- Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show that claims 1–10 were likely obvious over the asserted combinations.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re 1 US 2013/0108922 A1, published May 2, 2013 (Ex. 1004, “Shinozaki”). 2 G. Khatibi, Temperature Dependent Elastic and Thermal Properties of Thin Copper Foils, Copper; Proceedings of the International Conference Copper ’06 (2006) (Ex. 1006, “Khatibi”). 3 Korean Patent Pub. No. 10-2012-0003485, published Jan. 10, 2012 (Ex. 1013; Ex. 1014 (English translation), “Toshio”). 4 US 2013/0108887 A1, published May 2, 2013 (Ex. 1012, “Kim”). 5 Griesi, M.B., Characterization of Electrodeposited Copper Foil Surface Roughness for Accurate Conductor Power Loss Modeling (2014) (Master’s Thesis, University of South Carolina) (Ex. 1015, “Griesi”). rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Not shown unpatentable
“For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE[6] value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added).” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner, however, does not adequately explain why a POSITA would have been motivated to modify Kim’s copper foil surface to have a Pc value of 19.2 as reported in Griesi. In particular, neither Petitioner nor Dr. Randall points us to, nor do we discern, any teaching in Griesi that a peak count of 19.2 provides any particular benefits or properties that would have lead a POSITA to modify Kim’s copper foil surface as Petitioner proposes. Instead, Petitioner’s arguments that a POSITA would have been motivated to modify Kim’s copper foil surface with Griesi’s peak count patent itself. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 421 (2007) (stating that the fact finder must be aware “of the distortion caused by hindsight bias and must be cautious of arguments reliant upon ex post reasoning”). It was Petitioner’s burden to establish that the combined teachings Kim and Griesi disclose limitation [1g] as proposed. We are not persuaded that we misapprehended Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 8
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish the Khatibi, alone or in combination with Shinozaki, Toshio, and Kim, discloses limitation [1d]. We concluded that Petitioner failed to meet that burden for the reasons explained in our Decision. We are not persuaded that we overlooked or misapprehended Khatibi’s disclosures, or Petitioner’s evidence and explanation thereof, in doing so.7” slip op. at 5
§ 103 obviousnesscites KSRPatents in suitUS 10,811,689 - Shenzhen Tuozhu Technology Co. Ltd. v. Stratasys, Inc.Institution deniedPTAB · Oct 6, 2025 · IPR2025-00585 · APJ Lilan Ren · IPR · Institution
The Board denied institution on claims 1–6, 10–19 because claim 1’s scope is ambiguous and the petition did not show a reasonable likelihood of prevailing on any asserted obviousness ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. See 35 U.S.C. § 314 (2024); 37 C.F.R. § 42.4(a) (2024). Institution of an inter partes review requires that “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that the scope of claim 1 is ambiguous and that there is not a reasonable likelihood that Petitioner will prevail with respect to at least one challenged claim, and we deny inter partes review.1” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownOther
“distinguishes and contrasts build material property from operational parameters. The diagnostic test passage therefore only describes a diagnostic test of the build material property but does not describe a subsequent diagnostic test to assess whether an operational parameter is suitable for the printer. Based solely on the diagnostic test passage and the prosecution history, a possible interpretation may be that the operational parameter determination in claim element 1b encompasses the diagnostic testing in claim element 1c. That is, “performing a diagnostic test to determine whether the operational parameter is suitable for the three-dimensional printer” in claim element 1c is subsumed as part of “determining an operational parameter of a fabrication process using the three-dimensional printer based upon the data, the operational parameter including at least one of a build platform temperature, a build volume temperature, an infill requirement, a rafting requirement, a support structure requirement, and a cooling requirement” in claim element 1b.” slip op. at 15
