- Geotab Inc. / Geotab USA, Inc. v. Fractus, S.A.Institution deniedPTAB · Dec 3, 2025 · PGR2025-00056 · APJ Steven M Amundson · PGR · Institution
Institution was denied because Petitioner did not show it was more likely than not that claims 1–20 were unpatentable under the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“to institute a post-grant review. We may not institute a post-grant review unless we determine that “the information presented in the petition filed under section 321, if such information is not rebutted, would demonstrate that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a) (2024). After considering the Petition, the Preliminary Response, the Preliminary Reply, the Preliminary Sur-reply, and the evidence of record, and for the reasons explained below, we determine that Petitioner has failed to demonstrate that it is “more likely than not” that at least one of the claims challenged in the Petition is unpatentable. Hence, we deny the Petition and do not institute a post-grant review.” slip op. at 2
- Skill levelSkill level petitioner adoptedOther
“effective filing date would have had “at least a bachelor’s degree in electrical engineering, computer science, or a similar degree and at least four years of experience in applied electromagnetics with an emphasis on antennas.” Pet. 10 (quoting Ex. 1018 ¶ 32). Petitioner also asserts that “[a]lternatively, the person of ordinary skill in the art would have a master’s degree in electrical engineering (or similar discipline) and at least two years of similar experience.” Id. (quoting Ex. 1018 ¶ 32). Dr. van der Weide’s testimony supports Petitioner’s assertions. See Ex. 1007 ¶ 39. For purposes of the Preliminary Response only, Patent Owner employs Petitioner’s description of an ordinarily skilled artisan. Prelim. Resp. 22. Based on the current record and for purposes of this decision, we accept Petitioner’s description of an ordinarily skilled artisan because it comports with the technology and claims of the ’149 patent as well as the asserted references. See, e.g., Ex. 1005, 1:35–6:56, 42:44–46:28, code (57); infra §§ III.E.1–III.E.2, III.G.1–III.G.2, III.H.1.” slip op. at 25
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“4. DISCUSSION “[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.” Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999); see Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017). Based on the current record, we determine that no claim term requires an explicit construction to decide whether Petitioner satisfies the “more likely than not” standard for instituting a post-grant review. As Petitioner recognizes, the ’149 patent defines many of the claim terms Petitioner discusses in the “Claim Interpretation” section of the Petition. See Pet. 14–16. For instance, the patent defines “antenna rectangle” as “the orthogonal projection of the antenna box along the normal to the face with largest area of the antenna box.” Ex. 1005, 14:21–24. Further, the patent defines “complexity factor F21” and “complexity factor F32” consistent with the independent claims. See id. at 17:16–21, 17:49–61, 18:8–18, 19:12–25, 20:5–17, 42:62–43:25, 44:5–30, 45:8–46:3. E. Alleged Obviousness over Dou and Ciais-Multiband: Claims 7–9, 11–14, 16, 17, 19, and 20 Petitioner contends that claims 7–9, 11–14, 16, 17, 19, and 20 are” slip op. at 28
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“Petitioner does not explain why an ordinarily skilled artisan who used Ciais-Quadband’s antenna for Dou’s two antennas 206 and 208 would have departed from the commonly accepted rule of thumb and Dou’s preference for at least a quarter-wavelength spacing between antennas at the lowest frequency to the extent needed to implement the proposed combination, i.e., with only about 55% of the preferred spacing between antennas. See Pet. 60–69; Ex. 1007 ¶¶ 172–187. Hence, based on the current record, Petitioner does not establish sufficiently for purposes of institution that an ordinarily skilled artisan would have been motivated to combine Ciais-Quadband’s teachings with Dou’s teachings in the way Petitioner proposes. Further, the addition of two Nakano InvFL antennas extending from the ground plane both above and below the PCB does not remedy the insufficient spacing between “the swapped-in Ciais-Quadband antennas.” Ex. 2010 ¶ 67.” slip op. at 69
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 12,095,149 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Solus’s rehearing request, leaving institution denied for claims 1–8 because the petition did not adequately show motivation to combine Hanafusa and Dobashi.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve Dobashi’s RSm values. Dobashi teaches that because RSm “can be adopted as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66–3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66– 3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 4
