- Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Sep 15, 2025 · IPR2025-00005 · APJ John G New · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show a reasonable likelihood of prevailing on claims 1-4.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“In summary, we again conclude that Petitioner has failed to provide sufficient evidence to demonstrate that a person of ordinary skill in the art would have had a reasonable expectation of success in combining the cited prior art references, in combination with Dr. Josefowicz’s relatively unsupported testimony concerning a skilled artisan’s ability to optimize various constituents and conditions, to arrive at the claimed invention. Petitioner has not pointed to any argument or unconsidered evidence of record that is sufficient to show that, in reaching its conclusion, the Board abused its discretion by basing its Decision on an erroneous interpretation of law, a factual finding not supported by substantial evidence, or an unreasonable judgment in weighing relevant factors. Arnold, 362 F.3d at 1340.” slip op. at 8
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“teaches the tensile strengths of various types of copper-electroplated steel electrical cable wire of different properties, including high strength, hardness, low electrical resistivity, near zero strength, good leveling, and thermal stability, some of which fall within the claimed range of tensile strength of 30 to 40 kgf/mm2. Lowenheim, 196, Table II. However, none of these categories correspond to those copper foil properties recited in the claims, and Dr. Josefowicz’s testimony provides little guidance as to how a person of ordinary skill in the art would have known how to optimize the recited properties, and particularly so in combination with the teachings of Hirose and the other cited prior art references. Furthermore, as we noted in our Decision:” slip op. at 7
- Expert testimonyPetitioner expert discountedDecided for patent owner
“At the heart of this flaw is Petitioner’s argument, and Dr. Josefowicz’s opinion, that it would have been conventional in the art at the time of filing to vary the electrolyte concentration, electrolysis plating parameters, temperature, and the use of organic and inorganic additives, in order to obtain a copper foil with tensile strength and elongation values falling within the claimed ranges as these ranges were well known, at least since 1974. Ex. 1003 ¶ 63. This statement is largely unsupported by evidence of record, with the sole exception of Table 2 of Lowenheim, which, as Patent Owner points out, provides tensile strengths well outside the claimed range. Petitioner provides insufficient guidance as to how a person of ordinary skill in the art would have known which parameters to vary, or how to vary them, to provide the foil of Hirose with a tensile strength or weight deviation within the claimed range. Dr. Josefowicz’s statement that this would result from routine optimization, and was “conventional” may or may not be true, but it is insufficiently supported by evidence of record to be persuasive. Id. (emphasis added) (footnote omitted).” slip op. at 6
§ 103 obviousnessPatents in suitUS 9,457,541 - PTAB · Aug 29, 2025 · IPR2025-00479 · APJ Justin T Arbes · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–20 were obvious over Erskine, Scherzer, or Scherzer and Gillett.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsDenied
“III. CONCLUSION Based on the arguments and evidence presented by the parties, we conclude that Petitioner has not demonstrated a reasonable likelihood of prevailing with respect to at least one claim of the ’634 patent challenged in the Petition. Therefore, we do not institute an inter partes review. IV. ORDER In consideration of the foregoing, it is hereby: ORDERED that the Petition is denied and no inter partes review is instituted.” slip op. at 25
- Skill levelSkill level petitioner adoptedDecided for petitioner
“B. Level of Ordinary Skill in the Art Petitioner argues that at the time of the ’634 patent (July 2018), a person of ordinary skill in the art would have had “a bachelor’s degree in electrical engineering, computer science, computer engineering, or a similar major with at least two years of experience in the field; or a master’s degree with specialization in the field,” where “[a] person with less education but more relevant practical experience may also meet this standard.” Pet. 7 (citing Ex. 1003 ¶¶ 12–13). Petitioner further argues that a person of ordinary skill in the art would have had knowledge of “[d]esigning and using systems that include endpoint devices (e.g., client devices) and servers for establishing network connections and data transfer,” “[r]ecognizing and applying the client-server architecture,” and “[u]sing and applying concepts from known telecommunication and networking frameworks, protocols and standards, including TCP/IP, IEEE 802.11, VoIP, cellular systems and other known frameworks and standards.” Id. (citing Ex. 1003 ¶ 14). Patent Owner does not address the level of ordinary skill in the art in its Preliminary Response. Based on the record presented, including our review of the ’634 patent and the types of problems and solutions described in the ’634 patent and cited prior art, we agree with Petitioner’s definition and apply it for purposes of this Decision. See, e.g., Ex. 1001, col. 1, ll. 4–29 (describing in the “Background” section of the ’634 patent a “network connection between two endpoints” and known methods of reaching “full effective bandwidth capacity” in a network).