- Micron Technology, Inc. v. Yangtze Memory Technologies Company, Ltd.Institution deniedPTAB · Aug 12, 2025 · IPR2025-00294 · APJ Kimberly Mcgraw · IPR · Institution
The Board denied institution because Patent Owner statutorily disclaimed all challenged claims: claims 6, 7, 10, and 20.
RulingsInstitution decision- Adverse judgmentAdverse judgmentDenied
“A disclaimer is “recorded” pursuant to 35 U.S.C. § 253(a) on the date that the Office receives a disclaimer meeting the above-listed requirements of 37 C.F.R. § 1.321(a) – no further action is required in the Office for a disclaimer to be “recorded.” Vectra Fitness, Inc. v. TNWK Corp., 162 F.3d 1379, 1382 (Fed. Cir. 1998).” slip op. at 3
NonePatents in suitUS 10,886,291 - Micron Technology, Inc. v. Yangtze Memory Technologies Co., Ltd.Institution deniedPTAB · Aug 8, 2025 · IPR2025-00244 · APJ Kimberly Mcgraw · IPR · Institution
The Board denied institution because the petition did not sufficiently show that Costa disclosed or suggested claim 11.H’s required arrangement, and the dependent claims did not cure that deficiency.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“In view of these deficiencies, the Petition fails to identify the proposed grounds for review with particularity as required by 35 U.S.C. § 312(a)(3) with respect to the limitations of independent claim [11.H]. Petitioner presents no arguments or evidence with respect to the dependent claims challenged under this ground that would remedy the defects noted above with respect to independent claim 11. See generally Pet. Thus, Petitioner has failed to demonstrate a reasonable likelihood that the subject matter of claims 11, 12, or 14–19 would have been obvious over Costa.” slip op. at 23
- BurdenDenied
“3. Analysis A petition is required to identify “with particularity[ ] the grounds on which the challenge to each claim is based, and the evidence that supports the grounds for the challenge.” 35 U.S.C. § 312(a)(3). The “petition . . . must include . . . [a] full statement of the reasons for the relief requested, including a detailed explanation of the significance of the evidence”). 37 C.F.R. § 42.22(a)(2). Our rules require that a petition include fully developed arguments. See 37 C.F.R. § 42.22(a)(2) (the “petition . . . must include . . . [a] full statement of the reasons for the relief requested, including a detailed explanation of the significance of the evidence”). The petition must include both an adequate explanation of how the claims should be construed as well as how the construed claims are unpatentable over the asserted prior art. 37 C.F.R. § 42.104(b)(3), (b)(4). Additionally, the “petition must specify where each element of the claim is found in the prior art.” 37 C.F.R. § 42.104(b)(4). A petition should also “explain why a person of ordinary skill in the art would have combined elements from specific references in the way the claimed invention does.” ActiveVideo Networks, Inc. v. Verizon Comm'ns, Inc., 694 F.3d 1312, 1328 (Fed. Cir. 2012). Thus, based on our rules, we only consider fully developed arguments set forth in the petition.” slip op. at 16
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITANot reached
“arguments. See, e.g., id. at 34–35 (arguing that “on” does not require overlap in the Z direction but “includes both objects that are merely touching (in any dimension) and objects that are in proximity to each other but not touching” (citing Ex. 1078, 1; Ex. 1001, 8:3–12)); see also id. at 36–38 (arguing that if “on” is construed to mean “directly on or on with an intermediate feature or layer therebetween,” then Costa’s second stacked layer 232, 242 and third channel structure (173) are “directly on” each other, because their edges are directly touching each other). The Petition, however, does not clearly present any of the claim construction arguments set forth in the Opposition Brief. See Paper 22 (not clearly identifying where the Petition provides the proposed claim construction); see generally Pet.; see also Pet. 33, 43, 56 (arguing “on” does not require “directly on” and permits intermediate layers but not presenting any of the other claim construction arguments set forth in the Opposition Brief). Nor did the Petition provide any particularized argument as to how Costa discloses or suggests a second stacked layer disposed on the third channel structure applying any of the claim constructions proposed in the Opposition Brief. See generally Pet. (presenting no argument that Costa’s second stacked layer 232, 242 is “on” semiconduction portion layer 173 (the asserted third channel structure) because they touch each other as shown above in Petitioner’s annotation of Costa Figure 21A). We will not consider any arguments not sufficiently set forth in the Petition. See 37 C.F.R. § 42.104(b)(3) (“the petition must set forth . . . [h]ow the challenged claim is to be construed”); 37 C.F.R. § 42.104(b)(4) (“the petition must set forth . . . [h]ow the construed claim is unpatentable”).” slip op. at 19
- Parallel petitionsNot reached
“Because we determine that Petitioner did not show a reasonable likelihood that it would prevail on the merits, we do not address Patent Owner’s parallel petitions argument.” slip op. at 23
