- Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Solus’s rehearing request, leaving institution denied for claims 1–8 because the petition did not adequately show motivation to combine Hanafusa and Dobashi.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve Dobashi’s RSm values. Dobashi teaches that because RSm “can be adopted as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66–3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66– 3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 4
§ 103 obviousnessPatents in suitUS 11,346,014 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show that claims 1–10 were likely obvious over the asserted combinations.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re 1 US 2013/0108922 A1, published May 2, 2013 (Ex. 1004, “Shinozaki”). 2 G. Khatibi, Temperature Dependent Elastic and Thermal Properties of Thin Copper Foils, Copper; Proceedings of the International Conference Copper ’06 (2006) (Ex. 1006, “Khatibi”). 3 Korean Patent Pub. No. 10-2012-0003485, published Jan. 10, 2012 (Ex. 1013; Ex. 1014 (English translation), “Toshio”). 4 US 2013/0108887 A1, published May 2, 2013 (Ex. 1012, “Kim”). 5 Griesi, M.B., Characterization of Electrodeposited Copper Foil Surface Roughness for Accurate Conductor Power Loss Modeling (2014) (Master’s Thesis, University of South Carolina) (Ex. 1015, “Griesi”). rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Not shown unpatentable
“For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE[6] value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added).” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner, however, does not adequately explain why a POSITA would have been motivated to modify Kim’s copper foil surface to have a Pc value of 19.2 as reported in Griesi. In particular, neither Petitioner nor Dr. Randall points us to, nor do we discern, any teaching in Griesi that a peak count of 19.2 provides any particular benefits or properties that would have lead a POSITA to modify Kim’s copper foil surface as Petitioner proposes. Instead, Petitioner’s arguments that a POSITA would have been motivated to modify Kim’s copper foil surface with Griesi’s peak count patent itself. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 421 (2007) (stating that the fact finder must be aware “of the distortion caused by hindsight bias and must be cautious of arguments reliant upon ex post reasoning”). It was Petitioner’s burden to establish that the combined teachings Kim and Griesi disclose limitation [1g] as proposed. We are not persuaded that we misapprehended Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 8
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish the Khatibi, alone or in combination with Shinozaki, Toshio, and Kim, discloses limitation [1d]. We concluded that Petitioner failed to meet that burden for the reasons explained in our Decision. We are not persuaded that we overlooked or misapprehended Khatibi’s disclosures, or Petitioner’s evidence and explanation thereof, in doing so.7” slip op. at 5
§ 103 obviousnesscites KSRPatents in suitUS 10,811,689 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 25, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–8 were unpatentable under the asserted obviousness grounds.
RulingsInstitution decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“experience working on the development of materials or components for electronic devices such as batteries.” Pet. 2. Petitioner further contends that “[a]dditional education, such as a graduate degree, could compensate for less work experience, and additional work experience could compensate for less formal education.” Id. Patent Owner states that, “[f]or purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art.” Prelim. Resp. 4. For purposes of this Decision, we adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’014 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” 37 C.F.R. § 42.100(b). Under this standard, claim terms are generally given their plain and ordinary meaning as would have been understood by a person of ordinary skill in the art at the time of the invention and in the context of the entire patent disclosure. Phillips v. AWH Corp., 415 F.3d 1303, 1313 (Fed. Cir. 2005) (en banc). Only those terms in controversy need to be construed, and only to the extent necessary to resolve the controversy. Realtime Data LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019). in this proceeding.” Pet. 3. Patent Owner contends that “[t]he Board need not construe any term in order to determine that institution should be denied.” Prelim. Resp. 4. Based on the record before us, we determine that no claim term requires express construction for purposes of this Decision. See Realtime Data, 912 F.3d at 1375.” slip op. at 8
