• Home Depot U.S.A., Inc. v. H2 Intellect LLCInstitution denied
  PTAB · Oct 20, 2025 · IPR2025-00480 · APJ Lisa A Murray · IPR · Institution

  The Board denied institution because the Elliott/Jacob grounds did not show a reasonable likelihood that claims 1–15 were unpatentable, and Musk did not cure the deficiencies.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “c) Summary We may institute an inter partes review when “the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). We have determined that, at this stage of the proceeding and on the present record, the information presented in the Petition does not show that Petitioner is reasonably likely to prevail with respect to its challenge to claim 1 based on the combination of Elliott and Jacob. Specifically, the Petition does not demonstrate that the proposed Elliott/Jacob combination would teach or suggest either limitation [1.e] or limitation [1.a] of independent claim 1. For the same reasons, the Elliott/Jacob combination does not teach or suggest the commensurate limitations in independent claims 6 and 11. Compare Ex. 1001, 13:42–14:5, 14:31–15:5, 15:38–16:21.” slip op. at 19

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “a Bachelors’ degree in electrical or computer science or a comparable field of study, plus at least three years of professional experience in advertisement delivery systems or other relevant industry experience. Additional graduate education could substitute for professional experience, and significant experience in the field could substitute for formal education. Pet. 3; Ex. 1002 ¶ 79. Patent Owner does not offer a competing formulation, stating that “[f]or purposes of this preliminary response only, Patent Owner applies the same skill level proposed by Petitioner.” Prelim. Resp. 12. We find Petitioner’s formulation to be consistent with the evidence of record at this stage of the proceeding, including the asserted prior art and the ’296 Patent, and, accordingly, we adopt and apply that definition for purposes of this Decision. B.” slip op. at 6

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner

    “After reviewing the parties’ arguments and evidence, we determine that no express constructions of the terms identified by Petitioner are needed 6 For the term “recording a request identifier associated with the request,” Petitioner asserts that it is unclear which “request” is at issue, Pet. 7–8, while Patent Owner argues that “the ‘request’ refers to the ‘request for content to be used within the registered application program’ as described in claim element 1.h.” Prelim. Resp. 13. For the reasons discussed below, we determine that it is not necessary for us to construe this term for purposes of this Decision. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). C.” slip op. at 7

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached

    “as obvious over the combination of Elliott and Jacob. Pet. 9–60. Patent Owner contests Petitioner’s mapping of the cited prior art to four limitations in independent claim 1 (and the commensurate limitations in independent claims 6 and 11): limitations [1.a], [1.b], [1.d], and [1.e]. Prelim. Resp. 14– 39. Patent Owner also argues that one of ordinary skill in the art would not have been motivated to modify Elliott with the teachings of Jacob. Id. at 39– 46. We agree with Patent Owner that the proposed combination does not teach or suggest elements [1.a] and [1.e], for the reasons discussed below. Because the absence of these two elements from the cited prior art is a sufficient basis for denying institution, we do not address Patent Owner’s remaining arguments.” slip op. at 13

  Claim construction§ 103 obviousnesscites Phillips
  Patents in suitUS 8,433,296
• Alpinestars S.P.A. / Alpinestars USA Inc. v. Dainese S.P.A.Institution denied
  PTAB · Oct 15, 2025 · IPR2025-00750 · APJ Benjamin D M Wood · IPR · Institution

  The Board denied institution for claims 1–22 because Petitioner did not show a reasonable likelihood of prevailing on any of its three obviousness grounds.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “Because Petitioner has not shown a reasonable likelihood of establishing that one of ordinary skill in the art would have combined EP’536 (with or without Hatton) and CN’180 in the proposed manner, Petitioner has not shown a reasonable likelihood of prevailing with respect to claims 1 and 18. 5. Claims 2–17 and 19–22 Because Petitioner has not shown a reasonably likelihood of prevailing with respect to independent claims 1 and 18, Petitioner also has not shown a reasonable likelihood of prevailing with respect to the claims that depend therefrom (claims 2–17 and 19–22).” slip op. at 20

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Patent Owner does not offer its own definition of the level of ordinary skill or dispute Petitioner’s definition. See generally Prelim. Resp. The level of ordinary skill in the art usually is evidenced by the references themselves. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978). As Petitioner’s unchallenged description of an ordinarily skilled artisan appears consistent with the subject matter discussed in the references and that of the challenged claims, for purposes of this Decision we apply Petitioner’s description of a person of ordinary skill in the art.” slip op. at 8

