• Zhuhai Cosmx Battery Co., Ltd. v. Ninge Amperex Technology LimitedInstitution denied
  PTAB · Aug 20, 2025 · IPR2025-00385 · APJ Debra L Dennett · IPR · Institution

  The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–10 were anticipated by Nishikawa or obvious over the asserted combinations.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “review under 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least [one] of the claims challenged in the petition.” For the reasons set forth below, upon considering the Petition and Preliminary Response, we determine that Petitioner has not established a reasonable likelihood of prevailing with respect to at least one challenged claim. Accordingly, we deny the Petition and decline to institute an inter partes review.” slip op. at 2

  • Skill levelSkill level petitioner adoptedOther

    “Petitioner contends that A person of ordinary skill in the relevant art would typically hold an advanced degree in chemistry, material science, and/or a related discipline, and have at least two years of experience with designing and/or fabricating battery separators or have an equivalent level of education, training, and experience. Pet. 5. Patent Owner “adopts the definition proposed by Petitioner” for the purposes of the Preliminary Response. Prelim. Resp. 22. In light of the record before us, and for purposes of this Decision, we adopt Petitioner’s unopposed definition because it is consistent with the specification. We note that neither party indicated that the result would change under any different definition.” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Absolute plastic deformation rate” and “relative plastic deformation rate” are the only claim terms disputed in this proceeding, and are clearly defined in the Specification and in claim 1. See Spec. 4:22–27, 4:47–54; 25:31–37. Because we determine that claim construction is not necessary to decide whether to institute, we do not expressly construe any claim terms. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (holding that “only those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy”); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs. in the context of an inter partes review). slip op. at 11

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable

    “Petitioner’s arguments are unconvincing. Petitioner points to nothing in Nishikawa that allows a POSITA to determine L2 (defined as “a length of 4 Tensile strength is measured as force per units area, such as MPa or psi. One MPa equals one N/mm2. Nishikawa Table 1 discloses tensile strength in N/cm. Ex. 1004 Table 1. Petitioner makes calculations to convert the reported N/cm into N/m2 and then to GPa, but provides no explanation for why tensile strength is reported in N/cm or how it was measured. See Pet. 31. the porous substrate after the porous substrate is stretched to breakage and docked along the fracture caused by the breakage and flattened”) or L2 – L0. See generally Pet., Ex. 1004. Petitioner and its expert, Dr. Pecht, fail to adequately explain why tensile strength divided by Young’s modulus is “a proxy for L1 – L2” or why such a proxy is sufficient to disclose the limitation as stated. Instead, we are required to rely on “approximations” and “estimates” with insufficient explanation of why such they are appropriate or adequate. See Pet. 26, 30, 32; see also Ex. 1003 ¶¶ 97, 105–108, 111.” slip op. at 13

  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 10,964,927
• Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Institution denied
  PTAB · Apr 25, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Institution

  The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–8 were unpatentable under the asserted obviousness grounds.

  RulingsInstitution decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “experience working on the development of materials or components for electronic devices such as batteries.” Pet. 2. Petitioner further contends that “[a]dditional education, such as a graduate degree, could compensate for less work experience, and additional work experience could compensate for less formal education.” Id. Patent Owner states that, “[f]or purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art.” Prelim. Resp. 4. For purposes of this Decision, we adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’014 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))).” slip op. at 8

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” 37 C.F.R. § 42.100(b). Under this standard, claim terms are generally given their plain and ordinary meaning as would have been understood by a person of ordinary skill in the art at the time of the invention and in the context of the entire patent disclosure. Phillips v. AWH Corp., 415 F.3d 1303, 1313 (Fed. Cir. 2005) (en banc). Only those terms in controversy need to be construed, and only to the extent necessary to resolve the controversy. Realtime Data LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019). in this proceeding.” Pet. 3. Patent Owner contends that “[t]he Board need not construe any term in order to determine that institution should be denied.” Prelim. Resp. 4. Based on the record before us, we determine that no claim term requires express construction for purposes of this Decision. See Realtime Data, 912 F.3d at 1375.” slip op. at 8

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “For these reasons, we are not persuaded that Petitioner sufficiently establishes that a POSITA would have been motivated to modify Hanafusa in light of Dobashi with a reasonable expectation of success as Petitioner contends. Accordingly, we determine that Petitioner fails to demonstrate a reasonable likelihood of prevailing in its assertion that the subject matter of claim 1, and claims 4 and 8 that depend therefrom, would have been obvious over the combined teachings of Hanafusa and Dobashi.” slip op. at 18

