ex. 1005 ¶ 5. Although we do not agree with Patent Owner that this amounts to a “teaching away,” see In re Gurley, 27 F.3d 551, 553 (Fed. Cir. 1994), we do believe that this teaching suggests a trade off that should be weighed in determining whether to make the modification, see Medichem S.A. v. Rolabo S.L., 437 F.3d 1157, 1165 (Fed. Cir. 2006). However, Petitioner has failed to account adequately, if at all, for this trade off. Thus, we find that Petitioner has failed to show that it is more likely than not that Tomioka accounts for the claimed “comminuting.”” slip op. at 15
§ 103 obviousness§ 112 disclosurecites Phillips · Graham · NautilusPatents in suitUS 12,119,463 - PTAB · Jun 25, 2025 · IPR2024-01280 · APJ Jo-Anne M Kokoski · IPR · Remand
On remand, the Board denied institution under § 314(a), finding the Fintiv factors favored denial despite declining to deny under § 325(d).
RulingsRemand decision- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsInstitution denied 325dDecided for petitioner
“Other than initials on a lengthy IDS, nothing in the record indicates that the Examiner substantively considered Takeuchi, Kim, Pienemann, or among over 1,000 other references listed on the IDS, which, as noted in the Director Review Decision, “is over 40 times the size of a typical IDS.” Pet. Remand Br. 5–6; DR Dec. 7 n.3 (citing Setting and Adjusting Patent Fees During Fiscal Year 2025, 89 FR 91898 at 91924 (Nov. 20, 2024)); Ex. 1002, 228–284. Petitioner also shows that the applicant did not respond to the Examiner’s request that the applicant specifically point out “any particular reference or portion of a reference in the [IDS] which the examiner should take [sic] pay particular attention to.” Ex. 1002, 174, 295– 302.” slip op. at 13
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivInstitution denied
“Patent Owner is likely correct that the ITC would not have been inclined to grant a stay if one had been requested at the time the Institution Decision issued. Moreover, the ITC conducted a full evidentiary hearing a month after the Institution Decision issued, and the target date for the ITC’s final determination is several months before the projected statutory deadline for the Board’s final written decision. PO Remand Br. 7. Accordingly, we determine that Fintiv factor 1 weighs in favor of discretionary denial. See also Klein Tools, Inc. v. Milwaukee Electric Tool Corp., IPR2024-01400, Paper 22 at 2 (PTAB June 9, 2025) (Acting Director Stewart determining that Fintiv factor 1 weighs in favor of discretionary denial when the ITC investigation is unlikely to be stayed, the ITC already conducted a full evidentiary hearing, and the ITC final determination is expected to issue six months before the statutory deadline for the Board’s final written decision).” slip op. at 19
Discretionary denialcites PhillipsPatents in suitUS 11,925,202 - PTAB · Jun 25, 2025 · IPR2024-01406 · APJ Jo-Anne M Kokoski · IPR · Remand
On remand, the Board denied institution of review of claims 1, 3, 4, 8–13, and 15 under § 314(a), finding the Fintiv factors favored discretionary denial.