§ 103 obviousnessPatents in suitUS 11,346,014 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show that claims 1–10 were likely obvious over the asserted combinations.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re 1 US 2013/0108922 A1, published May 2, 2013 (Ex. 1004, “Shinozaki”). 2 G. Khatibi, Temperature Dependent Elastic and Thermal Properties of Thin Copper Foils, Copper; Proceedings of the International Conference Copper ’06 (2006) (Ex. 1006, “Khatibi”). 3 Korean Patent Pub. No. 10-2012-0003485, published Jan. 10, 2012 (Ex. 1013; Ex. 1014 (English translation), “Toshio”). 4 US 2013/0108887 A1, published May 2, 2013 (Ex. 1012, “Kim”). 5 Griesi, M.B., Characterization of Electrodeposited Copper Foil Surface Roughness for Accurate Conductor Power Loss Modeling (2014) (Master’s Thesis, University of South Carolina) (Ex. 1015, “Griesi”). rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Not shown unpatentable
“For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE[6] value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added).” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner, however, does not adequately explain why a POSITA would have been motivated to modify Kim’s copper foil surface to have a Pc value of 19.2 as reported in Griesi. In particular, neither Petitioner nor Dr. Randall points us to, nor do we discern, any teaching in Griesi that a peak count of 19.2 provides any particular benefits or properties that would have lead a POSITA to modify Kim’s copper foil surface as Petitioner proposes. Instead, Petitioner’s arguments that a POSITA would have been motivated to modify Kim’s copper foil surface with Griesi’s peak count patent itself. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 421 (2007) (stating that the fact finder must be aware “of the distortion caused by hindsight bias and must be cautious of arguments reliant upon ex post reasoning”). It was Petitioner’s burden to establish that the combined teachings Kim and Griesi disclose limitation [1g] as proposed. We are not persuaded that we misapprehended Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 8
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish the Khatibi, alone or in combination with Shinozaki, Toshio, and Kim, discloses limitation [1d]. We concluded that Petitioner failed to meet that burden for the reasons explained in our Decision. We are not persuaded that we overlooked or misapprehended Khatibi’s disclosures, or Petitioner’s evidence and explanation thereof, in doing so.7” slip op. at 5
§ 103 obviousnesscites KSRPatents in suitUS 10,811,689 - Tesla, Inc. v. The United States Of America As Represented By The Secretary Of The Navy (Intellectual Ventures II LLC)Institution deniedPTAB · Jul 24, 2025 · IPR2025-00341 · APJ Aaron W Moore · IPR · Institution
The Board denied institution because Tesla had not shown a reasonable likelihood that claims 10, 11, 14, 16, and 18 were unpatentable over the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Institution of an inter partes review is authorized when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a); see 37 C.F.R. § 42.108. Having considered the Petition, the Preliminary Response, the Reply, and the Sur-reply, as well as the evidence of record, we conclude that Petitioner has not shown a reasonable likelihood that it will prevail in establishing the unpatentability of claims 10, 11, 14, 16, and 18 of the ’743 patent. We accordingly do not institute inter partes review. A.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner asserts that a person of ordinary skill in the art would have “been someone knowledgeable and familiar with the areas of networking and distributed computing that are pertinent to the ’743 patent,” would “have a bachelor’s degree in computer science, computer engineering, electrical engineering, or equivalent training, and approximately 2-3 years of professional experience relating to distributed computing,” and that a “[l]ack of professional experience can be remedied by additional education, and vice versa.” Pet. 17 (citing Ex.1003, ¶¶ 32-34). Patent Owner does not address this issue in the Preliminary Response. As Patent Owner does not dispute Petitioner’s characterization of the level of skill in the art, we adopt it for purposes of this analysis. B.” slip op. at 7
