- Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Solus’s rehearing request, leaving institution denied for claims 1–8 because the petition did not adequately show motivation to combine Hanafusa and Dobashi.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve Dobashi’s RSm values. Dobashi teaches that because RSm “can be adopted as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66–3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66– 3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 4
§ 103 obviousnessPatents in suitUS 11,346,014 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show that claims 1–10 were likely obvious over the asserted combinations.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re 1 US 2013/0108922 A1, published May 2, 2013 (Ex. 1004, “Shinozaki”). 2 G. Khatibi, Temperature Dependent Elastic and Thermal Properties of Thin Copper Foils, Copper; Proceedings of the International Conference Copper ’06 (2006) (Ex. 1006, “Khatibi”). 3 Korean Patent Pub. No. 10-2012-0003485, published Jan. 10, 2012 (Ex. 1013; Ex. 1014 (English translation), “Toshio”). 4 US 2013/0108887 A1, published May 2, 2013 (Ex. 1012, “Kim”). 5 Griesi, M.B., Characterization of Electrodeposited Copper Foil Surface Roughness for Accurate Conductor Power Loss Modeling (2014) (Master’s Thesis, University of South Carolina) (Ex. 1015, “Griesi”). rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Not shown unpatentable
“For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE[6] value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added).” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner, however, does not adequately explain why a POSITA would have been motivated to modify Kim’s copper foil surface to have a Pc value of 19.2 as reported in Griesi. In particular, neither Petitioner nor Dr. Randall points us to, nor do we discern, any teaching in Griesi that a peak count of 19.2 provides any particular benefits or properties that would have lead a POSITA to modify Kim’s copper foil surface as Petitioner proposes. Instead, Petitioner’s arguments that a POSITA would have been motivated to modify Kim’s copper foil surface with Griesi’s peak count patent itself. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 421 (2007) (stating that the fact finder must be aware “of the distortion caused by hindsight bias and must be cautious of arguments reliant upon ex post reasoning”). It was Petitioner’s burden to establish that the combined teachings Kim and Griesi disclose limitation [1g] as proposed. We are not persuaded that we misapprehended Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 8
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish the Khatibi, alone or in combination with Shinozaki, Toshio, and Kim, discloses limitation [1d]. We concluded that Petitioner failed to meet that burden for the reasons explained in our Decision. We are not persuaded that we overlooked or misapprehended Khatibi’s disclosures, or Petitioner’s evidence and explanation thereof, in doing so.7” slip op. at 5
§ 103 obviousnesscites KSRPatents in suitUS 10,811,689 - Tesla, Inc. v. Intellectual Ventures II LLCInstitution deniedPTAB · Jun 11, 2025 · IPR2025-00218 · APJ Frederick C Laney · IPR · Institution
The Board denied institution because the Kim and Vayanos combination did not show that each individual bit indicates a separate time interval, as required by claims 1–12.
RulingsInstitution decision- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“limitation 1.2 because it is more consistent with the claim language and the specification of the ’416 patent. The language “each of the plurality of bits” clearly individualizes the “plurality of bits” and the language “indicates a respective time interval that physical shared channel resources are utilized to signal channels” clearly ascribes to each individual bit the function of identifying a time interval that is separate from the time interval(s) that the other individual bit(s) identify. Petitioner’s claim constriction argument largely ignores the words used in limitation 1.2. Petitioner fails to provide anything to explain how or why the plain meaning of “each” and “respective” in the context of limitation 1.2 could be understood by a skilled artisan to connote something other than the plurality of bits individually identifying a separate and distinct time interval (i.e., a “one-to-one correspondence”). Petitioner similarly does not identify anything from the specification of the ’416 patent that would support deviating from the plain meaning of limitation 1.2. And Petitioner’s reliance on 3M Innovative Properties appears to miss the mark. Pet. Reply 7. In that case, the Federal Circuit held that, when a claim term has an “ascertainable definition in the body of the claim,” their “cases do not support prescribing a more particularized meaning unless a narrower construction is required by the specification or prosecution history.” 3M Innovative Properties Co., 725 F.3d at 1329. Here, however, Patent Owner is not attempting to import a more particularized meaning into limitation 1.2, but to demonstrate that the ’416 specification is consistent with the ascertainable definition of “each” and “respective” within the context of limitation 1.2. In particular, Patent Owner highlights that the ’416 specification describes the resource allocation technique as using an indicator bit, within a plurality of indicator bits, that has a one-to-one correspondence to a specific time window established for a Forward Access Channel (FACH). See Ex. 1001, 13:63–14:25, 14:44–53, Figs. 7, 9; PO Resp. 11–14, 19–20; PO Sur-reply 2–3; Ex. 2001 ¶¶ 36–40, 49. And we agree that the ’416 specification informs, and is consistent with, the plain reading of limitation 1.2. See Ex. 1001, 13:63–14:25, 14:44–53, Figs. 7, 9. Therefore, we determine that the plain and ordinary meaning of limitation 1.2 requires all the plurality of bits to individually identify a separate and distinct time interval that physical shared channel resources are utilized to signal channels.” slip op. at 12
