- Ascend Elements, Inc. v. Duesenfeld GmbHInstitution deniedPTAB · Oct 10, 2025 · PGR2025-00037 · APJ Kevin W Cherry · PGR · Institution
The Board denied institution of PGR on claims 1–14 because Petitioner did not show that any challenged claim was more likely than not unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“information presented in the petition filed under [35 U.S.C. §] 321 . . . demonstrates that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a). For the reasons set forth below, we determine that Petitioner has failed to demonstrate that it is more likely than not that at least one of claims 1–14 of the ’463 patent is unpatentable. Accordingly, we deny institution of a postgrant review of claims 1–14 based on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art “would have had at least a Bachelor’s degree in electrical engineering, material science, chemical engineering, or an equivalent field, as well as at least 2 to 3 years of academic or industry experience in the recycling or processing of lithiumion batteries. Additional formal education focusing on processing of lithium batteries may substitute for practical experience and additional practical experience can substitute for less education.” Pet. 10–11. Patent Owner does not contest this definition of a person of skill in the art. See Prelim. Resp. 11. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as, on the present record, it appears consistent with the ’463 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 8
- Expert testimonyPetitioner expert discountedPatent owner expert creditedDecided for patent owner
“distinct from “comminute[ion],” Petitioner offers only the testimony of its expert, Mr. Juzkow, who equates Tomioka’s “cutting” with “comminute[ion].” See Ex. 1003 ¶ 121. However, Mr. Juzkow provides insufficient reasoning to support his conclusion, particularly given the intrinsic and extrinsic evidence discussed above. In contrast, Patent Owner’s expert, Mr. Dantam, provides extensive reasoning, supported by citations to other evidence, to support his conclusion that Tomioka’s “dismantling” is not the claimed “comminution.” Thus, we give more weight to Mr. Dantam’s testimony than Mr. Juzkow’s testimony. Weighing this evidence all together, we find that Petitioner has failed to show that it is more likely than not that Tomioka’s teaches the claimed comminution under Petitioner’s first theory.” slip op. at 15
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundTeaching away not foundNot shown unpatentable
“obvious. Pet. 34–35. However, we agree with Patent Owner that Petitioner has also failed to show that it is more likely than not that Tomioka renders this limitation obvious. See Prelim. Resp. 28–31. To begin with, Petitioner’s contentions lack sufficient reasoning explaining why a person of ordinary skill would have modified Tomioka in the manner proposed. “[R]ejections on obviousness grounds cannot be sustained by mere conclusory statements; instead, there must be some articulated reasoning with some rational underpinning to support the legal conclusion of obviousness.” In re Kahn, 441 F.3d 977, 988 (Fed. Cir. 2006). Petitioner merely asserts that a person of ordinary skill in the art could use the roller system in place of the dismantling disclosed for the embodiments in Figures 19 and 20. On this record, we find this bare contention insufficient. actual disclosure of Tomioka. The rollers in Tomioka are used to separate the “battery body” from the “resin package enclosing the battery body,” and Tomioka specifically discloses that this technique is designed to “avoid damaging the battery body.” Ex. 1005 ¶¶ 25, 26, 29; Ex. 2011 ¶¶ 72–73. Thus, there is a significant difference between what Tomioka teaches and what Petitioner proposes to use the roller system to do. In addition, as Patent Owner points out, Tomioka specifically discloses there are risks associated with mechanically crushing battery packs, such as “risk of sparking due to residual voltage if the battery units are damaged in the process.” Ex. 1005 ¶ 5. Although we do not agree with Patent Owner that this amounts to a “teaching away,” see In re Gurley, 27 F.3d 551, 553 (Fed. Cir. 1994), we do believe that this teaching suggests a trade off that should be weighed in determining whether to make the modification, see Medichem S.A. v. Rolabo S.L., 437 F.3d 1157, 1165 (Fed. Cir. 2006). However, Petitioner has failed to account adequately, if at all, for this trade off. Thus, we find that Petitioner has failed to show that it is more likely than not that Tomioka accounts for the claimed “comminuting.”” slip op. at 15