Claim constructionDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,886,291 - Micron Technology, Inc. v. Yangtze Memory Technologies Co., Ltd.Institution deniedPTAB · Aug 8, 2025 · IPR2025-00245 · APJ Michael T Cygan · IPR · Institution
Institution was denied because Petitioner did not show a reasonable likelihood that claims 11, 13, and 15–17 would have been obvious over Costa or Costa and Oh.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“§ 42.4(a), we may only institute an inter partes review when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a); see also 37 C.F.R. § 42.108(c). Based upon our review of the present record, Petitioner has not sufficiently shown a reasonable likelihood it will prevail with respect to at least one of the challenged claims. Accordingly, we do not institute inter partes review.” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner states that none of the claims require express construction and the claims should receive their plain and ordinary meaning. Pet. 23. Patent Owner argues that no claim construction is necessary for the institution determination, and that the Petition “still fails if the claim term ‘on’ receives its plain and ordinary meaning -- e.g., physically in contact with or directly on top of with intervening objects therebetween.” Prelim. Resp. 20 (citing Ex. 2006 ¶ 66). Although Patent Owner argues that Petitioner has construed “on” as including indirectly on; i.e., where there is no physical contact, the Petition addressed now-disclaimed claim 18, and the Petition does not advance any construction for the remaining claims. See id. at 16–17 (citing Pet. 92; Ex. 1003 ¶ 258). Consequently, we determine that no construction is required to resolve the issues for institution.” slip op. at 7
- Skill levelSkill level petitioner adoptedOther
“we consider the level of ordinary skill at the time of filing. 35 U.S.C. § 103; see also Graham v. John Deere Co., 383 U.S. 1, 17 (1966) (discussing pre- AIA obviousness). Petitioner contends that a person of ordinary skill in the art (“POSITA”) would have had “a bachelor’s degree in electrical engineering or a similar discipline, along with 2–3 years of professional experience working with (e.g., researching, designing, or teaching) monolithic 3D structures and NAND memory devices, or an equivalent level of skill, knowledge, and experience (e.g., an advanced degree may replace 1 The Leahy-Smith America Invents Act, Pub. L. No. 112-29, 125 Stat. 284 (2011) (“AIA”), amended 35 U.S.C. § 103. The earliest claimed priority date for the ’241 patent is after the effective date of the applicable AIA amendment. See Ex. 1001, (63). Thus, we refer to the AIA version of 35 U.S.C. § 103. 2 Costa, US 2018/001282771 (filed Feb. 28, 2017, published June 28, 2018) (Ex. 1005, “Costa”). 3 Oh, US 2017/0154892 A1 (filed June 10, 2016, published June 1, 2017) (Ex. 1006, “Oh”). some of the professional experience). Pet. 23–24. Petitioner also asserts that a POSITA “would have been aware of and generally knowledgeable about 3D NAND’s structure, how it is manufactured, and its component parts.” Id. (citing Ex. 1003 ¶¶ 36–40). Patent Owner does not take a position on the level of ordinary skill in the art. Prelim. Resp. 11; see also Ex. 2006 ¶ 34 (applying Petitioner’s definition of a POSITA to the opinions set forth in the declaration but reserving the right to opine to an alternative level of a POSITA). At this stage of the proceeding, we adopt Petitioner’s definition of a POSITA as it appears consistent with the level of ordinary skill in the art that is reflected by the prior art of record.” slip op. at 6
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“We agree with Patent Owner that the Petition fails to sufficiently show that Costa teaches a “second stacked layer disposed on the third channel structure” as required by apparatus claim element [11.E]. The Petition asserts that Costa’s second alternating stack 232, 242 is formed “on the top surface of joint-level material layers.” Pet. 64. However, Costa refers to the term “joint-level material layers” as representing layers 175–177, not the asserted third channel structure 173. Ex. 1005 ¶¶ 166, 178, 184–85; see Ex. 2006 ¶ 77. Thus, under Petitioner’s characterization, which is consistent with Costa, Costa’s second alternating stack is not formed on the third channel structure, but instead, “on the top surface of the joint level material layers” that surround the third channel structure. Because Petitioner has not explained how a second alternating stack on the surface of the joint material layers teaches a second alternating stack disposed on the third channel structure, Petitioner has not met its obviousness burden for limitation [11.E].” slip op. at 11
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,482,532 - Micron Technology, Inc. v. Yangtze Memory Technologies Company, Ltd.Institution deniedPTAB · Jun 4, 2025 · IPR2025-00119 · APJ Michael T Cygan · IPR · Institution
The Board denied institution of IPR on claims 2–4, 7–15, 17, 18, and 20 under § 314(a), finding a second petition unnecessary because its issues overlapped materially with the prior petition.