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Other

    “For purposes of our analysis, we need only address the meaning of “planar structure,” and only to note that this limitation requires that all portions of the casing body, when inflated against the first mesh portion, second mesh portion, and tie elements, “form a planar structure” when the casing body is inflated. This is evident from both the claim language and the written description of the ’065 patent. Limitation [1e] of claim 1 recites that in the inflated condition, “said portions of the casing body” are “inflated against said first mesh portion, said second mesh portion, and said tie elements.” We understand “said portions of the casing body” to refer to all of the portions of the casing body. Likewise, “said first mesh portion, said second mesh portion, and said tie elements” refers to the entire mesh structure recited in limitation [1a]. Thus, this limitation requires all of the casing-body portions to inflate against the entire mesh structure to form the “planar structure.” This reading is consistent with the Specification. The Specification teaches that “[t]he first mesh portion and the second mesh portion together with the tie elements determine with the casing body the final shape of the inflatable element,” which “can reach a generally flat and planar final shape.” Ex. 1001, 4:19–23; see also id. at 4:59–5:3 (teaching that the casing body inflated within the mesh structure results in a “globally planar structure”). Here, “inflatable element” refers to the entire structure because it is comprised of the mesh structure and casing body. Id. at 3:11–18. Thus, the entire structure, when inflated, is “generally flat and planar.”” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for patent owner

    “portions of the casing body, when inflated against the first mesh portion, second mesh portion, and tie elements, “form a planar structure” when the casing body is inflated. This is evident from both the claim language and the written description of the ’065 patent. Limitation [1e] of claim 1 recites that in the inflated condition, “said portions of the casing body” are “inflated against said first mesh portion, said second mesh portion, and said tie elements.” We understand “said portions of the casing body” to refer to all of the portions of the casing body. Likewise, “said first mesh portion, said second mesh portion, and said tie elements” refers to the entire mesh structure recited in limitation [1a]. Thus, this limitation requires all of the casing-body portions to inflate against the entire mesh structure to form the “planar structure.” This reading is consistent with the Specification. The Specification teaches that “[t]he first mesh portion and the second mesh portion together with the tie elements determine with the casing body the final shape of the inflatable element,” which “can reach a generally flat and planar final shape.” Ex. 1001, 4:19–23; see also id. at 4:59–5:3 (teaching that the casing body inflated within the mesh structure results in a “globally planar structure”). Here, “inflatable element” refers to the entire structure because it is comprised of the mesh structure and casing body. Id. at 3:11–18. Thus, the entire structure, when inflated, is “generally flat and planar.”” slip op. at 10

  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 12,012,065
• Ascend Elements, Inc. v. Duesenfeld GmbHInstitution denied
  PTAB · Oct 10, 2025 · PGR2025-00037 · APJ Kevin W Cherry · PGR · Institution

  The Board denied institution of PGR on claims 1–14 because Petitioner did not show that any challenged claim was more likely than not unpatentable.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “information presented in the petition filed under [35 U.S.C. §] 321 . . . demonstrates that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a). For the reasons set forth below, we determine that Petitioner has failed to demonstrate that it is more likely than not that at least one of claims 1–14 of the ’463 patent is unpatentable. Accordingly, we deny institution of a postgrant review of claims 1–14 based on the grounds set forth in the Petition.” slip op. at 2

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that one of ordinary skill in the art “would have had at least a Bachelor’s degree in electrical engineering, material science, chemical engineering, or an equivalent field, as well as at least 2 to 3 years of academic or industry experience in the recycling or processing of lithiumion batteries. Additional formal education focusing on processing of lithium batteries may substitute for practical experience and additional practical experience can substitute for less education.” Pet. 10–11. Patent Owner does not contest this definition of a person of skill in the art. See Prelim. Resp. 11. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as, on the present record, it appears consistent with the ’463 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 8

  • Expert testimonyPetitioner expert discountedPatent owner expert creditedDecided for patent owner

    “distinct from “comminute[ion],” Petitioner offers only the testimony of its expert, Mr. Juzkow, who equates Tomioka’s “cutting” with “comminute[ion].” See Ex. 1003 ¶ 121. However, Mr. Juzkow provides insufficient reasoning to support his conclusion, particularly given the intrinsic and extrinsic evidence discussed above. In contrast, Patent Owner’s expert, Mr. Dantam, provides extensive reasoning, supported by citations to other evidence, to support his conclusion that Tomioka’s “dismantling” is not the claimed “comminution.” Thus, we give more weight to Mr. Dantam’s testimony than Mr. Juzkow’s testimony. Weighing this evidence all together, we find that Petitioner has failed to show that it is more likely than not that Tomioka’s teaches the claimed comminution under Petitioner’s first theory.” slip op. at 15