§ 103 obviousness§ 112 disclosurecites Phillips · Graham · NautilusPatents in suitUS 12,119,463 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Solus’s rehearing request, leaving institution denied for claims 1–8 because the petition did not adequately show motivation to combine Hanafusa and Dobashi.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve Dobashi’s RSm values. Dobashi teaches that because RSm “can be adopted as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66–3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66– 3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 4
§ 103 obviousnessPatents in suitUS 11,346,014 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show that claims 1–10 were likely obvious over the asserted combinations.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re 1 US 2013/0108922 A1, published May 2, 2013 (Ex. 1004, “Shinozaki”). 2 G. Khatibi, Temperature Dependent Elastic and Thermal Properties of Thin Copper Foils, Copper; Proceedings of the International Conference Copper ’06 (2006) (Ex. 1006, “Khatibi”). 3 Korean Patent Pub. No. 10-2012-0003485, published Jan. 10, 2012 (Ex. 1013; Ex. 1014 (English translation), “Toshio”). 4 US 2013/0108887 A1, published May 2, 2013 (Ex. 1012, “Kim”). 5 Griesi, M.B., Characterization of Electrodeposited Copper Foil Surface Roughness for Accurate Conductor Power Loss Modeling (2014) (Master’s Thesis, University of South Carolina) (Ex. 1015, “Griesi”). rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Not shown unpatentable
“For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE[6] value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added).” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner, however, does not adequately explain why a POSITA would have been motivated to modify Kim’s copper foil surface to have a Pc value of 19.2 as reported in Griesi. In particular, neither Petitioner nor Dr. Randall points us to, nor do we discern, any teaching in Griesi that a peak count of 19.2 provides any particular benefits or properties that would have lead a POSITA to modify Kim’s copper foil surface as Petitioner proposes. Instead, Petitioner’s arguments that a POSITA would have been motivated to modify Kim’s copper foil surface with Griesi’s peak count patent itself. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 421 (2007) (stating that the fact finder must be aware “of the distortion caused by hindsight bias and must be cautious of arguments reliant upon ex post reasoning”). It was Petitioner’s burden to establish that the combined teachings Kim and Griesi disclose limitation [1g] as proposed. We are not persuaded that we misapprehended Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 8
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish the Khatibi, alone or in combination with Shinozaki, Toshio, and Kim, discloses limitation [1d]. We concluded that Petitioner failed to meet that burden for the reasons explained in our Decision. We are not persuaded that we overlooked or misapprehended Khatibi’s disclosures, or Petitioner’s evidence and explanation thereof, in doing so.7” slip op. at 5
§ 103 obviousnesscites KSRPatents in suitUS 10,811,689 - Micron Technology, Inc. v. Yangtze Memory Technologies Co., Ltd.Institution deniedPTAB · Aug 8, 2025 · IPR2025-00244 · APJ Kimberly Mcgraw · IPR · Institution
The Board denied institution because the petition did not sufficiently show that Costa disclosed or suggested claim 11.H’s required arrangement, and the dependent claims did not cure that deficiency.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“In view of these deficiencies, the Petition fails to identify the proposed grounds for review with particularity as required by 35 U.S.C. § 312(a)(3) with respect to the limitations of independent claim [11.H]. Petitioner presents no arguments or evidence with respect to the dependent claims challenged under this ground that would remedy the defects noted above with respect to independent claim 11. See generally Pet. Thus, Petitioner has failed to demonstrate a reasonable likelihood that the subject matter of claims 11, 12, or 14–19 would have been obvious over Costa.” slip op. at 23
- BurdenDenied