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“C. Claim Interpretation We interpret each challenged claim using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. 282(b), including construing the claim in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent. 37 C.F.R. § 42.100(b). Petitioner notes that it proposed a construction for the claim term “geographical area” in the district court case, but states that it “do[es] not believe proposing a construction for the term is necessary in this proceeding because the relied upon teachings of the prior art references are consistent with examples of ‘geographical area’ included in the ’634 patent [S]pecification.” Pet. 8. Patent Owner argues that “[t]he Board need not engage in express claim construction at this stage of the proceeding.” Prelim. Resp. 5. We conclude that no express interpretation of any claim term is necessary to determine whether to institute an inter partes review in this proceeding. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“Because we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy,’ we need not construe [a particular claim limitation] where the construction is not ‘material to the . . . dispute.’” (citation omitted) (emphasis added)).” slip op. at 9
- BurdenNot shown unpatentable
“Petitioner has not shown sufficiently that Erskine teaches or suggests the second requirement of limitation [1c], i.e., “initiating the next network connection . . . with a transmission bandwidth based on the parameter values for the past network connection.” Petitioner’s theory is that (1) the QoS parameters in Erskine are for a “past” connection from one zone to another, (2) the sliding maximum interzone bandwidth is “based on” the QoS parameters, and (3) a new call only proceeds if the transmission bandwidth needed for the call added to the current bandwidth being used over the interzone link is less than the sliding maximum interzone bandwidth, so Erskine therefore teaches a call with a transmission bandwidth determined “based on” the sliding maximum interzone bandwidth (which in turn is determined “based on” the QoS parameters). See Pet. 27–28; Ex. 1003 ¶¶ 59–60 (similar testimony from Dr. Crovella). As Patent Owner points out, however, Erskine only makes “a binary, accept/reject decision as to whether to allow a new call to proceed based on a comparison between the bandwidth needed for the call and a predetermined ‘sliding maximum interzone bandwidth value.’” See Prelim. Resp. 6–7. Specifically, the additional bandwidth that would be needed for the call is added to the current bandwidth being used on the interzone link; if the sum of those values is less than the sliding maximum interzone bandwidth for the link, the call “proceeds”; otherwise, it is “blocked.” Ex. 1004, col. 4, ll. 36–40, col. 6, l. 55–col. 7, l. 10, col. 8, ll. 36–43, col. 9, ll. 9–26, col. 10, ll. 23–25 (the sum is compared to the sliding maximum interzone bandwidth “to determine whether enough bandwidth is available to proceed with the new call”), Fig. 3 (steps 308, 310, and 312). Erskine repeatedly refers to the bandwidth for the new call as the amount of bandwidth that is “necessary” or “required” to handle the call. See, e.g., id. at col. 1, ll. 43–57 (“an amount of bandwidth necessary to handle the new call”), col. 6, ll. 61–64 (“the additional bandwidth required (of the new call)”), col. 8, ll. 36–40 (“the bandwidth necessary for the new call”), col. 9, ll. 16–21 (“the anticipated additional bandwidth necessary for the new call”), 54–56 (“the bandwidth amount the new call will utilize (if connected)”), col. 10, ll. 21–23 (same), 41–43 (same), col. 12, ll. 1–2 (“an amount of bandwidth necessary to handle the new call”). It is that value—determined prior to the addition and comparison to the sliding maximum interzone bandwidth—that will be used for the new call if it is allowed to “proceed[].” Id. at col. 6, ll. 64–67 (if the sum is less than the sliding maximum interzone bandwidth, the call “proceeds” and “the QoS table is updated with the additional bandwidth used by that call”). Erskine does not describe the transmission bandwidth for the new call as being based on any parameter values for a past network connection, but rather as “whatever bandwidth the system determined is necessary for the additional call.” See Prelim. Resp. 8–9. In other words, the transmission bandwidth needed for a new call is predetermined and independent of whatever the sliding maximum interzone bandwidth is currently. See id.” slip op. at 15