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“For these reasons, we are not persuaded that Petitioner sufficiently establishes that a POSITA would have been motivated to modify Hanafusa in light of Dobashi with a reasonable expectation of success as Petitioner contends. Accordingly, we determine that Petitioner fails to demonstrate a reasonable likelihood of prevailing in its assertion that the subject matter of claim 1, and claims 4 and 8 that depend therefrom, would have been obvious over the combined teachings of Hanafusa and Dobashi.” slip op. at 18
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“Petitioner also focuses on Hanafusa’s teaching that all known methods can be used to make a rough surface low-profile, and Dobashi’s teaching that RSm can be used as an indicator for judgment of the surface, to support its contention that a POSITA would have been motivated to apply Dobashi’s RSm to further achieve Hanafusa’s purpose, without explaining how and why that would be the case. In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness and is rough when RSm is small.” Id. at 3:1–3, 6:27–29. Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66– 3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66–3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 14
Claim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 11,346,014 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 23, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–10 were unpatentable over either asserted § 103 ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314 (2018); see also 37 C.F.R. § 42.4 (2023). For the reasons discussed below, we deny the Petition and do not institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“II. ANALYSIS A. Level of Ordinary Skill in the Art Petitioner contends that a person of ordinary skill in the art (“POSITA”) “would have had at least an undergraduate degree in materials science, chemical engineering, electrical engineering, or related field, or equivalent knowledge, training, or experience, with at least two years of experience working on the development of materials or components for electronic devices such as batteries.” Pet. 4. Petitioner further contends that “[a]dditional education, such as a graduate degree, could compensate for less 7 We refer to the page numbers added by Petitioner to the bottom-center of the page. formal education.” Id. (citing Ex. 1003 ¶ 10). Patent Owner states that, “[f]or purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art.” Prelim. Resp. 4. For purposes of this Decision, we adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’689 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163–64 (Fed. Cir. 1985))).” slip op. at 10
- Expert testimonyPetitioner expert discountedDecided for patent owner
“We are not persuaded, on this record, that Petitioner adequately establishes that Khatibi discloses a CTE in the claimed range of 16 to 22 µm/(m·°C.). Petitioner’s argument that Khatibi’s reported values meet this claim limitation are based solely on Dr. Randall’s testimony that Khatibi’s measurement method would produce results that would not significantly differ from results determined using the claimed method. See Pet. 16–18 (citing Ex. 1003 ¶¶ 56–60). Dr. Randall’s testimony, however, is largely conclusory and unsupported by adequate explanation and/or objective evidence. For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added). to little weight. See 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); Xerox Corp. v. Bytemark, Inc., IPR2022-00624, Paper 12 at 5 (PTAB Feb. 10, 2023) (finding that “the Board was correct in giving little weight to Petitioner’s expert because the expert declaration merely offered conclusory assertions without underlying factual support”); Upjohn Co. v. Mova Pharm. Corp., 225 F.3d 1306, 1311 (Fed. Cir. 2000) (“Lack of factual support for expert opinion to factual determinations, however, may render the testimony of little probative value in a validity determination.” (quoting Ashland Oil, Inc. v. Delta Resins and Refractories, Inc., 776 F.2d 281, 294 (Fed. Cir. 1985))); see also In re Ethicon, Inc., 844 F.3d 1344, 1348, 1352 (Fed. Cir. 2017) (concluding that the Board properly gave “little weight” to conclusory expert testimony of objective indicia). Because Petitioner offers Dr. Randall’s testimony to supply a limitation missing from the prior art, namely, the CTE measurement method, and we give Dr. Randall’s unsupported and conclusory testimony little weight, we are not persuaded that Petitioner establishes a reasonable likelihood of showing that Khatibi discloses limitation [1d].” slip op. at 17