“3. Analysis A petition is required to identify “with particularity[ ] the grounds on which the challenge to each claim is based, and the evidence that supports the grounds for the challenge.” 35 U.S.C. § 312(a)(3). The “petition . . . must include . . . [a] full statement of the reasons for the relief requested, including a detailed explanation of the significance of the evidence”). 37 C.F.R. § 42.22(a)(2). Our rules require that a petition include fully developed arguments. See 37 C.F.R. § 42.22(a)(2) (the “petition . . . must include . . . [a] full statement of the reasons for the relief requested, including a detailed explanation of the significance of the evidence”). The petition must include both an adequate explanation of how the claims should be construed as well as how the construed claims are unpatentable over the asserted prior art. 37 C.F.R. § 42.104(b)(3), (b)(4). Additionally, the “petition must specify where each element of the claim is found in the prior art.” 37 C.F.R. § 42.104(b)(4). A petition should also “explain why a person of ordinary skill in the art would have combined elements from specific references in the way the claimed invention does.” ActiveVideo Networks, Inc. v. Verizon Comm'ns, Inc., 694 F.3d 1312, 1328 (Fed. Cir. 2012). Thus, based on our rules, we only consider fully developed arguments set forth in the petition.” slip op. at 16
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITANot reached
“arguments. See, e.g., id. at 34–35 (arguing that “on” does not require overlap in the Z direction but “includes both objects that are merely touching (in any dimension) and objects that are in proximity to each other but not touching” (citing Ex. 1078, 1; Ex. 1001, 8:3–12)); see also id. at 36–38 (arguing that if “on” is construed to mean “directly on or on with an intermediate feature or layer therebetween,” then Costa’s second stacked layer 232, 242 and third channel structure (173) are “directly on” each other, because their edges are directly touching each other). The Petition, however, does not clearly present any of the claim construction arguments set forth in the Opposition Brief. See Paper 22 (not clearly identifying where the Petition provides the proposed claim construction); see generally Pet.; see also Pet. 33, 43, 56 (arguing “on” does not require “directly on” and permits intermediate layers but not presenting any of the other claim construction arguments set forth in the Opposition Brief). Nor did the Petition provide any particularized argument as to how Costa discloses or suggests a second stacked layer disposed on the third channel structure applying any of the claim constructions proposed in the Opposition Brief. See generally Pet. (presenting no argument that Costa’s second stacked layer 232, 242 is “on” semiconduction portion layer 173 (the asserted third channel structure) because they touch each other as shown above in Petitioner’s annotation of Costa Figure 21A). We will not consider any arguments not sufficiently set forth in the Petition. See 37 C.F.R. § 42.104(b)(3) (“the petition must set forth . . . [h]ow the challenged claim is to be construed”); 37 C.F.R. § 42.104(b)(4) (“the petition must set forth . . . [h]ow the construed claim is unpatentable”).” slip op. at 19
- Parallel petitionsNot reached
“Because we determine that Petitioner did not show a reasonable likelihood that it would prevail on the merits, we do not address Patent Owner’s parallel petitions argument.” slip op. at 23
Claim constructionDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,886,291 - Micron Technology, Inc. v. Yangtze Memory Technologies Co., Ltd.Institution deniedPTAB · Aug 8, 2025 · IPR2025-00245 · APJ Michael T Cygan · IPR · Institution
Institution was denied because Petitioner did not show a reasonable likelihood that claims 11, 13, and 15–17 would have been obvious over Costa or Costa and Oh.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“§ 42.4(a), we may only institute an inter partes review when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a); see also 37 C.F.R. § 42.108(c). Based upon our review of the present record, Petitioner has not sufficiently shown a reasonable likelihood it will prevail with respect to at least one of the challenged claims. Accordingly, we do not institute inter partes review.” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner states that none of the claims require express construction and the claims should receive their plain and ordinary meaning. Pet. 23. Patent Owner argues that no claim construction is necessary for the institution determination, and that the Petition “still fails if the claim term ‘on’ receives its plain and ordinary meaning -- e.g., physically in contact with or directly on top of with intervening objects therebetween.” Prelim. Resp. 20 (citing Ex. 2006 ¶ 66). Although Patent Owner argues that Petitioner has construed “on” as including indirectly on; i.e., where there is no physical contact, the Petition addressed now-disclaimed claim 18, and the Petition does not advance any construction for the remaining claims. See id. at 16–17 (citing Pet. 92; Ex. 1003 ¶ 258). Consequently, we determine that no construction is required to resolve the issues for institution.” slip op. at 7