Claim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 10,944,634 - Cambridge Industries USA, Inc. v. Applied Optoelectronics, Inc.Institution deniedPTAB · Aug 26, 2025 · IPR2025-00436 · APJ Mitchell G Weatherly · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that Mizobuchi or Akashi anticipates any of claims 1–17.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Institution of an inter partes review is authorized by statute when “the information presented in the petition filed under section 311 and any response filed under section 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Based on our review of the record, we conclude that Petitioner is reasonably likely to prevail with respect to at least one challenged claim.” slip op. at 2
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“All independent claims recite “a light engine driving circuit disposed on the substrate.” Ex. 1001, 9:59 (claim 1), 10:64 (claim 12), 12:7 (claim 15). Petitioner contends that “Mizobuchi discloses a light engine driving circuit disposed on the substrate that includes a clock data recovery (“CDR”) circuit and a power supply circuit.” See Pet. 19 (citing Ex. 1006, 3:57–4:18, 12:27–41, Figs. 2, 3A; Ex. 1003 ¶ 76 while addressing limitation 1d); see also id. at 26–28 (addressing claims 12 and 15 by cross-referencing showing for claim 1). Petitioner identifies the driving circuit on Mizobuchi’s “first circuit board” 2 in the annotated version of Mizobuchi’s Figure 2, reproduced below. See Pet. 19.” slip op. at 5
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner contends that the Board may find it necessary to interpret “feedthrough device,” “interconnect device,” and “opposing arrangement.” Pet. 8–11. Patent Owner responds to Petitioner’s proposed interpretations of these terms, but contends that the Board need not interpret them to determine whether to institute review. Prelim. Resp. 17–18. For reasons that become apparent below, we agree with Patent Owner and do not expressly construe these terms. B. Legal Standards” slip op. at 4
Claim construction§ 102 anticipationcites PhillipsPatents in suitUS 10,313,024 - Google LLC v. Metarail, Inc.Rehearing deniedPTAB · Aug 25, 2025 · IPR2024-01270 · APJ Frances L Ippolito · IPR · Rehearing
The Board denied Google’s rehearing request, leaving in place the denial of institution because the Petition did not show a reasonable likelihood that Belanger-Halevy teaches limitation [1C] of claims 1–26.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. ANALYSIS A request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, a reply or sur-reply.” 37 C.F.R. § 42.71(d). The party challenging a decision bears the burden of showing the decision should be modified. Id. We address Petitioner’s rehearing arguments below.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“[m]issing, however, from Halevy’s disclosure is any teaching or suggestion that a ‘plurality of computer-readable field identifiers’ are mapped ‘to one another’ as required by claim 1.” Dec. 22. We discussed and quoted extensively from Petitioner’s expert declaration of Dr. Fox and Patent Owner’s expert declaration of Dr. Malek. Id. at 22–26 (citing Ex. 1003 ¶ 104; Ex. 2001 ¶¶ 69, 71). In reviewing the parties’ submissions, we found that: Halevy’s disclosures are consistent with Patent Owner’s arguments and Dr. Malek’s testimony that Halevy does not teach mapping fields to one another or mapping of fields to one another through SO-properties. For example, as described, in Figure 6 and Halevy as a whole, Halevy does not teach or suggest mapping or linking different keywords to one another, rather the keywords are mapped to SO-properties. slip op. at 5
- Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner
“Dr. Fox states that “Halevy’s disclosure of a form database in which corresponding fields from different forms on different websites map to the same SO-properties would have been recognized by a POSA as what the ’378 patent refers to as a universal variable map.” Ex. 1003 ¶ 108 (citing Ex. 1001, 17:42–46). Based on this conclusory opinion, Dr. Fox reasons that Halevy’s form database is a “universal variable map” that must also link computer-readable field identifiers (including parameter names) from multiple different websites to each other in the form database, because the field identifiers are mapped to the same SO-properties associated with an SO-class. Id. We observe first that Dr. Fox’s conclusion is not supported by the cited portions of the ’378 patent. In column 17, lines 42–46, the ’378 patent explains that fields or variables may be part of forms and variations of these data fields or variables “may include a source form, a destination form, a single source to many destination form, many sources to one destination form, cascading forms (e.g., a first form links to a second form which links to a third form, etc.) and so on.” Ex. 1001, 17:42–46. While this portion of the ’378 patent indicates that forms may include variations on fields or variables, it does not describe any linking or mapping of variables to one another. Ex. 2001 ¶ 76 (“[T]hat portion of the specification does