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“second surfaces of the electrolytic copper foil ranges from 3 to 92.” Ex. 1001, 13:62–63. Petitioner contends that “Kim teaches that the electrolytic copper foil (e.g., untreated or treated copper foil) having Rz less than 2 µm is advantageous toward battery efficiency and performance,” and, similarly, Griesi describes the use of untreated electrolytic copper foil with an Rz value less than 2 µm in printed circuit boards that are compatible with secondary batteries. Pet. 58–59 (citing Ex. 1012, claim 2, ¶¶ 13, 25, 27; Ex. 1003 ¶ 157). In particular, Petitioner notes that Griesi’s Figure 3.16 describes an “Rz value of 1.2 µm.” Id. at 59 (citing Ex. 1015, 53–54; Ex. 1003 ¶ 158). Petitioner asserts that “Dr. Randall explains that a POSITA would have also recognized another surface roughness-related parameter, Rpc, in Griesi as a potentially useful parameter that can be optimized to further enhance uniformity or generally improve Kim’s copper foil surface, for example, to prevent wrinkles or achieve other advantageous effects.” Id. (citing Ex. 1003 ¶ 159). Although Dr. Randall demonstrates that Griesi’s Pc (or Rpc) value is 19.2 over a 4 mm sampling length (Ex. 1003 ¶ 155), Petitioner does not contend that Griesi addresses this value, or indicates any benefit that might be derived from its use. Instead, Griesi’s Pc value appears to be an incidental finding, which is not discussed or analyzed in the reference. See incidental, unexamined finding would lead a POSITA to import Griesi’s Pc value into Kim’s copper foil, absent a hindsight desire to reconstruct the claimed invention. As such, Petitioner’s arguments with respect to Kim and Griesi are not persuasive. See Cheese Sys. Inc. v. Tetra Pak Cheese and Powder Sys., Inc., 725 F.3d 1341, 1352 (Fed. Cir. 2013) (“Obviousness cannot be based on the hindsight combination of components selectively culled from the prior art to fit the parameters of the patented invention.” (internal quotations marks omitted)). Thus, we are not persuaded, on this record, that the combined disclosures of Kim and Griesi teach all of the elements of limitation [1g].” slip op. at 23
§ 103 obviousnesscites PhillipsPatents in suitUS 10,811,689 - Ewald Dörken AG v. Schaeffler Technology AG & Co. KG.Institution deniedPTAB · Feb 20, 2025 · IPR2024-01365 · APJ James J Mayberry · IPR · Institution
The Board denied institution on all three obviousness grounds because the Petition did not show a reasonable likelihood of prevailing on claims 1–7.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2024) (permitting the Board to institute trial on behalf of the Director). To institute an inter partes review, we must determine that the information presented in the Petition shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we do not institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“the prior art and the claimed invention. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). Petitioner contends that “[a] person having ordinary skill in the art (‘POSITA’) would have been a person having, as of 21 July 2017: (1) at least an undergraduate degree in engineering and/or material science, or similar education; and (2) two or more years of experience with coatings.” Pet. 7–8; see Ex. 1009 ¶ 25 (providing the same level of ordinary skill). Patent Owner does not dispute Petitioner’s level of ordinary skill in the art. Prelim. Resp. 5. We apply Petitioner’s definition of the level of ordinary skill in the art. We determine that this definition is consistent with the prior art of record and the skill reflected in the Specification of the ’756 patent, based on our review of the record.” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Plain and ordinary meaningNo construction neededOther
“Petitioner submits that . . . the claims should be given their plain and ordinary meaning.” Pet. 11. Patent Owner does not propose any specific constructions. See Prelim. Resp. 4–5.8 We determine that we need not expressly construe any other claim terms to resolve the parties’ disputes on the current record. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms that . . . are in controversy, and only to the extent necessary to resolve the controversy.’” (emphasis added)) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). To the extent that the scope of any other claim term requires discussion, however, we provide it in our assessment of the challenges, which we turn to next. slip op. at 11
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“Ex. 1003 ¶¶ 18–19. Petitioner provides no additional discussion on this disclosure, including how it satisfies the zinc flake coating limitation. See Pet. 15–17, 20. Petitioner’s sole citation to Dr. Haber’s declaration associated with this claim limitation is to paragraph 35, which provides the same claim chart as is in the Petition. See Pet. 17; Ex. 1009 ¶ 35.” slip op. at 12