- Skill levelSkill level petitioner adoptedOther
“we consider the level of ordinary skill at the time of filing. 35 U.S.C. § 103; see also Graham v. John Deere Co., 383 U.S. 1, 17 (1966) (discussing pre- AIA obviousness). Petitioner contends that a person of ordinary skill in the art (“POSITA”) would have had “a bachelor’s degree in electrical engineering or a similar discipline, along with 2–3 years of professional experience working with (e.g., researching, designing, or teaching) monolithic 3D structures and NAND memory devices, or an equivalent level of skill, knowledge, and experience (e.g., an advanced degree may replace 1 The Leahy-Smith America Invents Act, Pub. L. No. 112-29, 125 Stat. 284 (2011) (“AIA”), amended 35 U.S.C. § 103. The earliest claimed priority date for the ’241 patent is after the effective date of the applicable AIA amendment. See Ex. 1001, (63). Thus, we refer to the AIA version of 35 U.S.C. § 103. 2 Costa, US 2018/001282771 (filed Feb. 28, 2017, published June 28, 2018) (Ex. 1005, “Costa”). 3 Oh, US 2017/0154892 A1 (filed June 10, 2016, published June 1, 2017) (Ex. 1006, “Oh”). some of the professional experience). Pet. 23–24. Petitioner also asserts that a POSITA “would have been aware of and generally knowledgeable about 3D NAND’s structure, how it is manufactured, and its component parts.” Id. (citing Ex. 1003 ¶¶ 36–40). Patent Owner does not take a position on the level of ordinary skill in the art. Prelim. Resp. 11; see also Ex. 2006 ¶ 34 (applying Petitioner’s definition of a POSITA to the opinions set forth in the declaration but reserving the right to opine to an alternative level of a POSITA). At this stage of the proceeding, we adopt Petitioner’s definition of a POSITA as it appears consistent with the level of ordinary skill in the art that is reflected by the prior art of record.” slip op. at 6
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“We agree with Patent Owner that the Petition fails to sufficiently show that Costa teaches a “second stacked layer disposed on the third channel structure” as required by apparatus claim element [11.E]. The Petition asserts that Costa’s second alternating stack 232, 242 is formed “on the top surface of joint-level material layers.” Pet. 64. However, Costa refers to the term “joint-level material layers” as representing layers 175–177, not the asserted third channel structure 173. Ex. 1005 ¶¶ 166, 178, 184–85; see Ex. 2006 ¶ 77. Thus, under Petitioner’s characterization, which is consistent with Costa, Costa’s second alternating stack is not formed on the third channel structure, but instead, “on the top surface of the joint level material layers” that surround the third channel structure. Because Petitioner has not explained how a second alternating stack on the surface of the joint material layers teaches a second alternating stack disposed on the third channel structure, Petitioner has not met its obviousness burden for limitation [11.E].” slip op. at 11
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,482,532 - Micron Technology, Inc. v. Yangtze Memory Technologies Company, Ltd.Institution deniedPTAB · May 8, 2025 · IPR2025-00035 · APJ Michael T Cygan · IPR · Institution
The Board denied institution because Micron did not show a reasonable likelihood that claims 1–5, 8–13, or 15 were obvious over either asserted reference combination.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons given below, on this record, Petitioner has not established a reasonable likelihood that it would prevail in showing the unpatentability of at least one of challenged claims 1–5, 8–13, and 15 of the ’604 patent. Accordingly, we do not institute an inter partes review of the ’604 patent.