not have anything to do with the definition of a “universal variable map.” Rather, it merely discusses different types of variables and fields that might appear in different types of forms.”). Dec. 28–29. We again referred to the disclosure of the ’378 patent to address evidence in the Petition relied upon by Dr. Fox to support Petitioner’s position. Id. We credited Dr. Malek’s testimony over Dr. Fox’s testimony because Dr. Malek underlined the distinctions between the asserted Belanger-Halevy prior art combination and limitation [1C]. Dec. 28–31. In short, any confusion applying the prior art Belanger-Halevy references to the claim limitation is rooted in the Petition. The Board denied the Petition because the Petition did not demonstrate a reasonable likelihood of showing that Belanger-Halevy discloses or teaches limitation [1C] of the ’378 patent.” slip op. at 5
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner
“Finally, with regard to the Reply and Sur-Reply submitted by the parties (Req. 9), we note that our Decision on Institution reviewed the parties’ discussion of claim construction, but ultimately determined that “[b]ased on our review of the preliminary record, we do not need to construe any terms expressly to reach our decision.” Dec. 11. Thus, we disagree with Petitioner that we misconstrued the mapping limitation where we did not find it necessary to construe any claim term for the purposes of our institution decision because we determined the Petition deficient for failing to meet our threshold requirements as discussed above and in detail in the Decision on Institution. See Req. 1–11.” slip op. at 7
Claim constructionPatents in suitUS 9,633,378 - Therabody, Inc. v. Datafeel Inc.Institution deniedPTAB · Aug 21, 2025 · PGR2025-00026 · APJ Lisa L Tsang · PGR · Institution
The Board denied institution because Petitioner did not show claim 4 more likely than not unpatentable on either obviousness or § 112 ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Under 35 U.S.C. § 324(a), a post-grant review may be instituted only if “the information presented in the petition . . . demonstrate[s] that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” Post-grant review is available for patents that issue from applications that at one point contained at least one claim with an effective filing date on or after March 16, 2013. See Leahy-Smith America Invents Act, Pub. L. No. 112-29, 125 Stat. 284 (2011) (“AIA”), §§ 3(n)(1), 6(f)(2)(A). Upon considering the arguments and evidence, we conclude that the information presented shows it is not more likely than not that at least one challenged claim of the ’174 patent is unpatentable.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“For purposes of this Decision, we adopt the level of ordinary skill in the art articulated by Petitioner because, based on the current record, it is consistent with our review and understanding of the technology and descriptions in the ’174 patent and prior art of record. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). We note, however, that our analysis below would be the same regardless of whether we adopt Petitioner’s or Patent Owner’s proffered level of skill in the art.” slip op. at 11
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner
“Petitioner and Patent Owner agree that no claim terms need construction. Pet. 14; Prelim. Resp. 6. After reviewing the evidence and arguments presented by the parties, we determine that it is not necessary to expressly construe any claim terms because doing so would not change the outcome of our analysis below. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (noting that “we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng'g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 12
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not reached
“of Choi to support its argument that an ordinarily skilled artisan would have understood Choi’s infrared lamp housing to define a concave shape as claimed. See Pet. 61–62. With only this explanation and evidence from Petitioner and Dr. Jenson, however, we cannot not discern how these portions of Choi would have so apprised an ordinarily skilled artisan. For example, the side view of the infrared lamp housing, illustrated in Figure 5 reproduced below, shows the housing having a convex, rather than concave, shape. See Ex. 1008, Fig. 5. Furthermore, paragraphs 20 and 48 refer to the housing’s “circular” shape and outer periphery and also “tubular” shape. See id. ¶¶ 20, 48. But these descriptions, either alone or together with Figure 5, also do not support adequately a finding that Choi’s housing is concave. Choi’s teachings in paragraphs 20 and 46 regarding the lamp housing guiding or directing infrared light from the lamp to irradiate the skin of a user, without more, are similarly deficient. See id. ¶¶ 20, 46. And although Dr. Jensen appears to equate “concave” with “inner circular,” he does not provide the basis for his testimony or explain what “inner circular” means, particularly in the context of distinguishing a convex shape from a concave shape. See Ex. 1002 ¶ 197. Accordingly, we determine there is insufficient evidence to support Petitioner’s conclusory statements that an ordinarily skilled artisan would have understood Choi’s infrared lamp housing to define a concave shape as claimed.” slip op. at 23