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“of “event,” in which Petitioner argued that the term should be broad enough to include “processing radar sensor data, performing radar tracking initialization and refinement, and distributing radar tracking information to other modules,” and Patent Owner argued that the specification uses the term as “as an umbrella term to cover various types of ‘internal event and performance data’ such as ‘application statuses, states, performance, and internally detected errors.’” Reply 1; Sur-reply 2. We agree with Patent Owner that that claimed “events” must concern “application statuses, states, performance, and internally detected errors.” See Ex. 1001, 7:44–45. The patent explains that function group 2 collects that type of information from applications using an API and then “correlate[es], combin[es], and reformat[s] [the] application data into higherlevel metrics (composite events) for use by displays or other Resource Management components.” Id. at 7:52–54. The middleware described and claimed in the ’743 is concerned with how applications are performing, not what they doing.” slip op. at 13
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“This claim limitation, however, also requires “event correlation capabilities.” For that, Petitioner asserts that “Welch’s metrics calculation component (part of the ‘second function group’) provides ‘event correlation capabilities’ because the QoS management software “implementation includes the following capabilities: . . . (2) track correlation and filtering algorithms.” Pet. 44–45 (citing Ex. 1003, 4). This, we find, mischaracterizes Welch’s disclosure, because Welch’s metrics calculation component does not perform the identified “correlation.” The language quoted by Petitioner comes from the experimental results section of Welch, which describes how the implementation of the NSWC HiPer-D testbed, the system that was used test Welch’s QoS middleware, included “track correlation and filtering algorithms.” Ex. 1005, 4. Welch is not explaining that the middleware correlates the QoS system level events that Petitioner has identified as the claimed “events,” but, instead, that the NSWC HiPer-D system that was used to test the middleware included the ability to correlate radar data in a shipboard anti-air-warfare system.6 The correlating mentioned in Welch occurs at the application level, not in the middleware.” slip op. at 12
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 7,181,743 - Tesla, Inc. v. Intellectual Ventures II LLCInstitution deniedPTAB · Jun 11, 2025 · IPR2025-00218 · APJ Frederick C Laney · IPR · Institution
The Board denied institution because the Kim and Vayanos combination did not show that each individual bit indicates a separate time interval, as required by claims 1–12.
RulingsInstitution decision- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“limitation 1.2 because it is more consistent with the claim language and the specification of the ’416 patent. The language “each of the plurality of bits” clearly individualizes the “plurality of bits” and the language “indicates a respective time interval that physical shared channel resources are utilized to signal channels” clearly ascribes to each individual bit the function of identifying a time interval that is separate from the time interval(s) that the other individual bit(s) identify. Petitioner’s claim constriction argument largely ignores the words used in limitation 1.2. Petitioner fails to provide anything to explain how or why the plain meaning of “each” and “respective” in the context of limitation 1.2 could be understood by a skilled artisan to connote something other than the plurality of bits individually identifying a separate and distinct time interval (i.e., a “one-to-one correspondence”). Petitioner similarly does not identify anything from the specification of the ’416 patent that would support deviating from the plain meaning of limitation 1.2. And Petitioner’s reliance on 3M Innovative Properties appears to miss the mark. Pet. Reply 7. In that case, the Federal Circuit held that, when a claim term has an “ascertainable definition in the body of the claim,” their “cases do not support prescribing a more particularized meaning unless a narrower construction is required by the specification or prosecution history.” 3M Innovative Properties Co., 725 F.3d at 1329. Here, however, Patent Owner is not attempting to import a more particularized meaning into limitation 1.2, but to demonstrate that the ’416 specification is consistent with the ascertainable definition of “each” and “respective” within the context of limitation 1.2. In particular, Patent Owner highlights that the ’416 specification describes the resource allocation technique as using an indicator bit, within a plurality of indicator bits, that has a one-to-one correspondence to a specific time window established for a Forward Access Channel (FACH). See Ex. 1001, 13:63–14:25, 14:44–53, Figs. 7, 9; PO Resp. 11–14, 19–20; PO Sur-reply 2–3; Ex. 2001 ¶¶ 36–40, 49. And we agree that the ’416 specification informs, and is consistent with, the plain reading of limitation 1.2. See Ex. 1001, 13:63–14:25, 14:44–53, Figs. 7, 9. Therefore, we determine that the plain and ordinary meaning of limitation 1.2 requires all the plurality of bits to individually identify a separate and distinct time interval that physical shared channel resources are utilized to signal channels.” slip op. at 12