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“PICH, which is communicated to Kim’s receiver, has a plurality of bits, the evidence fails to demonstrate sufficiently that each of those bits indicates a respective time interval that physical shared channel resources are utilized to signal channels, as limitation 1.2 recites. As Patent Owner correctly argues, the Vayanos paging indicators use multiple bits to indicate information about a single time interval in a frame, rather having several bits that individually identify a separate and distinct time interval. PO Resp. 39–41 (citing Ex. 2001 ¶¶ 67, 74–75). Vayanos teaches that “[t]he number of paging indicators (Np) in each PICH frame is configurable by the system and can take on a value of 18, 36, 72 or 144,” and that “[e]ach paging indicator is sent in 288/Np consecutive bits in the PICH frame, where 288/Np can take on a value of 16, 8, 4 or 2.” Ex. 1006, 3:26–34. As a result, if there are 18 (Np = 18) paging indicators, 288/NP = 288/18 = 16 (meaning that each paging indicator is 16 bits long), if there are 36 (Np = 36) paging indicators, 288/Np = 288/36 = 8 (meaning that each paging indicator is 8 bits long), if there are 72 (Np=72) paging indicators, 288/Np = 288/72= 4 (meaning that each paging indicator is 4 bits long), and if there are 144 (Np=144) paging indicators, 288/Np = 288/144 = 2 (meaning that each paging indicator is 2 bits long). Ex. 2001 ¶ 66. Each paging indicator (singular) taught by Vayanos includes multiple bits––each paging indicator (singular) has either 16, 8, 4 or 2 bits–– and Vayanos does not disclose or suggest a paging indicator that indicates a time interval with only a single bit. Id. And Petitioner does not cite Kim to show the number of bits used to indicate a time interval; only to show that a UE would receive broadcast information with paging information including paging indicators that identify a time interval in which physical shared channel resources are utilized to signal channels. See Pet. 40–49. Even accepting that the Kim/Vayanos combination discloses a UE receiving a paging indicator that is indicative of a time interval in which a Paging Channel PCH may be found or indicative of whether a frame will include a signaling channel (e.g., PCH) at a specific TTI within that frame, the combination does not disclose or suggest using a paging indicator that is a single bit indicating either of those time intervals. On the contrary, as noted above, Vayanos teaches that all paging indicators consist of multiple bits and, thus, the Kim/Vayanos combination discloses a UE that only receives and uses a plurality of bits to indicate a time interval that physical shared channel resources are utilized to signal channels. This is insufficient to show a reasonable likelihood that Petitioner will be able to establish that the Kim/Vayanos combination discloses or suggests receiving a plurality of bits wherein the individual bits each identify a separate and distinct time interval. Therefore, Petitioner has not shown sufficiently that the Kim/Vayanos combination discloses or suggests the subject matter limitation 1.2 recites. For the above reasons, we are not persuaded that Petitioner has shown sufficiently that the combination of Kim and Vayanos disclose or suggest broadcast information that includes a plurality of bits, wherein each of the plurality of bits indicates a respective time interval that physical shared channel resources are utilized to signal channels. This failing undermines Petitioner’s showing as to independent claims 1 and 7 (in the asserted Grounds 1 and 2) and, as a result, the same deficiency extends through to all of the dependent claims challenged in all of the grounds.4” slip op. at 18
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“sufficiently that the combination of Kim and Vayanos disclose or suggest broadcast information that includes a plurality of bits, wherein each of the plurality of bits indicates a respective time interval that physical shared channel resources are utilized to signal channels. This failing undermines Petitioner’s showing as to independent claims 1 and 7 (in the asserted Grounds 1 and 2) and, as a result, the same deficiency extends through to all of the dependent claims challenged in all of the grounds.4 IV. CONCLUSION Based on the arguments and evidence presented by the parties, we conclude that Petitioner has not demonstrated a reasonable likelihood of prevailing with respect to at least one claim of the ’416 patent challenged in the Petition. Therefore, we do not institute an inter partes review.” slip op. at 20
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,136,416 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 25, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–8 were unpatentable under the asserted obviousness grounds.