Claim construction§ 103 obviousness§ 112 disclosurecites Phillips · KSR · GrahamPatents in suitUS 12,036,174 - Zhuhai Cosmx Battery Co., Ltd. v. Ninge Amperex Technology LimitedInstitution deniedPTAB · Aug 20, 2025 · IPR2025-00385 · APJ Debra L Dennett · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–10 were anticipated by Nishikawa or obvious over the asserted combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review under 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least [one] of the claims challenged in the petition.” For the reasons set forth below, upon considering the Petition and Preliminary Response, we determine that Petitioner has not established a reasonable likelihood of prevailing with respect to at least one challenged claim. Accordingly, we deny the Petition and decline to institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedOther
“Petitioner contends that A person of ordinary skill in the relevant art would typically hold an advanced degree in chemistry, material science, and/or a related discipline, and have at least two years of experience with designing and/or fabricating battery separators or have an equivalent level of education, training, and experience. Pet. 5. Patent Owner “adopts the definition proposed by Petitioner” for the purposes of the Preliminary Response. Prelim. Resp. 22. In light of the record before us, and for purposes of this Decision, we adopt Petitioner’s unopposed definition because it is consistent with the specification. We note that neither party indicated that the result would change under any different definition.” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Absolute plastic deformation rate” and “relative plastic deformation rate” are the only claim terms disputed in this proceeding, and are clearly defined in the Specification and in claim 1. See Spec. 4:22–27, 4:47–54; 25:31–37. Because we determine that claim construction is not necessary to decide whether to institute, we do not expressly construe any claim terms. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (holding that “only those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy”); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs. in the context of an inter partes review). slip op. at 11
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“Petitioner’s arguments are unconvincing. Petitioner points to nothing in Nishikawa that allows a POSITA to determine L2 (defined as “a length of 4 Tensile strength is measured as force per units area, such as MPa or psi. One MPa equals one N/mm2. Nishikawa Table 1 discloses tensile strength in N/cm. Ex. 1004 Table 1. Petitioner makes calculations to convert the reported N/cm into N/m2 and then to GPa, but provides no explanation for why tensile strength is reported in N/cm or how it was measured. See Pet. 31. the porous substrate after the porous substrate is stretched to breakage and docked along the fracture caused by the breakage and flattened”) or L2 – L0. See generally Pet., Ex. 1004. Petitioner and its expert, Dr. Pecht, fail to adequately explain why tensile strength divided by Young’s modulus is “a proxy for L1 – L2” or why such a proxy is sufficient to disclose the limitation as stated. Instead, we are required to rely on “approximations” and “estimates” with insufficient explanation of why such they are appropriate or adequate. See Pet. 26, 30, 32; see also Ex. 1003 ¶¶ 97, 105–108, 111.” slip op. at 13
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,964,927 - Micron Technology, Inc. v. Yangtze Memory Technologies Co., Ltd.Institution deniedPTAB · Aug 8, 2025 · IPR2025-00244 · APJ Kimberly Mcgraw · IPR · Institution
The Board denied institution because the petition did not sufficiently show that Costa disclosed or suggested claim 11.H’s required arrangement, and the dependent claims did not cure that deficiency.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“In view of these deficiencies, the Petition fails to identify the proposed grounds for review with particularity as required by 35 U.S.C. § 312(a)(3) with respect to the limitations of independent claim [11.H]. Petitioner presents no arguments or evidence with respect to the dependent claims challenged under this ground that would remedy the defects noted above with respect to independent claim 11. See generally Pet. Thus, Petitioner has failed to demonstrate a reasonable likelihood that the subject matter of claims 11, 12, or 14–19 would have been obvious over Costa.” slip op. at 23
- BurdenDenied