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“PICH, which is communicated to Kim’s receiver, has a plurality of bits, the evidence fails to demonstrate sufficiently that each of those bits indicates a respective time interval that physical shared channel resources are utilized to signal channels, as limitation 1.2 recites. As Patent Owner correctly argues, the Vayanos paging indicators use multiple bits to indicate information about a single time interval in a frame, rather having several bits that individually identify a separate and distinct time interval. PO Resp. 39–41 (citing Ex. 2001 ¶¶ 67, 74–75). Vayanos teaches that “[t]he number of paging indicators (Np) in each PICH frame is configurable by the system and can take on a value of 18, 36, 72 or 144,” and that “[e]ach paging indicator is sent in 288/Np consecutive bits in the PICH frame, where 288/Np can take on a value of 16, 8, 4 or 2.” Ex. 1006, 3:26–34. As a result, if there are 18 (Np = 18) paging indicators, 288/NP = 288/18 = 16 (meaning that each paging indicator is 16 bits long), if there are 36 (Np = 36) paging indicators, 288/Np = 288/36 = 8 (meaning that each paging indicator is 8 bits long), if there are 72 (Np=72) paging indicators, 288/Np = 288/72= 4 (meaning that each paging indicator is 4 bits long), and if there are 144 (Np=144) paging indicators, 288/Np = 288/144 = 2 (meaning that each paging indicator is 2 bits long). Ex. 2001 ¶ 66. Each paging indicator (singular) taught by Vayanos includes multiple bits––each paging indicator (singular) has either 16, 8, 4 or 2 bits–– and Vayanos does not disclose or suggest a paging indicator that indicates a time interval with only a single bit. Id. And Petitioner does not cite Kim to show the number of bits used to indicate a time interval; only to show that a UE would receive broadcast information with paging information including paging indicators that identify a time interval in which physical shared channel resources are utilized to signal channels. See Pet. 40–49. Even accepting that the Kim/Vayanos combination discloses a UE receiving a paging indicator that is indicative of a time interval in which a Paging Channel PCH may be found or indicative of whether a frame will include a signaling channel (e.g., PCH) at a specific TTI within that frame, the combination does not disclose or suggest using a paging indicator that is a single bit indicating either of those time intervals. On the contrary, as noted above, Vayanos teaches that all paging indicators consist of multiple bits and, thus, the Kim/Vayanos combination discloses a UE that only receives and uses a plurality of bits to indicate a time interval that physical shared channel resources are utilized to signal channels. This is insufficient to show a reasonable likelihood that Petitioner will be able to establish that the Kim/Vayanos combination discloses or suggests receiving a plurality of bits wherein the individual bits each identify a separate and distinct time interval. Therefore, Petitioner has not shown sufficiently that the Kim/Vayanos combination discloses or suggests the subject matter limitation 1.2 recites. For the above reasons, we are not persuaded that Petitioner has shown sufficiently that the combination of Kim and Vayanos disclose or suggest broadcast information that includes a plurality of bits, wherein each of the plurality of bits indicates a respective time interval that physical shared channel resources are utilized to signal channels. This failing undermines Petitioner’s showing as to independent claims 1 and 7 (in the asserted Grounds 1 and 2) and, as a result, the same deficiency extends through to all of the dependent claims challenged in all of the grounds.4” slip op. at 18
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“sufficiently that the combination of Kim and Vayanos disclose or suggest broadcast information that includes a plurality of bits, wherein each of the plurality of bits indicates a respective time interval that physical shared channel resources are utilized to signal channels. This failing undermines Petitioner’s showing as to independent claims 1 and 7 (in the asserted Grounds 1 and 2) and, as a result, the same deficiency extends through to all of the dependent claims challenged in all of the grounds.4 IV. CONCLUSION Based on the arguments and evidence presented by the parties, we conclude that Petitioner has not demonstrated a reasonable likelihood of prevailing with respect to at least one claim of the ’416 patent challenged in the Petition. Therefore, we do not institute an inter partes review.” slip op. at 20
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,136,416 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 25, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–8 were unpatentable under the asserted obviousness grounds.