RulingsRemand decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“stay or evidence exists that one may be granted if a proceeding is instituted.” Fintiv, Paper 11 at 6. A stay of litigation pending resolution of an inter partes review allays concerns about inefficiency and duplication of efforts, and strongly weighs against exercising our authority to deny institution. Fintiv, Paper 11 at 6. The Guidance Memo states that “the Board will apply the Fintiv factors when there is a parallel proceedings at the International Trade Commission.” Guidance Memo 2. Patent Owner asserts that a stay of the ITC Investigation had not been requested at the time of the Institution Decision,7 and argues that “the ITC does not stay investigations pending IPR.” PO Supp. Br. 4. Patent Owner also notes that the Institution Decision issued “just days before the ITC evidentiary hearing.” Id. Accordingly, Patent Owner argues that this factor favors denial. Id. Patent Owner is likely correct that the ITC would not have been inclined to grant a stay if one had been requested at the time the Institution Decision issued. Moreover, the ITC conducted a full evidentiary hearing less than three weeks after the Institution Decision issued, and the target date for the ITC’s final determination is four months before the statutory deadline for the Board’s final written decision. PO Supp. Br. 5. Accordingly, we” slip op. at 9
Discretionary denialPatents in suitUS 11,925,202 - Innoscience America, Inc. v. Infineon Technologies Americas Corp.Institution deniedPTAB · May 16, 2025 · IPR2025-00010 · APJ Michelle N Wormmeester · IPR · Institution
The Board denied institution of IPR challenging claims 1–14, exercising § 314(a) discretion under Fintiv because the balance of factors favored denial.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“2. Factor 2: ITC Final Determination Date Fintiv provides that an ITC trial date that is earlier than the Board’s projected statutory deadline for a final written decision may favor discretionary denial if the ITC is going to decide the same or substantially similar issues to those presented in the petition. Fintiv, Paper 11 at 8. The Guidance Memo further provides that “the Board is more likely to deny institution where the ITC’s projected final determination date is earlier than the Board’s deadline to issue a final written decision.” Guidance Memo 2. Here, the ITC has set the target date for its final determination to March 2, 2026. Ex. 2010, 3 (ITC Order Amending the Procedural Schedule). Our final written decision would be due almost three months later, in late May 2026, should we institute inter partes review.” slip op. at 8
Discretionary denialPatents in suitUS 9,070,755 - PTAB · Apr 25, 2025 · IPR2024-01492 · APJ Richard H Marschall · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–9 were unpatentable over the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Based on the foregoing, we conclude that Petitioner fails to establish that Coccia discloses “a resulting solvent valve” as required by claim 1 and as alleged in the Petition. See Pet. 35–42. 4. Conclusion Based on our review of the current record, Petitioner does not establish a reasonable likelihood of proving that claim 1 would have been obvious based on Coccia and Anson. The remaining challenged claims, claims 2–9, all ultimately depend from claim 1. See Ex. 1001, 18:42–19:48. Petitioner’s obviousness challenges to claims 2–9 build on its analysis for claim 1. See Pet. 10, 43–70, 79–86. Accordingly, for the same reasons we discuss above in the context of claim 1, Petitioner has not shown a reasonable likelihood in prevailing on its challenge to any of the dependent claims.” slip op. at 22
- Skill levelSkill level petitioner adoptedDecided for petitioner
“we view the prior art and the claimed invention. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). The person of ordinary skill in the art is a hypothetical person presumed to have known the relevant art at the time of the invention. In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995). In determining the level of ordinary skill in the art, we may consider certain factors, including: “(1) the educational level of the inventor; (2) type of problems encountered in the art; (3) prior art solutions to those problems; (4) rapidity with which innovations are made; (5) sophistication of the technology; and (6) educational level of active workers in the field.” Best Med. Int’l, Inc. v. Elekta Inc., 46 F.4th 1346, 1353 (Fed. Cir. 2022) (quoting Daiichi Sankyo Co. v. Apotex, Inc., 501 F.3d 1254, 1256 (Fed. Cir. 2007)). “The patent’s purpose can also be informative.” Id.” slip op. at 8