RulingsInstitution decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“experience working on the development of materials or components for electronic devices such as batteries.” Pet. 2. Petitioner further contends that “[a]dditional education, such as a graduate degree, could compensate for less work experience, and additional work experience could compensate for less formal education.” Id. Patent Owner states that, “[f]or purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art.” Prelim. Resp. 4. For purposes of this Decision, we adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’014 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” 37 C.F.R. § 42.100(b). Under this standard, claim terms are generally given their plain and ordinary meaning as would have been understood by a person of ordinary skill in the art at the time of the invention and in the context of the entire patent disclosure. Phillips v. AWH Corp., 415 F.3d 1303, 1313 (Fed. Cir. 2005) (en banc). Only those terms in controversy need to be construed, and only to the extent necessary to resolve the controversy. Realtime Data LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019). in this proceeding.” Pet. 3. Patent Owner contends that “[t]he Board need not construe any term in order to determine that institution should be denied.” Prelim. Resp. 4. Based on the record before us, we determine that no claim term requires express construction for purposes of this Decision. See Realtime Data, 912 F.3d at 1375.” slip op. at 8
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“For these reasons, we are not persuaded that Petitioner sufficiently establishes that a POSITA would have been motivated to modify Hanafusa in light of Dobashi with a reasonable expectation of success as Petitioner contends. Accordingly, we determine that Petitioner fails to demonstrate a reasonable likelihood of prevailing in its assertion that the subject matter of claim 1, and claims 4 and 8 that depend therefrom, would have been obvious over the combined teachings of Hanafusa and Dobashi.” slip op. at 18
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“Petitioner also focuses on Hanafusa’s teaching that all known methods can be used to make a rough surface low-profile, and Dobashi’s teaching that RSm can be used as an indicator for judgment of the surface, to support its contention that a POSITA would have been motivated to apply Dobashi’s RSm to further achieve Hanafusa’s purpose, without explaining how and why that would be the case. In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness and is rough when RSm is small.” Id. at 3:1–3, 6:27–29. Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66– 3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66–3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 14
Claim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 11,346,014 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 23, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–10 were unpatentable over either asserted § 103 ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314 (2018); see also 37 C.F.R. § 42.4 (2023). For the reasons discussed below, we deny the Petition and do not institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“II. ANALYSIS A. Level of Ordinary Skill in the Art Petitioner contends that a person of ordinary skill in the art (“POSITA”) “would have had at least an undergraduate degree in materials science, chemical engineering, electrical engineering, or related field, or equivalent knowledge, training, or experience, with at least two years of experience working on the development of materials or components for electronic devices such as batteries.” Pet. 4. Petitioner further contends that “[a]dditional education, such as a graduate degree, could compensate for less 7 We refer to the page numbers added by Petitioner to the bottom-center of the page. formal education.” Id. (citing Ex. 1003 ¶ 10). Patent Owner states that, “[f]or purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art.” Prelim. Resp. 4. For purposes of this Decision, we adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’689 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163–64 (Fed. Cir. 1985))).” slip op. at 10
- Expert testimonyPetitioner expert discountedDecided for patent owner