RulingsInstitution decision- Other 314aInstitution denied discretionary otherInstitution denied
“The issue of multiple petitions resolves against Petitioner because Petitioner, not Patent Owner, bears the burden to show that an additional petition is “necessary.” See Consolidated Trial Practice Guide at 59. Institution of a second petition may be avoided where differences between the issues in two petitions are “not material or in dispute.” Id. at 60–61. In view of the overlap of assertions that are at issue in the prior-instituted trial and in the Petition in this proceeding, discussed above, we agree with Patent Owner that Petitioner has not explained why the issues in this second-filed petition differ from those in the prior-instituted proceeding in a material manner such that a second petition is necessary. Consequently, the factual record supports exercising our discretion to deny the second-filed petition under consideration in this proceeding.” slip op. at 10
Discretionary denialPatents in suitUS 10,879,254 - PTAB · May 21, 2025 · IPR2025-00193 · APJ Sheridan K Snedden · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1, 3, 6, 10, 11, 16, 18, 21, 24–26, or 30 were unpatentable on any asserted ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“To institute an inter partes review, we must determine that the information presented in the Petition shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). After considering the evidence and arguments presented in the Petition, we determine that Petitioner has not demonstrated a reasonable likelihood of success in proving that at least 1 claim of the ’030 patent is unpatentable.” slip op. at 2
- BurdenNot shown unpatentable
“What is missing from Petitioner’s stated motivation for modifying the array of Cantor is a reason why a POSA would seek to correlate the identification sequence with a location on the array at all. Prelim. Resp. 72. Indeed, the location of a bead on the substrate is not pertinent to the analysis disclosed in Cantor. Ex. 2002 ¶ 172; see also id. at ¶ 31 (Cantor “does not relate to the [spatial] analysis of tissue samples . . . .”). “[O]bviousness concerns whether a skilled artisan not only could have made but would have been motivated to make the combinations or modifications of prior art to arrive at the claimed invention.” Belden Inc. v. Berk-Tek LLC, 805 F.3d 1064, 1073 (Fed. Cir. 2015). Here, Cantor fails to teach or suggest capture probes distributed randomly on a substrate comprising a nucleic acid sequence that identifies a unique location on the substrate as required by the challenged claims, and Petitioner fails to adequately articulate why a person of ordinary skill in the art would have modified Cantor to make the recited capture probes. In view of the above, we find that, on this record, Petitioner has failed to establish that Cantor teaches or suggests each element of the challenged claims. Accordingly, we determine that Petitioner has not demonstrated a reasonable likelihood of prevailing on its challenge that any of claims 1, 3, 6, 10, 11, 16, 18, 21, 24–26, and 30 would have been obvious over Cantor.” slip op. at 20
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner does not argue that any claim term requires construction. Pet. 22–23. Likewise, Patent Owner takes the position that “no claim terms 2 Person of ordinary skill in the art. require explicit construction” for purposes of determining whether to institute inter partes review. Prelim. Resp. 19. Having considered the parties’ positions and evidence of record, we determine that no express construction of any claim term is necessary to determine whether to institute inter partes review. Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co. Matal, 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 8
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“What is missing from Petitioner’s stated motivation for modifying the array of Cantor is a reason why a POSA would seek to correlate the identification sequence with a location on the array at all. Prelim. Resp. 72. Indeed, the location of a bead on the substrate is not pertinent to the analysis disclosed in Cantor. Ex. 2002 ¶ 172; see also id. at ¶ 31 (Cantor “does not relate to the [spatial] analysis of tissue samples . . . .”). “[O]bviousness concerns whether a skilled artisan not only could have made but would have been motivated to make the combinations or modifications of prior art to arrive at the claimed invention.” Belden Inc. v. Berk-Tek LLC, 805 F.3d 1064, 1073 (Fed. Cir. 2015). Here, Cantor fails to teach or suggest capture probes distributed randomly on a substrate comprising a nucleic acid sequence that identifies a unique location on the substrate as required by the challenged claims, and Petitioner fails to adequately articulate why a person of ordinary skill in the art would have modified Cantor to make the recited capture probes. In view of the above, we find that, on this record, Petitioner has failed to establish that Cantor teaches or suggests each element of the challenged claims. Accordingly, we determine that Petitioner has not demonstrated a reasonable likelihood of prevailing on its challenge that any of claims 1, 3, 6, 10, 11, 16, 18, 21, 24–26, and 30 would have been obvious over Cantor.” slip op. at 20
