- PTAB · Oct 14, 2025 · IPR2025-00747 · APJ Richard H Marschall · IPR · Institution
The Board denied institution because Buttiker was not prior art, so Petitioner did not show a reasonable likelihood that claims 5, 6, 9, or 10 were unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“establish a reasonable likelihood of proving that any of the challenged claims would have been obvious because all of the challenges rely on Buttiker for specific limitations, and Buttiker is not prior art to the challenged claims of the ’271 patent. Accordingly, Petitioner has not shown” slip op. at 16
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportPriority date awardedDecided for patent owner
“When claiming the benefit of priority to a provisional application, the provisional application must provide written description support for the claims in question. See 35 U.S.C. § 119(e) (referring to “an invention 10 Petitioner does not dispute Patent Owner’s arguments on this point in its Preliminary Reply. See Prelim. Reply 2–4. disclosed in the manner provided by section 112(a)”); see also New Railhead Mfg., L.L.C. v. Vermeer Mfg. Co., 298 F.3d 1290, 1294 (Fed. Cir. 2002) (“[T]o be afforded the priority date of the provisional application, . . . the written description of the provisional must adequately support the claims of the non-provisional application.”). Patent Owner argues that the ’688 provisional application supports claims 5, 6, 9, and 10 of the ’271 patent because they describe the method of controlling the pumps and thermal modulators to achieve selected temperatures upstream of the brewing chamber and creating a resulting solvent used to infuse a solute, creating an infused beverage. See Prelim. Sur-reply 3–4 (citing Prelim. Resp. 16–18, 35–37; Ex. 1012, 12–15). Patent Owner also refers to Figure 2 of the ’688 provisional application, which discloses the device that performs the method described in the application. See id. at 4–5. With one exception that we address immediately below, Petitioner does not contest these assertions or argue that the ’688 provisional application fails to disclose the subject matter claimed in claims 5, 6, 9, and 10 of the ’271 patent. See Pet. 18–20; Prelim. Reply 2–4. Based on our review of the record, the ’688 provisional application provides adequate written description support for the challenged claims of the ’271 patent.11 See Ex. 1012, 11–15 (describing Figure 2 of the ’688 provisional application and related methods), Fig. 2.” slip op. at 12
- Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityReference not prior artPrinted publication establishedDecided for patent owner
“only qualify as prior art under section 102(a)(1) because section 102(a)(2) does not apply to purely foreign patent publications like Buttiker. See 35 U.S.C. § 102(a)(2) (describing scope of prior art as including “a patent issued under section 151” (addressing issued U.S. patents) and “an application for patent published or deemed published under section 122(b)” (addressing published U.S. applications)); MPEP § 2152 (“The documents upon which a prior art rejection under 35 U.S.C. 102(a)(2) may be based are U.S. patent documents only.”).10 Under section 102(a)(1), Buttiker may be prior art if it “was patented [or] described in a printed publication . . . before the effective filing date of the claimed invention.” 35 U.S.C. § 102(a)(1). Buttiker published after the ’688 provisional application was filed, but before the other applications to which the ’271 patent claims priority were filed. See Ex. 1010, 1; Ex. 1001, code (60). Accordingly, whether the ’271 patent claims at issue here have adequate support in the ’688 provisional application determines whether Buttiker is prior art to those claims because Buttiker’s publication predates later applications to which the ’271 patent claims priority.” slip op. at 12
- Disclosure Requirements (§112) › Written description (Ariad)Written description adequateDecided for patent owner
“When claiming the benefit of priority to a provisional application, the provisional application must provide written description support for the claims in question. See 35 U.S.C. § 119(e) (referring to “an invention 10 Petitioner does not dispute Patent Owner’s arguments on this point in its Preliminary Reply. See Prelim. Reply 2–4. disclosed in the manner provided by section 112(a)”); see also New Railhead Mfg., L.L.C. v. Vermeer Mfg. Co., 298 F.3d 1290, 1294 (Fed. Cir. 2002) (“[T]o be afforded the priority date of the provisional application, . . . the written description of the provisional must adequately support the claims of the non-provisional application.”). Patent Owner argues that the ’688 provisional application supports claims 5, 6, 9, and 10 of the ’271 patent because they describe the method of controlling the pumps and thermal modulators to achieve selected temperatures upstream of the brewing chamber and creating a resulting solvent used to infuse a solute, creating an infused beverage. See Prelim. Sur-reply 3–4 (citing Prelim. Resp. 16–18, 35–37; Ex. 1012, 12–15). Patent Owner also refers to Figure 2 of the ’688 provisional application, which discloses the device that performs the method described in the application. See id. at 4–5. With one exception that we address immediately below, Petitioner does not contest these assertions or argue that the ’688 provisional application fails to disclose the subject matter claimed in claims 5, 6, 9, and 10 of the ’271 patent. See Pet. 18–20; Prelim. Reply 2–4. Based on our review of the record, the ’688 provisional application provides adequate written description support for the challenged claims of the ’271 patent.11 See Ex. 1012, 11–15 (describing Figure 2 of the ’688 provisional application and related methods), Fig. 2.” slip op. at 12
§ 102 anticipation§ 103 obviousness§ 112 disclosurePatents in suitUS 11,957,271 - Tanklogix, LLC v. Sitepro, Inc.Institution deniedPTAB · Oct 10, 2025 · IPR2025-00653 · APJ Bart A Gerstenblith · IPR · Institution