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundTeaching away not foundNot shown unpatentable

    “obvious. Pet. 34–35. However, we agree with Patent Owner that Petitioner has also failed to show that it is more likely than not that Tomioka renders this limitation obvious. See Prelim. Resp. 28–31. To begin with, Petitioner’s contentions lack sufficient reasoning explaining why a person of ordinary skill would have modified Tomioka in the manner proposed. “[R]ejections on obviousness grounds cannot be sustained by mere conclusory statements; instead, there must be some articulated reasoning with some rational underpinning to support the legal conclusion of obviousness.” In re Kahn, 441 F.3d 977, 988 (Fed. Cir. 2006). Petitioner merely asserts that a person of ordinary skill in the art could use the roller system in place of the dismantling disclosed for the embodiments in Figures 19 and 20. On this record, we find this bare contention insufficient. actual disclosure of Tomioka. The rollers in Tomioka are used to separate the “battery body” from the “resin package enclosing the battery body,” and Tomioka specifically discloses that this technique is designed to “avoid damaging the battery body.” Ex. 1005 ¶¶ 25, 26, 29; Ex. 2011 ¶¶ 72–73. Thus, there is a significant difference between what Tomioka teaches and what Petitioner proposes to use the roller system to do. In addition, as Patent Owner points out, Tomioka specifically discloses there are risks associated with mechanically crushing battery packs, such as “risk of sparking due to residual voltage if the battery units are damaged in the process.” Ex. 1005 ¶ 5. Although we do not agree with Patent Owner that this amounts to a “teaching away,” see In re Gurley, 27 F.3d 551, 553 (Fed. Cir. 1994), we do believe that this teaching suggests a trade off that should be weighed in determining whether to make the modification, see Medichem S.A. v. Rolabo S.L., 437 F.3d 1157, 1165 (Fed. Cir. 2006). However, Petitioner has failed to account adequately, if at all, for this trade off. Thus, we find that Petitioner has failed to show that it is more likely than not that Tomioka accounts for the claimed “comminuting.”” slip op. at 15

  § 103 obviousness§ 112 disclosurecites Phillips · Graham · Nautilus
  Patents in suitUS 12,119,463
• Shenzhen Tuozhu Technology Co. Ltd. v. Stratasys, Inc.Institution denied
  PTAB · Oct 6, 2025 · IPR2025-00585 · APJ Lilan Ren · IPR · Institution

  The Board denied institution on claims 1–6, 10–19 because claim 1’s scope is ambiguous and the petition did not show a reasonable likelihood of prevailing on any asserted obviousness ground.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “review. See 35 U.S.C. § 314 (2024); 37 C.F.R. § 42.4(a) (2024). Institution of an inter partes review requires that “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that the scope of claim 1 is ambiguous and that there is not a reasonable likelihood that Petitioner will prevail with respect to at least one challenged claim, and we deny inter partes review.1” slip op. at 2

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownOther

    “distinguishes and contrasts build material property from operational parameters. The diagnostic test passage therefore only describes a diagnostic test of the build material property but does not describe a subsequent diagnostic test to assess whether an operational parameter is suitable for the printer. Based solely on the diagnostic test passage and the prosecution history, a possible interpretation may be that the operational parameter determination in claim element 1b encompasses the diagnostic testing in claim element 1c. That is, “performing a diagnostic test to determine whether the operational parameter is suitable for the three-dimensional printer” in claim element 1c is subsumed as part of “determining an operational parameter of a fabrication process using the three-dimensional printer based upon the data, the operational parameter including at least one of a build platform temperature, a build volume temperature, an infill requirement, a rafting requirement, a support structure requirement, and a cooling requirement” in claim element 1b.” slip op. at 15

  • Disclosure Requirements (§112) › Written description (Ariad)Not entitled to earlier dateOther