“3. Analysis A petition is required to identify “with particularity[ ] the grounds on which the challenge to each claim is based, and the evidence that supports the grounds for the challenge.” 35 U.S.C. § 312(a)(3). The “petition . . . must include . . . [a] full statement of the reasons for the relief requested, including a detailed explanation of the significance of the evidence”). 37 C.F.R. § 42.22(a)(2). Our rules require that a petition include fully developed arguments. See 37 C.F.R. § 42.22(a)(2) (the “petition . . . must include . . . [a] full statement of the reasons for the relief requested, including a detailed explanation of the significance of the evidence”). The petition must include both an adequate explanation of how the claims should be construed as well as how the construed claims are unpatentable over the asserted prior art. 37 C.F.R. § 42.104(b)(3), (b)(4). Additionally, the “petition must specify where each element of the claim is found in the prior art.” 37 C.F.R. § 42.104(b)(4). A petition should also “explain why a person of ordinary skill in the art would have combined elements from specific references in the way the claimed invention does.” ActiveVideo Networks, Inc. v. Verizon Comm'ns, Inc., 694 F.3d 1312, 1328 (Fed. Cir. 2012). Thus, based on our rules, we only consider fully developed arguments set forth in the petition.” slip op. at 16
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITANot reached
“arguments. See, e.g., id. at 34–35 (arguing that “on” does not require overlap in the Z direction but “includes both objects that are merely touching (in any dimension) and objects that are in proximity to each other but not touching” (citing Ex. 1078, 1; Ex. 1001, 8:3–12)); see also id. at 36–38 (arguing that if “on” is construed to mean “directly on or on with an intermediate feature or layer therebetween,” then Costa’s second stacked layer 232, 242 and third channel structure (173) are “directly on” each other, because their edges are directly touching each other). The Petition, however, does not clearly present any of the claim construction arguments set forth in the Opposition Brief. See Paper 22 (not clearly identifying where the Petition provides the proposed claim construction); see generally Pet.; see also Pet. 33, 43, 56 (arguing “on” does not require “directly on” and permits intermediate layers but not presenting any of the other claim construction arguments set forth in the Opposition Brief). Nor did the Petition provide any particularized argument as to how Costa discloses or suggests a second stacked layer disposed on the third channel structure applying any of the claim constructions proposed in the Opposition Brief. See generally Pet. (presenting no argument that Costa’s second stacked layer 232, 242 is “on” semiconduction portion layer 173 (the asserted third channel structure) because they touch each other as shown above in Petitioner’s annotation of Costa Figure 21A). We will not consider any arguments not sufficiently set forth in the Petition. See 37 C.F.R. § 42.104(b)(3) (“the petition must set forth . . . [h]ow the challenged claim is to be construed”); 37 C.F.R. § 42.104(b)(4) (“the petition must set forth . . . [h]ow the construed claim is unpatentable”).” slip op. at 19
- Parallel petitionsNot reached
“Because we determine that Petitioner did not show a reasonable likelihood that it would prevail on the merits, we do not address Patent Owner’s parallel petitions argument.” slip op. at 23
Claim constructionDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,886,291 - Micron Technology, Inc. v. Yangtze Memory Technologies Co., Ltd.Institution deniedPTAB · Aug 8, 2025 · IPR2025-00245 · APJ Michael T Cygan · IPR · Institution
Institution was denied because Petitioner did not show a reasonable likelihood that claims 11, 13, and 15–17 would have been obvious over Costa or Costa and Oh.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“§ 42.4(a), we may only institute an inter partes review when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a); see also 37 C.F.R. § 42.108(c). Based upon our review of the present record, Petitioner has not sufficiently shown a reasonable likelihood it will prevail with respect to at least one of the challenged claims. Accordingly, we do not institute inter partes review.” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner states that none of the claims require express construction and the claims should receive their plain and ordinary meaning. Pet. 23. Patent Owner argues that no claim construction is necessary for the institution determination, and that the Petition “still fails if the claim term ‘on’ receives its plain and ordinary meaning -- e.g., physically in contact with or directly on top of with intervening objects therebetween.” Prelim. Resp. 20 (citing Ex. 2006 ¶ 66). Although Patent Owner argues that Petitioner has construed “on” as including indirectly on; i.e., where there is no physical contact, the Petition addressed now-disclaimed claim 18, and the Petition does not advance any construction for the remaining claims. See id. at 16–17 (citing Pet. 92; Ex. 1003 ¶ 258). Consequently, we determine that no construction is required to resolve the issues for institution.” slip op. at 7
- Skill levelSkill level petitioner adoptedOther