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“We agree that Petitioner has not shown that a person having ordinary skill in the art at the critical time would have been motivated to replace the wordlines in the staircase region with dielectric material if the result is that one of the memory cell arrays becomes unavailable. Petitioner relies upon two usable arrays for its combination, emphasizing Thimmegowda as desirably enabling “a single conductive contact (e.g., 334a) to bidirectionally drive memory cells in the memory arrays on either side of the bridge”; i.e., both the left and right memory cell blocks. Pet. 26 (citing Ex. 1003 ¶¶ 81– 83; Ex. 1005, 9:49–51; 7:61–64), 41 (stating that in the combination, “there Similarly, Thimmegowda emphasizes that the purpose of its bridge is to connect first and second blocks, which desirably replaces prior connection methods that consumed silicon real estate and interfered with the goal of shrinking the sizes or increasing the densities of memory arrays. Ex. 1005, 1:11–25, 3:20–28; Ex. 1003 ¶¶ 79–80 (“allowing a single staircase to access both memory arrays”), 83 (“a stairstep electrically couples to a respective gate layer (wordline) in both of the blocks on the right and left”). Dr. Banerjee also underscores the importance of using both arrays, stating that the combination relies on “Thimmegowda’s bridge and array architecture (to drive two memory arrays with one wordline via)” as part of the reasonable expectation of success in such a combination Ex. 1003 ¶¶ 102, 113. Petitioner and Dr. Banerjee rely upon the motivation of reducing punch-through, because punch-through causes “yield loss”; i.e., loss of the usability of the wordlines connected by the punch-through. Ex. 1003 ¶ 103; Pet. 35. However, such advantage is premised on retaining both arrays, and neither Petitioner nor Dr. Banerjee explains how the advantages of reducing punch-through should be weighed against a disadvantage of losing access to one of the two arrays. Nor do Petitioner and Dr. Banerjee discuss how the advantages of metal gate replacement should be weighed against losing access to one of the two arrays.4 Patent Owner’s declarant, Dr. Giapis, attests to the undesirability of such a combination, in which one array 4 Additionally, the claims of the ’604 patent do not require a metal conductor portion; Petitioner does not explain why gate replacement to a metal conductor from a polysilicon conductor, described as used in Lee’s “memory device at large,” (Pet. 40) is a benefit associated with Lee’s finger teaching relevant to the claims. Ex. 2007 ¶¶ 50–54. We agree with Patent Owner that the advantage of preventing individual wordlines from becoming unusable because of punchthrough would be outweighed by the loss of half of the wordlines if one of the memory arrays were to become unavailable because its connections were removed.” slip op. at 15
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Not reached
“III. DISCRETION UNDER 35 U.S.C. § 314(a) Patent Owner argues that the Board should exercise its discretion to deny institution under 35 U.S.C. § 314(a) based on the factors set forth in Apple Inc. v. Fintiv, Inc., IPR2020-00019, Paper 11 at 6 (Mar. 20, 2020) additional briefing. Papers 12, 14. Because we determine that Petitioner has not shown a reasonable likelihood of success on the merits of its obviousness contentions, we need not resolve whether Fintiv would require discretionary denial of the Petition.6” slip op. at 23
- Skill levelSkill level petitioner adoptedOther
“at the critical time “would have had a bachelor of science degree in electrical engineering or a similar discipline, along with 2-3 years of professional experience working with (e.g., researching, designing, or teaching) 2 We apply AIA 35 U.S.C. § 103 to the ’604 patent because it was filed after, and never claimed the benefit of an effective filing date before, March 16, 2013. Ex. 1001, codes (22), (63); Pet. 6. 3 Neither party presents evidence or arguments regarding objective evidence of non-obviousness. Pet. 89; Prelim. Resp. level of skill, knowledge, and experience (e.g., an advanced degree may replace some of the professional experience).” Pet. 34 (citing Ex. 1003 ¶¶ 40–43). Petitioner further asserts that a POSITA “would have been aware of and generally knowledgeable about 3D NAND’s structure, its component parts, how it operates, and how it is controlled.” Id. Patent Owner does not provide any such assessment in its Preliminary Response. Prelim. Resp. 10. For purposes of this Decision, we adopt Petitioner’s proposed level of ordinary skill, as it appears to be consistent with the specification of the ’604 patent and the prior art of record.” slip op. at 6
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,450,604 - Cargill, Incorporated v. Bunge Loders Croklaan USA, LLCRehearing deniedPTAB · Apr 29, 2025 · IPR2024-01360 · APJ Debra L Dennett · IPR · Rehearing