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable

    “Petitioner also focuses on Hanafusa’s teaching that all known methods can be used to make a rough surface low-profile, and Dobashi’s teaching that RSm can be used as an indicator for judgment of the surface, to support its contention that a POSITA would have been motivated to apply Dobashi’s RSm to further achieve Hanafusa’s purpose, without explaining how and why that would be the case. In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness and is rough when RSm is small.” Id. at 3:1–3, 6:27–29. Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66– 3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66–3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 14

  Claim construction§ 103 obviousnesscites Phillips · KSR
  Patents in suitUS 11,346,014
• Inari Agriculture, Inc. v. Pioneer Hi-Bred International, Inc.Institution denied
  PTAB · Nov 1, 2024 · PGR2024-00025 · APJ Jeffrey W Abraham · PGR · Institution

  The Board denied institution because Petitioner did not show that claims 1–20 were more likely than not unpatentable over either obviousness ground, for lack of utility, or as indefinite.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsDenied

    “Institution of a post-grant review is authorized by statute when “the information presented in the petition filed under [35 U.S.C. §] 321 . . . demonstrates that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a). For the reasons set forth below, we determine that Petitioner has failed to demonstrate that it is more likely than not that at least one of claims 1–20 of the ’033 patent is unpatentable. Accordingly, we deny institution of a postgrant review of claims 1–20 based on the grounds set forth in the Petition.” slip op. at 2

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “level of skill, with a doctoral degree in plant breeding or a related field, at least five years of experience with corn breeding, and additional experience interfacing with laboratory-side personnel (including a computational biologist along with genetics specialists) and field-side personnel.” Pet. 15 (citing Ex. 1003 ¶¶ 19–22, 44–45). Petitioner also states that, “[a]lternatively, additional experience could take the place of an advanced degree.” Pet. 15. Patent Owner states that it “does not dispute Petitioner’s definition of the qualifications of person of skill in the art” and “reserves its right to challenge Petitioner’s definition and to provide its own definition, should trial be instituted.” Prelim. Resp. 25. Petitioner’s unopposed proposed definition is consistent with the cited prior art and the disclosure of the ’033 patent, and we adopt it for purposes of this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that the prior art itself may “reflect[] an appropriate level”” slip op. at 6

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Petitioner does not offer a specific construction for any claim terms. Pet. 19–20. Rather, Petitioner contends that “the outer boundary of the Challenged Claims lacks reasonable certainty,” and, therefore, “the Challenged Claims are unpatentable as indefinite under §112(b).” Pet. 20. Petitioner further contends that the challenged claims are unpatentable as obvious “regardless of the outer boundary of the claims.” Pet. 21. Patent Owner disagrees with Petitioner’s arguments regarding indefiniteness, and does not construe any claim terms. See generally Prelim. Resp. As explained in detail below, based on the record before us, we are not persuaded by Petitioner’s indefiniteness arguments, and determine that none of the claim terms require an explicit construction to determine whether to institute post-grant review. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary” slip op. at 7

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableReasonable expectation not foundNot shown unpatentable

    “Patent Owner is correct that Petitioner focuses its obviousness challenge on 1PNZQ23’s phenotype, and does not address its genotype. Prelim. Resp. 41–42; see Pet. 26–32 (comparing 1PNZQ23’s phenotype with the phenotypes of the asserted prior art). Petitioner does not direct us to, nor do we discern, any information in the Petition or Reply regarding 1PNZQ23’s genotype that supports Petitioner’s arguments regarding obviousness. Furthermore, Patent Owner offers information suggesting that “the breeding of 1PNZQ23 was unpredictable even with both parents being known in the art.” Prelim. Resp. 47. Dr. Schnable addresses unpredictability in the breeding process, stating: distinct even when the F1 plant itself results from a cross of two inbreds. A [person of ordinary skill in the art] would not expect that a cross of the same parents will produce F2 or D1 progeny identical to 1PNZQ23. . . . [T]he genome of a progeny plant is the result of genetic segregation and recombination in the F1 plant of the two parental genomes and the chance of the exact same child resulting from that initial biparental cross is infinitesimally small. Ex. 2004 ¶ 123. This information undermines Petitioner’s arguments regarding an expectation of success in achieving the claimed invention.” slip op. at 13

  Claim construction§ 101 eligibility§ 103 obviousness§ 112 disclosureDiscretionary denialcites Phillips
  Patents in suitUS 11,707,033
• Inari Agriculture, Inc. v. Pioneer Hi-Bred International, Inc.Institution denied
  PTAB · Oct 15, 2024 · PGR2024-00023 · APJ Jeffrey W Abraham · PGR · Institution