The Board denied institution on all claims because the Petition did not show a reasonable likelihood that any challenged claim was unpatentable over the asserted grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“An inter partes review may be instituted only if “the information presented in the petition . . . and any [preliminary] response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2024). For the reasons given below, on this record Petitioner has not established a reasonable likelihood that it would prevail in showing the unpatentability of any of the Challenged Claims. Accordingly, we do not institute an inter partes review.” slip op. at 2
- Skill levelSkill level patent owner adoptedDecided for patent owner
“The parties’ proposed levels of ordinary skill in the art are similar, although Patent Owner proposes two years of experience along with a bachelor’s degree whereas Petitioner proposes “significant” experience. Patent Owner also proposes an alternative with more extensive experience in lieu of a bachelor’s degree. Although we find Petitioner’s proposed qualifications acceptable, we adopt Patent Owner’s proposed qualifications for the purposes of this Decision because they offer a wider range of qualifications that nonetheless comport with the level of ordinary skill necessary to understand and implement the teachings of the ’504 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978). Our analysis and findings herein, however, do not turn on any differences in the parties’ proposed qualifications.” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Additionally, only terms that are in controversy need to be construed, and these need be construed only to the extent necessary to resolve the controversy. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). The parties assert that each claim term should be construed in accordance with its plain and ordinary meaning. Pet. 9; Prelim. Resp. 4 (citing Ex. 2009 ¶ 72); see Ex. 1002 ¶ 22 (opining the same). And, in the respective claim construction sections of their briefs, the parties do not propose any claim terms for express construction. We agree with the parties that no claim terms require express construction to resolve the controversy before us. See Realtime Data, 912 F.3d at 1375.” slip op. at 13
- Expert testimonyPetitioner expert discountedDecided for patent owner
“Ex. 1002 ¶ 47. As reflected above, Dr. Wooley’s testimony as to element [1.2] does not even assert that Cardamone discloses a tank, let alone one or more sensors disposed at a tank as recited in element [1.2]. Thus, Dr. Wooley’s testimony does not support Petitioner’s argument on this issue.” slip op. at 18
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,726,504 - Tanklogix, LLC v. Sitepro, Inc.Institution deniedPTAB · Oct 10, 2025 · IPR2025-00652 · APJ Bart A Gerstenblith · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–23 and 25–30 were unpatentable over the asserted grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsDenied
“presented in the petition . . . and any [preliminary] response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2024). For the reasons given below, on this record Petitioner has not established a reasonable likelihood that it would prevail in showing the unpatentability of any of the Challenged Claims. Accordingly, we do not institute an inter partes review.” slip op. at 2
- Skill levelSkill level patent owner adoptedDecided for patent owner
“The parties’ proposed levels of ordinary skill in the art are similar, although Patent Owner proposes two years of experience along with a bachelor’s degree whereas Petitioner proposes “significant” experience. Patent Owner also proposes an alternative with more extensive experience in lieu of a bachelor’s degree. Although we find Petitioner’s proposed qualifications acceptable, we adopt Patent Owner’s proposed qualifications for the purposes of this Decision because they offer a wider range of qualifications that nonetheless comport with the level of ordinary skill necessary to understand and implement the teachings of the ’403 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978). Our analysis and findings herein, however, do not turn on any differences in the parties’ proposed qualifications.” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“The parties assert that each claim term should be construed in accordance with its plain and ordinary meaning. Pet. 10; Prelim. Resp. 4 (citing Ex. 2009 ¶ 73); see Ex. 1002 ¶ 22 (opining the same). And, in the respective claim construction sections of their briefs, the parties do not propose any claim terms for express construction. We agree with the parties that no claim terms require express construction to resolve the controversy before us. See Realtime Data, 912 F.3d at 1375.” slip op. at 13
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“We agree with Patent Owner that the Petition fails to demonstrate that Kahn discloses element [1.2] because the evidence cited does not disclose a “first computer system being configured to provide remote control of the first pump or first valve” (i.e., a fluid-handling device). Kahn is directed to providing access to fluid sensing data and analyzing and providing visual information on that data, but Petitioner has not identified any disclosure of the capability to remotely control fluid-handling devices. See, e.g., Ex. 1005, code (54), 1:27–36, 2:50–3:2. More specifically, Kahn’s disclosures that Petitioner relies on for allegedly teaching remote control are deficient. We discuss each. First, Petitioner points to the following, “[f]or instance, as illustrated in FIG. 1C, a fluid control device such as a valve 15A is located on the input side of a sen[s]or unit 110.” Ex. 1005, 8:19–21, cited in Pet. 13. This portion of Kahn, however, does not disclose remote control. Second, Petitioner cites to the following: Finally, or in addition to, the communication unit 112B can include on-site alerts such as optical (indicator lights), audible alerts (e.g., alarm sounds), tactile (e.g., vibration of the unit) or can be interfaced to an appropriate control valve for simply shutting off the supply of fluid upon the detection of emergency events, for instance. Pet. 13 (citing Ex. 1005, 10:62–67). We agree with Patent Owner that this portion of Kahn teaches on-site alerts and local control of the fluid-handling device. See Prelim. Resp. 7. This portion of Kahn does not disclose remote control.” slip op. at 18