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,098,756 - Vusiongroup SA v. Hanshow Technology Co., Ltd.Institution deniedPTAB · Jan 14, 2025 · IPR2024-01045 · APJ Patrick R Scanlon · IPR · Institution
The Board denied institution on all challenged claims because the Petition did not show a reasonable likelihood of prevailing on any of its four § 103 grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“We have authority to determine whether to institute an inter partes review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). To institute an inter partes review, we must determine that the information presented in the Petition shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that Petitioner has not demonstrated a reasonable likelihood that it would prevail with respect to at least one challenged claim. Accordingly, we do not institute an inter partes review of the challenged claims on the grounds set forth in the Petition.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableNot shown unpatentable
“We agree with Patent Owner. At best, Schwartz’s disclosure cited by Petitioner teaches aggregating product information obtained from different stores, but neither the Petition nor Dr. Wolfe explains sufficiently how aggregating product information would have suggested cross-correlating different product facing bounding boxes to one of ordinary skill in the art. See Pet. 35–37; Ex. 1003 ¶¶ 148–151. We are not persuaded that aggregating product information and cross-correlating different product facing bounding boxes would have been recognized as similar or comparable processes. Moreover, Petitioner does not even assert that one of ordinary skill in the art would have recognized that Schwartz cross-correlates one or more product facing bounding boxes and one or more other product facing bounding boxes as required by limitation [1.5]. Instead, Petitioner asserts only that one of ordinary skill in the art “would have recognized Schwartz . . . cross-correlates that product and affiliated shelf added). Furthermore, limitation [1.5] recites cross-correlating different product facing bounding boxes by matching shelf label content of the different product facing bounding boxes. But Petitioner does not explain adequately how the combination of Schwartz and Katircioglu satisfies this requirement. Pet. 35–37. Although Petitioner asserts that the combination discloses associating shelf label content with product facing bounding boxes (id. at 30–35), we are not directed to any disclosure in either Schwartz or Katircioglu that teaches or suggests matching the shelf label content of different product facing bounding boxes. For the above reasons, Petitioner fails to persuade us that the combination of Schwartz and Katircioglu discloses limitation [1.5]. Therefore, we determine Petitioner has not met its burden to show a reasonable likelihood it would prevail with respect to the contention that claim 1 is unpatentable over the combination of Schwartz and Katircioglu.” slip op. at 13
- Skill levelSkill level petitioner adoptedOther
“Petitioner contends that [a] person of ordinary skill in the art (“POSITA”) in November 2016 would have had a Bachelor’s degree in electrical engineering, computer engineering, computer science, or a related field, and two or more years of work experience or research related to computer vision, image analytics, machine learning, artificial intelligence or automated object recognition methods and systems, or equivalent training and work experience in the field. Formal education can substitute for work experience and relevant work experience could substitute for formal education. Pet. 8–9 (citing Ex. 1003 ¶ 29). Patent Owner indicates it agrees with Petitioner’s definition of a person having ordinary skill in the art. Prelim. Resp. 4–5. Based on our review of the record before us, we determine that Petitioner’s stated level of ordinary skill in the art is reasonable because it appears consistent with the evidence of record, including the asserted prior definition.” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner contends that “[n]o formal claim constructions are necessary ‘to resolve the controversy.’” Pet. 9 (quoting Wellman, Inc. v. Eastman Chem. Co., 642 F.3d 1355, 1361 (Fed. Cir. 2011)). Petitioner adds that there is a rebuttable presumption that § 112(f) does not apply because the challenged claims do not recite “means.” Id. In the event the presumption is overcome with respect to the claim terms “processor” and “product classifier,” Petitioner identifies the disclosure describing the corresponding structure for these terms. Id. at 9–10. Patent Owner contends that claim construction is not necessary and the claims should be given their plain and ordinary meaning. Prelim. Resp. 5. Regarding the claim terms “processor” and “product classifier,” Patent Owner argues that Petitioner has not advanced any argument to rebut the presumption that § 112(f) does not apply. Id. at 6. any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 8