The Board denied Cargill’s rehearing request, leaving institution denied for claims 1, 6–9, and 11–24 because the petition did not show a reason to combine the selected prior-art data without hindsight.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“Upon request for rehearing, we assess a decision on institution “for an abuse of discretion” (37 C.F.R. § 42.71(c) (2020)), which occurs when a “decision was based on an erroneous conclusion of law,” “clearly erroneous factual findings,” or “a clear error of judgment.” PPG Indus. Inc. v. Celanese Polymer Specialties Co., 840 F.2d 1565, 1567 (Fed. Cir. 1988) (citations omitted). The burden of showing a decision should be modified lies with the party challenging the decision. 37 C.F.R. § 42.71(c) (2020). The request must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply. Id. Thus, a request for rehearing is not an opportunity merely to disagree with the Board’s assessment of the arguments or weighing of the evidence, or to present new arguments or evidence. We have reviewed Petitioner’s Rehearing Request and carefully considered all the arguments presented. For the following reasons, we are not persuaded that we misapprehended or overlooked any arguments or evidence.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“As discussed in the Decision, “obviousness concerns whether a skilled artisan not only could have made but would have been motivated to make the combinations or modifications of prior art to arrive at the claimed invention.” Belden Inc. v. Berk-Tek LLC, 805 F.3d 1064, 1073 (Fed. Cir. 2015) (citing InTouch Technologies, Inc. v. VGO Communications, Inc., 751 F.3d 1327, 1352 (Fed. Cir. 2014)). No matter the result of combining the allegedly “readily available and well-known” information taken from particular examples from the “documentary evidence” with Petrauskaite’s disclosure, a POSITA had to have been motivated to do so at the time the invention was made.1 What is missing from the Petition is the “why.” The only motivating force in this case appears to be hindsight spurring Petitioner on to choose particular examples of palm stearin disclosed in Deffense and the soybean oil in Neff in order to justify its assertion that Petrauskaite discloses the claimed wt% ranges of triglyceride classes.” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightMotivation not foundNot shown unpatentableNot shown unpatentable
“artisan not only could have made but would have been motivated to make the combinations or modifications of prior art to arrive at the claimed invention.” Belden Inc. v. Berk-Tek LLC, 805 F.3d 1064, 1073 (Fed. Cir. 2015) (citing InTouch Technologies, Inc. v. VGO Communications, Inc., 751 F.3d 1327, 1352 (Fed. Cir. 2014)). No matter the result of combining the allegedly “readily available and well-known” information taken from particular examples from the “documentary evidence” with Petrauskaite’s disclosure, a POSITA had to have been motivated to do so at the time the invention was made.1 What is missing from the Petition is the “why.” The only motivating force in this case appears to be hindsight spurring Petitioner on to choose particular examples of palm stearin disclosed in Deffense and the soybean oil in Neff in order to justify its assertion that Petrauskaite discloses the claimed wt% ranges of triglyceride classes.” slip op. at 4
- Strike new argumentNew argument disregardedDecided for patent owner
“Petitioner’s. We find no instance in the Petition in which “motivation” and “iodine value” are discussed together or linked in any way. The same can be said of Dr. Marangoni’s declaration. And, as noted in the Decision, it was not until the Preliminary Reply that Petitioner argued that specific data on fatty acid wt% used for the conversion calculations were selected to represent “knowledge generally available to one of ordinary skill in the art” due to similarity of the iodine value (“IV”) of the palm stearin (and soybean oil) disclosed in Petrauskaite. See Prelim. Reply 2–3. New evidence or argument in the Preliminary Reply that could have presented earlier is not permitted. On this record, we find Petitioner relies its Rehearing Request on arguments about a motivation to combine, stemming from the significance of iodine values, that were not raised in the Petition. Accordingly, Petitioner fails to support that the Decision misapprehended or overlooked arguments in the Petition about the significance of iodine values.” slip op. at 8
§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,645,473 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 25, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–8 were unpatentable under the asserted obviousness grounds.