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,294,403 - Tanklogix, LLC v. Sitepro, Inc.Institution deniedPTAB · Oct 10, 2025 · IPR2025-00651 · APJ Bart A Gerstenblith · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–3, 6, 7, and 9–20 were unpatentable over any asserted ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsDenied
“presented in the petition . . . and any [preliminary] response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2024). For the reasons given below, on this record Petitioner has not established a reasonable likelihood that it would prevail in showing the unpatentability of any of the Challenged Claims. Accordingly, we do not institute an inter partes review.” slip op. at 2
- Skill levelSkill level patent owner adoptedDecided for patent owner
“The parties’ proposed levels of ordinary skill in the art are similar, although Patent Owner proposes two years of experience along with a bachelor’s degree whereas Petitioner proposes “significant” experience. Patent Owner also proposes an alternative with more extensive experience in lieu of a bachelor’s degree. Although we find Petitioner’s proposed qualifications acceptable, we adopt Patent Owner’s proposed qualifications for the purposes of this Decision because they offer a wider range of qualifications that nonetheless comport with the level of ordinary skill necessary to understand and implement the teachings of the ’680 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978). Our analysis and findings herein, however, do not turn on any differences in the parties’ proposed qualifications.” slip op. at 11
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“target value” is part of a command that is sent from a computing device to a server and then to a controller. The controller then receives a measurement of the fluid by a sensor and determines whether the measurement satisfies the “target value.” If the measurement does not satisfy the “target value,” further operations are undertaken. The recited operation sequence makes clear that the plain and ordinary meaning of “target value” is not as Dr. Wooley opines because the particular operating condition that a device is in at a particular time is represented by the measurement taken by the sensor, 11 Some claim language less relevant to construing “target value” was omitted for ease of reference. which the controller then uses to determine whether the measurement satisfies the “target value.” Additionally, claim 1 recites that the “target value” is sent as part of a command to the controller. The “target value” is not sent to the controller from the sensor, as might be expected if the plain and ordinary meaning of “target value” were as Dr. Wooley opines. Petitioner and Dr. Wooley’s construction would also result in “target value” meaning effectively the same thing as the measurement of the fluid by the sensor, a concept that is separately recited in claim 1 and to which the “target value” is compared. The Specification of the ’680 patent does not support Petitioner’s understanding of the plain and ordinary meaning of “target value.” Although the Specification does not recite “target value,” it recites “target state,” and describes “target state” sufficiently to understand the plain and ordinary meaning of “target” as used in “target value” and “target state.” In particular, the ’680 patent explains that “[i]n some embodiments, the process 104 includes receiving, via a network interface, from a remote user device, (e.g., via a command-center server) a command to change a state of a fluid-handling device to a target state.” Ex. 1001, 11:48–51. This portion reflects that the command is seeking to change a state of a fluid-handling device to a target state. In other words, the “target value” or “target state” is not generally “the particular operating condition that a device is in at a particular time”; rather, it is a value or state that the fluid-handling device is desired to be in, as Patent Owner and Dr. Durham explain. Additionally, just as claim 1 recites a directional component for the “target value” to be sent to the controller in a command, so too does the Specification describe a “target state” as being sent in a command from a remote user device. Thus, the Specification clearly supports the plain and ordinary meaning proposed by Patent Owner and Dr. Durham and not the plain and ordinary meaning proposed by Petitioner and Dr. Wooley. slip op. at 14
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“time-stamped process data, report exception therein to the remote host, and extract and transmit time-stamped process data to the remote host.” Ex. 1005, Abst. (emphases added). Almadi explains that its remote field systems must include a plurality of controller units “to issue commands to, and gather and process data from a plurality of field devices, including remote systems and instruments, . . . [and] a database server for the storage of process data retrieved from the remote subsystems and instruments.” Id. at 2:22–30 (emphases added). Based on these disclosures, we agree with Patent Owner that Petitioner has not established that Almadi discloses element [1.4]. Specifically, the teachings from Almadi identified by Petitioner refer to process data, which is data retrieved from the remote subsystems/field devices. Thus, we understand that Almadi’s teaching—of using an Ethernet switch to transmit “process data”—describes transmitting data from the remote subsystems/field devices. See Ex. 1005, 3:13–17, cited in Pet. 15. But claim 1 and particularly element [1.4], recites “sending, with the server, the target value to the network address [which identifies a controller of the fluid-handling device13] via the network,” which is different than sending process data from the field devices to the remote host or database server for storage.” slip op. at 19