Claim construction§ 103 obviousnesscites GrahamPatents in suitUS 11,087,272 - Intel Corporation v. Telefonaktiebolaget LM EricssonInstitution deniedPTAB · Dec 18, 2024 · IPR2024-01008 · APJ Patrick R Scanlon · IPR · Institution
The Board denied institution on all challenged claims because Petitioner did not show a reasonable likelihood of prevailing on any asserted obviousness ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsDenied
“We have authority to determine whether to institute an inter partes review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). To institute an inter partes review, we must determine that the information presented in the Petition shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that Petitioner has not demonstrated a reasonable likelihood that it would prevail with respect to at least one challenged claim. Accordingly, we do not institute an inter partes review of the challenged claims on the grounds set forth in the Petition.” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Petitioner contends that the challenged claims do not need construction to demonstrate unpatentability. Pet. 14. Petitioner, however, notes that the parties in the ITC proceeding identified above dispute the meaning of several claim terms. Id. (citing Ex. 1026). Petitioner specifically notes that “the parties dispute what is required of independent claims 1, 5, and 16 to ‘determin[e] how many pixels’ to filter in each block.” Id. (citing Ex. 1026, 6–7). Petitioner argues that “ITC Respondent Lenovo mathematical basis (no relationship) with the pixel values of the pixels in said neighboring block’” (id. (citing Ex. 1026, 6–7)), but Patent Owner “contends that no construction is necessary,” “and the ‘plain meaning’ does not foreclose some ‘mathematical basis’ existing as long as separate decision values are calculated for each block” (id. (citing Ex. 1027, 14–19)). Petitioner indicates that Ground 1 adopts Patent Owner’s broader construction from the ITC proceeding and Ground 2 adopts Lenovo’s narrower construction. Id. at 14–15. Patent Owner argues that “none of the asserted grounds disclose or render obvious the Challenged Claims under the plain meaning of the claims (which is [Patent Owner’s] proposed construction) or under Lenovo’s narrower proposed construction.” Prelim. Resp. 29. On the present record, we do not discern a need to construe explicitly any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Furthermore, we are not persuaded that modifying Aksu in view of Gonzalez in the manner proposed by Petitioner overcomes this problem. As noted above, Petitioner asserts that, in the proposed combination, one of ordinary skill in the art “would have understood that the Laplacian’s output would be compared directly to a threshold based on β—just like Aksu’s difference calculations—to determine how many pixels to filter.” Pet. 60 (citing Ex. 1019, 13:15–19; Ex. 1003 ¶¶ 406–410). We disagree with this assertion, however, because it relies on erroneously equating the output of calculations (i.e., |r1-rj| and |r1-ri+1|). In other words, Aksu’s difference calculations, although used in setting dr, are not the same as dr; and we are not persuaded that one of ordinary skill in the art would have considered comparing Gonzalez’s Laplacian output to threshold β because Aksu discloses comparing its difference calculations to β. As noted above, we are not directed to any disclosure in Aksu of comparing dr to β. In addition, Dr. Schonfeld’s testimony on this point is not persuasive. Specifically, Dr. Schonfeld testifies that “dr can simply be defined as the output of the Laplacian (dr=|r3-2r2+r1|), and dr could be directly compared to a threshold based on β.” Ex. 1003 ¶ 408 (underline emphasis added). This testimony, however, is entitled to little weight because Dr. Schonfeld fails to provide a sufficient underlying basis for his opinion. See 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); see also Nobel Biocare Services AG v. Instradent USA, Inc., 903 F.3d 1365, 1382 (Fed. Cir. 2018) (explaining that the Board can reject arguments based on expert testimony that lacks specificity or detail). Moreover, opining that output of the Laplacian, dr, could be directly compared to β does not establish sufficiently that one of ordinary skill in the art would have been motivated to do so. See Belden Inc. v. Berk-Tek LLC, 805 F.3d 1064, 1073 (Fed. Cir. 2015) (“[O]bviousness concerns whether a skilled artisan not only could have made but would have been motivated to make the combinations or modifications of prior art to arrive at the claimed invention.”).” slip op. at 26