“We are not persuaded, on this record, that Petitioner adequately establishes that Khatibi discloses a CTE in the claimed range of 16 to 22 µm/(m·°C.). Petitioner’s argument that Khatibi’s reported values meet this claim limitation are based solely on Dr. Randall’s testimony that Khatibi’s measurement method would produce results that would not significantly differ from results determined using the claimed method. See Pet. 16–18 (citing Ex. 1003 ¶¶ 56–60). Dr. Randall’s testimony, however, is largely conclusory and unsupported by adequate explanation and/or objective evidence. For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added). to little weight. See 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); Xerox Corp. v. Bytemark, Inc., IPR2022-00624, Paper 12 at 5 (PTAB Feb. 10, 2023) (finding that “the Board was correct in giving little weight to Petitioner’s expert because the expert declaration merely offered conclusory assertions without underlying factual support”); Upjohn Co. v. Mova Pharm. Corp., 225 F.3d 1306, 1311 (Fed. Cir. 2000) (“Lack of factual support for expert opinion to factual determinations, however, may render the testimony of little probative value in a validity determination.” (quoting Ashland Oil, Inc. v. Delta Resins and Refractories, Inc., 776 F.2d 281, 294 (Fed. Cir. 1985))); see also In re Ethicon, Inc., 844 F.3d 1344, 1348, 1352 (Fed. Cir. 2017) (concluding that the Board properly gave “little weight” to conclusory expert testimony of objective indicia). Because Petitioner offers Dr. Randall’s testimony to supply a limitation missing from the prior art, namely, the CTE measurement method, and we give Dr. Randall’s unsupported and conclusory testimony little weight, we are not persuaded that Petitioner establishes a reasonable likelihood of showing that Khatibi discloses limitation [1d].” slip op. at 17
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“second surfaces of the electrolytic copper foil ranges from 3 to 92.” Ex. 1001, 13:62–63. Petitioner contends that “Kim teaches that the electrolytic copper foil (e.g., untreated or treated copper foil) having Rz less than 2 µm is advantageous toward battery efficiency and performance,” and, similarly, Griesi describes the use of untreated electrolytic copper foil with an Rz value less than 2 µm in printed circuit boards that are compatible with secondary batteries. Pet. 58–59 (citing Ex. 1012, claim 2, ¶¶ 13, 25, 27; Ex. 1003 ¶ 157). In particular, Petitioner notes that Griesi’s Figure 3.16 describes an “Rz value of 1.2 µm.” Id. at 59 (citing Ex. 1015, 53–54; Ex. 1003 ¶ 158). Petitioner asserts that “Dr. Randall explains that a POSITA would have also recognized another surface roughness-related parameter, Rpc, in Griesi as a potentially useful parameter that can be optimized to further enhance uniformity or generally improve Kim’s copper foil surface, for example, to prevent wrinkles or achieve other advantageous effects.” Id. (citing Ex. 1003 ¶ 159). Although Dr. Randall demonstrates that Griesi’s Pc (or Rpc) value is 19.2 over a 4 mm sampling length (Ex. 1003 ¶ 155), Petitioner does not contend that Griesi addresses this value, or indicates any benefit that might be derived from its use. Instead, Griesi’s Pc value appears to be an incidental finding, which is not discussed or analyzed in the reference. See incidental, unexamined finding would lead a POSITA to import Griesi’s Pc value into Kim’s copper foil, absent a hindsight desire to reconstruct the claimed invention. As such, Petitioner’s arguments with respect to Kim and Griesi are not persuasive. See Cheese Sys. Inc. v. Tetra Pak Cheese and Powder Sys., Inc., 725 F.3d 1341, 1352 (Fed. Cir. 2013) (“Obviousness cannot be based on the hindsight combination of components selectively culled from the prior art to fit the parameters of the patented invention.” (internal quotations marks omitted)). Thus, we are not persuaded, on this record, that the combined disclosures of Kim and Griesi teach all of the elements of limitation [1g].” slip op. at 23
§ 103 obviousnesscites PhillipsPatents in suitUS 10,811,689 - Samsung Electronics Co., Ltd. v. Anonymous Media Research Holdings, LLCInstitution deniedPTAB · Mar 24, 2025 · IPR2024-01349 · APJ Frederick C Laney · IPR · Institution
The Board denied institution because claims 1–13 are entitled to the May 26, 2005 priority date, making the asserted references not prior art and the obviousness grounds unlikely to prevail.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsDenied
“to show with particularity why the patent it challenges is unpatentable.” Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1363 (Fed. Cir. 2016); see also 35 U.S.C. § 312(a)(3) (requiring inter partes review petitions to identify “with particularity . . . the evidence that supports the grounds for the challenge to each claim”). This burden of persuasion never shifts to the patent owner. See Dynamic Drinkware, LLC v. Nat’l Graphics, Inc., 800 F.3d 1375, 1378 (Fed. Cir. 2015). Thus, if Petitioner has not satisfied the threshold reasonable likelihood standard for institution, then institution will be denied. See id. at 1378–1379.” slip op. at 8
- Disclosure Requirements (§112) › Written description (Ariad)Written description adequateEntitled to earlier dateDecided for patent owner