- Disclosure Requirements (§112) › Written description (Ariad)Not entitled to earlier dateOther
“benefit of the filing date of an earlier filed application only if the disclosure of the earlier application provides support for the claims of the later application, as required by 35 U.S.C. § 112.” PowerOasis, Inc. v. T-Mobile USA, Inc., 522 F.3d 1299, 1306 (Fed. Cir. 2008); see also Research Corps. Techs. v. Microsoft Corp., 627 F.3d 859, 871–72 (Fed. Cir. 2010) (holding that claims of the later-filed application, which were not limited to a “blue noise mask,” were “not entitled to claim the benefit of their parent applications’ filing dates”); ICU Med., Inc. v. Alaris Med. Sys., 558 F.3d 1368, 1377–78 (Fed. Cir. 2009) (holding that “spikeless” claims “added years later during prosecution” were not supported by the specification which “describe[d] only medical valves with spikes”); Tronzo v. Biomet, Inc., 156 F.3d 1154, 1158–60 (Fed. Cir. 1998) (holding the generic shaped cup claims of the later-filed child application were not entitled to the filing date of the parent application that “disclosed only a trapezoidal cup and nothing more”). “To satisfy the written description requirement the disclosure of the prior application must convey with reasonable clarity to those skilled in the art that, as of the filing date sought, [the inventor] was in possession of the invention.” PowerOasis, 522 F.3d at 1306 (emphasis omitted; alteration in original). The sufficiency of written description support is based on “an objective inquiry into the four corners of the specification from the perspective of a person of ordinary skill in the art.” Ariad Pharm., Inc. v. Eli Lilly & Co., 598 F.3d 1336, 1351 (Fed. Cir. 2010) (en banc).” slip op. at 20
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person of ordinary skill in the art in the field in the relevant time frame would have had “(1) at least a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a related field, and (2) at least two years of research or industry experience in 3D printing or materials used for 3D printing.” Pet. 5 (citing Ex. 1003 ¶ 20). Petitioner also contends that “[a]dditional experience could substitute for a formal degree or formal training (and vice versa).” Id. (citing the same). Patent Owner contends that an ordinarily skilled artisan “would have had a bachelor’s degree in Mechanical Engineering, Computer Engineering, Electrical Engineering, Chemical Engineering, Materials Science, or a comparable field and at least two years of experience related to 3D printing, with additional experience potentially being a substitute for a formal degree or training (and vice versa).” Prelim. Resp. 12. For purposes of this decision, we adopt Petitioner’s definition of the level of ordinary skill in the art as it appears unopposed and consistent with the disclosures of the ’464 patent and the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 9
Claim construction§ 112 disclosurecites Phillips · KSR · GrahamPatents in suitUS 11,167,464 - Alliance Laundry Systems, LLC v. Payrange LLCInstitution deniedPTAB · Oct 1, 2025 · IPR2025-00573 · APJ Meredith C Petravick · IPR · Institution
The Board denied institution because the Petition did not show a reasonable likelihood that claims 7 or 11 were unpatentable under the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Under 35 U.S.C. § 314(a), an inter partes review may not be instituted unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” After considering the Petition, the Preliminary Response, and the evidence of record, we determine the information presented fails to show a reasonable likelihood that Petitioner would prevail in establishing the unpatentability of at least one of the challenged claims of the ’772 patent. Accordingly, we do not institute an inter partes review of claims 7 and 11 of the ’772 patent on the grounds asserted in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends a person having ordinary skill in the art (“POSA”) pertaining to the ’772 patent “would have had an educational background of, engineering, computer engineering, computer science, or equivalent training, and approximately