  The Board denied institution on claims 1–20 because the petition did not show they were unpatentable on any asserted obviousness, utility, written-description, or enablement ground.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “Institution of a post-grant review is authorized by statute when “the information presented in the petition filed under [35 U.S.C. §] 321 . . . demonstrates that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a). For the reasons set forth below, we determine that Petitioner has failed to demonstrate that it is more likely than not that at least one of claims 1–20 of the ’545 patent is unpatentable. Accordingly, we deny institution of a postgrant review of claims 1–20 based on the grounds set forth in the Petition.” slip op. at 2

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “level of skill, with a doctoral degree in plant breeding or a related field, at least five years of experience with corn breeding, and additional experience interfacing with laboratory-side personnel (including a computational biologist as along with genetics specialists) and field-side personnel.” Pet. 16 (citing Ex. 1003 ¶¶ 50–51). Petitioner also states that, “[a]lternatively, additional experience could take the place of an advanced degree.” Pet. 16. Patent Owner states that it “does not dispute Petitioner’s definition of the qualifications of person of skill in the art” and “reserves its right to challenge Petitioner’s definition and to provide its own definition, should trial be instituted.” Prelim. Resp. 24. Petitioner’s unopposed proposed definition is consistent with the cited prior art and the disclosure of the ’545 patent, and we adopt it for purposes” slip op. at 6

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. [§] 282(b).” 37 C.F.R. § 42.200(b) (2019). Under that standard, the words of a claim are generally given their “ordinary and customary meaning,” which is the meaning the term would have to a person of ordinary skill at the time of the invention, in the context of the entire patent including the specification. Phillips v. AWH Corp., 415 F.3d 1303, 1312–13 (Fed. Cir. 2005) (en banc). Petitioner contends that “[b]ecause Petitioner’s grounds plainly render the claims unpatentable under any plausible construction, no outer boundary constructions are necessary.” Pet. 21. Patent Owner also does not construe any claim terms. See generally Prelim. Resp. For purposes of this Decision, and based on the record before us, we determine that none of the claim terms require an explicit construction to determine whether to institute post-grant review. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). slip op. at 7

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableReasonable expectation not foundNot shown unpatentable

    “additional reasons. For example, we agree with Patent Owner that Petitioner fails to demonstrate sufficiently that a person of ordinary skill in the art would have had a reasonable expectation of success in arriving at PH4CYJ based on Smalley’s disclosure alone. Prelim. Resp. 51–52. According to the ’545 patent specification, the claimed PH4CYJ inbred maize variety is a cross between inbred line PH1VNA and inbred line PH1KTF. Ex. 1001, 37:62–64. In the simplest terms, PH1VNA and PH1KTF are the parents, and their cross ultimately resulted in the inbred variety PH4CYJ. The ’545 patent explains that after the initial crossing of the parental lines, the” slip op. at 14

  Claim construction§ 101 eligibility§ 103 obviousness§ 112 disclosurecites Phillips
  Patents in suitUS 11,696,545
• Inari Agriculture, Inc. v. Pioneer Hi-Bred International, Inc.Institution denied
  PTAB · Sep 24, 2024 · PGR2024-00019 · APJ Ulrike W Jenks · PGR · Institution

  The Board denied institution of PGR on claims 1–20 because the Petition did not show they were more likely than not unpatentable on any asserted ground.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “Institution of a post-grant review is authorized by statute when “the information presented in the petition filed under [35 U.S.C. §] 321 . . . demonstrates that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a). For the reasons set forth below, we determine that Petitioner failed to demonstrate that it is more likely than not that claims 1–20 of the ’803 patent are unpatentable. Accordingly, we deny institution of a post-grant review of claims 1–20 based on the grounds set forth in the Petition.” slip op. at 2

  • Skill levelSkill level petitioner adoptedOther

    “Patent Owner states that it “does not dispute Petitioner’s definition of the qualifications of person of skill in the art” and “reserves its right to challenge Petitioner’s definition and to provide its own definition, should trial be instituted.” Prelim. Resp. 24. Petitioner’s unopposed proposed definition is consistent with the cited prior art and the disclosure of the ’803 patent, and we adopt it for purposes of this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that the prior art itself may “reflect[] an appropriate level” of ordinary skill in the art) (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985)).” slip op. at 7