“we consider the level of ordinary skill at the time of filing. 35 U.S.C. § 103; see also Graham v. John Deere Co., 383 U.S. 1, 17 (1966) (discussing pre- AIA obviousness). Petitioner contends that a person of ordinary skill in the art (“POSITA”) would have had “a bachelor’s degree in electrical engineering or a similar discipline, along with 2–3 years of professional experience working with (e.g., researching, designing, or teaching) monolithic 3D structures and NAND memory devices, or an equivalent level of skill, knowledge, and experience (e.g., an advanced degree may replace 1 The Leahy-Smith America Invents Act, Pub. L. No. 112-29, 125 Stat. 284 (2011) (“AIA”), amended 35 U.S.C. § 103. The earliest claimed priority date for the ’241 patent is after the effective date of the applicable AIA amendment. See Ex. 1001, (63). Thus, we refer to the AIA version of 35 U.S.C. § 103. 2 Costa, US 2018/001282771 (filed Feb. 28, 2017, published June 28, 2018) (Ex. 1005, “Costa”). 3 Oh, US 2017/0154892 A1 (filed June 10, 2016, published June 1, 2017) (Ex. 1006, “Oh”). some of the professional experience). Pet. 23–24. Petitioner also asserts that a POSITA “would have been aware of and generally knowledgeable about 3D NAND’s structure, how it is manufactured, and its component parts.” Id. (citing Ex. 1003 ¶¶ 36–40). Patent Owner does not take a position on the level of ordinary skill in the art. Prelim. Resp. 11; see also Ex. 2006 ¶ 34 (applying Petitioner’s definition of a POSITA to the opinions set forth in the declaration but reserving the right to opine to an alternative level of a POSITA). At this stage of the proceeding, we adopt Petitioner’s definition of a POSITA as it appears consistent with the level of ordinary skill in the art that is reflected by the prior art of record.” slip op. at 6
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“We agree with Patent Owner that the Petition fails to sufficiently show that Costa teaches a “second stacked layer disposed on the third channel structure” as required by apparatus claim element [11.E]. The Petition asserts that Costa’s second alternating stack 232, 242 is formed “on the top surface of joint-level material layers.” Pet. 64. However, Costa refers to the term “joint-level material layers” as representing layers 175–177, not the asserted third channel structure 173. Ex. 1005 ¶¶ 166, 178, 184–85; see Ex. 2006 ¶ 77. Thus, under Petitioner’s characterization, which is consistent with Costa, Costa’s second alternating stack is not formed on the third channel structure, but instead, “on the top surface of the joint level material layers” that surround the third channel structure. Because Petitioner has not explained how a second alternating stack on the surface of the joint material layers teaches a second alternating stack disposed on the third channel structure, Petitioner has not met its obviousness burden for limitation [11.E].” slip op. at 11
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,482,532 - Cambridge Industries USA, Inc. v. Applied Optoelectronics, Inc.Institution deniedPTAB · Jul 29, 2025 · IPR2025-00434 · APJ Monica S Ullagaddi · IPR · Institution
Institution was denied for claims 1–7 because the Petition did not show a reasonable likelihood that either Shen or Soldano anticipates any challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“The standard for institution is set forth in 35 U.S.C. § 314, which provides that an inter partes review may not be instituted unless the information presented in the Petition and the Preliminary Response shows that “there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314 (2019); see also 37 C.F.R § 42.4(a) (2019) (“The Board institutes the trial on behalf of the Director.”). Upon consideration of the parties’ contentions and the evidence of record, we conclude that Petitioner has not established a reasonable likelihood of prevailing in demonstrating the unpatentability of at least one challenged claim of the ’301 patent. Accordingly, we deny Petitioner’s request and do not institute an inter partes review.” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“C. Claim Construction We interpret a claim “using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. 282(b).” 37 C.F.R. § 42.100(b). Under this standard, we construe the claim “in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” Id.” slip op. at 8
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“onset to show with particularity why the patent it challenges is unpatentable.” Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1363 (Fed. Cir. 2016) (citing 35 U.S.C. § 312(a)(3)). “A claim is anticipated only if each and every element as set forth in the claim is found, either expressly or inherently described, in a single prior art reference.” Verdegaal Bros., Inc. v. Union Oil Co. of California, 814 F.2d 628, 631 (Fed. Cir. 1987). We analyze” slip op. at 7