three years of experience with electronic payment systems, vending machine technologies, or distributed network systems.” Pet. 19–20; Ex. 1003 ¶¶ 20–26. “Lack of work experience can be remedied by additional education, and vice versa.” Pet. 20; Ex. 1003 ¶ 22. Patent Owner does not oppose Petitioner’s formulation of ordinary skill. See Prelim. Resp. generally. On this record, we adopt Petitioner’s assessment of the level of ordinary skill in the art as it is consistent with the ’772 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“In this inter partes review, we apply the same claim construction standard that would be used in a civil action under 35 U.S.C. § 282(b). 37 C.F.R. § 42.100(b). In applying this standard, we generally give claim terms their ordinary and customary meaning as would be understood by a person of ordinary skill in the art at the time of the invention and in the context of the entire patent disclosure. See id.; Phillips v. AWH Corp., 415 F.3d 1303, 1312–14 (Fed. Cir. 2005) (en banc). We do not need to construe any terms expressly to determine whether or not to institute a trial. See Realtime Data LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,481,772 - Microsoft Corporation v. Edge Networking Systems, LLCInstitution deniedPTAB · Sep 30, 2025 · IPR2025-00619 · APJ Jason M Repko · IPR · Institution
The Board denied institution because Microsoft did not show a reasonable likelihood of proving claims 1, 2, 4–7, and 9 obvious over Vasell, Alves, Hall, and Rellermeyer.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“To institute an inter partes review, we must determine “that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons discussed below, Petitioner has not shown a reasonable likelihood that it would prevail with respect to any claim challenged in the Petition. Thus, we do not institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“[Persons of ordinary skill in the art (“POSITAs”)] as of June 2013 would have had a bachelor’s degree in computer science, computer engineering, or equivalent degree, and approximately three years of experience working in the computer science or engineering field. Additional experience might substitute for less education and vice versa. To that end, POSITAs in June 2013 would have been knowledgeable about the design and management of networked systems and virtualization technologies, and familiar with operating/distributed systems and security and privacy techniques. Pet. 15 (citing Ex. 1003 ¶ 58).4 Patent Owner does not contest this in its Preliminary Response. Prelim. Resp. 36–37. We apply Petitioner’s definition of the level of ordinary skill in the art here.” slip op. at 5
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
“Petitioner has not sufficiently explained how the combination of Vasell, Alves, Hall, and Rellermeyer teaches or suggests a programmable network device and a programmable cloud device that are each “powered by a sandboxing operating system,” as required by all challenged claims. Our reasoning follows.” slip op. at 10
§ 103 obviousnessPatents in suitUS 10,686,871 - Microsoft Corporation v. Edge Networking Systems, LLCInstitution deniedPTAB · Sep 30, 2025 · IPR2025-00617 · APJ Jason M Repko · IPR · Institution
The Board denied institution because Microsoft did not show a reasonable likelihood of proving claims 1, 2, 6–8, 10–13, and 15 obvious over Vasell, Alves, Hall, and Rellermeyer.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“To institute an inter partes review, we must determine “that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons discussed below, Petitioner has not shown a reasonable likelihood that it would prevail with respect to any claim challenged in the Petition. Thus, we do not institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“[Persons of ordinary skill in the art (“POSITAs”)] as of June 2013 would have had a bachelor’s degree in computer science, computer engineering, or equivalent degree, and approximately three years of experience working in the computer science or engineering field. Additional experience might substitute for less education and vice versa. To that end, POSITAs in June 2013 would have been knowledgeable about the design and management of networked systems and virtualization technologies, and familiar with operating/distributed systems and security and privacy techniques. Pet. 14 (citing Ex. 1003 ¶ 59).4 Patent Owner does not contest this in its Preliminary Response. Prelim. Resp. 39. We apply Petitioner’s definition of the level of ordinary skill in the art here. 2 Congress amended § 103 when it passed the Leahy-Smith America Invents Act (AIA). Pub. L. No. 112–29, § 3(c), 125 Stat. 284, 287 (2011). Petitioner asserts that the version amended by the AIA applies here. Pet. 23. 