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“cites the specification for support, but that argument largely misses the point and elides the claim requirements tied to the resulting solvent valve. See Pet. 35; Prelim. Reply 4. Patent Owner agrees with the general proposition that “a resulting solvent valve” means one or more resulting solvent valves. See Prelim. Resp. 10 (acknowledging that “two duplicative resulting solvent valves having the three positions” could each qualify as “a resulting valve”); Prelim. Sur-reply 4–5 (“Had Petitioner cited to multiple ‘resulting solvent’ valves that each” meet the claim requirements, “Patent Owner would not have raised an issue.”). The general statement that “a” or “an” means “one or more than one,” however, does not support Petitioner’s argument that the limitation broadly covers systems where no single resulting valve meets the three claimed valve positions. The dispute does not turn on whether “a” means “one or more than one”; the dispute, rather, concerns whether the claim allows for multiple valves to meet the three claimed states or whether a single valve must meet those claim requirements.” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
“Patent Owner that Petitioner fails to establish that Coccia discloses the claimed “resulting solvent valve.” Importantly, Petitioner premises its argument for this limitation on a claim construction that we rejected in our analysis above. Because we determine that the claim requires at least one resulting valve to meet the three claimed states identified in the claim, Petitioner may not rely on a combination of Coccia’s valves 26 and 36 to provide the three claimed states, as Petitioner does throughout its analysis. See Pet. 35–42; Prelim. Reply 4. As to Petitioner’s alternative argument that Anson discloses the claimed resulting solvent valve, we decline to consider the argument because it was not included in the Petition and was made for the first time in Petitioner’s Preliminary Reply. See Pet. 35–42; Prelim. Reply 5. Petitioner relied on Anson in the Petition as an alternative reason to find that it would have been obvious to place Coccia’s valve 36 in the claimed location (downstream of the conduit joint and upstream of the brewing chamber), not to meet all of the limitations associated with the resulting solvent valve. See Pet. 38–39. Moreover, Petitioner’s limited argument and evidence in the Preliminary Reply lacks adequate development and fails to persuade us that Anson’s valve 28 performs all of the “claimed functions” associated with the resulting solvent valve, including the two “active” states that the Petition addresses with reliance on Coccia alone. See Pet. 40–42; Prelim. Reply 5. Based on the foregoing, we conclude that Petitioner fails to establish that Coccia discloses “a resulting solvent valve” as required by claim 1 and as alleged in the Petition. See Pet. 35–42. 4. Conclusion Based on our review of the current record, Petitioner does not establish a reasonable likelihood of proving that claim 1 would have been obvious based on Coccia and Anson. The remaining challenged claims, claims 2–9, all ultimately depend from claim 1. See Ex. 1001, 18:42–19:48. Petitioner’s obviousness challenges to claims 2–9 build on its analysis for claim 1. See Pet. 10, 43–70, 79–86. Accordingly, for the same reasons we discuss above in the context of claim 1, Petitioner has not shown a reasonable likelihood in prevailing on its challenge to any of the dependent claims.” slip op. at 21
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,772,456 - PTAB · Apr 25, 2025 · IPR2024-01483 · APJ Richard H Marschall · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–12 would be unpatentable over the asserted obviousness combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the challenged claims in the petition.” For the reasons that follow, we determine that Petitioner has not demonstrated a reasonable likelihood of prevailing with respect to any of the challenges in the Petition. Accordingly, we do not institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person having ordinary skill in the art at the time of the invention “would have had at least the following (or equivalents): a B.S. degree in mechanical engineering with at least five years of experience in product design; or an M.S. degree in mechanical engineering with at least two years of experience in product design.” Pet. 17 (citing Ex. 1002, 13). Patent Owner “submits a person of ordinary skill in the art (‘POSITA’) would be a mechanical or materials