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsNot reached
“G. Discretion Under 35 U.S.C. § 325(d) Patent Owner argues that we should exercise our discretion to deny institution under § 325(d). Prelim. Resp. 64–66; Paper 8. Petitioner argues that discretionary denial is not appropriate in this case. Pet. 85–86; Paper 7. Because we are not persuaded the Petition demonstrates sufficiently a reasonable likelihood that Petitioner will prevail with respect to at least one challenged claim as discussed above, we need not reach Patent Owner’s arguments regarding discretionary denial under § 325(d).” slip op. at 29
Claim construction§ 103 obviousnessDiscretionary denialcites GrahamPatents in suitUS 9,641,841 - Intel Corporation v. Telefonaktiebolaget LM EricssonInstitution deniedPTAB · Dec 18, 2024 · IPR2024-01009 · APJ Patrick R Scanlon · IPR · Institution
The Board denied institution on all challenged claims because Petitioner did not show a reasonable likelihood of prevailing on either asserted obviousness ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“We have authority to determine whether to institute an inter partes review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). To institute an inter partes review, we must determine that the information presented in the Petition shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that Petitioner has not demonstrated a reasonable likelihood that it would prevail with respect to at least one challenged claim. Accordingly, we do not institute an inter partes review of the challenged claims on the grounds set forth in the Petition.” slip op. at 2
- Skill levelOther
“Although not identical, the parties’ definitions are substantially similar. Accordingly, for purposes of this Decision, we determine that no express finding is necessary, and that the level of ordinary skill in the art is reflected by the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). We note, however, that our obviousness analysis in this Decision would not differ if we adopted either Petitioner’s or Patent Owner’s definition.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“On the present record, we do not discern a need to construe explicitly any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 9
- Expert testimonyPetitioner expert discountedDecided for patent owner
“Dr. Schonfeld’s testimony cited by Petitioner does not rectify this problem. See Ex. 1003 ¶ 263. Dr. Schonfeld does not actually state that the well as the number of pixel differences, as “variables” that “were known to control the frequency response of the filter, or, in other words, how much particular frequencies would be filtered,” as allegedly shown by Gonzalez.9 Id. (citing Ex. 1020, 153, 273). But Dr. Schonfeld does not explain adequately how the cited portions of Gonzalez disclose that the coefficients were known to control the frequency response in a deblocking filter. Indeed, the cited portions of Gonzalez do not appear to discuss determining offsets for deblocking filtering or the coefficients used in an equation for determining offset. See Ex. 1020, 153, 273. Accordingly, this testimony is entitled to little weight because Dr. Schonfeld fails to provide a sufficient underlying basis for his opinion. See 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); see also Nobel Biocare Services AG v. Instradent USA, Inc., 903 F.3d 1365, 1382 (Fed. Cir. 2018) (explaining that the Board can reject arguments based on expert testimony that lacks specificity or detail).” slip op. at 11
Claim construction§ 103 obviousnesscites GrahamPatents in suitUS 10,142,659 - PTAB · Nov 15, 2024 · IPR2024-00851 · APJ Eric C Jeschke · IPR · Institution
The Board denied institution on all claims 1–7 because the Petition did not show a reasonable likelihood of prevailing on any challenged ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023) (“The Board institutes the trial on behalf of the Director.”). Inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314. Upon consideration of the evidence and arguments in the record, for the reasons below, we determine that the information presented does not show a reasonable likelihood that Petitioner would prevail with respect to at least one of challenged claims 1–7. We thus deny institution of inter partes review. See 37 C.F.R. § 42.108(b) (“At any” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“we view the prior art and the claimed invention. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). The person of ordinary skill in the art is a hypothetical person presumed to have known the relevant prior art. In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995). In determining the level of ordinary skill in the art, we may consider certain factors, including the “type of problems encountered in the art; prior art solutions to those problems; rapidity with which innovations are made; sophistication of the technology; and educational level of active workers in the field.” Id. (internal quotation marks and citation omitted).” slip op. at 10