RulingsInstitution decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“experience working on the development of materials or components for electronic devices such as batteries.” Pet. 2. Petitioner further contends that “[a]dditional education, such as a graduate degree, could compensate for less work experience, and additional work experience could compensate for less formal education.” Id. Patent Owner states that, “[f]or purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art.” Prelim. Resp. 4. For purposes of this Decision, we adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’014 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” 37 C.F.R. § 42.100(b). Under this standard, claim terms are generally given their plain and ordinary meaning as would have been understood by a person of ordinary skill in the art at the time of the invention and in the context of the entire patent disclosure. Phillips v. AWH Corp., 415 F.3d 1303, 1313 (Fed. Cir. 2005) (en banc). Only those terms in controversy need to be construed, and only to the extent necessary to resolve the controversy. Realtime Data LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019). in this proceeding.” Pet. 3. Patent Owner contends that “[t]he Board need not construe any term in order to determine that institution should be denied.” Prelim. Resp. 4. Based on the record before us, we determine that no claim term requires express construction for purposes of this Decision. See Realtime Data, 912 F.3d at 1375.” slip op. at 8
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“For these reasons, we are not persuaded that Petitioner sufficiently establishes that a POSITA would have been motivated to modify Hanafusa in light of Dobashi with a reasonable expectation of success as Petitioner contends. Accordingly, we determine that Petitioner fails to demonstrate a reasonable likelihood of prevailing in its assertion that the subject matter of claim 1, and claims 4 and 8 that depend therefrom, would have been obvious over the combined teachings of Hanafusa and Dobashi.” slip op. at 18
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“Petitioner also focuses on Hanafusa’s teaching that all known methods can be used to make a rough surface low-profile, and Dobashi’s teaching that RSm can be used as an indicator for judgment of the surface, to support its contention that a POSITA would have been motivated to apply Dobashi’s RSm to further achieve Hanafusa’s purpose, without explaining how and why that would be the case. In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness and is rough when RSm is small.” Id. at 3:1–3, 6:27–29. Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66– 3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66–3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 14
Claim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 11,346,014 - PTAB · Apr 25, 2025 · IPR2024-00793 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Micron’s rehearing requests, finding no misapprehension or overlooked matter in its denial of institution based on the failure to show the challenged claims obvious.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“Petitioner’s own formulations of the grounds based on either Seo or Nam in combination with Choi posit the alternative theories that either Seo or Nam alone disclose Limitation [1.D], or the combination of either Seo or Nam with Choi teaches this limitation. Although Petitioner did not invoke inherency by name for the theories based on Seo or Nam alone, this is, in effect, the nature of Petitioner’s assertions, namely, voltage differentials in Seo and Nam would inherently remove fast charges. For example, with respect to Seo, Petitioner argues that “Seo teaches having a higher voltage on unselected WLs (e.g., adjacent WLs to the selected WL) during the first time period,” and “the ’342 patent recognizes [that] this voltage differential removes fast charges.” Pet. 35–36 (citing Ex. 1001, 12:24–34; Ex. 1003 ¶¶ 129–131) (emphasis omitted); see also id. at 82–83 (relying on the ’342 patent to support the contention that Nam teaches Limitation [1.D] because Nam “teaches having a higher voltage on unselected WLs (including WLs adjacent to the selected WL) relative to the selected WL during the first time period” (citing Ex. 1001, 12:24–34) (emphasis omitted)). Petitioner does not argue that Seo and Nam expressly disclose removing fast charges or sufficiently explain how a POSITA would have understood that the procedures used in Seo and Nam would have removed fast charges; instead, Petitioner effectively argues that removing fast charges is the inherent result of applying the voltage differential. See, e.g., Pet. 36 (stating Seo would have been understood to disclose “performing its read operation on chargetrap memories, which removes fast charges”).” slip op. at 5
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Petitioner’s reliance on Choi does not cure the deficiencies set forth above. Petitioner asserts that “Choi explains the primary mechanism and unwanted impact of fast-charge loss on verification,” which provides the motivation “to use Seo’s and Nam’s methods to achieve fast charge removal to improve verification.” Req. 7 n.1. But again, Petitioner does not sufficiently explain how a POSITA, looking at Choi, would have understood that either Seo’s or Nam’s techniques result in fast charge removal. In other words, even if Choi teaches the impact of fast-charge loss on verification, Petitioner fails to sufficiently show that a POSITA would have understood that either Seo or Nam teach or suggest fast charge removal. It was Petitioner’s burden to establish that Seo and Nam, alone or in combination with Choi, disclose Limitation [1.D]. We are not persuaded that we misapprehended the nature of Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 7