engineer, or other similar degree, having at least two to three years of personal experience in designing or development of espresso machines.” Prelim. Resp. 8. In the alternative, Patent Owner states that “because Petitioner’s definition is so close to that of Patent Owner’s definition, that no express finding is necessary to find Petitioner has not met its burden to show with particularity that claim 1 is unpatentable.” Id. We find Petitioner’s definition to be consistent with the problems and solutions disclosed in the ’524 patent and prior art of record, and adopt it as our own for purposes of this Decision. See, e.g., GPAC, 57 F.3d at 1579 (approving the determination of the level of ordinary skill in the art by appeal to the references of record). The outcome of this case would remain the same if we applied Patent Owner’s similar proposal.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“standard set forth in Phillips v. AWH Corp., 415 F.3d 1303 (Fed. Cir. 2005) (en banc). Under that standard, we give the words of a claim their plain and ordinary meaning as would have been understood by one skilled in the art at the time of the invention and in the context of the entire patent disclosure. Id. at 1312–13. Only terms in controversy need be construed, and only to the extent necessary to resolve the controversy. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017). The parties propose constructions for several claim terms. For example, Petitioner contends that we should construe “conduit,” “coupled,” “another solvent,” and “dynamically modulate.” See Pet. 13–17. Patent Owner reserves its right to challenge Petitioner’s constructions and proposes its own constructions for “another solvent” and “communicatively coupled.” Prelim. Resp. 9–11. We determine that we need not construe any of these additional terms to determine whether Petitioner met its burden as to any of its challenges in the Petition.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“that any of them disclose an electronic controller coupled to two pumps and a thermal modulator, such as a heater. Petitioner suggests that Lai’s controller controls two “pump(s),” but Lai appears to describe a single pump 138, and Petitioner fails to point to any disclosure or suggestion in Lai that its system employs more than one pump. See Pet. 38–39 (citing Ex. 1002, 41–42); Ex. 1007 ¶ 98, Fig. 60. Petitioner does not directly assert that Santi discloses a controller connected to two pumps, and it too, like Lai, appears to only disclose a single pump. See Pet. 39; Ex. 1005 ¶ 64, Fig. 1. Petitioner correctly notes that Majer discloses controller 9 connected to two pumps, but we agree with Patent Owner that only one of those pumps meets the requirements of the claimed pumps, which are both connected to conduits that eventually lead to the brewing chamber. See Pet. 40; Prelim. Resp. 28; Ex. 1008, 9:11–12 (describing circuit C2 containing pump 4bis as not including any “brewing means”). In addition, Petitioner does not allege, and Majer does not appear to disclose, a controller coupled to Majer’s heating elements. See Pet. 40. Based on the foregoing, none of the prior art Petitioner relies on discloses an electronic controller that controls both claimed pumps and a thermal modulator. Despite these deficiencies, Petitioner summarily concludes that one of ordinary skill in the art “would have recognized that it would be obvious to combine Startz’s machine with the electronic controller of any of Lai, Santi, and/or Majer, and that such electronic controller would be communicatively coupled to both the thermal modulator and the pumps.” Pet. 40 (citing Ex. 1002, 43). The Petition provides no additional rationale or argument in support of this conclusion, and the cited declarant testimony provides no further analysis. See id.; Ex. 1002, 43. Given the lack of any teaching of a controller coupled to two pumps and a thermal modulator, it was incumbent upon Petitioner to provide some reason why one of ordinary skill in the art would have been motivated to combine the references in a manner that meets the limitation.14 Because the Petition lacks any such statement or rationale, we find Petitioner’s obviousness argument and evidence lacking in this critical respect.” slip op. at 21
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,576,524 - Babybjörn AB v. The Ergo Baby Carrier, Inc.Institution deniedPTAB · Apr 22, 2025 · IPR2025-00111 · APJ Eric C Jeschke · IPR · Institution
The Board denied institution of IPR on all challenged claims under § 314(a), finding the reasons offered for a second parallel petition unpersuasive.