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,175,680 - Tanklogix, LLC v. SiteproInstitution deniedPTAB · Oct 10, 2025 · IPR2025-00650 · APJ Sheila F Mcshane · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 18–32 and 34 were unpatentable over Kahn or Kahn and Gutierrez.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2024). Upon consideration of the Petition, the Preliminary Response, and the evidence of record, we determine that Petitioner has not established a reasonable likelihood of prevailing with respect to the unpatentability of at least one claim of the ’871 patent. Accordingly, for the reasons that follow, we decline to institute an inter partes review of claims 18–32 and 34 of the ’871 patent.” slip op. at 2
- Skill levelSkill level patent owner adoptedDecided for patent owner
“The respective proposed levels of qualifications for a person of ordinary skill in the art are similar, with Patent Owner proposing two years of experience compared to Petitioner proposing significant experience with remotely controlling fluid-handling devices, like SCADA systems. Patent Owner also proposes more extensive experience in lieu of educational experience. While we find Petitioner’s proposed qualifications to be acceptable, we adopt Patent Owner’s proposed qualifications for the purposes of this Decision because they offer a wider range of qualifications that nonetheless comport with the level of skill necessary to understand and implement the teachings of the ’871 patent and the asserted prior art. Our analysis and findings herein, however, do not turn on any differences in the qualifications adopted.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“We determine that we need not expressly construe any claim terms to resolve the parties’ disputes on the current record. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 10
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“actuators and the remote control of fluid handling devices, including the receipt with the user-interface module of “a user command to actuate an actuator via a presented control interface” (limitation [18.7]) and “account authorized to send commands to remotely control fluid handling devices” (limitation [18.11]). We agree with Patent Owner that the Petition fails to demonstrate that Kahn discloses or teaches these limitations because the evidence does not provide support that there is remote control of fluid handling devices or the use of a user command on a control interface to send a command to a fluid handling device, for instance. Kahn is directed to providing access to fluid sensing data and analyzing and providing visual information on that data, but we do not discern that it teaches or discloses the capability to remotely control fluid handling devices. See, e.g., Ex. 1005, code (54), 1:27–36, 2:50–3:2. More specifically, the Kahn disclosures that Petitioner repeatedly relies upon for allegedly teaching this control are deficient. See Ex. 1005, 10:62–67, 14:35– 15:2, 15:62–16:32; see also Pet. 12–14, 16–18. Kahn discloses that “the communication unit 112B can include on-site alerts such as optical (indicator lights), audible alerts (e.g., alarm sounds), tactile (e.g., vibration of the unit) or can be interfaced to an appropriate control valve for simply shutting off the supply of fluid upon the detection of emergency events, for instance.” Ex. 1005, 10:62–67. Communication unit 112B is part of the local “sensor unit,” wherein the detection conditions determined by the sensor are communicated to remote devices by communication unit 112B. See id. at 3:31–33, 5:62–6:2, 6:27–35, 7:33–37, 13:7–12, Figs. 1A–1C. Kahn discloses that the sensor units, which include communication units 112B, can be located near shut-off valves and can communicate with distant locations. See id. at 11:1–13. There are no disclosures, however, in the above passages that there is remote control of fluid handling devices, that there is a user command on a control interface that actuates an actuator, or that there is a command sent to the facility actuators via a network connection, as required in limitations [18.5]–[18.7] and [18.9]–[18.12], respectively. Rather, the disclosure indicates that the communication unit 112B includes on-site alerts and that the local (non-remote) communication unit 112B can be interfaced with the control valve.” slip op. at 18
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,488,871 - Intel Corporation / Lenovo (United States) Inc. et al. v. Collision Communications, Inc.Institution deniedPTAB · May 28, 2025 · IPR2025-00301 · APJ Bart A Gerstenblith · IPR · Institution
The Board denied institution of review for claims 1–11, 16, and 21 under § 314(a), finding the Fintiv factors favored discretionary denial, and denied joinder.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivInstitution denied
“2026. This date is nearly five months prior to the date on which the final written decision would be due if trial were instituted in this proceeding. And, even if we assume Petitioner’s alleged February–March 2026 trial date, this date too is several months prior to the projected final written decision deadline. As such, it is unlikely that a final written decision in this proceeding would issue before trial in the district court, unless the trial was delayed or rescheduled for a later time. Thus, we find this factor weighs in favor of exercising our discretion to deny institution. See ARM Ltd. v. Daedalus Prime LLC, IPR2025-00207, Paper 10 at 2 (May 16, 2025) (Before the Office of the Under Secretary of Commerce for Intellectual Property and Director of the United States Patent and Trademark Office) (exercising discretion to deny institution with the same relative timing between district court trial and final written decision deadline).” slip op. at 13
- PTAB / AIA Trials › Motions to amend / substitute claimsNot reached
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, deniedDenied