3 We use Petitioner’s nomenclature in which Petitioner collectively refers to the Vasell patent (Ex. 1004) and its corresponding provisional applications (Exs. 1015, 1016) as “Vasell.” 4 Erez Zadok, Ph.D. submitted a declaration on behalf of Petitioner. See Ex. 1003.” slip op. at 5
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
“Petitioner has not sufficiently explained how the combination of Vasell, Alves, Hall, and Rellermeyer teaches or suggests a programmable network device and a programmable cloud device that are each “powered by a sandboxing operating system,” as required by all challenged claims. Our reasoning follows.” slip op. at 10
- BurdenNot shown unpatentable
“Petitioner has not sufficiently explained how the combination of Vasell, Alves, Hall, and Rellermeyer teaches or suggests a programmable network device and a programmable cloud device that are each “powered by a sandboxing operating system,” as required by all challenged claims. Our reasoning follows.” slip op. at 10
§ 103 obviousnessPatents in suitUS 10,893,095 - Røde Microphones, LLC / Freedman Electronics Pty Ltd. v. Zaxcom, Inc.Institution deniedPTAB · Sep 30, 2025 · IPR2025-00557 · APJ Justin T Arbes · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that the challenged claims were unpatentable over the asserted obviousness combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Based on the record before us, Petitioner has not shown sufficiently that Strub teaches or suggests “a remote receiver, the remote receiver configured to create at least one master timecode and to receive audio data,” as recited in claim 1. Accordingly, Petitioner has not shown a reasonable likelihood of prevailing on its assertion that claim 1 is unpatentable over Strub and Woo.” slip op. at 26
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“We agree with Patent Owner that the “master timecode generator” produces a signal that “controls” another timecode generator. See Prelim. Resp. 19 (citing a dictionary definition of “master” as “[one] that has control over another or others,” Ex. 2019, 3). We see no basis, however, to limit the claim term to a particular type of control. Patent Owner points to Figure 6 of the ’444 patent where “the master timecode generator creates master timecodes that are used to control the speed of the local timecode generator to ensure the two timecode generators are synchronized.” See Prelim. Resp. 19‒20 (citing Ex. 1001, col. 17, ll. 9‒16, Fig. 6). But Figure 6 merely depicts an exemplary “process for recording audio and for replaying and re-recording segments of missed audio in accordance with one embodiment of the present invention.” See Ex. 1001, col. 3, ll. 15‒17. Further, the Specification describes the exemplary embodiment of Figure 6 as a master unit providing master timecodes to a local audio device, which “synchronizes (e.g., jam syncs) its respective on board local timecode generator with the master timecodes,” but does not specify exactly how the master unit exercises control. Id. at col. 17, ll. 9‒17. Thus, we do not include any particular control mechanism (e.g., changing the speed of the local timecode generator) in our interpretation at this time. Based on the record presented, we interpret “master timecode generator” as “a producer of a master time reference signal that controls at least one other timecode generator” and “master timecode” as “a time reference signal used to synchronize at least one device.”” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableNot shown unpatentable