Claim construction§ 102 anticipation§ 103 obviousnessPatents in suitUS 11,761,030 - PTAB · May 21, 2025 · IPR2025-00192 · APJ Sheridan K Snedden · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1, 5, 17, 20, 23, 28, or 29 were unpatentable over the asserted grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“To institute an inter partes review, we must determine that the information presented in the Petition shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). After considering the evidence and arguments presented in the Petition, we determine that Petitioner has not demonstrated a reasonable likelihood of success in proving that at least 1 claim of the ’138 patent is unpatentable.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“[O]bviousness concerns whether a skilled artisan not only could have made but would have been motivated to make the combinations or modifications of prior art to arrive at the claimed invention.” Belden Inc. v. Berk-Tek LLC, 805 F.3d 1064, 1073 (Fed. Cir. 2015). Here, Cantor fails to teach or suggest capture probes distributed randomly on a substrate comprising a nucleic acid sequence that identifies a unique location on the substrate as required by the challenged claims, and Petitioner fails to adequately articulate why a person of ordinary skill in the art would have modified Cantor to make the recited capture probes. In view of the above, we find that, on this record, Petitioner has failed to establish that Cantor teaches or suggests each element of the challenged claims. Accordingly, we determine that Petitioner has not demonstrated a reasonable likelihood of prevailing on its challenge that any of claims 1, 5, 17, 20, 23, 28, and 29 would have been obvious over Cantor. slip op. at 21
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportPriority date awardedDecided for patent owner
“3. Discussion Petitioner challenges whether certain elements of independent claims 1 and 17 are supported by the ’124 provisional and/or whether the ’138 patent’s priority chain is intact. Pet. 52–60. Having considered the parties’ positions and evidence of record, however, we agree with Patent Owner’s written description analysis, summarized above, and find (1) that the ’124 Provisional provides adequate written description support for each of the challenged claim elements; (2) that the ’138 patent’s priority chain is intact; and (3) that the ’138 patent is therefore entitled to the priority date of April 5, 2010. Consequently, Frisen is not prior art to the challenged claims.” slip op. at 28
- Novelty / Anticipation (§102) › Prior-art status of a reference › Patents / published applications (effective date, provisional support)Reference not prior artDecided for patent owner
“3. Discussion Petitioner challenges whether certain elements of independent claims 1 and 17 are supported by the ’124 provisional and/or whether the ’138 patent’s priority chain is intact. Pet. 52–60. Having considered the parties’ positions and evidence of record, however, we agree with Patent Owner’s written description analysis, summarized above, and find (1) that the ’124 Provisional provides adequate written description support for each of the challenged claim elements; (2) that the ’138 patent’s priority chain is intact; and (3) that the ’138 patent is therefore entitled to the priority date of April 5, 2010. Consequently, Frisen is not prior art to the challenged claims.” slip op. at 28
Claim construction§ 102 anticipation§ 103 obviousnessPatents in suitUS 11,549,138 - SML Intelligent Inventory Solutions LLC / SML (USA) Inc. v. Adasa Inc.Institution deniedPTAB · May 20, 2025 · IPR2025-00125 · APJ Devon Zastrow Newman · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that any challenged claim was unpatentable under the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. 35 U.S.C. § 314(b) (2018); 37 C.F.R. § 42.4(a) (2019). An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Upon consideration of the Petition, the Preliminary Response, and the evidence of record, we conclude that Petitioner has not established a reasonable likelihood of prevailing on its assertion that at least one challenged claim is unpatentable based on the grounds advanced here. Accordingly, we deny institution of inter partes review of claims 1–20 of the ’967 patent.” slip op. at 2