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied discretionary otherInstitution denied
“presented in the petition . . . and any [preliminary] response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Institution of inter partes review, however, is discretionary. See Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1367 (Fed. Cir. 2016) (“[T]he PTO is permitted, but never compelled, to institute an IPR proceeding.”). For the reasons discussed below, we exercise discretion pursuant to 35 U.S.C. § 314(a) not to institute inter partes review. Additionally, for the same reasons and because institution was denied in IPR2024-01248, we deny Petitioner’s Motion for Joinder. See 35 U.S.C. § 315(c) (“[T]he Director . . . may join as a party . . . any person who properly files a petition under section 311 that the Director . . . determines warrants the institution of an inter partes review under section 314.”).” slip op. at 3
Discretionary denialPatents in suitUS 9,814,071 - PTAB · Apr 25, 2025 · IPR2024-01492 · APJ Richard H Marschall · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–9 were unpatentable over the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Based on the foregoing, we conclude that Petitioner fails to establish that Coccia discloses “a resulting solvent valve” as required by claim 1 and as alleged in the Petition. See Pet. 35–42. 4. Conclusion Based on our review of the current record, Petitioner does not establish a reasonable likelihood of proving that claim 1 would have been obvious based on Coccia and Anson. The remaining challenged claims, claims 2–9, all ultimately depend from claim 1. See Ex. 1001, 18:42–19:48. Petitioner’s obviousness challenges to claims 2–9 build on its analysis for claim 1. See Pet. 10, 43–70, 79–86. Accordingly, for the same reasons we discuss above in the context of claim 1, Petitioner has not shown a reasonable likelihood in prevailing on its challenge to any of the dependent claims.” slip op. at 22
- Skill levelSkill level petitioner adoptedDecided for petitioner
“we view the prior art and the claimed invention. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). The person of ordinary skill in the art is a hypothetical person presumed to have known the relevant art at the time of the invention. In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995). In determining the level of ordinary skill in the art, we may consider certain factors, including: “(1) the educational level of the inventor; (2) type of problems encountered in the art; (3) prior art solutions to those problems; (4) rapidity with which innovations are made; (5) sophistication of the technology; and (6) educational level of active workers in the field.” Best Med. Int’l, Inc. v. Elekta Inc., 46 F.4th 1346, 1353 (Fed. Cir. 2022) (quoting Daiichi Sankyo Co. v. Apotex, Inc., 501 F.3d 1254, 1256 (Fed. Cir. 2007)). “The patent’s purpose can also be informative.” Id.” slip op. at 8
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“cites the specification for support, but that argument largely misses the point and elides the claim requirements tied to the resulting solvent valve. See Pet. 35; Prelim. Reply 4. Patent Owner agrees with the general proposition that “a resulting solvent valve” means one or more resulting solvent valves. See Prelim. Resp. 10 (acknowledging that “two duplicative resulting solvent valves having the three positions” could each qualify as “a resulting valve”); Prelim. Sur-reply 4–5 (“Had Petitioner cited to multiple ‘resulting solvent’ valves that each” meet the claim requirements, “Patent Owner would not have raised an issue.”). The general statement that “a” or “an” means “one or more than one,” however, does not support Petitioner’s argument that the limitation broadly covers systems where no single resulting valve meets the three claimed valve positions. The dispute does not turn on whether “a” means “one or more than one”; the dispute, rather, concerns whether the claim allows for multiple valves to meet the three claimed states or whether a single valve must meet those claim requirements.” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
“Patent Owner that Petitioner fails to establish that Coccia discloses the claimed “resulting solvent valve.” Importantly, Petitioner premises its argument for this limitation on a claim construction that we rejected in our analysis above. Because we determine that the claim requires at least one resulting valve to meet the three claimed states identified in the claim, Petitioner may not rely on a combination of Coccia’s valves 26 and 36 to provide the three claimed states, as Petitioner does throughout its analysis. See Pet. 35–42; Prelim. Reply 4. As to Petitioner’s alternative argument that Anson discloses the claimed resulting solvent valve, we decline to consider the argument because it was not included in the Petition and was made for the first time in Petitioner’s Preliminary Reply. See Pet. 35–42; Prelim. Reply 5. Petitioner relied on Anson in the Petition as an alternative reason to find that it would have been obvious to place Coccia’s valve 36 in the claimed location (downstream of the conduit joint and upstream of the brewing chamber), not to meet all of the limitations associated with the resulting solvent valve. See Pet. 38–39. Moreover, Petitioner’s limited argument and evidence in the Preliminary Reply lacks adequate development and fails to persuade us that Anson’s valve 28 performs all of the “claimed functions” associated with the resulting solvent valve, including the two “active” states that the Petition addresses with reliance on Coccia alone. See Pet. 40–42; Prelim. Reply 5. Based on the foregoing, we conclude that Petitioner fails to establish that Coccia discloses “a resulting solvent valve” as required by claim 1 and as alleged in the Petition. See Pet. 35–42. 4. Conclusion Based on our review of the current record, Petitioner does not establish a reasonable likelihood of proving that claim 1 would have been obvious based on Coccia and Anson. The remaining challenged claims, claims 2–9, all ultimately depend from claim 1. See Ex. 1001, 18:42–19:48. Petitioner’s obviousness challenges to claims 2–9 build on its analysis for claim 1. See Pet. 10, 43–70, 79–86. Accordingly, for the same reasons we discuss above in the context of claim 1, Petitioner has not shown a reasonable likelihood in prevailing on its challenge to any of the dependent claims.” slip op. at 21