“disclosed in the manner provided by the first paragraph of section 112 of this title in an application previously filed in the United States . . . shall have the same effect, as to such invention, as though filed on the date of the prior application.” (emphasis added). “In essence, this means that in a chain of continuing applications, a claim in a later application receives the benefit of the filing date of an earlier application so long as the disclosure in the earlier application meets the requirements of 35 U.S.C. § 112, ¶ 1, including the written description requirement, with respect to that claim.” Technology Licensing Corp. v. Videotek, Inc., 545 F.3d 1316, 1326 (Fed. Cir. 2008). And to determine whether a parent application meets the written description requirement, “the disclosure must be considered as a whole, as the person of ordinary skill in the art would read it, to determine if it reasonably conveys possession” of the claimed invention. Allergan USA, Inc. v. MSN Labs. Private Ltd., 111 F.4th 1358, 1375 (Fed. Cir. 2024) (citation and emphasis omitted); see also Reiffin v. Microsoft Corp., 214 F.3d 1342, 1345–46 (Fed. Cir. 2000) (the purpose of the written description requirement “is to ensure that the scope of the right to exclude . . . does not overreach the scope of the inventor’s contribution to the field of art as described in the patent specification”).” slip op. at 9
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not reached
“A claim is unpatentable under 35 U.S.C. § 103(a) if the differences between the claimed subject matter and the prior art are such that the subject matter, as a whole, “would have been obvious at the time the invention was made to a person having ordinary skill in the art to which said subject matter pertains.” KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 406 (2007). The question of obviousness is resolved on the basis of underlying factual differences between the claimed subject matter and the prior art; (3) the level of ordinary skill in the art; and (4) if presented, objective evidence of non-obviousness. See Graham v. John Deere Co., 383 U.S. 1, 17–18 (1966). As previously noted, the first factor regarding the scope of available prior art is the dispositive issue of this Petition, which is largely defined by the effective filing date of the challenged claims.” slip op. at 8
- PTAB / AIA Trials › Other PTAB motions (exclude, strike, seal, additional discovery, rehearing)Denied
“Because we determine that no inter partes review will be instituted on IPR2024-01350, we find it unnecessary to exercise exclusive jurisdiction over the ’849 patent. See Paper 9, 9. Therefore, Petitioner’s motion for the Board to exercise exclusive jurisdiction over the ’849 patent is denied. Petitioner further requests that all briefing in this proceeding be provided to the Certificates of Correction and Petitions branches for their consideration, citing Patent Owner’s “duties of candor and good faith.” Id. at 2, 10. However, in view of our determination not to institute review in this proceeding, we defer to the Certificates of Correction and Petitions branches to carry out their duly authorized duties. Honeywell Int’l Inc. v. Arkema Inc., 939 F.3d 1345, 1349 (Fed. Cir. 2019).” slip op. at 23
§ 103 obviousness§ 112 disclosurecites Phillips · KSR · GrahamPatents in suitUS 10,719,849 - Samsung Electronics Co., Ltd v. Anonymous Media Research Holdings, LLCInstitution deniedPTAB · Mar 21, 2025 · IPR2024-01350 · APJ Michael T Cygan · IPR · Institution
Institution was denied for claims 1–15 because Petitioner did not show the asserted references were prior art; the claims were supported by the ’330 application’s 2005 filing date.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“To prevail on its obviousness challenges, Petitioner must show that the ’848 patent is not entitled to the benefit of the ’330 application. This issue is dispositive because none of the references relied on by Petitioner qualify as prior art if the ’848 patent is entitled to the benefit of the May 26, 2005, filing date of the ’330 application. Pet. 6, 13. We start by explaining why Petitioner bears the burden of persuasion.” slip op. at 9
- BurdenDecided for patent owner
“1. The Burden of Persuasion “In an inter partes review . . ., the petitioner shall have the burden of proving a proposition of unpatentability by a preponderance of the evidence.” 35 U.S.C. § 316(e). That burden, termed the burden of persuasion, “is the ultimate burden assigned to a party who must prove something to a specified degree of certainty.” Dynamic Drinkware, LLC v. National Graphics, Inc., 800 F.3d 1375, 1378 (quoting Tech. Licensing Corp. v. Videotek, Inc., 545 F.3d 1316, 1326–27 (Fed. Cir. 2008)). That burden never shifts to the patentee. Id. at 1379. In order for an inter partes review to be instituted, “the information presented in the petition filed under section 311 and any response filed under section 313 [must] show[] that there is a reasonable likelihood that the petitioner would prevail.” 35 U.S.C. § 314(a).” slip op. at 9
- Disclosure Requirements (§112) › Written description (Ariad)Written description adequateEntitled to earlier dateDecided for patent owner
“d) Analysis Petitioner has not shown a reasonable likelihood that it would prevail in showing that its asserted references, including Steuer 750 which is a publication of the ’330 application, are prior art to the ’848 patent. Petitioner has not shown that the ’330 application fails to provide written description support for claim 1 of the ’848 patent, which recites “video data” samples and representations.” slip op. at 16