- Skill levelSkill level petitioner adoptedOther
“VSI Int’l Inc., 174 F.3d 1308, 1324 (Fed. Cir. 1999) (citing Graham v. John Deere Co., 383 U.S. 1, 17–18 (1966); Ryko Mfg. Co. v. Nu-Star, Inc., 950 F.2d 714, 718 (Fed. Cir. 1991)). Petitioner adopts the following definition of a person of ordinarily skill in the art (hereafter, sometimes “POSITA”) of the ’967 patent proposed by Patent Owner in the Avery Dennison litigation: [A]t least a bachelor’s degree in electrical engineering, computer science, or computer engineering, or a related discipline, and at least five years of experience which would consist of, A, designing, developing, evaluating and/or using RFID or other AIDC [automatic identification and data capture] technologies in inventory management, unique object identification, and/or security; or B, studying and conducting research related to RFID technologies and using RFID and other AIDC technologies in inventory management, unique object identification, and/or security. Pet. 6 (citing Ex. 1030, 707:3–13). Patent Owner does not offer a definition of an ordinarily skilled artisan of the ’967 patent at this time. See generally Prelim. Resp. Based on the information presented, we find that the asserted prior art itself is sufficient to demonstrate the level of skill in the art at the time of the invention. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (prior art itself can reflect the appropriate level of ordinary skill in the art). To the extent a more precise definition is required, we apply Petitioner’s unopposed proposed definition for purposes of determining whether to institute review because it is consistent with the disclosures of the asserted prior art references and the problems addressed in the ’967 patent.” slip op. at 17
- Prior constructionPrior construction adoptedDecided for patent owner
“Petitioner proposes the following claim constructions: “an allocated block of serial numbers” as “a pre-authorized range of binary serial numbers” and “uniquely corresponding” as the “term’s plain and ordinary meaning, consistent with the articulation of the plain and ordinary meaning” in the Avery Dennison litigation. Pet. 8–12. As to the remaining claim terms, Petitioner applies the district court’s constructions in the Avery Dennison litigation. Id. at 12 (citing Ex. 1028). Patent Owner applies the following constructions that were entered during in the Avery Dennison litigation: “object class information space” as “data field within the memory of the RFID integrated circuit chip for information identifying the class of an object, such as a company prefix, item reference code, partition value, and/or filter value,” “unique serial number space” as “data field within the memory of the RFID integrated circuit for information identifying a unique serial number,” “being assigned a limited number of most significant bits” as “includes a limited, predefined sequence at the leading end,” “remaining bits of lesser significance” as “the remaining lower order bits at the trailing end,” “is encoded with one serial number instance” as “has stored within it one serial number instance,” “an allocated block of serial numbers” as “a pre-authorized range of serial numbers,” and “uniquely corresponding” as its plain and ordinary meaning. Prelim. Resp. 32. For purposes of resolving whether to institute trial, we adopt and apply the interpretations stated in the district court’s claim construction order and applied by the Federal Circuit on appeal, Ex. 1028.11 See 55 F.4th 900, 908–909, 912–913 (Fed. Cir. 2022) (citing the district court’s claim construction order).” slip op. at 18
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
“IBM200 and Kuhno would have made it obvious for a POSITA to commission RFID tags with unique serial numbers partitioned into MSBs and bits of lesser significance. See Pet. 34–39; Ex. 1005 ¶¶ 167–176. However, on this record, Petitioner has not sufficiently shown that the POSITA, having read IBM200 and Kuhno, would have been led to create a serial number space in which the limited number of “most significant bits” uniquely corresponds to those bits assigned to an allocated block of serial numbers, as recited in limitation [f].” slip op. at 25