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish that Seo and Nam, alone or in combination with Choi, disclose Limitation [1.D]. We are not persuaded that we misapprehended the nature of Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner’s reliance on Choi does not cure the deficiencies set forth above. Petitioner asserts that “Choi explains the primary mechanism and unwanted impact of fast-charge loss on verification,” which provides the motivation “to use Seo’s and Nam’s methods to achieve fast charge removal to improve verification.” Req. 7 n.1. But again, Petitioner does not sufficiently explain how a POSITA, looking at Choi, would have understood that either Seo’s or Nam’s techniques result in fast charge removal. In other words, even if Choi teaches the impact of fast-charge loss on verification, Petitioner fails to sufficiently show that a POSITA would have understood that either Seo or Nam teach or suggest fast charge removal.” slip op. at 7
§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,600,342 - PTAB · Apr 25, 2025 · IPR2024-00912 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Micron’s rehearing requests, leaving institution denied because the petitions did not show that the prior-art combinations disclose or render obvious fast-charge removal.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re Gartside, 203 F.3d 1305, 1315–16 (Fed. Cir. 2000)). The party requesting rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 3
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“It was Petitioner’s burden to establish that Seo and Nam, alone or in combination with Choi, disclose Limitation [1.D]. We are not persuaded that we misapprehended the nature of Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“determined that the combinations of Seo or Nam with Choi were not persuasive. Dec. 14–15, 19–20. For example, we determined that “Dr. Liu’s statement that ‘[a] POSITA would have recognized that the lateral-electrical-field-inducing voltage differential, as Seo discloses, is what Choi describes as driving the lateral fast-charge loss,’ is not supported by objective evidence or sufficient explanation as to why a POSITA would have come to that understanding” and was therefore insufficient to support Petitioner’s asserted motivation to combine Seo with Choi. Id. at 14–15. In particular, we were not persuaded that “Seo creates a large lateral electric field like the one described in Choi,” and, in any case, we disagreed that “Choi teaches that a large lateral electric field removes fast charges.” Id. at 15. Accordingly, regardless of the duration of the voltage application described in Seo, Petitioner failed to show that the combination of Seo and Choi would result in removal of fast charges. We further determined that Petitioner’s combination of Nam with Choi was problematic for similar reasons, given Petitioner’s reliance on similar arguments. See id. at 20.” slip op. at 10
- Expert testimonyPetitioner expert discountedOther
“the knowledge of one of ordinary skill in the art relating to charge-trap memory devices demonstrates fast charge removal. See Pet. 36, 81–82. And although Petitioner cites its declarant, Dr. Liu, for the proposition that “Seo discloses, and would have been understood to disclose, performing its read operation on charge-trap memories, which removes fast charges,” Dr. Liu does not cite objective evidence to support this assertion, aside from the ’342 patent itself. Id. at 36 (citing Ex. 1003 ¶ 136). Moreover, Dr. Liu’s testimony simply circles back to logic similar to that relied on with respect to the inherency theory, namely that, given certain similarities between Seo and the ’342 patent, Seo removes fast charges because the ’342 patent teaches removing fast charges, even though Seo does not explicitly teach doing so. See Ex. 1003 ¶ 136 (“[A] POSITA would have immediately understood from reading Seo that Seo is disclosing its read operation as applicable to Flash memories, including Flash charge-trap memories. And as the ’342 states, Seo’s operation would remove fast charges in a charge-trap memory.” (citing Ex. 1001, Abstract)). As already discussed, we disagree with this logic based on the lack of sufficient evidence to support its conclusion. See Dec. 13 (“Petitioner and Dr. Liu do not provide any objective evidence or explanation as to how or why a POSITA would have understood that Seo’s voltage amounts applied during Seo’s time periods operate the same way [as in the ’342 patent] on Seo’s memory device to generate fields with sufficient magnitude and duration to remove fast charges.”). Petitioner’s assertions regarding Nam suffer from the same shortcomings. See Dec. 19–20; Pet 82 (“[A] POSITA would have found that Nam’s teachings are applicable to charge-trap devices”); Ex. 1003 ¶¶ 293–298.” slip op. at 8
§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,600,342
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.