RulingsInstitution decision- Parallel petitionsInstitution denied discretionary otherDenied
“petitioner files two or more petitions challenging the same patent, we consider guidance in the Consolidated Trial Practice Guide, which provides that “one petition should be sufficient to challenge the claims of a patent in most situations” and that “multiple petitions by a petitioner are not necessary in the vast majority of cases.” Trial Practice Guide 59 (Nov. 2019), available at https://www.uspto.gov/TrialPracticeGuideConsolidated (“TPG”). In such circumstances, a petitioner should provide: (1) a ranking of the petitions in the order in which it wishes the Board to consider the merits, if the Board uses its discretion to institute any of the petitions, and (2) a succinct explanation of the differences between the petitions, why the issues addressed by the differences are material, and why the Board should exercise its discretion to institute additional petitions if it identifies one petition that satisfies petitioner’s burden under 35 U.S.C. § 314(a). TPG 59–60. The Trial Practice Guide provides that “the Board recognizes that there may be circumstances in which more than one petition may be necessary” and that “two petitions by a petitioner may be needed, although this should be rare.” Id. at 59.” slip op. at 9
- Novelty / Anticipation (§102) › Prior-art status of a reference › Patents / published applications (effective date, provisional support)Reference is prior artDecided for petitioner
“We disagree with Petitioner that the still-open outcome of Lynk Labs in any way impacts the availability of Lundh in either the 110 IPR or this proceeding.10 Critically, in Lynk Labs, the Federal Circuit examined the prior art date of a U.S. patent application publication under pre-AIA § 102(e)(1) because the challenged patent in that case had a priority date in February 2004—well before the 2013 effective date of the AIA’s revisions to §§ 102, 103—such that the pre-AIA versions of § 102 determined the” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Decided for patent owner
“We are not persuaded that this assertion supports the argument for a second petition. As argued by Patent Owner, Petitioner’s alleged need is undermined by the distribution of its arguments across the 110 IPR and this proceeding. As discussed above, for the “at least one thigh support adjusters” in the 110 IPR, Petitioner relies on one prior art structure from the first category and two prior art structures from the second category; and for the “at least one thigh support adjusters” in this proceeding, Petitioner relies on two prior art structures from the first category and one prior art structure from the second category. Id. In other words, as stated by Patent Owner, “Petitioner was able to address both its constructions in both of its Petitions.” Resp. 3–411; see also Medacta USA, Inc. v. RSB Spine, LLC, IPR2020-00275, Paper 22 at 10–11 (PTAB May 22, 2020) (denying institution of a second-ranked parallel petition challenging the same claims of the same patent and stating, “Because Petitioner was able to present an alternative challenge contingent upon [the] alternative claim construction” in the first-ranked petition, “we fail to see how uncertainty regarding claim construction justifies two petitions.”). In contrast, in the SolarEdge decision cited by Petitioner, the first-ranked petition presented one approach as to the prior art and the second-ranked petition was permitted because it presented a different approach, such that the two petitions “do not overlap in any meaningful way.” SolarEdge v. SMA Solar Techs., IPR2019-01224, Paper 10 at 10 (PTAB Jan. 23, 2020), cited at Expl. 4. Turning to the discovery issue, we determine that the alleged failure of Patent Owner to answer adequately an interrogatory in the Texas Litigation seeking information on “all corresponding disclosures and written 11 Petitioner highlights the two categories of prior art structures identified across the six grounds in these two proceedings rather than the two different constructions for “at least one thigh support adjuster” proposed. Looking at the distributions of the constructions presented, however, the same reasoning above applies as Petitioner relied on each construction at least twice to address the “one thigh support adjuster” in each proceeding. See 110 Petition 27 (relying on both constructions for Ground 1), 53–57 (relying on only a § 112(f) construction for Ground 2), 86–90 (relying on both constructions for Ground 3); Pet. 29–34 (relying on only a § 112(f) construction for Ground 4), 61–63 (relying on both constructions for Ground 5), 88–90 (relying on both constructions for Ground 6). description support for the ‘at least one thigh support adjuster’ limitation” (Ex. 1029 at 5) does not warrant a second petition here. The challenged patent was clearly available to Petitioner, and Petitioner was—even with Patent Owner’s non-substantive answer to the interrogatory (id. at 6)—able to propose a construction of “at least one thigh support adjuster” under § 112(f). See Pet. 7–12. For these reasons, the two different constructions presented do not warrant a second petition in this proceeding.” slip op. at 12
Claim construction§ 102 anticipationDiscretionary denialPatents in suitUS 11,786,055
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.