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 9,798,967 - Micron Technology, Inc. v. Yangtze Memory Technologies Company, Ltd.Institution deniedPTAB · May 8, 2025 · IPR2025-00035 · APJ Michael T Cygan · IPR · Institution
The Board denied institution because Micron did not show a reasonable likelihood that claims 1–5, 8–13, or 15 were obvious over either asserted reference combination.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons given below, on this record, Petitioner has not established a reasonable likelihood that it would prevail in showing the unpatentability of at least one of challenged claims 1–5, 8–13, and 15 of the ’604 patent. Accordingly, we do not institute an inter partes review of the ’604 patent.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“We agree that Petitioner has not shown that a person having ordinary skill in the art at the critical time would have been motivated to replace the wordlines in the staircase region with dielectric material if the result is that one of the memory cell arrays becomes unavailable. Petitioner relies upon two usable arrays for its combination, emphasizing Thimmegowda as desirably enabling “a single conductive contact (e.g., 334a) to bidirectionally drive memory cells in the memory arrays on either side of the bridge”; i.e., both the left and right memory cell blocks. Pet. 26 (citing Ex. 1003 ¶¶ 81– 83; Ex. 1005, 9:49–51; 7:61–64), 41 (stating that in the combination, “there Similarly, Thimmegowda emphasizes that the purpose of its bridge is to connect first and second blocks, which desirably replaces prior connection methods that consumed silicon real estate and interfered with the goal of shrinking the sizes or increasing the densities of memory arrays. Ex. 1005, 1:11–25, 3:20–28; Ex. 1003 ¶¶ 79–80 (“allowing a single staircase to access both memory arrays”), 83 (“a stairstep electrically couples to a respective gate layer (wordline) in both of the blocks on the right and left”). Dr. Banerjee also underscores the importance of using both arrays, stating that the combination relies on “Thimmegowda’s bridge and array architecture (to drive two memory arrays with one wordline via)” as part of the reasonable expectation of success in such a combination Ex. 1003 ¶¶ 102, 113. Petitioner and Dr. Banerjee rely upon the motivation of reducing punch-through, because punch-through causes “yield loss”; i.e., loss of the usability of the wordlines connected by the punch-through. Ex. 1003 ¶ 103; Pet. 35. However, such advantage is premised on retaining both arrays, and neither Petitioner nor Dr. Banerjee explains how the advantages of reducing punch-through should be weighed against a disadvantage of losing access to one of the two arrays. Nor do Petitioner and Dr. Banerjee discuss how the advantages of metal gate replacement should be weighed against losing access to one of the two arrays.4 Patent Owner’s declarant, Dr. Giapis, attests to the undesirability of such a combination, in which one array 4 Additionally, the claims of the ’604 patent do not require a metal conductor portion; Petitioner does not explain why gate replacement to a metal conductor from a polysilicon conductor, described as used in Lee’s “memory device at large,” (Pet. 40) is a benefit associated with Lee’s finger teaching relevant to the claims. Ex. 2007 ¶¶ 50–54. We agree with Patent Owner that the advantage of preventing individual wordlines from becoming unusable because of punchthrough would be outweighed by the loss of half of the wordlines if one of the memory arrays were to become unavailable because its connections were removed.” slip op. at 15
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Not reached
“III. DISCRETION UNDER 35 U.S.C. § 314(a) Patent Owner argues that the Board should exercise its discretion to deny institution under 35 U.S.C. § 314(a) based on the factors set forth in Apple Inc. v. Fintiv, Inc., IPR2020-00019, Paper 11 at 6 (Mar. 20, 2020) additional briefing. Papers 12, 14. Because we determine that Petitioner has not shown a reasonable likelihood of success on the merits of its obviousness contentions, we need not resolve whether Fintiv would require discretionary denial of the Petition.6” slip op. at 23
- Skill levelSkill level petitioner adoptedOther