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesDecided for patent owner
“claim element creates a rebuttable presumption that § 112[(f)] applies” and that “the failure to use the word ‘means’ also creates a rebuttable presumption—this time that § 112[(f)] does not apply.”12 Williamson v. Citrix Online, LLC, 792 F.3d 1339, 1348 (Fed. Cir. 2015) (en banc in relevant part) (internal citations omitted). Because the “sealing means” limitation includes the word “means,” we start from the rebuttable presumption that § 112(f) applies. Petitioner does not address the applicability of § 112(f) and does not rebut the presumption. We continue the analysis, however, and, for the reasons below, we agree with Patent Owner that § 112(f) applies to the “sealing means” limitation.” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“3. “fits behind” In wherein clause (vi), claim 1 recites: “the outwardly pointing outer flange of the first connecting device fits behind the inner flange of the nut unit.” Ex. 1001, 9:4–5 (emphasis added). In the Preliminary Response, Patent Owner discusses the term “fits behind” in this claim language. See Prelim. Resp. 41–45. We need not construe explicitly this language or any other claim terms because doing so would not change the outcome of the analysis. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 14
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 9,851,030 - Cub Elecparts Inc. v. Orange Electronic Co., Ltd.Institution deniedPTAB · Nov 12, 2024 · IPR2024-00744 · APJ Patrick R Scanlon · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood of prevailing on any challenged claim under the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“We have authority to determine whether to institute an inter partes review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). To institute an inter partes review, we must determine that the information presented in the Petition shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that Petitioner has not demonstrated a reasonable likelihood that it would prevail with respect to at least one challenged claim. Accordingly, we do not institute an inter partes review of the challenged claims on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person having ordinary skill in the art (“POSA”) “would have a bachelor’s degree in electrical engineering and at least one year of experience in sensor/detector design or RF communications (RFIDs)” and “would have a working knowledge of tire pressure management systems and, as most POSA would also be automobile owners, would have had personal experience with tire pressure management systems which have been required in all new cars, trucks, and SUVs in the United States since 2007.” Pet. 17. Petitioner adds that “[e]ducation may substitute for experience and vice versa.” Id.” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner contends that all claim terms should be given their ordinary and customary meaning. Pet. 17. Petitioner notes that, in the tire pressure detecting field, terms such as “detector,” “sensor,” and “monitor” relate to the same device and can be used interchangeably. Id. at 17–18. Patent Owner contends that no claim term needs construction to resolve the grounds asserted in the Petition. Prelim. Resp. 16. On the present record, we do not discern a need to construe explicitly any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the” slip op. at 13
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“We agree with Patent Owner that Petitioner’s unsupported assertion that tire pressure sensors typically are programmed with only the ID as part of the factory installation is insufficient to establish obviousness in this instance. Petitioner does not provide adequate reasoning or evidence to 11 Petitioner relies on the same analysis of this claim 26 limitation for the substantially similar limitation of claim 27. Pet. 66. Accordingly, our analysis of the claim 26 limitation applies equally to the corresponding limitation of claim 27. art would have known that tire pressure sensors typically are programmed at the factory with a single ID. Furthermore, even if assuming for the sake of argument that Petitioner’s assertion is correct, the Petition fails to explain adequately how or why one of ordinary skill in the art would have modified the combination of Tang and Lemense to store only the old identification in the old tire pressure detector.” slip op. at 20
Claim construction§ 103 obviousnessDiscretionary denialcites GrahamPatents in suitUS 8,031,064
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.