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,772,456 - PTAB · Apr 25, 2025 · IPR2024-01483 · APJ Richard H Marschall · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–12 would be unpatentable over the asserted obviousness combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the challenged claims in the petition.” For the reasons that follow, we determine that Petitioner has not demonstrated a reasonable likelihood of prevailing with respect to any of the challenges in the Petition. Accordingly, we do not institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person having ordinary skill in the art at the time of the invention “would have had at least the following (or equivalents): a B.S. degree in mechanical engineering with at least five years of experience in product design; or an M.S. degree in mechanical engineering with at least two years of experience in product design.” Pet. 17 (citing Ex. 1002, 13). Patent Owner “submits a person of ordinary skill in the art (‘POSITA’) would be a mechanical or materials engineer, or other similar degree, having at least two to three years of personal experience in designing or development of espresso machines.” Prelim. Resp. 8. In the alternative, Patent Owner states that “because Petitioner’s definition is so close to that of Patent Owner’s definition, that no express finding is necessary to find Petitioner has not met its burden to show with particularity that claim 1 is unpatentable.” Id. We find Petitioner’s definition to be consistent with the problems and solutions disclosed in the ’524 patent and prior art of record, and adopt it as our own for purposes of this Decision. See, e.g., GPAC, 57 F.3d at 1579 (approving the determination of the level of ordinary skill in the art by appeal to the references of record). The outcome of this case would remain the same if we applied Patent Owner’s similar proposal.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“standard set forth in Phillips v. AWH Corp., 415 F.3d 1303 (Fed. Cir. 2005) (en banc). Under that standard, we give the words of a claim their plain and ordinary meaning as would have been understood by one skilled in the art at the time of the invention and in the context of the entire patent disclosure. Id. at 1312–13. Only terms in controversy need be construed, and only to the extent necessary to resolve the controversy. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017). The parties propose constructions for several claim terms. For example, Petitioner contends that we should construe “conduit,” “coupled,” “another solvent,” and “dynamically modulate.” See Pet. 13–17. Patent Owner reserves its right to challenge Petitioner’s constructions and proposes its own constructions for “another solvent” and “communicatively coupled.” Prelim. Resp. 9–11. We determine that we need not construe any of these additional terms to determine whether Petitioner met its burden as to any of its challenges in the Petition.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“that any of them disclose an electronic controller coupled to two pumps and a thermal modulator, such as a heater. Petitioner suggests that Lai’s controller controls two “pump(s),” but Lai appears to describe a single pump 138, and Petitioner fails to point to any disclosure or suggestion in Lai that its system employs more than one pump. See Pet. 38–39 (citing Ex. 1002, 41–42); Ex. 1007 ¶ 98, Fig. 60. Petitioner does not directly assert that Santi discloses a controller connected to two pumps, and it too, like Lai, appears to only disclose a single pump. See Pet. 39; Ex. 1005 ¶ 64, Fig. 1. Petitioner correctly notes that Majer discloses controller 9 connected to two pumps, but we agree with Patent Owner that only one of those pumps meets the requirements of the claimed pumps, which are both connected to conduits that eventually lead to the brewing chamber. See Pet. 40; Prelim. Resp. 28; Ex. 1008, 9:11–12 (describing circuit C2 containing pump 4bis as not including any “brewing means”). In addition, Petitioner does not allege, and Majer does not appear to disclose, a controller coupled to Majer’s heating elements. See Pet. 40. Based on the foregoing, none of the prior art Petitioner relies on discloses an electronic controller that controls both claimed pumps and a thermal modulator. Despite these deficiencies, Petitioner summarily concludes that one of ordinary skill in the art “would have recognized that it would be obvious to combine Startz’s machine with the electronic controller of any of Lai, Santi, and/or Majer, and that such electronic controller would be communicatively coupled to both the thermal modulator and the pumps.” Pet. 40 (citing Ex. 1002, 43). The Petition provides no additional rationale or argument in support of this conclusion, and the cited declarant testimony provides no further analysis. See id.; Ex. 1002, 43. Given the lack of any teaching of a controller coupled to two pumps and a thermal modulator, it was incumbent upon Petitioner to provide some reason why one of ordinary skill in the art would have been motivated to combine the references in a manner that meets the limitation.14 Because the Petition lacks any such statement or rationale, we find Petitioner’s obviousness argument and evidence lacking in this critical respect.” slip op. at 21
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,576,524 - Babybjörn AB v. The Ergo Baby Carrier, Inc.Institution deniedPTAB · Apr 22, 2025 · IPR2025-00111 · APJ Eric C Jeschke · IPR · Institution
The Board denied institution of IPR on all challenged claims under § 314(a), finding the reasons offered for a second parallel petition unpersuasive.