“We agree with Patent Owner that Petitioner has not sufficiently shown that Strub teaches or suggests limitation 1[A]. Petitioner relies on Strub’s disclosure of a “master” recording unit as the claimed “remote receiver.” Pet. 34 (citing Ex. 1003, col. 38, ll. 29‒39). The cited portion of Strub is reproduced below: Data other than recording data can also be exchanged between recording units. For example, it may be desirable to coordinate the recordings obtained by recording units so that frames of visual recording data obtained by different recording units are temporally synchronized (e.g., so that a frame begins at the same time for each recording unit). This can be done by transmitting a synchronization pulse from a “master” recording unit to each of the other recording units (“slave” recording units). (Synchronizing analog visual data acquisition devices in this way is referred to as “genlocking.”) Ex. 1003, col. 38, ll. 29‒39. As argued by Patent Owner (see Prelim. Resp. 36), the cited procedure involves synchronizing frames of visual recording data, not audio recording data. Petitioner has not disputed Patent Owner’s assertions that the described “genlocking” technique is a video synchronization technique that does not apply to or affect the synchronization of system clocks or audio timestamps and has no bearing on audio synchronization. Nor does Petitioner explain in the Petition or the Preliminary Reply how or why an ordinarily skilled artisan would have applied this teaching to audio data recorded by an audio device. Petitioner cites this visual recording data synchronization passage as a solution to a problem that Strub identifies in clocks not being adequately synchronized to enable use of time-stamps associated with recordings to be used to synchronize the recordings. See Prelim. Reply 1‒2 (citing Ex. 1003, col. 38, ll. 29‒37, col. 79, l. 63‒col. 80, l. 2). However, immediately following the cited portion that identifies this problem, Strub further explains that “[i]f recording units according to the invention each include a GPS receiver, such mis-synchronization will only exist to an appreciable degree if one or more recording units are shielded from a GPS transmitter system for an extended period of time, e.g., several hours.” Ex. 1003, col. 80, ll. 2–27. Thus, Strub suggests that the solution to this problem is for the recording units to receive their timecodes not from a master recording unit, as argued by Petitioner, but from a GPS satellite.4 Petitioner does not address this teaching.” slip op. at 22
- BurdenNot shown unpatentable
“We agree with Patent Owner that the Petition does not rely on Woo as teaching or suggesting limitation 1[A]; Petitioner relies solely on the teachings of Strub. See Pet. 33–35 (arguing that “Strub teaches this element”). Petitioner references Strub’s teachings as being “consistent with and reinforced by the Woo reference” in the Preliminary Reply (Prelim. Reply 2), but this is not sufficient to rely on Woo, alone or in combination with Strub, as teaching this limitation. We also agree that the Lectrosonics IPRs’ findings regarding Woo teaching the “master timecode generator” limitation recited in those challenged claims are inapplicable here, where claim 1 recites additional limitations not present in those challenged claims. Compare Ex. 1001, col. 43, ll. 26‒27 (claim 1 of the ’444 patent: “a remote receiver, the remote receiver configured to create at least one master timecode and to receive audio data”) with Ex. 1028, col. 23, ll. 20‒21 (claim 1 of the ’814 patent: “at least one master timecode generator for generating a plurality of master timecodes”) and Ex. 1030, col. 23, ll. 38‒39 (claim 1 of the ’902 patent: “at least one master timecode generator for generating a plurality of master timecodes”). Based on the record before us, Petitioner has not shown sufficiently that Strub teaches or suggests “a remote receiver, the remote receiver configured to create at least one master timecode and to receive audio data,” as recited in claim 1. Accordingly, Petitioner has not shown a reasonable likelihood of prevailing on its assertion that claim 1 is unpatentable over Strub and Woo.” slip op. at 26
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 12,051,444 - Skullcandy, Inc. v. Earin ABInstitution deniedPTAB · Sep 15, 2025 · IPR2025-00690 · APJ Monica S Ullagaddi · IPR · Director review
The Board denied institution because the petition did not show a reasonable likelihood that claims 20 and 21 were unpatentable on any asserted obviousness ground.