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Petitioner contends that “[b]ecause Petitioner’s grounds plainly render the claims unpatentable under any plausible construction, no outer boundary constructions are necessary.” Pet. 20. Patent Owner also does not construe and based on the record before us, we determine that none of the claim terms requires an explicit construction to determine whether to institute post-grant review. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 7

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundReasonable expectation not foundNot shown unpatentable

    “their cross ultimately resulted in the inbred variety 1PFLQ21. The ’803 patent explains that after the initial crossing of the parental lines, the selection of the progeny was based on genetic analysis predicting disease, insect, and agronomic phenotypic performance. Id. 37:64–66. “Inbred 1PFLQ21 was developed by producing a doubled haploid from the F1 plants, selfing and using pedigree selection amongst the D1 lines, and selfing and bulking from the subsequent generations.” Id. 37:66–38:3. The ’803 patent specification, therefore, makes it clear that simply crossing both parental inbred maize lines is not reasonably expected to result in the claimed inbred maize variety; rather, it explains that more plant breeding work is required to arrive at the 1PFLQ21 inbred maize line than just having both parental inbred maize lines available.” slip op. at 15

  Claim construction§ 101 eligibility§ 103 obviousnessDiscretionary denialcites Phillips
  Patents in suitUS 11,659,803
• Inari Agriculture, Inc. v. Pioneer Hi-Bred International, Inc.Institution denied
  PTAB · Sep 24, 2024 · PGR2024-00020 · APJ Jeffrey W Abraham · PGR · Institution

  Denied institution of PGR on claims 1–20 because Petitioner did not show a reasonable likelihood equivalent under § 324 that any challenged claim was unpatentable.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “Institution of a post-grant review is authorized by statute when “the information presented in the petition filed under [35 U.S.C. §] 321 . . . demonstrates that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a). For the reasons set forth below, we determine that Petitioner has failed to demonstrate that it is more likely than not that at least one of claims 1–20 of the ’020 patent is unpatentable. Accordingly, we deny institution of a postgrant review of claims 1–20 based on the grounds set forth in the Petition.” slip op. at 2

  • Skill levelSkill level petitioner adoptedOther

    “Petitioner asserts that a person of ordinary skill in the art “had a high level of skill, with a doctoral degree in plant breeding or a related field, at least five years of experience with corn breeding, and additional experience interfacing with laboratory-side personnel (including a computational biologist . . . along with genetics specialists) and field-side personnel.” Pet. 15 (citing Ex. 1003 ¶¶ 19–21). Petitioner also states that, “[a]lternatively, additional experience could take the place of an advanced degree.” Pet. 15. Patent Owner states that it “does not dispute Petitioner’s definition of the qualifications of person of skill in the art,” but “reserves its right to challenge Petitioner’s definition and to provide its own definition, should trial be instituted.” Prelim. Resp. 25. Petitioner’s unopposed proposed definition is consistent with the cited prior art and the disclosure of the ’020 patent, and we adopt it for purposes of this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that the prior art itself may “reflect[] an appropriate level” of ordinary skill in the art) (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985)).” slip op. at 6

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Petitioner contends that “[b]ecause Petitioner’s grounds plainly render the claims unpatentable under any plausible construction, no outer boundary constructions are necessary.” Pet. 22. Patent Owner also does not construe any claim terms. See generally Prelim. Resp. For purposes of this Decision, and based on the record before us, we determine that none of the claim terms require an explicit construction to determine whether to institute post-grant review. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 7

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable

    “Based on these disclosures in Smalley, we agree with Petitioner that a person of ordinary skill in the art would have understood that the parental line PH1D84 could have been used as a starting point to arrive at other inbred lines. See Pet. 41. Petitioner, however, fails to demonstrate sufficiently how or why a person of ordinary skill in the art would have had a reasonable expectation of success in developing 1PFHC43 specifically, when its other parent was not known in the art at the relevant time. As Dr. Schnable explains, 1PFHC43’s genome is derived from its parents. Ex. 2004 ¶ 115. Petitioner does not address how a person of ordinary skill in the art would have been able to produce the claimed seed, including its unique genotype, without having access to PH1VNA or its genomic and phenotypic information.” slip op. at 15

  Claim construction§ 101 eligibility§ 103 obviousnessDiscretionary denialcites Phillips
  Patents in suitUS 11,666,020
• Dexcom, Inc. v. Abbott Diabetes Care Inc.Institution denied
  PTAB · Aug 8, 2024 · IPR2024-00520 · APJ John G New · IPR · Institution