    “benefit of the filing date of an earlier filed application only if the disclosure of the earlier application provides support for the claims of the later application, as required by 35 U.S.C. § 112.” PowerOasis, Inc. v. T-Mobile USA, Inc., 522 F.3d 1299, 1306 (Fed. Cir. 2008); see also Research Corps. Techs. v. Microsoft Corp., 627 F.3d 859, 871–72 (Fed. Cir. 2010) (holding that claims of the later-filed application, which were not limited to a “blue noise mask,” were “not entitled to claim the benefit of their parent applications’ filing dates”); ICU Med., Inc. v. Alaris Med. Sys., 558 F.3d 1368, 1377–78 (Fed. Cir. 2009) (holding that “spikeless” claims “added years later during prosecution” were not supported by the specification which “describe[d] only medical valves with spikes”); Tronzo v. Biomet, Inc., 156 F.3d 1154, 1158–60 (Fed. Cir. 1998) (holding the generic shaped cup claims of the later-filed child application were not entitled to the filing date of the parent application that “disclosed only a trapezoidal cup and nothing more”). “To satisfy the written description requirement the disclosure of the prior application must convey with reasonable clarity to those skilled in the art that, as of the filing date sought, [the inventor] was in possession of the invention.” PowerOasis, 522 F.3d at 1306 (emphasis omitted; alteration in original). The sufficiency of written description support is based on “an objective inquiry into the four corners of the specification from the perspective of a person of ordinary skill in the art.” Ariad Pharm., Inc. v. Eli Lilly & Co., 598 F.3d 1336, 1351 (Fed. Cir. 2010) (en banc).” slip op. at 20

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person of ordinary skill in the art in the field in the relevant time frame would have had “(1) at least a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a related field, and (2) at least two years of research or industry experience in 3D printing or materials used for 3D printing.” Pet. 5 (citing Ex. 1003 ¶ 20). Petitioner also contends that “[a]dditional experience could substitute for a formal degree or formal training (and vice versa).” Id. (citing the same). Patent Owner contends that an ordinarily skilled artisan “would have had a bachelor’s degree in Mechanical Engineering, Computer Engineering, Electrical Engineering, Chemical Engineering, Materials Science, or a comparable field and at least two years of experience related to 3D printing, with additional experience potentially being a substitute for a formal degree or training (and vice versa).” Prelim. Resp. 12. For purposes of this decision, we adopt Petitioner’s definition of the level of ordinary skill in the art as it appears unopposed and consistent with the disclosures of the ’464 patent and the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 9

  Claim construction§ 112 disclosurecites Phillips · KSR · Graham
  Patents in suitUS 11,167,464
• Alliance Laundry Systems, LLC v. Payrange LLCInstitution denied
  PTAB · Oct 1, 2025 · IPR2025-00573 · APJ Meredith C Petravick · IPR · Institution

  The Board denied institution because the Petition did not show a reasonable likelihood that claims 7 or 11 were unpatentable under the asserted obviousness grounds.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “Under 35 U.S.C. § 314(a), an inter partes review may not be instituted unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” After considering the Petition, the Preliminary Response, and the evidence of record, we determine the information presented fails to show a reasonable likelihood that Petitioner would prevail in establishing the unpatentability of at least one of the challenged claims of the ’772 patent. Accordingly, we do not institute an inter partes review of claims 7 and 11 of the ’772 patent on the grounds asserted in the Petition.” slip op. at 2

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends a person having ordinary skill in the art (“POSA”) pertaining to the ’772 patent “would have had an educational background of, engineering, computer engineering, computer science, or equivalent training, and approximately three years of experience with electronic payment systems, vending machine technologies, or distributed network systems.” Pet. 19–20; Ex. 1003 ¶¶ 20–26. “Lack of work experience can be remedied by additional education, and vice versa.” Pet. 20; Ex. 1003 ¶ 22. Patent Owner does not oppose Petitioner’s formulation of ordinary skill. See Prelim. Resp. generally. On this record, we adopt Petitioner’s assessment of the level of ordinary skill in the art as it is consistent with the ’772 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “In this inter partes review, we apply the same claim construction standard that would be used in a civil action under 35 U.S.C. § 282(b). 37 C.F.R. § 42.100(b). In applying this standard, we generally give claim terms their ordinary and customary meaning as would be understood by a person of ordinary skill in the art at the time of the invention and in the context of the entire patent disclosure. See id.; Phillips v. AWH Corp., 415 F.3d 1303, 1312–14 (Fed. Cir. 2005) (en banc). We do not need to construe any terms expressly to determine whether or not to institute a trial. See Realtime Data LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 10

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,481,772
• Microsoft Corporation v. Edge Networking Systems, LLCInstitution denied
  PTAB · Sep 30, 2025 · IPR2025-00619 · APJ Jason M Repko · IPR · Institution