“at the critical time “would have had a bachelor of science degree in electrical engineering or a similar discipline, along with 2-3 years of professional experience working with (e.g., researching, designing, or teaching) 2 We apply AIA 35 U.S.C. § 103 to the ’604 patent because it was filed after, and never claimed the benefit of an effective filing date before, March 16, 2013. Ex. 1001, codes (22), (63); Pet. 6. 3 Neither party presents evidence or arguments regarding objective evidence of non-obviousness. Pet. 89; Prelim. Resp. level of skill, knowledge, and experience (e.g., an advanced degree may replace some of the professional experience).” Pet. 34 (citing Ex. 1003 ¶¶ 40–43). Petitioner further asserts that a POSITA “would have been aware of and generally knowledgeable about 3D NAND’s structure, its component parts, how it operates, and how it is controlled.” Id. Patent Owner does not provide any such assessment in its Preliminary Response. Prelim. Resp. 10. For purposes of this Decision, we adopt Petitioner’s proposed level of ordinary skill, as it appears to be consistent with the specification of the ’604 patent and the prior art of record.” slip op. at 6
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,450,604 - Aardevo North America, LLC v. Agventure B.V.Institution deniedPTAB · May 1, 2025 · IPR2025-00136 · APJ Jeffrey N Fredman · IPR · Institution
Institution of inter partes review was denied for claims 1–10 because Petitioner did not establish a reasonable likelihood of prevailing on any asserted ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Accordingly, we find that on the current record Petitioner has not shown that it has a reasonable likelihood that it would prevail on these obviousness grounds. XII. DISCRETIONARY DENIAL – 35 U.S.C. § 325(d) In view of our determination that the Petitioner does not meet the threshold for instituting review on the merits, we need not address the parties’ dispute about whether the Board should exercise its discretion to deny institution under 35 U.S.C. § 325(d). Pet. 74–75; Prelim. Resp. 38–54; Pet. Reply 1–5; PO Sur-Reply 1–5. XIII. CONCLUSION After reviewing the information presented in the Petition and the Preliminary Response, we determine that, based on the evidence of record, Petitioner has not established a reasonable likelihood that claims 1–10 of the ’841 patent are unpatentable. XIV. ORDER Accordingly, it is ORDERED that, pursuant to 35 U.S.C. § 314(a), institution of an inter partes review of all challenged claims on all grounds presented in the Petition is denied.” slip op. at 35
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element) › Inherent disclosureNot shown unpatentableInherency not foundNot shown unpatentable
“However, neither Petitioner nor Dr. Jansky provide specific data on the record before us showing the actual measured homozygosity of either of the inbred lines, US-W 5309 and US-W 5315. And Phumichai experimentally demonstrates that Dr. Jansky’s assumption that theoretical heterozygosity reduction of 50% per generation is not necessarily accurate, stating the “observed average percentage of reduction of heterozygosity per generation (38.4% or 38.5%) was lower than the theoretically expected value of 50%.” Ex. 1005, 982. Indeed, Phumichai disclosed that the “SOPH [Section-based observed percentage of heterozygosity] decreased steadily from the original 100% in 99H2–1 (S0) to the family means of 62.4% in 3H2 (S1), 37.9% in 3H3 (S2).” Id. at 981. That is, Phumichai experimentally shows that in an S2 generation of a potato line, the heterozygosity was 37.9%, resulting in homozygosity of about 62.1%, below the 75% theoretically expected and the 75% required by claim 1 of the ’841 patent. Therefore, the evidence of record does not show that the S2 generation of potato lines in Jong necessarily satisfies the homozygosity recitation in claim 1 of the ’841 patent, and so cannot establish on the record before us that Jong inherently teaches this limitation.” slip op. at 15
- Obviousness (§103) › Objective indicia / secondary considerationsObjective indicia outweighedNot shown unpatentableNot shown unpatentable
“Owner is telling. Petitioner does not refute Patent Owner’s evidence of objective indicia. On the current record, the objective indicia evidence is compelling. As to long felt need, Patent Owner cited evidence on record before the Examiner that showed a persistent need recognized by ordinarily skilled artisans. In re Gershon, 372 F.2d 535, 538 (CCPA 1967). For example, Dr. Huang states “This research is the breakthrough we have been waiting for since nearly a century . . . This is crucial for the potato breeding worldwide.” Ex. 2009, 687. There is no evidence that this long-felt need was satisfied by another before Appellant’s invention. See Newell Companies, Inc. v. Kenney Mfg. Co., 864 F.2d 757, 768 (Fed. Cir. 1988) (“[O]nce another supplied the key element, there was no long-felt need or, indeed, a problem to be solved . . . .”). Lastly, Dr. Lindhout explains that this invention satisfies the long-felt need, stating “I have discovered, and disclosed in the present application for patent, how a fertile homozygote in” slip op. at 33