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not reached
“a chain of priority from the ’330 application to the ’848 patent contain at least the same disclosure as the ’330 application, Petitioner has not shown that the ’848 patent should not be given the benefit of the effective filing date of the ’330 application. The May 26, 2005 filing date of the ’330 application predates the December 1, 2005 publication date of Steuer 750, the August 13, 2013 issue date of Steuer 768, and the December 2, 2010 and May 27, 2010 publication and filing dates of Neumeier.10 Pet. 7; Ex. 1005, code (43); Ex. 1006, code (45); Ex. 1007, codes (43), (60).11 Therefore, Petitioner has not shown by a preponderance of the evidence that any of the asserted claims in the ’848 patent would have been obvious over the asserted combinations of Steuer 750, Steuer 768, and Neumeier.” slip op. at 22
Claim construction§ 103 obviousness§ 112 disclosurecites Phillips · KSR · GrahamPatents in suitUS 10,719,848 - ROKU, Inc. v. Anonymous Media Research Holdings, LLCInstitution deniedPTAB · Feb 12, 2025 · IPR2024-01058 · APJ Frederick C Laney · IPR · Institution
The Board denied institution because Roku did not show a reasonable likelihood that any challenged claim was unpatentable over the asserted § 103 combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“arguments presented by both parties, we find Petitioner’s evidence to be insufficient to carry its burden of showing Wang777 discloses or suggests claim elements 1.3, 6.3, and 10.3. More specifically, we find that Petitioner does not present persuasive evidence that Wang777 discloses or suggests the use of “a sequential order of at least two different obtained content identifiers in the play stream to identify a channel corresponding to the data samples.” Furthermore, Petitioner’s declarant, Dr. Russ, adds little, if any, persuasive value because his testimony is almost indistinguishable from Petitioner’s argument in the Petition and, as such, incorporates the same flaws. Compare Pet. 52–56 with Ex. 1003 ¶¶ 137–144. The reason Petitioner’s reliance on paragraph 72 of Wang777 is unavailing is because we are not persuaded that it discloses or suggests using two different content identifiers to identify a channel. When viewing the cited portions of that paragraph in the proper context of what Wang777 teaches as a whole (as we are required to do), we are not persuaded a skilled artisan would understand that the disclosed additional and different content identifiers in the alleged play stream are being used to identify a channel.” slip op. at 21
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDenied
“claims issued in the ’849 patent. Pet. 40–103. Patent Owner contends that 35 U.S.C. § 325(d) applies to this case and that we should discretionarily deny institution. Prelim. Resp. 7–19. Patent Owner also asserts that Petitioner’s challenges are deficient under § 314(a); in particular, Patent Owner disputes the sufficiency of Petitioner’s evidence to show the prior art discloses or suggests claim elements 1.3, 6.3, and 10.3 of the independent claims. Id. at 20–62. Although Patent Owner’s arguments applying § 325(d) and Advanced Bionics, 4 U.S. Patent Application Publication No. US 2004/0260682 A1, published December 23, 2004 (“Herley”) (Ex. 1011). 5 U.S. Patent Application Publication No. US 2005/0193016 A1, published September 1, 2005, filed February 17, 2005 (“Seet”) (Ex. 1012). 6 U.S. Patent Application Publication No. US 2002/0116195 A1, published August 22, 2002 (“Pitman”) (Ex. 1013). 7 U.S. Patent Application Publication No. US 2003/0018709 A1, published January 23, 2003 (“Schrempp”) (Ex. 1014). 8 U.S. Patent Application Publication No. US 2003/0086341 A1, published May 8, 2003 (“Wells”) (Ex. 1015). Paper 6, (PTAB Feb. 13, 2020) (precedential) are sound, we decline to exercise our discretion. Nevertheless, as discussed below, our merits analysis also leads to denial of the Petition because the cited evidence fails to persuade us that Petitioner is reasonably likely to prevail on any claim challenged.” slip op. at 7
- Skill levelSkill level board ownOther
“We agree with Patent Owner that a person can qualify as a skilled artisan based on relevant industry experience in lieu of a formal degree. We also agree that ACR systems are relevant to the subject matter of the ’849 patent. We disagree, however, that industry experience with ACR systems is required to qualify as a skilled artisan. The ’849 patent describes a media usage monitoring and measurement method that relies on “known content recognition methods,” including known ACR. Ex. 1001, code (54), 5:48–54. The claimed invention relates to analyzing sample sequence data to enhance content identification and to establish channel identification. Id. at code (57), 15:14–32 (claim 1). The ’849 patent relies upon known ACR systems, but does not claim a new method of content recognition such that industry experience designing or implementing ACR systems is required. We accept that such experience may assist in providing relevant industry experience. For these reasons, we determine that a skilled artisan would have had a bachelor’s degree in electrical engineering, computer engineering, computer science, or an equivalent degree, with two years of relevant industry experience in digital media content delivery or designing or implementing ACR systems. A person may qualify as a skilled artisan based on more than two years of relevant industry experience in lieu of a bachelor’s degree.” slip op. at 10