RulingsDirector review decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Having considered the parties’ arguments and the evidence of record, we determine that, for the reasons discussed herein, Petitioner does not demonstrate a reasonable likelihood that it would prevail with respect to at least one of the challenged claims. We thus decline to institute an inter partes review on all challenged claims on all asserted grounds. See SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1354, 1359–60 (2018).” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“may be considered, including the “type of problems encountered in the art; prior art solutions to those problems; rapidity with which innovations are made; sophistication of the technology; and educational level of active workers in the field.” In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995) (citing Custom Accessories, Inc. v. Jeffrey–Allan Indus., Inc., 807 F.2d 955, 962 (Fed.Cir.1986)).” slip op. at 7
- BurdenNot shown unpatentable
“Analysis of the Parties’ Contentions We agree with Patent Owner that the Petition is conclusory––the Cooperstock Declaration merely reiterates the position set forth in the Petition and does not provide sufficient detail or explanation of why Olodort’s “low power state” would have been understood by a POSITA to mean that “existing connections to a second wireless earbud and to a wireless audio streaming host device will be disconnected,” as recited in claim 20. 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); see Pet. 23–24; Ex. 1007 ¶¶ 84–87. We further agree that claim 38 is not directed to entering “a standby mode” as it recites “the low power state is a standby mode from which the second earpiece is awakened in response to detecting that the second earpiece has been attached to an ear.” Ex. 1002, claim 38 (emphasis added). As such, we agree with Patent Owner that Olodort’s “claim 38 contains no disclosure concerning what happens to ‘existing connections’ when exiting, let alone entering, the ‘standby mode.’” See Prelim. Resp. 9 (citing Ex. 1002, claims 32, 34, 38). We further agree with Patent Owner that the Cooperstock Declaration in paragraphs 86 and 87 sets forth an alternative obviousness theory “based on a modification to Olodort to add ‘circuitry for disconnecting the earbuds from one another and from any wireless audio streaming host device when in the low power state’” that is improperly incorporated by reference into the Petition. Prelim. Resp. 10–11 (emphasis added) (citing 35 U.S.C. § 312(a)(3) (A petition for inter partes review “may be considered only if . . . the petition identifies, in writing and with particularity . . . the evidence that supports the grounds for challenged to each claim.”); 37 C.F.R. § 42.104(b)(4) (“The petition must specify where each element of the claim is found in the prior art patents or printed publications relied upon.”); 37 C.F.R. § 42.6(a)(3) (“Arguments must not be incorporated by reference from one document into another.”)). As such, we need not and do not consider this alternative obviousness theory.” slip op. at 18
- Expert testimonyDecided for patent owner
“Analysis of the Parties’ Contentions We agree with Patent Owner that the Petition is conclusory––the Cooperstock Declaration merely reiterates the position set forth in the Petition and does not provide sufficient detail or explanation of why Olodort’s “low power state” would have been understood by a POSITA to mean that “existing connections to a second wireless earbud and to a wireless audio streaming host device will be disconnected,” as recited in claim 20. 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); see Pet. 23–24; Ex. 1007 ¶¶ 84–87. We further agree that claim 38 is not directed to entering “a standby mode” as it recites “the low power state is a standby mode from which the second earpiece is awakened in response to detecting that the second earpiece has been attached to an ear.” Ex. 1002, claim 38 (emphasis added). As such, we agree with Patent Owner that Olodort’s “claim 38 contains no disclosure concerning what happens to ‘existing connections’ when exiting, let alone entering, the ‘standby mode.’” See Prelim. Resp. 9 (citing Ex. 1002, claims 32, 34, 38). We further agree with Patent Owner that the Cooperstock Declaration in paragraphs 86 and 87 sets forth an alternative obviousness theory “based on a modification to Olodort to add ‘circuitry for disconnecting the earbuds from one another and from any wireless audio streaming host device when in the low power state’” that is improperly incorporated by reference into the Petition. Prelim. Resp. 10–11 (emphasis added) (citing 35 U.S.C. § 312(a)(3) (A petition for inter partes review “may be considered only if . . . the petition identifies, in writing and with particularity . . . the evidence that supports the grounds for challenged to each claim.”); 37 C.F.R. § 42.104(b)(4) (“The petition must specify where each element of the claim is found in the prior art patents or printed publications relied upon.”); 37 C.F.R. § 42.6(a)(3) (“Arguments must not be incorporated by reference from one document into another.”)). As such, we need not and do not consider this alternative obviousness theory.” slip op. at 18