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsNot reached
“XII. DISCRETIONARY DENIAL – 35 U.S.C. § 325(d) In view of our determination that the Petitioner does not meet the threshold for instituting review on the merits, we need not address the parties’ dispute about whether the Board should exercise its discretion to deny institution under 35 U.S.C. § 325(d). Pet. 74–75; Prelim. Resp. 38–54; Pet. Reply 1–5; PO Sur-Reply 1–5.” slip op. at 35
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,140,841 - PTAB · Apr 25, 2025 · IPR2024-00793 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Micron’s rehearing requests, finding no misapprehension or overlooked matter in its denial of institution based on the failure to show the challenged claims obvious.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“Petitioner’s own formulations of the grounds based on either Seo or Nam in combination with Choi posit the alternative theories that either Seo or Nam alone disclose Limitation [1.D], or the combination of either Seo or Nam with Choi teaches this limitation. Although Petitioner did not invoke inherency by name for the theories based on Seo or Nam alone, this is, in effect, the nature of Petitioner’s assertions, namely, voltage differentials in Seo and Nam would inherently remove fast charges. For example, with respect to Seo, Petitioner argues that “Seo teaches having a higher voltage on unselected WLs (e.g., adjacent WLs to the selected WL) during the first time period,” and “the ’342 patent recognizes [that] this voltage differential removes fast charges.” Pet. 35–36 (citing Ex. 1001, 12:24–34; Ex. 1003 ¶¶ 129–131) (emphasis omitted); see also id. at 82–83 (relying on the ’342 patent to support the contention that Nam teaches Limitation [1.D] because Nam “teaches having a higher voltage on unselected WLs (including WLs adjacent to the selected WL) relative to the selected WL during the first time period” (citing Ex. 1001, 12:24–34) (emphasis omitted)). Petitioner does not argue that Seo and Nam expressly disclose removing fast charges or sufficiently explain how a POSITA would have understood that the procedures used in Seo and Nam would have removed fast charges; instead, Petitioner effectively argues that removing fast charges is the inherent result of applying the voltage differential. See, e.g., Pet. 36 (stating Seo would have been understood to disclose “performing its read operation on chargetrap memories, which removes fast charges”).” slip op. at 5
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Petitioner’s reliance on Choi does not cure the deficiencies set forth above. Petitioner asserts that “Choi explains the primary mechanism and unwanted impact of fast-charge loss on verification,” which provides the motivation “to use Seo’s and Nam’s methods to achieve fast charge removal to improve verification.” Req. 7 n.1. But again, Petitioner does not sufficiently explain how a POSITA, looking at Choi, would have understood that either Seo’s or Nam’s techniques result in fast charge removal. In other words, even if Choi teaches the impact of fast-charge loss on verification, Petitioner fails to sufficiently show that a POSITA would have understood that either Seo or Nam teach or suggest fast charge removal. It was Petitioner’s burden to establish that Seo and Nam, alone or in combination with Choi, disclose Limitation [1.D]. We are not persuaded that we misapprehended the nature of Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 7
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish that Seo and Nam, alone or in combination with Choi, disclose Limitation [1.D]. We are not persuaded that we misapprehended the nature of Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner’s reliance on Choi does not cure the deficiencies set forth above. Petitioner asserts that “Choi explains the primary mechanism and unwanted impact of fast-charge loss on verification,” which provides the motivation “to use Seo’s and Nam’s methods to achieve fast charge removal to improve verification.” Req. 7 n.1. But again, Petitioner does not sufficiently explain how a POSITA, looking at Choi, would have understood that either Seo’s or Nam’s techniques result in fast charge removal. In other words, even if Choi teaches the impact of fast-charge loss on verification, Petitioner fails to sufficiently show that a POSITA would have understood that either Seo or Nam teach or suggest fast charge removal.” slip op. at 7
§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,600,342
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.