- Expert testimonyPetitioner expert discountedOther
“arguments presented by both parties, we find Petitioner’s evidence to be insufficient to carry its burden of showing Wang777 discloses or suggests claim elements 1.3, 6.3, and 10.3. More specifically, we find that Petitioner does not present persuasive evidence that Wang777 discloses or suggests the use of “a sequential order of at least two different obtained content identifiers in the play stream to identify a channel corresponding to the data samples.” Furthermore, Petitioner’s declarant, Dr. Russ, adds little, if any, persuasive value because his testimony is almost indistinguishable from Petitioner’s argument in the Petition and, as such, incorporates the same flaws. Compare Pet. 52–56 with Ex. 1003 ¶¶ 137–144.” slip op. at 21
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,719,849 - ROKU, Inc. v. Anonymous Media Research Holdings, LLCInstitution deniedPTAB · Feb 12, 2025 · IPR2024-01055 · APJ Frederick C Laney · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that any challenged claim was unpatentable over the asserted obviousness combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsDenied
“partes review. 35 U.S.C. § 314 (2024); 37 C.F.R. § 42.4(a) (2024). An inter partes review may not be instituted “unless . . . the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons that follow, we do not institute an inter partes review because the information presented in the Petition, in view of the Preliminary Response, does not show that Petitioner is reasonably likely to prevail with respect to at least 1 of the claims challenged.” slip op. at 2
- Skill levelSkill level board ownOther
“We agree with Patent Owner that a person can qualify as a skilled artisan based on relevant industry experience in lieu of a formal degree. We also agree that ACR systems are relevant to the subject matter of the ‘622 patent. We disagree, however, that industry experience with ACR systems is required to qualify as a skilled artisan. The ‘622 patent describes a media usage monitoring and measurement method that relies on “known content recognition methods,” including known ACR. Ex. 1001, code (54), 5:38–44, 5:59–6:13. The claimed invention relates to analyzing sample sequence data to enhance content identification and to establish channel identification. Id. at code (57), 14:37–51 (claim 1). The ‘622 patent relies upon known ACR systems, but does not claim a new method of content recognition such that industry experience designing or implementing ACR systems is required. We accept that such experience may assist in providing relevant industry experience. For these reasons, we determine that a skilled artisan would have had a bachelor’s degree in electrical engineering, computer engineering, computer science, or an equivalent degree, with two years of relevant industry experience in digital media content delivery or designing or implementing ACR systems. A person may qualify as a skilled artisan based on more than two years of relevant industry experience in lieu of a bachelor’s degree.” slip op. at 10
- Expert testimonyPetitioner expert discountedOther
“arguments presented by both parties, we find Petitioner’s evidence to be insufficient to carry its burden of showing Wang777 discloses or suggests claim elements 1.3, 6.3, and 10.3. More specifically, we find that Petitioner does not present persuasive evidence that Wang777 discloses or suggests the use of “a sequential order of at least two different obtained content identifiers in the play stream to identify a channel corresponding to the data samples.” Furthermore, Petitioner’s declarant, Dr. Russ, adds little, if any, persuasive value because his testimony is almost indistinguishable from Petitioner’s argument in the Petition and, as such, incorporates the same flaws. Compare Pet. 52–56 with Ex. 1003 ¶¶ 135–142. The reason Petitioner’s reliance on paragraph 72 of Wang777 is unavailing is because we are not persuaded that it discloses or suggests using two different content identifiers to identify a channel. When viewing the cited portions of that paragraph in the proper context of what Wang777 teaches as a whole (as we are required to do), we are not persuaded a skilled artisan would understand that the disclosed additional and different content identifiers in the alleged play stream are being used to identify a channel.” slip op. at 21