RulingsInstitution decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“experience working on the development of materials or components for electronic devices such as batteries.” Pet. 2. Petitioner further contends that “[a]dditional education, such as a graduate degree, could compensate for less work experience, and additional work experience could compensate for less formal education.” Id. Patent Owner states that, “[f]or purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art.” Prelim. Resp. 4. For purposes of this Decision, we adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’014 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” 37 C.F.R. § 42.100(b). Under this standard, claim terms are generally given their plain and ordinary meaning as would have been understood by a person of ordinary skill in the art at the time of the invention and in the context of the entire patent disclosure. Phillips v. AWH Corp., 415 F.3d 1303, 1313 (Fed. Cir. 2005) (en banc). Only those terms in controversy need to be construed, and only to the extent necessary to resolve the controversy. Realtime Data LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019). in this proceeding.” Pet. 3. Patent Owner contends that “[t]he Board need not construe any term in order to determine that institution should be denied.” Prelim. Resp. 4. Based on the record before us, we determine that no claim term requires express construction for purposes of this Decision. See Realtime Data, 912 F.3d at 1375.” slip op. at 8
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“For these reasons, we are not persuaded that Petitioner sufficiently establishes that a POSITA would have been motivated to modify Hanafusa in light of Dobashi with a reasonable expectation of success as Petitioner contends. Accordingly, we determine that Petitioner fails to demonstrate a reasonable likelihood of prevailing in its assertion that the subject matter of claim 1, and claims 4 and 8 that depend therefrom, would have been obvious over the combined teachings of Hanafusa and Dobashi.” slip op. at 18
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“Petitioner also focuses on Hanafusa’s teaching that all known methods can be used to make a rough surface low-profile, and Dobashi’s teaching that RSm can be used as an indicator for judgment of the surface, to support its contention that a POSITA would have been motivated to apply Dobashi’s RSm to further achieve Hanafusa’s purpose, without explaining how and why that would be the case. In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness and is rough when RSm is small.” Id. at 3:1–3, 6:27–29. Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66– 3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66–3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 14
Claim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 11,346,014 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 23, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–10 were unpatentable over either asserted § 103 ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314 (2018); see also 37 C.F.R. § 42.4 (2023). For the reasons discussed below, we deny the Petition and do not institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“II. ANALYSIS A. Level of Ordinary Skill in the Art Petitioner contends that a person of ordinary skill in the art (“POSITA”) “would have had at least an undergraduate degree in materials science, chemical engineering, electrical engineering, or related field, or equivalent knowledge, training, or experience, with at least two years of experience working on the development of materials or components for electronic devices such as batteries.” Pet. 4. Petitioner further contends that “[a]dditional education, such as a graduate degree, could compensate for less 7 We refer to the page numbers added by Petitioner to the bottom-center of the page. formal education.” Id. (citing Ex. 1003 ¶ 10). Patent Owner states that, “[f]or purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art.” Prelim. Resp. 4. For purposes of this Decision, we adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’689 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163–64 (Fed. Cir. 1985))).” slip op. at 10
- Expert testimonyPetitioner expert discountedDecided for patent owner