§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,402,120 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Sep 15, 2025 · IPR2025-00005 · APJ John G New · IPR · Rehearing
Denied Solus’s rehearing request; the Board maintained its denial of institution because the petition did not show a reasonable likelihood of prevailing on the challenged claims.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“[O]f the 44 specimens tested by Ye, as revealed in Ye’s Table II, only a single specimen, specimen 15, meets the required TC ratios recited in challenged claim 1 of the ’541 patent. Furthermore, none of the references cited by Petitioner teach, or even remotely suggest, the four requisite TC ratios recited by challenged claim 1. We find Petitioner’s argument that a person of ordinary skill in the art would have been motivated to exclusively select Ye’s sample 15, out of the remaining 43, to which to apply the teachings of Hara and Otsuka concerning the requisite tensile strength and weight deviation ranges in the hope of arriving at the claimed invention, is implausible. Indeed, only the ’541 patent, among all of the evidence of record, that actually mentions the required texture coefficient ratios recited in challenged claim 1. Petitioner provides no convincing argument as to why a skilled artisan would have selected sample 15 for combination with Hara and Otsuka.” slip op. at 10
- Expert testimonyPetitioner expert discountedDecided for patent owner
“At the heart of this flaw is Petitioner’s argument, and Dr. Josefowicz’s opinion, that it would have been conventional in the art at the time of filing to vary the electrolyte concentration, electrolysis plating parameters, temperature, and the use of organic and inorganic additives, in order to obtain a copper foil with tensile strength and elongation values falling within the claimed ranges as these ranges were well known, at least since 1974. Ex. 1003 ¶ 63. This statement is largely unsupported by evidence of record, with the sole exception of Table 2 of Lowenheim, which, as Patent Owner points out, provides tensile strengths well outside the claimed range. Petitioner provides insufficient guidance as to how a person of ordinary skill in the art would have known which parameters to vary, or how to vary them, to provide the foil of Hirose with a tensile strength or weight deviation within the claimed range. Dr. Josefowicz’s statement that this would result from routine optimization, and was “conventional” may or may not be true, but it is insufficiently supported by evidence of record to be persuasive.” slip op. at 6
§ 103 obviousnessPatents in suitUS 9,457,541 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Sep 15, 2025 · IPR2025-00005 · APJ John G New · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show a reasonable likelihood of prevailing on claims 1-4.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“In summary, we again conclude that Petitioner has failed to provide sufficient evidence to demonstrate that a person of ordinary skill in the art would have had a reasonable expectation of success in combining the cited prior art references, in combination with Dr. Josefowicz’s relatively unsupported testimony concerning a skilled artisan’s ability to optimize various constituents and conditions, to arrive at the claimed invention. Petitioner has not pointed to any argument or unconsidered evidence of record that is sufficient to show that, in reaching its conclusion, the Board abused its discretion by basing its Decision on an erroneous interpretation of law, a factual finding not supported by substantial evidence, or an unreasonable judgment in weighing relevant factors. Arnold, 362 F.3d at 1340.” slip op. at 8
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“teaches the tensile strengths of various types of copper-electroplated steel electrical cable wire of different properties, including high strength, hardness, low electrical resistivity, near zero strength, good leveling, and thermal stability, some of which fall within the claimed range of tensile strength of 30 to 40 kgf/mm2. Lowenheim, 196, Table II. However, none of these categories correspond to those copper foil properties recited in the claims, and Dr. Josefowicz’s testimony provides little guidance as to how a person of ordinary skill in the art would have known how to optimize the recited properties, and particularly so in combination with the teachings of Hirose and the other cited prior art references. Furthermore, as we noted in our Decision:” slip op. at 7