  The Board denied institution because Microsoft did not show a reasonable likelihood of proving claims 1, 2, 4–7, and 9 obvious over Vasell, Alves, Hall, and Rellermeyer.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “To institute an inter partes review, we must determine “that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons discussed below, Petitioner has not shown a reasonable likelihood that it would prevail with respect to any claim challenged in the Petition. Thus, we do not institute an inter partes review.” slip op. at 2

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “[Persons of ordinary skill in the art (“POSITAs”)] as of June 2013 would have had a bachelor’s degree in computer science, computer engineering, or equivalent degree, and approximately three years of experience working in the computer science or engineering field. Additional experience might substitute for less education and vice versa. To that end, POSITAs in June 2013 would have been knowledgeable about the design and management of networked systems and virtualization technologies, and familiar with operating/distributed systems and security and privacy techniques. Pet. 15 (citing Ex. 1003 ¶ 58).4 Patent Owner does not contest this in its Preliminary Response. Prelim. Resp. 36–37. We apply Petitioner’s definition of the level of ordinary skill in the art here.” slip op. at 5

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached

    “Petitioner has not sufficiently explained how the combination of Vasell, Alves, Hall, and Rellermeyer teaches or suggests a programmable network device and a programmable cloud device that are each “powered by a sandboxing operating system,” as required by all challenged claims. Our reasoning follows.” slip op. at 10

  § 103 obviousness
  Patents in suitUS 10,686,871
• Microsoft Corporation v. Edge Networking Systems, LLCInstitution denied
  PTAB · Sep 30, 2025 · IPR2025-00617 · APJ Jason M Repko · IPR · Institution

  The Board denied institution because Microsoft did not show a reasonable likelihood of proving claims 1, 2, 6–8, 10–13, and 15 obvious over Vasell, Alves, Hall, and Rellermeyer.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “To institute an inter partes review, we must determine “that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons discussed below, Petitioner has not shown a reasonable likelihood that it would prevail with respect to any claim challenged in the Petition. Thus, we do not institute an inter partes review.” slip op. at 2

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “[Persons of ordinary skill in the art (“POSITAs”)] as of June 2013 would have had a bachelor’s degree in computer science, computer engineering, or equivalent degree, and approximately three years of experience working in the computer science or engineering field. Additional experience might substitute for less education and vice versa. To that end, POSITAs in June 2013 would have been knowledgeable about the design and management of networked systems and virtualization technologies, and familiar with operating/distributed systems and security and privacy techniques. Pet. 14 (citing Ex. 1003 ¶ 59).4 Patent Owner does not contest this in its Preliminary Response. Prelim. Resp. 39. We apply Petitioner’s definition of the level of ordinary skill in the art here. 2 Congress amended § 103 when it passed the Leahy-Smith America Invents Act (AIA). Pub. L. No. 112–29, § 3(c), 125 Stat. 284, 287 (2011). Petitioner asserts that the version amended by the AIA applies here. Pet. 23. 3 We use Petitioner’s nomenclature in which Petitioner collectively refers to the Vasell patent (Ex. 1004) and its corresponding provisional applications (Exs. 1015, 1016) as “Vasell.” 4 Erez Zadok, Ph.D. submitted a declaration on behalf of Petitioner. See Ex. 1003.” slip op. at 5

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached

    “Petitioner has not sufficiently explained how the combination of Vasell, Alves, Hall, and Rellermeyer teaches or suggests a programmable network device and a programmable cloud device that are each “powered by a sandboxing operating system,” as required by all challenged claims. Our reasoning follows.” slip op. at 10

  • BurdenNot shown unpatentable

    “Petitioner has not sufficiently explained how the combination of Vasell, Alves, Hall, and Rellermeyer teaches or suggests a programmable network device and a programmable cloud device that are each “powered by a sandboxing operating system,” as required by all challenged claims. Our reasoning follows.” slip op. at 10

  § 103 obviousness
  Patents in suitUS 10,893,095
• Skullcandy, Inc. v. Earin ABInstitution denied
  PTAB · Sep 15, 2025 · IPR2025-00690 · APJ Monica S Ullagaddi · IPR · Director review

  The Board denied institution because the petition did not show a reasonable likelihood that claims 20 and 21 were unpatentable on any asserted obviousness ground.