  The Board denied institution because Dexcom did not show a reasonable likelihood that claims 5–7 were unpatentable under either Stafford–Raymond ground.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “Burden of Proof “In an [inter partes review], the petitioner has the burden from the onset to show with particularity why the patent it challenges is unpatentable.” Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1363 (Fed. Cir. 2016 (citing 35 U.S.C. § 312(a)(3) (requiring inter partes review petitions to identify “with particularity … the evidence that supports the grounds for the challenge to each claim”)). Therefore, in an inter partes review, the burden of proof is on the Petitioner to show that the challenged claims are unpatentable; that burden never shifts to the patentee. See 35 U.S.C. § 316(e); In re Magnum Oil Tools Int’l, Ltd., 829 F.3d 1364, 1375 (Fed. Cir. 2016) (citing Dynamic Drinkware, LLC v. Nat’l Graphics, Inc., 800 F.3d 1375, 1378 (Fed. Cir. 2015)). At the institution stage, Petitioner must show a reasonable likelihood that it would prevail with respect to at least one of the claims challenged in the petition. 35 U.S.C. § 314.” slip op. at 14

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable

    “We do not find these arguments persuasive. It may be so that Turner teaches that its recesses 77 receive rotation-restricting protrusions 71, which “extend[] into each recess 77 such that the recess side walls interfere with the protrusions to prevent rotation of the insertion device relative to body 20.” Ex. 1011 ¶ 69. And, it may also be so that Turner teaches this assembly as an advantage in that it prevents rotation of body 20. Id. However, Petitioner did not present this “design choice” theory of obviousness in the Petition. Petitioner first raises its “obvious design choice” argument with respect to Turner and Ground 2 in its Reply Brief; it is not to be found in its Petition.12 Petitioner cannot raise an argument in its” slip op. at 32

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for patent owner

    “In each of the ’335 Specification, Stafford, Raymond, and Turner, the OBU is universally depicted as having a circular perimeter oriented around a longitudinal axis, and possessing either a cylindrical shape (’335 patent, Stafford, Raymond) or a roughly domed shape, with a circular, circumferential collar. See, e.g., Ex. 1001, Figs. 8, 17, 52, 54; Ex. 1009, Figs 3A–C, 4A; Ex. 1010, Figs. 14–16, Ex. 1011, Figs. 2A–B, 5G, 7A-B, 9, 11, 13A–B, 14, 15, 19, 20, 21, 25, 29, 30, 37, 38. Moreover, in each description of the location of recesses 3766 in the ’335 Specification, the recesses are described as being located “on the side walls” of the OBU. See Ex. 1001, col. 44, ll. 8–12; col. 45, ll. 61–64. Given the circular perimeter of all of these embodiments of the disclosures of the ’335 Specification, the teachings of Petitioner’s cited references, the dictionary definition of “periphery” as being “the perimeter of a circle or other closed curve,” and the ordinary meaning that the terms would have had to a skilled artisan at the time of the invention, in view of the ’335 Specification and file history” (Phillips, 415 F.3d at 1312–13), we conclude that a person of ordinary skill in the art would understand that the “plurality of recesses disposed on a periphery of the on body electronics unit housing” would be located “on the circumference of the on-body housing,” as we concluded in the ’01396 IPR Decision. See Dec. 48; see also Ex. 1001, col. 44, ll. 9–14 (stating that “gripping arms 3762 [of medical device carrier 3730] are provided with engagement boss 3764 which are configured to engage with corresponding recesses 3766 provided on the side walls of the on body housing 322”).” slip op. at 38

  • Strike new argumentNew argument disregardedDecided for patent owner

    “However, Petitioner did not present this “design choice” theory of obviousness in the Petition. Petitioner first raises its “obvious design choice” argument with respect to Turner and Ground 2 in its Reply Brief; it is not to be found in its Petition.12 Petitioner cannot raise an argument in its 12 The Petition makes a design choice argument with respect to the teachings of Raymond on Ground 1, contending that “it would have been an obvious design choice to implement two spaced-apart plural recesses on the housing—one to engage the protrusions on each of the two arms taught by Raymond.” Pet. 38. However, Petitioner adduced no prior art teaching or evidence of record of “spaced-apart plural recesses on the housing” that Reply Brief if that argument could first have been raised in its Petition. 37 C.F.R. § 42.23(b); see also L’Oréal USA, Inc. v. Univ. of Massachusetts, 2018 WL 4278992, *5 n.4 (PTAB Sept. 7, 2018); Matterport, Inc. v. Appliance Comp. III, Inc., 2021 WL 6340164, *9–10 (PTAB Nov. 19, 2021).” slip op. at 32