“We are not persuaded, on this record, that Petitioner adequately establishes that Khatibi discloses a CTE in the claimed range of 16 to 22 µm/(m·°C.). Petitioner’s argument that Khatibi’s reported values meet this claim limitation are based solely on Dr. Randall’s testimony that Khatibi’s measurement method would produce results that would not significantly differ from results determined using the claimed method. See Pet. 16–18 (citing Ex. 1003 ¶¶ 56–60). Dr. Randall’s testimony, however, is largely conclusory and unsupported by adequate explanation and/or objective evidence. For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added). to little weight. See 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); Xerox Corp. v. Bytemark, Inc., IPR2022-00624, Paper 12 at 5 (PTAB Feb. 10, 2023) (finding that “the Board was correct in giving little weight to Petitioner’s expert because the expert declaration merely offered conclusory assertions without underlying factual support”); Upjohn Co. v. Mova Pharm. Corp., 225 F.3d 1306, 1311 (Fed. Cir. 2000) (“Lack of factual support for expert opinion to factual determinations, however, may render the testimony of little probative value in a validity determination.” (quoting Ashland Oil, Inc. v. Delta Resins and Refractories, Inc., 776 F.2d 281, 294 (Fed. Cir. 1985))); see also In re Ethicon, Inc., 844 F.3d 1344, 1348, 1352 (Fed. Cir. 2017) (concluding that the Board properly gave “little weight” to conclusory expert testimony of objective indicia). Because Petitioner offers Dr. Randall’s testimony to supply a limitation missing from the prior art, namely, the CTE measurement method, and we give Dr. Randall’s unsupported and conclusory testimony little weight, we are not persuaded that Petitioner establishes a reasonable likelihood of showing that Khatibi discloses limitation [1d].” slip op. at 17
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“second surfaces of the electrolytic copper foil ranges from 3 to 92.” Ex. 1001, 13:62–63. Petitioner contends that “Kim teaches that the electrolytic copper foil (e.g., untreated or treated copper foil) having Rz less than 2 µm is advantageous toward battery efficiency and performance,” and, similarly, Griesi describes the use of untreated electrolytic copper foil with an Rz value less than 2 µm in printed circuit boards that are compatible with secondary batteries. Pet. 58–59 (citing Ex. 1012, claim 2, ¶¶ 13, 25, 27; Ex. 1003 ¶ 157). In particular, Petitioner notes that Griesi’s Figure 3.16 describes an “Rz value of 1.2 µm.” Id. at 59 (citing Ex. 1015, 53–54; Ex. 1003 ¶ 158). Petitioner asserts that “Dr. Randall explains that a POSITA would have also recognized another surface roughness-related parameter, Rpc, in Griesi as a potentially useful parameter that can be optimized to further enhance uniformity or generally improve Kim’s copper foil surface, for example, to prevent wrinkles or achieve other advantageous effects.” Id. (citing Ex. 1003 ¶ 159). Although Dr. Randall demonstrates that Griesi’s Pc (or Rpc) value is 19.2 over a 4 mm sampling length (Ex. 1003 ¶ 155), Petitioner does not contend that Griesi addresses this value, or indicates any benefit that might be derived from its use. Instead, Griesi’s Pc value appears to be an incidental finding, which is not discussed or analyzed in the reference. See incidental, unexamined finding would lead a POSITA to import Griesi’s Pc value into Kim’s copper foil, absent a hindsight desire to reconstruct the claimed invention. As such, Petitioner’s arguments with respect to Kim and Griesi are not persuasive. See Cheese Sys. Inc. v. Tetra Pak Cheese and Powder Sys., Inc., 725 F.3d 1341, 1352 (Fed. Cir. 2013) (“Obviousness cannot be based on the hindsight combination of components selectively culled from the prior art to fit the parameters of the patented invention.” (internal quotations marks omitted)). Thus, we are not persuaded, on this record, that the combined disclosures of Kim and Griesi teach all of the elements of limitation [1g].” slip op. at 23
§ 103 obviousnesscites PhillipsPatents in suitUS 10,811,689 - Sterlite Technologies Inc. v. Afl Telecommunications, LLC.Institution deniedPTAB · Apr 9, 2025 · IPR2025-00127 · APJ Josiah C Cocks · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–4, 8, or 13 were unpatentable over either proposed obviousness ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“At this preliminary stage, we determine whether the information presented shows a reasonable likelihood that Petitioner would prevail in establishing that at least one of the challenged claims would have been unpatentable over the proposed prior art. We analyze the asserted grounds with the above-noted principles in mind.” slip op. at 10
- Skill levelOther