RulingsInstitution decision- Parallel petitionsInstitution denied discretionary otherDenied
“petitioner files two or more petitions challenging the same patent, we consider guidance in the Consolidated Trial Practice Guide, which provides that “one petition should be sufficient to challenge the claims of a patent in most situations” and that “multiple petitions by a petitioner are not necessary in the vast majority of cases.” Trial Practice Guide 59 (Nov. 2019), available at https://www.uspto.gov/TrialPracticeGuideConsolidated (“TPG”). In such circumstances, a petitioner should provide: (1) a ranking of the petitions in the order in which it wishes the Board to consider the merits, if the Board uses its discretion to institute any of the petitions, and (2) a succinct explanation of the differences between the petitions, why the issues addressed by the differences are material, and why the Board should exercise its discretion to institute additional petitions if it identifies one petition that satisfies petitioner’s burden under 35 U.S.C. § 314(a). TPG 59–60. The Trial Practice Guide provides that “the Board recognizes that there may be circumstances in which more than one petition may be necessary” and that “two petitions by a petitioner may be needed, although this should be rare.” Id. at 59.” slip op. at 9
- Novelty / Anticipation (§102) › Prior-art status of a reference › Patents / published applications (effective date, provisional support)Reference is prior artDecided for petitioner
“We disagree with Petitioner that the still-open outcome of Lynk Labs in any way impacts the availability of Lundh in either the 110 IPR or this proceeding.10 Critically, in Lynk Labs, the Federal Circuit examined the prior art date of a U.S. patent application publication under pre-AIA § 102(e)(1) because the challenged patent in that case had a priority date in February 2004—well before the 2013 effective date of the AIA’s revisions to §§ 102, 103—such that the pre-AIA versions of § 102 determined the” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Decided for patent owner
“We are not persuaded that this assertion supports the argument for a second petition. As argued by Patent Owner, Petitioner’s alleged need is undermined by the distribution of its arguments across the 110 IPR and this proceeding. As discussed above, for the “at least one thigh support adjusters” in the 110 IPR, Petitioner relies on one prior art structure from the first category and two prior art structures from the second category; and for the “at least one thigh support adjusters” in this proceeding, Petitioner relies on two prior art structures from the first category and one prior art structure from the second category. Id. In other words, as stated by Patent Owner, “Petitioner was able to address both its constructions in both of its Petitions.” Resp. 3–411; see also Medacta USA, Inc. v. RSB Spine, LLC, IPR2020-00275, Paper 22 at 10–11 (PTAB May 22, 2020) (denying institution of a second-ranked parallel petition challenging the same claims of the same patent and stating, “Because Petitioner was able to present an alternative challenge contingent upon [the] alternative claim construction” in the first-ranked petition, “we fail to see how uncertainty regarding claim construction justifies two petitions.”). In contrast, in the SolarEdge decision cited by Petitioner, the first-ranked petition presented one approach as to the prior art and the second-ranked petition was permitted because it presented a different approach, such that the two petitions “do not overlap in any meaningful way.” SolarEdge v. SMA Solar Techs., IPR2019-01224, Paper 10 at 10 (PTAB Jan. 23, 2020), cited at Expl. 4. Turning to the discovery issue, we determine that the alleged failure of Patent Owner to answer adequately an interrogatory in the Texas Litigation seeking information on “all corresponding disclosures and written 11 Petitioner highlights the two categories of prior art structures identified across the six grounds in these two proceedings rather than the two different constructions for “at least one thigh support adjuster” proposed. Looking at the distributions of the constructions presented, however, the same reasoning above applies as Petitioner relied on each construction at least twice to address the “one thigh support adjuster” in each proceeding. See 110 Petition 27 (relying on both constructions for Ground 1), 53–57 (relying on only a § 112(f) construction for Ground 2), 86–90 (relying on both constructions for Ground 3); Pet. 29–34 (relying on only a § 112(f) construction for Ground 4), 61–63 (relying on both constructions for Ground 5), 88–90 (relying on both constructions for Ground 6). description support for the ‘at least one thigh support adjuster’ limitation” (Ex. 1029 at 5) does not warrant a second petition here. The challenged patent was clearly available to Petitioner, and Petitioner was—even with Patent Owner’s non-substantive answer to the interrogatory (id. at 6)—able to propose a construction of “at least one thigh support adjuster” under § 112(f). See Pet. 7–12. For these reasons, the two different constructions presented do not warrant a second petition in this proceeding.” slip op. at 12