  Claim construction§ 103 obviousnesscites Phillips · Graham
  Patents in suitUS 11,266,335
• Mara Renewables Corporation v. DSM IP Assets, B.V.Institution denied
  PTAB · Apr 18, 2024 · IPR2024-00070 · APJ Zhenyu Yang · IPR · Institution

  The Board denied institution because the Petition did not show a reasonable likelihood that claims 1–15 were anticipated by Radianingtyas or obvious over either asserted combination.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “We have authority under 35 U.S.C. § 314, which provides that an inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons provided below, we determine Petitioner has not demonstrated a reasonable likelihood that it would prevail with respect to at least one claim challenged in the Petition. Accordingly, we deny institution of an inter partes review.” slip op. at 2

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. [§] 282(b).” 37 C.F.R. § 42.100(b). Under this standard, we construe the claim term “in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” Id.; see also Phillips v. AWH Corp., 415 F.3d 1303, 1312–13 (Fed. Cir. 2005) (en banc) (holding that the words of a claim “are generally given their ordinary and customary meaning,” which is “the meaning that the term would have to a person of ordinary skill in the art in question at the time of the invention, i.e., as of the effective filing date of the patent application”). Claim terms need only be construed to the extent necessary to resolve the controversy. Wellman, Inc. v. Eastman Chem. Co., 642 F.3d 1355, 1361 (Fed. Cir. 2011). On this record and for purposes of this Decision, we see no need to construe any claim term.” slip op. at 6

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Patent Owner does not provide a definition of the level of ordinary skill in the art. See Prelim. Resp. 19. Patent Owner also states that any differences between the parties’ proposed definition of the skill level would not impact its arguments. Id. For purposes of this Decision, we adopt Petitioner’s definition of the skill level because it is consistent with the prior art’s demonstration of the level of ordinary skill at the relevant time. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (holding that the prior art itself can reflect the appropriate level of ordinary skill in the art).” slip op. at 7

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable

    “triglyceride, DHA, and heptadecanoic acid content recited therein. In order to anticipate a claim, a prior art reference “must not only disclose all elements of the claim within the four corners of the document, but must also disclose those elements arranged as in the claim.” NetMoneyIN, Inc. v. VeriSign, Inc., 545 F.3d 1359, 1370 (Fed. Cir. 2008) (quotation marks omitted). A reference, however, can anticipate a claim “even if it does not expressly spell out all the limitations arranged or combined as in the claim, if a person of skill in the art, reading the reference, would at once envisage the claimed arrangement or combination.” Microsoft Corp. v. Biscotti, Inc., 878 F.3d 1052, 1068 (Fed. Cir. 2017) (quotation marks and brackets omitted). As explained below, here, Petitioner has not shown Radianingtyas discloses a microbial oil comprising the required triglyceride, DHA and heptadecanoic acid content. Specifically, although the exemplified strain ONC-T18 produces oil that meets the claimed triglyceride fraction and heptadecanoic acid level, Petitioner has not shown the same oil contains the recited DHA level.” slip op. at 10

  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips
  Patents in suitUS 8,207,363
• Zimvie, Inc. / Zimmer Biomet Spine, Inc. v. Roger P. JacksonInstitution denied
  PTAB · Apr 1, 2024 · IPR2023-01433 · APJ Zhenyu Yang · IPR · Institution

  The Board denied institution because Petitioner did not show a reasonable likelihood of proving any challenged claim unpatentable, chiefly because the cited art did not disclose the claimed curved leading faces.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons provided below, we determine Petitioner has not demonstrated a reasonable likelihood that it would prevail with respect to at least one claim challenged in the Petition. Accordingly, we deny institution of inter partes review.” slip op. at 2

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner

    “and consistent with the plain meaning, a POSA would have understood that a ‘start structure’ is the beginning of a thread and the ‘leading face’ is the forward most surface of the thread in the direction the thread is to be rotated.” Pet. 15–16 (citing Ex. 1001, 9:38–42, Fig. 5; Ex. 1003 ¶¶ 158, 159). Petitioner further asserts that the concave portion is “inwardly curving,” and the convex portion is “outwardly curving.” Id. at 16 (citing Ex. 1003 ¶ 161). Patent Owner does not propose any claim construction for these terms. See Prelim. Resp. 7. Instead, Patent Owner asserts that “there are no express constructions for the Board to consider or the Patent Owner to address.” Id. We disagree with Patent Owner’s allegation because Petitioner sufficiently explains the plain meaning of the terms “start structure,” “leading face,” “concave surface portion,” and “convex surface portion.” Pet. 15–16. On this record, and for purposes of this Decision, we adopt Petitioner’s proposed constructions of these terms. Claim terms need only be construed to the extent necessary to resolve the controversy. Wellman, Inc. v. Eastman Chem. Co., 642 F.3d 1355, 1361 (Fed. Cir. 2011). On this record, and for purposes of this Decision, we see no need to address the construction of any other claim term. slip op. at 7