“B. Level of Ordinary Skill in the Art As noted above, resolving the question of obviousness requires determination of the level of ordinary skill in the art. Graham, 383 U.S. at 17–18. Here, however, as Patent Owner observes (Prelim. Resp. 10), 8 Patent Owner does not present arguments or evidence of secondary considerations in its Preliminary Response. Therefore, secondary considerations do not constitute part of our analysis herein. Petitioner has provided no assessment as to the level of ordinary skill to be considered in evaluating the grounds of obviousness that are advanced by Petitioner. The absence of such assessment calls into question the fundamental adequacy of Petitioner in carrying its burden to show a reasonable likelihood of success of unpatentability of the challenged claims that necessarily must take into account the level of ordinary skill in the art.” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“In any event, we do not discern that there is any apparent dispute between the parties as to the meaning of any claim term. In considering the record at hand, we determine that it is unnecessary to make explicit, or further address, any claim term in deciding whether or not to institute trial. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (holding that only claim terms in controversy need to be construed, and only to the extent necessary to resolve the 9 Throughout their briefings, the parties refer to the limitations designated [1.1] through [1.7] using the term “element,” e.g., “element [1.7]” (see, e.g., Pet. 23; Prelim. Resp. 23). For consistency with the parties’ chosen nomenclature, we do the same in this Decision. controversy (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundReasonable expectation not foundNot shown unpatentable
“A POSITA would have been motivated to modify Summers’ fiber optic cable 50 to include Kaji’s intermittently-fixed optical fiber tape 2A to obtain the predictable result of enabling a higher density of optical fibers to be packed in Summers’ fiber optic cable 50, as contemplated by Kaji. *** a POSITA would have had a reasonable expectation of success because such modification would amount to nothing more than a simple substitution of Summers’ four-fiber ribbons 52 with Kaji’s intermittently-fixed optical fiber tape 2A by known methods of cable manufacturing. ***” slip op. at 20
Claim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 11,287,591 - Fortinet, Inc. v. Croga Innovations Ltd.Institution deniedPTAB · Mar 27, 2025 · IPR2025-00086 · APJ Terrence W Mcmillin · IPR · Institution
The Board denied institution on all challenged claims because Delco and Adams did not teach the internal firewall limitations; it also denied Fortinet’s motion for joinder.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“In an [inter partes review], the petitioner has the burden from the onset to show with particularity why the patent it challenges is unpatentable.” Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1363 (Fed. Cir. 2016) (citing 35 U.S.C. § 312(a)(3) (requiring inter partes review petitions to identify “with particularity . . . the evidence that supports the grounds for the challenge to each claim”)). Petitioner cannot satisfy its burden of proving obviousness by employing “mere conclusory statements.” In re Magnum Oil Tools Int’l, Ltd., 829 F.3d 1364, 1380 (Fed. Cir. 2016). slip op. at 9
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, deniedDenied
“III. JOINDER In this proceeding, Petitioner seeks to join IPR2024-01196. However, the Board did not institute an inter partes review in that proceeding, relying on substantially identical reasoning as here. Thus, there is no pending proceeding in the ’1196 IPR to join. As a result, Petitioner’s request to join the ’1196 IPR is denied.” slip op. at 21
- Expert testimonyPetitioner expert discountedOther
“The testimony of Petitioner’s expert as to the “internal firewall” limitation should be given little weight as, apart from a single extended quotation in ¶91, it merely repeats verbatim the assertion in the Petition it purportedly supports. Compare Pet. at 39–42 with EX1003 at ¶¶ 90–96; see Xerox Corp. v. Bytemark, Inc., IPR2022-00624, Paper No. 9 at 15 (PTAB Aug. 24, 2022) (precedential). Prelim. Resp. 4 n.1. We agree with Patent Owner. The testimony of Dr. Shenoy is not supported by Delco for the same reasons that the largely verbatim argument in the Petition is not supported by Delco.” slip op. at 13
- Skill levelSkill level petitioner adoptedOther
“B. Level of Ordinary Skill in the Art With regard to the level of ordinary skill in the art, Petitioner contends a person of ordinary skill in the art “would have a bachelor’s degree in electrical engineering, computer science, or equivalent training, and approximately two years of experience working in the field of virtual computing systems.” Pet. 11–12 (citing Ex. 1003 ¶¶ 23–25). Patent Owner does not address the level of ordinary skill in the art. See generally Prelim. Resp. For purposes of this Decision, we adopt Petitioner’s definition of the level of ordinary skill in the art because it is consistent with the ’780 patent and the asserted prior art.” slip op. at 9