  RulingsDirector review decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Having considered the parties’ arguments and the evidence of record, we determine that, for the reasons discussed herein, Petitioner does not demonstrate a reasonable likelihood that it would prevail with respect to at least one of the challenged claims. We thus decline to institute an inter partes review on all challenged claims on all asserted grounds. See SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1354, 1359–60 (2018).” slip op. at 2

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “may be considered, including the “type of problems encountered in the art; prior art solutions to those problems; rapidity with which innovations are made; sophistication of the technology; and educational level of active workers in the field.” In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995) (citing Custom Accessories, Inc. v. Jeffrey–Allan Indus., Inc., 807 F.2d 955, 962 (Fed.Cir.1986)).” slip op. at 7

  • BurdenNot shown unpatentable

    “Analysis of the Parties’ Contentions We agree with Patent Owner that the Petition is conclusory––the Cooperstock Declaration merely reiterates the position set forth in the Petition and does not provide sufficient detail or explanation of why Olodort’s “low power state” would have been understood by a POSITA to mean that “existing connections to a second wireless earbud and to a wireless audio streaming host device will be disconnected,” as recited in claim 20. 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); see Pet. 23–24; Ex. 1007 ¶¶ 84–87. We further agree that claim 38 is not directed to entering “a standby mode” as it recites “the low power state is a standby mode from which the second earpiece is awakened in response to detecting that the second earpiece has been attached to an ear.” Ex. 1002, claim 38 (emphasis added). As such, we agree with Patent Owner that Olodort’s “claim 38 contains no disclosure concerning what happens to ‘existing connections’ when exiting, let alone entering, the ‘standby mode.’” See Prelim. Resp. 9 (citing Ex. 1002, claims 32, 34, 38). We further agree with Patent Owner that the Cooperstock Declaration in paragraphs 86 and 87 sets forth an alternative obviousness theory “based on a modification to Olodort to add ‘circuitry for disconnecting the earbuds from one another and from any wireless audio streaming host device when in the low power state’” that is improperly incorporated by reference into the Petition. Prelim. Resp. 10–11 (emphasis added) (citing 35 U.S.C. § 312(a)(3) (A petition for inter partes review “may be considered only if . . . the petition identifies, in writing and with particularity . . . the evidence that supports the grounds for challenged to each claim.”); 37 C.F.R. § 42.104(b)(4) (“The petition must specify where each element of the claim is found in the prior art patents or printed publications relied upon.”); 37 C.F.R. § 42.6(a)(3) (“Arguments must not be incorporated by reference from one document into another.”)). As such, we need not and do not consider this alternative obviousness theory.” slip op. at 18

  • Expert testimonyDecided for patent owner

    “Analysis of the Parties’ Contentions We agree with Patent Owner that the Petition is conclusory––the Cooperstock Declaration merely reiterates the position set forth in the Petition and does not provide sufficient detail or explanation of why Olodort’s “low power state” would have been understood by a POSITA to mean that “existing connections to a second wireless earbud and to a wireless audio streaming host device will be disconnected,” as recited in claim 20. 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); see Pet. 23–24; Ex. 1007 ¶¶ 84–87. We further agree that claim 38 is not directed to entering “a standby mode” as it recites “the low power state is a standby mode from which the second earpiece is awakened in response to detecting that the second earpiece has been attached to an ear.” Ex. 1002, claim 38 (emphasis added). As such, we agree with Patent Owner that Olodort’s “claim 38 contains no disclosure concerning what happens to ‘existing connections’ when exiting, let alone entering, the ‘standby mode.’” See Prelim. Resp. 9 (citing Ex. 1002, claims 32, 34, 38). We further agree with Patent Owner that the Cooperstock Declaration in paragraphs 86 and 87 sets forth an alternative obviousness theory “based on a modification to Olodort to add ‘circuitry for disconnecting the earbuds from one another and from any wireless audio streaming host device when in the low power state’” that is improperly incorporated by reference into the Petition. Prelim. Resp. 10–11 (emphasis added) (citing 35 U.S.C. § 312(a)(3) (A petition for inter partes review “may be considered only if . . . the petition identifies, in writing and with particularity . . . the evidence that supports the grounds for challenged to each claim.”); 37 C.F.R. § 42.104(b)(4) (“The petition must specify where each element of the claim is found in the prior art patents or printed publications relied upon.”); 37 C.F.R. § 42.6(a)(3) (“Arguments must not be incorporated by reference from one document into another.”)). As such, we need not and do not consider this alternative obviousness theory.” slip op. at 18

  § 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 9,402,120
• Advanced Micro Devices, Inc. / Pensando Systems, Inc. v. Xtreamedge, Inc.Institution denied
  PTAB · Aug 29, 2025 · IPR2025-00479 · APJ Justin T Arbes · IPR · Institution

  The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–20 were obvious over Erskine, Scherzer, or Scherzer and Gillett.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsDenied

    “III. CONCLUSION Based on the arguments and evidence presented by the parties, we conclude that Petitioner has not demonstrated a reasonable likelihood of prevailing with respect to at least one claim of the ’634 patent challenged in the Petition. Therefore, we do not institute an inter partes review. IV. ORDER In consideration of the foregoing, it is hereby: ORDERED that the Petition is denied and no inter partes review is instituted.” slip op. at 25

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “B. Level of Ordinary Skill in the Art Petitioner argues that at the time of the ’634 patent (July 2018), a person of ordinary skill in the art would have had “a bachelor’s degree in electrical engineering, computer science, computer engineering, or a similar major with at least two years of experience in the field; or a master’s degree with specialization in the field,” where “[a] person with less education but more relevant practical experience may also meet this standard.” Pet. 7 (citing Ex. 1003 ¶¶ 12–13). Petitioner further argues that a person of ordinary skill in the art would have had knowledge of “[d]esigning and using systems that include endpoint devices (e.g., client devices) and servers for establishing network connections and data transfer,” “[r]ecognizing and applying the client-server architecture,” and “[u]sing and applying concepts from known telecommunication and networking frameworks, protocols and standards, including TCP/IP, IEEE 802.11, VoIP, cellular systems and other known frameworks and standards.” Id. (citing Ex. 1003 ¶ 14). Patent Owner does not address the level of ordinary skill in the art in its Preliminary Response. Based on the record presented, including our review of the ’634 patent and the types of problems and solutions described in the ’634 patent and cited prior art, we agree with Petitioner’s definition and apply it for purposes of this Decision. See, e.g., Ex. 1001, col. 1, ll. 4–29 (describing in the “Background” section of the ’634 patent a “network connection between two endpoints” and known methods of reaching “full effective bandwidth capacity” in a network).” slip op. at 8

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “C. Claim Interpretation We interpret each challenged claim using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. 282(b), including construing the claim in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent. 37 C.F.R. § 42.100(b). Petitioner notes that it proposed a construction for the claim term “geographical area” in the district court case, but states that it “do[es] not believe proposing a construction for the term is necessary in this proceeding because the relied upon teachings of the prior art references are consistent with examples of ‘geographical area’ included in the ’634 patent [S]pecification.” Pet. 8. Patent Owner argues that “[t]he Board need not engage in express claim construction at this stage of the proceeding.” Prelim. Resp. 5. We conclude that no express interpretation of any claim term is necessary to determine whether to institute an inter partes review in this proceeding. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“Because we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy,’ we need not construe [a particular claim limitation] where the construction is not ‘material to the . . . dispute.’” (citation omitted) (emphasis added)).” slip op. at 9

  • BurdenNot shown unpatentable

    “Petitioner has not shown sufficiently that Erskine teaches or suggests the second requirement of limitation [1c], i.e., “initiating the next network connection . . . with a transmission bandwidth based on the parameter values for the past network connection.” Petitioner’s theory is that (1) the QoS parameters in Erskine are for a “past” connection from one zone to another, (2) the sliding maximum interzone bandwidth is “based on” the QoS parameters, and (3) a new call only proceeds if the transmission bandwidth needed for the call added to the current bandwidth being used over the interzone link is less than the sliding maximum interzone bandwidth, so Erskine therefore teaches a call with a transmission bandwidth determined “based on” the sliding maximum interzone bandwidth (which in turn is determined “based on” the QoS parameters). See Pet. 27–28; Ex. 1003 ¶¶ 59–60 (similar testimony from Dr. Crovella). As Patent Owner points out, however, Erskine only makes “a binary, accept/reject decision as to whether to allow a new call to proceed based on a comparison between the bandwidth needed for the call and a predetermined ‘sliding maximum interzone bandwidth value.’” See Prelim. Resp. 6–7. Specifically, the additional bandwidth that would be needed for the call is added to the current bandwidth being used on the interzone link; if the sum of those values is less than the sliding maximum interzone bandwidth for the link, the call “proceeds”; otherwise, it is “blocked.” Ex. 1004, col. 4, ll. 36–40, col. 6, l. 55–col. 7, l. 10, col. 8, ll. 36–43, col. 9, ll. 9–26, col. 10, ll. 23–25 (the sum is compared to the sliding maximum interzone bandwidth “to determine whether enough bandwidth is available to proceed with the new call”), Fig. 3 (steps 308, 310, and 312). Erskine repeatedly refers to the bandwidth for the new call as the amount of bandwidth that is “necessary” or “required” to handle the call. See, e.g., id. at col. 1, ll. 43–57 (“an amount of bandwidth necessary to handle the new call”), col. 6, ll. 61–64 (“the additional bandwidth required (of the new call)”), col. 8, ll. 36–40 (“the bandwidth necessary for the new call”), col. 9, ll. 16–21 (“the anticipated additional bandwidth necessary for the new call”), 54–56 (“the bandwidth amount the new call will utilize (if connected)”), col. 10, ll. 21–23 (same), 41–43 (same), col. 12, ll. 1–2 (“an amount of bandwidth necessary to handle the new call”). It is that value—determined prior to the addition and comparison to the sliding maximum interzone bandwidth—that will be used for the new call if it is allowed to “proceed[].” Id. at col. 6, ll. 64–67 (if the sum is less than the sliding maximum interzone bandwidth, the call “proceeds” and “the QoS table is updated with the additional bandwidth used by that call”). Erskine does not describe the transmission bandwidth for the new call as being based on any parameter values for a past network connection, but rather as “whatever bandwidth the system determined is necessary for the additional call.” See Prelim. Resp. 8–9. In other words, the transmission bandwidth needed for a new call is predetermined and independent of whatever the sliding maximum interzone bandwidth is currently. See id.” slip op. at 15