Claim construction§ 102 anticipationDiscretionary denialPatents in suitUS 11,786,055 - Babybjörn AB v. The Ergo Baby Carrier, Inc.Institution deniedPTAB · Apr 22, 2025 · IPR2025-00110 · APJ Eric C Jeschke · IPR · Institution
The Board denied institution because the petition did not show a reasonable likelihood of proving any challenged claim unpatentable over the asserted prior art.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2024) (“The Board institutes the trial on behalf of the Director.”). Inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314. Upon consideration of the evidence and arguments in the record, for the reasons below, we determine that the information presented does not show a reasonable likelihood that Petitioner would prevail with respect to at least one of the challenged claims. We thus deny institution of inter partes review. See 37 C.F.R. § 42.108(b) (“At any time prior to a decision on institution of inter partes review, the Board may deny all grounds for unpatentability for all of the challenged claims. Denial of all grounds is a Board decision not to institute inter partes review.”).” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“person having ordinary skill in the art “would have had at least a four-year degree in a design-based field, which may include fashion design, industrial design, mechanical engineering, or another technical field, or equivalent experience, and familiarity working with child products and/or adjustable products.” Pet. 6–7 (citing Smith Decl. ¶¶ 32–38). Patent Owner does not address Petitioner’s proposed definition, which appears consistent with the record in this proceeding, including the prior art. See GPAC Inc., 57 F.3d at 1579. Furthermore, Patent Owner does not argue that Petitioner’s proposal for the level of ordinary skill leads to an improper understanding of how a skilled artisan would understand either the challenged patent or the prior art. For purposes of this Decision, we adopt the definition of the level of ordinary skill in the art proposed by Petitioner.” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Based on the current record, we need not construe explicitly the term “at least one thigh support adjuster” because doing so would not change the outcome of the analysis below. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). More particularly, and as discussed below, Petitioner does not show sufficiently how the prior art teaches the structure identified as corresponding to the alleged claimed function. Further, because we deny on the merits (as discussed below), we do not address Patent Owner’s alternative argument that we should deny institution because “Petitioner fails to construe th[is] limitation and otherwise argues for an advisory opinion from the Board on indefiniteness.” Prelim. Resp. 1; see id. at 1–6 (entire argument). 2. “defined by” Limitations 1j and 11l each recite “a first setting, a second setting, and a third setting defined by the adjustable child carrier.” Ex. 1001, 17:38–39 (emphasis added), 19:43–44 (emphasis added). Limitation 6k recites “a first position, a second position, and a third position defined by the adjustable child carrier.” Id. at 18:36–37 (emphasis added). Patent Owner proposes a construction for “defined by” in these limitations. See Prelim. Resp. 12–15. At this stage of the proceeding and based on the current record, we need not construe explicitly “defined by”” slip op. at 11
- Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication not establishedNot shown unpatentable
“Public accessibility “has been called the touchstone in determining whether a reference constitutes a ‘printed publication’ . . . .” Blue Calypso, LLC v. Groupon, Inc., 815 F.3d 1331, 1348 (Fed. Cir. 2016) (quoting In re Hall, 781 F.2d 897, 898–99 (Fed. Cir. 1986)). In Hulu, the Precedential Opinion Panel (“POP”) rejected a petitioner’s argument that a reference necessarily meets “the reasonable likelihood standard for institution where the reference bears conventional markers of publication, such as a copyright date, edition identifiers, publication by a commercial publisher, and the assignment of an ISBN number.” Hulu, Paper 29 at 17. The POP stated: “We do not hold that any particular indicia per se is sufficient at the institution stage. Rather, the indicia on the face of a reference, such as printed dates and stamps, are considered as part of the totality of the evidence.” Id. at 17–18 (citing Nobel Biocare Servs. AG v. Instradent USA, Inc., 903 F.3d 1365, 1377 (Fed. Cir. 2018)). Here, Petitioner provides no citation, no discussion, and no support for its assertion that the Synergy Manual was “published” in “2007.” See Pet. 2. Instead, we are left to assume that Petitioner relies on the text “© BabyBjörn AB, Stockholm, 2007” at the bottom of page 6 of the Synergy Manual. More to the point, Petitioner does not discuss in the Petition any evidence supporting the implicit position that the Synergy Manual was publicly accessible prior to the critical date of the claimed invention.” slip op. at 13
Claim construction§ 102 anticipation§ 103 obviousnesscites PhillipsPatents in suitUS 11,786,055
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.