Claim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 10,601,780 - Ecto World, LLC / Sv3, LLC v. Rai Strategic Holdings, Inc.Institution deniedPTAB · Mar 10, 2025 · PGR2024-00049 · APJ Jo-Anne M Kokoski · PGR · Institution
The Board denied institution because Petitioner did not show the patent was eligible for PGR; the challenged claims were supported by the 2006 priority application.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Accordingly, we determine that Petitioner does not demonstrate that it is more likely than not that the challenged claims lack written support in the Specification (and the ’634 application). That is, on this record, it appears that the challenged claims properly claim priority to the ’634 application and, accordingly, have an effective filing date in October 2006. 2. Conclusion: PGR Eligibility For the foregoing reasons, and based on the record before us, we determine that Petitioner has not demonstrated that it is more likely than not that the ’202 patent has, or had, at least one claim having an effective filing date on or after March 16, 2013. Accordingly, we determine that the ’202 patent is entitled to the filing date of the ’634 application (October 18, 2006), and, thus, the ’202 patent is not eligible for post-grant review.” slip op. at 18
- Claim Construction › Intrinsic evidence (Phillips canons) › Specification disavowal / 'present invention' languageTerm construed board ownDecided for patent owner
“Accordingly, the ’202 patent consistently and repeatedly characterizes the invention as incorporating tobacco in some form and ties the stated benefits of the invention to the inclusion of tobacco. Moreover, the Specification is directed to smoking articles containing tobacco, all of the embodiments include tobacco, and “the present invention” is described as a smoking article, where the smoking article includes tobacco. Consequently, we determine that “smoking article” as it is used in the challenged claims is limited to devices that include tobacco. See Mosaic Brands, Inc. v. Ridge Wallet LLC, 55 F.4th 1354, 1361 (Fed. Cir. 2022) (finding claimed “lip” is limited to “extrudable plastic materials” where specification states that “the device of the present invention is constructed of extrudable plastic materials” and “emphasizes the benefits of using extrudable plastics and describes them as benefits of the invention as a whole”); Poly-Am., L.P. v. described in the specification has inwardly extended short seals and every section of the specification indicates the importance of inwardly extended short seals. These two facts provide together a proper reason to limit the claims in this way.”); Phillips v. AWH Corp., 415 F.3d 1303, 1312–1317 (Fed. Cir. 2005) (en banc) (“[T]he specification may reveal an intentional disclaimer, or disavowal, of claim scope by the inventor. In that instance as well, the inventor has dictated the correct claim scope, and the inventor’s intention, as expressed in the specification, is regarded as dispositive.”).” slip op. at 13
- Disclosure Requirements (§112) › Written description (Ariad)Written description adequateEntitled to earlier dateNot shown unpatentable
“Petitioner’s argument is dependent on accepting Petitioner’s assertion that the claims include a smoking article that does not contain tobacco, which we have not done. Instead, as set forth above, we construe “smoking article” as being limited to devices that include tobacco. See § II.B.2, supra. Based on our construction of “smoking article” and the evidence of record in this proceeding, we determine that the challenged claims are supported by the specification of the ’202 patent, which is identical to the specification of all of the continuations in the chain leading back to the October 18, 2006 that the specification of the ’202 patent and every patent in its priority chain “have identical specifications”); Prelim. Resp. 13 (noting that Petitioner does not identify other limitations in the challenged claims “allegedly lacking support in the ’202 patent family’s applications dating back to U.S. App. No. 11/550,634, filed on October 18, 2006”). Accordingly, we determine that Petitioner does not demonstrate that it is more likely than not that the challenged claims lack written support in the Specification (and the ’634 application). That is, on this record, it appears that the challenged claims properly claim priority to the ’634 application and, accordingly, have an effective filing date in October 2006.” slip op. at 17
Claim construction§ 112 disclosurecites PhillipsPatents in suitUS 11,925,202
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.