  Claim construction§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 10,944,634
• Therabody, Inc. v. Datafeel Inc.Institution denied
  PTAB · Aug 21, 2025 · PGR2025-00026 · APJ Lisa L Tsang · PGR · Institution

  The Board denied institution because Petitioner did not show claim 4 more likely than not unpatentable on either obviousness or § 112 ground.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied

    “Under 35 U.S.C. § 324(a), a post-grant review may be instituted only if “the information presented in the petition . . . demonstrate[s] that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” Post-grant review is available for patents that issue from applications that at one point contained at least one claim with an effective filing date on or after March 16, 2013. See Leahy-Smith America Invents Act, Pub. L. No. 112-29, 125 Stat. 284 (2011) (“AIA”), §§ 3(n)(1), 6(f)(2)(A). Upon considering the arguments and evidence, we conclude that the information presented shows it is not more likely than not that at least one challenged claim of the ’174 patent is unpatentable.” slip op. at 2

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “For purposes of this Decision, we adopt the level of ordinary skill in the art articulated by Petitioner because, based on the current record, it is consistent with our review and understanding of the technology and descriptions in the ’174 patent and prior art of record. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). We note, however, that our analysis below would be the same regardless of whether we adopt Petitioner’s or Patent Owner’s proffered level of skill in the art.” slip op. at 11

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner

    “Petitioner and Patent Owner agree that no claim terms need construction. Pet. 14; Prelim. Resp. 6. After reviewing the evidence and arguments presented by the parties, we determine that it is not necessary to expressly construe any claim terms because doing so would not change the outcome of our analysis below. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (noting that “we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng'g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 12

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not reached

    “of Choi to support its argument that an ordinarily skilled artisan would have understood Choi’s infrared lamp housing to define a concave shape as claimed. See Pet. 61–62. With only this explanation and evidence from Petitioner and Dr. Jenson, however, we cannot not discern how these portions of Choi would have so apprised an ordinarily skilled artisan. For example, the side view of the infrared lamp housing, illustrated in Figure 5 reproduced below, shows the housing having a convex, rather than concave, shape. See Ex. 1008, Fig. 5. Furthermore, paragraphs 20 and 48 refer to the housing’s “circular” shape and outer periphery and also “tubular” shape. See id. ¶¶ 20, 48. But these descriptions, either alone or together with Figure 5, also do not support adequately a finding that Choi’s housing is concave. Choi’s teachings in paragraphs 20 and 46 regarding the lamp housing guiding or directing infrared light from the lamp to irradiate the skin of a user, without more, are similarly deficient. See id. ¶¶ 20, 46. And although Dr. Jensen appears to equate “concave” with “inner circular,” he does not provide the basis for his testimony or explain what “inner circular” means, particularly in the context of distinguishing a convex shape from a concave shape. See Ex. 1002 ¶ 197. Accordingly, we determine there is insufficient evidence to support Petitioner’s conclusory statements that an ordinarily skilled artisan would have understood Choi’s infrared lamp housing to define a concave shape as claimed.” slip op. at 23

  Claim construction§ 103 obviousness§ 112 disclosurecites Phillips · KSR · Graham
  Patents in suitUS 12,036,174

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.