Claim construction§ 102 anticipationPatents in suitUS 10,379,301 - PTAB · Jul 25, 2025 · IPR2025-00237 · APJ Annette R Reimers · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1, 2, 5, 6, 11, 12, 17, 21, 23, 27, 28, or 30 were unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. 35 U.S.C. § 314(b) (2018); 37 C.F.R. § 42.4(a) (2024). An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Upon consideration of the Petition and the evidence of record, we determine that Petitioner has not demonstrated a reasonable likelihood of success in proving that at least 1 claim of the ’879 patent is unpatentable.” slip op. at 2
- Skill levelSkill level petitioner adoptedOther
“Patent Owner does not contest the level of ordinary skill in the art set forth in the Petition. Prelim. Resp. 19. Because Petitioner’s unopposed definition is consistent with the ’879 patent and the prior art of record, we adopt that definition. See Okajima v. Bourdeau, 261 F.3d 1350, 1354–55 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579–80 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978).” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“In particular, we agree with Patent Owner that Cantor does not teach or suggest contacting a ‘tissue section’ with its beads, let alone that its beads could be contacted with a tissue section to identify spatial location. Prelim. Resp. 36–48. In this case, we are persuaded by the testimony of Dr. Cantor, sole inventor of Cantor (Ex. 2002 ¶ 29), that Cantor’s nucleic acid samples are made in bulk from the extraction of nucleic acids from a biological sample and mixed together “to create the sample nucleic acid prior to mixing that with the solid phase nucleic acids to capture molecule(s) from the sample nucleic acid.” Id. at ¶ 36 (citing EX.1031 1:5–6). More specifically, according to Dr. Cantor, “[f]or bulk-analysis methods, nucleic acids are extracted from the different types of cells within a tissue sample without preserving their spatial distribution.” Id. at ¶ 19. Dr. Cantor further explains that in bulk-analysis methods, the mixture is analyzed to determine if a particular nucleic acid was present in the tissue sample or not. They cannot, however, determine where the molecule was in the tissue sample. As such, bulk-analysis techniques provide no information about spatial location of biological molecules in tissue samples. This is in contrast to spatial analysis methods such as those claimed in the ’879 patent which can determine both if a biological molecule was present in a tissue sample and where the molecule was in the tissue sample. Id. at ¶¶ 16–17. Although we recognize that Cantor discloses “providing the beads according to an (X,Y) array” (Pet. 24, 30–31 (citing to Dr. Puglisi, Ex. 1102 ¶¶ 133, 155, respectively), this disclosure makes no mention of using this array to map where the nucleic acids of Cantor came from relative to the original sample, let alone when that original sample is a tissue. See e.g. Ex. 1031, 17. The only mention of “tissue” made in Cantor is in reference to where the sample may be obtained, for example, “[t]he biological sample can be in any form, including without limitation a solid material such as a tissue.” Id. at 6. Cantor provides no teaching, however, regarding how to use a tissue sample with the probes and methods described in Cantor to identify where the target nucleic acids of Cantor were spatially located within the tissue section itself. See Ex. 2002 ¶¶ 142, 143 (Dr. Cantor testifying that (1) “a POSA would only be able to determine where on the array a target nucleic acid was captured, but not where in the original tissue section the nucleic acid came from,” because “all information about the spatial location of a target nucleic acid in a tissue sample is lost when the nucleic acid sample is prepared as Cantor teaches”; and (2) “Cantor [] does not teach or suggest contacting its solid supports (e.g. beads) with a tissue section and certainly not with its beads at known locations to obtain spatial information.”).” slip op. at 23
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportPriority date awardedDecided for patent owner
“3. Discussion Petitioner challenges whether certain elements of independent claim 1 are supported by the’124 provisional and/or whether the ’879 patent’s priority chain is intact. Pet. 57–66. Having considered the parties’ positions and evidence of record, however, we agree with Patent Owner’s written description analysis, summarized above, and find that (1) the’124 provisional provides adequate written description support for each of the challenged claim elements; (2) the ’879 patent’s priority chain is intact; and (3) the ’879 patent is therefore entitled to the priority date of April 5, 2010. Consequently, Frisen is not prior art to the challenged claims. Because Frisen is not prior art, we do not specifically comment on its teachings, nor the factual assertions regarding its teachings provided by Petitioner or Patent Owner. 4. Conclusion For the foregoing reasons, we determine that Petitioner has not established a reasonable likelihood of showing that Frisen anticipates any of claims 1, 2, 5, 6, 11, 12, 17, 21, 23, 27, 28, and 30.” slip op. at 32
§ 102 anticipation§ 103 obviousnessPatents in suitUS 11,001,879
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.