- Expert testimonyPetitioner expert discountedDecided for patent owner
“At the heart of this flaw is Petitioner’s argument, and Dr. Josefowicz’s opinion, that it would have been conventional in the art at the time of filing to vary the electrolyte concentration, electrolysis plating parameters, temperature, and the use of organic and inorganic additives, in order to obtain a copper foil with tensile strength and elongation values falling within the claimed ranges as these ranges were well known, at least since 1974. Ex. 1003 ¶ 63. This statement is largely unsupported by evidence of record, with the sole exception of Table 2 of Lowenheim, which, as Patent Owner points out, provides tensile strengths well outside the claimed range. Petitioner provides insufficient guidance as to how a person of ordinary skill in the art would have known which parameters to vary, or how to vary them, to provide the foil of Hirose with a tensile strength or weight deviation within the claimed range. Dr. Josefowicz’s statement that this would result from routine optimization, and was “conventional” may or may not be true, but it is insufficiently supported by evidence of record to be persuasive. Id. (emphasis added) (footnote omitted).” slip op. at 6
§ 103 obviousnessPatents in suitUS 9,457,541 - Lifevac, LLC v. Dcstar Inc.Institution deniedPTAB · Sep 8, 2025 · IPR2025-00454 · APJ Cynthia M Hardman · IPR · Institution
The Board denied institution on claims 1–17 because Petitioner did not show a reasonable likelihood that Zhongnan qualifies as prior art under the § 102(b)(1)(B) exception.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“to show with particularity why the patent it challenges is unpatentable.” Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1363 (Fed. Cir. 2016) (citing 35 U.S.C. § 312(a)(3) (requiring inter partes review petitions to identify “with particularity . . . the evidence that supports the grounds for the challenge to each claim”)). Petitioner ultimately bears the burden of persuasion to prove unpatentability of each challenged claim by a preponderance of the evidence. 35 U.S.C. § 316(e). This burden never shifts to Patent Owner. See Dynamic Drinkware, LLC v. Nat’l Graphics, Inc., 800 F.3d 1375, 1378 (Fed. Cir. 2015). The Board may authorize inter partes review if we determine that the information presented in the Petition and Patent Owner’s Preliminary Response shows a reasonable likelihood that Petitioner will prevail with respect to at least one of the claims challenged in the petition. 35 U.S.C. § 314(a).” slip op. at 8
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportReference not prior artDecided for patent owner
“provides that a disclosure which would otherwise qualify as prior art under AIA 35 U.S.C. 102(a)(1) (patent, printed publication, public use, sale, or other means of public availability) is excepted as prior art if: (1) the disclosure was made one year or less before the effective filing date of the claimed invention; and (2) the subject matter disclosed had been previously publicly disclosed by the inventor, a joint inventor, or another who obtained the subject matter directly or indirectly from the inventor or joint inventor. MPEP § 2153.02 (9th ed. rev. 01.2024 Nov. 2024); see also Sanho, 108 F.4th at 1381. As to point (1), there is no dispute that Zhongnan was published one year or less before the effective filing date of the challenged claims. See, e.g., Ex. 1005, code (43); Pet. 11, 20; Prelim. Resp. 9–10. Thus, we focus on point (2), which requires that IDEAR be previously publicly disclosed by the inventor, and that Zhongnan and IDEAR disclose the same subject matter.” slip op. at 10
- BurdenDecided for patent owner
“Our rules require that in determining whether to institute inter partes review, we “take into account a patent owner preliminary response where such a response is filed, including any testimonial evidence.” 37 C.F.R. § 42.108(c) (emphasis added); Prelim. Sur-reply 3. As Patent Owner correctly notes, “the Board routinely weighs declaratory testimony at the institution[] stage and virtually always makes institution decisions without the benefit of cross-examination.” Prelim. Resp. 19–20 (emphasis omitted) (citing LG Elecs. Inc. v. Wi-LAN Inc., IPR2018-00704, Paper 14 at 13–14 (PTAB 2018); Freebit AS v. Bose Corp., IPR2017-01308, Paper 8 at 28 (PTAB 2017)). For example, in LG Electronics and Freebit, the Board denied institution, finding that the patent owner had provided sufficient evidence to antedate the petitioners’ proffered prior art references. See LG Elecs., IPR2018-00704, Paper 14 at 7; Freebit, IPR2017-01308, Paper 8 at 25, 34.10” slip op. at 23
§ 102 anticipationPatents in suitUS 11,478,575
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.