  • Expert testimonyPetitioner expert discountedDecided for patent owner

    “As Patent Owner correctly points out, the ’477 publication does not describe, or even identify, the line in Figure 10 that Petitioner relies on as the leading face. Prelim. Resp. 20. Thus, the only evidence purportedly supports Petitioner’s argument that the unidentified and undescribed line is the leading surface is Dr. McMillin’s testimony. See Ex. 1003 ¶¶ 186, 234. In paragraph 186, Dr. McMillin’s testimony merely repeats, nearly verbatim, Petitioner’s argument, without any explanation or other evidentiary support. See id. ¶ 186. As a result, we accord limited weight to this testimony. See Xerox Corp. v. Bytemark, Inc., IPR2022-00624, Paper 9 at 15 (PTAB Aug. 24, 2022) (precedential). In paragraph 234, Dr. McMillin testifies that an ordinarily skilled artisan would have recognized the unidentified and undescribed line of Figure 10 “as the leading face of the thread, at least because it is the only feature shown that matches with leading face shown in Fig. 8.” Ex. 1003 ¶ 234. We find this testimony inconsistent with the disclosures in Figures 7 and 8.” slip op. at 12

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable

    “For the foregoing reasons, Petitioner does not persuade us that the unidentified and undescribed line in Figure 10 of the ’477 publication represents a leading surface having a partially concave surface and a partially convex surface as required in claim 1.7 For this reason alone, on this record, Petitioner has not established a reasonable likelihood that it would prevail in its challenge of claim 1 based on the ’477 publication. Each of claims 2 and 4–9 depends from claim 1. For the same reasons as explained above, Petitioner has not established a reasonable likelihood that it would prevail in its obviousness challenge of these claims either. b. Substantially Equal Radius of Curvature Claim 1 requires “the partial concave and partial convex surfaces each defined by a radius of curvature that is substantially equal with respect to 7 We also express doubt on whether Petitioner adequately shows the line in Figure 10 is partially concave and partially convex, as required in the disputed limitation. Petitioner’s argument on this point is predicated on an enlarged section of a small drawing, showing a single unidentified and undescribed line that was not apparently intended to demonstrate the direction of any curvature. Ultimately, we do not need to address this issue, because Petitioner does not sufficiently persuade us that the line depicts the leading face recited in the disputed limitation.” slip op. at 16

  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips
  Patents in suitUS 11,129,646
• Mara Renewables Corporation v. DSM IP Assets, B.V.Institution denied
  PTAB · Feb 23, 2024 · IPR2023-01342 · APJ Jon B Tornquist · IPR · Institution

  The Board denied institution because the petition did not show a reasonable likelihood that any challenged claim was anticipated or obvious over the asserted references.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). Having considered the arguments and evidence presented by Petitioner and Patent Owner, we determine that Petitioner has not demonstrated a reasonable likelihood of prevailing on at least one of the challenged claims of the ’959 patent. Accordingly, we deny institution of an inter partes review.” slip op. at 2

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that, as of the earliest claimed priority date of the ’959 patent, an ordinarily skilled artisan “would have had a Master of Science degree in an academic discipline emphasizing chemistry, chemical engineering, or biochemistry, in combination with training or at least two to three years of related work experience with lipid chemistry technologies, including but not limited to lipid extraction technologies.” Pet. 6 (citing Ex. 1003 ¶¶ 63–64). Alternatively, Petitioner proposes that an ordinarily skilled artisan “could have also had a Doctorate degree in a relevant academic discipline with one to two years of related work experience in the same discipline.” Id. Petitioner argues that an ordinarily skilled artisan “would have been familiar with microbial oils” and “would have understood the benefits of polyunsaturated fats (PUFAs), microbial sources for obtaining them, and methods for culturing and extracting oils from those microbial sources.” Id. (citing Ex. 1003 ¶¶ 36–48, 64). Patent Owner does not provide a definition of the level of ordinary skill in the art, but “reserves its right to proffer what it contends to be the appropriate level of ordinary skill in the art should the Board institute review.” Prelim. Resp. 15. Patent Owner asserts, however, that a person of ordinary skill in the art would have a detailed understanding of the information provided in its Technology Background section, including “the expected impact of cellular biomass growth characteristics on the proportion of triglycerides and phospholipids produced during a microbial fermentation.” Id. For purposes of this Decision, we adopt Petitioner’s definition of the skill level of an ordinarily skilled artisan as it is consistent with the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (holding that the prior art itself can reflect the appropriate level of ordinary skill in the art). As to the background knowledge possessed by the ordinarily skilled artisan, we agree that such an artisan would have been aware of methods for culturing and extracting oils from microbial sources, including the impact of growth characteristics on the proportions of triglycerides and phospholipids produced during microbial fermentation. Pet. 6; Prelim. Resp. 15.” slip op. at 7