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner contends that “none of the claim terms require explicit constructions” and “all claim terms have been given their plain and ordinary meaning, in the context of the ’622 patent specification, under the Phillips standard.” Pet. 20. Patent Owner does not dispute this contention (see generally Prelim. Resp.) and its declarant, Mr. Hoarty, states that he “applied the plain and ordinary meaning of all claim terms at issue” (Ex. 2001 ¶ 52). are in controversy, and only to the extent necessary to resolve the controversy.’” Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (quoting Vivid Techs., Inc. v. Am. Sci. Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Here, both parties rely on the plain and ordinary meaning for all of the terms used in the claims challenged in the Petition and neither party suggests a particular meaning beyond what is clearly conveyed by the claim terms in the context of the ’622 patent. Therefore, we need not construe expressly any of the claim terms.” slip op. at 11
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,756,622 - ROKU, Inc. v. Anonymous Media Research Holdings, LLCInstitution deniedPTAB · Feb 10, 2025 · IPR2024-01054 · APJ Michael T Cygan · IPR · Institution
Institution denied for claims 1–15 because Petitioner did not show Seet was prior art, defeating the reasonable-likelihood showing for every asserted obviousness ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons given below, on this record, Petitioner has not established a reasonable likelihood that it would prevail in showing the unpatentability of any one of claims 1–15 of the ’768 patent. Accordingly, we do not institute an inter partes review of the ’768 patent.” slip op. at 2
- Novelty / Anticipation (§102) › Prior-art status of a reference › Patents / published applications (effective date, provisional support)Reference not prior artDecided for patent owner
“Petitioner fails to show that the full scope of claim 9 of Seet is described in the Seet provisional. Seet expressly defines the claim term “media,” stating that, as it is “used herein,” “media” includes audio, video, software, and pictures. Ex. 1006 ¶ 50 (“Media content may include one . . . of audio . . ., video . . ., software . . ., and pictures”). Such a statement provides a clear definition of the term “media” that includes video, software, and pictures, in addition to audio. In addition to the express definition, Seet elsewhere indicates that its media includes video and other non-audio signals and databases. See, e.g., Ex. 1006 ¶¶ 26 (“if the media stream 102 is a video broadcast, each media item may comprise a television show or segment, an advertisement, or any other type of video”), 42–46 (creating databases of “videos,” “faces,” and “files”), 49 (“any signal that contains repeating content over any broadcast medium can benefit from the procedure described herein.”). Accordingly, the use of media in claim 9 for its claimed “media content database” and “media stream[s]” also includes both audio and non-audio media.” slip op. at 14
- Disclosure Requirements (§112) › Written description (Ariad)Not entitled to earlier dateNot shown unpatentable
“We agree with Patent Owner that Petitioner has not met its burden to show that Seet is prior art. Seet is not entitled to the benefit of its provisional filing date unless a claim in Seet has written description support in the Seet provisional. See Dynamic Drinkware, 800 F.3d at 1381–82. As the “‘hallmark’ of written description, . . . the disclosure must be considered as a whole, as the person of ordinary skill in the art would read it to determine if it reasonably conveys possession” of the claimed invention. Allergan USA, Inc. v. MSN Laboratories Private Ltd., 111 F.4th 1358, 1375 (Fed. Cir. 2024) (citation and emphasis omitted).” slip op. at 12
- Skill levelSkill level board ownDecided for patent owner
“B. Level of Ordinary Skill in the Art Petitioner asserts that a person of ordinary skill in the art [“POSITA”] at the critical time would have had “a bachelor’s degree in electrical engineering, computer engineering, computer science, or equivalent degree with at least two years of relevant industry experience, including in digital media content delivery.” Pet. 2 (citing Ex. 1003 ¶ 32). Patent Owner argues that the level of ordinary skill should include persons lacking a formal degree but possessing considerable industry experience designing and implementing automated content recognition systems, and that such systems are the relevant industry experience. Prelim. Resp. 6–7. For purposes of this Decision, we adopt Petitioner’s proposed level of ordinary skill, modified by the more inclusive standards of Patent Owner, as it appears to be consistent with the specification of the ’768 patent and the prior art of record.” slip op. at 7
Claim construction§ 102 anticipation§ 112 disclosurecites Phillips · KSR · GrahamPatents in suitUS 8,510,768
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.