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Petitioner contends that all claim terms of the ’959 patent “should be given their plain and ordinary meaning.” Pet. 3. Patent Owner does not contend that any claim terms require construction. Prelim. Resp. 14–15. For purposes of this Decision, we determine that no claim terms require express construction. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 8

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable

    “3. Analysis In order to anticipate a claim, a prior art reference “must not only disclose all elements of the claim within the four corners of the document, but must also disclose those elements ‘arranged as in the claim.’” NetMoneyIN, Inc. v. VeriSign, Inc., 545 F.3d 1359, 1370 (Fed. Cir. 2008) (quoting Connell v. Sears, Roebuck & Co., 722 F.2d 1542, 1548 (Fed. Cir. 1983)). Radianingtyas discloses microbial oils with various levels of DHA and arachidonic acid. There is no disclosure of an individual microbial oil, however, that contains at least 45% DHA and 1.5% or less arachidonic acid by weight as required by claim 1. With respect to the level of DHA, although Radianingtyas might be interpreted to disclose that some microorganisms can produce up to 60% DHA,8 Radianingtyas discloses that the DHA content of ONC-T18 is “typical[ly]” 35% of the total intracellular fatty acids, and in each experiment disclosed in Radianingtyas DHA was produced by ONC-T18 at 8 Radianingtyas discloses that “the oil producing microbe can produce a lipid composition comprising from about 25% to about 40% of an omega-3 fatty acid, such as n-3 DHA.” Ex. 1007, 26:31–33. It then gives examples that include 15%, 20%, 45%, 50%, 55%, and 60%, which are outside of the disclosed range. Id. at 26:33–34. Dr. Curtis contends the disclosure as a whole should be read as “from about 15% to about 60% of an omega-3 fatty acid, such as n-3 DHA.” Ex. 1003, 39 n.1. Dr. Curtis identifies no microbe in Radianingtyas, however, that is shown to produce more than 40% DHA, and Radianingtyas expressly notes that the typical DHA content produced by ONC-T18 is 35%. Thus, we question Dr. Curtis’ conclusions regarding the DHA content disclosure of Radianingtyas. levels less than “at least 45%.”9 Ex. 1007, 32:21–25 (noting that the “typical composition of fatty acids” produced by ONC-T18 includes 25% DHA), 34:4–37:14 (noting that the control microorganism produced 13.54%, 19.98%, 18.77%, 18.77%, 21.48%, 28.48%, and 14.13% DHA) (Figure 12), 91 (Table 5) (noting that total DHA produced by ONC-T18 was from 24- 34.2%), 99:22–24 (“Of particular interest is ONC-T18 which produces up to 90% of its C20 to C22 content as DHA which is approximately 35% of the total intracellular fatty acids.”). Thus, we are not persuaded that Radianingtyas discloses microbial oils produced by ONC-T18 that have a DHA content of “at least 45%.” As noted by Petitioner, Radianingtyas provides a definition of “purify” and “purifying,” and notes that when these terms are used, it means that a composition could be, for example, 90% pure. Pet. 11; Ex. 1007, 7:26–8:2. As an example of how the term “purified” may be used, Radianingtyas states “[f]or example, if a disclosed eukaryotic microorganism, for example, produces 35% DHA, this could be further ‘purified’ such that the final lipid composition was greater than 90% DHA.” Id. at 8:2–4. We are directed to no actual microbial oil in Radianingtyas, however, that was purified to have increased levels of DHA. Rather, Petitioner only proffers what Radianingtyas might say if such an oil existed or had been purified to increase levels of DHA.10” slip op. at 12

  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 10,757,959

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.